Do's & Dont's DO’S - For Better Performance
DONT’S - For Safe Operation
•
Ensure that all safety shields are in place and in good condition.
•
Do not run the engine without the air cleaner.
•
Do not start the tractor in high idle.
•
Read all operating instructions commencing to operate tractor.
•
•
Ensure all lights are in 'OFF' position before starting the tractor.
Do not start the tractor in an enclosed building unless the doors and windows are open for proper ventilation.
•
•
Carry out all maintenance tasks without fail.
Do not operate the tractor or engine while lubricating or cleaning.
•
Keep the air cleaner clean.
•
•
Ensure that the correct grade of lubricating oils are used and that they are replenished and changed at the recommended intervals.
Do not allow the tractor to run out of diesel fuel otherwise it will be necessary to bleed the system.
•
Do not tamper with fuel, EGR, SCR or any other emission systems. It may cause engine to derate as per legal inducement requirements since it may affect emissions.
•
Do not allow the engine to run idle for a long period.
•
Do not run the engine if it is not firing on all cylinders.
•
Do not ride the brake or clutch pedal. This will result in excessive wear of the brake linings, clutch driven member and clutch release bearing.
•
Do not use the independent brakes for making turns on the highway or at high speeds.
•
Do not refuel the tractor with the engine running.
•
Do not use draft control lever for lifting of implements.
•
Do not start the engine with the P.T.O. engaged.
•
Do not use the hand throttle while driving on roads.
•
Do not run cold engine at full throttle.
•
Watch the oil pressure warning light investigate any abnormality immediately.
•
Keep the radiator filled with clean anti-freeze mixture. Drain the system only in an emergency and fill before starting the engine.
•
and
Ensure that the transmission is in neutral before starting the engine.
•
Keep all fuel in clean storage and use a filter when filling the tank.
•
Attend to minor adjustments and repairs as soon as necessity is apparent.
•
Allow the engine to cool before removing the radiator cap and remove the radiator cap slowly.
•
Shift into low gear when driving down steep hills.
•
Latch the brake pedals together when driving on a highway.
•
82
before
Keep draft control lever and position control lever fully down when not in use.
•
Visit Dealer for adjustment on Injector pressure. Adjust if required.
•
Do not run the tractor on road with 4WD engaged above 10 mph.
•
Slow down the engine speed before shifting the F-R shuttle switch.
•
Do not operate F-R shuttle switch while tractor is in motion beyond 6.2 mph speed.
•
Keep the auxiliary valve levers in neutral (N) when not in use.
•
Do not operate the power steering when the oil level is below the minimum level in the reservoir.
•
Replace both clutch and brake cables after 1000 hours of tractor operation.
•
•
Idle the engine for 1 to 2 minutes after starting and before stopping the engine.
Do not run the tractor if the power steering system is damaged. In this condition, contact the Dealer.
•
Do not park the tractor on a gradient with transmission gear engaged and with no parking brake.
•
Do not operate the wipers on dry windshield, it may scratch the glass.
8000 Series, Models - 8090/8100 4WD CAB TIER-4 Final
