5. Operating Instructions
14. Troubleshooting If the action below does not solve the problem or the fault cannot be found, contact Moxy dealer.
*= Always contact your Moxy Dealer. Symptom
Cause
Action
Engine: • • • • • • • •
Main switch disconnected Out of fuel Low battery current Blown fuse Defective wiring Hydrostatic lock Starter motor defective Electronic controller or sensors defective
• • • • • • • • • • • • •
Fuel system disturbance Condensated water in diesel Bad fuel quality Low fuel level Fuel filters clogged Air filter clogged Fuel tank breather clogged Throttle system disturbance Wrong injection timing Injector defective Turbo charger defective Worn engine or internal damage Electronic controller or sensors defective
Check fuel lines, bleed system Drain tank Change fuel Refill fuel Replace filters Replace or clean Clean tank cover Adjust/replace/repair Adjust* Repair/replace* Repair/replace* Overhaul* Check/repair*
Overheated (warning light)
• • • • • • • •
Low coolant level Fan belt problem Air in cooling system Dirt inside cooling system Radiator fins clogged/damaged Thermostat faulty Sensor/gauge defective Coolant pump worn
Add coolant, check for leakages Tighten/replace Bleed system Clean and replace coolant Clean Replace Replace Overhaul*
Low coolant temperature
• Sensor/gauge defective • Thermostat stuck open
Replace Replace
Low oil pressure
• • • • •
Add oil, check for leakage Change to correct oil type Replace Overhaul* Overhaul*
Will not start
Starts but stops again, runs un-evenly or hunts. Low output
112
Too low oil level Incorrect oil type Sensor/gauge defective Oil pressure red. valve faulty Worn oil pump
Operating & Maintenance Manual
• Turn on Refill fuel, bleed system Recharge Check circuit, replace fuse Check connections, wires Repair* Replace* Check/repair*
