TROUBLESHOOTING The following information identifies loader problems which can occur most often. Service procedures for correcting loader problems can be found in this manual on the pages indicated. Some procedures are marked D/S (Dealer Service) and must be performed only by qualified Bobcat service personnel.
Instructions are necessary before operating or servicing machine. Read Operation & Maintenance Manual, Handbook and signs (decals) on machine. Follow warnings and instructions in the manuals when making repairs, adjustments or servicing. Check for correct function after adjustments, repairs or service. Failure to follow instructions can cause injury or death.
W–2003–0797
PROBLEM Engine won’t turn over with starter.
Engine turns with starter, but is difficult to start.
Engine has little power or runs rough.
CAUSE
CORRECTION
PAGE
Battery has low charge.
Charge battery and find cause for loss of charge.
44
Cables loose or dirty.
Clean and tighten the battery cables.
45
Damaged starter, solenoid or wiring.
Check the starting circuit. Repair as needed.
DS
Wrong starting procedure.
Use correct starting procedure.
15
No fuel in tank.
Add fuel.
DS
Dirt or water in fuel system.
Repairs as needed.
40
Damaged fuel pump.
Make repairs as needed.
DS
Fuel filter is dirty.
Install a new filter.
40
Hole in fuel line.
Repair as needed.
DS
Wrong oil in engine.
See Oil Specifications.
42
Engine has lost compression.
Recondition the engine.
DS
Engine has overheated.
Check Cooling System.
43
Poor fuel quality.
Use fresh, good quality fuel.
39
Dirt, water or air in fuel system.
Clean and repair as needed.
40
Dealer Copy -- Not for Resale
TROUBLESHOOTING THE ENGINE
DS = Dealer Service Only
77 of 96
–57–
453 Bobcat Loader Operation & Maintenance Manual
