Fuel/Lubrication/Cooling ! WARNING Whenever the gasline hoses are removed (other than for pressure testing), the battery must be disconnected to prevent inadvertent activation of the electric fuel pump.
! WARNING Whenever any maintenance or inspection is performed on the fuel system during which there may be fuel leakage, there should be no welding, smoking, open flames, etc., in the area.
XX084
3. Disconnect the gas tank vent hose
SPECIAL TOOLS
A number of special tools must be available to the technician when performing service procedures in this section. Refer to the current Special Tools Catalog for the appropriate tool description. NOTE: When indicated for use, each special tool will be identified by its specific name, as shown in the chart below, and capitalized. Description Oil Pressure Test Kit
p/n 0644-495
NOTE: Special tools are available from the Service Department.
XX105
! WARNING
TROUBLESHOOTING
1. Verify that the electric fuel pump is operating by listening for a “whirring” sound for several seconds after the ignition switch is turned to the ON position. If no sound can be heard, see EFI Sensors/Components in Electrical System.
Extreme care must be taken when removing gas line. Pressure in the line may cause gas to spray out.
4. Disconnect wire harness connector for fuel pump. Disconnect the gas line by pushing in on tabs.
2. Check for a diagnostic trouble code (DTC) on the LCD gauge. If a code is flashing, see Diagnostic Trouble Codes (DTC) in Electrical System. 3. Make sure there is sufficient, clean gas in the gas tank.
Gas Tank ! WARNING Whenever any maintenance or inspection is made on the fuel system during which there may be fuel leakage, there should be no welding, smoking, open flames, etc., in the area.
REMOVING
XX106
5. Remove the cap screws securing brackets for gas tank. Remove the three brackets holding tank down. Slide gas tank toward front of vehicle
1. Remove the passenger seat, and battery access panel. Disconnect battery cables from battery. 2. Disconnect the fuel filler hose from the fender. Seal off the hose to prevent objects from entering the hose.
69
