Mustang 634 Telehandler Service Parts Manual 908484 - PDF DOWNLOAD

TELEHANDLERS

634 Telehandler

Service Parts Manual #908484 Revision B

S/N 71101 and Before

Introduction

634 Telehandler

The table of contents pages show the page location of various component groups on the machine.

When ordering service parts, specify the correct part number, full description, quantity required, and the unit model and serial number.

Model and serial numbers for this unit are stamped on a plate located inside the operator’s station. The serial number is also stamped on the top front frame.

The following reference shows the breakdown of the serial number:

Model

Unit Number Engine

NOTE: On original tire replacement, Company policy prohibits the sale of replacement tires for all Mustang machinery. Replacement wheel sets are available and tire size information is called out with the wheel sets to facilitate replacement tire selection. ALL REPLACEMENT TIRES MUST BE PURCHASED LOCALLY. Grease fittings and common attaching hardware, such as cotter pins, set screws, woodruff keys, screws, nuts, etc., are included in the parts list, indented below the part it is (they are) associated with, but may NOT be illustrated, except where a particular routing or special fastening arrangement MUST be maintained. The hardware listed is for mounting purposes and is NOT included when the part is ordered for replacement.

Part numbers for standard hardware are listed indented under the component being fastened.

634 J U 02 70011 Month Year (U=03, V=04, W=05, etc.)

“Right” and “Left” are determined from a position sitting on the seat and facing forward.

Mustang Manufacturing Company reserves the right to make changes or improvements in the design or construction of any part of the unit without incurring the obligation to install such changes on any unit previously delivered.

A complete listing of part numbers for attaching washers/nuts used on this machine is included in the table on the facing page. Refer to the abbreviations list on the facing page for descriptions.

Standard attaching hardware torque values are provided on the inside back cover. Unless otherwise specified, all cap screws are Grade 5, cadmium or zinc plated; hexagon nuts for Grade 5 cap screws or bolts are Grade A.

634 Telehandler

Introduction

List of Abbreviations Used in this Manual AN AR ASY BHB CB CN CYL CS DIA FHMS FLN FLS FT GR HLN HYD JN L LH LT N NIN NPTF P PB PHS RH RHMS RHSMS RNF RT SHCS SHSS SFN SHSS STS THMS TRS W/ WN

FILTER REFERENCE TYPE Engine Oil Engine Fuel Engine Air Transmission Oil Hydraulic Oil

Acorn Nut As Required Assembly Button Head Bolt Carriage Bolt Castellated Nut Cylinder Cap Screw (Hexagon Head) Diameter Flat Head Machine Flanged Flexlock Nut Flanged Lock Screw Foot or Feet Grade Hexlock Nut Hydraulic Jam Nut Lock (Washer) Left Hand Left Nut (Plain Hex) Nylon Insert Lock Nut National Pipe Threaded Fitting Plain (Washer) Plow Bolt Pan Head Screw Right Hand Round Head Machine Screw Round Head Sheet Metal Screw Retained Nut Fastener Right Socket Head Cap Screw Socket Head Set Screw Serrated Flange Nut Square Head Set Screw Self-Thread Screw Hex. Washer Head Truss-Head Machine Screw Thread Roll Screw With Wing Nut

PRINTED IN U.S.A.

PART NUMBER L99420 L98978 L120054 L99184 L97489

TABLE OF STANDARD WASHERS, NUTS

1

Size & Description

Part No.

Size & Description

Part No.

#10-32 N

L50050

1/4 L 1/4-20 NIN 1/4 P 1/4-20 SFN

L50139 L520003 L50137 L50051

7/16 L 7/16-14 NIN 7/16 P

L50150 L50517 L50149

1/2-13 NIN 1/2 P

L520019 L50151

5/16 L 5/16-18 N 5/16-18 NIN 5/16 P 5/16-18 RNF 5/16-18 SFN

L50143 L50230 L520004 L50141 L530004 L50056

5/8 L 5/8-11 N

L50156 L50081

3/4-10 N 3/4-10 NIN 3/4 P

L50086 L50519 L50147

3/8-16 L 3/8-16 N 3/8-16 NIN 3/8-16 P 3/8-16 SFN 3/8-16 WN

L50147 L50066 L520005 L50145 L50061 L530003

1-8 JN

L50145

908484/BP0615

Table of Contents

634 Telehandler

Page INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Inside Front Cover List of Abbreviations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 Filter Reference Chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 DECALS General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 New Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 Decal Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 OPERATOR STATION Safety Guards, Windows and Cab . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 Front and Rear Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 Windshield Wipers / Top and Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16 Side Door and Window . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18 Cab Mounts and Panels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20 Steering Column Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22 Seat Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24 Top Dash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26 Under Dash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28 Accelerator and Brake Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30 Heater (No Air Conditioning) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32 Air Conditioning (w/Heater) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .34 CHASSIS Frame and Covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36 Hydraulic and Fuel Tanks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38 Battery Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40 Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42 ENGINE External Engine Components Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .44 Radiator and Cooler Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46 Engine Air Intake Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48 Engine Exhaust Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .50 TRANSMISSION External Transmission and Drive Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52 Internal Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .54

908484/BP0615

2

PRINTED IN U.S.A.

634 Telehandler

Table of Contents

Page AXLES External Components Group (S/N 70017 - 71101) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56 External Components Group (S/N 70016 and before) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .58 Outer End Group (S/N 70017 - 71101) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60 Outer End Group - Part I (S/N 70016 and before) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .62 Outer End Group - Part II (S/N 70016 and before) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .64 Differential Housing Group (S/N 70017 - 71101) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66 Differential Group (S/N 70017 - 71101) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .68 Differential Housing Group - Part I (S/N 70016 and before) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70 Differential Housing Group - Part II (S/N 70016 and before) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .72 Differential Housing Group - Part III (S/N 70016 and before) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .74 Brake Group (S/N 70017 - 71101) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .76 Brake Group (S/N 70016 and before) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .78 BOOM Outer Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80 Intermediate Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .82 Inner Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .84 Quickattach . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .86 HYDRAULIC SYSTEMS Hydraulic Pump and Flow Divider . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .88 Steer Motor and Steer Select Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90 Main Valve Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .92 Joystick Controller Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .94 Frame Level Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .96 Lift Cylinder Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98 Tilt / Slave Cylinder Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .100 Boom Extend Cylinder Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .102 Auxilary Hydraulics Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .104 HYDRAULIC COMPONENTS Hydraulic Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .106 Flow Divider Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .107 Main Valve Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .108 Auxilary Hydraulics Work Section Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .108 Steer Cylinders Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .110 Steer Valve Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .111 Steer Motor Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .112 Brake Valve Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .113 Joystick Controller Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .114 Auxilary Hydraulic Joystick Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .116 (Continued on next page)

PRINTED IN U.S.A.

3

908484/BP0615

Table of Contents

634 Telehandler

Page HYDRAULIC COMPONENTS (CONTINUED) Frame Level Cylinder Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .118 Lift Cylinder Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .120 Slave Cylinder Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .122 Tilt Cylinder Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .124 Boom Extend Cylinder Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .126 Fork Shift Carriage Cylinder Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .128 Rotate Carriage Cylinder Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .129 ATTACHMENTS Standard Carriage Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .130 Shift Fork Carriage Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .132 Rotate Carriage Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .134 Boom Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .136 Bucket Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .138 NUMERICAL INDEX Numerical Index List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .140

908484/BP0615

4

PRINTED IN U.S.A.

634 Telehandler

PRINTED IN U.S.A.

Notes

5

908484/BP0615

Decals

634 Telehandler

NEW DECAL APPLICATION

GENERAL INFORMATION

Before applying the new decals, surfaces must be free from dirt, dust, grease and other foreign material. To apply a solid-formed decal, remove the smaller portion of the decal backing paper and apply this part of the exposed adhesive backing to the clean surface while maintaining proper position and alignment.

Slowly peel off the other portion of the backing paper while applying hand pressure to smooth-out decal surface. To apply a die-cut decal, first remove the backing paper. Then, properly orient and position the decal onto the clean mounting surface. After the decal is firmly applied and smoothly pressed down, remove the front covering paper.

CAUTION ALWAYS follow the safety precautions on decals. Replace decals if they are damaged, or if the unit is repainted. If repainting, be sure that all applicable decals are affixed in their proper locations.

Decal locations information is provided to assist in the proper selection and application of new decals, in the event original decals become damaged or the machine is repainted.

PAINT FINISH Use this list to order paint for refinishing:

For correct replacement of decals, compare the location illustrations to your machine before starting to refinish the unit. Check off each required decal using the illustration reference number to find the part number, description and quantity in the list. Refer to the appropriate illustration for replacement locations.

420-35479 420-35480 420-35498 420-36117 420-36229 420-36230

One 12 oz. Spray Can Yellow One Quart Yellow One Gallon Yellow One 12 oz. Spray Can Gray One Quart Gray One Gallon Gray

Decal Kits L500599

Model 634

NOTE: Decals may be purchased in kits or individually.

908484/BP0615

6

PRINTED IN U.S.A.

634 Telehandler

Decals

4 1

5

8

6

3

7 2

10

5

9

DECAL LOCATIONS - LEFT SIDE OF MACHINE REF. NO.

DESCRIPTION

PART NO.

01 02 03 04 05

DANGER - ROTATING FAN MUSTANG - REAR 634 - LEFT SIDE MUSTANG - LEFT BOOM SIDE WARNING - PINCH POINT

L98864 100155 100627 100622 L65927

06 07 08 09 10

WARNING - NO RIDERS WARNING - JUMP START HORSE - LEFT SIDE BRAKE FLUID LEVEL OPERATOR MANUAL INSIDE

L65932 L65933 100624 L63474 L65922

PRINTED IN U.S.A.

7

908484/BP0615

Decals

634 Telehandler

3

8 10 4

5

1

6

4

7

2

9

11

4

DECAL LOCATIONS - RIGHT SIDE OF MACHINE REF. NO.

DESCRIPTION

PART NO.

01 02 03 04 05

DANGER - ROTATING FAN 634 - RIGHT SIDE MUSTANG - RIGHT BOOM SIDE WARNING - PINCH POINT HORSE - RIGHT SIDE

L65924 100626 100623 L65927 100625

06 07 08 09 10 11

WARNING - HOT SURFACE WARNING - NO RIDERS MUSTANG - FRONT DYNATTACH UNLOCK RED STRIPE DANGER - PERSONNEL GREASE DAILY

L65942 L65932 100156 L66613 L65928 L65920

908484/BP0615

8

PRINTED IN U.S.A.

634 Telehandler

1

2

5

Decals

2

1 8

3 7

6 4

10

9

5

DECAL LOCATIONS REF. NO.

DESCRIPTION

PART NO.

01 02 02 02 02

HALF ZONE EXTENSION MARKER NO. “0” EXTENSION MARKER NO. “1” EXTENSION MARKER NO. “2” EXTENSION MARKER NO. “3” EXTENSION MARKER

L62583 L67718 L67719 L67720 L67721

02 02 03 04 05

NO. “4” EXTENSION MARKER NO. “5” EXTENSION MARKER GREASE DAILY QUICKATTACH DIAGRAM WARNING - PINCH POINT

L67722 L67723 L65920 L65937 L65927

06 07 08 09 10

WARNING - CARRY LOAD LOW COOLANT UNDER PRESSURE ANTI-FREEZE NOTE DIESEL FUEL HYDRAULIC OIL

L65926 072798 056859 072797 072794

PRINTED IN U.S.A.

9

908484/BP0615

Decals

634 Telehandler

9

8

3

2

7

10

11

6

4

1

5

DECAL LOCATIONS - DETAILS IN OPERATOR STATION REF. NO.

DESCRIPTION

PART NO.

01 02 03 04 05

MUSTANG - STEERING CAP WARNING - SEAT BELT STEER SELECTOR F-N-R CONTROL IGNITION/HORN

100401 L65440 L63618 L68295 L68513

06 07 08 09 10

MADE IN USA WARNING - PARK BRAKE WARNING - OPERATOR WARNING CARRY LOAD LOW WARNING - BACKUP ALARM

094951 L65925 L63690 093475 L500445

10 10 10 10 10

LOADCHART-ROTATING CARRIAGE LOADCHART-TRUSS BOOM LOADCHART-STANDARD CARRIAGE LOADCHART-BUCKET LOADCHART - WINCH

100658 100659 100657 100660 100661

908484/BP0615

10

PRINTED IN U.S.A.

Decals

634 Telehandler

2

9

1

8

11

5

3

6

7

10

4

12

DECAL LOCATIONS - DETAILS IN OPERATOR STATION REF. NO.

DESCRIPTION

PART NO.

01 02 03 04 05 06

DANGER - PERSONNEL WARNING - TRUSS BOOM WARNING - MACHINE LEVEL MAINTENANCE CHART TILT/LEVEL CONTROL BOOM CONTROL

L65928 L66042 L65930 L63542 L63632 L63631

07 08 09 10 11 12

FILTER CHART DANGER - PANEL IN PLACE DANGER - POWER LINES BRAKE FLUID LEVEL OPERATOR MANUAL INSIDE WARNING - PINCH POINT

100656 L65948 L65929 L63474 L65922 L65927

PRINTED IN U.S.A.

11

908484/BP0615

Operator’s Station

634 Telehandler

Safety Guards and Windows

5 4 1

6

2

7 8

3

9

11

10

908484/BP0615

12

PRINTED IN U.S.A.

634 Telehandler

Operator’s Station

Safety Guards and Windows Ref. No.

Part No.

01 02 03 04 05 06 07

L67282 L99137 L520019 L50286 L63725 L50367 L50147

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

GLASS, RIGHT SIDE . . . . . . . . . . . 1 GASKET, SINGLE (12.5’) . . . . . . . . 1 1/2”-13 NYLON INSERT NUT . . . . . 2 1/2”-13X1-3/4” BOLT . . . . . . . . . . . . 2 OVERHEAD GUARD, WLDMNT. . . 1 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 4 3/8” LOCK WASHER . . . . . . . . . . . . 4

08

L63737 L71393 L71392 L68784 L63700 L67865

09 10 11

13

Description

Qty. Req.

GLASS, TOP . . . . . . . . . . . . . . . . . . 1 PRIMER, GLASS ADHESIVE . . . . 1 ADHESIVE, GLASS . . . . . . . . . . . . 1 CANOPY WELDMENT . . . . . . . . . . 1 HANDLE (welded on) . . . . . . . . . . . 2 FRONT WINDOW GUARD . . . . . . . 1

908484/BP0615

Operator’s Station

634 Telehandler

Front and Rear Windows

7 1

2

8

6 3 4

9

5 4

2

1

2 1 13

6 12 8

1

7

8

2

2

10 11

FRONT

908484/BP0615

14

PRINTED IN U.S.A.

634 Telehandler

Operator’s Station Front and Rear Windows

Ref. No.

Part No.

01 02 03 04 05 06 07 08

L68438 L520003 L68466 L68437 L67815 L67832 L67813 L50202

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

BOLT CAP . . . . . . . . . . . . . . . . . . . 28 1/4-20 NYLON INSERT NUT . . . . 28 WINDOW PIVOT ROD . . . . . . . . . . 4 SHOULDER WASHER . . . . . . . . . 16 WINDOW HINGE WELDMENT. . . . 4 RUBBER GROMMET . . . . . . . . . . 16 SCREW HEAD COVER . . . . . . . . 16 1/4-20X5/8” BUTTON HD BOLT . . 20

09

L67858 L99325 L67811 L67809 L67804 L67821 L99324

10 11 12 13

15

Description

Qty. Req.

REAR GLASS . . . . . . . . . . . . . . . . . 1 VINYL BULB SEAL (127”) . . . . . . . 1 WINDOW BRACKET. . . . . . . . . . . . 4 WINDOW SLIDE KNOB . . . . . . . . . 4 WINDOW SLIDE BRACKET . . . . . . 4 FRONT GLASS . . . . . . . . . . . . . . . . 1 VINYL BULB SEAL (118”) . . . . . . . 1

908484/BP0615

Operator’s Station

634 Telehandler

Windshield Wipers / Top and Front

2

1

3 8 4

5

7

6

14

13

12

11

9

10

15 22

16 17 20

18

19 21

908484/BP0615

16

PRINTED IN U.S.A.

634 Telehandler

Operator’s Station

Windshield Wipers / Top and Front Ref. No.

Part No.

01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18

101279 L50202 L50061 NSS NSS L63546 L66843 L68459 L50896 L68439 L67832 L514001 L67813 L61199 L61200 L63932 L66850 L63335 L50655 L50896 L63699 L50051 L50202

19 20 21

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

NOZZLE, WASHER. . . . . . . . . . . . . 2 3/8” FLAT WASHER . . . . . . . . . . . . 2 3/8”-16 FLANGE NUT . . . . . . . . . . . 2 NUT (Included with item 7) . . . . . . . 1 WASHER (Included with item 7) . . . 1 RUBBER GROMMET . . . . . . . . . . . 2 WIPER MOTOR (2-SPEED) . . . . . . 2 WIPER COVER . . . . . . . . . . . . . . . . 2 #10-24 NUT . . . . . . . . . . . . . . . . . . . 2 NYLON SPACER. . . . . . . . . . . . . . . 2 RUBBER GROMMET . . . . . . . . . . . 2 #10-24X1” RD HD SCREW. . . . . . . 2 COVER, SCREW HEAD . . . . . . . . . 2 WIPER ARM BLADE . . . . . . . . . . . . 2 WIPER BLADE . . . . . . . . . . . . . . . . 2 SWITCH, WASHER. . . . . . . . . . . . . 1 SWITCH, WIPER (2-SPEED) . . . . . 1 RELAY . . . . . . . . . . . . . . . . . . . . . . . 1 #10-24X1/2” RD HD SCREW. . . . . 1 #10-24 NUT . . . . . . . . . . . . . . . . . . 1 BREAKER, CIRCUIT - 15AMP . . . . 1 1/4”-20 FLANGE NUT . . . . . . . . . . . 4 1/4”-20 BUTTON HD BOLT . . . . . . . 4

22

L70649 L71394

WASHER RESERVOIR W/PUMP . . 1 3/16” TEE, WASHER HOSE . . . . . . 1

a b c

L68448 L68447 L68468 L57011 L63757 L63906 L68460

-- ITEMS NOT SHOWN -HARNESS, WIPER . . . . . . . . . . . . . 2 HARNESS, CAB OPT./WIPER . . . AR HARNESS, WIPER/WASHER . . . AR WIRE LOOM, 11/32 ID . . . . . . . . . 3.5 WIRE ASY, WASHER GRND . . . . . 1 WIRE ASY, WASHER MOTOR . . . . 1 RUBBER GROMMET . . . . . . . . . . . 2

a

Attaches to wiper motor.

b

Used instead of L68468 when unit is equipped with heater only option. (Attaches to rocker switches)

c

Used instead of L68447 when unit is equipped with air conditioning option. (Attaches to rocker switches)

17

Description

Qty. Req.

908484/BP0615

Operator’s Station

634 Telehandler

Side Door and Window

2

3

8 4

9 5 6

1

7

20

18

19

17 16

4

15

14

11

12

10

13

908484/BP0615

18

PRINTED IN U.S.A.

634 Telehandler

Operator’s Station Side Door and Window

Ref. No.

Part No.

01

L63793 L99319 L63799 L63574 L520019 L50072 L63801 L67309 L99318 L67285 L99323 L99316 L67308 L63478 L99317

02 03 04 05 06 07 08 09 10 11 12

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

WELDMENT, UPPER DOOR . . . . . 1 VINYL DOOR SEAL (144”). . . . . . . 1 HANDLE, DOOR RELEASE . . . . . . 1 SPRING, DOOR RELEASE . . . . . . 1 1/2”-13 NYLON INSERT NUT . . . . . 1 1/2”-13 NUT. . . . . . . . . . . . . . . . . . . 2 WELDMENT, DOOR REL LATCH . . 1 GLASS, UPPER DOOR . . . . . . . . . 1 GASKET, WINDOW (120”) . . . . . . . 1 GLASS, LEFT SIDE . . . . . . . . . . . . 1 GASKET, UPPER WINDOW (89”) . 1 GASKET, LOWER WINDOW (76”) . 1 GLASS, LOWER DOOR . . . . . . . . . 1 WELDMENT, LOWER DOOR . . . . . 1 VINYL DOOR SEAL (69”). . . . . . . . 1

13 14 15 16 17 18

L61085 L63547 L63548 L50152 L50202 L66907 L50212 L61086 L50211

19 20

Description

Qty. Req.

HANDLE, LOCKING . . . . . . . . . . . . 1 LATCH, DOOR / ROTARY . . . . . . . 1 STRIKER, DOOR . . . . . . . . . . . . . . 1 1/2” LOCK WASHER . . . . . . . . . . . . 1 1/4”-20X5/8” BUTTON HD BOLT . . 4 HANDLE, INSIDE DOOR . . . . . . . . 1 #10-24X1/4” HEX HD SETSCRW . 1 DOOR LOCK (UPPER DOOR) . . . . 1 1/4”-20X3/4” BOLT . . . . . . . . . . . . . 4 -- ITEMS NOT SHOWN --

-

19

L68441

DOOR ASSEMBLY (Complete) . . . . 1 (includes all items shown except items 8, 9, 15 & 16.)

908484/BP0615

Operator’s Station

634 Telehandler

Cab Mounts and Panels

22

1

2

21

3 4

5 6

20 19

8

8 6

18

7 8

17

9 15

10

16

11 12

7

13

14

6

908484/BP0615

20

PRINTED IN U.S.A.

634 Telehandler

Operator’s Station Cab Mounts and Panels

Ref. No.

Part No.

01 02 03 04 05 06 07 08 09 10 11 12 13 14

L50294 L50151 L63269 L520019 L63870 L50230 L50141 L530004 L50567 L64124 L64197 L520007 L63458 L54002

PRINTED IN U.S.A.

Description

Qty. Req.

1/2”-13X3-1/2” BOLT . . . . . . . . . . . . 2 1/2” WASHER . . . . . . . . . . . . . . . . . 2 MOUNT, VIBRATION ISOLATOR . . 2 1/2”-13 NYLON INSERT NUT . . . . . 2 WLDMNT, FRONT OPER . . . . . . . . 1 5/16”-18X3/4” BOLT . . . . . . . . . . . 14 5/16” FLAT WASHER . . . . . . . . . . 10 5/16”-18 FASTENER NUT. . . . . . . 10 5/8”X11X3-1/2” BOLT . . . . . . . . . . . 2 MOUNT, VIRATION ISOLATOR . . . 2 WASHER, ISOLATOR MOUNT. . . . 2 5/8”-11 NYLON INSERT NUT . . . . . 2 COVER, BOTTOM OPER. . . . . . . . 1 SAFETY TREAD . . . . . . . . . . . . . . . 1 (Cut into 6”x24” pieces)

21

Ref. No.

Part No.

Description

Qty. Req.

15 16 17 18 19 20 21 22

L63519 L63559 L50051 L50202 L52025 L68347 L50143 L68449 L68784

FLOOR MAT (43”) . . . . . . . . . . . . . . 1 WLDMNT, BRAKE ACCS COVR. . . 1 1/4”-20 FLANGE NUT . . . . . . . . . . . 2 1/4”-20X5/8” BUTTON HD BOLT . . 2 5/16”-18X3/4” BUTTON HD BOLT . 3 PANEL, JOYSTICK ACCESS . . . . . 1 5/16” LOCK WASHER . . . . . . . . . . . 4 WLDMNT, REAR FENDER . . . . . . . 1 CANOPY WELDMENT . . . . . . . . . . 1

00 00

L63813 L66842

-- ITEMS NOT SHOWN -HOLE PLUG 2-1/2” DIA. . . . . . . . AR HOLE PLUG 2” DIA.. . . . . . . . . . . AR

908484/BP0615

Operator’s Station

634 Telehandler

Steering Column Group

1

2

3

14 5

4 5

6

7 8 13 12

9 T

11

L P R 10

908484/BP0615

22

11

STEER MOTOR PORTS

PRINTED IN U.S.A.

634 Telehandler

Operator’s Station Steering Column Group

Ref. No.

Part No.

01 02 03 04 05 06

L40496 L41260 L41261 L50101 L68772 L500446 L500447 L67832 L500673

07 08

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

STEERING WHEEL (15”) . . . . . . . . 1 CAP, STEERING WHEEL . . . . . . . . 1 NUT, STEERING WHEEL . . . . . . . . 1 M5X.8X35mm HX SKTHD BOLT . . 2 SHIFTER, 3-SPD F-N-R . . . . . . . . . 1 HANDLE, TILT . . . . . . . . . . . . . . . . . 1 KNOB, HANDLE . . . . . . . . . . . . . . . 1 RUBBER GROMMET . . . . . . . . . . . 1 BOOT, DUST . . . . . . . . . . . . . . . . . . 1

09 10 11 12 13 14

L50253 L64524 L444004 L62842 L68713 L68773

3/8”-16 BUTTON HD BOLT . . . . . . . 4 CHECK VALVE . . . . . . . . . . . . . . . . 1 ADAP, -8ORM -8JICM STR. . . . . . . 3 ADAP, -4ORM -6JICM 90DEG . . . . 1 MOTOR, STEER, 17.9 DYN LS . . . 1 COLUMN, TILT . . . . . . . . . . . . . . . . 1

L68774

-- ITEMS NOT SHOWN-WIRE HARNESS, FNR SHIFTER. . 1

NOTE: See hydraulic section for list of hoses and locations.

PRINTED IN U.S.A.

23

908484/BP0615

Operator’s Station

634 Telehandler Seat Group

1 2

5

6

3

7 4

5

8

7

6

STANDARD SEAT (SHOWN)

908484/BP0615

24

PRINTED IN U.S.A.

634 Telehandler

Operator’s Station Seat Group

Ref. No.

Part No.

01

100135 L63811 L99454 L62459 L50208

02 03 04 05 06 07 08

L63810 L500948 L50061 L52026 L50056

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

-- ITEMS NOT SHOWN --

SEAT, OPERATOR’S (Standard) . . . 1 SEAT, SUSPENSION (Optional) . . . 1 ARM REST, SEAT (LH) (Std. Seat) . 1 HOLDER, MANUAL. . . . . . . . . . . . . 1 1/4”-20X1/2” CUTTING SCREW . . . 2 SEAT BELT ASSEMBLY . . . . . . . . . 1 Used on standard seat Used on suspension seat 3/8”-16 FLANGE NUT . . . . . . . . . . . 2 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 2 5/16”-18 FLANGE NUT . . . . . . . . . . 4

25

00a 00a 00a 00a

L52025 L520005 L50367 L50145

a

Used to mount suspension seat.

5/16”-18x3/4” BUTTN HD BOLT . . . 4 3/8”-16 LOCK NUT . . . . . . . . . . . . . 4 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 4 3/8” FLAT WASHER . . . . . . . . . . . . 8

908484/BP0615

Operator’s Station

634 Telehandler Top Dash

35

34

DE-CLUTCH

OPTIONAL SWITCHES 1

33 36

ETHER

2

TURN

32 LIGHTS

3

31 HAZARD

30

4

5

FAN

38

28 WASHER

WIPER

37

9

8

6

29

7

13 27

12

26

11 10

16

14

15

25

17

21

19

20

19

18

14 22

908484/BP0615

23

26

24

2

PRINTED IN U.S.A.

634 Telehandler

Operator’s Station Top Dash

Ref. No.

Part No.

01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18 19 20 21

L63674 L50141 L52025 L66011 L50417 L68638 L63688 L63640 L66437 L63610 072340 L520017 L50546 L50056 L62484 L50230 L650012 L50835 L41848 L63699 089069 089070 L43965 L43964 L63941 L63936 L63942 L63935 L67674

22 23 24

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

PLATE, LEVEL INDICATOR . . . . . . 1 5/16” FLAT WASHER . . . . . . . . . . . 6 5/16”-18X3/4” BUTTN HD BOLT . . . 2 INDICATOR, FRAME LEVEL . . . . . 1 #8X1” RND HD MACH SCREW. . . 2 STEER SELECT SWITCH . . . . . . . 1 PANEL, RECESSED GUAGE . . . . . 1 GUAGE, FUEL . . . . . . . . . . . . . . . . 1 GUAGE, WATER TEMP. . . . . . . . . . 1 GUAGE, LIGHT CLUSTER . . . . . . . 1 GUAGE, HOUR METER . . . . . . . . . 1 #6-32 NYLON INSERT NUT . . . . . . 2 #6-32X3/4” RD MACH SCREW . . . 2 5/16”-18 FLANGE NUT . . . . . . . . . . 3 BRACKET, SWITCH MOUNT . . . . . 1 5/16”-18X3/4” BOLT . . . . . . . . . . . . 1 SWITCH, BRAKE LIGHT. . . . . . . . . 1 5/16-18X2” BOLT. . . . . . . . . . . . . . . 2 SWITCH, PUSH BUTTON. . . . . . . . 2 BREAKER, CIRCUIT 15 AMP . . . . . 1 SWITCH, IGNITION . . . . . . . . . . . . 1 KEY ONLY . . . . . . . . . . . . . . . . . . . 1 SPACER, PARK BRAKE LEVER . . 1 SPACER, PARK BRAKE LEVER . . 1 SWITCH PANEL (3 HOLES) . . . . . . 1 SWITCH PANEL (NO HOLES) SWITCH PANEL (6 HOLES) SWITCH PANEL (9 HOLES) SWITCH PANEL (A/C - 7 HOLES.)

25 26 27 28 29 30 31 32 33 34 35 36 37 38

L50896 L50655 L277568 L63932 L66850 L66849 L63934 L63937 L68054 NA L63938 L63933 L63689 L50202

#10-24 NUT . . . . . . . . . . . . . . . . . . . 4 #10-24X1/2” RD MACH. SCREW . . 4 LEVER, PARK BRAKE . . . . . . . . . . 1 SWITCH, WASHER SYSTEM . . . . . 1 SWITCH, WIPER (2-SPEED) . . . . . 1 SWITCH, HEATER FAN (2-SPD) . . 1 SWITCH, HAZARD LIGHTS . . . . . . 1 SWITCH, LIGHTS . . . . . . . . . . . . . . 1 SWITCH, ETHER . . . . . . . . . . . . . . 1 OTHER OPTION . . . . . . . . . . . . . . . 1 SWITCH, CLUTCH CUT OUT. . . . . 1 SWITCH, TURN LIGHTS . . . . . . . . 1 GUAGE, COVER PANEL . . . . . . . . 1 1/4”-20X5/8” BTTN HD BOLT . . . . . 4

L67681

-- ITEMS NOT SHOWN-(SWITCHES) SWITCH, AIR COND. . . . . . . . . . . . 1

Qty. Req.

L63634 L63887

(LOAD CHARTS) LOAD CHART PACKAGE . . . . . . . . 1 (Includes load chart plates, load charts, u-bolts and nuts) PLATE, LOAD CHART . . . . . . . . . . 6 1/4”-20 U-BOLT . . . . . . . . . . . . . . . . 1

L63633 L42342 L47275

(PARKING BRAKE) PARK BRAKE CABLE . . . . . . . . . . . 1 3/8”X1-1/4” CLEVIS PIN . . . . . . . . . 1 CLAMP, BRAKE CABLE . . . . . . . . . 1

L63837

27

Description

908484/BP0615

Operator’s Station

634 Telehandler Under Dash

16 15

3 1

14

4

2

17

5 6

7 8

13

11

10

7 9

10

12

11

FRONT

908484/BP0615

28

PRINTED IN U.S.A.

634 Telehandler

Operator’s Station Under Dash

Ref. No.

Part No.

01a

L650004 L68447 L650012 L66437 072340 L41848 L62132 L63699 L63872

02 03 04 05 06 07 08 09 10 11 12

L63894 L62949 L650004 L650005 L66736 L63335

13

L63335

14

089069 089070

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

BLOCK, TERMINAL 3 BANK . . . . . 1 HARNESS, CAB OPTION . . . . . . . 1 BRAKE LIGHT SWITCH . . . . . . . . . 1 GUAGE, WATER TEMP . . . . . . . . . 1 GUAGE, HOURMETER . . . . . . . . . 1 SWITCH, PUSH BUTTON. . . . . . . . 2 BUZZER, 12 VDC . . . . . . . . . . . . . . 1 BREAKER, CIRCUIT 15 AMP . . . AR HARNESS, LIGHT PKG . . . . . . . . . 1 (Used with Deluxe Light Pkg) FLASHER . . . . . . . . . . . . . . . . . . . . 1 RELAY, DPDT 12VDC . . . . . . . . . AR BLOCK, TERMINAL 3 BANK . . . . AR JUMPER . . . . . . . . . . . . . . . . . . . AR CLINCH JUMPER . . . . . . . . . . . . AR RELAY . . . . . . . . . . . . . . . . . . . . . . . 1 (Used with windshield wipers) RELAY . . . . . . . . . . . . . . . . . . . . . . . 1 (Used for electrical system) SWITCH, IGNITION . . . . . . . . . . . . 1 KEY ONLY . . . . . . . . . . . . . . . . . . . 1

15 16 17

L63610 L63640 L68638

GUAGE, LIGHT CLUSTER . . . . . . . 1 GUAGE, FUEL . . . . . . . . . . . . . . . . 1 SWITCH, STEER SELECT . . . . . . . 1

L63142 L63606 L63611 L63751 L63752 L63753 L64090 L64097 L64970 L66053 L66162

-- ITEMS NOT SHOWN -WIRE ASY . . . . . . . . . . . . . . . . . . . . 1 WIRE ASY, 16GA.X18” RED . . . . . . 1 WIRE ASY . . . . . . . . . . . . . . . . . . . . 2 WIRE ASY, RELAY TO BUZZER. . . 1 WIRE ASY, 16GA.X8” BLACK . . . . . 1 WIRE ASY, RELAY TO BLOCK. . . . 2 WIRE ASY, 14GAX6” BLACK . . . . . 5 WIRE ASY, 8” .25 SLIDE #10 EYE . 2 WIRE ASY, 14GAX6” BLACK . . . . . 5 WIRE ASY, 14GAX8” BLACK . . . . . 2 WIRE ASY, 16GAX6”. . . . . . . . . . . . 1

a

29

Description

Qty. Req.

Terminal block and wire harness used for units equipped with heater only option. Units equipped with Air Conditioning uses L68468 harness and no terminal block.

908484/BP0615

Operator’s Station

634 Telehandler

Accelerator and Brake Pedals FRONT

OPTIONAL CLUTCH CUT-OUT

40 39 38 37

1

35 2

35

TO FRONT AXLE 33

9 10

34

5

4

11

36

3

7

8

6

32 31

24 25

26

23

27

22

28 30

13

12

22 18 19 20

29 18

21 20

14

19

15 16

908484/BP0615

TO REAR AXLE

17

30

PRINTED IN U.S.A.

634 Telehandler

Operator’s Station

Accelerator and Brake Pedals Ref. No.

Part No.

01 02 03 04a

L63230 L50235 L50056 L63172

05 06 07

L66156 L50151 L48179

08 09 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28

P470079 L64890 L67330 L50628 L63564 L520004 L50835 L51591 L63651 L63651 L50607 L580005 L50072 L63373 L44859 L10465 L510041 L50150 L520005 L50145 L50261

Description

Qty. Req.

Ref. No.

Part No.

PAD, BRAKE PEDAL . . . . . . . . . . . 1 5/16”-18X1-1/4” BOLT . . . . . . . . . . . 2 5/16”-18 FLANGE NUT . . . . . . . . . . 2 BRAKE LEVER ASSEMBLY . . . . . . 1 (Includes item 7) BRAKE LINKAGE, WLDMNT . . . . . 1 1/2” FLAT WASHER . . . . . . . . . . . . 1 BRONZE BUSHING . . . . . . . . . . . . 2 (Included with item 4) SPACER . . . . . . . . . . . . . . . . . . . . . 1 SWITCH, BRAKE LIGHT. . . . . . . . . 1 PIN, BRAKE LEVER PIVOT . . . . . . 1 ROLL PIN, .19X1 . . . . . . . . . . . . . . . 1 SWITCH, DIFF. PRESSURE . . . . . . 1 5/16”-18 NYLON INSERT NUT . . . . 2 5/16”-18X2” BOLT . . . . . . . . . . . . . . 2 ADAP, -4ORM -4JICM 90DEG . . . . 2 HOSE, -4 A4/DM4 17” . . . . . . . . . . . 1 HOSE, -4 AT/DM4 17” . . . . . . . . . . . 1 1/8”X1” COTTER PIN . . . . . . . . . . . 2 YOKE, CLEVIS 1/2”-13 . . . . . . . . . . 2 1/2”-13 NUT. . . . . . . . . . . . . . . . . . . 2 ROD, BRAKE VALVE . . . . . . . . . . . 1 PIN, CLEVIS 1/2”X27/64” . . . . . . . . 2 ZERK, GREASE 1/4”-28 . . . . . . . . . 1 7/16”-20X1” BOLT . . . . . . . . . . . . . . 2 7/16” LOCK WASHER . . . . . . . . . . . 2 3/8”-16 NYLON INSERT NUT . . . . . 6 3/8” FLAT WASHER . . . . . . . . . . . . 6 3/8”-16X1-1/2” BOLT . . . . . . . . . . . . 6

29 30 31 32 33 34 35 36 37

38 39 40

L63382 L63382 100012 L446044 L62741 L63363 L63629 L62926 L68641 L52024 L50051 L98865 L446044 L51622 L63286

HOSE, -4 A4/DS6 88” . . . . . . . . . . . 1 HOSE, -4 A4/DS6 88” . . . . . . . . . . . 1 ADAP, -4JICFS -4JICM 90DEG . . . 1 ADAP, -4 SWIVEL TEE . . . . . . . . . . 2 ADAP, HYDROMAX -4JICM STR . . 2 VALVE, BRAKE MASTER CYL. . . . 2 BRACKET, THROTTLE RETRN . . . 2 SPRING, CABLE TENSION . . . . . . 1 PEDAL, ACCELERATOR . . . . . . . . 1 1/4”-20X1” BUTTN HD BOLT . . . . . 3 1/4”-20 FLANGE NUT . . . . . . . . . . 3 BOOT . . . . . . . . . . . . . . . . . . . . . . . 1 ADAP, -4 SWIVEL TEE . . . . . . . . . . 1 ADAP, 1/4”NPTF -4JICFS . . . . . . . . 1 PRESSURE SWITCH . . . . . . . . . . . 1

a

L98709

LEVER KIT . . . . . . . . . . . . . . . . . . . 1 (Includes items 4, 7, 8, 10, 11 & 23)

Qty. Req.

-- ITEMS NOT SHOWN-(Throttle) L63420 THROTTLE CABLE. . . . . . . . . . . . . 1 L64664 COUPLER (John Deere) . . . . . . . . 1 L64663 THROTTLE ROD (John Deere) . . . 1 L561004

L66135

PRINTED IN U.S.A.

Description

31

(Brake) RETURN SPRING (Brake lever) . . . 1 (attaches to item 4) (Clutch Cut-Out) HARNESS, CLUTCH CUT-OUT . . . 1

908484/BP0615

Operator’s Station

634 Telehandler Heater (No Air Conditioning) 1

2

FRONT

3

5 4

7

6

8

Heater shut-off valve DEFROSTER FAN (OPTIONAL)

12

13

14

ENGINE (Left Side)

10 11

9 5

16 15

REAR OF MACHINE 5

17

908484/BP0615

32

PRINTED IN U.S.A.

634 Telehandler

Operator’s Station Heater (No Air Conditioning)

Ref. No.

Part No.

01 02 03

L63545 L99320 L66849 L99449 L50056 L75956 L52025 L63536 L66997 L500448 L68592 L69718 L68591 L66986 L50208 L66993

04 05 06 07 08 09 10 11a 12 13 14

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

GRILL, DEFROSTER . . . . . . . . . . . 1 TUBING, DUCT (12”). . . . . . . . . . . . 1 SWITCH, HEATER (2SPD) . . . . . . . 1 RESISTOR, 12W/3 OHM . . . . . . . . 1 5/16”-18 FLANGE NUT . . . . . . . . . . 5 #10 HOSE CLAMP . . . . . . . . . . . . . 4 5/16”-18X3/4” BUTTN HD BOLT . . . 2 BRACKET, CAB HEATER . . . . . . . . 1 HEATER, CAB . . . . . . . . . . . . . . . . . 1 BLOWER MOTOR (no fan blade) . 1 SHUTOFF, MANUAL . . . . . . . . . . . . 1 ADAP, 3/8”NPTF 18MX1.5 ORING . 2 STEM, HOSE . . . . . . . . . . . . . . . . . 1 DEFROSTER FAN (Optional) . . . . . 1 1/4”-20X1/2” SELF TAP SCREW . . 2 BRACKET, DEFROSTER FAN . . . . 1

15 16 17

L50896 L50655 101158 L42448 L67832

#10-24 NUT . . . . . . . . . . . . . . . . . . . 3 #10-24 BOLT . . . . . . . . . . . . . . . . . . 3 HARNESS, DEFROSTER FAN . . . . 1 CONNECTOR, 14-16 GA. BUTT . . 4 RUBBER GROMMET. . . . . . . . . . . 2

00 00 00

L63813 L66842 L68447

-- ITEMS NOT SHOWN-HOLE PLUG 2-1/2” DIA. . . . . . . . AR HOLE PLUG 2” DIA.. . . . . . . . . . . AR HARNESS, CAB OPTION . . . . . . . . 1

00

L99321

HOSE, HEATER 5/8”X216” . . . . . . . 2

a

L447005 adapter replaces L68591 hose stem and one L69718 adapter (item 10)

33

Description

Qty. Req.

908484/BP0615

Operator’s Station

634 Telehandler Air Conditioning 6

1 7

5

2

MOUNTED ON BOOM

MOUNTED ON BOOM

8 3

4

9 10

17 16 2

2

15

15

18 19

11

12

20 14

DEFROSTER VENT

21

13

15

25

24

23

22

26 27

MOUNTED UNDER SEAT

29

28

30

FRONT

908484/BP0615

34

PRINTED IN U.S.A.

634 Telehandler

Operator’s Station Air Conditioning

Ref. No.

Part No.

01 02 03 04 05 06 07 08 09 10

L50367 L520005 L50823 L50141 101275 101274 L71520 101276 101275 L68463 L500720 L67681 L99010 L67674 L63545 L68602 L50403 L66675 L50836 L50147 L67629 L99124 L68569 L68600 L68592 L68591 L69718

11 12 13 14 15 16 17 18 19 20 21 22 23a 24

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

3/8”-16X1” BOLT . . . . . . . . . . . . . . . 4 3/8”-16 NYLON INSERT NUT . . . . 12 5/16”-18X1” BOLT . . . . . . . . . . . . . . 4 5/16” FLAT WASHER . . . . . . . . . . . 4 MOUNT, AC COND-FRONT . . . . . . 1 MOUNT, AC-COND-REAR . . . . . . . 1 ELECTRIC CONDENSER. . . . . . . . 1 BRACKET, AC-COND-REAR . . . . . 1 BRACKET, AC-COND-FRONT . . . . 1 DRYER W/BINARY SWITCH . . . . . 1 BINARY SWITCH (ONLY) . . . . . . . 1 SWITCH, AC-HEAT - ROCKER . . . 1 FAN SPEED SWITCH (not shown) . 1 PANEL, AC SWITCH . . . . . . . . . . . . 1 GRILL, DUCT . . . . . . . . . . . . . . . . . 2 COMRESSOR BRKT, WLDMNT . . . 1 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 8 V-BELT, AC COMPRESSOR . . . . . . 1 3/8”-16X1-3/4” BOLT . . . . . . . . . . . . 4 3/8” LOCK WASER . . . . . . . . . . . . . 4 KIT, OUTSIDE AIR. . . . . . . . . . . . . . 1 A/C FILTER. . . . . . . . . . . . . . . . . . . 1 AUXLIARY DRIVE PULLY. . . . . . . . 1 TIGHTENER, COMPRESSOR . . . . 1 SHUT-OFF, MANUAL . . . . . . . . . . . 1 STEM, HOSE . . . . . . . . . . . . . . . . . 1 ADAP, M18X1.5 -6NPTF STR . . . . . 2

25 26 27 28 29 30

L68461 L63554 L67732 L98999 L67630 L500768 L68451

COMPRESSOR, AC . . . . . . . . . . . . 1 TUBING, DUCT 2” DIA. . . . . . . . . AR ADAPTER, AC TUBING . . . . . . . . . 2 TUBING, DUCT 2-1/2” DIA. . . . . . AR A/C & HEATER BLOWER UNIT . . . 1 FAN MOTOR WITH BLADE . . . . . . 1 AIR CHANNEL WELDMENT . . . . . . 1

31 32 33 34 35 36

L68610 L68611 L68274 L68276 L68277 L68156

(A/C Hoses) HOSE, AC 1/2”X104”. . . . . . . . . . . . 1 HOSE, AC 13/32”x43” . . . . . . . . . . . 1 HOSE, AC 13/323”X71”. . . . . . . . . . 1 HOSE, AC 5/16”X61”. . . . . . . . . . . . 1 HOSE, AC 5/16”X100”. . . . . . . . . . . 1 HOSE, AC -5/16”X58” . . . . . . . . . . . 1

a

L447005 Adap, M18ORM 10BEAD STR can be . . . used to replace this part L68591 hose stem and one of item 24 #L69718 adapter.

00 00 00 00 00 00

L68467 L99448 L75956 L99141 L99321 L99847

-- ITEMS NOT SHOWN -HARNESS, AC . . . . . . . . . . . . . . . . 1 INLINE FUSE, 20AMP. . . . . . . . . . . 1 #10 HOSE CLAMP . . . . . . . . . . . . . 4 HOSE, HEATER 5/8”X120” . . . . . AR HOSE, HEATER 5/8”X216” . . . . . AR HOSE, HEATER 5/8”X192” . . . . . AR

CONDENSER

33 32

34 RECEIVER/DRYER

COMPRESSOR

36

35

31

AIR CONDITIONING HOSES

EVAPORATOR/BLOWER

PRINTED IN U.S.A.

35

908484/BP0615

Chassis

634 Telehandler Frame and Covers 1

27

2

5

6

3

9

7

9 8

2

10

4 26

25

12

13

11

9

5

3 4

23

24

14

22 21 20

15 16 9 2 11

11 19

18

908484/BP0615

17

16

36

PRINTED IN U.S.A.

634 Telehandler

Chassis Frame and Covers

Ref. No.

Part No.

01 02 03 04 05 06 07

L50823 L50141 L50056 L62722 L62720 L68192 L68133 L68134 L68135 L68171 L50230 L68310 L530004 L68182 L68185 NSS L68205 L67756 L50145 L50442 L41847 L52025

08 09 10 11 12 13 14 15 16 17 18 19 20

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

5/16”-18x1” BOLT . . . . . . . . . . . . . . 2 5/16” FLAT WASHER . . . . . . . . . . 30 5/16” FLANGE NUT. . . . . . . . . . . . . 5 FASTNER RECEPTACLE . . . . . . . . 4 FASTNER STUD . . . . . . . . . . . . . . . 4 TOP ACCESS PANEL . . . . . . . . . . . 1 FASTNER, WING STYLE . . . . . . . . 4 STAR LOCK WASHER. . . . . . . . . . 4 QUICK NUT . . . . . . . . . . . . . . . . . . 4 RADIATOR GRILLE. . . . . . . . . . . . . 1 5/16”-18X3/4” BOLT . . . . . . . . . . . 26 REAR HOOD WELDMENT . . . . . . . 1 5/16” NUT/CLIP RETAINING. . . . . 24 REAR HOOD EXT WLDMNT . . . . . 1 RADIATOR PANEL WLDMNT (LH) . 1 MAIN FRAME WELDMENT . . . . . . 1 FRONT HOOD WELDMENT. . . . . . 1 MUFFLER GUARD WLDMNT. . . . . 1 3/8” FLAT WASHER . . . . . . . . . . . . 4 3/8”-16X1-1/4” SELF TAP BOLT . . . 4 HORN, 12V ELEC B21 . . . . . . . . . . 1 5/16”-18X3/4” BUTTN HD SCREW. 4

21 22 23 24 25 26 27

L68866 L68200 L63913 L50755 L63756 L68193 L68186

Description

Qty. Req.

FRAME FRONT PANEL . . . . . . . . . 1 ACCESS COVER (Battery) . . . . . . . 1 MIRROR BRACKET WLDMENT. . . 1 5/16”-18 ACORN NUT . . . . . . . . . . . 5 MIRROR, CONVEX 6-1/2”X10”. . . . 1 MID HOOD SECT. WLDMNT . . . . . 1 RADIATOR PANEL WLDMNT (RH) 1

-- ITEMS NOT SHOWN -HARNESS, MAIN FRAME. . . . . . . . 1 RUBBER MOLDING. . . . . . . . . . . AR (used around various panels) L550003 5/16”-18X3/4” WELD STUDS . . . . . 4 (used to fasten mirror brkt to tank) L70200 BACKUP ALARM. . . . . . . . . . . . . . . 1 L68777 L68268

L63870 L68449 L63864

37

(FENDERS) FENDER, LEFT FRONT . . . . . . . . . 1 FENDER, LEFT, REAR . . . . . . . . . . 1 FENDER, RIGHT SIDE . . . . . . . . . . 2 (used on both front and back)

908484/BP0615

Chassis

634 Telehandler Hydraulic and Fuel Tanks

3 7 4

6

1 2

2

8

5 9

23

24

22 10

11

12 14

15

21

13

16 17

20 19 18

FRONT INSIDE TANK

908484/BP0615

38

PRINTED IN U.S.A.

634 Telehandler

Chassis Hydraulic and Fuel Tanks

Ref. No.

Part No.

01 02 03

L63215 L99163 L62831 L98568 .L97489 L97489 L63505 L63798 L61867 L50418 L41854 L63217

04 05 06 07 08 09 10 11 12 13 14 15

L50286 L520019 L442022 L67616 L72175 L81690 L68619 L444002

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

CAP, HYDRAULIC ASSEMBLY . . . . 1 GASKET, FILLER NECK . . . . . . . . . 4 ASSEMBLY, IN-TANK FILTER. . . . . 1 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1 ELEMENT (item #4) . . . . . . . . . . . . 1 ELEMENT . . . . . . . . . . . . . . . . . . . . 1 ADAP -12JICM -24NPTM STR . . . . 1 CAP, FUEL ASSEMBLY. . . . . . . . . . 1 SENDER, FUEL LEVEL . . . . . . . . . 1 #10-32X1/2” RD MACH SCREW . . 5 GASKET, FUEL SENDER . . . . . . . . 1 FUEL TANK WELDMENT . . . . . . . . 1 (Includes item 13) 1/2”-13X1-3/4” BOLT . . . . . . . . . . . . 8 1/2”-13 NYLON INSERT NUT . . . . . 8 ADAP -4JICM -4NPTM . . . . . . . . . . 1 HOSE -4 73”(Fuel Return) . . . . . . . 1 PLUG, 1/2” NPT. . . . . . . . . . . . . . . . 1 ADAP -6JICM -4NPTM . . . . . . . . . . 1 HOSE -6 73” (Fuel Supply) . . . . . . 1 ADAP -6ORM -6JICM STR . . . . . . . 3

16 17 18 19 20 21

L446046 L441010 L61620 L49327 L43221 L68763

22 23 24

L65144 L50230 L65142

PLUG, -6ORM . . . . . . . . . . . . . . . . . 1 ADAP -24NPTM -24JICM STR . . . . 1 1-1/2” THREADED PIPE . . . . . . . . . 1 STRAINER, HYD. OIL . . . . . . . . . . . 1 PLUG, 1/2”-14 MAGNETIC . . . . . . . 1 HYDRAULIC TANK WELDMENT . . 1 (Includes items 18-20) GASKET, RUBBER . . . . . . . . . . . . . 1 5/16”-18X1-1/4” BOLT . . . . . . . . . . 10 PLATE, HYDRAULIC TANK COVR. 1

L75906

-- ITEMS NOT SHOWN -CLAMP, HOSE #6 . . . . . . . . . . . . . . 1

L63864

L63756 L63913 L50755

39

Description

Qty. Req.

(Fenders) FENDER, RIGHT SIDE . . . . . . . . . . 2 (fits both front and rear) (Mirror) MIRROR, CONVEX 6-1/2”X10”. . . . 1 BRACKET, MIRROR . . . . . . . . . . . . 1 5/16”-18 ACORN NUT . . . . . . . . . . 5

908484/BP0615

Chassis

634 Telehandler Battery Group

1

2

10 4

3

9

5

8

6

7

FRONT

908484/BP0615

40

PRINTED IN U.S.A.

634 Telehandler

Chassis Battery Group

Ref. No.

Part No.

01 02 03 04 05

L63334 L630004 L630001 L630003 L63248

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

BAR, BATTERY HOLD DOWN . . . . 1 GROUND STRAP, 14GA.X14” . . . . 1 CABLE, NEG. BATTERY . . . . . . . . . 1 BOOT, RUBBER . . . . . . . . . . . . . . . 1 CABLE, POS. BATTERY . . . . . . . . . 1

06 07 08 09 10

L41847 NSS L50061 L70146 L530003

41

Description

Qty. Req.

HORN, 12V ELEC B2I. . . . . . . . . . . 1 BATTERY, 4DLT TYPE . . . . . . . . . . 1 3/8”-16 FLANGE NUT . . . . . . . . . . . 4 ROD, BATTERY HOLD DOWN. . . . 2 3/8”-16 WING NUT . . . . . . . . . . . . . 2

908484/BP0615

Chassis

634 Telehandler Lights

STANDARD TAIL LIGHTS 6

1 1 2

5

3 4

1

3 7

10 13

9 8

8

11

9

10

12

11

DELUXE TAIL LIGHTS

FRONT

908484/BP0615

42

PRINTED IN U.S.A.

634 Telehandler

Chassis Lights

Ref. No.

Part No.

01 02 03 04 05 06

L4445 L50367 L63853 L520005 L4446 L62814 L50230 L50056 L70200 L50230 L50056 L63816 L63814 L63815 L68304 L50209 L50136

07

08a 09a 10a 11

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

LIGHT, HEAD . . . . . . . . . . . . . . . . . 3 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 2 MOUNT, WORK LIGHT . . . . . . . . . . 2 3/8”-16 NYLON INSERT NUT . . . . . 2 LIGHT, TAIL . . . . . . . . . . . . . . . . . . . 2 BRACKET, LIGHT . . . . . . . . . . . . . . 1 5/16”-18X3/4” BOLT . . . . . . . . . . . . 2 5/16”-18 FLANGE NUT . . . . . . . . . 2 BACKUP ALARM. . . . . . . . . . . . . . . 1 5/16”-18X3/4” BOLT . . . . . . . . . . . . 2 5/16”-18 FLANGE NUT . . . . . . . . . 2 LIGHT, BACKUP . . . . . . . . . . . . . . . 2 LIGHT, STOP-TAIL . . . . . . . . . . . . . 2 LIGHT, TURN. . . . . . . . . . . . . . . . . . 2 BRACKET, TAIL LIGHTS. . . . . . . . . 2 1/4”-20X1/2” BOLT . . . . . . . . . . . . . 4 1/4” LOCK WASHER . . . . . . . . . . . 4

12b 13b

L99204 L99205

HEAD LIGHT, RIGHT SIDE. . . . . . . 1 HEAD LIGHT, LEFT SIDE . . . . . . . . 1

a a

L64987 L63873 L63874 L63872 L63546 L67832

-- ITEMS NOT SHOWN -HARNESS, BRAKE LIGHTS . . . . . . 1 HARNESS, LIGHT ASY (FRONT). . 1 HARNESS, TAIL LIGHT . . . . . . . . . 1 HARNESS, UNDER DASH . . . . . . . 1 GROMMET, RUBBER . . . . . . . . . . . 1 GROMMET, RUBBER . . . . . . . . . . . 2

a

Used with deluxe light package

b

L63854

b b

L99423 NSS

43

Description

Qty. Req.

HEADLIGHT KIT . . . . . . . . . . . . . . . 1 (includes items 12 & 13) SEALED BEAM ONLY. . . . . . . . . . . 1 TURN SIGNAL BULB (GE 1157)

908484/BP0615

Engine

634 Telehandler External Engine Components Group

1

27

4

2 3

5

26

6

25 24

23

22

21

JOHN DEERE 4045TF (SHOWN)

20

8 9 7 19

10

18

12

12 11

14 15 17

16

TRANSMISSION MOUNTS

REAR

13 14 15 16

908484/BP0615

44

PRINTED IN U.S.A.

634 Telehandler

Engine

External Engine Components Group Ref. No.

Part No.

01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18 19 20 21

NSS L41179 L68571 L64437 L69166 L66606 L64664 L64663 L580009 L68531 L68533 L50319 L64196 L64124 L64197 L520007 L50704 L64646 L68596 L68595 L50667

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

ENGINE . . . . . . . . . . . . . . . . . . . . . . 1 RELAY, ENGINE STARTER . . . . . . 1 MOUNT, RELAY . . . . . . . . . . . . . . . .

SENDER, WATER TEMP . . . . . . . . 1 FUEL LINE TUBE . . . . . . . . . . . . . . 1 BRACKET, THROTTLE (JD) . . . . . . 1 COUPLER, ROD-CABLE . . . . . . . . 1 ROD, THROTTLE EXTEND . . . . . . 1 BALL JOINT #10-32 ROD END. . . . 1 TRANS MOUNT (LEFT) . . . . . . . . . 1 TRANS MOUNT (RIGHT) . . . . . . . . 1 5/8”-11X3-1/2” BOLT . . . . . . . . . . . . 4 SPACER . . . . . . . . . . . . . . . . . . . . . 2 MOUNT, VIBRATION ISOLATOR . . 4 WASHER, ISOLATOR MOUNT. . . . 4 5/8”-11 NYLON INSERT NUT . . . . . 4 M12X1.175X40M BOLT GR8 . . . . . 4 SENDER, OIL PRESSURE . . . . . . . 1 ENGINE MOUNT (RIGHT) . . . . . . . 1 ENGINE MOUNT (LEFT) . . . . . . . . 1 M8X1.25X45M BOLT GR8 . . . . . . . 4

22 23 24 25 26a 27

L69718 L68592 L68591 L68614 L447005 L68604

a

Replaces item 23 and (1) of item 21.

ADAP, M18 -6NPTF STR . . . . . . . . 2 SHUTOFF, MANUAL/WATER . . . . . 1 STEM, HOSE . . . . . . . . . . . . . . . . . 1 FAN BELT (JD 1620mm) . . . . . . . . . 1 ADAP, M18 10 BEAD STR . . . . . . . 1 BRACKET, ALTERNATOR. . . . . . . . 1

-- ITEMS NOT SHOWN -ENGINE BLOCK HEATER . . . . . . . 1 (Filters) L98978 FUEL FILTER . . . . . . . . . . . . . . . . . 1 L99420 OIL FILTER . . . . . . . . . . . . . . . . . . . 1 (Ether) L66855 ETHER KIT . . . . . . . . . . . . . . . . . . . 1 L66360 CANNISTER AND MOUNT . . . . . . 1 L68054 SWITCH, ROCKER (ETHER) . . . . 1 L650004 TERMINAL BLOCK . . . . . . . . . . . . 1 L65570

45

908484/BP0615

Engine

634 Telehandler Radiator and Cooler Group

6 25

7

1 9 6

2 4

8

5

3 19 5

4

24

21 23 22

12

11

4

10

13 3 18 14

17 19 10

5

4

16

15

4 20

FRONT

908484/BP0615

46

PRINTED IN U.S.A.

634 Telehandler

Engine

Radiator and Cooler Group Ref. No.

Part No.

01 02 03 04 05 06 07 08 09 10 11 12 13 14

L76084 L96989 L63356 L50141 L50228 L445001 L446020 L67452 L63399 L50230 L530004 L66119 L45934 L50151

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

HOSE CLAMP . . . . . . . . . . . . . . . . . 1 RADIATOR CAP . . . . . . . . . . . . . . . 1 COOLER MOUNT . . . . . . . . . . . . . . 2 5/16” FLAT WASHER . . . . . . . . . . 22 5/16”-18X1/2” BOLT . . . . . . . . . . . 10 ADAP, -12ORM -12JICM 90 DEG . . 2 ADAP -12JICFS -12JICM 90 DEG . 1 HOSE -12 A12/DS12 135”. . . . . . . . 1 HOSE -12 DS12/A12 82” . . . . . . . . 1 5/16”-18X3/4” BOLT . . . . . . . . . . . 12 5/16” NUT RETAINING CLIP. . . . . . 4 COOLER/HEAT-EXCHANGER . . . . 1 RADIATOR (MODINE). . . . . . . . . . . 1 1/2” FLAT WASHER . . . . . . . . . . . . 2

15 16 17 18 19 20 21

L520019 L40805 L67589 L50815 L76020 L68580

22 23 24 25

47

L63665 L67751 L66709 L66265 L47212 L68539

Description

Qty. Req.

1/2”-13 NYLON INSERT NUT . . . . . 2 VALVE, DRAIN COCK . . . . . . . . . . . 1 SHROUD WELDMENT . . . . . . . . . . 1 5/16”X2-1/2” BOLT . . . . . . . . . . . . . 4 HOSE CLAMP . . . . . . . . . . . . . . . . . 3 LOWER RADIATOR HOSE . . . . . . . 1 FAN GUARD (HALF) . . . . . . . . . . . . 2 (STANDARD) (WITH A/C) FAN SPACER 1” . . . . . . . . . . . . . . . 1 FAN, 18” . . . . . . . . . . . . . . . . . . . . 1 VINYL CLAMP 3/8” HOSE . . . . . . . 2 UPPER RADIATOR HOSE . . . . . . . 1

908484/BP0615

Engine

634 Telehandler Engine Air Intake Group

Pre-cleaner (Optional)

9

8 7 6

5

4 2

1

3 10 11 12

13 14 15

FRONT

AIR CLEANER

14

Air Intake (Turbo Charged)

14 16

ENGINE

18

19

Air Intake (Natural Aspirated )

14 17

17 ENGINE

AIR CLEANER

908484/BP0615

48

PRINTED IN U.S.A.

634 Telehandler

Engine Engine Air Intake Group

Ref. No.

Part No. L120038A

01

L98678

02 03 04

L98677 078936 L98647 L98649 L120054 L68516 L70468

05 06 07

L68517

08

L120039

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

AIR CLEANER ASSEMBLY. . . . . . . 1 (Includes items 1-5, and 10) DUST CUP ASSEMBLY . . . . . . . . . 1 (Includes item 2). . . . . . . . . . . . . . . .

BAFFLE (Included with item 1) . . . . 1 WING NUT . . . . . . . . . . . . . . . . . . . 1 TIGHTENING CLAMP . . . . . . . . . . . 1 THUMBSCREW . . . . . . . . . . . . . . . 1 ELEMENT . . . . . . . . . . . . . . . . . . . . 1 PRE-CLEANER (OPTIONAL) . . . . . 1 4” T-BOLT BAND CLAMP. . . . . . . . 1 (Includes item 7) REDUCER, RUBBER 4”-3” . . . . . . . 1 (Included with item 6) BAND, FILTER MOUNTING . . . . . . 2

09 10 11 12 13a 14a 15a 16b 17b 18b 19b

L60291 NSS L50230 L50056 L67657 L51099 L120041 L63439 L66877 L68643 L64788

a b

Used on turbo equipped engine.

Used on natural aspirated engine.

49

Description

Qty. Req.

AIR INTAKE CAP (STANDARD) . . . 1 AIR CLEANER BODY . . . . . . . . . . . 1 5/16”-18X3/4” BOLT . . . . . . . . . . . . 4 5/16”-18 FLANGE NUT . . . . . . . . . . 4 ELBOW, METAL 3” 90 DEGREE. . . 1 CLAMP, HOSE SAE #52 . . . . . . . . 5 ELBOW, RUBBER 3”ID 90 DEG . . . 2 ELBOW, RUBBER 2-1/2” ID 90. . . . 1 CLAMP, HOSE SAE #44 . . . . . . . . . 3 AIR INTAKE PIPE 2-1/2” OD. . . . . . 1 ELBOW, RUBBER 3”IDX2-1/2” ID . 1

908484/BP0615

Engine

634 Telehandler Engine Exhaust Group

1 3 2

Engine Exhaust Pipes

4 5 6

9

7

11

8

12

10 13

JD Natural JD Turbo

14 15 8 2

Muffler Bracket (JD Turbo) 20

19

2 17

18

5

16

FRONT

908484/BP0615

50

PRINTED IN U.S.A.

634 Telehandler

Engine Engine Exhaust Group

Ref. No.

Part No.

01 02 03 04 05 06 07 08 09a 10a 11b 12b

L67617 L68529 L520005 L48011 L120047 L64764 L50145 L50367 L50952 L500315 L68651 L500314 L120047 L99434 L68544

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

TAILPIPE . . . . . . . . . . . . . . . . . . . . . 1 Note a (2-1/4” OD) Note b (2-1/2” OD) 3/8”-16 NYLON INSERT NUT . . . . . 3 MUFFLER CLAMP . . . . . . . . . . . . . 1 Note a (2-1/4” CLAMP) Note b (2-1/2” CLAMP) TAILPIPE HANGER. . . . . . . . . . . . . 1 3/8” FLAT WASHER . . . . . . . . . . . . 5 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 1 M10 1.5X25mm BOLT . . . . . . . . . . . 4 M12 1.75X39mm BOLT . . . . . . . . . . 2 EXHAUST PIPE (JD Natural) . . . . . 1 EXHAUST GASKET . . . . . . . . . . . . 1 2-1/2” MUFFLER CLAMP . . . . . . . . 1 TURBO CLAMP. . . . . . . . . . . . . . . . 1 EXHAUST PIPE (JD Turbo) . . . . . . 1

13b 14

L60492 L120047 L60492

15

51

Description

Qty. Req.

3” MUFFLER CLAMP . . . . . . . . . . . 1 MUFFLER CLAMP Note a (2-1/2” CLAMP) Note b (3” CLAMP) MUFFLER . . . . . . . . . . . . . . . . . . . . 1 Note a Note b 3/8”-16X1-1/4” SELF TAP BOLT . . . 4 MUFFLER GUARD . . . . . . . . . . . . . 1 3/8”-16X1-3/4” BOLT . . . . . . . . . . . . 1 MUFFLER STRAP. . . . . . . . . . . . . . 1 MUFFLER BRACKET . . . . . . . . . . . 1

16 17 18 19b 20b

L63660 L64821 L50442 L67756 L50836 L61021 L64572

a b

Used with John Deere natural aspirated engine.

Used with John Deere turbo charged engine.

908484/BP0615

Transmission

634 Telehandler

External Components and Driveshaft Group

FRONT 1

2 3

25

4

26 27

24

6

5

12

7

9

8 23 22

20

11

21

12

17

10 18

19 10

10

16 15 14 13

REAR

908484/BP0615

52

PRINTED IN U.S.A.

634 Telehandler

Transmission

External Components and Driveshaft Group Ref. No.

Part No.

01

L63633 L42342 L47275 L50367 L50056 L63399 L444001 L66965 L444007 L67452 L444070 L68588 L68562 L50468 L50319 L50704 L520007 L64197 L64124

02 03 04 05 06 07 08 09 10a 11 12 13 14 15

Description

Qty. Req.

Ref. No.

Part No.

PARK BRAKE CABLE . . . . . . . . . . . 1 CLEVIS PIN. . . . . . . . . . . . . . . . . . . 2 CABLE CLAMP . . . . . . . . . . . . . . . 1 3/8”-16X1” BOLT . . . . . . . . . . . . . . 1 3/8”-16 FLANGE NUT . . . . . . . . . . 1 HOSE -12 A12/DS12 82”. . . . . . . . . 1 ADAP, -12ORM -12JICM STR. . . . . 1 SENDER, TEMP 250 DEGREE . . . 1 ADAP, -10ORM -12JICM STR . . . . 1 HOSE -12 DS12/A12 135” . . . . . . . 1 ADAP, -3ORM . . . . . . . . . . . . . . . . . 1 SWITCH, PRESSURE. . . . . . . . . . . 1 DRIVESHAFT, FRONT . . . . . . . . . . 1 3/8”-24X1-3/4” GR8 BOLT. . . . . . . 16 5/8”-11X3-1/2” BOLT . . . . . . . . . . . . 2 M12X1.75X40mm BOLT . . . . . . . . . 4 5/8”-11 NYLON INSERT NUT . . . . . 2 WASHER, ISOLATOR MOUNT. . . . 2 MOUNT, VIBRATION ISOLATOR . . 2

16 17 18 19 20

L64196 L68533 L68296 L68563 L99182 L10151 650965 L50147 L50833 L68531 L71637 L50952 L50727 L99184

21b 22c 23 24 25 26d 27 a b c d

Description

Qty. Req.

SPACER . . . . . . . . . . . . . . . . . . . . . 2 TRANS MOUNT, RIGHT . . . . . . . . . 1 TRANSMISSION,T12000 TURBO . 1 DRIVESHAFT, REAR . . . . . . . . . . . 1 UNIVERSAL JOINT . . . . . . . . . . . . . 4 GREASE ZERK . . . . . . . . . . . . . . . 2 3/8”-24X1-1/4” GR 8 BOLT . . . . . . . 8 3/8” LOCK WASHER . . . . . . . . . . . 8 3/8”-24X2” GRADE 8 BOLT . . . . . . 8 TRANS MOUNT, LEFT . . . . . . . . . . 1 BRACKET, PARK BRAKE . . . . . . . . 1 M10X1.5X25mm . . . . . . . . . . . . . . 10 M10X1.5X35mm . . . . . . . . . . . . . . . 2 FILTER, TRANSMISSION OIL . . . . 1

Used to fasten universal joint to transmission and to axle yokes.

Used to fasten universal joint to driveshaft.

Used to fasten flex plate to flywheel.

Used to fasten throttle bracket to transmission

HOSE LOCATOR 02 06

TRANSIMISSION (RIGHT SIDE) TRANSIMISSION (LEFT SIDE)

PRINTED IN U.S.A.

OIL COOLER (LEFT SIDE) OIL COOLER (RIGHT SIDE)

53

908484/BP0615

Transmission

634 Telehandler Internal Components

NOTICE FOR INTERNAL PARTS BREAKDOWN OF THE 12000 SERIES TRANSMISSION, REFER TO SEPERATE MANUAL FORM 907368.

IF YOU DO NOT HAVE THIS MANUAL, IT CAN BE ORDERED BY CALLING SERVICE PARTS AT (605)665-6500.

908484/BP0615

54

PRINTED IN U.S.A.

634 Telehandler

Transmission Notes

PRINTED IN U.S.A.

55

908484/BP0615

Axles

634 Telehandler External Components S/N 70017 - 71101

6

4 1

REAR

7

5

3

BRAKE LINES

2

10

11

9

8

12

14

15

13 STEERING LINES

16 17 27

26

FRONT AXLE (SHOWN) 25

19

18

FRONT

24

21 20

23

22

AXLE SUPPORT

908484/BP0615

56

PRINTED IN U.S.A.

634 Telehandler

Axles External Components S/N 70017 - 71101

Ref. No.

Part No.

Description

Qty. Req.

NOTE: All quantities are per axle.

01 02a 03a 04a 05 06 07 08 09 10a 11

L68849 L68878 L50157 L50084 P471370 L63382 L63381 L60653 L66139 651543 L500546

12 13

L500540 L500539 L500541

14 15

100011 L63386 L63403

16

L63387 L63388

17

L446017

AXLE, MODEL 212/233. . . . . . . . . . 2 FRAME LEVEL MOUNT . . . . . . . . . 1 3/4” WASHER, FLAT . . . . . . . . . . . . 4 3/4”-10 STOVER LOCK NUT . . . . . 4 ADAP, -6JICM -6JICFS TEE . . . . . . 1 HOSE, -4 A4/DS6 88” . . . . . . . . . . . 1 HOSE, -4A6/A6 15” . . . . . . . . . . . . . 1 ADAP, -6JICFS -6JICM 90 DEG . . . 1 ADAP, M14ORM -6JICM STR . . . . . 2 M20X2.5X130mm C10 BOLT . . . . . 4 ARTICULATED TIE ROD . . . . . . . . 1 (Right Front, Left Rear) STEER CYLINDER . . . . . . . . . . . . . 1 STEER CYLINDER BOLT . . . . . . . 4 ARTICULATED TIE ROD . . . . . . . . 1 (Left Front, Right Rear) ADAP, M18ORM -8JICM STR . . . . . 2 HOSE, -6 A8/A6 36” . . . . . . . . . . . . 1 (front axle right side) HOSE, -6 A8/DS6 110” . . . . . . . . . . 1 (rear axle right side) HOSE, -6 A8/DS8 67” . . . . . . . . . . . 1 (front axle left side) HOSE, -6 A8/DS6 100” . . . . . . . . . . 1 (rear axle left side) ADAP, -8JICFS -8JICM 90 DEG . . . 2

Ref. No.

Part No.

18 19

L69734

Description

Qty. Req.

L63222 L45049 L68875

M22X1.5 WHEEL NUT . . . . . . . . . 16 TIRE AND WHEEL ASY . . . . . . . . AR VALVE STEM. . . . . . . . . . . . . . . . . . 1 TIRE, 15.00X19.5 12 PLY . . . . . . . . 1 WHEEL ONLY (for tire L45049). . . . 1

L67499 L68884

TIRE, 405/70R 20XM27 . . . . . . . . . 1 WHEEL ONLY (for tire L67499). . . . 1

L67502 L67504

TIRE, 9.00R 20XMINE D2. . . . . . . . 1 WHEEL ONLY (for tire L67502). . . . 1

20 21 22 23 24 25 26 27a

L500543 L500544 L500490 L98355 L500542 L50201 L50712 L68876

THRUST BUSHING. . . . . . . . . . . . . 2 SUPPORT . . . . . . . . . . . . . . . . . . . . 2 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 2 GREASE FITTING. . . . . . . . . . . . . . 2 REDUCTION BUSHING . . . . . . . . . 2 M20X2.5 NYL. LOCK NUT C10 . . . 4 3/4”-10X9” GR8 BOLT . . . . . . . . . . . 4 PLATE, FRAME LEVEL. . . . . . . . . . 1

a

Used only on front axle.

HOSE LOCATOR 15 16

STEER CYLINDER, FRONT AXLE RIGHT SIDE STEER CYLINDER, REAR AXLE RIGHT SIDE STEER CYLINDER, FRONT AXLE LEFT SIDE STEER CYLINDER, REAR AXLE LEFT SIDE

PRINTED IN U.S.A.

STEER SELECT VALVE PORT “T” STEER SELECT VALVE PORT “B” STEER MOTOR PORT “L” STEER SELECT VALVE PORT “A”

57

908484/BP0615

Axles

634 Telehandler External Components S/N 70016 and before 6 BRAKE LINES

7 5 4 3 1

8

2

12 11 10 9

14

STEERING LINES

15 13 9 16

20 11

10

18 19

FRONT AXLE (SHOWN)

17

FRONT

908484/BP0615

58

PRINTED IN U.S.A.

634 Telehandler

Axles External Components S/N 70016 and before

Ref. No.

Part No.

Description

Qty. Req.

NOTE: All quantities are per axle.

01 02a 03a 04a 05 06 07 08 09b 10 11 12 13

14

L63234 L63009 L50157 L50084 L446049 L63382 L63381 L66139 L98443 L99969 L98422 L63280 L63943 L63114 L50462 L520019 L98444 L98445 L98565 L98430 L63386 L63403

15

L63387 L63388

16

L66138

AXLE, ASSEMBLY . . . . . . . . . . . . . 2 FRAME LEVEL MOUNT . . . . . . . . . 1 3/4” WASHER, FLAT . . . . . . . . . . . . 4 3/4”-10 STOVER LOCK NUT . . . . . 4 ADAP, -6JICM -6JICFS SVL TEE . . 1 HOSE, -4 A4/DS6 88” . . . . . . . . . . . 1 HOSE, -4A6/A6 15” . . . . . . . . . . . . . 1 ADAP, M14ORM -6JICM STR . . . . . 2 ARTICULATED TIE ROD W/NUT . . 2 TIE ROD NUT. . . . . . . . . . . . . . . . . 2 THRUST BUSHING. . . . . . . . . . . . . 2 THRUST WASHER, THICK. . . . . . . 2 THRUST WASHER, THIN . . . . . . . . 2 AXLE PIVOT PIN. . . . . . . . . . . . . . . 1 1/2”-13X5” BOLT . . . . . . . . . . . . . . 1 1/2”-13 NYLON INSERT NUT . . . . 1 STEER CYLINDER ASSEMBLY . . . 1 CYLINDER BOLT . . . . . . . . . . . . . . 5 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1 VENT BOLT . . . . . . . . . . . . . . . . . . 1 HOSE, -6 A8/A6 36” . . . . . . . . . . . . 1 (front axle right side) HOSE, -6 A8/DS6 110” . . . . . . . . . . 1 (rear axle right side) HOSE, -6 A8/DS8 67” . . . . . . . . . . . 1 (front axle left side) HOSE, -6 A8/DS6 100” . . . . . . . . . . 1 (rear axle left side) ADAP, 18X1.5ORM -8JICM 90D . . . 2

Ref. No.

Part No.

17 18

L98345

19 20a

Description

Qty. Req.

L63222 L45049 L63044

WHEEL NUT . . . . . . . . . . . . . . . . . 16 WHEEL & TIRE . . . . . . . . . . . . . . AR VALVE STEM. . . . . . . . . . . . . . . . . . 1 TIRE, 15-19.5 12 PLY . . . . . . . . . . . 1 WHEEL (FOR L45049 TIRE). . . . . . 1

L67499 L67498

TIRE, 405/70 R20 . . . . . . . . . . . . . . 1 WHEEL(FOR L67499 TIRE) . . . . . 1

L67502 L67504 L67507 L67508 L50712 L63115

TIRE, 9.00XR20XMINE D2 . . . . . . .1 WHEEL (FOR L67502 TIRE). . . . . . 1 FLAP . . . . . . . . . . . . . . . . . . . . . . . . 1 TUBE . . . . . . . . . . . . . . . . . . . . . . . . 1 3/4”-10X9” GR8 BOLT . . . . . . . . . . . 4 MOUNT PLATE . . . . . . . . . . . . . . . . 1

a

Used on front axle only.

b

The left and right side use the same tie rod, the tie rod ends are not sold seperately.

HOSE LOCATOR 14 15

STEER CYLINDER, FRONT AXLE RIGHT SIDE STEER CYLINDER, REAR AXLE RIGHT SIDE STEER CYLINDER, FRONT AXLE LEFT SIDE STEER CYLINDER, REAR AXLE LEFT SIDE

PRINTED IN U.S.A.

STEER SELECT VALVE PORT “T” STEER SELECT VALVE PORT “B” STEER MOTOR PORT “L” STEER SELECT VALVE PORT “A”

59

908484/BP0615

Axles

634 Telehandler Outer End Group S/N 70017 - 71101

FRONT

5 3

4 1 2

25

13

12

24

14 8 15 47 7 16 6 17

9 10

49 19 21,26 27 28

29

20 1

19

45 44

48

13

23

30 31

2

22 11

28 32

18

33

16

46

15

34

35 36 50

43

37

38 41 42

908484/BP0615

60

40

39

25

PRINTED IN U.S.A.

634 Telehandler

Axles Outer End Group S/N 70017 - 71101

Ref. No.

Part No.

Description

Qty. Req.

NOTE: All quantities are per axle.

01 02 03 04 05

L500483 L500484 L500485 L500486 L500488

06 07 07 09 10 11

L500489 L98371 L98372 L500490 L500491 L500492

12 13 14 15 16 17

L500493 L500494 L500495 L500496 L98355 L500497

18

L500498

19 20 21

L500499 L500500 L500501

22 23 24

L500502 L500503 L500456

PRINTED IN U.S.A.

NUT . . . . . . . . . . . . . . . . . . . . . . . . . 2 STEERING ADJUST BOLT . . . . . . . 2 AXLE CASE. . . . . . . . . . . . . . . . . . . 2 BOLT . . . . . . . . . . . . . . . . . . . . . . . 32 REDUCTION BUSHING . . . . . . . . . 2 (includes items 6-9, and 47) SEAL . . . . . . . . . . . . . . . . . . . . . . . . 2 BALL BEARING. . . . . . . . . . . . . . . . 2 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 2 O-RING . . . . . . . . . . . . . . . . . . . . . . 2 JOINT . . . . . . . . . . . . . . . . . . . . . . . 2 THRUST BUSHING. . . . . . . . . . . . . 2 (included with items 21 and 26) OUTER RACE . . . . . . . . . . . . . . . . . 2 BOLT . . . . . . . . . . . . . . . . . . . . . . . 20 COVER . . . . . . . . . . . . . . . . . . . . . . 2 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 4 GREASE FITTING. . . . . . . . . . . . . . 2 PIVOT PIN . . . . . . . . . . . . . . . . . . . . 2 (includes item 16) PIVOT PIN . . . . . . . . . . . . . . . . . . . . 2 (includes items 16, 19 and 20) SEAL . . . . . . . . . . . . . . . . . . . . . . . . 2 ARTICULATION. . . . . . . . . . . . . . . . 2 STEERING CASE - LF/RR . . . . . . . 1 (includes item 11) SEAL . . . . . . . . . . . . . . . . . . . . . . . . 2 DUST EXCLUDER . . . . . . . . . . . . . 2 MAGNETIC PLUG. . . . . . . . . . . . . . 2

Ref. No.

Part No.

25 26

L98318 L500504

27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49

L500505 L500506 L500507 L500508 L98417 L500509 L500510 L500511 L500512 L500513 L69734 L500455 L500515 L500516 L500517 L500518 L500519 L500554 L500521 L500522 L98373 L500555 L500523 L500524 L500525 L500526

50

61

Description

Qty. Req.

PLUG . . . . . . . . . . . . . . . . . . . . . . . . 4 STEERING CASE - RF/LR . . . . . . . 1 (includes item 11) SEAL . . . . . . . . . . . . . . . . . . . . . . . . 2 BEARING. . . . . . . . . . . . . . . . . . . . . 4 WHEEL STUD . . . . . . . . . . . . . . . . 16 WHEEL HUB . . . . . . . . . . . . . . . . . . 2 O-RING . . . . . . . . . . . . . . . . . . . . . . 2 RING GEAR . . . . . . . . . . . . . . . . . . 2 RING GEAR SUPPORT . . . . . . . . . 2 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 8 PLANET GEAR . . . . . . . . . . . . . . . . 8 BEARING. . . . . . . . . . . . . . . . . . . . . 8 WHEEL NUT . . . . . . . . . . . . . . . . . 16 SEAL WASHER . . . . . . . . . . . . . . . . 6 COUNTERSUNK BOLT. . . . . . . . . . 4 PLANET GEAT CARRIER . . . . . . . . 2 STUD . . . . . . . . . . . . . . . . . . . . . . . 16 NUT . . . . . . . . . . . . . . . . . . . . . . . . 16 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 2 ADJUSTING BOLT . . . . . . . . . . . . . 4 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 4 LOCKING PLATE . . . . . . . . . . . . . . 2 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 2 SPACER . . . . . . . . . . . . . . . . . . . . . 2 SHIM - .15mm . . . . . . . . . . . . . . . . . 2 SHIM - .20mm . . . . . . . . . . . . . . . . . 2 SHIM - .50mm . . . . . . . . . . . . . . . . . 2 PLANET GEAR CARRIER . . . . . . . 2 (includes items 32-36, 40-41)

908484/BP0615

Axles

634 Telehandler Outer End Group - Part I S/N 70016 and before

5

24

4 1 6

7

2

8 9

22

10

21

20

16 14 11

3

15

23

10

19 9

4

8

18

17

5 13

24

908484/BP0615

12

62

PRINTED IN U.S.A.

634 Telehandler

Axles Outer End Group - Part I S/N 70016 and before

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

NOTE: All quantities are per axle.

01 02 03 04 05 06 07 08 09 10

L98352 L98353 L98997 L98375 L98998 L98354 L98355 L98377 L98356 L98360 L98361 L97134

11 12 13 14 15 16

CASE . . . . . . . . . . . . . . . . . . . . . . . . 2 GRUB BOLT . . . . . . . . . . . . . . . . . . 2 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 2 STUD . . . . . . . . . . . . . . . . . . . . . . . 24 NUT . . . . . . . . . . . . . . . . . . . . . . . . 24 PIVOT PIN . . . . . . . . . . . . . . . . . . . . 4 GREASE ZERK . . . . . . . . . . . . . . . . 4 STUD . . . . . . . . . . . . . . . . . . . . . . . . 4 SHIM - PACK. . . . . . . . . . . . . . . . . . 2 DUST EXCLUDER . . . . . . . . . . . . . 4 RING . . . . . . . . . . . . . . . . . . . . . . . . 4 TAPER ROLLER BRG CONE . . . . . . . . . . . . . . . . . . . . . . . 4

17 18 19 20 21 22 23 24

PRINTED IN U.S.A.

63

Part No. L97135 L98376 L98363 L98364 L98365 L98366 L98367 L99188 L98368 L98370 L98369 L98371 L98372 L98373 L98374 L98996 L99639

Description

Qty. Req.

CUP . . . . . . . . . . . . . . . . . . . . . . . . . 4 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 2 NEEDLE BRG . . . . . . . . . . . . . . . . . 2 SNAP RING . . . . . . . . . . . . . . . . . . . 2 SEAL, OUTER. . . . . . . . . . . . . . . . . 2 DUST EXCLUDER . . . . . . . . . . . . . 2 DOUBLE UNIVERSAL JOINT . . . . 2 U-JOINT CROSS ONLY . . . . . . . . . 1 O-RING . . . . . . . . . . . . . . . . . . . . . . 2 REDUCER BUSHING . . . . . . . . . . . 2 SEAL, INNER . . . . . . . . . . . . . . . . . 2 BALL BRG.. . . . . . . . . . . . . . . . . . . . 2 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 2 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 2 STUD . . . . . . . . . . . . . . . . . . . . . . . . 4 NUT . . . . . . . . . . . . . . . . . . . . . . . . 4 HEX BOLT . . . . . . . . . . . . . . . . . . . 24

908484/BP0615

Axles

634 Telehandler Outer End Group - Part II S/N 70016 and before

5 2 1

7

3 8

17

11

10

12

14 18 13

15 22

27

24

4

23

3 6

9

16 28 29

26

25

19 20

21

20 30

908484/BP0615

64

PRINTED IN U.S.A.

634 Telehandler

Axles Outer End Group - Part II S/N 70016 and before

Ref. No.

Part No.

Description

Qty. Req.

NOTE: All quantities are per axle.

01 02 03 04 05 06 07 08 09 10 11 12 13 14

L98338 L98339 L98341 L98973 L98342 L98343 L98344 L98345 L98346 L98347 L98348 L98349 L98350 L98331

PRINTED IN U.S.A.

O-RING . . . . . . . . . . . . . . . . . . . . . . 2 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 2 TAPER ROLLER BRG. . . . . . . . . . . 4 SPACER . . . . . . . . . . . . . . . . . . . . . 2 WHEEL STUD . . . . . . . . . . . . . . . . 16 WHEEL HUB . . . . . . . . . . . . . . . . . . 2 O-RING . . . . . . . . . . . . . . . . . . . . . . 2 WHEEL NUT . . . . . . . . . . . . . . . . . 16 SNAP RING . . . . . . . . . . . . . . . . . . . 2 RING GEAR SUPPORT . . . . . . . . . 2 DOWEL . . . . . . . . . . . . . . . . . . . . . . 8 LOCKING PLATE . . . . . . . . . . . . . . 2 PINION . . . . . . . . . . . . . . . . . . . . . . 2 RING GEAR . . . . . . . . . . . . . . . . . . 2

Ref. No.

Part No.

15 16 17 18 19 20 21 22 23 24 25 26 27

L98332 L98324 L98325 L98333 L98323 L98321 L98322 L98334 L98318 L98335 L98319 L98320

28 29 30

65

L98336 L98337 L98972 L99213 L99203

Description

Qty. Req.

CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 2 FRICTION WASHER . . . . . . . . . . . . 2 SHIM-PAC . . . . . . . . . . . . . . . . . . . . 1 FRICTION WASHER . . . . . . . . . . . . 2 FRICTION WASHER . . . . . . . . . . . . 6 NEEDLE BRG . . . . . . . . . . . . . . . 12 PLANET GEAR . . . . . . . . . . . . . . . . 6 PLANET GEAR CARRIER . . . . . . . 2 PLUG, 12MM (Socket Head) . . . . . . 2 SEAL WASHER . . . . . . . . . . . . . . . . 2 O-RING . . . . . . . . . . . . . . . . . . . . . . 6 PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 6 CASE KNUCKLE. . . . . . . . . . . . . . . .

RIGHT FRONT / LEFT REAR . . . . . 1 LEFT FRONT / RIGHT REAR . . . . . 1 STUD . . . . . . . . . . . . . . . . . . . . . . . . 8 BOLT . . . . . . . . . . . . . . . . . . . . . . . . 8 SPACER . . . . . . . . . . . . . . . . . . . . . 6

908484/BP0615

Axles

634 Telehandler Differential Housing Group S/N 70017 - 71101

2 3

4

5

6

7 1 8

6

1

1

908484/BP0615

66

PRINTED IN U.S.A.

634 Telehandler

Axles Differential Housing Group S/N 70017 - 71101

Ref. No.

Part No.

Qty. Req.

Ref. No.

Part No.

NOTE: All quantities are per axle.

01 L98417 O-RING . . . . . . . . . . . . . . . . . . . . . . 3 02 L500451 INTERMEDIATE COVER . . . . . . . . 1 03 L500452 HOUSING . . . . . . . . . . . . . . . . . . . . 1

04 05 06 07 08

L500453 L500454 L500455 L98318 L500456

PRINTED IN U.S.A.

Description

67

Description

Qty. Req.

COVER . . . . . . . . . . . . . . . . . . . . . . 1 VENT . . . . . . . . . . . . . . . . . . . . . . . . 1 SEAL WASHER . . . . . . . . . . . . . . . . 2 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1 MAGNETIC PLUG. . . . . . . . . . . . . . 1

908484/BP0615

Axles

634 Telehandler Differential Group S/N 70017 - 71101

7

8

6

24

12

13

11

10

14

12 24

5 4 16

24

3

18

9 11 12

13

12 24

22

21

7

13

14 11

20

15 4

13

16

11

9 5

1

17 2

23

908484/BP0615

19

68

PRINTED IN U.S.A.

634 Telehandler

Axles Differential Group S/N 70017 - 71101

Ref. No.

Part No.

Description

Qty. Req.

NOTE: All quantities are per axle.

01 02

03 04 05 06 07 08 09 10

L500457 L500458 L500459 L500460 L500461 L500462 L500463 L98380 L500464 L500465 L500466 L500467 L500468 L500469

PRINTED IN U.S.A.

O-RING . . . . . . . . . . . . . . . . . . . . . . 1 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 BEVEL GEAR SET . . . . . . . . . . . . . 1 TAPER ROLLER BEARING . . . . . . 2 RING NUT . . . . . . . . . . . . . . . . . . . . 2 CYLINDER BOLT . . . . . . . . . . . . . . 4 CYLINDER BOLT . . . . . . . . . . . . . . 2 BOLT . . . . . . . . . . . . . . . . . . . . . . . 12 FRICTION WASHER . . . . . . . . . . . . 2 DIFFERENTIAL SIDE GEAR . . . . . 2

Ref. No.

Part No.

11 12 13 14 15 16 17

L500470 L500471 L500472 L500473 L500474 L500771 L98404 L98406 L500476 L500477 L500478 L98396 L98395 L98394 L500479 L500480 L500481

18 19 20 21 22 23 24

69

Description

Qty. Req.

PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 4 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 4 FRICTION WASHER . . . . . . . . . . . . 4 DIFFERENTIAL PINION . . . . . . . . . 4 DIFFERENTIAL CARRIER . . . . . . . 1 TAPER ROLLER BEARING . . . . . . 2 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1 SPACER . . . . . . . . . . . . . . . . . . . . . 1 RING NUT . . . . . . . . . . . . . . . . . . . . 1 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 1 COVERPLATE. . . . . . . . . . . . . . . . . 1 FLANGE . . . . . . . . . . . . . . . . . . . . . 1 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 1 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 4

908484/BP0615

Axles

634 Telehandler Differential Housing Group - Part I S/N 70016 and before

1 2 3

CASE (SEE PART III)

5 6

4

8 5 HOUSING (SEE PART III) 13

7

14 9 10 11 12

908484/BP0615

70

PRINTED IN U.S.A.

634 Telehandler

Axles

Differential Housing Group - Part I S/N 70016 and before Ref. No.

Part No.

Description

Qty. Req.

NOTE: All quantities are per axle.

01 02 03 04 05 06

L98378 L98379 L98380 L98381 L500771 L98404 L98405 L98406 L98407

PRINTED IN U.S.A.

Ref. No.

Part No.

07

L98414 L98415 L98400 L98401 L98396 L98395 L98394 L98393 L98392 L98391

08

SHEET. . . . . . . . . . . . . . . . . . . . . . . 2 RING NUT . . . . . . . . . . . . . . . . . . . . 2 TAPERED ROLLER BRG . . . . . . . . 2 BEVEL GEAR SET . . . . . . . . . . . . . 1 TAPER ROLLER BRG. . . . . . . . . . . 2 SHIM. . . . . . . . . . . . . . . . . . . . . . . AR SHIM. . . . . . . . . . . . . . . . . . . . . . . AR SHIM. . . . . . . . . . . . . . . . . . . . . . . AR SHIM. . . . . . . . . . . . . . . . . . . . . . . AR

09 10 11 12 13 14

71

Description

Qty. Req.

SHIM. . . . . . . . . . . . . . . . . . . . . . . AR SHIM. . . . . . . . . . . . . . . . . . . . . . . AR SPACER . . . . . . . . . . . . . . . . . . . . . 1 SPACER . . . . . . . . . . . . . . . . . . . . . 1 RING NUT . . . . . . . . . . . . . . . . . . . . 1 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 1 COVER PLATE . . . . . . . . . . . . . . . . 1 FLANGE . . . . . . . . . . . . . . . . . . . . . 1 O-RING . . . . . . . . . . . . . . . . . . . . . . 1 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 1

908484/BP0615

Axles

634 Telehandler Differential Housing Group - Part II S/N 70016 and before

16 17

HOUSING (SEE PART III)

15

13

7 8

6 10

9

5 11

14 6

4 3

11

5

9 10 8

2

12

8

908484/BP0615

72

CASE (SEE PART III)

1

PRINTED IN U.S.A.

634 Telehandler

Axles

Differential Housing Group - Part II S/N 70016 and before Ref. No.

Part No.

Description

Qty. Req.

NOTE: All quantities are per axle.

01 02 03 04 05 06 07 08

L98378 L98379 L98380 L98388 L98382 L98383 L98381 L98386

PRINTED IN U.S.A.

SHEET. . . . . . . . . . . . . . . . . . . . . . . 2 RING NUT . . . . . . . . . . . . . . . . . . . . 2 TAPERED ROLLER BRG . . . . . . . . 2 COVER . . . . . . . . . . . . . . . . . . . . . . 1 DISK . . . . . . . . . . . . . . . . . . . . . . . . 2 DIFF. SIDE GEAR . . . . . . . . . . . . . . 2 BEVEL GEAR SET . . . . . . . . . . . . . 1 ROLL PIN . . . . . . . . . . . . . . . . . . . . 3

Ref. No.

Part No.

09 10 11 12 13 14 15

L98385 L98384 L98387 L98389 L98390 L98416 L500317 L500356 L64326 L277013

16 17

73

Description

Qty. Req.

PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 2 DISK . . . . . . . . . . . . . . . . . . . . . . . . 4 DIFF. PINION. . . . . . . . . . . . . . . . . . 4 PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 1 DIFF. CASE . . . . . . . . . . . . . . . . . . . 1 RETAINER. . . . . . . . . . . . . . . . . . . . 1 BOLT . . . . . . . . . . . . . . . . . . . . . . . 16 SPRING WASHER . . . . . . . . . . . . 16 HOSE. . . . . . . . . . . . . . . . . . . . . . . . 2 GREASE ZERK . . . . . . . . . . . . . . . . 2

908484/BP0615

Axles

634 Telehandler Differential Housing Group - Part III S/N 70016 and before

2

3 1 6 4 11

2

10 5

9 12 1

9

2

6 8 5 2 7 9

908484/BP0615

74

PRINTED IN U.S.A.

634 Telehandler

Axles

Differential Housing Group - Part III S/N 70016 and before Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

CASE . . . . . . . . . . . . . . . . . . . . . . . . 2 O-RING . . . . . . . . . . . . . . . . . . . . . . 4 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1 O-RING . . . . . . . . . . . . . . . . . . . . . . 2

06 07 08 09 10 11 12

L98422 L98427 L98428 L98425 L98423 L98424 L98426

NOTE: All quantities are per axle.

01 02 03 04 05

L98418 L98417 L98419 L98420 L98421

PRINTED IN U.S.A.

75

Description

Qty. Req.

THRUST BUSHING. . . . . . . . . . . . . 2 ADAPTER . . . . . . . . . . . . . . . . . . . . 2 HOUSING . . . . . . . . . . . . . . . . . . . . 1 MAGNETIC PLUG. . . . . . . . . . . . . . 3 CIRCLIP. . . . . . . . . . . . . . . . . . . . . . 1 COVER . . . . . . . . . . . . . . . . . . . . . . 1 VENT . . . . . . . . . . . . . . . . . . . . . . . . 1

908484/BP0615

Axles

634 Telehandler Brake Group S/N 70017 - 71101

10

2 3 1

4 5

12 14 11 6 7 9 8 13

908484/BP0615

76

PRINTED IN U.S.A.

634 Telehandler

Axles Brake Group S/N 70017 - 71101

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

BRAKE DISC. . . . . . . . . . . . . . . . . . 6 ADJUSTING BOLT . . . . . . . . . . . . . 6 SPRING . . . . . . . . . . . . . . . . . . . . . . 6 PISTON . . . . . . . . . . . . . . . . . . . . . . 2 SPRING . . . . . . . . . . . . . . . . . . . . . . 6 BACK-UP RING. . . . . . . . . . . . . . . . 2

07 08 09 10 11 12 13 14

L500533 L500534 L500535 L500536 L98430 L500496 L500537 L500538

NOTE: All quantities are per axle.

01 02 03 04 05 06

L500527 L500528 L500529 NSS L500531 L500532

PRINTED IN U.S.A.

77

Description

Qty. Req.

O-RING . . . . . . . . . . . . . . . . . . . . . . 2 BACK-UP RING. . . . . . . . . . . . . . . . 2 O-RING . . . . . . . . . . . . . . . . . . . . . . 2 INTERMEDIATE BRAKE DISC . . . . 8 BLEEDING BOLT . . . . . . . . . . . . . . 2 PLUG . . . . . . . . . . . . . . . . . . . . . . . . 2 DOWEL . . . . . . . . . . . . . . . . . . . . . . 2 PISTON . . . . . . . . . . . . . . . . . . . . . . 2 (includes items 4-9)

908484/BP0615

Axles

634 Telehandler Brake Group S/N 70016 and before

1 2

13 4 4

4

3

5 4

5

4

14

3

14 11

5

10

5

12 6 7 9

8 12

908484/BP0615

78

PRINTED IN U.S.A.

634 Telehandler

Axles Brake Group S/N 70016 and before

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

PLUG . . . . . . . . . . . . . . . . . . . . . . . . 2 VENT BOLT . . . . . . . . . . . . . . . . . . . 2 SPACER . . . . . . . . . . . . . . . . . . . . . 2 BRAKE DISC. . . . . . . . . . . . . . . . . . 8 INTERMEDIATE DISC. . . . . . . . . . . 8 RING . . . . . . . . . . . . . . . . . . . . . . . . 8

07 08 09 10 11 12 13 14

L98435 L98436 L98437 L98438 L98439 L98440 L98441 L98442

NOTE: All quantities are per axle.

01 02 03 04 05 06

L98429 L98430 L98431 L98432 L98433 L98434

PRINTED IN U.S.A.

79

Description

Qty. Req.

RING . . . . . . . . . . . . . . . . . . . . . . . . 8 PISTON . . . . . . . . . . . . . . . . . . . . . . 8 SPACER . . . . . . . . . . . . . . . . . . . . . 8 SPRING . . . . . . . . . . . . . . . . . . . . . . 8 CUP SPRING . . . . . . . . . . . . . . . . 16 CIRCLIP. . . . . . . . . . . . . . . . . . . . . 16 PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 6 SPACER . . . . . . . . . . . . . . . . . . . . . 2

908484/BP0615

Boom

634 Telehandler Outer Boom Section

FRONT

1

32 33

27 30

35

34

10

2

31

3 4

5 6

27 29

7

28

23

8

24

9

27 25

26

22

25

10

12 11

21

13

14

15

15 20 16

908484/BP0615

80

19 18 17

16

REAR

PRINTED IN U.S.A.

634 Telehandler

Boom Outer Boom Section

Ref. No.

Part No.

01 02 03 04 05 06a 07 08 09 10 11 12 13 14 15 16 17 18 19 20 21

L68350 L70242 L65640 L50141 L52028 L65638 L50791 L50380 L50152 L50612 L63169 L63173 L63131 L50226 L68006 L63017 L520004 L50878 L68358 L68348 L63099 L50462 L520019

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

OUTER SECT. WELDMENT . . . . . . 1 5/16”-18 NUTSERT . . . . . . . . . . . . . 2 PLATE, BOOM ANGLE IND. . . . . . . 1 5/16” FLAT WASHER . . . . . . . . . . . 2 5/16”-18X1” BTNHD BOLT . . . . . . . 2 INCLINOMETER-ANGLE IND. . . . . 1 #8X5/8” RND HD MACH.SCREW. . 2 1/2”-20X1-1/4” BOLT . . . . . . . . . . . . 2 1/2” LOCK WASHER . . . . . . . . . . . . 2 PIN, COTTER 1/16”X3/4” . . . . . . . . 6 PIN, OUTER BOOM CLEVIS . . . . . 1 CLEVIS, OUTER BOOM . . . . . . . . . 1 REAR OUTER COVER . . . . . . . . . . 1 5/16”-18X1” SELF TAP SCREW . . . 4 BUSHING 2.5IDX2.75ODX4” . . . . . 2 LIFT CYL. PIVOT BUSHING . . . . . . 2 5/16”-18 NYLON INSERT NUT . . . . 4 5/16”-18X3” STUD. . . . . . . . . . . . . . 4 CUSHION TOP PLATE . . . . . . . . . . 2 .88 HOSE CUSHION SINGLE . . . . 4 PIN, PIVOT PIN. . . . . . . . . . . . . . . . 1 CAPSCREW 1/2-13X5 . . . . . . . . . . 1 NYLON INSERT NUT 1/2-13 . . . . . 1

22

L63694 L50367 L50147 L61708 L62715 L50251 L50367 L50147 L61709 L62733 L50403 L64143 L50261 L63137 L63166 L50086

23 24 25 26 27 28 29 30 31 32 33 34b 35

Description

Qty. Req.

EXT. CYL. BRACKET . . . . . . . . . . . 1 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 2 3/8” LOCK WASHER . . . . . . . . . . . . 2 SLIDE PAD 5/8”X4”X6” . . . . . . . . . . 2 FLAT-BOLT LOCK . . . . . . . . . . . . . . 2 3/8”-16X3/4” BOLT . . . . . . . . . . . . . 6 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 2 3/8” LOCK WASHER . . . . . . . . . . . 12 SLIDE PAD 5/8”X3”X4” . . . . . . . . . . 4 SHIM .06”X3”X4” . . . . . . . . . . . . . . . 2 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 4 SHIM 1/2”X3”X4” . . . . . . . . . . . . . . . 2 3/8”-16X1-1/2” BOLT . . . . . . . . . . . . 4 PIN, CLEVIS ADJUSTMENT. . . . . . 2 CLEVIS, CHAIN ADJUSTMENT . . . 2 3/4”-10 NUT. . . . . . . . . . . . . . . . . . . 4

--- ITEMS NOT SHOWN --L50207 VINYL CLAMP . . . . . . . . . . . . . . . . . 2 L50228 5/16”-18X1/2” BOLT . . . . . . . . . . . . 2 L520004 5/16”-18 NYLON INSERT NUT . . . 2

81

a

Boom angle indicator kit #L97956 includes items 2, 3, 4, 5, 6, and 7.

b

Refer to Inner Boom Section for boom chains.

908484/BP0615

Boom

634 Telehandler Intermediate Boom Section 12 8 13

11

10

14

9

1

8 2 3 7

15

FRONT

4 5

6

16 17 18

19 21

20 17 16 19

12 8

11 10

22

9 8 27

2

13

23

24

25

28

26

29 16

21

19 17 19 17

21

16 19 16 21

REAR

1

908484/BP0615

82

PRINTED IN U.S.A.

634 Telehandler

Boom

Intermediate Boom Section Ref. No.

Part No.

01 02 03 04 05 06 07 08 09 10 11 12 13 14 15

L68744 L63006 L50228 L50207 L520004 L520005 L52026 L68697 L63158 L63157 L63153 L50273 L520005 L68695 L50367

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

INTERMEDIATE SECT WLDMNT. . 1 TRAY, INTERMEDIATE . . . . . . . . . . 1 5/16”-18X1/2” BOLT . . . . . . . . . . . . 1 CLAMP, VINLYL .69 DBL . . . . . . . . 1 5/16”X18 NYLON INSERT NUT . . . 1 3/8”-16 NYLON INSERT NUT . . . . . 2 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 2 WASHER, CHAIN SHEAVE . . . . . . 6 RING, BEARING-INNER . . . . . . . . . 3 BEARING, BOOM SHEAVE . . . . . . 3 SHEAVE, CHAIN . . . . . . . . . . . . . . . 3 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 2 3/8”-16 NYLON INSERT NUT . . . . . 2 PIN, FRONT SHEAVE . . . . . . . . . . . 1 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 4

16 17 18 19 20 21 22 23 24 25 26 27 28 29

L62715 L62734 L62733 L50251 L50147 L61709 L50261 L50147 L68696 L63239 L61699 L61708 L62731 L62732

Description

Qty. Req.

FLAT-BOLT LOCK . . . . . . . . . . . . . 12 SHIM, .105”X3”X4” . . . . . . . . . . . . . 8 SHIM, .06”X3”X4” . . . . . . . . . . . . . . 2 3/8”-16X3/4” BOLT . . . . . . . . . . . . 28 3/8” LOCK WASHER . . . . . . . . . . . . 8 SLIDE PAD, 5/8”X3”X4”. . . . . . . . . 12 3/8”-16X1-1/2” BOLT . . . . . . . . . . . . 1 3/8” LOCK WASHER . . . . . . . . . . . . 1 PIN, REAR SHEAVE . . . . . . . . . . . . 1 SPACER, TRAY BRACKET. . . . . . . 1 SLIDE PAD, 2”X3” . . . . . . . . . . . . . . 1 SLIDE PAD, 5/8”X4”X6”. . . . . . . . . . 2 SHIM, .06”X4”X6” . . . . . . . . . . . . . . 2 SHIM, .105”X4”X6” . . . . . . . . . . . . . 2

Note: Refer to Inner Boom Section for boom chains.

83

908484/BP0615

Boom

634 Telehandler Inner Boom Section

REAR 14

16

13 6

7 8

5 1

17

15

12 9 10 11

2

18 19

7 4 3

27

21

26

20

10

3

7

9

11 25

9

24 23

22

22

FRONT

908484/BP0615

84

PRINTED IN U.S.A.

634 Telehandler

Boom Inner Boom Section

Ref. No.

Part No.

01 02 03 04 05 06 07 08 09 10 11 12 13 14 15a 16 17 18b 19

L68762 L63005 L520004 L61699 L50207 L50228 L50251 L50147 L61709 L62734 L62715 L66783 L66782 L66780 L63156 L50612 L63168 L63156 L63166

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

INNER BOOM WELDMENT . . . . . . 1 HOSE TRAY, INNER BOOM . . . . . . 1 5/16”-18 NYLON INSERT NUT . . . . 3 SLIDE PAD 2”X3” . . . . . . . . . . . . . . 1 CLAMP, VINYL .69 DBL . . . . . . . . . 1 5/16”-18X1/2” BOLT . . . . . . . . . . . . 1 3/8”-16X3/4” BOLT . . . . . . . . . . . . 17 3/8” LOCK WASHER . . . . . . . . . . . . 1 SLIDE PAD 5/8”X3”X4” . . . . . . . . . . 4 SHIM .105”X3”X4” . . . . . . . . . . . . . . 2 FLAT-BOLT LOCK . . . . . . . . . . . . . . 8 SHIM .105”X3”X8” . . . . . . . . . . . . . . 2 SHIM .06”X3”X8” . . . . . . . . . . . . . . . 2 SLIDE PAD 3”x8”. . . . . . . . . . . . . . . 2 CHAIN, BOOM LEAF . . . . . . . . . . . 2 PIN, COTTER 1/16”X3/4” . . . . . . . . 4 PIN, INNER BOOM CLEVIS . . . . . . 1 CHAIN, BOOM LEAF . . . . . . . . . . . 1 CLEVIS, CHAIN ADJUSTMENT . . . 1

20 21 22 23 24 25 26 27

L63167 L50086 L63017 L50877 L63716 L63715 L520005 L52026

a

Attaches from the rear of the inner boom to the chain adjustment clevis’ located on the front of the outer boom section. (Refer to Outer Boom Section, item #34, chain adjustment clevis.)

b

Attaches from item #19 (chain adjustment clevis) to outer boom clevis. (Refer to Outer Boom Section, item #12, outer boom clevis.)

85

Description

Qty. Req.

PIN, CLEVIS ADJUSTMENT. . . . . . 1 3/4”-10 NUT. . . . . . . . . . . . . . . . . . . 2 BUSHING . . . . . . . . . . . . . . . . . . . . 2 5/16”-18X2-1/4” STUD. . . . . . . . . . . 2 CUSHION, HOSE-TWIN .68 . . . . . . 2 PLATE, TWIN CUSHION TOP . . . . 1 3/8”-16 NYLON INSERT NUT . . . . . 2 3/8”-1-1/4” BOLT . . . . . . . . . . . . . . . 2

908484/BP0615

Boom

634 Telehandler Quickattach

FRONT

3

1

4

2

5

14 13

Tilt Cylinder

3 6 7

8 9 12 2

11 10 9

908484/BP0615

86

PRINTED IN U.S.A.

634 Telehandler

Boom Quickattach

Ref. No.

Part No.

01

L98700

02 03 04 05 06 07

L520005 L50273 L63274 L63017 L63272 L63018

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

QUICKATTACH ASSY . . . . . . . . . . . 1 (Includes items 9-14) 3/8”-16 NYLON INSERT NUT . . . . . 3 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 3 PIN, TAPPED 1-1/2” DIA . . . . . . . . . 2 BUSHING . . . . . . . . . . . . . . . . . . . . 2 PIN, TILT CYL.(ROD END) . . . . . . . 1 BUSHING, TILT CYL (ROD END) . . 1

08 09 10 11 12 13 14

L63013 L66456 L63326 L63312 L50646 L65097 L65098

87

Description

Qty. Req.

TILT CYLINDER . . . . . . . . . . . . . . . 1 BUSHING, LOCK PIN . . . . . . . . . . . 2 PIN, QUICKATTACH LOCK . . . . . . 1 QUICKATTACH LOCK WLDMNT . . 1 3/16”X1-3/4” ROLL PIN . . . . . . . . . . 1 LOCK SPRING . . . . . . . . . . . . . . . . 1 SPRING MOUNT. . . . . . . . . . . . . . . 1

908484/BP0615

Hydraulics

634 Telehandler

Hydraulic Pump, Tank and Flow Divider 1

2 5

3

FRONT

6

7

4

8

9

Hydraulic Pump

10

11 12

Transmission

9

19

18

17

13

16

14

Hydraulic Tank 24 23

10 21 19

20

10

Flow Divider

15

FRONT

23

24 22

FRONT

908484/BP0615

02

88

PRINTED IN U.S.A.

634 Telehandler

Hydraulics

Hydraulic Pump, Tank and Flow Divider Ref. No.

Part No.

01 02 03 04a 05 06 07 08 09 10 11 12 13 14 15

L445014 L63309 L46865 L68714 L50184 L50283 L62842 L69920 L68802 L445012 L63384 L68804 L445003 L63406 L50741

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

ADAP, -20ORM -24JICM 90DEG . . 1 HOSE, -24 A24/A24 35” . . . . . . . . . 1 GASKET, HYD PUMP . . . . . . . . . . . 1 HYDRAULIC PUMP . . . . . . . . . . . . 1 1/2” FLAT WASHER . . . . . . . . . . . . 2 1/2”-13X1-1/4” BOLT . . . . . . . . . . . . 2 ADAP, -4ORM -6JICM 90 DEG . . . . 1 HOSE, -4 A6/A6 40” . . . . . . . . . . . . 1 HOSE, -12 A12/A12 17” . . . . . . . . . 1 ADAP, -12ORM -12JICM 45 DEG . . 3 HOSE, -6 A8/DS8 40” . . . . . . . . . . . 1 HOSE, -4 A6/DS6 26” . . . . . . . . . . . 1 ADAP, -6ORM -6JICM 90 DEG . . . . 1 HOSE, -12 A12/DS12 114” . . . . . . . 1 STUD . . . . . . . . . . . . . . . . . . . . . . . . 2

16a 17 18 19 20 21 22 23 24b

L68783 L444012 L445002 L68803 L68805 L68813 L441010 L444002 L68763

a

Refer to hydraulic breakdown section for a break down of this component.

b

Refer to Hydraulic and Fuel Tanks located in Chasis Section for complete list of parts.

FLOW DIVIDER. . . . . . . . . . . . . . . . 1 ADAP, -4ORM -6JICM STR. . . . . . . 1 ADAP, -8ORM -8JICM 90 DEG . . . . 1 HOSE, -4 A6/A6 40” . . . . . . . . . . . . 1 HOSE, -6 A6/DS6 70” . . . . . . . . . . . 1 HOSE, -4 A6/AS6 44” . . . . . . . . . . . 1 ADAP, -24NPTM -24JICM STR . . . . 1 ADAP, -6ORM -6JICM STR. . . . . . . 3 HYDRAULIC TANK WELDMENT . . 1

HOSE LOCATOR 02 08 09 11 12 14 19 20 21

HYDRAULIC PUMP HYDRAULIC PUMP HYDRAULIC PUMP HYDRAULIC PUMP FLOW DIVIDER PORT “PF” FLOW DIVIDER PORT “EF” FLOW DIVIDER PORT “T” HYDRAULIC TANK RETURN MANIFOLD HYDRAULIC TANK RETURN MANIFOLD

PRINTED IN U.S.A.

HYDRAULIC TANK STEER MOTOR PORT “LS” (refer to next page) FLOW DIVIDER PORT “IN” STEER MOTOR PORT “P” FRONT JOYSTICK- SIDE - (LOWER PORT) V20 MAIN VALVE PORT (FRONT LEFT) HYDRAULIC TANK RETURN MANIFOLD STEER MOTOR PORT “T” (UPPER LEFT) FRONT JOYSTICK - SIDE - (UPPER PORT)

89

908484/BP0615

Hydraulics

634 Telehandler Steer Motor and Steer Select Valve

LEFT

1 T

LS

FRONT

17 2

L

R

3 P

16

Steer Motor

15

12

13

14

Steer Select Valve

4

6

5

12

P A

11

T

6 B

10

8

9 7

908484/BP0615

90

RIGHT

PRINTED IN U.S.A.

634 Telehandler

Hydraulics

Steer Motor and Steer Select Valve Ref. No.

Part No.

01 02 03 04 05 06 07 08 09

L68713 L62482 L69920 L50535 L69747 L445003 L63386 L520003 L444002

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

STEERING CONTROL UNIT . . . . . 1 ADAP, -4ORM -6JICM 90 DEG . . . . 1 HOSE, -4 A6/A6 40” . . . . . . . . . . . . 1 1/4”-20X3” BOLT . . . . . . . . . . . . . . . 2 VALVE, STEER SELECT . . . . . . . . 1 ADAP, -6ORM -6JICM 90 DEG . . . . 2 HOSE, -6 A8/A6 36” . . . . . . . . . . . . 1 1/4”-20 NYLON INSERT NUT . . . . . 2 ADAP, -6ORM -6JICM STR. . . . . . . 2

10 11 12 13 14 15 16a 17

L63403 L63388 L63383 L63387 L63384 L68805 L64524 L444004

a

Refer to hydraulic breakdown section for a break down of this component.

HOSE, -6 A8/DS6 110” . . . . . . . . . . 1 HOSE, -6 A8/DS6 100” . . . . . . . . . . 1 HOSE, -6 A6/DS8 52” . . . . . . . . . . . 1 HOSE, -6 A8/DS8 67” . . . . . . . . . . . 1 HOSE, -6 A8/DS8 40” . . . . . . . . . . . 1 HOSE, -6 A6/DS6 70” . . . . . . . . . . . 1 VALVE, CHECK . . . . . . . . . . . . . . . . 1 ADAP, -8ORM -8JICM STR. . . . . . . 3

HOSE LOCATOR 03 07 10 11 12 13 14 15

STEER MOTOR PORT “LS” STEER SELECT VALVE PORT “T” STEER SELECT VALVE PORT “B” STEER SELECT VALVE PORT “A” STEER MOTOR PORT “R” STEER MOTOR PORT “L” STEER MOTOR PORT “P” STEER MOTOR PORT “T”

PRINTED IN U.S.A.

HYDRAULIC PUMP (item #8 on previous page) STEER CYLINDER, FRONT AXLE RIGHT SIDE STEER CYLINDER, REAR AXLE RIGHT SIDE STEER CYLINDER, REAR AXLE LEFT SIDE STEER SELECT VALVE PORT “P” STEER CYLINDER, FRONT AXLE RIGHT SIDE HYDRAULIC PUMP (item #11 on previous page) HYDRAULIC TANK RETURN MANIFOLD

91

908484/BP0615

Hydraulics

634 Telehandler Main Valve Group 1

2

1 Left Side Bulkhead

Right Side Bulkhead

3

17 18 21

22

15

16 4

20 19 5

6

28

14 7

6 13 9

7

8

12 EL LIFT M BOO T TIL

10

LEV

B

11

A 23

7

FRONT

1

Optional Hydraulics

24 25 26

27

908484/BP0615

92

PRINTED IN U.S.A.

634 Telehandler

Hydraulics Main Valve Group

Ref. No.

Part No.

01a 02 03 04 05 06 07a 08 09 10 11 12 13 14

L443011 L68814 L68814 L68816 L68815 L446026 L444008 L68817 L63407 L50895 L520004 L68694 L444001 L60253

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

ADAP, BLKHEAD 90 -10JICM. . . . . 4 HOSE, -8 A10/DS10 15” . . . . . . . . . 1 HOSE, -8 A10/DS10 15” . . . . . . . . . 1 HOSE, -8 A10/DS8 14” . . . . . . . . . . 1 HOSE, -8 A10/DS8 17” . . . . . . . . . . 1 ADAP, -8JICFS -8JICM RUN T . . . . 4 ADAP, -10ORM -8JICM . . . . . . . . . . 4 HOSE, -6 A8/A8 26” . . . . . . . . . . . . 1 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1 5/16”-18X3” BOLT . . . . . . . . . . . . . . 3 5/16”-18 NYLON INSERT NUT . . . . 3 VALVE, MAIN CONTROL (V20) . . . 1 ADAP, -12ORM -12JICM STR. . . . . 2 ADAP, -10ORM -JICM STR. . . . . . . 2

15 16 17 18 19 20 21 22 23 24 25

L63407 L63407 L68807 L68808 L68809 L68809 L63406 L68806 L68815 L68816 L68778

26 27 28

L445003 NSS L444010

a

Add (2) to quanitity when unit is equipped with optional hydraulics

HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1 HOSE, -6 A8/DS8 54” . . . . . . . . . . . 1 HOSE, -6 A8/DS8 48” . . . . . . . . . . . 1 HOSE, -4 A6/DS6 136” . . . . . . . . . . 1 HOSE, -4 A6/DS6 136” . . . . . . . . . . 1 HOSE, -12 A12/DS12 114” . . . . . . . 1 HOSE, -12 A12/DS12 120” . . . . . . . 1 HOSE, -8 A10/DS8 17” . . . . . . . . . . 1 HOSE, -8 A10/DS8 14” . . . . . . . . . . 1 KIT, VALVE SECTION . . . . . . . . . . . 1 (includes item #27) ADAP, -6ORM -6JICM 90 DEG . . . 10 BOLT KIT (included with item #25) . 1 ADAP, -10ORM -10JICM . . . . . . . . . 2

HOSE LOCATOR 02 03 04 05 08 09 15 16 17 18 19 20 21 22 23 24

MAIN VALVE SECTION 3 PORT “A” MAIN VALVE SECTION 3 PORT “B” MAIN VALVE SECTION 4 PORT “B” MAIN VALVE SECTION 4 PORT “A” MAIN VALVE SECTION 4 PORT “B” MAIN VALVE SECTION 4 PORT “A” MAIN VALVE SECTION 2 PORT “A” MAIN VALVE SECTION 2 PORT “B” MAIN VALVE SECTION 2 PORT “B” MAIN VALVE SECTION 2 PORT “A” MAIN VALVE SECTION 1 PORT “B” MAIN VALVE SECTION 1 PORT “A” MAIN VALVE “IN” MAIN VALVE “OUT” OPTIONAL HYD. SECTION PORT “B” OPTIONAL HYD. SECTION PORT “A”

PRINTED IN U.S.A.

BULKHEAD FITTING TO (BOOM EXTEND) BULKHEAD FITTING TO (BOOM RETRACT) BULKHEAD FITTING TO (TILT CYL. RETRACT) BULKHEAD FITTING TO (TILT CYL. EXTEND) SLAVE CYLINDER (BOTTOM-RETRACT) SLAVE CYLINDER (TOP-EXTEND) LIFT CYLINDER (RIGHT) (OUTSIDE-EXTEND) LIFT CYLINDER (RIGHT) (INSIDE-RETRACT) LIFT CYLINDER (LEFT) (OUTSIDE-RETRACT) LIFT CYLINDER (LEFT) (INSIDE-EXTEND) LEVEL CYLINDER (OUTSIDE-RETRACT) LEVEL CYLINDER (INSIDE-EXTEND) FLOW DIVIDER PORT “EF” HYDRAULIC TANK (FILTER COVER FITTING) BULKHEAD FITTING TO (OPTION - RETRACT) BULKHEAD FITTING TO (OPTION - EXTEND)

93

908484/BP0615

Hydraulics

634 Telehandler Joystick Group 1

FRONT

3

Level

Tilt

4 2

Level

Optional Hydraulics

Tilt Lift

Boom

5 Boom

Lift

13

6 12 3

5

7

3

3 9 8

8 9

4

3

Optional Hydraulics 8 9 Level Lift Boom

5

Tilt

Retract

5 5

10

Extend

11

Optional Hydraulics

REAR

908484/BP0615

94

PRINTED IN U.S.A.

634 Telehandler

Hydraulics Joystick Group

Ref. No.

Part No.

01

L68775 L50211 L50051 L62553 L50211 L50051 L444002 L68824 L445003 L60302 L50211 L50051 L68812 L68811 L68810

02a

03b 04c 05b 06c 07 08b 09b

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

JOYSTICK, W/GATE . . . . . . . . . . . . 1 1/4”-20X3/4” BOLT . . . . . . . . . . . . . 4 1/4”-20 FLANGE NUT . . . . . . . . . . 4 JOYSTICK . . . . . . . . . . . . . . . . . . . . 1 1/4”-20X3/4” BOLT . . . . . . . . . . . . . 4 1/4”-20 FLANGE NUT . . . . . . . . . . 4 ADAP, -6ORM -6JICM . . . . . . . . . . 12 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 2 ADAP, -6ORM -6JICM 90 DEG . . . . 8 JOYSTICK, 2 WAY . . . . . . . . . . . . . 1 1/4”-20X3/4” BOLT . . . . . . . . . . . . . 4 1/4”-20 FLANGE NUT . . . . . . . . . . 4 HOSE, -4 A6/B6 18” . . . . . . . . . . . . 2 HOSE, -4 A6/A6 108” (retract). . . . . 4 HOSE, -4 A6/A6 96” (extend) . . . . . 4

10c 11 12 13

L68778 L68694 L68804 L68805

a

Use (2) L446048 -6ORM Plugs when not equipped with optional hydraulics.

b

Hydraulic option requires (4) additional L444002 fittings and (4) additional L445003 fittings and (1) additional L68810 hose and (1) additional L68811 hose.

c

Used only on units equipped with hydraulic option.

KIT, VALVE SECTION . . . . . . . . . . . 1 VALVE, MAIN CONTROL . . . . . . . . 1 HOSE, -4 A6/DS6 26” . . . . . . . . . . . 1 HOSE, -4 A6/DS6 70” . . . . . . . . . . . 1

HOSE LOCATOR 12 13

FRONT JOYSTICK - SIDE - (LOWER PORT) FRONT JOYSTICK - SIDE - (UPPER PORT)

FLOW DIVIDER PORT “PF” HYDRAULIC TANK RETURN MANIFOLD

Other hoses are located as shown in illustration.

PRINTED IN U.S.A.

95

908484/BP0615

Hydraulics

634 Telehandler Frame Level Group 3 2

1

4 5 6

FRONT

7 7

9 16

8

10 11

15

12

14

FR

ON

TA

Main Control Valve (V20)

XL

E

13 17

FRONT

908484/BP0615

96

PRINTED IN U.S.A.

634 Telehandler

Hydraulics Frame Level Group

Ref. No.

Part No.

01 02 03 04 05 06 07 08 09 10 11

L63015 L64367 L50277 L63276 L520005 L68794 L68809 L50403 L68881 L68882 L63016

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

LEVEL CYLINDER . . . . . . . . . . . . . 1 BRONZE BEARING . . . . . . . . . . . . 1 3/8”-16X3-1/2” BOLT . . . . . . . . . . . . 1 PIN, CYLINDER (BASE END). . . . . 1 3/8”-16 NYLON INSERT NUT . . . . . 1 ADAP, W/ORIFICE -8ORM -6JICM . 2 HOSE, -4 A6/DS6 136” . . . . . . . . . . 1 3/8”-16X1-1/4’ BOLT . . . . . . . . . . . . 1 LOCK, PIVOT PIN . . . . . . . . . . . . . . 1 PIVOT PIN (ROD END). . . . . . . . . . 1 BRONZE BEARING . . . . . . . . . . . . 1

12

Part No. L68878 L63009

13 14 15 16 17

97

L68876 L63115 L50712 L50157 L50084 L60253

Description

Qty. Req.

FRAME LEVEL MOUNT . . . . . . . . . 1 S/N 70017 - 71101 S/N 70016 and before PLATE, FRAME LEVEL. . . . . . . . . . 1 S/N 70017 - 71101 S/N 70016 and before 3/4”-10X9” GR8 BOLT . . . . . . . . . . . 4 3/4” FLAT WASHER . . . . . . . . . . . . 4 3/4”-10 STOVER NUT . . . . . . . . . . . 4 ADAP, -10ORM -6JICM . . . . . . . . . . 2

908484/BP0615

Hydraulics

634 Telehandler Lift Cylinder Group

2

1 3 4

RIGHT

5

LEFT

6

11 7

12 Main Valve

9

EXTEND

10 RETRACT

FRAME

EXTEND

8 RETRACT

LIFT 4

5

FRONT FRAME

908484/BP0615

3

2

98

PRINTED IN U.S.A.

634 Telehandler

Hydraulics Lift Cylinder Group

Ref. No.

Part No.

01 02 03 04 05 06

L63199 L63017 L63274 L50273 L520005 L446026

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

LIFT CYLINDER . . . . . . . . . . . . . . . 2 BRONZE BUSHING . . . . . . . . . . . . 4 PIN, LIFT CYLINDER . . . . . . . . . . . 4 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 4 3/8”-16 NYLON INSERT NUT . . . . . 4 ADAP -8JICFS -8JICM RUN TEE . . 2

07 08 09 10 11 12

L444008 L68807 L68808 L63407 L63407 L445002

99

Description

Qty. Req.

ADAP -10ORM -8JICM STR . . . . . . 2 HOSE, -6 A8/DS8 54” . . . . . . . . . . . 1 HOSE, -6 A8/DS8 48” . . . . . . . . . . . 1 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1 ADAP -8ORM -8JICM 90 DEG . . . . 4

908484/BP0615

Hydraulics

634 Telehandler Tilt / Slave Cylinder Group

2 1 3

Extend

25 24

Retract

13

23

12 18

5

14

22

17

4

Right Bulkhead

15

6 Slave Cylinder

12 16

11

21

7

11 10

Retract

8

Extend

20

13

Extend Tilt Cylinder

13

19

Main Valve TILT

12 18 17 12

9

14

Retract

15

13

FRONT

908484/BP0615

100

PRINTED IN U.S.A.

634 Telehandler

Hydraulics Tilt / Slave Cylinder Group

Ref. No.

Part No.

01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18

L68351 L68239 L68239 L443011 L68815 L68816 L446026 L444008 L68817 L63407 L445002 L520005 L50273 L63272 L63018 L63014 L63017 L63273

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

TUBE, TILT/AUX . . . . . . . . . . . . . . . 2 HOSE, -8 H10/DS10 54” . . . . . . . . . 1 HOSE, -8 H10/DS10 54” . . . . . . . . . 1 ADAP, -10JICM BLKHEAD 90DEG . 2 HOSE, -8 A10/DS8 17” . . . . . . . . . . 1 HOSE, -8 A10/DS8 14” . . . . . . . . . . 1 ADAP, -8JICFS -8JICM RUN TEE . 2 ADAP, -10ORM -8JICM . . . . . . . . . . 2 HOSE, -6 A8/A8 26” . . . . . . . . . . . . 1 HOSE -6 A8/A8 48” . . . . . . . . . . . . . 1 ADAP, -8ORM -8JICM 90 DEG . . . . 3 3/8”-16 NYLON INSERT NUT . . . . . 4 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 4 PIN, CYLINDER (ROD END) . . . . . 2 BUSHING (ROD END) . . . . . . . . . . 2 CYLINDER, SLAVE . . . . . . . . . . . . . 1 BUSHING (BASE END). . . . . . . . . . 2 PIN, CYLINDER (BUTT END) . . . . . 2

19 20a 21a 22 23 24 25

L63013 L68374 L68374 L52004 L50877 L63715 L68039

Description

Qty. Req.

CYLINDER, TILT . . . . . . . . . . . . . . . 1 HOSE, -6 A8/H10 322” . . . . . . . . . . 1 HOSE, -6 A8/H10 322” . . . . . . . . . . 1 5/16”-18 NYLON INSERT NUT . . . . 8 5/16”-18X2-1/4” STUD. . . . . . . . . . . 8 PLATE, TWIN CUSHION. . . . . . . . . 8 5/8” DOUBLE TUBE CUSHION . . 16

--- ITEMS NOT SHOWN --L50207 VINYL CLAMP . . . . . . . . . . . . . . . . . 2 L50228 5/16”-18X1/2” BOLT . . . . . . . . . . . . 2 L520004 5/16”-18 NYLON INSERT NUT . . . 2 a

101

Used with protective fabric sleeve part number L500784.

908484/BP0615

Hydraulics

634 Telehandler Boom Extend Cylinder Group

4

3

5 6

7

2 8 5

1

3

9

12

10

2 11

19 12

18

11

13

17 16

14 15 Retract

FRONT

Extend

Main Valve Boom Extend

908484/BP0615

102

PRINTED IN U.S.A.

634 Telehandler

Hydraulics

Boom Extend Cylinder Group Ref. No.

Part No.

01 02 03 04 05 06 07 08 09 10 11

L63012 L443022 L520005 L63273 L50273 L63017 L68346 L68356 L50878 L520004 L68352

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

CYLINDER, EXTEND . . . . . . . . . . . 1 ADAP, -8ORM -8JICM 90 LONG. . . 2 3/8”-16 NYLON INSERT NUT . . . . . 2 PIN, CYLINDER (BUTT END) . . . . . 1 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 2 BUSHING (BUTT END). . . . . . . . . . 1 7/8” HOSE CUSHION, SINGLE . . . 4 CUSHION TOP PLATE . . . . . . . . . . 2 5/-16”-18X3” STUD . . . . . . . . . . . . . 4 5/16”-18 NYLON INSERT NUT . . . . 4 HOSE, -8 A8/DS10 73” . . . . . . . . . . 1

12 13 14 15 16 17

L68352 L68814 L68814 L444010 L443011 L63694 L50367 L50147 L63018 L63272

18 19

103

Description

Qty. Req.

HOSE, -8 A8/DS10 73” . . . . . . . . . . 1 HOSE, -8 A10/DS10 15” . . . . . . . . . 1 HOSE, -8 A10/DS10 15” . . . . . . . . . 1 ADAP, -10ORM -10JICM . . . . . . . . . 2 ADAP, -10JICM 90 BLKHEAD. . . . . 2 EXTEND CYL. BRACKET . . . . . . . . 1 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 2 3/8” LOCK WASHER . . . . . . . . . . . . 2 BUSHING (ROD END) . . . . . . . . . . 1 PIN, CYLINDER (ROD END) . . . . . 1

908484/BP0615

Hydraulics

634 Telehandler Auxilary Hydraulics Group

1

2 3

12 11 14

10

13

9 8

15

7

16 6

9

17 11

Auxilary Hydraulics Valve Section

13 18

5 Left Bulkhead

14

4 21

19 20

FRONT

908484/BP0615

104

PRINTED IN U.S.A.

634 Telehandler

Hydraulics Auxilary Hydraulics Group

Ref. No.

Part No.

01 02 03 04 05a 06 07 08 09 10 11 12 13b 14b

L68351 L68239 L68239 L443011 L68778 L444008 L68815 L68816 L52004 L50877 L63715 L68039 L68376 L68376-

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

TUBE, TILT/AUX . . . . . . . . . . . . . . . 2 HOSE, -8 H10/DS10 54” . . . . . . . . . 1 HOSE, -8 H10/DS10 54” . . . . . . . . . 1 ADAP, -10JICM BLKHEAD 90DEG . 2 KIT, VALVE SECTION . . . . . . . . . . . 1 ADAP, -10ORM -8JICM . . . . . . . . . . 2 HOSE, -8 A10/DS8 17” . . . . . . . . . . 1 HOSE, -8 A10/DS8 14” . . . . . . . . . . 1 5/16”-18 NYLON INSERT NUT . . . 10 5/16”-18X2-1/4” STUD. . . . . . . . . . . 8 PLATE, TWIN CUSHION. . . . . . . . . 8 5/8” DOUBLE TUBE CUSHION . . 16 HOSE, -6 A8/H10 352” . . . . . . . . . . 1 HOSE, -6 A8/H10 352” . . . . . . . . . . 1

15 16 17

L50228 L50207 L50545 L50143 L63716 L444004 L65274 L65275

18 19 20 21

Description

Qty. Req.

3/8”-16X1/2” BOLT . . . . . . . . . . . . . 2 VINYL CLAMP . . . . . . . . . . . . . . . . . 2 5/16”-18X2-3/4” BOLT . . . . . . . . . . . 2 5/16” LOCK WASHER . . . . . . . . . . 2 11/16” DOUBLE TUBE CUSHI0N . . 4 ADAP, -8ORM -8JICM STR. . . . . . . 2 COUPLER, MALE . . . . . . . . . . . . . . 1 COUPLER, FEMALE. . . . . . . . . . . . 1

a

Kit includes a single V20 valve section and tie bolt kit for five section valve.

b

Used with protective fabric sleeve part number L500784.

105

908484/BP0615

Hydraulics

634 Telehandler Hydraulic Pump Breakdown

1

2

3

Ref. No.

Part No.

01 02

L68714 L46865

908484/BP0615

Description

Qty. Req.

Ref. No.

Part No.

HYDRAULIC PUMP . . . . . . . . . . . . 1 GASKET . . . . . . . . . . . . . . . . . . . . . 1

03

L500368

106

Description

Qty. Req.

SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown)

PRINTED IN U.S.A.

634 Telehandler

Hydraulics Flow Divider Breakdown

3

2

1

4

Ref. No.

Part No.

01

L68783

02

L99928 L99929

PRINTED IN U.S.A.

Description

5

Qty. Req.

Ref. No.

Part No.

FLOW DIVIDER. . . . . . . . . . . . . . . . 1 (Includes all items shown) PRESSURE REGULATOR . . . . . . . 1 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1

03

L99927 L99925 P471997 L62840

04 05

107

Description

Qty. Req.

RELIEF VALVE (350 PSI) . . . . . . . . 1 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1 TEST PORT. . . . . . . . . . . . . . . . . . . 2 CAP, DUST COVER . . . . . . . . . . . . 2

908484/BP0615

Hydraulics

634 Telehandler Main Valve Breakdown

1

FRONT

3

3 6

4

10

9

8 13

7

3

9

5

6

4 3

TILT

14

4

‘B’ PORT 2

12

11

IN

BOOM

4

OUT

1

LIFT

14 17

12

16

15

LEVEL

14

14

‘A’ PORT 3

4

19

4 18 Auxilary Hydraulics Work Section 14 SEAL KITS

20

908484/BP0615

108

PRINTED IN U.S.A.

634 Telehandler

Hydraulics Main Valve Breakdown

Ref. No.

Part No.

01 02 03 04 05

L68694 L98891 L500954 L500134 L500132 L500130 L98895

06 07

L500952 L500953

08

L500956

09 10

L98896 L98897 L98898 L98899

11

L500955

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

MAIN VALVE [V20] (Complete) . . . . 1 STUD KIT (tie bolts and nuts) . . . . . 1 INLET COVER. . . . . . . . . . . . . . . . . 1 HRO ACUATOR “B” END . . . . . . . . 4 NO RELIEF-NO ANTI-CAV.PLUG . . 4 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1 WORK SECTION 1 (Level) . . . . . . . 1 (includes items 3, 4, 14 & 15) NO RELIEF - ANTI-CAV PLUG. . . . 1 WORK SECTION 2 (Lift) . . . . . . . . . 1 (includes items 3, 4, 6, 14 & 15) WORK SECTION 3 (Boom Ext.) . . . 1 (includes items 3, 4, 6, 14 & 15) RELIEF CARTRIDGE . . . . . . . . . . . 2 SERVICE KIT (less seals) . . . . . . . 2 SEAL KIT . . . . . . . . . . . . . . . . . . . . 2 WORK SECTION 4 (Tilt) . . . . . . . . . 1 (includes items 3, 9, 14 & 15) OUTLET COVER. . . . . . . . . . . . . . . 1

12 13 14 15

L500957 L500959 L500135 L500961 654022 L500129 L96580 L500958

16 17 18

L500127 L98887 19 20

109

L98895 L500960

Description

Qty. Req.

PLUG SAE-12 PLUG SAE 12 (SOCKET HEAD) . . 1 HRO ACUATOR “A” END . . . . . . . . 4 SCREW . . . . . . . . . . . . . . . . . . . . 32 LOCK WASHER . . . . . . . . . . . . . . 32 RELIEF CARTRIDGE (RP51-A) . . . 1 RELIEF SEAL KIT . . . . . . . . . . . . . 1 PLUG WITH TEST PLUG . . . . . . . . 1 SEAL KITS FOR WORK SECTIONS SECTION SEAL KIT . . . . . . . . . . 1ea (used with items 5-7 & 10) SPOOL SEAL KIT . . . . . . . . . . . . 1ea (used with items 3 & 14) WORK SECTION (Aux. Hyd.) . . . . . 1 STUD ASSEMBLY KIT (Aux. Hyd.) . 1 (used with item 20)

908484/BP0615

Hydraulics

634 Telehandler Steer Cylinders Breakdown

For units S/N 70017 - 71101

For units S/N 70016 and before

1

1

2 2

Ref. No.

Part No.

01

L500540 L500539

02 L500943

Description

Qty. Req.

Ref. No.

Part No.

STEER CYLINDER . . . . . . . . . . . . . 1 STEER CYLINDER BOLT . . . . . . . 4 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown)

01

L98444 L98445 L98565

02

Qty. Req.

STEER CYLINDER ASSEMBLY . . . 1 CYLINDER BOLT . . . . . . . . . . . . . . 5 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown)

NOTE: Quantities are per axle

NOTE: Quantities are per axle

908484/BP0615

Description

110

PRINTED IN U.S.A.

634 Telehandler

Hydraulics Steer Valve Breakdown

1 2 3

4

Ref. No.

Part No.

01

L69747

02 03

L500770 NSS

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

STEER SELECT VALVE . . . . . . . . . 1 (Includes all items shown) COIL 12VDC W/CONNECTOR . . . . 2 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 2 (Included with item 1)

04

L99907

L68711

111

Description

Qty. Req.

SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown) -- ITEMS NOT SHOWN -HARNESS, WIRE ADAPTER . . . . . 1

908484/BP0615

Hydraulics

634 Telehandler Steer Motor Breakdown

1

LS L T

R P

2

Ref. No.

Part No.

01

L68713

Description

Qty. Req.

Ref. No.

Part No.

STEERING CONTROL UNIT . . . . . 1

02

L500962

Description

Qty. Req.

SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown)

NOTE: Field service is limited to seals replacement.

908484/BP0615

112

PRINTED IN U.S.A.

634 Telehandler

Hydraulics Brake Valve Breakdown

1

2

REPAIR KIT

3

7

4 5

6

Ref. No.

Part No.

00

L63363

01 02

L98532 L98533 L98534 NSS L98543 L98536

03 04 05

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

BRAKE VALVE ASY. (Complete). . . .

(Unit requires two brake valves) BAIL WIRE. . . . . . . . . . . . . . . . . . . . 1 COVER . . . . . . . . . . . . . . . . . . . . . . 1 DIAPHRAM GASKET . . . . . . . . . . . 1 BODY TUBE SEAT (not shown) . . . . . . . . . 1 RUBBER BOOT . . . . . . . . . . . . . . . 1

06 07a

L98535 L98537

a

Repair kit includes seals, cups, return spring, second arm piston, and snap ring. Piston is not included or sold seperately.

113

Description

Qty. Req.

PUSH ROD . . . . . . . . . . . . . . . . . . . 1 REPAIR KIT . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown)

908484/BP0615

Hydraulics

634 Telehandler Joystick Breakdown

USED WITH JOYSTICK #L68775

USED WITH JOYSTICK #L62553

1

29 28 27 30

26

28 2

25 3

24

32

23 13

4

17 22

5

21

33

6 20 7

19 14

8

18 17

9 10

31 16 15

11 12

908484/BP0615

114

PRINTED IN U.S.A.

634 Telehandler

Hydraulics Joystick Breakdown

Ref. No.

Part No.

00a 00b

L68775 L62553

01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18 19

Note: Quantities shown are for one joystick.

L46572 KNOB. . . . . . . . . . . . . . . . . . . . . . . . 1 L96852 BOOT. . . . . . . . . . . . . . . . . . . . . . . . 1 L96853 RETAINER. . . . . . . . . . . . . . . . . . . . 1 L98044 HANDLE, ROD . . . . . . . . . . . . . . . . 1 L50151 1/2” FLAT WASHER . . . . . . . . . . . . 1 L96851 RETAINER RING. . . . . . . . . . . . . . . 1 L50082 5/8”-11 JAM NUT. . . . . . . . . . . . . . . 1 L98042 HANDLE ADAPTER . . . . . . . . . . . . 1 L96993 CAM PLATE. . . . . . . . . . . . . . . . . . . 1 L500949 PIVOT RACE . . . . . . . . . . . . . . . . . . 1 L500950 PIVOT PIN . . . . . . . . . . . . . . . . . . . . 1 L500951 PIVOT BALL . . . . . . . . . . . . . . . . . . 1 L96994 MOUNTING PLATE . . . . . . . . . . . . . 1 L96995 MOUNTING PLATE . . . . . . . . . . . . . 1 NSS BODY. . . . . . . . . . . . . . . . . . . . . . . . 1 L96999 SPACER . . . . . . . . . . . . . . . . . . . . . 4 L97583 RETAINING RING . . . . . . . . . . . . . . 8 NSS SPOOL . . . . . . . . . . . . . . . . . . . . . . 4 L97585 SHIM PAC . . . . . . . . . . . . . . . . . . A/R (Includes sizes: 0.01, 0.02, 0.06)

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

JOYSTICK W/GATE (Complete) . . . 1 JOYSTICK (Complete) . . . . . . . . . . 1

20 21 22 23 24 25 26 27 28 29 30

L97584 L96928 NSS L97579 L97580 L97581 L500945 L500944 L50139 L500947 L500946

31

L96997

32

L97631

33

L97582

a b c

This joystick is used for Tilt and Level operations.

This joystick is used for Boom Lift and Extend.

Used only with joystick #L68775.

115

Description

Qty. Req.

SPRING 0.341ODX.051WD . . . . . . 4 SPRING 0.771ODX0.55WD . . . . . . 4 SPRING RETAINER . . . . . . . . . . . . 4 PLUNGER PIN . . . . . . . . . . . . . . . . 4 PLUNGER GUIDE. . . . . . . . . . . . . . 4 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 4 SPACER, JOYSTICK GATE . . . . . . 4 GATE, JOYSTICK CONTROLLER . 1 1/4” LOCK WASHER . . . . . . . . . . . . 4 1/4”-20X3/4” SOCKET HD BOLT . . 4 1/4”-20 SOCKET HD BOLT . . . . . . . 4 -- KITS-PIVOT BALL ASSEMBLY . . . . . . . . 1 (Includes items 8-13) PLUNGER GUIDE ASSEMBLY. . . . 4 (Includes items 23-25) SPOOL ASSEMBLY . . . . . . . . . . . . 4 (Includes items 17-20 & 22)

908484/BP0615

Hydraulics

634 Telehandler

Auxilary Hydraulic Joystick Breakdown

1

25

2

24

27

14 23 3

18

4

13

22 21

5

12

28

20 19

26 6

17

18

7 15 8

16

9 10

908484/BP0615

11

116

PRINTED IN U.S.A.

634 Telehandler

Hydraulics

Auxilary Hydraulic Joystick Breakdown Ref. No.

Part No.

00 01 02 03 04 05 06 07 08 09 10 11 12 13 14 15

Qty. Req.

Ref. No.

Part No.

L60302

AUXILARY JOYSTICK (Complete) 1

L97634 L97633 L96920 L50151 L96851 L96911 L50082 651270 L97041 L96933 NSS NSS L97042 NSS L500769 NSS

KNOB. . . . . . . . . . . . . . . . . . . . . . . . 1 BOOT. . . . . . . . . . . . . . . . . . . . . . . . 1 RETAINER . . . . . . . . . . . . . . . . . . . 1 1/2” FLAT WASHER . . . . . . . . . . . . 1 RETAINER RING. . . . . . . . . . . . . . . 1 HANDLE, ROD . . . . . . . . . . . . . . . . 1 5/8”-11 JAM NUT. . . . . . . . . . . . . . . 1 1/4”-20 JAM NUT. . . . . . . . . . . . . . . 2 ROCKER ARM . . . . . . . . . . . . . . . . 1 BUTTON . . . . . . . . . . . . . . . . . . . . . 2 PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 1 RETAINING RING . . . . . . . . . . . . . . 2 BOTTOM PLATE . . . . . . . . . . . . . . . 1 TOP PLATE . . . . . . . . . . . . . . . . . . . 1 BOOT PLATE . . . . . . . . . . . . . . . . . 1 BODY. . . . . . . . . . . . . . . . . . . . . . . . 1

16 17 18 19

L96999 NSS L96923 L97585

20 21 22 23 24 25

L96924 L96928 NSS L97579 L97580 L96929

26

L96932

27

L97631

28

L96931

PRINTED IN U.S.A.

Description

117

Description

Qty. Req.

SPACER . . . . . . . . . . . . . . . . . . . . . 4 SPOOL . . . . . . . . . . . . . . . . . . . . . . 4 RETAINING RING . . . . . . . . . . . . . . 4 SHIM PAC . . . . . . . . . . . . . . . . . . A/R (Includes sizes: 0.01, 0.02, 0.06) SPRING 0.341ODX0.051WD . . . . . 2 SPRING 0.771ODX0.55WD . . . . . . 4 SPRING RETAINER . . . . . . . . . . . . 4 PLUNGER PIN . . . . . . . . . . . . . . . . 4 PLUNGER GUIDE. . . . . . . . . . . . . . 4 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 2 -- KITS-ROCKER ARM ASSEMBLY . . . . . . 1 (Includes items 7-13) PLUNGER GUIDE ASSEMBLY. . . . 4 (Includes items 23-25) SPOOL ASSEMBLY . . . . . . . . . . . . 4 (Includes items 17-20 & 22)

908484/BP0615

Hydraulics

634 Telehandler Frame Level Cylinder Breakdown

1

7

2

6

5 3

8

4

9

11

10

12

908484/BP0615

118

PRINTED IN U.S.A.

634 Telehandler

Hydraulics

Frame Level Cylinder Breakdown Ref. No.

Part No.

00 01 02 03 04 05 06

Qty. Req.

Ref. No.

Part No.

L63015

FRAME LEVEL CYL. (Complete) . . 1

L98503 L63016 L98547 L99857 L98507 L98550

ROD. . . . . . . . . . . . . . . . . . . . . . . . . 1 BUSHING . . . . . . . . . . . . . . . . . . . . 1 HEAD GLAND CAP. . . . . . . . . . . . . 1 5/16”-18x1/4” SET SCREW. . . . . . . 1 HEAD GLAND . . . . . . . . . . . . . . . . . 1 PISTON . . . . . . . . . . . . . . . . . . . . . . 1

07 08 09 10 11

L99405 L64367 NSS L98509 L70495 L97889 L98506

PRINTED IN U.S.A.

Description

12

119

Description

Qty. Req.

1-1/4”-12 UNF LOCKNUT . . . . . . . . 1 BUSHING 2.0X2.25X2.0” . . . . . . . . 1 TUBE WELDMENT . . . . . . . . . . . . . 1 OIL LINE TUBE ASSEMBLY . . . . . . 1 COUNTER BALANCE VALVE . . . . . 2 SEAL KIT (CBV) . . . . . . . . . . . . . . . 1 CYLINDER SEAL KIT . . . . . . . . . . . 1 (Items included are not shown)

908484/BP0615

Hydraulics

634 Telehandler Lift Cylinder Breakdown

1

6 5 4 2

3

7

9 8 10

908484/BP0615

120

PRINTED IN U.S.A.

634 Telehandler

Hydraulics Lift Cylinder Breakdown

Ref. No.

Part No.

00

L63199

01 02 03 04 05

Note: Quantities shown are for one cylinder.

L98518 ROD WELDMENT . . . . . . . . . . . . . . 1 L98520 HEAD GLAND CAP. . . . . . . . . . . . . 1 L99857 5/16”-18X1/4” SET SCREW . . . . . . 1 L98522 HEAD GLAND . . . . . . . . . . . . . . . . . 1 L98523 PISTON . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

LIFT CYLINDER (Complete) . . . . . . 2

06 07 08

L99405 NSS L98519

09

L64175 L97889 L98521

10

121

Description

Qty. Req.

1-1/4”-12 UNF LOCKNUT . . . . . . . . 1 TUBE WELDMENT . . . . . . . . . . . . . 1 OIL LINE TUBE ASSEMBLY . . . . . . 1 (includes nuts and ferrules) COUNTER BALANCE VALVE . . . . . 1 SEAL KIT (CBV) . . . . . . . . . . . . . . . 1 CYLINDER SEAL KIT . . . . . . . . . . . 1 (Items included are not shown)

908484/BP0615

Hydraulics

634 Telehandler Slave Cylinder Breakdown

2 1

7

6

5

4 3

8 9

10

908484/BP0615

122

PRINTED IN U.S.A.

634 Telehandler

Hydraulics Slave Cylinder Breakdown

Ref. No.

Part No.

00 01 02 03 04 05

Qty. Req.

Ref. No.

Part No.

L63014

SLAVE CYLINDER (Complete) . . . . 1

L98524 L63018 L99857 L98513 L98528

ROD WELDMENT . . . . . . . . . . . . . . 1 BUSHING . . . . . . . . . . . . . . . . . . . . 1 5/16”-18X1/4” SET SCREW . . . . . . 1 HEAD GLAND CAP. . . . . . . . . . . . . 1 HEAD GLAND . . . . . . . . . . . . . . . . . 1

06 07 08 09 10

L98529 L500668 L63017 NSS L98527

PRINTED IN U.S.A.

Description

123

Description

Qty. Req.

PISTON . . . . . . . . . . . . . . . . . . . . . . 1 1-1/8”-12 UN LOCKNUT . . . . . . . . . 1 BUSHING . . . . . . . . . . . . . . . . . . . . 1 TUBE WELDMENT . . . . . . . . . . . . . 1 CYLINDER SEAL KIT . . . . . . . . . . . 1 (Items included are not shown)

908484/BP0615

Hydraulics

634 Telehandler Tilt Cylinder Breakdown

2

1

7

6

5 4 3

8

9 10

11

908484/BP0615

12

124

PRINTED IN U.S.A.

634 Telehandler

Hydraulics Tilt Cylinder Breakdown

Ref. No.

Part No.

00 01 02 03 04 05 06 07

Qty. Req.

Ref. No.

Part No.

L63013

SLAVE CYLINDER (Complete) . . . . 1

L98545 L63018 L99857 L98547 L99866 L98550 L99405

ROD WELDMENT . . . . . . . . . . . . . . 1 BUSHING . . . . . . . . . . . . . . . . . . . . 1 5/16”-18X1/4” SET SCREW . . . . . . 1 HEAD GLAND CAP. . . . . . . . . . . . . 1 HEAD GLAND . . . . . . . . . . . . . . . . . 1 PISTON . . . . . . . . . . . . . . . . . . . . . . 1 1-1/4”-12 UN LOCKNUT . . . . . . . . . 1

08 09 10 11

NSS L63017 L70495 L97889 L98548

12

L98551

PRINTED IN U.S.A.

Description

125

Description

Qty. Req.

TUBE WELDMENT . . . . . . . . . . . . . 1 BUSHING . . . . . . . . . . . . . . . . . . . . 1 COUNTER BALANCE VALVE . . . . . 1 SEAL KIT (CBV) CYLINDER SEAL KIT . . . . . . . . . . . 1 (Items included are not shown) HYDRAULIC LINE ASSY. . . . . . . . . 1

908484/BP0615

Hydraulics

634 Telehandler Boom Extend Cylinder Breakdown

1 2 7

6

8 5 4 3 9

11 10

12

908484/BP0615

126

PRINTED IN U.S.A.

634 Telehandler

Hydraulics

Boom Extend Cylinder Breakdown Ref. No.

Part No.

00 01 02 03 04 05 06

Qty. Req.

Ref. No.

Part No.

L63012

EXTEND CYLINDER (Complete) . . 1

L98511 L63018 L99857 L98513 L99515 L98516

ROD WELDMENT . . . . . . . . . . . . . . 1 BUSHING . . . . . . . . . . . . . . . . . . . . 1 5/16”-18X1/4” SET SCREW . . . . . . 1 HEAD GLAND CAP. . . . . . . . . . . . . 1 HEAD GLAND . . . . . . . . . . . . . . . . . 1 PISTON . . . . . . . . . . . . . . . . . . . . . . 1

07 08 09 10

L500668 L63017 NSS L48868A L96838 L98517 L98558

PRINTED IN U.S.A.

Description

11 12

127

Description

Qty. Req.

1-1/8”-12 UN LOCKNUT . . . . . . . . . 1 BUSHING . . . . . . . . . . . . . . . . . . . . 1 TUBE WELDMENT . . . . . . . . . . . . . 1 COUNTER BALANCE VALVE . . . . . 1 SEAL KIT (CBV) HYDRAULIC LINE ASSY. . . . . . . . . 1 CYLINDER SEAL KIT . . . . . . . . . . . 1 (Items included are not shown)

908484/BP0615

Hydraulics

634 Telehandler Fork Shift Cylinder Breakdown

1

3

4

2

6 5

Ref. No.

Part No.

01 02 03

L68337 L500763 L500762 L500761

908484/BP0615

Description

Qty. Req.

Ref. No.

Part No.

COMPLETE ASSEMBLY ROD WELDMENT . . . . . . . . . . . . . . 1 HEAD GLAND . . . . . . . . . . . . . . . . . 1 PISTON . . . . . . . . . . . . . . . . . . . . . . 1

04 05 06

L500367 NSS L500370

128

Description

Qty. Req.

3/4”-16 UNF LOCKNUT. . . . . . . . . . 1 TUBE WELDMENT . . . . . . . . . . . . . 1 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1 (Items included are not shown)

PRINTED IN U.S.A.

634 Telehandler

Hydraulics

Rotate Carriage Cylinder Breakdown

1 9

2

8 7 6 5 3

4

10

12

11

Ref. No.

Part No.

00 01 02 03 04 05 06

Qty. Req.

Ref. No.

Part No.

L63594

ROTATE CYLINDER (Complete) . . 1

L99168 L63593 L99169 L99857 L99171 L99174

ROD WELDMENT . . . . . . . . . . . . . . 1 BUSHING . . . . . . . . . . . . . . . . . . . . 1 HEAD GLAND CAP. . . . . . . . . . . . . 1 5/16”-18X1/4” SET SCREW . . . . . . 1 HEAD GLAND . . . . . . . . . . . . . . . . . 1 SPACER, ROD . . . . . . . . . . . . . . . . 1

07 06 09 10

L99175 L98921 L500367 L64175 L97889 NSS L99170

PRINTED IN U.S.A.

Description

11 12

129

Description

Qty. Req.

SUPPORT WASHER. . . . . . . . . . . . 1 PISTON . . . . . . . . . . . . . . . . . . . . . . 1 3/4”-16 UN LOCKNUT. . . . . . . . . . . 1 COUNTER BALANCE VALVE . . . . . 1 SEAL KIT (CBV) TUBE WELDMENT . . . . . . . . . . . . . 1 CYLINDER SEAL KIT . . . . . . . . . . . 1 (Items included are not shown)

908484/BP0615

Attachments

634 Telehandler

Standard Carriage Attachment Group

5 3 2 1

4 3 5

908484/BP0615

130

PRINTED IN U.S.A.

634 Telehandler

Attachments

Standard Carriage Attachment Group Ref. No.

Part No.

01

L99192 L99193 L66615 L42871 L63319 L63320 L47263 L47265 L61017

02 03 04 04 04

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

STD. CARR. WELD. 48” . . . . . . . . . 1 STD. CARR. WELD. 66” . . . . . . . . . 1 CAPACITY PLATE. . . . . . . . . . . . . . 1 POPRIVET . . . . . . . . . . . . . . . . . . . 4 FORK SHAFT BAR 51-1/2 O.A.L.. . 1 FORK SHAFT BAR 68-1/2 O.A.L.. . 1 FORK 2X5X48. . . . . . . . . . . . . . . . . 2 FORK 2X5X60. . . . . . . . . . . . . . . . . 2 BRICK FORK2X4X48 . . . . . . . . . . . 2

04 04 04 05

L61001 L400929 L66406 L400425 L50273 L520005

131

Description

Qty. Req.

BLOCK FORK 2X2X48 . . . . . . . . . . 4 FORK,1 3/4X5X48. . . . . . . . . . . . . . 2 FORK, 2 1/4X4X48 . . . . . . . . . . . . . 2 RETAINER. . . . . . . . . . . . . . . . . . . . 2 CAPSCREW 3/8-16X2-3/4 . . . . . . . 2 NYLON INSERT NUT 3/8-16 . . . . . 2

908484/BP0615

Attachments

634 Telehandler

Shift Fork Carriage Attachment Group

1

19 20

18 14 15 15 17

13 2

11

9

12

16

10

9 8

7 6 5 2 3 4

908484/BP0615

132

PRINTED IN U.S.A.

634 Telehandler

Attachments

Shift Fork Carriage Attachment Group Ref. No.

Part No.

01

L500215 L42871 L66615 L50519 L400425 L50333 L66919 L66931 L50875 Note a L63715 L50242 L63716 L520004 Note b Note b L66918 L68337 L50562

02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

FORK SHIFT CARRIAGE . . . . . . . . 1 1/8” POP RIVET . . . . . . . . . . . . . . . 4 NAME PLATE . . . . . . . . . . . . . . . . . 1 3/4”-10 NYLON INSERT NUT . . . . . 3 FORK SHAFT WASHER . . . . . . . . . 1 3/4”-10X3” BOLT . . . . . . . . . . . . . . 1 FORK SHAFT, 50” . . . . . . . . . . . . . . 1 FORK SLIDE PLATE . . . . . . . . . . . . 2 3/4”-10X1-1/2” BOLT . . . . . . . . . . . . 1 FORK SLIDE COUPLER. . . . . . . . . 1 TWIN CUSHION TOP PLATE . . . . . 2 5/16”-18X2-1/4” BOLT . . . . . . . . . . . 2 TWIN HOSE CUSHION. . . . . . . . . . 1 5/16”-18 NYLON INSERT NUT . . . . 2 COUPLER, MALE . . . . . . . . . . . . . . 1 COUPLER, FEMALE. . . . . . . . . . . . 1 CYLINDER MOUNT . . . . . . . . . . . . 2 FORK SHIFT CYLINDER . . . . . . . . 1 3/4”-10X4” BOLT . . . . . . . . . . . . . . . 2

18 19 20

L63143 L66950 L66949

a

For 4” wide forks use P/N L66921.

For 5” wide forks use P/N L66948.

b

Sold as a set. Order part # L65273 Quick Couplers

00 00 00 00 00

-- ITEMS NOT SHOWN -(FORKS) L47263 FORK, 2X5X48 . . . . . . . . . . . . . . . . 2 L47265 FORK, 2X5X60 . . . . . . . . . . . . . . . . 2 L61017 BRICK FORK, 2X4X48 . . . . . . . . . . 2 L400929 FORK, 1 3/4X5X48 . . . . . . . . . . . . . 2 L66406 FORK, 2 1/4X4X48 . . . . . . . . . . . . . 2

133

Description

Qty. Req.

ADAP -8ORM -6JICM W/.06 ORF . 2 HOSE -6 A6/A6 59” . . . . . . . . . . . . . 1 HOSE -6 A6/A6 56” . . . . . . . . . . . . . 1

908484/BP0615

Attachments

634 Telehandler

Rotate Carriage Attachment Group

11 10 8 5

14

7 1

10

2

11

13 3

12

9

6 4 12

908484/BP0615

134

PRINTED IN U.S.A.

634 Telehandler

Attachments

Rotate Carriage Attachment Group Ref. No.

Part No.

01 02

L63952 NSS L50801 L520005 L50205 L61287 L63968 L50892 L520019 L50273 L520005 L99225 L99224 L64367 L61709 L50261 L66615 L42871 L63969 L50294 L520019 L50273 L520005 L63319

03 04

05 06 07 08 09

10

PRINTED IN U.S.A.

Description

Qty. Req.

ROTATE PLATE WELD (IncI. 2) . . . 1 ROTATE PIN (Welded To Item 1). . 1 CAPSCREW 3/8-16X4 . . . . . . . . . 1 NYLON INSERT NUT 3/8-16 . . . . . 1 CASTELLATED NUT 2-12. . . . . . . . 1 WASHER . . . . . . . . . . . . . . . . . . . . 1 BUTT END PIVOT PIN . . . . . . . . . . 1 CAPSCREW 1/2-13X4 . . . . . . . . . 1 NYLON INSERT NUT 1/2-13 . . . . . 1 CAPSCREW 3/8-16X2-3/4 . . . . . . 1 NYLON INSERT NUT 3/8-16 . . . . . 1 ROT. CARR. WELD. 48” (IncI.6,7). 1 ROT. CARR. WELD. 66” (IncI.6,7). 1 BUSHING . . . . . . . . . . . . . . . . . . . . 1 SLIDE PAD 3X4. . . . . . . . . . . . . . . . 3 CAPSCREW 3/8-16X1-1/2 . . . . . . . 6 CAPACITY PLATE. . . . . . . . . . . . . . 1 POPRIVET . . . . . . . . . . . . . . . . . . . 4 ROD END PIVOT PIN . . . . . . . . . . . 1 CAPSCREW 1/2-13X3-1/2 . . . . . . . 1 NYLON INSERT NUT 1/2-13 . . . . . 1 CAPSCREW 3/8-16X2-3/4 . . . . . . . 1 NYLON INSERT NUT 3/8-16 . . . . . 1 FORK SHAFT BAR 51-1/2” LG. . . . 1

Ref. No.

11 12 13a 14

Part No. L63320 L50273 L520005 L400425 L61307 L63594 L47263 L47265 L61017 L61001 L400929 L66406

a

Description

Qty. Req.

FORK SHAFT BAR 68-1/2’ LG. . . . . 1 CAPSCREW 3/8-16X2-3/4 . . . . . . . 2 NYLON INSERT NUT 3/8-16 . . . . . 2 RETAINER. . . . . . . . . . . . . . . . . . . . 2 SPACER . . . . . . . . . . . . . . . . . . . . . 2 ROTATE CYLINDER . . . . . . . . . . . . 1 FORKS FORK, 2X5X48 . . . . . . . . . . . . . . . . 2 FORK, 2X5X60 . . . . . . . . . . . . . . . . 2 BRICK FORK, 2X4X48 . . . . . . . . . . 2 BLOCK FORK, 2X2X48. . . . . . . . . . 4 FORK, 1 3/4X5X48 . . . . . . . . . . . . . 2 FORK, 2 1/4X4X48 . . . . . . . . . . . . . 2

Hoses and fittings are listed in the “Items Not Shown” section below.

-- ITEMS NOT SHOWN -L51968 L63344 L63143 L65273

135

ADAP, -6ORM -6JICM 90DEG . . . . 2 HOSE, -6 A8/A6 20” . . . . . . . . . . . . 2 ADAP, -8ORM -6JICM STR. . . . . . . 2 (with orifice) QUICK COUPLER SET. . . . . . . . . . 1

908484/BP0615

Attachments

634 Telehandler Boom Attachment Group

1 8’ Truss Boom

26 25

2 5’ Jib Boom

24

8

7

Hydraulic Winch With Brake 27

6

23

19 18

17

15

16

14

11

4 3

13 9

22 21

20

12

5 9

908484/BP0615

136

9

PRINTED IN U.S.A.

634 Telehandler

Attachments Boom Attachment Group

Ref. No.

Part No.

01 02 03 04 05

L99237 L500214 L64294 L64660 L50841 L520003 L444004

06 07a 08a 09 10 11b 12 13 14 15 16 17 18 19 20c

L445002 L82358 100963 L50286 L520019 L444008 L400398 L50815 100076 L520004 L65338 L66946

PRINTED IN U.S.A.

Description

Qty. Req.

Ref. No.

Part No.

8’ TRUSS BOOM WELDMENT . . . . 1 5’ JIB BOOM WELDMENT . . . . . . . 1 HOSE -8 A8/A8 53” . . . . . . . . . . . . . 2 ADAP -8ORM -8JICM RUN TEE. . . 1 1/4-20”X2” BOLT . . . . . . . . . . . . . . . 2 1/4”-20 NYLON INSERT NUT . . . . 2 ADAP -8ORM -8JICM STR . . . . . . . 2 COUPLER, MALE . . . . . . . . . . . . . . 1 COUPLER, FEMALE. . . . . . . . . . . . 1 ADAP -8ORM -8JICM 90 DEG . . . . 2 RELIEF VALVE . . . . . . . . . . . . . . . . 1 HYDRAULIC WINCH. . . . . . . . . . . . 1 1/2”-13X1-3/4” GR 8 BOLT . . . . . . . 6 1/2-13 NYLON INSERT NUT . . . . . 6 ADAP -10ORM -8JICM . . . . . . . . . . 2 HOSE -6 A8/A8 18.5” . . . . . . . . . . . 2 5/16”X2-1/2” BOLT . . . . . . . . . . . . . 2 PIN, TRUSS WINCH . . . . . . . . . . . . 1 5/16”-18 NYLON INSERT NUT . . . . 2 WINCH SHEAVE . . . . . . . . . . . . . . . 1 3/8”X60’ WINCH CABLE . . . . . . . . . 1 (Includes hook and swivel)

21 22 23 24 25 26 27d

L50371 L50147 L60451 L61411 L50380 L50152 L446017

a

Sold as a set. Order part # L65273 Quick Couplers

b

Used with 5’ truss booms after attachment serial number 11182. The winch on 5’ truss booms before attachment serial number 11183 have been discontinued, you must purchase a boom and a winch.

c

Used with 5’ truss booms with winch.

d

Not used on some attachments.

L500222

137

Description

Qty. Req.

3/8”X2-1/2” BOLT . . . . . . . . . . . . . . 2 3/8” LOCK WASHER . . . . . . . . . . . . 2 WINCH BALL. . . . . . . . . . . . . . . . . . 1 PINTLE HOOK . . . . . . . . . . . . . . . . 1 1/2”-20X1-1/4” GR 8 BOLT . . . . . . . 4 1/2” LOCK WASHER . . . . . . . . . . . . 4 ADAP -8JICFS -8JICM 90 . . . . . . . . 2

-- ITEMS NOT SHOWN -AUGER, ADAPTER PLATE. . . . . . . 1

908484/BP0615

Attachments

634 Telehandler Bucket Attachment Group

1

Ref. No.

Part No.

01

L500373 L42871 L66615

908484/BP0615

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1.3 CU. YD. BUCKET WELDMNT . 1 1/8” POP RIVET . . . . . . . . . . . . . . . 4 NAME PLATE . . . . . . . . . . . . . . . . . 1

138

PRINTED IN U.S.A.

634 Telehandler

Attachments Notes

PRINTED IN U.S.A.

139

908484/BP0615

Numerical Index Part No.

Page No.

Ref. No.

056859 072340 072340 072794 072797 072798 078936 089069 089069 089070 089070 093475 094951 100011 100012 100076 100135 100155 100156 100401 100622 100623 100624 100625 100626 100627 100656 100657 100658 100659 100660 100661 100963 101158 101274 101275 101275 101276 101279 650965 651270 651543 654022 L10151 L10465 L120038A L120039 L120041 L120047 L120047 L120047 L120054 L277013 L277568 L400398 L400425 L400425

9 27 29 9 9 9 49 27 29 27 29 10 10 57 31 137 25 7 8 10 7 8 7 8 8 7 11 10 10 10 10 10 137 33 35 35 35 35 17 53 117 57 109 53 31 49 49 49 51 51 51 49 73 27 137 131 133

08 11 04 10 09 07 03 21 14 21 14 09 06 14 31 17 01 02 08 01 04 03 08 05 02 03 07 10 10 10 10 10 11 17 06 05 09 08 01 21 07 10 15 20 23

908484/BP0615

08 15 03 10 14 05 17 27 15 05 03

Mustang Telehandler

Part No.

Page No.

Ref. No.

L400425 L400929 L400929 L400929 L40496 L40805 L41179 L41260 L41261 L41847 L41847 L41848 L41848 L41854 L42342 L42342 L42448 L42871 L42871 L42871 L42871 L43221 L43964 L43965 L441010 L441010 L442022 L443011 L443011 L443011 L443011 L443022 L444001 L444001 L444002 L444002 L444002 L444002 L444004 L444004 L444004 L444004 L444007 L444008 L444008 L444008 L444008 L444008 L444010 L444010 L444012 L444070 L4445 L4446 L445001 L445002 L445002

135 131 133 135 23 47 45 23 23 37 41 27 29 39 27 53 33 131 133 135 138 39 27 27 39 89 39 101 103 105 93 103 53 93 39 89 91 95 105 137 23 91 53 101 105 137 93 99 103 93 89 53 43 43 47 101 137

11 04 00 14 01 16 02 02 03 19 06 19 05 08 01 17 02 01 08 01 20 23 22 17 22 12 04 16 04 01 02 03 13 15 23 09 03 19 06 11 17 05 08 06 14 07 07 15 28 17 07 01 05 06 11 09

Part No.

Page No.

Ref. No.

L445002 L445002 L445003 L445003 L445003 L445003 L445012 L445014 L446017 L446017 L446020 L446026 L446026 L446026 L446044 L446044 L446046 L446049 L447005 L44859 L45049 L45049 L45934 L46572 L46865 L46865 L47212 L47263 L47263 L47263 L47265 L47265 L47265 L47275 L47275 L48011 L48179 L48868A L49327 L500127 L500129 L500130 L500132 L500134 L500135 L500214 L500215 L500222 L500314 L500315 L500317 L500356 L500367 L500367 L500368 L500370 L500373

89 99 89 91 93 95 89 89 137 57 47 101 93 99 31 31 39 59 45 31 57 59 47 115 106 89 47 131 133 135 131 133 135 27 53 51 31 127 39 109 109 109 109 109 109 137 133 137 51 51 73 73 128 129 106 128 138

18 12 13 06 26 05 10 01 27 17 07 07 06 06 32 38 16 05 26 22 19 18 13 01 02 03 24 04 00 14 04 00 14

140

01 03 07 10 19 18 16 04 04 03 14 02 01 09 08 15 15 04 09 03 06 01

Part No.

Page No.

Ref. No.

L500445 L500446 L500447 L500448 L500451 L500452 L500453 L500454 L500455 L500455 L500456 L500456 L500457 L500458 L500459 L500460 L500461 L500462 L500463 L500464 L500465 L500466 L500467 L500468 L500469 L500470 L500471 L500472 L500473 L500474 L500476 L500477 L500478 L500479 L500480 L500481 L500483 L500484 L500485 L500486 L500488 L500489 L500490 L500490 L500491 L500492 L500493 L500494 L500495 L500496 L500496 L500497 L500498 L500499 L500500 L500501 L500502

10 23 23 33 67 67 67 67 61 67 61 67 69 69 69 69 69 69 69 69 69 69 69 69 69 69 69 69 69 69 69 69 69 69 69 69 61 61 61 61 61 61 57 61 61 61 61 61 61 61 77 61 61 61 61 61 61

10 06 08 02 03 04 05 38 06 24 08 01 02 02 02 02 02 03 05 06 07 08 09 10 11 12 13 14 15 17 17 18 22 23 24 01 02 03 04 05 06 22 09 10 11 12 13 14 15 12 17 18 19 20 21 22

PRINTED IN U.S.A.

Mustang Telehandler Part No.

Page No.

Ref. No.

L500503 L500504 L500505 L500506 L500507 L500508 L500509 L50051 L50051 L50051 L50051 L50051 L50051 L500510 L500511 L500512 L500513 L500515 L500516 L500517 L500518 L500519 L500521 L500522 L500523 L500524 L500525 L500526 L500527 L500528 L500529 L500531 L500532 L500533 L500534 L500535 L500536 L500537 L500538 L500539 L500539 L500540 L500540 L500541 L500542 L500543 L500544 L500546 L500549 L500550 L500551 L500554 L500555 L50056 L50056 L50056 L50056

61 61 61 61 61 61 61 17 21 31 95 95 95 61 61 61 61 61 61 61 61 61 61 61 61 61 61 61 77 77 77 77 77 77 77 77 77 77 77 110 57 110 57 57 57 57 57 57 115 115 115 61 61 25 27 31 33

23 26 27 28 29 30 32 20 16 37 01 02 06 33 34 35 36 39 40 41 42 43 45 46 49 49 49 50 01 02 03 05 06 07 08 09 10 13 14 01 12 01 12 13 24 20 21 11 10 11 12 44 48 08 14 03 04

PRINTED IN U.S.A.

Numerical Index

Part No.

Page No.

Ref. No.

Part No.

Page No.

L50056 L50056 L50056 L50056 L50056 L50061 L50061 L50061 L500668 L500668 L500673 L50072 L50072 L500720 L500761 L500762 L500763 L500768 L500769 L500770 L500771 L500771 L50082 L50082 L50084 L50084 L50084 L50086 L50086 L500943 L500944 L500945 L500946 L500947 L500948 L500952 L500953 L500954 L500955 L500956 L500957 L500958 L500959 L500960 L500961 L500962 L50101 L50136 L50139 L50141 L50141 L50141 L50141 L50141 L50141 L50143 L50143

37 43 43 49 53 17 25 41 123 127 23 19 31 35 128 128 128 35 117 111 69 71 115 117 57 59 97 81 85 110 115 115 115 115 25 109 109 109 109 109 109 109 109 109 109 112 23 43 115 21 27 35 37 47 81 105 21

03 06 07 12 01 03 06 08 07 07 08 04 20 10 03 02 01 29 14 02 16 05 07 06 04 04 16 35 21 02 27 26 30 29 05 06 07 02 11 08 12 17 13 20 15 02 04 11 28 07 02 04 02 04 04 17 20

L50145 L50145 L50145 L50145 L50147 L50147 L50147 L50147 L50147 L50147 L50147 L50147 L50147 L50147 L50150 L50151 L50151 L50151 L50151 L50151 L50152 L50152 L50152 L50157 L50157 L50157 L50184 L50201 L50202 L50202 L50202 L50202 L50202 L50202 L50205 L50207 L50207 L50207 L50207 L50207 L50208 L50208 L50209 L50211 L50211 L50211 L50211 L50212 L50226 L50228 L50228 L50228 L50228 L50228 L50228 L50230 L50230

25 31 37 51 103 13 137 35 53 81 81 83 83 85 31 115 117 21 31 47 137 19 81 57 59 97 89 57 15 17 17 19 21 27 135 101 105 81 83 85 25 33 43 19 95 95 95 19 81 101 105 47 81 83 85 21 27

141

Ref. No. 27 17 05 17 07 22 18 21 22 27 20 23 08 25 05 03 02 06 14 26 16 09 03 03 15 05 25 08 02 21 17 17 38 03 16 04 05 04 13 11 20 01 02 06 18 14 15 05 03 06 06 16

Part No.

Page No.

Ref. No.

L50230 L50230 L50230 L50230 L50230 L50230 L50235 L50242 L50251 L50251 L50251 L50253 L50261 L50261 L50261 L50261 L50273 L50273 L50273 L50273 L50273 L50273 L50273 L50273 L50273 L50277 L50283 L50286 L50286 L50286 L50294 L50294 L50319 L50319 L50333 L50367 L50367 L50367 L50367 L50367 L50367 L50367 L50367 L50367 L50367 L50371 L50380 L50380 L50403 L50403 L50403 L50417 L50418 L50442 L50442 L50462 L50462

37 39 43 43 47 49 31 133 81 83 85 23 135 31 81 83 101 103 131 135 135 135 83 87 99 97 89 13 137 39 135 21 45 53 133 103 13 25 35 43 51 53 81 81 83 137 137 81 35 81 97 27 39 37 51 59 81

09 23 06 07 10 11 02 10 25 19 07 09 07 28 32 22 13 05 05 04 09 10 12 03 04 03 06 04 12 10 09 01 12 11 04 17 06 01 02 06 01 22 26 15 21 25 08 15 30 08 05 07 18 16 12 21

908484/BP0615

Numerical Index Part No.

Page No.

Ref. No.

L50468 L50519 L50535 L50545 L50546 L50562 L50567 L50607 L50612 L50612 L50628 L50646 L50655 L50655 L50655 L50667 L50704 L50704 L50712 L50712 L50712 L50727 L50741 L50755 L50755 L50791 L50801 L50815 L50815 L50823 L50823 L50833 L50835 L50835 L50836 L50836 L50841 L50875 L50877 L50877 L50877 L50878 L50878 L50892 L50895 L50896 L50896 L50896 L50896 L50952 L50952 L510041 L51099 L514001 L51591 L51622 L51968

53 133 91 105 27 133 21 31 81 85 31 87 17 27 33 45 45 53 57 59 97 53 89 37 39 81 135 137 47 35 37 53 27 31 35 51 137 133 101 105 85 103 81 135 93 17 17 27 33 51 53 31 49 17 31 31 135

10 02 04 17 13 17 09 18 10 16 11 12 18 26 16 21 17 12 26 19 14 26 15 24

908484/BP0615

07 02 16 18 03 01 22 18 14 17 18 05 07 23 10 23 09 18 04 10 09 18 25 15 07 25 24 14 12 15 39

Mustang Telehandler

Part No.

Page No.

Ref. No.

L520003 L520003 L520003 L520004 L520004 L520004 L520004 L520004 L520004 L520004 L520004 L520004 L520004 L520005 L520005 L520005 L520005 L520005 L520005 L520005 L520005 L520005 L520005 L520005 L520005 L520005 L520005 L520005 L520005 L520005 L520005 L520007 L520007 L520007 L520017 L520019 L520019 L520019 L520019 L520019 L520019 L520019 L520019 L520019 L520019 L52004 L52004 L52024 L52025 L52025 L52025 L52025 L52025 L52026 L52026 L52026 L52028

137 15 91 101 103 133 137 31 81 81 83 85 93 101 103 131 135 135 135 135 25 31 35 43 51 83 83 85 87 97 99 21 45 53 27 13 135 135 137 19 21 39 47 59 81 101 105 31 21 25 27 33 37 25 83 85 81

05 02 08 10 12 18 13 17 05 03 11 12 03 05 02 04 09 10 26 02 04 02 06 13 26 02 05 05 12 16 13 12 03 04 09 13 03 04 11 15 12 21 22 09 37 18 03 06 20 07 07 27 05

Part No.

Page No.

Ref. No.

L530003 L530004 L530004 L530004 L54002 L550003 L561004 L57011 L580005 L580009 L60253 L60253 L60291 L60302 L60302 L60451 L60492 L60492 L60653 L61001 L61001 L61017 L61017 L61017 L61021 L61085 L61086 L61199 L61200 L61287 L61307 L61411 L61620 L61699 L61699 L61708 L61708 L61709 L61709 L61709 L61709 L61867 L62132 L62459 L62482 L62484 L62553 L62553 L62583 L62715 L62715 L62715 L62720 L62722 L62731 L62732 L62733

41 21 37 47 21 37 31 17 31 45 93 97 49 117 95 137 51 51 57 131 135 131 133 135 51 19 19 17 17 135 135 137 39 83 85 81 83 135 81 83 85 39 29 25 91 27 115 95 9 81 83 85 37 37 83 83 81

10 08 11 11 14

142

19 09 14 17 09 00 06 23 13 14 08 04 14 04 00 14 19 13 19 14 15 03 12 24 18 26 04 23 27 07 28 21 09 07 06 03 02 15 00 02 01 24 16 11 05 04 28 29 29

Part No.

Page No.

Ref. No.

L62733 L62734 L62734 L62741 L62814 L62831 L62840 L62842 L62842 L62926 L62949 L630001 L630003 L630004 L63005 L63006 L63009 L63009 L63012 L63012 L63013 L63013 L63013 L63014 L63014 L63015 L63015 L63016 L63016 L63017 L63017 L63017 L63017 L63017 L63017 L63017 L63017 L63017 L63018 L63018 L63018 L63018 L63018 L63018 L63044 L63099 L63114 L63115 L63115 L63131 L63137 L63142 L63143 L63143 L63153 L63156 L63156

83 83 85 31 43 39 107 23 89 31 29 41 41 41 85 83 59 97 103 127 101 125 87 101 123 119 97 119 97 101 103 123 125 127 81 85 87 99 101 103 123 125 127 87 59 81 59 59 97 81 81 29 133 135 83 85 85

18 17 10 33 06 03 05 12 07 36 10 03 04 02 02 02 02 12 01 00 19 00 08 16 00 00 01 02 11 17 06 08 09 08 16 22 05 02 15 18 02 02 02 07 18 21 12 20 13 13 33 18 11 15 18

PRINTED IN U.S.A.

Mustang Telehandler

Numerical Index

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

L63157 L63158 L63166 L63166 L63167 L63168 L63169 L63172 L63173 L63199 L63199 L63215 L63217 L63222 L63222 L63230 L63234 L63239 L63248 L63269 L63272 L63272 L63272 L63273 L63273 L63274 L63274 L63276 L63280 L63286 L63309 L63312 L63319 L63319 L63320 L63320 L63326 L63334 L63335 L63335 L63335 L63344 L63356 L63363 L63363 L63373 L63381 L63381 L63382 L63382 L63382 L63382 L63383 L63384 L63384 L63386 L63386

83 83 81 85 85 85 81 31 81 121 99 39 39 57 59 31 59 83 41 21 101 103 87 101 103 87 99 97 59 31 89 87 131 135 131 135 87 41 17 29 29 135 47 113 31 31 57 59 31 31 57 59 91 89 91 57 59

10 09 34 19 20 17 11 04a 12 00 01 01 09 19 18 01 01 25 05 03 14 19 06 18 04 04 03 04 11 40 02 11 03 10 03 10 10 01 18 12 13

L63386 L63387 L63387 L63387 L63388 L63388 L63388 L63399 L63399 L63403 L63403 L63403 L63406 L63406 L63407 L63407 L63407 L63407 L63407 L63407 L63420 L63439 L63458 L63474 L63474 L63478 L63505 L63519 L63536 L63542 L63545 L63545 L63546 L63546 L63547 L63548 L63554 L63559 L63564 L63574 L63593 L63594 L63594 L63606 L63610 L63610 L63611 L63618 L63629 L63631 L63632 L63633 L63633 L63634 L63640 L63640 L63651

91 57 59 91 57 59 91 47 53 57 59 91 89 93 101 93 93 93 99 99 31 49 21 7 11 19 39 21 33 11 33 35 17 43 19 19 35 21 31 19 129 129 135 29 27 29 29 10 31 11 11 27 53 27 27 29 31

07 16 15 13 16 15 11 09 02 15 14 10 14 21 10 09 15 16 10 11

L63651 L63660 L63665 L63674 L63688 L63689 L63690 L63694 L63694 L63699 L63699 L63699 L63700 L63715 L63715 L63715 L63715 L63716 L63716 L63716 L63725 L63737 L63751 L63752 L63753 L63756 L63756 L63757 L63793 L63798 L63799 L63801 L63810 L63811 L63813 L63813 L63814 L63815 L63816 L63853 L63854 L63864 L63864 L63870 L63870 L63872 L63872 L63873 L63874 L63887 L63894 L63906 L63913 L63913 L63932 L63932 L63933

31 51 47 27 27 27 10 103 81 17 27 29 13 101 105 133 85 105 133 85 13 13 29 29 29 37 39 17 19 39 19 19 25 25 21 33 43 43 43 43 43 37 39 21 37 29 43 43 43 27 29 17 37 39 17 27 27

17 15 21 01 07 37 08 17 22 19 20 07 10 24 11 09 25 18 11 24 05 08

PRINTED IN U.S.A.

03 00 34 21 07 07 29 30 06 06 12 11 14 15 14

16 13 09 10 12 05 07 04 01 13 06 14 15 26 15 12 02 02 00 13 10 15 03 35 06 05 01 08 16 16

143

25 01 06 02 05 05 01 09 10 08 03

05 08

09 23 16 28 36

Part No.

Page No.

Ref. No.

L63934 L63935 L63936 L63937 L63938 L63941 L63942 L63943 L63952 L63968 L63969 L64090 L64097 L64124 L64124 L64124 L64143 L64175 L64175 L64196 L64196 L64197 L64197 L64197 L64294 L64326 L64367 L64367 L64367 L64437 L64524 L64524 L64572 L64646 L64660 L64663 L64663 L64664 L64664 L64764 L64788 L64821 L64890 L64970 L64987 L650004 L650004 L650004 L650005 L650012 L650012 L65097 L65098 L65142 L65144 L65273 L65273

27 27 27 27 27 27 27 59 135 135 135 29 29 21 45 53 81 121 129 45 53 21 45 53 137 73 119 135 97 45 23 91 51 45 137 31 45 31 45 51 49 51 31 29 43 29 29 45 29 27 29 87 87 39 39 135 137

31 24 24 32 35 24 24 11 01 04 09 10 14 15 31 09 10 13 16 11 15 14 03 16 08 06 02 04 10 16 20 18 04 08 07 04 19 15 09 01 11 11 17 02 13 14 24 22 07

908484/BP0615

Numerical Index

Mustang Telehandler

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

L65274 L65275 L65338 L65440 L65570 L65638 L65640 L65920 L65920 L65922 L65922 L65924 L65925 L65926 L65927 L65927 L65927 L65927 L65928 L65928 L65929 L65930 L65932 L65932 L65933 L65937 L65942 L65948 L66011 L66042 L66053 L66119 L66135 L66138 L66139 L66139 L66156 L66162 L66265 L66360 L66406 L66406 L66406 L66437 L66437 L66456 L66606 L66613 L66615 L66615 L66615 L66615 L66675 L66709 L66736 L66780 L66782

105 105 137 10 45 81 81 8 9 7 11 8 10 9 7 11 8 9 11 8 11 11 7 8 7 9 8 11 27 11 29 47 31 59 57 59 31 29 47 45 131 133 135 27 29 87 45 8 131 133 135 138 35 47 29 85 85

20 21 19 02

L66783 L66842 L66842 L66843 L66849 L66849 L66850 L66850 L66855 L66877 L66907 L66918 L66919 L66931 L66946 L66949 L66950 L66965 L66986 L66993 L66997 L67282 L67285 L67308 L67309 L67330 L67452 L67452 L67498 L67499 L67499 L67502 L67502 L67504 L67504 L67507 L67508 L67589 L67616 L67617 L67629 L67630 L67657 L67674 L67674 L67681 L67681 L67718 L67719 L67720 L67721 L67722 L67723 L67732 L67751 L67756 L67756

85 21 33 17 27 33 17 27 45 49 19 133 133 133 137 133 133 53 33 33 33 13 19 19 19 31 47 53 59 57 59 57 59 57 59 59 59 47 39 51 35 35 49 27 35 27 35 9 9 9 9 9 9 35 47 37 51

12

L67804 L67809 L67811 L67813 L67813 L67815 L67821 L67832 L67832 L67832 L67832 L67832 L67858 L67865 L68006 L68039 L68039 L68054 L68054 L68133 L68134 L68135 L68156 L68171 L68182 L68185 L68186 L68192 L68193 L68200 L68205 L68239 L68239 L68239 L68239 L68268 L68274 L68276 L68277 L68295 L68296 L68304 L68310 L68337 L68337 L68346 L68347 L68348 L68350 L68351 L68351 L68352 L68352 L68356 L68358 L68374 L68374

15 15 15 15 17 15 15 15 17 23 33 43 15 13 81 101 105 27 45 37 37 37 35 37 37 37 37 37 37 37 37 101 101 105 105 37 35 35 35 10 53 43 37 128 133 103 21 81 81 101 105 103 103 103 81 101 101

12 11 10 07 13 05 13 06 11 07 17

908484/BP0615

06 03 11 03 10 11 01 07 06 05 12 04 05 01 10 09 03 06 07 07 04 06 08 04 02 12 16 09 08 05 23 04 00 14 09 03 09 06 09 02 01 08 01 16 22 11 14 13

07 30 03 17 29 17 18 15 05 06 20 20 19 04 12 14 08 01 08 11 06 10 08 06 18 19 18 19 18 19 18 18 18 17 12 01 19 29 13 24 12 11 02 02 02 02 02 02 27 21 16 17

144

09 11 15 25 12 33 07 07 07 36 08 12 13 27 06 26 22 15 02 03 02 03 33 34 35 04 18 11 10 16 07 19 20 01 01 01 11 12 08 19 20 21

Part No.

Page No.

Ref. No.

L68376 L68376L68437 L68438 L68439 L68441 L68447 L68447 L68447 L68448 L68449 L68449 L68451 L68459 L68460 L68461 L68463 L68466 L68467 L68468 L68513 L68516 L68517 L68529 L68531 L68531 L68533 L68533 L68539 L68544 L68562 L68563 L68569 L68571 L68580 L68588 L68591 L68591 L68591 L68592 L68592 L68592 L68595 L68596 L68600 L68602 L68604 L68610 L68611 L68614 L68619 L68638 L68638 L68641 L68643 L68651 L68694

105 105 15 15 17 19 17 29 33 17 21 37 35 17 17 35 35 15 35 17 10 49 49 51 45 53 45 53 47 51 53 53 35 45 47 53 33 35 45 33 35 45 45 45 35 35 45 35 35 45 39 27 29 31 49 51 109

13 14 04 01 10 01 21 30 08 25 10 03 05 06 07 01 10 23 11 17 25 12 09 19 20 03 20 08 11a 23 24 09 22 23 20 19 21 14 27 31 32 25 14 06 17 37 18 09

PRINTED IN U.S.A.

Mustang Telehandler

Numerical Index

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

L68694 L68694 L68695 L68696 L68697 L68711 L68713 L68713 L68713 L68714 L68714 L68744 L68762 L68763 L68763 L68772 L68773 L68774 L68775 L68775 L68777 L68778 L68778 L68778 L68783 L68783 L68784 L68784 L68794 L68802 L68803 L68804 L68804 L68805 L68805 L68805 L68806 L68807 L68807 L68808 L68808 L68809 L68809 L68809 L68810 L68811 L68812 L68813 L68814 L68814 L68814 L68814 L68815 L68815 L68815 L68815 L68816

93 95 83 83 83 111 112 23 91 106 89 83 85 39 89 23 23 23 115 95 37 105 93 95 107 89 13 21 97 89 89 89 95 89 91 95 93 93 99 93 99 93 93 97 95 95 95 89 103 103 93 93 101 105 93 93 101

12 11 14 24 08

L68816 L68816 L68816 L68817 L68817 L68824 L68849 L68866 L68875 L68876 L68876 L68878 L68878 L68881 L68882 L68884 L69166 L69718 L69718 L69718 L69734 L69734 L69747 L69747 L69920 L69920 L70146 L70200 L70200 L70242 L70468 L70495 L70495 L70649 L71392 L71393 L71394 L71520 L71637 L72175 L75906 L75956 L75956 L76020 L76084 L81690 L82358 L96580 L96838 L96851 L96851 L96852 L96853 L96911 L96920 L96923 L96924

105 93 93 101 93 95 57 37 57 57 97 57 97 97 97 57 45 33 35 45 57 61 111 91 89 91 41 37 43 81 49 119 125 17 13 13 17 35 53 39 39 33 35 47 47 39 137 109 127 115 117 115 115 117 117 117 117

08 04 24 09 08 04 01 21 19 27 13 02 12 09 10 19 05 10 24 22 18 37 01 05 08 03 09

L96928 L96928 L96929 L96931 L96932 L96933 L96989 L96993 L96994 L96995 L96997 L96999 L96999 L97041 L97042 L97134 L97135 L97489 L97489 L97579 L97579 L97580 L97580 L97581 L97582 L97583 L97584 L97585 L97585 L97631 L97631 L97633 L97634 L97889 L97889 L97889 L97889 L98042 L98044 L98318 L98318 L98318 L98319 L98320 L98321 L98322 L98323 L98324 L98325 L98331 L98332 L98333 L98334 L98335 L98336 L98337 L98338

115 117 117 117 117 117 47 115 115 115 115 115 117 117 117 63 63 39 39 115 117 115 117 115 115 115 115 115 117 115 117 117 117 119 121 125 129 115 115 61 65 67 65 65 65 65 65 65 65 65 65 65 65 65 65 65 65

21 21 25 28 26 09 02 09 13 14 31 16 16 08 12 10 10 03 04 23 23 24 24 25 33 17 20 19 19 32 27 02 01 11 09 10 10 08 04 25 23 07 25 26 20 21 19 16 17 14 15 18 22 24 27 27 01

L98339 L98341 L98342 L98343 L98344 L98345 L98345 L98346 L98347 L98348 L98349 L98350 L98352 L98353 L98354 L98355 L98355 L98355 L98356 L98360 L98361 L98363 L98364 L98365 L98366 L98367 L98368 L98369 L98370 L98371 L98371 L98372 L98372 L98373 L98373 L98374 L98375 L98376 L98377 L98378 L98378 L98379 L98379 L98380 L98380 L98380 L98381 L98381 L98382 L98383 L98384 L98385 L98386 L98387 L98388 L98389 L98390

65 65 65 65 65 59 65 65 65 65 65 65 63 63 63 57 61 63 63 63 63 63 63 63 63 63 63 63 63 61 63 61 63 61 63 63 63 63 63 71 73 71 73 69 71 73 71 73 73 73 73 73 73 73 73 73 73

02 03 05 06 07 17 08 09 10 11 12 13 01 02 04 23 16 05 07 08 09 12 13 14 15 16 17 19 18 07 20 07 21 47 22 23 03 11 06 01 01 02 02 04 03 03 04 07 05 06 10 09 08 11 04 12 13

PRINTED IN U.S.A.

01 13 01 01 04 01 01 21 24 05 14 00 01 05 25 10 01 16 09 22 06 09 19 12 12 20 15 13 22 17 08 18 09 19 20 07 09 08 07 21 13 14 02 03 05 07 05 23 06

07 02 06 11 10 22 08 08 22 07 24 13 05 19 01 14 10 16 10 06 04 02 03 05 02 18 20

145

908484/BP0615

Numerical Index

Mustang Telehandler

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

L98391 L98392 L98393 L98394 L98394 L98395 L98395 L98396 L98396 L98400 L98401 L98404 L98404 L98405 L98406 L98406 L98407 L98414 L98415 L98416 L98417 L98417 L98417 L98418 L98419 L98420 L98421 L98422 L98422 L98423 L98424 L98425 L98426 L98427 L98428 L98429 L98430 L98430 L98430 L98431 L98432 L98433 L98434 L98435 L98436 L98437 L98438 L98439 L98440 L98441 L98442 L98443 L98444 L98444 L98445 L98445 L98503

71 71 71 69 71 69 71 69 71 71 71 69 71 71 69 71 71 71 71 73 61 67 75 75 75 75 75 59 75 75 75 75 75 75 75 79 59 77 79 79 79 79 79 79 79 79 79 79 79 79 79 59 110 59 110 59 119

14 13 12 21 11 20 10 19 09 08 08 17 06 06 17 06 06 07 07 14 31 01 02 01 03 04 05 10 06 10 11 09 12 07 08 01 13 11 02 03 04 05 06 07 08 09 10 11 12 13 14 09 01 13 01 13 01

L98506 L98507 L98509 L98511 L98513 L98513 L98516 L98517 L98518 L98519 L98520 L98521 L98522 L98523 L98524 L98527 L98528 L98529 L98532 L98533 L98534 L98535 L98536 L98537 L98543 L98545 L98547 L98547 L98548 L98550 L98550 L98551 L98558 L98565 L98565 L98568 L98647 L98649 L98677 L98678 L98700 L98709 L98864 L98865 L98887 L98891 L98895 L98895 L98896 L98897 L98898 L98899 L98921 L98972 L98973 L98978 L98996

119 119 119 127 123 127 127 127 121 121 121 121 121 121 123 123 123 123 113 113 113 113 113 113 113 125 119 125 125 119 125 125 127 110 59 39 49 49 49 49 87 31 7 31 109 109 109 109 109 109 109 109 129 65 65 45 63

12 05 10 01 04 04 06 11 01 08 02 10 04 05 01 10 05 06 01 02 02 06 05 07 04 01 03 04 11 06 06 12 12 02 13 03 04 04 02 01 01

L98997 L98998 L98999 L99010 L99124 L99137 L99141 L99163 L99168 L99169 L99170 L99171 L99174 L99175 L99182 L99184 L99188 L99192 L99193 L99203 L99204 L99205 L99213 L99224 L99225 L99237 L99316 L99317 L99318 L99319 L99320 L99321 L99321 L99323 L99324 L99325 L99405 L99405 L99405 L99420 L99423 L99434 L99448 L99449 L99454 L99515 L99639 L99847 L99857 L99857 L99857 L99857 L99857 L99857 L99866 L99907 L99925

63 63 35 35 35 13 35 39 129 129 129 129 129 129 53 53 63 131 131 65 43 43 65 135 135 137 19 19 19 19 33 33 35 19 15 15 119 121 125 45 43 51 35 33 25 127 63 35 119 121 123 125 127 129 125 111 107

02 03 28

908484/BP0615

01 37 18 01 05 19 09 09 09 10 06 28 04 23

146

19 02

Part No.

Page No.

Ref. No.

L99927 L99928 L99929 L99969 P470079 P471370 P471997

107 107 107 59 31 57 107

03 02 02 09 08 05 04

02 01 03 12 05 06 07 20 27 16 01 01 30 12 13 29 05 05 01 10 12 07 01 02 09 13 09 07 06 07 11 02 05 24 04 03 03 03 03 04 05 04 03

PRINTED IN U.S.A.

Torque Specifications Use these torque values when tightening Mustang hardware (excluding: Locknuts and Self-tapping, Thread-forming and Metal Screws) unless otherwise specified.

Grade 5

Grade 8

Unified National Thread

Grade 2 Dry

Lubed

Dry

Lubed

Dry

Lubed

8-32 8-36 10-24 10-32 1/4-20 1/4-28 5/16-18 5/16-24 3/8-16 3/8-24 7/16-14 7/16-20 1/2-13 1/2-20 9/16-12 9/16-18 5/8-11 5/8-18 3/4-10 3/4-16 7/8-9 7/8-14 1-8 1-14

19* 20* 27* 31* 66* 76* 11 12 20 23 32 36 35 40 55 60 75 85 130 150 125 140 190 210

14* 15* 21* 23* 50* 56* 9 9 15 17 24 27 35 40 55 60 75 85 130 150 125 140 190 210

30* 31* 43* 49* 9 10 17 19 30 35 50 55 75 90 110 120 150 180 260 300 430 470 640 710

22* 23* 32* 36* 75* 86* 13 14 23 25 35 40 55 65 80 90 110 130 200 220 320 360 480 530

41* 43* 60* 68* 12 14 25 25 45 50 70 80 110 120 150 170 220 240 380 420 600 660 900 1000

31* 32* 45* 51* 9 10 18 20 35 35 55 60 80 90 110 130 170 180 280 320 460 500 680 740

Metric Course Thread

Grade 8.8 Dry

Lubed

Dry

Lubed

Dry

Lubed

M6-1 24M8-1.25 M10-1.5 M12-1.75 M14-2 M16-2

8 19 37.5 65 103.5 158.5

6 14 28 48 76.5 117.5

11 27 53 91.5 145.5 223.5

7 20 39 67.5 108 165.5

13.5 32.5 64 111.5 176.5 271

10* 24* 47 82 131 200

Grade 10.9

Grade 12.9

* All torque values are in lb-ft except those marked with an * which are in lb-in.

For metric torque value (Nm) muiltiply lb-ft x 1.355 or lb-in value x 0.113.

Manitou Americas, Inc. P. O. Box 179 West Bend, WI 53095-0179 U.S.A www.mustangmfg.com

908484/BP0615

© 2015 Manitou Americas, Inc. All rights reserved.

PRINTED IN U.S.A.