SF224,235

25. WASHING OF THE MACHINE

CAUTION: If you use compressed water, be sure to use in accordance with this operator’s manual and safety label. In case of irregular use, it may cause personal injury and damage to the machine.

CAUTION: Set the spraying nozzle in ‘spread’ position and keep the distance away from the machine more than 60 cm in order to avoid damage to the machine. Especially, be care not to hit the compressed water to electrical parts and label.

Unsuitable washing may cause the following accidents;

1. Fire as a result of short circuit or the damage to the electrical parts.

2. Oil leakage as a result of the damage to the hydraulic hose.

3. Damage to the machine.

(1) Label peeling.

(2) Accident occurs by the damaged electrical parts, engine, radiator, and interior.

(3) Lubber parts (tire, seal) and resin parts are damaged.

(4) Paint peeling.

26. FILLING DIAGRAM

Ref.NoFilling pointsLubricantsQuantity: liter

1RadiatorLLC50%2.5

2Reserve tankLLC50%1.0

3EngineEngine Oil2.4-3.5(SF224), 3.0-4.8(SF235).

4Rear axle Gear oil #803.7

5Transmission caseShell donax TD16.0

6Knuckle spindlesGreaseAs required

7HST pedal hubGreaseAs required

8Brake shaftGreaseAs required

9Fuel tankDiesel fuel40.0

10Brake PedalGreaseAs requried

11Diff lock pedalGreaseAs requried

12Chain caseGear oil #801.6

134WD caseGear oil #800.2

27. PERIODICAL INSPECTION TABLE

: Inspect, replenish or adjust : Replace : Clean or wash : Replacement or servicing at authorized service facility recommended.

IMPORTANT: • Above mentioned service intervals are for normal usage. If working conditions are harder, earlier service is recommended.

• If special skill or special tool are required or you feel difficulty in maintenance, consult your dealer.

CHAPTER 9. STORAGE

■ DAILY AND SHORT TERM STORAGE

a. Clean the front mower.

IMPORTANT:When washing the front mower, avoid splashing compressed water directly to the electric parts, and fuel fillers. Remove the starter key and cap the switch key hole to prevent short circuits.

b. Lower the mower deck on the ground.

CAUTION: A lifted up mower deck may go down unexpectedly if the lift lever is operated by children or unauthorised people, which may lead to serious accidents.

c. The front mower should be stored indoors if possible. When it has to be left outdoors, cover it with tarpaulin or the like.

WARNING: When covering the front mower with tarpaulin, wait until heated components such as the engine, muffler, etc. have completely cooled down . Otherwise a fire may be caused.

d. When the ambient temperature is very low, remove the battery and store it in a warm shaded dry place. This will help to easy start of the engine the following morning.

CAUTION: Remove the starter key without fail before storage.

WARNING: Always clean up accumulated grass or leaves around heated parts, such as muffler, engine and brake, and around terminals of battery, which have possibility of leakage of electricity by water. Otherwise, it may cause a fire.

■ LONG TERM STORAGE

a. Clean the front mower and correct all troubles such as repair, replacement of defective parts, readjustment, etc.

b. Top up the fuel tank and close the fuel cock.

c. Replace the engine oil with new and let the engine idle for about 5 minutes to lubricate every part in the engine sufficiently.

d. Lubricate all lubrication points.

e. Grease up all greasing points.

f. Check bolts and nuts for looseness and re-tighten loose ones.

g. Inflate each tire a little higher than specified.

h. Dismount the mower deck or lower it to the ground.

CAUTION: A lifted up mower deck may go down unexpectedly if the lift lever is operated by children or unauthorised people, which may lead to serious accidents.

i. Cover the front mower with tarpaulin or the like in order to protect it from rainfall and dust.

WARNING: When covering the front mower with tarpaulin, wait until heated components such as the engine, muffler, etc. have completely cooled down . Otherwise a fire may be caused.

j. Remove the battery, charge it, and store it in a shaded dry place with no access to children.

k. Charge the battery completely every month.

CAUTION: Remove the starter key without fail before storage.

■ OPERATION AFTER A LONG TIME OF STORAGE

a. Perform the pre-operation inspection without fail.

b. Let the engine idle for about 30 minutes before applying any load, to ensure maximum engine performance and service life.

WARNING: Provide sufficient ventilation for exhaust fumes when starting the engine, because such fumes are very poisonous.

1. ENGINE

CHAPTER 10.

Troubles

・ Starter motor does not work.