Gehl Scavenger Spreaders1329 & 1330 Parts Manual(907523C) - PDF DOWNLOAD

1329 & 1330

Form No.

907523 Revision C

Scavenger Spreaders





PARTS MANUAL

Introduction When ordering service parts, specify the correct part number, full description, quantity required, the unit model number and serial number.

The Spreader model and serial numbers are on a plate located on the front, left corner of the tank. “Right” and “left” are determined from a position standing behind the Spreader and facing in the direction of travel. From this position, the expeller is on the “right” side.

Gehl Company reserves the right to make changes or improvements in the design or construction of any part of the unit without incurring the obligation to install such changes on any previously delivered units.

NOTE:

On original tire replacement, Company policy prohibits the sale of replacement tires for all Gehl machinery. Replacement wheel sets are available and tire size information is called out with the wheel sets to facilitate replacement tire selection. ALL REPLACEMENT TIRES MUST BE PURCHASED LOCALLY. Refer to the abbreviations table located on this page for the various fastener descriptions. Standard attaching hardware torque values are also provided on the inside back cover.

Items shown in the parts list that do not have Reference Numbers are shown for reference purposes only and are NOT available for purchase.

Unless otherwise specified, all cap screws or bolts are Grade 5, cadmium or zinc plated; hexagon nuts for Grade 5 screws or bolts are Grade B; hexagon nuts for other screws or bolts are Grade A.

NOTE:

The following abbreviations may be used herein: ASSD - Assembled ASSY - Assembly CB - Carriage Bolt CCW - Counterclockwise CP - Cotter Pin

CS CTR CW DEG DIA FCS FHMS FL FLN FLS FW GA GR HD HN INCL JT LFLN LG LH LN LW LT M MM/mm NF PB PTO RH RHMS RPM RT SERR SHCS SHSS SN SQ T TFS THMS THRD WLDMT

- Cap Screw (Hexagon Head) - Center - Clockwise - Degree - Diameter - Flanged Cap Screw - Flat Head Machine Screw - Flanged - Flanged Lock Nut (Hexagon) - Flanged Lock Screw (Hexagon) - Flat Washer - Gauge - Grade - Hard or Head - Hex Nut - Includes - Joint - Large Flanged Lock Nut (Hexagon) - Large - Left Hand - Lock Nut - Lock Washer - Left - Metric - Millimeter - National Fine - Plow Bolt - Power Take Off - Right Hand - Round Head Machine Screw - Revolutions Per Minute - Right - Serrated - Socket Head Cap Screw - Socket Head Set Screw - Serial Number or Slotted Nut - Square - Tooth or Teeth - Thread Forming Screw - Truss Head Machine Screw - Thread - Weldment

TABLE OF CONTENTS Subject

Page No.

Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Inside Front Cover Decal Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3 Auger, Liner & Slides . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5 Auger & Expeller Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7 Expeller & Discharge Gate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-9 Hydraulics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-13 Guards & Shields . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-15 Tandem Axles (Standard 12K & Heavy-Duty 15K) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-17 Tandem Axles (w/Brakes) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18-19 Tandem Axles (Brake Hydraulics) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20-21 Transport Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22-23 Tank Repair Panels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 Component Parts Listing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25-31 Hydraulic Cylinders . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25 Gearbox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26-27 Auger . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28 PTO . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29-30 Hitchjacks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31 Options & Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32-37 Safety Chain (20-Ton) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 Splash Guards & Rails . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33 Solids Spill Guards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34 Chain Oiler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 Lubeminder System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36 Hydraulic Lid Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37-41 Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42 Numerical Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43-47 Hydraulic Fitting Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48 Standard Hardware Torque Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Inside Back Cover

Printed in U.S.A.

1

907523/CP0605

DECAL LOCATIONS GENERAL INFORMATION

PAINT NOTICE Use this list to order paint for refinishing: 906315 One Gal. AG Red 906324 One Qt. Light Grey 906316 6 (12 oz. Spray Cans) AG Red 906325 6 (12 oz. Spray Cans) Light Grey

Decal locations information is provided to assist in the proper selection and application of new decals, in the event the original decals become damaged or the machine is repainted. Refer to the listing for the illustration reference number, part number, description and quantity of each decal provided in the kit. Refer to the appropriate illustrations for replacement locations.

The decal kit number for the 1329 & 1330 Scavenger Spreaders is 141263. The set includes the following:

NOTE: Refer to the SAFETY Chapter for information on the safety decals in the decal kit.

To ensure proper selection for correct replacement decals, compare all of the various close-up location photographs to your machine BEFORE starting to refinish the unit. Then circle each pictured decal (applicable to your machine) while checking off its part number in the listing. After you have verified all the decals needed for replacement, set aside unneeded decals for disposal. The decal kit number for safety decals in the French language is 174812.

NEW DECAL APPLICATION Surfaces MUST be free from dirt, dust, grease and other foreign material before applying the new decal. To apply a solid-formed decal, remove the smaller portion of the decal backing paper and apply this part of the exposed adhesive backing to the clean surface while maintaining proper position and alignment. Slowly peel off the other portion of the backing paper while applying hand pressure to smooth out the decal surface.

WARNING ALWAYS observe safety precautions shown on decals. If decals become damaged, or if the unit is repainted, replace the decals. If repainting, BE SURE that ALL decals from the kits that apply to your machine are affixed to your unit.

907523/CP0605

Ref. No. 1 2 3 4 5 6

Part No. 145234 060510 060511 145216 091444 093020

7 8 9

093208 093366 093367

10 11 12 13 14 15 16 17 18 19 20 21 22 23 ** ** ** **

093373 093457 093638 093653 093639 094912 094913 094951 115628* 120399 120740 141249 122736 145217 093202 093793 120399 157332

Description & Quantity SMV Decal Jack Storage Position Jack Lifting Position Red Reflector Strip (2 Places) DANGER - Rotating Drive Line Lubrication Symbol (7 Places W/Tandem Axles, 5 Places W/Single Axles) Rotating Spiral Symbol IMPORTANT - Store Manual Here WARNING - Owner’s Responsibility & Read Manual WARNING - General Safety Precautions WARNING - Keep Door Closed DANGER - Rotating Expeller (2 Places) WARNING - Rotating Drive Line DANGER - Manure Gas Colorbar (2 Places) GEHL (2 Places, All models) Made in USA Decal - All Model Numbers (2 Places) DANGER - Rotating Auger (3 Places) Scavenger Decal (2 Places, All models) Decal - Patent GEHL (2 Places, All models) Amber Reflector Strip (5 Places) DANGER - Electrical DANGER - Manure Gas for Lid On DANGER - Auger WARNING - Valve Lockout

* 115628 Model number decal covers all Scavenger model numbers. ** Not included in decal kit. Decals only on units with optional hydraulic lid 808951. See Options & Accessories chapter for decal locations.

2

Printed in U.S.A.

22 15

18

19

16

4

4 20

6

Both Sides

1

23

7

Rear View

2

22

21

3

20

23

19 17

10

13

14

9 15 19

16

5

18 12

12

Both Sides

23 6 6

6

11

Front View

6

Printed in U.S.A.

6

8

3

907523/CP0605

1329 & 1330 - AUGER, LINER & SLIDES

20 5

19 26

12

28 22 11

23

18 28 26

30

Rear View for Clarity

15 14 26 24 28

6 1 17

4

24

16 21 13

29

14 2

7 6

9 3

10

32 31

Items 7 & 17, 8 & 16 to be adhered together with 3M #90, NAPA #08088 adhesive, or equivalent

907523/CP0605

25

27

8

2 32

4

33

Printed in U.S.A.

1329 & 1330 - AUGER, LINER & SLIDES Ref. No. 1 2

Part No. 053894 061845d 142302

3

061847

4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31

061848 070856 075105 083228 083252 083255 083256 088749 094842 098088 120334 120527 120531 120532 120600 120590a 141782 606676 650221 650490 650773 651187 653010 654014 654026 654034 655016 061846

32

065185b 142303c

33

142301

Description

1329

FITTING/GREASE CONNECTOR/STRAIGHT TUBE (INCL 31) (BEFORE SN4714-1329) CONNECTOR (AFTER SN4713-1329 & ALL 1330) ADAPTER/BULKHEAD (BEFORE SN4714-1329) NUT/BULKHEAD ADAPTER FLN 3/8 FITTING/GREASE LINER/REAR LINER/FRONT TRUNNION/ASSY BUSHING/BRONZE COLLAR/SET (INCL 22) LINER/TANK BEARING/FIBER AUGER PLATE/ADJUSTMENT COVER/TANK REAR ASSY SLIDE/AUGER ASSY FRONT SLIDE/AUGER ASSY REAR ROD/INDICATOR AUGER/ASSY RETAINER/LINER (7 SLOTS) BUSHING/OILITE SHSS 1/2X1/2 CS 3/8X1 CB 3/8X1-1/2 CS 3/4X1-3/4 GR8 HN 3/8 FW 3/4 LW 3/8 LW 3/4 CP 3/16X1 NUT/COMPRESSION (BEFORE SN4714-1329) KIT/GREASE TUBING (BEFORE SN4714-1329) KIT/GREASE LINE (AFTER SN4713-1329 & ALL 1330) ELBOW/90 DEG (AFTER SN4713-1329 & ALL 1330)

Quantity 1330

5 10

5 -

6

6

5

-

5 14 5 1 1 1 1 1 1 1 8 1 1 1 1 1 2 2 2 4 16 2 24 2 24 2 2 10

5 5 5 1 1 1 1 1 1 1 8 1 1 1 1 1 2 2 2 4 16 2 24 2 24 2 2 -

5

-

5

5

4

4

a) For Auger repair see Component Parts Listing page titled Auger. b) Kit contains 5-ft Steel Tubing, two 061846 Compression Nuts and one 061844 Compression Nut. c) Kit contains 3-ft Nylon Tubing, one 142301 Elbow and one 142302 Connector. d) For Compression Nut order 061846.

Printed in U.S.A.

5

907523/CP0605

1329 & 1330 - AUGER & EXPELLER DRIVE

39

9 6 45

44 47

33

8

21

50

31

8 18 43

19

20

1

26

49

24

27

5

13 17

5 44

30

2

17

40

23

20

47 6

30

5

7 1 18

28 29

3

45 39

48

10

42

12 14

10

36

6

25 34 35

Jackshaft Sprocket Drive Chain

22 Auger Drive Chain

32

38

41 46 4 14

32 Expeller Drive Chain

37

41 46 4 14 11 16

16 11

907523/CP0605

6

15

Printed in U.S.A.

1329 & 1330 - AUGER & EXPELLER DRIVE Ref. No.

Part No.

Quantity 1329 1330

Description

1 2 3 4 5 6 7 8 9 10

B11433A 053894 056230 057557 064331 071703 080646 080834 080846 081135

HOOK-S FITTING/GREASE KEY/SQUARE 3/8 FW 17-32 LN 3/4 LN 3/8 SPRING/EXTENSION FW 2-17/32 BRACE/JACKSHAFT SPACER/PTO

2 1 1 2 3 3 1 6 1 3

2 1 1 2 3 3 1 6 1 3

11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

082022a 083254 083259 083281 083283 083289 091918 095026 095027 099242 120331b 120332 120339 120341 120344 120347 120539 120604 120615 128015

SPROCKET/DRIVE (#80X14T) SPACER JACKSHAFT/ASSY FW 1.760/1.775 SPECIAL SPACER FW 1.760/1.775 SPECIAL SPROCKET/IDLER#80X12T BOLT/EYE FW .780 SQ ID BUSHING/MACH 3/4X1-1/4 SPROCKET/JACKSHAFT ASSY (#80X70T, #140X11T) SPROCKET/ASSY 140B54 IDLER ARM ASSY IDLER/ASSY CHAIN/ROLLER #140X77 SPRING/EXTENSION ROLLER/IDLER SHIM/TRANSMISSION SPROCKET/80B17 FW 1-1/32 SPECIAL

2 1 1 6 1 AR 2 2 1 7 1 1 1 1 1 1 1 4 1 AR

2 1 1 6 1 AR 2 2 1 7 1 1 1 1 1 1 1 4 1 AR

31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50

NSc 500195 570000 601155 601237 056640 606662 606663 650307 650492 650495 651090 651292 653021 654006 654030 654032 654034 655020 080605

GEARBOX/1000 RPM COUPLER/PLAIN (#80) FITTING/GREASE LINK/OFFSET (#140) LINK/CONNECTOR (#140) EXT.RETAIN.RING(SEEBEAR.).109 THK X CHAIN/ROLLER #80X98 CHAIN/ROLLER #80X82 CS 5/8 X 1-1/2 CS 3/8 X 2-1/2 CS 1/2 X 1-1/4 CS 3/4 X 2 GR8 CB 3/4 X 3 HN 5/8 FW 3/8 LW 1/2 LW 5/8 LW 3/4 CP 3/16 X 1-1/2 BUSHING/BRONZE (REQUIRES BORE SIZING AFTER INSTALLATION)

1 2 1 1 1 1 1 1 14 1 2 8 1 14 2 2 14 8 3 2

1 2 1 1 1 1 1 1 14 1 2 8 1 1 2 2 14 8 3 2

a) See Operator’s Manual Operation chapter for optional Sprockets and their function. b) Includes Qty. 2 of 080605 2-1/2 X 3” Bronze Bush 3” W/Grease G. c) Not available as a complete assembly. For individual parts, see Component Parts Listing page titled Gearbox.

Printed in U.S.A.

7

907523/CP0605

1329 & 1330 - EXPELLER & DISCHARGE GATE 15 2 28 26

6

30 28

18

17

19 1

3 32 29 14

22

5

16

21 29

20

5

1 19

3

17 5

18 29 2

31 27

10

22

11

24 10

12 32 33 13

25

7

8

9

28 23 32 34 4

907523/CP0605

8

Printed in U.S.A.

1329 & 1330 - EXPELLER & DISCHARGE GATE Ref. No.

Part No.

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

R13216 071703 071706 076373 081380 082010 094474 120240 120245 120249 120544 120587 120725 120742 120751 141247 520194 520195 570002 650490 650495 650569 650553 650786 651100 653010 653018 654006 654009 654026 654030 210-19470 210-19530 380-13297

Printed in U.S.A.

Quantity 1329 1330

Description HOUSING/BEARING LN 3/8 LN 1/2 PIN/RETAINER FLS 5/16 X 3/4 WIPER/RUBBER TOOTH/EXPELLER PAN ASSY PANEL/ASSY ANGLE/GATE RETAINER GATE/ASSY COVER/SLOT ASSY DISCHARGE EXPELLER/ASSY 4 SECTION PLATE/COVER REAR STRIP/HOLDDOWN BAR/INDICATOR BEARING/BALL COLLAR/BEARING FITTING/GREASE CS 3/8 X 1 CS 1/2 X 1-1/4 CS 1/2 X 1-3/4 CP 1/8 X 3/4 CB 3/8 X 1-1/4 CB 1/2X1-1/4 GR8 HN 3/8 HN 1/2 FW 3/8 FW 1/2 LW 3/8 LW 1/2 FLN 5/16 FLN 1/2 (LARGE FLANGE) SPRING

2 6 8 2 16 1 12 1 1 2 1 1 1 1 1 1 2 2 2 1 2 8 2 8 24 8 2 15 8 8 2 16 24 2

9

2 6 8 2 16 1 12 1 1 2 1 1 1 1 1 1 2 2 2 1 2 8 2 8 24 8 2 15 8 8 2 16 24 2

907523/CP0605

1329 & 1330 - HYDRAULICS (AFTER SN5338-1329)

7 35 11

12

24

22

16 15

6

5

32 2 28 17

14 33

30

22 26

23 20

35

10

27

11 13

21 5 20 17

18

31 3 8

9 1

21

29 25 19

34

5 8

4

907523/CP0605

10

Printed in U.S.A.

1329 & 1330 - HYDRAULICS (AFTER SN5338-1329) Ref. No.

Part No.

Description

Qty.

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

018453 054994 055021 056080 068938 071700 071701 071703 074091 076099 076581 079098 080629 087107 088904 094164

CLAMP/HOSE UNION/HYD FITTING CLAMP/HOSE QUICK-DISCONNECT (MALE) ELBOW/HYD FITTING 90 DEG LN 1/4 LN 5/16 LN 3/8 TIE/NYLON COTTER/HAIR PIN PIN/CLEVIS PLATE/TWIN COVER PIN/GATE CYLINDER UNION/HYD FITTING CLAMP/TUBE VALVE/DIVIDER COMBINER

1 1 6 4 3 2 3 7 4 4 4 3 2 2 3 1

17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35

095145a 095147 095148 095149 095150 095151 114824 115607 118757 119257 119258 119694 120362a 650019 650490 650692 654002 654006 655022

CYLINDER/HYDRAULIC 2 X 8 HOSE/ASSY HOSE/ASSY HOSE/ASSY HOSE/ASSY HOSE/ASSY ELBOW/HYD FITTING 90 DEG CHANNEL/MOUNT GROMMET ELBOW/JIC TEE/JIC9 TUBE CYLINDER/HYD 2 X 16 CS 1/4 X 4 CS 3/8 X 1 CS 5/16X1-3/4 FW 1/4 FW 3/8 CP 3/16 X 1-3/4

2 1 1 2 2 2 1 1 1 2 1 4 1 2 1 3 2 1 4

a) See Component Parts Listing page entitled Hydraulic Cylinders.

Printed in U.S.A.

11

907523/CP0605

1329 - HYDRAULICS (BEFORE SN5339-1329)

7 2 11

12 22 15

16

28 17

14

22 26 27 20

2

10

27

11 13

21 5 20 17

18

23 3 8

9 1

21

24 25 19

6

5 8

4

907523/CP0605

12

Printed in U.S.A.

1329 & 1330 - HYDRAULICS (BEFORE SN5339-1329) Ref. No.

Part No.

Description

Qty.

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

018453 655022 055021 056080 068938 654006 071701 071703 074091 076099 076581 079098 080629 087107 088904 650692

CLAMP/HOSE CP 3/16 X 1-3/4 CLAMP/HOSE QUICK-DISCONNECT (MALE) ELBOW/HYD FITTING 90 DEG FW 3/8 LN 5/16 LN 3/8 TIE/NYLON COTTER/HAIR PIN PIN/CLEVIS PLATE/TWIN COVER PIN/GATE CYLINDER UNION/HYD FITTING CLAMP/TUBE CS 5/16X1-3/4

1 4 6 4 2 1 3 7 4 4 4 3 2 2 3 3

17 18 19 20 21 22 23 24 25 26 27 28

095145a 095147 095148 095149 095150 095151 650490 120362a 118757 119257 119258 119694

CYLINDER/HYDRAULIC 2 X 8 HOSE/ASSY HOSE/ASSY HOSE/ASSY HOSE/ASSY HOSE/ASSY CS 3/8 X 1 CYLINDER/HYD 2 X 16 GROMMET ELBOW/JIC TEE/JIC9 TUBE

2 1 1 2 2 2 1 1 1 2 1 4

a) See Component Parts Listing page titled Hydraulic Cylinders.

Printed in U.S.A.

13

907523/CP0605

1329 & 1330 - GUARDS & SHIELDS 22 37

34 36

18 10 29

14

20 12

33 3

9 6

23

3

17

38

4

1

38 8

24 31

35 33

8

27

19 21

25

3

26 32

8 31

39

35 13 15 11

5

16 7

33 2 28

907523/CP0605

14

30

Printed in U.S.A.

1329 & 1330 - GUARDS & SHIELDS Ref. No.

Part No.

Quantity 1329 1330

Description

1 2 3 4 5 6 7

059272 064331 070648 071700 071703 075274 170695a

HOLDER/SHEARBOLT LN 3/4 FLN 5/16 LN 1/4 LN 3/8 RIVET/BLIND JACK/ASSY (HAMMERBLOW)

1 4 19 4 1 4 1

1 4 19 4 1 4 1

8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

082027a 081380 091899 092665 110032 111421 116786 120291 120618 120755 127119 141811 142097 142098 142102 142368b

JACK/ASSY (THURSTON) FLS 5/16 X 3/4 HOOK/RUBBER PIN/CLEVIS SUPPORT HYD HOSE CLEVIS/BRACKET BRACKET/PIVOT PROP ROD ASSY ROD/PTO SUPPORT HITCH/ASSY KIT/8 SHEARBOLTS GR9 (4 HELD IN BOLT HOLDER) PIN/HINGE PANEL/RT PANEL/LT SHIELD/LT COVER/FRONT ASSY

1 19 2 2 1 2 1 1 1 1 4 2 1 1 1 1

1 19 2 2 1 2 1 1 1 1 4 2 1 1 1 1

23

142371c

SHIELD/FRONT ASSY

1

1

24

142372d

SHIELD/ASSY PTO

1

1

25 26 27 28 29 30 31 32 33 34 35 36 37 38

142373e 650216 650490 650491 650590 651090 653010 653038 654006 654009 654026 655016 220-10238 420-19509

SHIELD/RT SHSS 3/8 X 3/4 CS 3/8 X 1 CS 3/8 X 1-1/4 CP 1/16 X 1/2 CS 3/4 X 2 GR8 HN 3/8 JN 3/8 FW 3/8 FW 1/2 LW 3/8 CP 3/16 X 1 PIN STOP/RUBBER

1 2 2 1 2 4 3 2 7 2 3 2 2 3

1 2 2 1 2 4 3 2 7 2 3 2 2 3

39

NS f

UNIVERSAL DRIVE ASSEMBLY

1

1

a) See Component Parts Listing page titled Hitchjacks for individual parts. b) Includes 093653 & 120399 Decals. c) Includes 093367 & 093373 Decals. d) Includes 080247 Decal. e) Includes 093638 Decal. f) NOT sold as a complete assembly. See Component Breakdowns page titled PTO for individual parts.

Printed in U.S.A.

15

907523/CP0605

1329 & 1330 - TANDEM AXLES (STANDARD 12K & HEAVY -DUTY 15K) 18

12

14

13 23

3

10 15 1

17 5

16

4 6 21

9

11 8 20 22

7

19

2

24

907523/CP0605

16

Printed in U.S.A.

1329 & 1330 - TANDEM AXLES (STANDARD 12K & HEAVY -DUTY 15K) Ref. No. 1 2 3 4 5 6 7 8 9 10

11 12 13 14 15

16 17 18 19 20 21 22 23 24

Part No.

Quantity 1329 1330

Description

045581 070755 173477 071706 112190 078943 112191 167021 173528 120408 172322 120434 120538 120565 173230 120566 173231 120617 120575 120576 120577 141266a

VALVE/TIRE FW 1-9/32 SPECIAL FW 1.25 HT LN 1/2 CUP/BEARING BEARING/CUP 15K HEAVY-DUTY AXLE CONE/BEARING BEARING CONE 33275 15K HEAVY-DUTY AXLE BOLT/WHEEL 3/4X2-3/4 F HUB/12K SUBASSY W/BRAKE HUB/15K SUBASSY HEAVY-DUTY AXLE CONE/BEARING NUT/FLANGE 3/4-16 AXLE/TANDEM RT 15K HEAVY-DUTY AXLE/TANDEM RIGHT (NOT SHOWN) AXLE/TANDEM LT (NOT SHOWN) 15K HEAVY-DUTY AXLE/TANDEM LEFT (NOT SHOWN) CAP/HUB BUSHING/NYLON WASHER/RETAINER TUBE/RETAINER WHEEL/W18C X 16.1

4 8 8 8 4 4 4 4 40 4 4 4 40 1 1 1 1 4 2 4 2 4

4 8 8 8 4 4 4 4 40 4 4 4 40 1 1 1 1 4 2 4 2 4

141268b 142496C 141853 141827 078947 142369 174735 570002 075105 120433 650484 650640 651381 651277 654002

WHEEL/ASSY 13.5 X 22.5 RIM/ASSY 15 X 20 10 BOLT RIM/24.0 X 22.5 15K 10BOLT HEAVY-DUTY AXLE SEAL SEAL/OIL 15K HEAVY-DUTY AXLE KIT/SPINDLE REPAIR KIT/SPINDLE REPAIR 15K HEAVY-DUTY AXLE FITTING/GREASE ZERK, GREASE ST 1/8 NPT ST 15K HEAVY-DUTY AXLE CUP/BEARING CS 5/16 X 1/2 CP 1/4 X 2-1/2 SN 1-1/4 CS 1/2X1-1/2 GR8 FW 1/4 AWZY

4 4 4 4 4 4 4 2 6 4 16 4 4 8 16

4 4 4 4 4 4 4 2 6 4 16 4 4 8 16

a) Used with 21.5L x 16.1 14-ply tires. b) Used with 18.0 x 22.5 tires. c) Used with 49 x 17 x 20 recapped aircraft tires with implement tread.

Printed in U.S.A.

17

907523/CP0605

1329 & 1330 - TANDEM AXLES (W/BRAKES)

17

23 16

15 23

4

5

16 17 8 9 31

32

3 25

19

33

1

30

28

33 20

22 21

18

7 6 27

10 12 29

2

24 13 11

26 14

907523/CP0605

18

Printed in U.S.A.

1329 & 1330 - TANDEM AXLES (W/BRAKES) Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

20 21 22 23 24 25 26 27 28 29 30 31 32 33

Part No.

Quantity 1329 1330

Description

045581 070755 071706 093995 093996 112190 112191 112208 113247 173528 120408 120434 120538 120617 120575 120576 120577 141274 141266a

VALVE/TIRE FW 1-9/32 SPECIAL LN 1/2 AXLE/TANDEM RT AXLE/TANDEM LT CUP/BEARING CONE/BEARING KIT/CYLINDER REPAIR SHOE/BRAKE ASSY BOLT/WHEEL 3/4X2-3/4 F HUB/12K SUBASSY W/BRAKE CONE/BEARING NUT/FLANGE 3/4-16 CAP/HUB BUSHING/NYLON WASHER/RETAINER TUBE/RETAINER FLANGE/BRAKE WHEEL/W18C X 16.1

4 4 8 1 1 4 4 4 4 40 4 4 40 4 2 2 2 4 4

4 4 8 1 1 4 4 4 4 40 4 4 40 4 2 2 2 4 4

141268b

WHEEL/ASSY 13.5 X 22.5

4

4

142496c 158573 141827 142369 570002 120433 606127 606128 650484 650640 650858 651381 651011 651277 653019 654030

RIM/ASSY 15 X 20 10 BOLT DRUM/BRAKE 13 X 2.5 SEAL KIT/SPINDLE REPAIR FITTING/GREASE CUP/BEARING BRAKE/ASSY RH (INCL 8 & 9) BRAKE/ASSY LH (INCL 8 & 9) (NOT SHOWN) CS 5/16 X 1/2 CP 1/4 X 2-1/2 CS 1/2X1-1/2 NF SN 1-1/4 CS 1/2X1 NF CS 1/2X1-1/2 GR8 HN 1/2 NF LW 1/2

4 4 4 4 2 4 2 2 16 4 16 4 32 8 16 48

4 4 4 4 2 4 2 2 16 4 16 4 32 8 16 48

a) Used with 21.5L x 16.1 14-ply tires. b) Used with 18.0 x 22.5 tires. c) Used with 49 x 17 x 20 recapped aircraft tires with implement tread.

Printed in U.S.A.

19

907523/CP0605

1329 & 1330 - TANDEM AXLES (BRAKE HYDRAULICS)

18

20

5

15

18

8

14 9 22

20

17

8

10 16

9

4 18 13

24

12 21 23

7 19

8

6

20

9 5 15

1

22

Return 3

11 18 Pressure

2

907523/CP0605

20

Printed in U.S.A.

1329 & 1330 - TANDEM AXLES (BRAKE HYDRAULICS) Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24

Part No. 054997 056080 067880 074091 075274 098369 115415 115416 115418 115504 142837 142943 606119 606124 606130 606170 606173 607181 607185 650985 653007 654004 654024 660044

Printed in U.S.A.

Quantity 1329 1330

Description ELBOW/HYD FITTING 90 DEG QUICK-DISCONNECT (MALE) CLAMP/HOSE TIE/NYLON RIVET/BLIND VALVE/HYDRAULIC TUBE/BRAKE LINE ASSY (125″) BRAKE LINE TEE HOSE/BRAKE HOLDER/HOSE HOSE/ASSY VALVE/RELIEF 1100 PSI ELBOW/HYD FITTING 90 DEG CLIP/BRAKE HOSE CLAMP/BRAKE LINE TUBE/BRAKE LINE ASSY (12″) TUBE/BRAKE LINE ASSY (36″) TUBE 41″/BRAKE LINE U-CLAMP 5/16 X 3/4 THREAD CUTTING SCREW HN 5/16 FW 5/16 LW 5/16 BUSHING/HEX REDUCING 1/2 TO 1/8

2 2 1 4 8 1 1 3 2 2 2 1 1 2 8 1 1 4 1 3 2 6 2 1

21

2 2 1 4 8 1 1 3 2 2 2 1 1 2 8 1 1 4 1 3 2 6 2 1

907523/CP0605

1329 & 1330 - TRANSPORT LIGHTS (AFTER SN5441-1329)

17

7

1

16

1 Amber light to be on outside, both sides.

1

12

8

12

9

13

2

13 4

5

6

8 15 10

Route harness with hydraulic lines.

1

11

14

3 Ref. No.

Part No.

Quantity 1329 1330

1 2 3 4

055648 074257 084175 156836

TIE/WIRE CLIP/CUSHIONED HALF HLN INST #10-24 MODULE/LIGHT

7 4 4 1

7 4 4 1

5 6 7 8 9 10 11 12 13 14 15 16 17

157123a 157711 159696 159697 650815 650943 651456 653005 654022 650584 170938 112917 112886

LIGHT SHIELD/LIGHT HARNESS/LIGHT HARNESS/LAMP RHMS SLT #10-24 THMS SLTD 1/4X1/2 HLN INS M5 HN 1/4 LW 1/4 FW #10 COVER PLUG/7-PIN W/CABLE HOLDER/PLUG (OPTIONAL, HARDWARE FIELD SUPPLIED)

2 2 1 2 4 4 4 4 4 4 2 1 1

2 2 1 2 4 4 4 4 4 4 2 1 1

Description

a) Replacement bulbs (Amber 1156 12V, Red 1157 12V). Obtain locally.

907523/CP0605

22

Printed in U.S.A.

1329 & 1330 - TRANSPORT LIGHTS (BEFORE SN5442-1329) 3 4 5

6 Loop excess harness & nylon tie together

6

12 1

1

7 1

11 dk dd

2 1

1 Nylon tie harness to hydraulic lines 9

Auxiliary light connector

Typical both sides 10 8

Ref. No.

Part No.

1 2 3 4 5 6 7 8 9 10 11 12

074091 074257 119532 119533 119665 119666 120726 650943 653005 654022 112917 112886

Printed in U.S.A.

Quantity 1329 1330

Description TIE/NYLON CLIP/CUSHIONED HALF BEZEL/WARNING LIGHT SOCKET/WARNING LIGHT LIGHT ASSY/AMBER LIGHT ASSY/RED HARNESS/WARNING LIGHTS THMS 1/4X1/2 HN 1/4 LW 1/4 PLUG/7-PIN W/CABLE HOLDER/PLUG (OPTIONAL, MOUNTING HARDWARE FIELD SUPPLIED)

23

7 4 4 4 2 2 1 4 4 4 1 1

7 4 4 4 2 2 1 4 4 4 1 1

907523/CP0605

1329 & 1330 - TANK REPAIR PANELS

Ref. No. 1a 2

Part No. 171787 171793

Description

1329

LINER/FRONT (42.5″) LINER/TROUGH (49.6″)

1 3

Quantity 1330 1 3

a) Panel 1 is adjacent to discharge.

907523/CP0605

24

Printed in U.S.A.

1329 & 1330 - COMPONENT PARTS LISTING Hydraulic Cylinders 1 3 1 2 1

5 1 4 1 Quantity Ref. No. 1 2 3 4 5

Part No. 089693 129829 089689 128372 129831 089690 129834 073788

Printed in U.S.A.

Description KIT/SEAL KIT/SEAL RING/SNAP HEAD/HYD CYL HEAD/HYD CYL PISTON/HYD CYL PISTON/HYD CYL NUT/LOCK

25

095145 (2x8)

095146 (2x18)

120362 (2x16)

1 1 1 1 1

1 1 1 1 1

1 1 1 1 1

907523/CP0605

1329 & 1330 - COMPONENT PARTS LISTING Gearbox 21

6

25

24

5 23

7 4

3

20

33

32 31 22

34

19 29 32 31 22 26 28

11 30

10 18

17 16

22

18

11

15

30 2 15 14

18

16

15 1

16 17

907523/CP0605

26

17

Printed in U.S.A.

1329 & 1330 - COMPONENT PARTS LISTING Ref. No. 1 2 3 4 5 6 7 10 11 12 14 15 16 17 18 19 20 21 22 23 24 25 26 28 29 30 31 32 33 34

Part No. 080856 660004 083284 651113 654028 653015 606678 083288 059566 083283 083287 650569 654030 653018 606541 083282 080845 083285 083281 660044 045668 650396 654049 067847 606673 056230 083289 042858 606672 570005

Printed in U.S.A.

Quantity 1329 1330

Description GEARBOX ASSY PLUG/PIPE 1/2 SQ HD SPACER CS 7/16 X 1-3/4 LW 7/16 HN 7/16 BEARING/ROLLER SHAFT KEY SPACER SHAFT CS 1/2 X 1-3/4 LW 1/2 FW 1/2 BEARING/FLANGE SPACER GASKET/GEARBOX COVER TOP/TRANSMISSION FW 1.760/1.775 SPECIAL BUSHING/HEX RED 1/2 X 1/8 FITTING/RELIEF CS 3/8 X 1-1/4 FW 3/8 NILN 3/8 GEAR/ 1-3/4 SPUR KEY/SQUARE FW 1.760/1.775 SPECIAL FW 1-25/32 SPECIAL GEAR/ 1-3/4 SPUR FITTING/GREASE

1 1 1 4 4 4 1 1 2 1 1 12 12 12 3 1 1 1 AR 1 1 4 4 4 1 3 AR AR 1 1

27

1 1 1 4 4 4 1 1 2 1 1 12 12 12 3 1 1 1 AR 1 1 4 4 4 1 3 AR AR 1 1

907523/CP0605

1329 & 1330 - COMPONENT PARTS LISTING Auger

4

1

3 5

2

Ref. No. 1 2 3 4 5

Part No. 120590 141269 141270 120593 120594

907523/CP0605

Quantity 1329 1330

Description AUGER/ASSY PADDLE/FRONT REPAIR (WELD IN) PADDLE/REAR REPAIR (WELD IN) SHAFT/ASSY IDLE (WELD IN) SHAFT/ASSY DRIVE (WELD IN)

1 2 32 1 1

28

1 2 32 1 1

Printed in U.S.A.

1329 & 1330 - COMPONENT PARTS LISTING PTO - 1329 & 1330 19

17

16 15

1 11

8 7

14

9

9

13 10

5

18

6 3

5

4 2

Printed in U.S.A.

29

907523/CP0605

1329 & 1330 - COMPONENT PARTS LISTING Ref. No. 1 2 3 4 5 6 7 8 9 10 11 13 14 15 16 17 18 19

Part No. 173016a 173018b 088818 084248 173811 144629 094539 084241c 084239d 084238e 172986 095132 510100 173014f 084242 172594 095130 112772 045327g 112771h 112767 173017i 127119

Quantity 1329 1330

Description JOINT & TUBE HALF W/GUARD (1-3/8 X 21”) JOINT & TUBE HALF W/GUARD (1-3/4” OPTION) GUARD/PLASTIC (FOR STEEL GUARD SET ONLY) YOKE/SLIDE LOCK ASSY (1-3/8 X 21”) YOKE W/SLIDE LOCK (1-3/4” OPTION) AUTO-LOCK REPAIR KIT (1-3/8 X 21”) KIT/SLIDE LOCK REPAIR (1-3/4” OPTION) KIT/CROSS HOUSING/CENTER ASSY YOKE & TUBE/ASSY KIT/NYLON REPAIR (FOR PLASTIC GUARD SET ONLY) KIT/REPAIR (INCL REF. 09) (FOR STEEL GUARD SET ONLY) RETAINER/BEARING (FOR STEEL GUARD SET ONLY) GUARD SET BEARING/CENTRALIZER (FOR STEEL GUARD SET ONLY) KIT/NYLON REPAIR (FOR PLASTIC GUARD SET ONLY) KIT/REPAIR (INCL REF. 09) (FOR STEEL GUARD SET ONLY) YOKE & SHAFT/ASSY KIT/CENTER CROSS 35R BALL/SHEAR ASSY BALL SHEAR REPAIR KIT JOINT & SHAFT HALF W/GUARD KIT/8 SHEAR BOLTS GR 9

1 1 1 1 1 1 1 2 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1

1 1 1 1 1 1 1 2 1 1 1 1 2 1 1 1 1 1 1 1 1 1

a) Includes 173014, 172986, 084238, 084241, 084239, 084248, 144629 Auto-Lock Repair Kit (not shown), and 143007 Safety Sign (not shown). b) Includes 173014, 172986, 084238, 084241, 084239, 173811, 094539, and 143007 Safety Sign (not shown). c) Includes Qty. 2 of 570009 Fitting/Grease (not shown). d) Includes 570014 Fitting/Grease (not shown). e) Includes 570001 Fitting/Grease (long) and 570002 Fitting/ Grease (not shown). f) Includes 172986 Kit/Nylon Repair. g) Includes 570009 Zerk/Grease 1/4-28 45 Degree (not shown). h) Includes 570002 Fitting/Grease (not shown). i) Includes 091444 DANGER Decal.

907523/CP0605

30

Printed in U.S.A.

1329 & 1330 - COMPONENT PARTS LISTING 082027 Hitchjack Capacity - 8000 lbs.

Travel - 13 inches

Ref. No.

3

5

8

10

Description

Qty. Req.

082027

HITCHJACK - THURSTON . . . . . . . . 1

1

082650

PIN/BALL LOCK ASSY . . . . . . . . . . . 1

2

082649

CAP/POLY . . . . . . . . . . . . . . . . . . . . . . 1

3

082660

GEAR/12T . . . . . . . . . . . . . . . . . . . . . . 1

4

082645

KEY/SQUARE 1/4X3/4 . . . . . . . . . . . . 2

5

082659

SHAFT/PINION . . . . . . . . . . . . . . . . . . 1

6

082647

CRANK/ASSY W/GRIP . . . . . . . . . . . 1

7

082658

GEAR/18T . . . . . . . . . . . . . . . . . . . . . . 1

8

082657

SCREW/LOCK CAP . . . . . . . . . . . . . . 1

9

082656

WASHER/GEAR RETAINER . . . . . . . 1

10

082644

WASHER/SPACER . . . . . . . . . . . . . . 1

11

082655

BEARING/THRUST . . . . . . . . . . . . . . 1

12

082654

SCREW/LH ACME ASSY . . . . . . . . . 1

13

082653

TUBE/OUTER . . . . . . . . . . . . . . . . . . . 1

14

082652

PIN/RETAINING 3/8 NUT . . . . . . . . . 1

15

082651

TUBE/INNER . . . . . . . . . . . . . . . . . . . . 2

2 1

CONSISTS OF:

9

4 7

6

Part No.

11

12

13

14

THURSTON 15

170695 Hitchjack Capacity - 8000 lbs.

Travel - 13 inches

1

3

4

Ref. No.

Part No.

Description

Qty. Req.

170695

HITCHJACK - HAMMERBLOW . . . . 1

1

082650

PIN/BALL LOCK ASSY . . . . . . . . . . . 1

2

170770

INNER TUBE/SCREW & NUT . . . . . 1

3

170771

FINAL ASSY KIT . . . . . . . . . . . . . . . . . 1

4

170772

CRANK ASSY . . . . . . . . . . . . . . . . . . . 1

CONSISTS OF:

HAMMERBLOW

2

Printed in U.S.A.

31

907523/CP0605

1329 & 1330 - OPTIONS & ACCESSORIES Safety Chain 158120 20-Ton - 1329 & 1330 5

6 7 10

1

8 9

2

11

3 4 Ref. No. 1 2 3 4 5 6 7 8 9 10 11

Part No. 650695 080894 654032 653021 653026 654034 654014 069076 651073 043912 143369

907523/CP0605

Quantity 1329 1330

Description CS 5/8X3-1/2 CLEVIS LW 5/8 HN 5/8 HN 3/4 LW 3/4 FW 3/4 FW 25/32 CS 3/4X3-1/4 GR8 FW 1-1/32 CHAIN/SAFETY

1 1 1 1 1 1 1 1 1 1 1

32

1 1 1 1 1 1 1 1 1 1 1

Printed in U.S.A.

1329 & 1330 - OPTIONS & ACCESSORIES Splash Guards & Rails

1 3

4

2

6 2 5 4

8 8

9 7

8 1

3

9 7

Ref. No. 1 2 3 4 5 6 7 8 9

Part No. 099979 099980 111347 112137 650490 650540 653010 654006 654026

Printed in U.S.A.

Quantity 1329 1330

Description SHIELD/RIGHT SHIELD/LEFT SHIELD RAIL/WOOD CS 3/8X1 CB 3/8X3-1/2 HN 3/8 FW 3/8 LW 3/8

2 2 2 2 24 8 32 56 32

33

2 2 2 2 24 8 32 56 32

907523/CP0605

1329 & 1330 - OPTIONS & ACCESSORIES Solids Spill Guards

2 4 3 1 6 7 5 3 1

2

Ref. No. 1 2 3 4 5 6 7

Part No. 141258 141259 141257 650704 653010 654006 654026

907523/CP0605

Quantity 1329 1330

Description SHIELD FRONT R.H. SHIELD L.H. SHIELD/FRONT CB 3/8X1 HN 3/8 FW 3/8 LW 3/8

2 2 2 34 34 34 34

34

2 2 2 34 34 34 34

Printed in U.S.A.

1329 & 1330 - OPTIONS & ACCESSORIES 8

14

11

17

158510 Chain Oiler (Field Installed) Attaching hardware varies 13

18 Ref. 21 1

10 5

From Tractor

20 16

2

4

20

Ref. 15

19 22

6 3

*23 * 15 9

12 7

Ref. No.

Part No.

Ref. No.

Part No.

1

055648

2

072806

TIE/WIRE . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

14

654026

TEE/HYD FITTING . . . . . . . . . . . . . . . . . . . 1

15

158729

3

HOSE/ASSY - 54″ . . . . . . . . . . . . . . . . . . . 1

091210

BRUSH/ASSY . . . . . . . . . . . . . . . . . . . . . . . 4

16

158006

U-BOLT . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

172736

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

650758

CB 1/4X3/4 . . . . . . . . . . . . . . . . . . . . . . . . . . 4

6

157982

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 4

18

653005

HN 1/4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

7

650487

CS 5/16X1 . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

079340

TIE/NYLON . . . . . . . . . . . . . . . . . . . . . . . . . 2

CS 3/8X1-1/4 . . . . . . . . . . . . . . . . . . . . . . . . 4

20

158379

TUBE/NYLON 360 . . . . . . . . . . . . . . . . . . . 1

8

650491

Description

Qty. Req.

Description

Qty. Req.

LW 3/8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

9

650510

TCS 5/16X1/2 . . . . . . . . . . . . . . . . . . . . . . . 3

21

172744a

LUBEMINDER SYSTEM . . . . . . . . . . . . . . 1

10

653007

HN 5/16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

22

158730b

HOSE/ASSY - 24″ . . . . . . . . . . . . . . . . . . . 1

11

653010

HN 3/8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

23

230-17076b

UNION/HYD FITTING . . . . . . . . . . . . . . . . 1

12

654004

FW 5/16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

13

654022

LW 1/4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

a) See following page for further breakdown. b) Use as required on certain models.

Printed in U.S.A.

35

907523/CP0605

1329 & 1330 - OPTIONS & ACCESSORIES 172744 Lubeminder System

7

6 Ref. No.

Part No.

Qty. Req.

Description

1

091213

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

172916

OILER PUMP KIT . . . . . . . . . . . . . . . . 1

3

420-21748

CLAMP . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

172743

MANIFOLD ASSY . . . . . . . . . . . . . . . . 4

5

119565 a

KIT/VALVE . . . . . . . . . . . . . . . . . . . . . . 4

6

091209

TANK/OIL . . . . . . . . . . . . . . . . . . . . . . . 1

7

112269

CAP/OIL TANK . . . . . . . . . . . . . . . . . . 1

3 1 3 4

5

a) Kit contains four Sleeve Nuts and four Ferrules.

2

907523/CP0605

36

Printed in U.S.A.

1329 & 1330 - OPTIONS & ACCESSORIES 808951 Hydraulic Lid Parts list - Inlet

26 17 31 5

21 30

8

13

25 24

25

18 12 19

33

30 33

29 2

29 30

13 30

12

33 29

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

2

071703

LN CTR 3/8 CBZY . . . . . . . . . . . . . . . . . . . 4

21

157446

COVER/TOP . . . . . . . . . . . . . . . . . . . . . . . . 2

5

084175

HLN INST #1024 CZY . . . . . . . . . . . . . . . . 4

24

157848

PLATE/LOCK . . . . . . . . . . . . . . . . . . . . . . . . 1 CS 3/8X1 C2 . . . . . . . . . . . . . . . . . . . . . . . . 6

8

089079

PIN/KLIK . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

25

650059

12

093202

DECAL/DANGER ELECTRICAL . . . . . . . . 2

26

650815

RHMS SLT #1024X3/4 CZY . . . . . . . . . . . . 4

13

093639

DECAL/DANGER MANURE GAS

..... 2

29

653010

HN 3/8 C2ZY . . . . . . . . . . . . . . . . . . . . . . . 22

17

155176

BUMPER/RUBBER . . . . . . . . . . . . . . . . . . 4

30

654006

FW 3/8 AWZY . . . . . . . . . . . . . . . . . . . . . . 28

18

156845

INLET/FILLER . . . . . . . . . . . . . . . . . . . . . . . 1

31

654017

FW #10 A . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

19

156890

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

33

654026

LW 3/8 RZY . . . . . . . . . . . . . . . . . . . . . . . . 22

Printed in U.S.A.

37

907523/CP0605

1329 & 1330 - OPTIONS & ACCESSORIES 22

808951 Hydraulic Lid Parts list - Lid/Frame

9

1 28 32 14

6 4 7

27 6

16

14

34 11

10 35

16

20

15 3 23

Ref. No.

Part No.

Ref. No.

Part No.

1

071701

LN 5/16 CBZY . . . . . . . . . . . . . . . . . . . . . . . 4

16

120399

DECAL/DANGER AUGER . . . . . . . . . . . . . 2

3 4

074090

PIN/SPRING 3/16X1-1/2 Z . . . . . . . . . . . . 4

20

157434

SUBFRAME . . . . . . . . . . . . . . . . . . . . . . . . . 1

079098

PLATE/TWIN COVER . . . . . . . . . . . . . . . . 4

22

157603

LID/TANK WELDMENT . . . . . . . . . . . . . . . 1

6

087107

CONNECTOR/UNION 37 DEG JIC . . . . . 2

7

088904

CLAMP/TUBE 2PC SET . . . . . . . . . . . . . . 4

Description

Qty. Req.

Description

Qty. Req.

23

157632

PIN/PIVOT . . . . . . . . . . . . . . . . . . . . . . . . . . 4

27

651069

FCH ELVTR BOLT 5/16X1-1/2 C2ZY . . 48

28

653007

HN 5/16 C2ZY . . . . . . . . . . . . . . . . . . . . . . 48

9

092809

SEAL/LID SIDE 6” X 185.5 . . . . . . . . . . . . 2

10

092810

.875 CD ROUND 18.87 PIN/HINGE . . . . . 3

11

092824

SEAL/LID END 6X103.7 . . . . . . . . . . . . . . . 2

32

654024

LW 5/16 RZY . . . . . . . . . . . . . . . . . . . . . . . 48

655018

CP EPSC 3/16X1-1/4 Z . . . . . . . . . . . . . . . 6

7H37

SPACER . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

14

119694

TUBE/HYDRAULIC 96.75” . . . . . . . . . . . . 4

34

15

120362

CYLINDER/HYDRAULIC 2 X 16 . . . . . . . . 2

35

907523/CP0605

38

Printed in U.S.A.

1329 & 1330 - OPTIONS & ACCESSORIES 808951 Hydraulic Lid Parts list - Frame Hardware 62

ref.

63

67 72

67

53

71 66

64

73

54 56 65

75

70 59

76 74

Ref. No.

Part No.

Description

52

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

52

071701

LN 5/16 CBZY . . . . . . . . . . . . . . . . . . . . . . . 2

66

157918

HANDLE . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

53

071703

LN CTR 3/8 CBZY . . . . . . . . . . . . . . . . . . . 4

67

157979

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

54

081374

LN SER FL 1/2 CZY . . . . . . . . . . . . . . . . . . 4

70

170691

ANGLE/SIGN . . . . . . . . . . . . . . . . . . . . . . . 1

56

092164

CS FL LOCK 1/2X1-1/4 C5ZY . . . . . . . . . 4

71

650535

CS 3/8X2-1/4 C5ZY . . . . . . . . . . . . . . . . . . 4

59

141492

VALVE/LOCKOUT . . . . . . . . . . . . . . . . . . . 1

72

650704

CB 3/8X1 C5ZY . . . . . . . . . . . . . . . . . . . . . 18

62

156727

WLDMT/LATCH . . . . . . . . . . . . . . . . . . . . . . 2

73

650733

CS 5/16X2-1/2 C5ZY . . . . . . . . . . . . . . . . . 2

63

156734

PIN/TRUNNION . . . . . . . . . . . . . . . . . . . . . 2

74

653010

HN 3/8 C2ZY . . . . . . . . . . . . . . . . . . . . . . . 18

64

156798

PIN/LOCK . . . . . . . . . . . . . . . . . . . . . . . . . . 2

75

654005

FW 3/8 AW . . . . . . . . . . . . . . . . . . . . . . . . . 18

65

157332

DECAL/WARNING VALVE LOCKOUT . . . 1

76

654026

LW 3/8 RZY . . . . . . . . . . . . . . . . . . . . . . . . 18

Printed in U.S.A.

39

907523/CP0605

1329 & 1330 - OPTIONS & ACCESSORIES 808951 Hydraulic Lid Parts list - Hydraulics

57

69

51

51 69

55

57 58 68

51 69

51 51 60 51 61

Ref. No.

Part No.

Ref. No.

Part No.

51

068938

55

091039

ELBOW/90 DEG ADJUSTABLE . . . . . . . . 7

60

154160

HOSE/ASSY . . . . . . . . . . . . . . . . . . . . . . . . 2

ELBOW/HYDR. FITT 90 DEG 6500-6-6 . 1

61

154615

57

COUPLER/MALE . . . . . . . . . . . . . . . . . . . . 2

119257

ELBOW/JIC (SPECIAL) . . . . . . . . . . . . . . . 3

68

170683

HOSE/ASSY . . . . . . . . . . . . . . . . . . . . . . . . 1

58

119258

TEE/JIC (SPECIAL) . . . . . . . . . . . . . . . . . . 1

69

170684

HOSE/ASSY . . . . . . . . . . . . . . . . . . . . . . . . 4

907523/CP0605

Description

Qty. Req.

40

Description

Qty. Req.

Printed in U.S.A.

1329 & 1330 - OPTIONS & ACCESSORIES 808951 Hydraulic Lid Parts list - Ladder

74 76

72

78

80

72

79

74 76

76

72

74

Part No.

53

071703

LN CTR 3/8 CBZY . . . . . . . . . . . . . . . . . . . 2

78

170782

LADDER ASSY . . . . . . . . . . . . . . . . . . . . . . 1

72

650704

CB 3/8X1 C5ZY . . . . . . . . . . . . . . . . . . . . . . 6

79

170796

STEP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

74

653010

HN 3/8 C2ZY . . . . . . . . . . . . . . . . . . . . . . . . 6

80

170799

BRACKET/MOUNT . . . . . . . . . . . . . . . . . . . 1

76

654026

LW 3/8 RZY . . . . . . . . . . . . . . . . . . . . . . . . . 6

81

650579

CS 3/8X1-3/4 C5ZY . . . . . . . . . . . . . . . . . . 2

Printed in U.S.A.

Ref. No.

53

Ref. No.

Description

Qty. Req.

81

41

Part No.

Description

Qty. Req.

907523/CP0605

Index A Auger, 28

C Component Breakdowns Auger, 28 Hitchjacks, 31 Hydraulic Cylinders, 25 PTO - 1329 & 1330, 29

D Decal Application, 2

907523/CP0605

Decal Kit and list, 2 Decal Locations, 2–4

H Hitchjacks, 31 Hydraulic Cylinders, 25 Hydraulics, 10–13

O Options & Accessories Safety Chain, 32 Solids Spill Guards, 34 Splash Guards & Rails, 33

42

P Paint Notice, 2 PTO - 1329 & 1330, 29

S Safety Chain, 32 Solids Spill Guards, 34 Splash Guards & Rails, 33

T Tank Repair Panels, 24 Transport Lights, 22–23

Printed in U.S.A.

1329 & 1330 - NUMERICAL INDEX Part No.

Page No.

Ref. No.

38

35

070856

7H37

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

05

Page Ref. No. No.

05

080845

27

20

084238

30

07

B11433A

07

01

071700

11

06

080846

07

09

084239

30

06

R13216

09

01

071700

15

04

080856

27

01

084241

30

05

018453

11

01

071701

11

07

080894

32

02

084242

30

11

018453

13

01

071701

13

07

081135

07

10

084248

30

03

042858

27

32

071701

38

01

081374

39

54

087107

11

14

043912

32

10

071701

39

52

081380

09

05

087107

13

14

38

06

05 30

11 02

045327

30

15

071703

07

06

081380

15

08

087107

045581

17

01

071703

09

02

082010

09

06

045581

19

01

071703

11

08

082022

07

11

088749 088818

045668

27

24

071703

13

08

082027

31

00

088904

11

15

10

088904

13

15

088904

38

07

089079

37

08

089689

25

02

089690

25

04

089693

25

01

091039

40

55

091209 091210

36 35

06 03

091213

36

01

091444

02

05

091899

15

09

091918

07

17

092164

39

56

092665

15

10

092809

38

09

092810

38

10

092824

38

11

093020 093202

02 02

06 **

093202

37

12

093208

02

07

093366

02

08

093367

02

09

053894

05

01

071703

15

05

082644

31

053894

07

02

071703

37

02

082645

31

04

054994

11

02

071703

39

53

082647

31

06

054997

21

01

071703

41

53

082649

31

02

055021

11

03

071706

09

03

082650

31

01

055021

13

03

071706

17

03

082650

31

01

055648

22

01

071706

19

03

082651

31

15

055648

35

01

072806

35

02

082652

31

14

056080

11

04

073788

25

05

082653

31

13

056080

13

04

074090

38

03

082654

31

12

056080

21

02

074091

11

09

082655

31

11

056230

07

03

074091

13

09

082656

31

09

056230

27

30

074091

21

04

082657

31

08

056640

07

36

074091

23

01

082658

31

07

057557

07

04

074257

22

02

082659

31

05

059272

15

01

074257

23

02

082660

31

03

059566

27

11

075105

05

06

083228

05

07

060510

02

02

075105

17

18

083252

05

08

060511

02

03

075274

15

06

083254

07

12

061845

05

02

075274

21

05

083255

05

09

061846

05

31

076099

11

10

083256

05

10

061847

05

03

076099

13

10

083259

07

13

061848

05

04

076373

09

04

083281

07

14

064331

07

05

076581

11

11

083281

27

22

093373

02

10

064331

15

02

076581

13

11

083282

27

19

093457

02

11

065185

05

32

078943

17

04

083283

07

15

093638

02

12

067847

27

28

078947

17

16

083283

27

12

093639

02

14

067880

21

03

079098

11

12

083284

27

03

068938

11

05

079098

13

12

083285

27

21

093653 093793

02 02

13 **

068938

13

05

079098

38

04

083287

27

14

093793

38

13

068938

40

51

079340

35

19

083288

27

10

093995

19

04

069076

32

08

080629

11

13

083289

07

16

093996

19

05

070648

15

03

080629

13

13

083289

27

31

094164

11

16

070755

17

02

080646

07

07

084175

22

03

094474

09

07

070755

19

02

080834

07

08

084175

37

05

094539

30

04

Printed in U.S.A.

43

907523/CP0605

1329 & 1330 - NUMERICAL INDEX Part No.

Page No.

Ref. No.

094842

05

12

094912

02

094913

02

094951 095026

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

115418

21

15

115504

16

115607

02

17

07

18

Page Ref. No. No.

09

120532

05

17

141268

19

19

21

10

120538

17

09

141269

28

02

11

24

120538

19

13

141270

28

03

115628

02

18

120539

07

27

141274

19

18

116786

15

13

120544

09

11

141492

39

59

05

20

095027

07

19

118757

11

25

120565

17

10

141782

095130

30

13

118757

13

25

120566

17

10

141811

15

18

17

16

095132

30

08

119257

11

26

120575

17

12

141827

095145

11

17

119257

13

26

120575

19

15

095145

13

17

119257

40

57

120576

17

13

141827 141853

19 17

21 15

095147

11

18

119258

11

27

120576

19

16

142097

15

19

14

142098

15

20

142102

15

21

142301

05

33

142302

05

02

142303

05

32

142368

15

22

142369

17

17

142369 142371

19 15

22 23

142372

15

24

142373

15

25

142496

17

15

142496

19

19

142837

21

11

142943

21

12

143369

32

11

144629

30

04

145216

02

04

145217 145234

02 02

23 01

154160

40

60

154615

40

61

155176

37

17

156727

39

62

095147

13

18

119258

13

27

120577

17

095148

11

19

119258

40

58

120577

19

17

095148

13

19

119532

23

03

120587

09

12

095149

11

20

119533

23

04

120590

05

19

095149

13

20

119565

36

05

120590

28

01

095150

11

21

119665

23

05

120593

28

04

095150

13

21

119666

23

06

120594

28

05

095151

11

22

119694

11

28

120600

05

18

095151

13

22

119694

13

28

120604

07

28

098088

05

13

119694

38

14

120615

07

29

098369

21

06

120240

09

08

120617

17

11

099242

07

20

120245

09

09

120617

19

14

099979

33

01

120249

09

10

120618

15

15

099980

33

02

120291

15

14

120725

09

13

110032

15

11

120331

07

21

120726

23

07

111347

33

03

120332

07

22

120740

02

20

111421

15

12

120334

05

14

120742

09

14

112137

33

04

120339

07

23

120751

09

15

112190

17

04

120341

07

24

120755

15

16

112190

19

06

120344

07

25

122736

02

22

112191

17

05

120347

07

26

127119

15

17

112191

19

07

120362

11

29

127119

30

19

112208

19

08

120362

13

24

128015

07

30

112269

36

07

120362

38

15

128372

25

03

156734

39

63

112767

30

17

120399

02

19

129829

25

01

156798

39

64

112771

30

16

120399

02

**

129831

25

03

156836

22

04

112772

30

14

120399

38

16

129834

25

04

156845

37

18

112886

22

17

120408

17

07

141247

09

16

112886

23

12

120408

19

11

141249

02

21

156890 157123

37 22

19 05

112917

22

16

120433

17

19

141257

34

03

157332

02

**

112917

23

11

120433

19

24

141258

34

01

157332

39

65

113247

19

09

120434

17

08

141259

34

02

157434

38

20

114824

11

23

120434

19

12

141266

17

15

157446

37

21

115415

21

07

120527

05

15

141266

19

19

157603

38

22

115416

21

08

120531

05

16

141268

17

15

157632

38

23

907523/CP0605

44

Printed in U.S.A.

1329 & 1330 - NUMERICAL INDEX Part No.

Page No.

Ref. No.

157711

22

06

157848

37

157918

39

157979 157982

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

520194

09

24

520195

66

570000

39

67

35

06

Page Ref. No. No.

17

650491

35

08

653005

23

09

09

18

650492

07

40

653005

35

18

07

33

650495

07

41

653007

21

21

570001

30

07

650495

09

21

653007

35

10

570002

09

19

650510

35

09

653007

38

28

05

26

158006

35

16

570002

17

18

650535

39

71

653010

158379

35

20

570002

19

23

650540

33

06

653010

09

26

15

31 07 05

158573

19

20

570002

30

07

650553

09

23

653010

158729

35

15

570002

30

16

650569

09

22

158730

35

22

570005

27

34

650569

27

15

653010 653010

33 34

159696

22

07

570009

30

05

650579

41

81

653010

35

11

37

29

159697

22

08

570014

30

06

650584

22

14

653010

167021

17

05

601155

07

34

650590

15

29

653010

39

74

170683

40

68

601237

07

35

650640

17

21

653010

41

74

170684

40

69

606119

21

13

650640

19

27

653015

27

06

170691

39

70

606124

21

14

650692

11

32

653018

09

27

170695

15

07

606127

19

25

650692

13

16

653018

27

17

170695

31

00

606128

19

25

650695

32

01

653019

19

32

170770

31

02

606130

21

15

650704

34

04

170771

31

03

606170

21

16

650704

39

72

653021 653021

07 32

44 04

170772

31

04

606173

21

17

650704

41

72

653026

32

05

170782

41

78

606541

27

18

650733

39

73

653038

15

32

170796

41

79

606662

07

37

650758

35

17

654002

11

33

170799

41

80

606663

07

38

650773

05

24

654002

17

24

170938

22

15

606672

27

33

650786

09

24

654004

21

22

171787

24

01

606673

27

29

650815

22

09

654004

35

12

171793

24

02

606676

05

21

650815

37

26

654005

39

75

172322

17

07

606678

27

07

650858

19

28

654006

07

45

172594

30

13

607181

21

18

650943

22

10

654006

09

28

172736

35

05

607185

21

19

650943

23

08

172743

36

04

650019

11

30

650985

21

20

654006 654006

11 13

34 06

172916

36

02

650059

37

25

651011

19

30

654006

15

33

172986

30

08

650201

05

22

651069

38

27

654006

33

08

173014

30

10

650216

15

26

651073

32

09

654006

34

06

173016

30

01

654006

37

30

650307

07

39

651090

07

42

654009

09

29

173017

30

18

650396

27

25

651090

15

30

654009

15

34

173018

30

01

650484

17

20

651100

09

25

654014

05

27

173230

17

10

650484

19

26

651113

27

04

654014

32

07

173231

17

10

650487

35

07

651187

05

25

173477

17

02

650490

05

23

651277

17

23

654017 654022

37 22

31 13

173528

17

06

650490

09

20

651277

19

31

654022

23

10

173528

19

10

650490

11

31

651292

07

43

654022

35

13

173811

30

03

650490

13

23

651381

17

22

654024

21

23

174735

17

17

650490

15

27

651381

19

29

654024

38

32

500195

07

32

650490

33

05

651456

22

11

654026

05

28

510100

30

09

650491

15

28

653005

22

12

654026

09

30

Printed in U.S.A.

45

907523/CP0605

1329 & 1330 - NUMERICAL INDEX Part No.

Page No.

Ref. No.

654026

15

35

654026

33

654026

34

654026

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

654030

09

31

655016

05

30

660044

27

23

09

654030

07

654030

19

33

655016

15

36

210 -19470

09

32

27

16

35

14

654032

07

47

655018

38

34

210 -19530

09

33

654026

37

33

654032

32

03

655020

07

49

220 -10238

15

37

654026

39

76

654034

05

29

655022

11

35

230 -17076

35

23

654026

41

76

654034

07

48

655022

13

02

380 -13297

09

34

654028

27

05

654034

32

06

660004

27

02

420 -19509

15

38

654030

07

46

654049

27

26

660044

21

24

420 -21748

36

03

907523/CP0605

Part No.

46

Page Ref. No. No.

Printed in U.S.A.

1329 & 1330 - NUMERICAL INDEX Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page Ref. No. No.

NOTES:

Printed in U.S.A.

47

907523/CP0605

907523/CP0605

48

Printed in U.S.A.

TORQUE SPECIFICATIONS NOTE:

Use these torque values when tightening hardware (excluding: locknuts and self tapping, thread forming and sheet metal screws) unless specified otherwise.

All torque values are in Lb-Ft, except those marked with an *, which are Lb-In. (For metric torque value Nm, multiply Lb-Ft value by 1.355 or Lb-In value by 0.113)

Unified National Thread

Grade 2

Grade 5

Dry

Lubed

Dry

Lubed

Dry

Lubed

8-32 8-36

19 19* 20*

14 14* 15*

30 30* 31*

22 22* 23*

41 41* 43*

31* 31 32*

10-24 10-32

27 27* 31*

21 21* 23*

43 43* 49*

32 32* 36*

60 60* 68*

45 45* 51*

1/4-20 1/4-28

66 66* 76*

50 50* 56*

9 10

75 75* 86*

12 14

9 10

5/16-18 5/16-24

11 12

9

17 19

13 14

25

18 20

3/8-16 3/8-24

20 23

15 17

30 35

23 25

45 50

35

7/16-14 7/16-20

32 36

24 27

50 55

35 40

70 80

55 60

1/2-13 1/2-20

50 55

35 40

75 90

55 65

110 120

80 90

9/16-12 9/16-18

70 80

55 60

110 120

80 90

150 170

110 130

5/8-11 5/8-18

100 110

75 85

150 180

110 130

220 240

170 180

3/4-10 3/4-16

175 200

130 150

260 300

200 220

380 420

280 320

7/8-9 7/8-14

170 180

125 140

430 470

320 360

600 660

460 500

1-8 1-14

250 270

190 210

640 710

480 530

900 1000

680 740

Metric Course Thread

Grade 8.8

8.8

Grade 10.9

Grade 8

10.9

Grade 12.9

12.9

Dry

Lubed

Dry

Lubed

Dry

Lubed

M6-1

8

6

11

8

13.5

10

M8-1.25

19

14

27

20

32.5

24

M10-1.5

37.5

28

53

39

64

47

M12-1.75

65

48

91.5

67.5

111.5

82

M14-2

103.5

76.5

145.5

108

176.5

131

M16-2

158.5

117.5

223.5

165.5

271

200



Gehl Company 143 Water Street, P.O. Box 179, West Bend, WI 53095-0179 U.S.A. www.gehl.com

907523/CP0605

2005 GEHL Company. All Rights Reserved.

Printed in U.S.A.