GEHL Mini-excavator 802 Parts Manual(908545) - PDF DOWNLOAD

Mini-excavator

PARTS MANUAL

CONSTRUCTION

802

Form No.

908545

Introduction When ordering service parts, specify the correct part number, full description, quantity required, the unit model number and serial number.

The Mini-excavator model and serial numbers are on a plate located on the lower left front outer side of the cabin (from the driver’s perspective).

OUR Company reserves the right to make changes or improvements in the design or construction of any part of the unit without incurring the obligation to install such changes on any previously delivered units.

To ensure continued safe operation, replace damaged or worn-out parts with genuine Factory service parts, BEFORE attempting to operate this equipment.

Refer to the abbreviations table located on this page for the various fastener descriptions.

In the exploded view parts list, Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in that section. Refer to the Table of Contents for locations of specific assemblies.

NOTE: The following abbreviations may be used herein:

AR ASSD ASSY CB CCW CP CS CTR CW DEG DIA FCHC FCS FHMS FL FLN FLS FW GA GR HD HLN HJN HN HS INCL INS JT LG LH LN LW M MM/mm NF PB PTO RH RHMS RPM RT SERR SHCS SHSS SN SQ SQSS T TFS THMS THRD WLDMT ZO #

– As Required – Assembled – Assembly – Carriage Bolt – Counterclockwise – Cotter Pin – Cap Screw (Hexagon Head) – Center – Clockwise – Degree – Diameter – Flanged Cap Screw – Flat Head Machine Screw – Flanged – Flanged Lock Nut (Hexagon) – Flanged Lock Screw (Hexagon) – Flat Washer – Gauge – Grade – Hard or Head – Hex Lock Nut – Hex Jam Nut – Hex Nut – Includes – Joint – Large – Left Hand – Lock Nut – Lock Washer – Metric – Millimeter – National Fine – Plow Bolt – Power Take Off – Right Hand – Round Head Machine Screw – Revolutions Per Minute – Right – Serrated – Socket Head Cap Screw – Socket Head Set Screw – Serial Number or Slotted Nut – Square – Square Head Set Screw – Tooth or Teeth – Thread Forming Screw – Truss Head Machine Screw – Thread – Weldment – Zinc Oxide Plating – Number

Table of Contents SECTION A: UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5 UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 MODEL 802 — UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 MODEL 802 — TRACK ROLLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 MODEL 802 — SUPPORT ROLLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 MODEL 802 — TENSION ROLLER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 SECTION B: DOZER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 DOZER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 MODEL 802 — DOZER BLADE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 SECTION C: CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15 CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16 MODEL 802 — CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 MODEL 802 — CHASSIS COVERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 MODEL 802 — CHASSIS LUBRICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 MODEL 802 — REAR WALL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 MODEL 802 — REAR HOOD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 MODEL 802 — COUNTERWEIGHT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 MODEL 802 — HOOD. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 MODEL 802 — TOOL COMPARTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 MODEL 802 — VALVE BRACKETS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 MODEL 802 — VALVE COVERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25 SECTION D: BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27 BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28 MODEL 802 — BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28 MODEL 802 — STICK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29 MODEL 802 — BUCKET LINK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30 SECTION E: CABIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31 CABIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32 MODEL 802 — CABIN MOUNTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 MODEL 802 — CABIN FRAME 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34 MODEL 802 — CABIN FRAME 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 MODEL 802 — CABIN FRAME 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36 MODEL 802 — CABIN FRAME 3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37 MODEL 802 — CABIN CABLES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38 MODEL 802 — FRONT WINDSHIELD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39 MODEL 802 — CABIN WINDOWS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40 MODEL 802 — SLIDING SIDE WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41 MODEL 802 — CABIN DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42 MODEL 802 — CABIN MATS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43 MODEL 802 — CABIN HEATING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44 MODEL 802 — DRIVERS SEAT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45 SECTION F: DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47 DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48 MODEL 802 — DIESEL ENGINE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48 MODEL 802 — DIESEL TANK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49 PRINTED IN U.S.A.

1

908545/BP0602

MODEL 802 — FUEL LINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 MODEL 802 — ACCELERATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51 MODEL 802 — ENGINE SUSPENSION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52 MODEL 802 — COOLING WATER SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53 MODEL 802 — AIR INTAKE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54 MODEL 802 — EXHAUST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55 SECTION G: HYDRAULIC SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .57 HYDRAULIC SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .58 MODEL 802 — HYDRAULIC PUMP ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58 MODEL 802 — HYDRAULIC OIL TANK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59 MODEL 802 — HYDRAULIC OIL COOLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60 MODEL 802 — TRAVELING MOTORS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61 MODEL 802 — SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62 MODEL 802 — CONTROL VALVE 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63 MODEL 802 — CONTROL VALVE 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64 MODEL 802 — CONTROL VALVE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65 MODEL 802 — HYDRAULIC PUMP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66 MODEL 802 — TURNING MOTOR. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67 MODEL 802 — PILOT OIL SUPPLY UNIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68 MODEL 802 — SELECTION VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69 MODEL 802 — VALVE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70 MODEL 802 — DISTRIBUTION BLOCK (BIG) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71 MODEL 802 — DISTRIBUTION BLOCK (SMALL) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72 MODEL 802 — HAND LEVERS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73 MODEL 802 — DOZER BLADE VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74 MODEL 802 — TRAVELING VALVES. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75 MODEL 802 — AUXILIARY HYDRAULICS CONTROL VALVE. . . . . . . . . . . . . . . . . . . . . . 76 MODEL 802 — BOOM CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77 MODEL 802 — STICK CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78 MODEL 802 — BUCKET CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79 MODEL 802 — BOOM OFFSET CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80 MODEL 802 — DOZER BLADE CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81 MODEL 802 — HYDRAULIC OIL COOLER INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . 82 MODEL 802 — BOOM OFFSET CYLINDER INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . 83 MODEL 802 — DOZER BLADE VALVE INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . 84 MODEL 802 — TRACK STEERING MOTOR ASSEMBLY INSTALLATION . . . . . . . . . . . . 85 MODEL 802 — HAND LEVER INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86 MODEL 802 — PILOT OPERATED CHECK VALVE INSTALLATION . . . . . . . . . . . . . . . . . 87 MODEL 802 — TURNING MOTOR / DISTRIBUTOR INSTALLATION . . . . . . . . . . . . . . . . . 88 MODEL 802 — PRESSURE HOLDING VALVE INSTALLATION. . . . . . . . . . . . . . . . . . . . . . 89 MODEL 802 — HYDRAULIC PUMP INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90 MODEL 802 — BOOM INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91 MODEL 802 — BOOM CYLINDER INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92 MODEL 802 — BUCKET / STICK INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93 SECTION H: ELECTRICAL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .95 ELECTRICAL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .96 MODEL 802 — ELECTRICAL INSTALLATION 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96 MODEL 802 — ELECTRICAL INSTALLATION 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97 MODEL 802 — CONTROL BOARD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98 MODEL 802 — RELAY BOX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99 908545/BP0602

2

PRINTED IN U.S.A.

MODEL 802 — RELAY BOX INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100 MODEL 802 — LIGHTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101 MODEL 802 — WORKING HEADLIGHTS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102 MODEL 802 — BATTERY INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103 MODEL 802 — HORN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 104 SECTION I: TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .105 TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .106 MODEL 802 — TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106 SECTION J: DECALS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .107 DECALS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .108 MODEL 802 — DECALS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108

PRINTED IN U.S.A.

3

908545/BP0602

908545/BP0602

4

PRINTED IN U.S.A.

SECTION A: UNDERCARRIAGE

SECTION A: UNDERCARRIAGE

UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 MODEL 802 — UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 MODEL 802 — TRACK ROLLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 MODEL 802 — SUPPORT ROLLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 MODEL 802 — TENSION ROLLER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

PRINTED IN U.S.A.

5

908545/BP0602

MODEL 802 MINI-EXCAVATOR UNDERCARRIAGE MODEL 802 — UNDERCARRIAGE

ET8002001

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

908545/BP0602

6

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR UNDERCARRIAGE MODEL 802 — UNDERCARRIAGE Ref. No.

Part No.

1

163168

UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . 1

25

651451

HLN INS M16-2.0 ZO . . . . . . . . . . . . . . . . . . . . . 2

2

161073

TRACK TENSIONER. . . . . . . . . . . . . . . . . . . . . 2

26

651491

SHCS HS M14-1.5 X 45 10.9 ZO D912 . . . . . . 24

3

160638

NON RETURN VALVE . . . . . . . . . . . . . . . . . . . . 2

27

651497

SHCS HS M16-1.5 X 50 10.9 ZO D912 . . . . . . 24

4

161578

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

28

651414

CS M16-2.0 X 40 C 10.9 ZO . . . . . . . . . . . . . . . . 4

5

161071

TRACK ROLLER . . . . . . . . . . . . . . . . . . . . . . . . 2

30

651486

SHCS HS M12-1.7 X 50 12.9 ZO D912 . . . . . . 40

6

161072

SUPPORT ROLLER . . . . . . . . . . . . . . . . . . . . . 2

31

651394

CS M10-1.5 X 25 C 10.9 ZO . . . . . . . . . . . . . . . . 4

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

7

161149

TRAVEL MOTOR . . . . . . . . . . . . . . . . . . . . . . . . 2

32

651391

CS M10-1.5 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . 8

8

161068

SPROCKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

33

651515

SHCS HS M8-1.2 X 20 8.8 ZO D912 . . . . . . . . . 8

9

161069

RUBBER CHAIN . . . . . . . . . . . . . . . . . . . . . . . . 2

34

161625

LW SPRING B14 DIN7983 . . . . . . . . . . . . . . . . 24

10

163068

SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . 1

35

161646

WASHER/GR A 15 DIN125 ZO. . . . . . . . . . . . . 24 WASHER/ROUND HI-TENS DIN6916 . . . . . . . . 8

11

163175

TURNTABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

36

161643

12

163203

ROLLER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

37

161636

WASHER/NORD-LOCK NL 12 STUCK . . . . . . 40

13

163174

SPRING SET . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

38

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 12

14

160886

TENSION CYLINDER . . . . . . . . . . . . . . . . . . . . 2

39

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . . 4

15

163169

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

40

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 12

16

163170

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

41

161663

WASHER/GR A 10.5 ZO DIN9021 . . . . . . . . . . . 4

17

163172

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

42

161647

WASHER/ROUND HI-TENS 17 . . . . . . . . . . . . 58

18

163171

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

43

161635

WASHER/NORD-LOCK NL 10 STUCK . . . . . . . 4

19

161070

TRACK ROLLER . . . . . . . . . . . . . . . . . . . . . . . . 8

44

161074

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

161417

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

45

161075

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

21

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 1

46

161076

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

22

161416

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 1

47

161207

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

651417

HB M16-2.0 X 80 C 10.9 ZO . . . . . . . . . . . . . . 30

48

160945

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

651416

HB M16-2.0 X 70 C 10.9 ZO . . . . . . . . . . . . . . . 2

49

161208

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

7

908545/BP0602

MODEL 802 MINI-EXCAVATOR UNDERCARRIAGE MODEL 802 — TRACK ROLLER

ET8002015

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163186

ROLLER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

163187

SHAFT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

163188

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

163189

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

163190

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

163191

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

163192

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

163193

COTTER PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

163194

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161075

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

8

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR UNDERCARRIAGE MODEL 802 — TRACK ROLLER

ET8002017

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1

163202

ROLLER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

163191

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

163187

SHAFT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

163192

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

163188

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

163193

COTTER PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

163189

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

163194

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

163190

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161076

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

9

908545/BP0602

MODEL 802 MINI-EXCAVATOR UNDERCARRIAGE MODEL 802 — SUPPORT ROLLER

ET8002020

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163176

ROLLER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

163182

CUFF . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

163177

SHAFT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

163183

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

3

163178

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

163184

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

163179

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

163185

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

163180

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

11

161074

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

163181

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

Ref. No.

10

Part No.

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR UNDERCARRIAGE MODEL 802 — SPRING

ET8002022

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

1

163195

FORK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

163196

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

163197

SPRING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

163198

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

163199

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

163200

COTTER PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

163201

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161207

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

11

908545/BP0602

MODEL 802 MINI-EXCAVATOR UNDERCARRIAGE MODEL 802 — TENSION ROLLER

ET8002023

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163203

TENSION ROLLER . . . . . . . . . . . . . . . . . . . . . . 1

2

163030

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

163031

COTTER PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

163032

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

163033

SHAFT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

163034

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

160983

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

160983

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

163035

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

12

PRINTED IN U.S.A.

SECTION B: DOZER BLADE

SECTION B: DOZER BLADE

DOZER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 MODEL 802 — DOZER BLADE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

PRINTED IN U.S.A.

13

908545/AP0300

MODEL 802 MINI-EXCAVATOR DOZER BLADE MODEL 802 — DOZER BLADE

ET8002027

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

163173

2

161191

DOZER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

651449

HLN INS M12-1.7 ZO . . . . . . . . . . . . . . . . . . . . . 6

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

161189

PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

3

161521

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

161411

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 2

4

161581

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

10

161416

PROTECTION CAP. . . . . . . . . . . . . . . . . . . . . . .2

5

161190

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

11

161143

DOZER BLADE CYLINDER . . . . . . . . . . . . . . . . 2

6

651477

SHCS HS M12-1.7 X 110 10.9 ZO D912 . . . . . . 6

Description

908545/AP0300

Qty. Req.

14

Description

Qty. Req.

PRINTED IN U.S.A.

SECTION C: CHASSIS

SECTION C: CHASSIS

CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 MODEL 802 — CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 MODEL 802 — CHASSIS COVERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 MODEL 802 — CHASSIS LUBRICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 MODEL 802 — REAR WALL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 MODEL 802 — REAR HOOD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 MODEL 802 — COUNTERWEIGHT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 MODEL 802 — HOOD. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 MODEL 802 — TOOL COMPARTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 MODEL 802 — VALVE BRACKETS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 MODEL 802 — VALVE COVERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

PRINTED IN U.S.A.

15

908545/BP0602

MODEL 802 MINI-EXCAVATOR CHASSIS MODEL 802 — CHASSIS

ET8002030

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

163138

2

163064

CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

161422

SWING BRACKET . . . . . . . . . . . . . . . . . . . . . . . 1

19

160409

3

161525

REFLECTOR. . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

161627

RIVET/BLIND A4 X 12 DIN7337 . . . . . . . . . . . . . 4

4 5

161202

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

21

163175

TURNTABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

163349

COTTER PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

22

161570

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

6

161142

BOOM OFFSET CYLINDER . . . . . . . . . . . . . . . 1

23

651417

HB M16-2.0 X 80 C 10.9 ZO . . . . . . . . . . . . . . . 30

8

161201

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

161647

WASHER/ROUND HI-TENS 17 . . . . . . . . . . . . 30

9

163074

AXLE BRACKET . . . . . . . . . . . . . . . . . . . . . . . . 2

25

161173

TURNING MOTOR . . . . . . . . . . . . . . . . . . . . . . . 1

10

651405

CS M12-1.7 X 30 C 10.9 ZO . . . . . . . . . . . . . . . 2

26

651486

SHCS HS M12-1.7 X 50 12.9 ZO D912 . . . . . . 10

Description

Qty. Req.

Description

Qty. Req.

PROTECTION CAP. . . . . . . . . . . . . . . . . . . . . . .2

11

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . 4

27

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . 10

12

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . 4

28

163053

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161206

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

29

656094

CS M8-1.2 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

14

656122

CS M12-1.7 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . 2

30

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . . 2

17

161420

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 2

31

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . . 2

908545/BP0602

16

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR CHASSIS MODEL 802 — CHASSIS COVERS

ET8002035

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

163153

2

163155

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162015

RUBBER SEAL (17 cm) . . . . . . . . . . . . . . . . . . . 1

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

162017

RUBBER PROTECTOR (134 cm). . . . . . . . . . . . 1

3 4

163156

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

162015

RUBBER SEAL (8 cm) . . . . . . . . . . . . . . . . . . . . 1

163154

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

162015

RUBBER SEAL (15 cm) . . . . . . . . . . . . . . . . . . . 1

5

163165

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

162017

RUBBER PROTECTOR (52 cm). . . . . . . . . . . . . 1

6

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . 24

23

162015

RUBBER SEAL (6 cm) . . . . . . . . . . . . . . . . . . . . 1

7

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . 24

24

162015

RUBBER SEAL (50 cm) . . . . . . . . . . . . . . . . . . . 1

8

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . 24

25

162015

RUBBER SEAL (3 cm) . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

9

162017

RUBBER PROTECTOR (144 cm) . . . . . . . . . . . 1

26

162015

RUBBER SEAL (44 cm) . . . . . . . . . . . . . . . . . . . 1

10

162015

RUBBER SEAL (13 cm). . . . . . . . . . . . . . . . . . . 1

27

162016

RUBBER PROTECTOR (35 cm). . . . . . . . . . . . . 1 RUBBER PROTECTOR (35 cm). . . . . . . . . . . . . 1

11

162016

RUBBER PROTECTOR (110 cm) . . . . . . . . . . . 1

28

162017

12

162015

RUBBER SEAL (27 cm). . . . . . . . . . . . . . . . . . . 1

29

162017

RUBBER PROTECTOR (91 cm). . . . . . . . . . . . . 1

13

162017

RUBBER PROTECTOR (49 cm) . . . . . . . . . . . . 1

30

162015

RUBBER SEAL (9 cm) . . . . . . . . . . . . . . . . . . . . 1

14

162015

RUBBER SEAL (42 cm). . . . . . . . . . . . . . . . . . . 1

31

162015

RUBBER SEAL (26 cm) . . . . . . . . . . . . . . . . . . . 1

15

162015

RUBBER SEAL (4 cm). . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

17

908545/BP0602

MODEL 802 MINI-EXCAVATOR CHASSIS MODEL 802 — CHASSIS LUBRICATION

ET8002040

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161722

LUBRICATION BLOCK . . . . . . . . . . . . . . . . . . . 1

8

161482

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

2

651509

SHCS HS M6-1 X 30 8.8 ZO D912 . . . . . . . . . . 2

9

161226

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

3

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 2

10

161392

LUBRICATION TUBE . . . . . . . . . . . . . . . . . . . . . 3

4

163348

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

11

161468

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

161411

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 2

12

161469

SLEEVE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

13

161457

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

7

161461

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

Ref. No.

18

Part No.

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR CHASSIS MODEL 802 — REAR WALL

ET8002045

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163140

REAR WALL . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

651405

CS M12-1.7 X 30 C 10.9 ZO . . . . . . . . . . . . . . . . 2

2

162791

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . . 8

3

651460

FCHC HS M5-0.8 X 16 8.8 ZO D7991 . . . . . . . . 4

16

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . . 4

4

161611

NUT/CAGE M5 . . . . . . . . . . . . . . . . . . . . . . . . . 4

17

651404

CS M12-1.7 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 1

5

163143

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

163157

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

161677

QUICKLOCK/HEXAGON. . . . . . . . . . . . . . . . . . 2

20

651411

HB M12-1.7X 60 C 10.9 ZO . . . . . . . . . . . . . . . . 4

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

7

161619

WASHER/QUICK LOCK . . . . . . . . . . . . . . . . . . 2

21

162666

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161691

QUICKLOCK/LOWER . . . . . . . . . . . . . . . . . . . . 2

22

163075

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161626

RIVET/BLIND A3 X 12 DIN7337 . . . . . . . . . . . . 2

23

163077

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

651502

SHCS HS M5-0.8 X 10 8.8 ZO D912 . . . . . . . . . 1

24

163078

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

651393

CS M10-1.5 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . 6

25

163076

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 6

26

162819

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161641

WASHER/GR 10.5 ZO . . . . . . . . . . . . . . . . . . . 6

27

162820

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

19

908545/BP0602

MODEL 802 MINI-EXCAVATOR CHASSIS MODEL 802 — REAR HOOD

ET8002055

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163161

REAR HOOD . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

2

162716

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

19

161058

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

160882

HINGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

4

162675

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

21

656149

CS M6-1.0 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . . 3

5

656094

CS M8-1.2 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

22

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . . 3

6

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . 10

23

161660

WASHER/GR A 6.4 ZO DIN125 . . . . . . . . . . . . . 5

7

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

24

161062

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

163162

BAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

25

161187

CABLE (200 cm) . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162072

BALL AND SOCKET . . . . . . . . . . . . . . . . . . . . . 1

26

162604

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 3

27

651457

HLN INS M6-1.0 8 Z0 . . . . . . . . . . . . . . . . . . . . . 2

11

161616

NUT/CAGE M8. . . . . . . . . . . . . . . . . . . . . . . . . . 3

28

161929

NIPPLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

12

162389

CLAMP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

29

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . . 2

13

651422

CS M5-0.8 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 1

30

161674

LOCKWASHER S5 . . . . . . . . . . . . . . . . . . . . . . . 1

14

161064

HANDLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

31

161659

WASHER/GR A 5.3 ZO DIN125 . . . . . . . . . . . . . 1

15

651459

FCHC HS M14-2.0 X 16 8.8 ZO D7991 . . . . . . . 2

32

656100

HN M5-.8 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

34

161358

RUBBER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

Description

Qty. Req.

16

163345

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

17

161061

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908545/BP0602

Ref. No.

20

Part No.

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR CHASSIS MODEL 802 — COUNTERWEIGHT

ET8002060

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163137

COUNTERWEIGHT . . . . . . . . . . . . . . . . . . . . . . 1

11

161642

2

161653

WASHER/ROUND HI-TENS 21 DIN6916 . . . . 12

12

161188

CABLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

651420

CS M20-2.5 X 70 C 8.8 ZO . . . . . . . . . . . . . . . 12

13

162604

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161057

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

656047

HN M6-1.0 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

161062

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161929

NIPPLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

656149

CS M6-1.0 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . 3

16

163167

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 5

17

162794

RETAINER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . . 2

8

161621

LW SPRING 6 DIN7980 . . . . . . . . . . . . . . . . . . . 3

18

160644

REFLECTOR. . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

656122

CS M12-1.7 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . 2

19

161627

RIVET/BLIND A4 X 12 DIN7337 . . . . . . . . . . . . . 4

10

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . 2

20

651433

HB M8-1.2 X 40 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

21

908545/BP0602

MODEL 802 MINI-EXCAVATOR CHASSIS MODEL 802 — HOOD

ET8002065

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162658

2

162667

HOOD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

656100

HN M5-.8 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161064

HANDLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

3

162716

4

160882

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

651459

FCHC HS M14-2.0 X 16 8.8 ZO D7991 . . . . . . . 2

HINGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

163345

5

FCHC HS M14-2.0 X 16 8.8 ZO . . . . . . . . . . . . . 2

162675

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161061

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

656094

CS M8-1.2 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

16

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 2

7

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 6

17

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

8

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

18

162016

RUBBER PROTECTOR . . . . . . . . . . . . . . . . . . . 2

9

161204

PNEUMATIC SPRING . . . . . . . . . . . . . . . . . . . . 2

Description

908545/BP0602

Qty. Req.

22

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR CHASSIS MODEL 802 — TOOL COMPARTMENT

ET8002070

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1

163145

TOOL COMPARTMENT . . . . . . . . . . . . . . . . . . 1

11

163139

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

163144

TOOL BOX. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

656094

CS M8-1.2 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . . . 4

3

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . 14

13

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

4

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . 22

14

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . . 8

5

161616

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . 8

15

163150

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162792

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

163081

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 8

17

162388

RUBBER PROTECTOR . . . . . . . . . . . . . . . . . . . 2

8

163151

HINGE BRACKET . . . . . . . . . . . . . . . . . . . . . . . 1

18

161063

LOCK (INCLUDES ITEM 19) . . . . . . . . . . . . . . . 1

9

162189

HINGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

19

170761

KEY/TOOLBOX 802 EXCAVATOR . . . . . . . . . . . 1

10

163152

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

651466

SCREW FCHC HS M8-1.2 X 20 8.8 ZO D7991. . . 4

PRINTED IN U.S.A.

23

908545/BP0602

MODEL 802 MINI-EXCAVATOR CHASSIS MODEL 802 — VALVE BRACKETS

ET8002075

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

163146

8

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 8

2

651396

3

161669

CS M10-1.5 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . 4

9

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 10

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 4

10

161616

4

161663

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . . 6

WASHER/GR A 10.5 ZO DIN9021. . . . . . . . . . . 4

11

163160

VALVE BAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

656102

HN M10-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . . . 4

12

163159

VALVE BAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

163147

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

656094

CS M8-1.2 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

7

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 6

Description

Qty. Req.

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908545/BP0602

24

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR CHASSIS MODEL 802 — VALVE COVERS

ET8002077

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

163148

2

163164

VALVE COVER . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

651393

VALVE COVER . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161610

3

163149

NUT/CAGE M10 . . . . . . . . . . . . . . . . . . . . . . . . . 1

VALVE COVER . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . . 5

4 5

651402

CS M10-1.5 X 50 C 8.8 ZO . . . . . . . . . . . . . . . . 8

12

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 9

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . 10

13

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . . 9

6

161663

WASHER/GR A 10.5 ZO DIN9021 . . . . . . . . . .11

14

161616

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . . 5

7

651399

CS M10-1.5 X 40 C 8.8 ZO . . . . . . . . . . . . . . . . 1

15

651432

CS M8-1.2 X 35 C 8.8 ZO . . . . . . . . . . . . . . . . . . 4

8

651448

HLN INS M10-1.5 ZO. . . . . . . . . . . . . . . . . . . . . 1

16

162388

RUBBER PROTECTOR (14 cm). . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

25

Description

Qty. Req.

CS M10-1.5 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . . 1

908545/BP0602

908545/BP0602

26

PRINTED IN U.S.A.

SECTION D: BOOM

SECTION D: BOOM

BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28 MODEL 802 — BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28 MODEL 802 — STICK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29 MODEL 802 — BUCKET LINK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

PRINTED IN U.S.A.

27

908545/BP0602

MODEL 802 MINI-EXCAVATOR BOOM MODEL 802 — BOOM

ET8002080

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

163061

2

161199

BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

163073

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

651393

3

CS M10-1.5 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . . 8

161518

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . . 8

4

161409

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

13

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . . 8

5

161583

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 1

6

163205

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

15

162928

PROTECTION CAP. . . . . . . . . . . . . . . . . . . . . . .1

7

651449

HLN INS M12-1.7 ZO. . . . . . . . . . . . . . . . . . . . . 3

16

161141

BOOM CYLINDER . . . . . . . . . . . . . . . . . . . . . . . 1

8

161200

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161144

BOOM CYLINDER . . . . . . . . . . . . . . . . . . . . . . . 1

9

161198

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

28

Description

Qty. Req.

PIN COVER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR BOOM MODEL 802 — STICK

ET8002085

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161136

STICK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161409

WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

2

161194

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161581

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

3

161519

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 2

4

161409

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

15

162928

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

5

161583

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

161140

STICK CYLINDER. . . . . . . . . . . . . . . . . . . . . . . . 1

6

163346

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

17

161203

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

651449

HLN INS M12-1.7 ZO. . . . . . . . . . . . . . . . . . . . . 3

18

161405

8

161192

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

REFER TO FACTORY

Description

Qty. Req.

Ref. No.

Part No.

Description

COTTER PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161193

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

REFER TO FACTORY

10

163205

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

REFER TO FACTORY

11

161528

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

PRINTED IN U.S.A.

29

Qty. Req.

908545/BP0602

MODEL 802 MINI-EXCAVATOR BOOM MODEL 802 — BUCKET LINK

ET8002090

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161135

CONNECTING LINK . . . . . . . . . . . . . . . . . . . . . 1

11

163205

2

161138

CONNECTING LINK . . . . . . . . . . . . . . . . . . . . . 1

12

651449

HLN INS M12-1.7 ZO . . . . . . . . . . . . . . . . . . . . . 1

3

161137

CONNECTING LINK . . . . . . . . . . . . . . . . . . . . . 1

13

161203

PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161195

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161581

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

161196

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161528

BUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

161197

PIN COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

161409

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

161517

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

17

161139

BUCKET CYLINDER. . . . . . . . . . . . . . . . . . . . . .1

8

161411

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 3

18

651494

SHCS HS M16-1.5 X 30 12.9 ZO D912 . . . . . . . 2

9

161416

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 3

19

161671

LOCKWASHER S14 . . . . . . . . . . . . . . . . . . . . . . 4

10

161191

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

161405

COTTER PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

Ref. No.

30

Part No.

Description

Qty. Req.

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

CABIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 MODEL 802 — CABIN MOUNTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 MODEL 802 — CABIN FRAME 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34 MODEL 802 — CABIN FRAME 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 MODEL 802 — CABIN FRAME 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36 MODEL 802 — CABIN FRAME 3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37 MODEL 802 — CABIN CABLES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38 MODEL 802 — FRONT WINDSHIELD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39 MODEL 802 — CABIN WINDOWS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40 MODEL 802 — SLIDING SIDE WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41 MODEL 802 — CABIN DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42 MODEL 802 — CABIN MATS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43 MODEL 802 — CABIN HEATING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44 MODEL 802 — DRIVERS SEAT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45

PRINTED IN U.S.A.

31

SECTION E: CABIN

SECTION E: CABIN

908545/BP0602

MODEL 802 MINI-EXCAVATOR CABIN MODEL 802 — CABIN MOUNTING

ET8002093

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

908545/BP0602

32

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR CABIN MODEL 802 — CABIN MOUNTING Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1

160711

CUSHION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

8

160714

SUPPORT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

2

651403

HB M12-1.7 X 100 C 8.8 ZO . . . . . . . . . . . . . . . 4

9

160715

SUPPORT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

3

161643

WASHER/ROUND HI-TENS DIN6916. . . . . . . . 4

10

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . . 4

4

651396

CS M10-1.5 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . 6

11

651449

HLN INS M12-1.7 ZO . . . . . . . . . . . . . . . . . . . . . 4

5

651393

CS M10-1.5 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . 2

12

656102

HN M10-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . . . 4

6

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . 12

13

161395

CABIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 8

PRINTED IN U.S.A.

33

908545/BP0602

MODEL 802 MINI-EXCAVATOR CABIN MODEL 802 — CABIN FRAME 1

ET8002095

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

908545/BP0602

34

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR CABIN MODEL 802 — CABIN FRAME 1 Ref. No.

Part No.

Ref. No.

Part No.

1

163036

2

161085

CABIN FRAME . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

161922

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

WIPER MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161924

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3 4

161084

WIPER BLADE HOLDER . . . . . . . . . . . . . . . . . 3

18

161923

WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

162795

WIPER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

162607

MIRROR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5 6

161086

CLIPS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

656149

CS M6-1.0 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

162796

WATER HOSE (190 cm) . . . . . . . . . . . . . . . . . . 1

21

162924

WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7 8

161087

NOZZLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

162737

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

160481

ASHTRAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

162006

RADIO . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162869

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

24

162839

ANTENNA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

162797

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

25

163037

CONSOLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

11

160488

ILLUMINATION . . . . . . . . . . . . . . . . . . . . . . . . . 1

26

162840

SPEAKER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

162798

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

27

162799

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

13

160716

WINDSHIELD WASHER . . . . . . . . . . . . . . . . . . 1

28

162035

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

14

656092

CS M6-1.0 X 12 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

29

162736

EDGE PROTECTION (110 cm). . . . . . . . . . . . . . 1

15

161921

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

35

908545/BP0602

MODEL 802 MINI-EXCAVATOR CABIN MODEL 802 — CABIN FRAME 2

ET8002100

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162018

RUBBER PROTECTOR (240 cm) . . . . . . . . . . . 1

14

161843

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

2

162018

RUBBER PROTECTOR (460 cm) . . . . . . . . . . . 1

15

651425

CS M6-1.0 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . . . 3

3

161949

RUBBER PROTECTOR (170 cm) . . . . . . . . . . . 1

16

651428

CS M6-1.0 X 50 C 8.8 ZO . . . . . . . . . . . . . . . . . . 1

4

162600

RUBBER BUFFER . . . . . . . . . . . . . . . . . . . . . . . 2

17

162924

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

5

162862

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

18

162801

DOOR LOCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162925

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

162802

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

7

162800

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

162803

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

656100

HN M5-.8 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

162804

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

9

162857

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

162805

RUBBER SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

160526

LOCK, L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

23

161088

BAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

11

160527

LOCK, R. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

24

161089

HANDLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

12

162029

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

25

162789

RUBBER BUFFER . . . . . . . . . . . . . . . . . . . . . . . 1

13

162863

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

26

162863

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

908545/BP0602

36

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR CABIN MODEL 802 — CABIN FRAME 3

ET8002105

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

163038

2

162044

SHIELD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

651458

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

16

162810

3

162806

NOZZLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

GUTTER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

162869

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

4 5

163039

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

160715

SUPPORT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

162807

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

160714

SUPPORT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

162036

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

651403

HB M12-1.7 X 100 C 8.8 ZO . . . . . . . . . . . . . . . . 4

7

162808

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

161643

WASHER/ROUND HI-TENS DIN6916 . . . . . . . . 4

8

162809

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

651449

HLN INS M12-1.7 ZO . . . . . . . . . . . . . . . . . . . . . 4

9

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

23

160711

CUSHION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

10

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . 6

24

161964

SILICON GLUE . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 6

25

12

656048

HN M8-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . 2

26

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 2

13

163040

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

27

161615

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

162870

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

37

Description

Qty. Req.

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . . 5

908545/BP0602

MODEL 802 MINI-EXCAVATOR CABIN MODEL 802 — CABIN CABLES

ET8002107

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160987

MAIN WIRING HARNESS . . . . . . . . . . . . . . . . . 1

2

160988

SECONDARY WIRING HARNESS . . . . . . . . . . 1

3

162811

CABLE TIE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

908545/BP0602

Qty. Req.

38

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR CABIN MODEL 802 — FRONT WINDSHIELD

ET8002110

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1

160495

FRONT WINDSHIELD . . . . . . . . . . . . . . . . . . . . 1

10

161618

NUT/HEX DOMED CAP M8 . . . . . . . . . . . . . . . . 4

2

162602

LOWER WINDSHIELD FRAME. . . . . . . . . . . . . 1

11

160494

PVC-WASHERS . . . . . . . . . . . . . . . . . . . . . . . . . 4

3

162603

UPPER WINDSHIELD FRAME . . . . . . . . . . . . . 1

12

161951

EDGE PROTECTION . . . . . . . . . . . . . . . . . . . . . 1 SUN VISOR. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162033

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

13

162606

5

651466

SCREW FCHC HS M8-1.2 X 20 8.8 ZO D7991 2

14

162868

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

6

161941

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

15

161964

SILICON GLUE . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

160640

RUBBER WASHER . . . . . . . . . . . . . . . . . . . . . . 4

16

8

160639

RUBBER WASHER . . . . . . . . . . . . . . . . . . . . . . 4

17

160641

PVC-WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

161668

WASHER/GR A 8.4 ZO DIN134 . . . . . . . . . . . . 4

18

162601

RUBBER PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

39

908545/BP0602

MODEL 802 MINI-EXCAVATOR CABIN MODEL 802 — CABIN WINDOWS

ET8002116

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160496

2

161080

UPPER FRONT WINDSHIELD . . . . . . . . . . . . . 1

10

161081

SIDE WINDOW, L . . . . . . . . . . . . . . . . . . . . . . . . 1

LOWER FRONT WINDSHIELD . . . . . . . . . . . . . 1

11

161082

SIDE WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

161091

PVC WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

161396

RUBBER PROTECTOR (130 cm) . . . . . . . . . . . . 1

4

160640

RUBBER WASHER . . . . . . . . . . . . . . . . . . . . . . 2

13

5

160639

RUBBER WASHER . . . . . . . . . . . . . . . . . . . . . . 2

14

161083

REAR WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161404

HANDLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

15

161964

SILICON GLUE . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162812

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

8

656048

HN M8-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . 2

17

161949

RUBBER PROTECTOR (87 cm) . . . . . . . . . . . . . 1

9

162018

RUBBER PROTECTOR (250 cm) . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

40

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR CABIN MODEL 802 — SLIDING SIDE WINDOW

ET8002120

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161092

2

161093

FRONT SLIDING WINDOW . . . . . . . . . . . . . . . 1

3

161094

REAR SLIDING WINDOW . . . . . . . . . . . . . . . . . 1

4

160642

LOCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

RIGHT SIDE WINDOW ASSEMBLY . . . . . . . . . 1

PRINTED IN U.S.A.

41

908545/BP0602

MODEL 802 MINI-EXCAVATOR CABIN MODEL 802 — CABIN DOOR

ET8002125

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161095

DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161078

DOOR WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . 1

2 3

163041

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

13

161079

DOOR WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . 1

160525

LOCK L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162923

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162864

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

15

161098

LOCK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . 2

16

651424

CS M6-1.0 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 3

6

161096

HANDLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

162813

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

7

160713

KEY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

18

651457

HLN INS M6-1.0 8 Z0 . . . . . . . . . . . . . . . . . . . . . 3

8

160712

COVER L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

162737

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

9

161097

TIE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

163042

DOOR ISOLATION . . . . . . . . . . . . . . . . . . . . . . . 1

10

161396

RUBBER PROTECTOR (440 cm) . . . . . . . . . . . 1

21

162814

Description

Qty. Req.

11

908545/BP0602

22

42

Description

Qty. Req.

DOOR ISOLATION . . . . . . . . . . . . . . . . . . . . . . . 1 DOOR ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR CABIN MODEL 802 — CABIN MATS

ET8002130

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161099

2

161100

RUBBER FLOOR MAT . . . . . . . . . . . . . . . . . . . 1

7

163046

REAR WALL COVER MAT . . . . . . . . . . . . . . . . . 1

RUBBER FLOOR MAT . . . . . . . . . . . . . . . . . . . 1

8

162816

3

ROOF COVER MAT . . . . . . . . . . . . . . . . . . . . . . 1

163043

COVER MAT . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

163047

FRONT COVER MAT . . . . . . . . . . . . . . . . . . . . . 1

4

163044

COVER MAT . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161937

FIXING STRIP. . . . . . . . . . . . . . . . . . . . . . . . . . 13

5

162815

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

11

162673

VELCRO STRAP. . . . . . . . . . . . . . . . . . . . . . . . . 7

6

163045

COVER MAT . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

43

Description

Qty. Req.

908545/BP0602

MODEL 802 MINI-EXCAVATOR CABIN MODEL 802 — CABIN HEATING

ET8002135

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161077

CAB HEATER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162064

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

2 3

163158

CAB HEATING CONSOLE . . . . . . . . . . . . . . . . 1

17

160860

HOSE COVER. . . . . . . . . . . . . . . . . . . . . . . . . . . 2

162605

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

18

161423

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

162015

RUBBER SEAL (70 cm). . . . . . . . . . . . . . . . . . . 1

19

161424

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

20

161470

REDUCTION JOINT . . . . . . . . . . . . . . . . . . . . . . 2

6

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 4

21

161484

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

22

161102

NOZZLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

8

161615

NUT/CAGE M8. . . . . . . . . . . . . . . . . . . . . . . . . . 4

23

161446

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

9

651424

CS M6-1.0 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

24

161323

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 2

10

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 4

25

161463

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161660

WASHER/GR A 6.4 ZO DIN125. . . . . . . . . . . . . 4

26

161504

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

162854

HOSE COVERING (65 cm) . . . . . . . . . . . . . . . . 1

27

160950

BALL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162835

STRAP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

28

161477

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161393

CAB HEATING HOSE (45 cm). . . . . . . . . . . . . . 1

29

161445

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

15

161393

CAB HEATING HOSE (60 cm). . . . . . . . . . . . . . 1

30

161496

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

44

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR CABIN MODEL 802 — DRIVERS SEAT

ET8002140

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

656048

2

162738

HN M8-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . 8

21

162214

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

DRIVER SEAT . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

163225

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

656001

4

161676

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

23

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . . 2

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . 20

24

162048

5

161661

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 6

25

651460

FCHC HS M5-0.8 X 16 8.8 ZO D7991 . . . . . . . 16

6

161615

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . 4

26

161805

TUBE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

160407

CONSOLE/CONTROL LEVERS . . . . . . . . . . . . 1

27

162210

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

160408

CONSOLE/CONTROL LEVERS . . . . . . . . . . . . 1

28

162211

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161730

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

29

162212

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

651517

SHCS HS M8-1.2 X 30 8.8 ZO D912 . . . . . . . . . 8

30

162213

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 ARMREST. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

11

161831

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

31

160532

12

160611

PNEUMATIC SPRING . . . . . . . . . . . . . . . . . . . . 1

32

160533

ARMREST. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161848

QUICK FIX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

33

161728

SEAT BELT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

651390

HB M10-1.5 X 120 C 8.8 ZO . . . . . . . . . . . . . . . 1

34

651424

CS M6-1.0 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 6

15

161651

WASHER 20 . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

35

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . . 6

16

161868

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

36

161666

WASHER/GR A 6.4 ZO DIN9021 . . . . . . . . . . . . 6

17

161403

BALL KNOB . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

37

161361

MICRO SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . 1

38

162674

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

39

161628

SCREW/PAN HEAD TAP . . . . . . . . . . . . . . . . . . 2

19

651448

HLN INS M10-1.5 ZO. . . . . . . . . . . . . . . . . . . . . 1

20

161947

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

45

908545/BP0602

908545/BP0602

46

PRINTED IN U.S.A.

DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48 MODEL 802 — DIESEL ENGINE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48 MODEL 802 — DIESEL TANK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49 MODEL 802 — FUEL LINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 MODEL 802 — ACCELERATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51 MODEL 802 — ENGINE SUSPENSION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52 MODEL 802 — COOLING WATER SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53 MODEL 802 — AIR INTAKE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54 MODEL 802 — EXHAUST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55

PRINTED IN U.S.A.

47

SECTION F: DIESEL ENGINE

SECTION F: DIESEL ENGINE

908545/BP0602

MODEL 802 MINI-EXCAVATOR DIESEL ENGINE MODEL 802 — DIESEL ENGINE

ET8002145

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161114

2

425-36108

DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . 1

14

425-36119

VALVE COVER SEAL . . . . . . . . . . . . . . . . . . 1

VENTILATOR FAN . . . . . . . . . . . . . . . . . . . 1

15

425-36120

3

425-36109

OIL PAN . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

BELT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

425-36121

4

425-36110

DRAIN PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1

GENERATOR . . . . . . . . . . . . . . . . . . . . . . . 1

17

425-36122

PRE-HEATER . . . . . . . . . . . . . . . . . . . . . . . . 1

5 6

425-36111

THERMO SWITCH . . . . . . . . . . . . . . . . . . . 1

18

425-36112

WATER PUMP . . . . . . . . . . . . . . . . . . . . . . . 1

425-34683

THERMO SWITCH . . . . . . . . . . . . . . . . . . . 1

19

425-36113

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

160427

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

425-36114

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

425-34635

OIL FILTER . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

425-36123

FUEL INJECTOR . . . . . . . . . . . . . . . . . . . . . 4

Description

Qty. Req.

Description

Qty. Req.

9

160845

FUEL FILTER . . . . . . . . . . . . . . . . . . . . . . . 1

22

425-36126

FUEL PUMP . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

425-36091

FUEL FILTER . . . . . . . . . . . . . . . . . . . . . . . 1

23

425-36125

STARTER . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

425-36111

THERMO SWITCH . . . . . . . . . . . . . . . . . . . 1

24

425-36124

INJECTION PUMP . . . . . . . . . . . . . . . . . . . . 1

12

425-36117

STOP SOLENOID . . . . . . . . . . . . . . . . . . . . 1

25

161112

ENGINE GASKETS 4TNE98 . . . . . . . . . . . .1

13

425-36118

CYLINDER HEAD SEAL . . . . . . . . . . . . . . . 1

908545/BP0602

48

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR DIESEL ENGINE MODEL 802 — DIESEL TANK

ET8002155

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163141

GAS-OIL STORAGE TANK . . . . . . . . . . . . . . . . 1

10

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

161059

STRAINER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161104

TRANSMITTER. . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

161060

TANK COVER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

163343

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

4

656017

CS M12-1.7 X 35 C 8.8 ZO . . . . . . . . . . . . . . . . 4

13

161673

LOCKWASHER S4 . . . . . . . . . . . . . . . . . . . . . . . 6

5

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . 4

14

161658

WASHER/GR A 4.3 ZO DIN125 . . . . . . . . . . . . . 6

6

161645

WASHER/GR. A 13 DIN7349 ZO . . . . . . . . . . . 4

15

160844

HOSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

163079

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162926

SCREW MOUNT. . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161415

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

17

162504

HOSE CLAMP. . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

161427

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

161065

KEY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

Ref. No.

49

Part No.

Description

Qty. Req.

908545/BP0602

MODEL 802 MINI-EXCAVATOR DIESEL ENGINE MODEL 802 — FUEL LINE

ET8002160

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

425-36115

2

425-36091

3

Ref. No.

Part No.

FUEL FILTER . . . . . . . . . . . . . . . . . . . . . . . 1

7

162617

FUEL FILTER . . . . . . . . . . . . . . . . . . . . . . . 1

8

161391

HOSE (50 cm). . . . . . . . . . . . . . . . . . . . . . . . 1

HOSE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161391

HOSE (140 cm). . . . . . . . . . . . . . . . . . . . . . .1

Description

Qty. Req.

Description

Qty. Req.

HOSE (120 cm). . . . . . . . . . . . . . . . . . . . . . .1

4

651440

HB M8-1.2 X 90 C 8.8 ZO . . . . . . . . . . . . . . 1

10

162504

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 4

5

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . 1

11

1405411

FUEL FILTER ASSEMBLY . . . . . . . . . . . . . . 1

6

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . 1

908545/BP0602

50

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR DIESEL ENGINE MODEL 802 — ACCELERATOR

ET8002165

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160755

CABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

162487

WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

2

162747

THROTTLE CONTROL LEVER. . . . . . . . . . . . . 1

9

162505

BALL AND SOCKET . . . . . . . . . . . . . . . . . . . . . . 1

3

162398

HANDLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

651457

HLN INS M6-1.0 8 Z0 . . . . . . . . . . . . . . . . . . . . . 1

4

162351

BRAKE DISC . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . . 4

5

162349

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 4

6

162350

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161668

WASHER/GR A 8.4 ZO DIN134 . . . . . . . . . . . . . 4

7

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

Description

PRINTED IN U.S.A.

Qty. Req.

Ref. No.

51

Part No.

Description

Qty. Req.

908545/BP0602

MODEL 802 MINI-EXCAVATOR DIESEL ENGINE MODEL 802 — ENGINE SUSPENSION

ET8002170

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

163048

ENGINE CARRIER . . . . . . . . . . . . . . . . . . . . . . 1

14

651391

CS M10-1.5 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . 8

2 3

163049

ENGINE CARRIER . . . . . . . . . . . . . . . . . . . . . . 1

15

651407

CS M12-1.7 X 40 C 8.8 ZO . . . . . . . . . . . . . . . . . 8

163050

ENGINE CARRIER . . . . . . . . . . . . . . . . . . . . . . 1

16

651449

HLN INS M12-1.7 ZO . . . . . . . . . . . . . . . . . . . . . 4

4

163051

ENGINE CARRIER . . . . . . . . . . . . . . . . . . . . . . 1

17

162008

CABLE, GROUND. . . . . . . . . . . . . . . . . . . . . . . . 1

5

162659

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

18

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

6

162660

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

19

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 4

7

160903

HYDRO SUSPENSION . . . . . . . . . . . . . . . . . . . 2

20

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . . 4

8

651475

SHCS HS M10-1.2 X 30 8.8 ZO D912 . . . . . . . 24

21

161113

HYDRO SUSPENSION . . . . . . . . . . . . . . . . . . . . 2

9

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . 32

22

163055

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . 32

23

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

11

651406

CS M12-1.7 X 35 C 10.9 ZO . . . . . . . . . . . . . . . 4

24

163347

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . 12

25

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . .1

13

161645

WASHER/GR. A 13 DIN7349 ZO. . . . . . . . . . . 16

Description

908545/BP0602

Qty. Req.

52

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR DIESEL ENGINE MODEL 802 — COOLING WATER SYSTEM

ET8002175

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

425-36127

2

425-36128

RADIATOR . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

161949

RADIATOR CAP . . . . . . . . . . . . . . . . . . . . . 1

22

161949

3

425-36129

RUBBER PROTECTOR (120 cm) . . . . . . . . 1

COOLING WATER HOSE . . . . . . . . . . . . . . 1

23

162017

RUBBER PROTECTOR (27 cm) . . . . . . . . . 1

4 5

425-36130

COOLING WATER HOSE . . . . . . . . . . . . . . 1

24

161616

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . 3

425-36131

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 4

25

163166

SEAL PLATE. . . . . . . . . . . . . . . . . . . . . . . . . 1

6 7

425-36171

EXPANSION CONTAINER . . . . . . . . . . . . . 1

26

651404

CS M12-1.7 X 20 C 8.8 ZO. . . . . . . . . . . . . . 1

425-36172

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

27

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . 1

8 9

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . 10

28

162017

RUBBER PROTECTOR (50 cm) . . . . . . . . . 1

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . 18

29

162017

10

RUBBER PROTECTOR (33 cm) . . . . . . . . . 1

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . 22

30

162017

RUBBER PROTECTOR (4 cm) . . . . . . . . . . 1

HOSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

31

162017

RUBBER PROTECTOR (22 cm) . . . . . . . . . 1

11 12

Description

Qty. Req.

Description

Qty. Req.

RUBBER PROTECTOR (130 cm) . . . . . . . . 1

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 4

32

162017

RUBBER PROTECTOR (17 cm) . . . . . . . . . 1

13

162387

SEAL (204 cm) . . . . . . . . . . . . . . . . . . . . . . 1

33

163080

RUBBER MAT. . . . . . . . . . . . . . . . . . . . . . . . 1

14

163052

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

34

651424

CS M6-1.0 X 20 C 8.8 ZO. . . . . . . . . . . . . . . 4

15

651407

CS M12-1.7 X 40 C 8.8 ZO . . . . . . . . . . . . . 4

35

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . 4

16

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . 5

36

161666

WASHER/GR A 6.4 ZO DIN9021 . . . . . . . . . 8

17

161641

WASHER/GR 10.5 ZO . . . . . . . . . . . . . . . . 4

37

651457

HLN INS M6-1.0 8 Z0 . . . . . . . . . . . . . . . . . . 4

18

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . . 8

38

162835

STRAP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

19

163054

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

39

656093

CS M8-1.2 X 16 C 8.8 ZO. . . . . . . . . . . . . . . 2

20

163056

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

40

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

53

908545/BP0602

MODEL 802 MINI-EXCAVATOR DIESEL ENGINE MODEL 802 — AIR INTAKE

ET8002180

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

425-36136

10

425-36138

AIR FILTER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . . 6

3

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . 6

11

162619

NUT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

425-36098

4

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . 6

DUST INDICATOR . . . . . . . . . . . . . . . . . . . . 1

13

425-36135

AIR INTAKE HOSE . . . . . . . . . . . . . . . . . . . . 1

5

656048

HN M8-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . 4

14

425-36132

AIR INTAKE HOSE . . . . . . . . . . . . . . . . . . . . 1

6 7

160897

HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

425-36134

MUFFLER (RESONATOR) . . . . . . . . . . . . . . 1

160898

CAP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162611

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 4

8 9

160899

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 1

17

160892

AIR INTAKE HOSE . . . . . . . . . . . . . . . . . . . . 1

425-36137

AIR FILTER . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

163210

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 1

908545/BP0602

Description

Qty. Req.

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

54

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR DIESEL ENGINE MODEL 802 — EXHAUST

ET8002185

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163057

EXHAUST SUPPORT . . . . . . . . . . . . . . . . . 1

2

425-36139

MUFFLER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

425-34652

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

161109

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . . 2

6

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . 4

7

656048

HN M8-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . 8

8

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . 14

9

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . 14

Description

PRINTED IN U.S.A.

Qty. Req.

55

908545/BP0602

908545/BP0602

56

PRINTED IN U.S.A.

HYDRAULIC SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58 MODEL 802 — HYDRAULIC PUMP ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58 MODEL 802 — HYDRAULIC OIL TANK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59 MODEL 802 — HYDRAULIC OIL COOLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60 MODEL 802 — TRAVELING MOTORS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61 MODEL 802 — SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62 MODEL 802 — CONTROL VALVE 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63 MODEL 802 — CONTROL VALVE 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64 MODEL 802 — CONTROL VALVE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65 MODEL 802 — HYDRAULIC PUMP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66 MODEL 802 — TURNING MOTOR. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67 MODEL 802 — PILOT OIL SUPPLY UNIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68 MODEL 802 — SELECTION VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69 MODEL 802 — VALVE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70 MODEL 802 — DISTRIBUTION BLOCK (BIG) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71 MODEL 802 — DISTRIBUTION BLOCK (SMALL) . . . . . . . . . . . . . . . . . . . . . . . . . . . 72 MODEL 802 — HAND LEVERS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73 MODEL 802 — DOZER BLADE VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74 MODEL 802 — TRAVELING VALVES. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75 MODEL 802 — AUXILIARY HYDRAULICS CONTROL VALVE. . . . . . . . . . . . . . . . 76 MODEL 802 — BOOM CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77 MODEL 802 — STICK CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78 MODEL 802 — BUCKET CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79 MODEL 802 — BOOM OFFSET CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80 MODEL 802 — DOZER BLADE CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81 MODEL 802 — HYDRAULIC OIL COOLER INSTALLATION . . . . . . . . . . . . . . . . . . 82 MODEL 802 — BOOM OFFSET CYLINDER INSTALLATION . . . . . . . . . . . . . . . . . . 83 MODEL 802 — DOZER BLADE VALVE INSTALLATION . . . . . . . . . . . . . . . . . . . . . 84 MODEL 802 — TRACK STEERING MOTOR ASSEMBLY INSTALLATION . . . . . . 85 MODEL 802 — HAND LEVER INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86 MODEL 802 — PILOT OPERATED CHECK VALVE INSTALLATION . . . . . . . . . . . 87 MODEL 802 — TURNING MOTOR / DISTRIBUTOR INSTALLATION . . . . . . . . . . . 88 MODEL 802 — PRESSURE HOLDING VALVE INSTALLATION. . . . . . . . . . . . . . . . 89 MODEL 802 — HYDRAULIC PUMP INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . 90 MODEL 802 — BOOM INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91 MODEL 802 — BOOM CYLINDER INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . 92 MODEL 802 — BUCKET / STICK INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . 93

PRINTED IN U.S.A.

57

SECTION G: HYDRAULIC SYSTEM

SECTION G: HYDRAULIC SYSTEM

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — HYDRAULIC PUMP ASSEMBLY

ET8002190

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161153

COUPLING . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

163344

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

3

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . 12

Description

908545/BP0602

Qty. Req.

58

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — HYDRAULIC OIL TANK

ET8002195

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

163142

2

160816

HYDRAULIC OIL STORAGE TANK. . . . . . . . . . 1

17

161067

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

651405

3

161573

CS M12-1.7 X 30 C 10.9 ZO . . . . . . . . . . . . . . . . 4

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

163382

SCREW SEAL. . . . . . . . . . . . . . . . . . . . . . . . . . . 4

4

161485

REDUCER BUSHING . . . . . . . . . . . . . . . . . . . . 1

20

161382

PRESSURE SWITCH . . . . . . . . . . . . . . . . . . . . . 1

5

161568

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

656017

CS M12-1.7 X 35 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

6

160949

AIR FILTER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . . 4

7

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . . 6

23

161645

WASHER/GR. A 13 DIN7349 ZO . . . . . . . . . . . . 4

8

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 6

24

163079

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

HYDRAULIC OIL FILTER . . . . . . . . . . . . . . . . . . 1

9

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 6

25

161414

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

11

161056

OIL TANK COVER . . . . . . . . . . . . . . . . . . . . . . . 1

26

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

12

161577

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

27

161427

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

651393

CS M10-1.5 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . 6

28

161430

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 6

29

163100

OIL LEVEL GLASS . . . . . . . . . . . . . . . . . . . . . . . 1

15

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . 6

30

161415

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

161066

HYDRAULIC OIL FILTER ASSEMBLY . . . . . . . 1

31

161397

OIL STRAINER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

59

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — HYDRAULIC OIL COOLER

ET8002225

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161172

2

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 3

3

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 3

4

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 3

5

161495

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

163374

NON RETURN VALVE . . . . . . . . . . . . . . . . . . . . 1

7

161494

REDUCTION JOINT . . . . . . . . . . . . . . . . . . . . . 1

8

162494

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161456

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

HYDRAULIC OIL COOLER . . . . . . . . . . . . . . . . 1

908545/BP0602

60

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — TRAVELING MOTORS

ET8002025

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161149

TRAVELING MOTOR. . . . . . . . . . . . . . . . . . . . . 2

2

161483

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

3

161429

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

161209

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

61

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — SWIVEL JOINT

ET8002200

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

163068

SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

163356

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

2 3

163358

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

7

161450

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

163357

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

8

163355

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

163115

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161459

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

10

161174

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

62

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — CONTROL VALVE 1

ET8002205

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161152

2

161676

CONTROL VALVE . . . . . . . . . . . . . . . . . . . . . . . 1

11

163360

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 3

12

162496

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

651516

SHCS HS M8-1.2 X 25 8.8 ZO D912 . . . . . . . . . 3

13

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

163351

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161443

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

161427

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

15

161474

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

163133

HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

163354

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

163367

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

163136

PRESSURE LIMITING VALVE . . . . . . . . . . . . . . 2

8

161210

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

163066

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162494

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

163067

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

163364

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Description

PRINTED IN U.S.A.

Qty. Req.

63

Description

Qty. Req.

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — CONTROL VALVE 2

ET8002210

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161148

CONTROL VALVE . . . . . . . . . . . . . . . . . . . . . . . 1

15

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

2

651394

CS M10-1.5 X 25 C 10.9 ZO . . . . . . . . . . . . . . . 3

16

163361

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

3

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . 3

17

163097

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 3

18

162034

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

5

161414

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

19

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . . 4

6

161501

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

20

163381

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

8

163102

NON RETURN VALVE . . . . . . . . . . . . . . . . . . . . 1

21

163353

REDUCTION JOINT . . . . . . . . . . . . . . . . . . . . . . 1

9

163372

REDUCTION JOINT . . . . . . . . . . . . . . . . . . . . . 1

22

161433

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

163360

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

23

162494

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161585

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

24

163351

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

162386

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 6

25

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . . 4

13

163362

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

26

163364

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

163371

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

27

161586

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

Description

908545/BP0602

Qty. Req.

Ref. No.

64

Part No.

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — CONTROL VALVE

ET8002213

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

163072

2

163065

VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

163110

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

163105

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

163104

PRESSURE LIMITING VALVE. . . . . . . . . . . . . . 6

10

163107

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

163108

PISTON END . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

163286

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

163103

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

163106

7

163111

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

65

Description

Qty. Req.

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — HYDRAULIC PUMP

ET8002220

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161150

HYDRAULIC PUMP . . . . . . . . . . . . . . . . . . . . . . 1

15

161151

2 3

163087

FLANGE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

163344

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

161580

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161514

MEASURE JOINT . . . . . . . . . . . . . . . . . . . . . . . . 2

4 5

651497

SHCS HS M16-1.5 X 50 10.9 ZO D912 . . . . . . . 4

18

163378

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

161672

LOCKWASHER S16 . . . . . . . . . . . . . . . . . . . . . 4

19

163099

FLANGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

6

163134

FLANGE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

161426

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

161591

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

21

651510

SHCS HS M6-1 X 35 12.9 ZO D912 . . . . . . . . . . 4

8

163363

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

22

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . . 8

9

161450

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

163383

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

10

651476

SHCS HS M10-1.2 X 35 10.9 ZO D912 . . . . . . . 8

24

163135

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . 10

25

651424

CS M6-1.0 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 4

12

163368

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

26

161162

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

27

161211

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

163380

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

66

Description

Qty. Req.

HYDRAULIC PUMP . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — TURNING MOTOR

ET8002230

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1

161173

TURNING MOTOR . . . . . . . . . . . . . . . . . . . . . . 1

13

162494

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

163070

HYDRAULIC MOTOR . . . . . . . . . . . . . . . . . . . . 1

14

161503

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

3

163069

TURNING MOTOR . . . . . . . . . . . . . . . . . . . . . . 1

15

161456

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

163364

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

161213

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161501

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

17

161212

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

163298

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

18

161175

BRAKE VALVE MANDREL . . . . . . . . . . . . . . . . . 2

7

161425

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

161176

BRAKE VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161418

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

161178

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161423

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

161177

PINION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161429

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

67

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — PILOT OIL SUPPLY UNIT

ET8002235

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160594

2

161567

PILOT OIL SUPPLY UNIT . . . . . . . . . . . . . . . . . 1

8

161514

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162790

3

160437

ACCUMULATOR . . . . . . . . . . . . . . . . . . . . . . . . 1

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 4

4

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

5

161443

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 4

12

161661

6

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

13

160571

SOLENOID SWITCH. . . . . . . . . . . . . . . . . . . . . .2

7

161450

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

160572

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

68

Description

Qty. Req.

MEASURE JOINT . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — SELECTION VALVE

ET8002240

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160763

SELECTION VALVE. . . . . . . . . . . . . . . . . . . . . . 1

2

161427

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

3

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

651428

CS M6-1.0 X 50 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

5

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 2

6

161660

WASHER/GR A 6.4 ZO DIN125 . . . . . . . . . . . . 4

7

161678

HN M6-1.0 8 ZO. . . . . . . . . . . . . . . . . . . . . . . . . 2

10

160438

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

69

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — VALVE

ET8002245

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161156

VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

163364

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

3

163354

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

656172

CS M6-1.0 X 45 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

5

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 2

6

161660

WASHER/GR A 6.4 ZO DIN125. . . . . . . . . . . . . 2

Description

908545/BP0602

Qty. Req.

70

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — DISTRIBUTION BLOCK (BIG)

ET8002250

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163098

DISTRIBUTION BLOCK . . . . . . . . . . . . . . . . . . 1

2

163366

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

3

163359

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

163365

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161433

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161155

BALL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

163351

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

8

162122

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . 2

10

161624

LW SPRING B12 DIN 7982 . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

71

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — DISTRIBUTION BLOCK (SMALL)

ET8002255

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163096

DISTRIBUTION BLOCK. . . . . . . . . . . . . . . . . . . 1

2

163360

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

3

163356

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

908545/BP0602

Qty. Req.

72

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — HAND LEVERS

ET8002260

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161180

CONTROL LEVER. . . . . . . . . . . . . . . . . . . . . . . 1

7

160487

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2 3

161179

CONTROL LEVER. . . . . . . . . . . . . . . . . . . . . . . 1

8

160486

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161437

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

9

160463

JOYSTICK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

651507

SHCS HS M6-1 X 20 8.8 ZO D912 . . . . . . . . . . 8

10

160470

BELLOWS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 8

11

160469

HANDLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161660

WASHER/GR A 6.4 ZO DIN125 . . . . . . . . . . . . 8

Description

PRINTED IN U.S.A.

Qty. Req.

73

Description

Qty. Req.

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — DOZER BLADE VALVE

ET8002265

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

2

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

9

160918

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 4

10

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . . 1

4

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

11

656017

CS M12-1.7 X 35 C 8.8 ZO . . . . . . . . . . . . . . . . . 1

5

161615

NUT/CAGE M8. . . . . . . . . . . . . . . . . . . . . . . . . . 4

12

161764

KNOB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

6

160912

CONTROL LEVER . . . . . . . . . . . . . . . . . . . . . . . 1

13

162027

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

14

160947

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161049

LEVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

Ref. No.

74

Part No.

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — TRAVELING VALVES

ET8002270

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

2

656001

3

161676

4

161661

Ref. No.

Part No.

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

12

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . . 2

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 4

13

656017

CS M12-1.7 X 35 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

14

160658

KNOB WITH RED SWITCH . . . . . . . . . . . . . . . . 1 SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

Qty. Req.

Description

Qty. Req.

5

161615

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . 4

15

162027

6

160760

CONTROL LEVER. . . . . . . . . . . . . . . . . . . . . . . 2

16

161450

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

18

161443

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

8

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

19

161764

KNOB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

160930

HAND LEVER, TRAVELING . . . . . . . . . . . . . . . 1

20

160918

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

10

160931

HAND LEVER, TRAVELING . . . . . . . . . . . . . . . 1

21

160947

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

11

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

75

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — AUXILIARY HYDRAULICS CONTROL VALVE

ET8002275

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161154

CONTROL LEVER . . . . . . . . . . . . . . . . . . . . . . . 1

7

161450

2 3

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

8

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 4

9

161443

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

4

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

11

160918

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161615

NUT/CAGE M8. . . . . . . . . . . . . . . . . . . . . . . . . . 4

12

160947

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Description

908545/BP0602

Qty. Req.

76

Description

Qty. Req.

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — BOOM CYLINDER

ET8002280

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161144

BOOM CYLINDER, COMPLETE, R . . . . . . . . . 1

16

161146

SHIELD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

161141

BOOM CYLINDER, COMPLETE, L . . . . . . . . . . 1

17

161650

WASHER/GR A 19 ZO DIN125. . . . . . . . . . . . . . 2

3

161181

BOOM CYLINDER HOUSING, R . . . . . . . . . . . . 1

18

651467

PIN/SPRING M5 X 30 D1481 . . . . . . . . . . . . . . . 1

4

161182

BOOM CYLINDER HOUSING, L . . . . . . . . . . . . 1

19

161145

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161159

PISTON ROD. . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

161147

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161163

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

163377

HOSE CLAMP. . . . . . . . . . . . . . . . . . . . . . . . . . . 4

7

161169

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

651408

CS M12-1.7 X 40 C 10.9 ZO . . . . . . . . . . . . . . . . 2

8

161216

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

651449

HLN INS M12-1.7 ZO . . . . . . . . . . . . . . . . . . . . . 2

10

162481

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

24

651405

CS M12-1.7 X 30 C 10.9 ZO . . . . . . . . . . . . . . . . 2

12

161526

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

25

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . . 2

13

161582

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

26

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . . 2

14

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 4

27

161205

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

15

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 4

Description

PRINTED IN U.S.A.

Qty. Req.

Ref. No.

77

Part No.

Description

Qty. Req.

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — STICK CYLINDER

ET8002285

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161140

STICK CYLINDER . . . . . . . . . . . . . . . . . . . . . . . 1

15

161583

2 3

161183

CYLINDER HOUSING . . . . . . . . . . . . . . . . . . . . 1

16

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 1

161158

PISTON ROD . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161422

PROTECTION CAP. . . . . . . . . . . . . . . . . . . . . . .1

4

161164

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

161461

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161168

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

161469

SLEEVE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161215

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

161468

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162481

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

161392

LUBRICATION TUBE (212 cm) . . . . . . . . . . . . . . 1

14

161523

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

908545/BP0602

Qty. Req.

78

Description

Qty. Req.

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — BUCKET CYLINDER

ET8002290

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161139

2

161184

BUCKET CYLINDER . . . . . . . . . . . . . . . . . . . . . 1

7

162481

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

BUCKET CYLINDER HOUSING . . . . . . . . . . . . 1

8

161524

BUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

3

161157

PISTON ROD. . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161163

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161581

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

10

161412

5

161167

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 2

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

6

161214

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

79

Description

Qty. Req.

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — BOOM OFFSET CYLINDER

ET8002295

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161142

2

161185

BOOM OFFSET CYLINDER . . . . . . . . . . . . . . . 1

9

162481

CYLINDER HOUSING . . . . . . . . . . . . . . . . . . . . 1

14

163352

3

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

161160

PISTON ROD . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

163375

BUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

161165

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161584

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

5

161170

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 1

6

161217

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

161422

PROTECTION CAP. . . . . . . . . . . . . . . . . . . . . . .1

Description

908545/BP0602

Qty. Req.

80

Description

Qty. Req.

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — DOZER BLADE CYLINDER

ET8002300

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1

161143

DOZER BLADE CYLINDER . . . . . . . . . . . . . . . 2

9

161171

2

161522

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

10

161166

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

3

161582

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

11

162481

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 4

12

161218

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

162928

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 4

13

163352

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

6

161186

CYLINDER HOUSING . . . . . . . . . . . . . . . . . . . . 2

14

163354

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

8

161161

PISTON ROD. . . . . . . . . . . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

81

GLAND . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — HYDRAULIC OIL COOLER INSTALLATION

ET8002305

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163328

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

2

163325

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

82

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — BOOM OFFSET CYLINDER INSTALLATION

ET8002310

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163304

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

2

163309

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

3

162445

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

4

163289

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

5

163308

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

83

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — DOZER BLADE VALVE INSTALLATION

ET8002315

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163301

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

2

163302

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

3

163303

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

4

163306

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

5

163307

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

6

161354

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

7

161224

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

84

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — TRACK STEERING MOTOR ASSEMBLY INSTALLATION

ET8002320

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

163300

2

163299

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

7

163311

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

8

163313

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

3

163310

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 4

9

163321

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

4

163292

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

10

163297

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

5

161256

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

11

162414

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

6

163312

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

12

162960

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

85

Description

Qty. Req.

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — HAND LEVER INSTALLATION

ET8002325

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163288

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . 12

2

161479

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

3

161465

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

161350

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 3

5

162959

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 4

6

162445

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

7

161354

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

86

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — PILOT OPERATED CHECK VALVE INSTALLATION

ET8002330

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161236

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 6

2

161351

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

3

161220

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

4

163291

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

5

163335

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 3

6

163290

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

7

161223

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

8

161240

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

87

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — TURNING MOTOR / DISTRIBUTOR INSTALLATION

ET8002335

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163305

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

2

163326

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

3

163329

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

4

161310

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

5

161223

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

6

161245

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

7

163294

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

8

161236

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

88

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — PRESSURE HOLDING VALVE INSTALLATION

ET8002340

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161236

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

2

161223

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 3

3

162447

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

89

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — HYDRAULIC PUMP INSTALLATION

ET8002345

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

163101

HOSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

163293

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

2 3

163109

SUCTION HOSE . . . . . . . . . . . . . . . . . . . . . . . . 1

7

163295

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

163333

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

8

163296

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

4

163332

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

9

163320

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

5

163330

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

10

163209

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Description

908545/BP0602

Qty. Req.

90

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — BOOM INSTALLATION

ET8002350

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

163082

2

163083

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

163063

COLLAR FOR HIGH PRESSURE TUBE . . . . . . 4

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

163376

FASTENER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

3

163084

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

163085

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

163377

FASTENER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

10

651404

5

163086

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

CS M12-1.7 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . 10

11

651408

CS M12-1.7 X 40 C 10.9 ZO . . . . . . . . . . . . . . . . 4

6

163062

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

651409

HB M12-1.7X 50 C 10.9 ZO . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

91

Description

Qty. Req.

908545/BP0602

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — BOOM CYLINDER INSTALLATION

ET8002355

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163092

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

163093

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

163317

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

3

163094

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

163316

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

4

163095

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

163163

HOSE COVER. . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

163373

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

12

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 4

6

163379

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

13

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 4

7

163323

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

14

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . . 4

Description

908545/BP0602

Qty. Req.

92

Ref. No.

Part No.

8

163324

Description

Qty. Req.

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 802 — BUCKET / STICK INSTALLATION

ET8002360

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

163089

2

163088

3

163379

Ref. No.

Part No.

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

163315

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 2

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

163334

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

17

163318

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 2 LUBRICATION TUBE (212 cm). . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

4

163373

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

18

161392

5

163322

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

19

161468

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

163327

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

20

161469

SLEEVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

163369

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

21

161461

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

163350

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

22

161411

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 1

9

163370

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

23

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 1

10

163090

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

163377

HOSE CLAMP. . . . . . . . . . . . . . . . . . . . . . . . . . . 2

11

163091

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

25

651404

CS M12-1.7 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

12

163319

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

26

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . . 2

13

163331

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

27

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . . 2

14

163314

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

93

908545/BP0602

908545/BP0602

94

PRINTED IN U.S.A.

ELECTRICAL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96 MODEL 802 — ELECTRICAL INSTALLATION 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96 MODEL 802 — ELECTRICAL INSTALLATION 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97 MODEL 802 — CONTROL BOARD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98 MODEL 802 — RELAY BOX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99 MODEL 802 — RELAY BOX INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100 MODEL 802 — LIGHTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101 MODEL 802 — WORKING HEADLIGHTS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102 MODEL 802 — BATTERY INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103 MODEL 802 — HORN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 104

PRINTED IN U.S.A.

95

SECTION H: ELECTRICAL SYSTEM

SECTION H: ELECTRICAL SYSTEM

908545/BP0602

MODEL 802 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 802 — ELECTRICAL INSTALLATION 1

ET8002365

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161105

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

2

162851

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

162848

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161387

RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

96

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 802 — ELECTRICAL INSTALLATION 2

ET8002366

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

1

161106

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

2

162849

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

162850

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161732

SOCKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161361

MICRO SWITCH . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

97

908545/BP0602

MODEL 802 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 802 — CONTROL BOARD

ET8002367

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160744

2

160535

CONTROL BOARD . . . . . . . . . . . . . . . . . . . . . . 1

18

161376

FUSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

CONTROL BOARD . . . . . . . . . . . . . . . . . . . . . . 1

19

161374

3

FUSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161364

FUSE BOX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

162836

FUSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161375

FUSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

21

161365

BUZZER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

5

161377

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

162845

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161378

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

161384

LAMP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

161372

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

161383

LAMP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161996

FRAME. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

25

162846

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

9

161380

IGNITION SWITCH ASSEMBLY . . . . . . . . . . . . 1

26

161385

10

162841

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

27

161111

RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

162842

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

28

161386

RELAY BRACKET . . . . . . . . . . . . . . . . . . . . . . . . 2

12

161107

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

29

162838

FUSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162843

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

30

162847

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162844

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

31

160713

KEY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161369

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

32

161368

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

16

161370

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

33

161858

FUSE HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

162837

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908545/BP0602

98

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 802 — RELAY BOX

ET8002368

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162717

2

161613

RELAY PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

160889

RELAY. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

NUT/CAGE M6 . . . . . . . . . . . . . . . . . . . . . . . . . 4

13

160821

RELAY. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3 4

161660

WASHER/GR A 6.4 ZO DIN125 . . . . . . . . . . . . 4

14

160891

RELAY. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 4

15

163014

FUSE HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

651424

CS M6-1.0 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 8

16

162025

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

161614

NUT/CAGE M6 . . . . . . . . . . . . . . . . . . . . . . . . . 4

17

651422

CS M5-0.8 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

7

162727

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

656047

HN M6-1.0 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

8

161659

WASHER/GR A 5.3 ZO DIN125 . . . . . . . . . . . . 4

19

656100

HN M5-.8 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

Qty. Req.

Description

Qty. Req.

9

161674

LOCKWASHER S5 . . . . . . . . . . . . . . . . . . . . . . 4

20

651457

HLN INS M6-1.0 8 Z0 . . . . . . . . . . . . . . . . . . . . . 6

10

651423

CS M5-0.8 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

21

651456

HLN INS M5-.8 8 ZO . . . . . . . . . . . . . . . . . . . . . . 2

11

161103

RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

99

908545/BP0602

MODEL 802 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 802 — RELAY BOX INSTALLATION

ET8002369

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161616

NUT/CAGE M8. . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

162608

CLAMP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

656094

CS M8-1.2 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . . 1

4

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 1

5

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 1

6

161105

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

Description

908545/BP0602

Qty. Req.

100

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 802 — LIGHTS

ET8002370

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161381

INTEGRATED LIGHT . . . . . . . . . . . . . . . . . . . . 1

6

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . . 8

2

161367

HALOGEN LAMP. . . . . . . . . . . . . . . . . . . . . . . . 2

7

161666

WASHER/GR A 6.4 ZO DIN9021 . . . . . . . . . . . . 8

3

160883

LIGHT COVER. . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

162390

WIRING HARNESS. . . . . . . . . . . . . . . . . . . . . . . 1

4

161614

NUT/CAGE M6 . . . . . . . . . . . . . . . . . . . . . . . . . 8

9

651501

SHCS HS M4-0.7 X 30 8.8 ZO D912 . . . . . . . . . 4

5

656149

CS M6-1.0 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . 8

10

160537

HEADLIGHT HOUSING . . . . . . . . . . . . . . . . . . . 2

Description

PRINTED IN U.S.A.

Qty. Req.

Ref. No.

101

Part No.

Description

Qty. Req.

908545/BP0602

MODEL 802 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 802 — WORKING HEADLIGHTS

ET8002371

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160951

2

161367

HALOGEN LAMP . . . . . . . . . . . . . . . . . . . . . . . . 1

3

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 1

4

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . 2

5

161108

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

6

162002

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162852

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

WORKING LIGHT . . . . . . . . . . . . . . . . . . . . . . . 1

908545/BP0602

102

PRINTED IN U.S.A.

MODEL 802 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 802 — BATTERY INSTALLATION

ET8002375

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162468

BATTERY. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

162735

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 1

4

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . 1

5

162818

CABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162817

CABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

103

908545/BP0602

MODEL 802 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 802 — HORN

ET8002380

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161366

2

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 1

3

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 1

4

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

HORN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908545/BP0602

104

PRINTED IN U.S.A.

SECTION I: TOOLS

SECTION I: TOOLS

TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106 MODEL 802 — TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106

PRINTED IN U.S.A.

105

908545/BP0602

MODEL 802 MINI-EXCAVATOR TOOLS MODEL 802 — TOOLS

ET8002385

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161989

2

161990

SCREW DRIVERS AND WRENCHES . . . . . . . 1

3

161991

HAMMER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161992

GREASE GUN . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161988

TOOL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

TOOL ORGANIZER . . . . . . . . . . . . . . . . . . . . . . 1

908545/BP0602

106

PRINTED IN U.S.A.

SECTION J: DECALS

SECTION J: DECALS

DECALS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108 MODEL 802 — DECALS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108

PRINTED IN U.S.A.

107

908545/BP0602

MODEL 802 MINI-EXCAVATOR DECALS MODEL 802 — DECALS

ET8002390

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162668

2

161981

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161969

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

18

161987

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3 4

163341

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

19

161982

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

161985

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

161974

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

163339

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

21

162824

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161986

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

163340

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162831

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

161970

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

163336

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

163337

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

163342

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

25

162825

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161965

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

26

161967

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

11

162449

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

28

162013

ID-PLATE (BIG) . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

162452

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

29

163338

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162451

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

30

162833

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162450

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

31

162834

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

162822

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

32

163287

DECAL SET. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

161966

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908545/BP0602

108

PRINTED IN U.S.A.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

1405411 160407 160408 160409 160427 160437 160438 160463 160469 160470 160481 160486 160487 160488 160494 160495 160496 160525 160526 160527 160532 160533 160535 160537 160571 160572 160594 160611 160638 160639

50 45 45 16 48 68 69 73 73 73 35 73 73 35 39 39 40 42 36 36 45 45 98 101 68 68 68 45 7 39 40 39 40 39 41 21 75 33 37 42 42 98 33 37 33 37 35 98 51 75 69 59 99 49 48 20 22 101 7 99 99 54 54 54 54 52 74 74 75 76 75 75 7 74 75 76 59 102 12 12 38 38 74 59 21 20

11 7 8 19 7 3 10 9 11 10 8 8 7 11 11 1 1 3 10 11 31 32 2 10 13 14 1 12 3 8 5 7 4 17 4 18 14 1 23 8 7 31 8 19 9 18 13 1 1 6 1 2 13 15 9 3 4 3 14 12 14 17 6 7 8 7 6 9 20 11 9 10 48 14 21 12 6 1 7 8 1 2 8 11 4 19

161059 161060 161061

49 49 20 22 20 21 23 20 22 49 59 59 7 7 7 7 7 7 7 10 7 8 7 9 44 42 42 40 40 40 40 35 35 35 35 36 36 40 41 41 41 42 42 42 42 43 43 99 49 96 100 97 98 102 55 98 48 52 48 30 29 30 30 30 79 29 78 28 77 16 80 14 81 28 77 77 77 77 64 7 61 66 66 63 58 76

2 3 17 15 24 5 18 14 11 18 16 17 8 9 19 5 6 2 44 11 45 10 46 10 1 12 13 2 10 11 14 3 2 5 7 23 24 3 1 2 3 1 6 9 15 1 2 11 11 1 6 1 12 5 4 27 25 21 1 1 1 3 2 17 1 16 1 16 2 6 1 11 1 17 1 19 16 20 1 7 1 1 15 1 1 1

161155 161156 161157 161158 161159 161160 161161 161162 161163

71 70 79 78 77 80 81 66 77 79 78 80 81 79 78 77 80 81 60 16 67 62 67 67 67 67 73 73 77 77 78 79 80 81 20 21 14 14 14 30 29 29 29 30 30 30 28 28 28 16 16 29 30 22 77 16 7 11 7 61 63 66 67 67 79 78 77 80 81 87 87 88 89 84 18 87 88 89 87 88 85 88 86 87 84 86

6 1 3 3 5 3 8 26 6 4 4 4 10 5 5 7 5 9 1 25 1 10 18 19 21 20 2 1 3 4 2 2 2 6 25 12 8 5 2 10 8 9 2 4 5 6 9 2 8 8 4 17 13 9 27 13 47 8 49 6 8 27 17 16 6 6 8 6 12 3 7 5 2 7 9 1 8 1 8 6 5 4 4 2 6 7

161358 161361

20 45 97 98 98 104 101 102 98 98 98 98 98 98 98 98 98 98 101 59 98 98 98 98 96 50 50 18 78 93 33 40 42 59 45 40 29 30 28 29 29 30 14 18 30 93 7 28 29 77 78 79 80 81 59 64 49 59 7 14 30 7 67 16 16 18 77 78 79 80 93 67 67 49 59 61 62 66 68 69 74 75 76 49 59 63

34 37 5 3 21 1 2 2 32 15 16 7 19 4 18 5 6 9 1 20 24 23 26 28 4 8 9 10 21 18 13 12 10 31 17 6 18 20 4 4 12 16 9 5 8 22 21 14 14 14 16 10 18 4 25 5 8 30 22 10 9 20 8 17 18 6 15 17 11 19 23 9 7 10 26 4 4 20 4 3 7 7 6 9 27 5

160640 160641 160642 160644 160658 160711 160712 160713 160714 160715 160716 160744 160755 160760 160763 160816 160821 160844 160845 160882 160883 160886 160889 160891 160892 160897 160898 160899 160903 160912 160918 160930 160931 160945 160947 160949 160951 160983 160987 160988 161049 161056 161057 161058

PRINTED IN U.S.A.

161062 161063 161064 161065 161066 161067 161068 161069 161070 161071 161072 161073 161074 161075 161076 161077 161078 161079 161080 161081 161082 161083 161084 161085 161086 161087 161088 161089 161091 161092 161093 161094 161095 161096 161097 161098 161099 161100 161103 161104 161105 161106 161107 161108 161109 161111 161112 161113 161114 161135 161136 161137 161138 161139 161140 161141 161142 161143 161144 161145 161146 161147 161148 161149 161150 161151 161152 161153 161154

161164 161165 161166 161167 161168 161169 161170 161171 161172 161173 161174 161175 161176 161177 161178 161179 161180 161181 161182 161183 161184 161185 161186 161187 161188 161189 161190 161191 161192 161193 161194 161195 161196 161197 161198 161199 161200 161201 161202 161203 161204 161205 161206 161207 161208 161209 161210 161211 161212 161213 161214 161215 161216 161217 161218 161220 161223 161224 161226 161236 161240 161245 161256 161310 161350 161351 161354

109

161364 161365 161366 161367 161368 161369 161370 161372 161374 161375 161376 161377 161378 161380 161381 161382 161383 161384 161385 161386 161387 161391 161392 161395 161396 161397 161403 161404 161405 161409

161411

161412

161414 161415 161416 161417 161418 161420 161422

161423 161425 161426

161427

NUMERICAL INDEX

802

908545/BP0602

802 Part No. 161429 161430 161433 161437 161443

161448

161450

NUMERICAL INDEX

161456 161457 161459 161461 161465 161468 161469 161474 161479 161482 161483 161485 161494 161495 161501 161503 161514 161517 161518 161519 161521 161522 161523 161524 161525 161526 161528 161567 161568 161570 161573 161577 161578 161580 161581

161582 161583 161584 161585 161586 161591 161610 161611 161613 161614 161615

908545/BP0602

Page No.

Ref. No.

69 61 67 59 64 71 73 63 68 75 76 63 64 66 68 75 76 62 66 68 75 76 60 67 18 62 18 78 93 86 18 78 93 18 78 93 63 86 18 61 59 60 60 64 67 67 66 68 30 28 29 14 81 78 79 16 77 29 30 68 59 16 59 59 7 66 14 29 30 79 77 81 28 29 78 80 64 64 66 25 19 99 99 101 37 45

2 3 12 28 22 5 3 14 5 18 9 13 15 13 6 8 8 7 9 7 16 7 9 15 13 5 7 18 21 3 11 20 19 12 19 20 15 2 8 2 4 7 5 6 5 14 17 8 7 3 3 3 2 14 8 3 12 11 15 2 5 22 3 12 4 3 4 13 14 9 13 3 5 5 15 17 11 27 7 10 4 2 6 4 27 6

Part No.

161616

161618 161619 161621 161624 161625 161626 161627 161628 161635 161636 161640

161641 161642

161643 161645 161646 161647 161650 161651 161653 161658 161659 161660

161661

161663 161666 161667

Page No.

Ref. No.

74 75 76 20 23 24 25 53 100 39 19 21 71 7 19 16 21 45 7 7 7 16 25 28 33 45 52 59 64 64 102 19 53 16 19 21 33 53 75 77 93 7 33 37 49 52 59 7 7 16 77 45 21 49 20 99 20 69 70 73 99 20 20 22 22 37 45 50 54 59 60 68 74 75 76 100 7 24 25 45 53 101 17 20 23 24

5 5 5 11 5 10 14 24 1 10 7 8 10 34 9 20 19 39 43 37 39 31 13 13 6 18 10 15 3 25 4 13 17 12 16 11 10 27 11 26 27 36 3 21 6 13 23 35 42 24 17 15 2 14 31 8 23 6 6 6 3 7 10 8 16 11 5 6 4 9 4 12 4 4 4 5 41 4 6 36 36 7 8 29 4 9

110

Part No.

161668 161669

161670

161671 161672 161673 161674 161675

161676

161677 161678 161691 161722 161728 161730 161732 161764 161805

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

52 53 55 92 103 104 39 51 7 16 19 24 25 28 33 52 58 59 64 64 66 102 16 16 19 21 49 52 53 59 71 74 75 77 93 30 66 49 20 99 18 20 21 45 53 66 69 70 73 99 101 7 17 20 22 23 24 25 37 45 50 51 52 53 54 55 59 60 63 68 74 75 76 92 100 104 19 69 19 18 45 45 97 74 75 45

20 10 9 14 3 4 9 13 40 30 12 3 5 12 7 9 3 14 4 19 11 3 11 27 15 10 5 12 16 22 9 10 12 25 26 19 5 13 30 9 3 22 7 35 35 22 5 5 5 4 6 38 7 6 7 3 8 12 26 4 5 12 19 9 3 8 8 3 2 11 3 3 3 13 4 3 6 7 8 1 33 9 4 12 19 26

161831 161843 161848 161858 161868 161921 161922 161923 161924 161929

45 36 45 98 45 35 35 35 35 20 21 43 39 45 36 40 53 53 39 37 39 40 108 108 108 108 108 108 108 108 108 108 108 106 106 106 106 106 98 102 35 52 108 17 17 17 17 17 17 17 17 17 17 17 17 17 17 17 22 17 17 17 17 17 17 53 53 53 53 53 53 36 36 40 99 74 75 36 39 64 35 37 37 45 20 71

11 14 13 33 16 15 16 18 17 28 15 10 6 20 3 17 21 22 12 24 15 15 10 16 26 17 23 20 2 19 4 6 18 5 1 2 3 4 8 6 23 17 28 10 12 14 15 16 18 19 23 24 25 26 30 31 11 27 18 9 13 17 22 28 29 23 28 29 30 31 32 1 2 9 16 13 15 12 4 18 28 6 2 24 9 8

161937 161941 161947 161949

161951 161964 161965 161966 161967 161969 161970 161974 161981 161982 161985 161986 161987 161988 161989 161990 161991 161992 161996 162002 162006 162008 162013 162015

162016 162017

162018 162025 162027 162029 162033 162034 162035 162036 162044 162048 162072 162122

PRINTED IN U.S.A.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

162189 162210 162211 162212 162213 162214 162349 162350 162351 162386 162387 162388

23 45 45 45 45 45 51 51 51 64 53 23 25 20 101 51 85 83 86 89 108 108 108 108 103 77 78 79 80 81 51 60 63 64 67 63 49 50 51 36 39 39 39 20 21 39 35 100 54 50 54 22 52 52 19 22 108 43 45 20 22 20 22 99 99 103 35 35 42 45 51 36 68 19 23 21 35 35 35 35 35 36 36 36 36 36

9 27 28 29 30 21 5 6 4 12 13 17 16 12 8 3 11 3 6 3 11 14 13 12 1 10 9 7 9 11 8 8 9 23 13 12 17 10 9 4 18 2 3 26 13 13 19 2 16 7 11 1 5 6 21 2 1 11 38 4 5 2 3 1 7 2 29 22 19 2 2 25 9 2 6 17 4 6 10 12 27 7 18 19 20 21

162805 162806 162807 162808 162809 162810 162811 162812 162813 162814 162815 162816 162817 162818 162819 162820 162822 162824 162825 162831 162833 162834 162835 162836 162837 162838 162839 162840 162841 162842 162843 162844 162845 162846 162847 162848 162849 162850 162851 162852 162857 162862 162863

36 37 37 37 37 37 38 40 42 42 43 43 103 103 19 19 108 108 108 108 108 108 53 98 98 98 35 35 98 98 98 98 98 98 98 96 97 97 96 102 36 36 36 36 42 39 35 37 37 42 35 36 36 49 28 29 81 86 85 99 12 12 12 12 12 12 35 35 37 37 37 42 42 43 43 43 43 43 52 52 52 52 53 16 53 52

22 3 5 7 8 16 3 7 17 21 5 8 6 5 26 27 15 21 25 7 30 31 38 20 17 29 24 26 10 11 13 14 22 25 30 3 2 3 2 7 9 5 13 26 4 14 9 17 14 14 21 17 6 16 15 15 5 5 12 15 2 3 4 5 6 9 1 25 1 4 13 2 20 3 4 6 7 9 1 2 3 4 14 28 19 22

163056 163057 163061 163062 163063 163064 163065 163066 163067 163068

53 55 28 91 91 16 65 63 63 7 62 67 67 65 28 16 19 19 19 19 49 59 53 23 91 91 91 91 91 66 93 93 93 93 92 92 92 92 72 64 71 66 59 90 64 65 65 65 65 65 65 90 65 65 62 63 66 66 63 21 16 23 19 49 59 19 23 23 24 24 25 25 23 23 23 17 17 17 17 19 24 24 20 20 92 25

20 1 1 6 7 2 2 18 19 10 1 3 2 1 10 9 22 25 23 24 7 24 33 16 1 2 3 4 5 2 2 1 10 11 1 2 3 4 1 17 1 19 29 1 8 11 4 9 12 10 5 2 8 7 9 6 6 24 17 1 1 11 1 1 1 5 2 1 1 6 1 3 15 8 10 1 4 2 3 19 12 11 1 8 11 2

163165 163166 163167 163168 163169 163170 163171 163172 163173 163174 163175

17 53 21 7 7 7 7 7 14 7 7 16 10 10 10 10 10 10 10 10 10 10 8 8 9 8 9 8 9 8 9 8 9 8 9 8 9 8 9 11 11 11 11 11 11 11 9 7 12 28 29 30 90 54 45 65 108 86 83 87 87 85 90 88 90 90 85 67 85 85 84 84 84 83 88 84 84 83 83 85 85 85 85 93 93 92

5 25 16 1 15 16 18 17 1 13 11 21 1 2 3 4 5 6 7 8 9 10 1 2 2 3 3 4 4 5 5 6 6 7 7 8 8 9 9 1 2 3 4 5 6 7 1 12 1 6 10 11 10 18 22 6 32 1 4 6 4 4 6 7 7 8 10 6 2 1 1 2 3 1 1 4 5 5 2 3 7 6 8 14 15 10

162389 162390 162398 162414 162445 162447 162449 162450 162451 162452 162468 162481

162487 162494

162496 162504 162505 162600 162601 162602 162603 162604 162606 162607 162608 162611 162617 162619 162658 162659 162660 162666 162667 162668 162673 162674 162675 162716 162717 162727 162735 162736 162737 162738 162747 162789 162790 162791 162792 162794 162795 162796 162797 162798 162799 162800 162801 162802 162803 162804

PRINTED IN U.S.A.

162864 162868 162869 162870 162923 162924 162925 162926 162928 162959 162960 163014 163030 163031 163032 163033 163034 163035 163036 163037 163038 163039 163040 163041 163042 163043 163044 163045 163046 163047 163048 163049 163050 163051 163052 163053 163054 163055

163069 163070 163072 163073 163074 163075 163076 163077 163078 163079 163080 163081 163082 163083 163084 163085 163086 163087 163088 163089 163090 163091 163092 163093 163094 163095 163096 163097 163098 163099 163100 163101 163102 163103 163104 163105 163106 163107 163108 163109 163110 163111 163115 163133 163134 163135 163136 163137 163138 163139 163140 163141 163142 163143 163144 163145 163146 163147 163148 163149 163150 163151 163152 163153 163154 163155 163156 163157 163159 163160 163161 163162 163163 163164

111

163176 163177 163178 163179 163180 163181 163182 163183 163184 163185 163186 163187 163188 163189 163190 163191 163192 163193 163194 163195 163196 163197 163198 163199 163200 163201 163202 163203 163205 163209 163210 163225 163286 163287 163288 163289 163290 163291 163292 163293 163294 163295 163296 163297 163298 163299 163300 163301 163302 163303 163304 163305 163306 163307 163308 163309 163310 163311 163312 163313 163314 163315 163316

NUMERICAL INDEX

802

908545/BP0602

NUMERICAL INDEX

802 Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

163317 163318 163319 163320 163321 163322 163323 163324 163325 163326 163327 163328 163329 163330 163331 163332 163333 163334 163335 163336 163337 163338 163339 163340 163341 163342 163343 163344

92 93 93 90 85 93 92 92 82 88 93 82 88 90 93 90 90 93 87 108 108 108 108 108 108 108 49 58 66 20 22 29 52 18 16 93 63 64 71 80 81 64 63 70 81 62 62 72 62 62 71 63 64 72 64 64 66 63 64 67 70 71 71 63 66 93 93 64 64 92 93 60 80 91 77 91 93 66 92 93 66 64 59 66 23 48

9 17 12 9 9 5 7 8 2 2 6 1 3 5 13 4 3 16 5 8 24 29 5 22 3 9 12 2 16 16 14 6 24 4 5 8 4 24 7 14 13 21 16 3 14 8 6 3 3 2 3 11 10 2 16 13 8 10 26 4 2 4 2 7 12 7 9 14 9 5 4 6 16 8 21 9 24 18 6 3 14 20 19 23 19 8

425-34652 425-34683 425-36091

55 48 48 50 54 48 48 48 48 48 48 48 48 50 48 48 48 48 48 48 48 48 48 48 53 53 53 53 53 54 54 54 54 54 54 55 53 53 45 7 52 19 25 28 33 59 7 64 24 33 25 25 33 37 19 53 91 93 16 19 59 77 52 52 53 77 91 91 19 7 7 7 16 21 20 99 99 42 45 53 66 99 36 36 69 25

3 6 10 2 12 2 3 4 5 11 18 19 20 1 12 13 14 15 16 17 21 24 23 22 1 2 3 4 5 14 15 13 1 9 10 2 6 7 14 32 14 11 9 11 5 13 31 2 2 4 7 4 2 20 17 26 10 25 10 14 18 24 11 15 15 22 11 12 20 28 24 23 23 3 13 17 10 16 34 34 25 5 15 16 4 15

651433 651440 651448

21 50 25 45 14 28 29 30 33 37 52 77 7 99 20 42 51 53 99 23 37 42 45 52 53 103 20 22 19 45 23 39 77 52 66 14 7 16 7 30 7 66 101 19 73 18 66 7 63 45 20 23 24 45 52 53 55 60 68 74 75 76 92 104 49 59 74 75 21 99 37 40 45 54 55 35 17 20 22 25 37 51 52 53 16 20

20 4 8 19 7 7 7 12 11 22 16 23 25 21 27 18 10 37 20 14 15 5 23 25 40 4 15 12 3 25 20 5 18 8 10 6 30 26 26 18 27 4 9 10 4 2 21 33 3 10 20 7 7 3 23 8 6 2 10 2 2 2 12 2 4 21 11 13 14 18 12 8 1 5 7 14 6 18 17 11 10 11 18 39 29 5

163345 163346 163347 163348 163349 163350 163351 163352 163353 163354 163355 163356 163357 163358 163359 163360 163361 163362 163363 163364

163365 163366 163367 163368 163369 163370 163371 163372 163373 163374 163375 163376 163377 163378 163379 163380 163381 163382 163383 170761 425-34635 908545/BP0602

425-36098 425-36108 425-36109 425-36110 425-36111 425-36112 425-36113 425-36114 425-36115 425-36117 425-36118 425-36119 425-36120 425-36121 425-36122 425-36123 425-36124 425-36125 425-36126 425-36127 425-36128 425-36129 425-36130 425-36131 425-36132 425-36134 425-36135 425-36136 425-36137 425-36138 425-36139 425-36171 425-36172 651390 651391 651393

651394 651396 651399 651402 651403 651404

651405

651406 651407 651408 651409 651411 651414 651416 651417 651420 651422 651423 651424

651425 651428 651432

112

651449

651451 651456 651457

651458

651459 651460 651466 651467 651475 651476 651477 651486 651491 651494 651497 651501 651502 651507 651509 651510 651515 651516 651517 656001

656017

656047 656048

656092 656093

656094

Part No.

656100

656102 656105

656122 656149

656172

Page No.

Ref. No.

22 23 24 100 20 22 36 99 24 33 23 37 51 53 54 55 59 16 21 20 21 35 101 70

6 12 13 3 32 10 8 19 5 12 13 9 7 18 2 5 7 14 9 21 6 20 5 4

PRINTED IN U.S.A.

®

Gehl Company 143 Water Street, P.O. Box 179, West Bend, WI 53095-0179 U.S.A www.gehl.com

908545/BP0602

©2002 GEHL Company. All rights reserved.

Printed in U.S.A