GEHL Mini-excavator 602 Parts Manual(908543) - PDF DOWNLOAD

Mini-excavator

PARTS MANUAL

CONSTRUCTION

602

Form No.

908543

Introduction When ordering service parts, specify the correct part number, full description, quantity required, the unit model number and serial number.

The Mini-excavator model and serial numbers are on a plate located on the lower left front outer side of the cabin (from the driver’s perspective).

OUR Company reserves the right to make changes or improvements in the design or construction of any part of the unit without incurring the obligation to install such changes on any previously delivered units.

To ensure continued safe operation, replace damaged or worn-out parts with genuine Factory service parts, BEFORE attempting to operate this equipment.

Refer to the abbreviations table located on this page for the various fastener descriptions.

In the exploded view parts list, Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in that section. Refer to the Table of Contents for locations of specific assemblies.

NOTE: The following abbreviations may be used herein:

AR ASSD ASSY CB CCW CP CS CTR CW DEG DIA FCHC FCS FHMS FL FLN FLS FW GA GR HD HLN HJN HN HS INCL INS JT LG LH LN LW M MM/mm NF PB PTO RH RHMS RPM RT SERR SHCS SHSS SN SQ SQSS T TFS THMS THRD WLDMT ZO #

– As Required – Assembled – Assembly – Carriage Bolt – Counterclockwise – Cotter Pin – Cap Screw (Hexagon Head) – Center – Clockwise – Degree – Diameter – Flanged Cap Screw – Flat Head Machine Screw – Flanged – Flanged Lock Nut (Hexagon) – Flanged Lock Screw (Hexagon) – Flat Washer – Gauge – Grade – Hard or Head – Hex Lock Nut – Hex Jam Nut – Hex Nut – Includes – Joint – Large – Left Hand – Lock Nut – Lock Washer – Metric – Millimeter – National Fine – Plow Bolt – Power Take Off – Right Hand – Round Head Machine Screw – Revolutions Per Minute – Right – Serrated – Socket Head Cap Screw – Socket Head Set Screw – Serial Number or Slotted Nut – Square – Square Head Set Screw – Tooth or Teeth – Thread Forming Screw – Truss Head Machine Screw – Thread – Weldment – Zinc Oxide Plating – Number

Table of Contents SECTION A: UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5 UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 MODEL 602 — UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 MODEL 602 — SUPPORT ROLLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 MODEL 602 — TRACK TENSION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 MODEL 602 — TRACK ROLLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 SECTION B: DOZER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11 DOZER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 MODEL 602 — DOZER BLADE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 SECTION C: CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 MODEL 602 — CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 MODEL 602 — CHASSIS COVERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 MODEL 602 — CHASSIS LUBRICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 MODEL 602 — REAR WALL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 MODEL 602 — VALVE COVERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 MODEL 602 — COUNTERWEIGHT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 MODEL 602 — HOOD. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 MODEL 602 — HOSE COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 MODEL 602 — TANK COVER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 SECTION D: BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23 BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24 MODEL 602 — BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 MODEL 602 — STICK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25 MODEL 602 — CONNECTING LINK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26 SECTION E: CABIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27 CABIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28 MODEL 602 — CABIN MOUNTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28 MODEL 602 — CABIN FRAME 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29 MODEL 602 — CABIN FRAME 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30 MODEL 602 — CABIN FRAME 3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31 MODEL 602 — CABIN CABLES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 MODEL 602 — FRONT WINDSHIELD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33 MODEL 602 — CABIN WINDOWS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34 MODEL 602 — SLIDING SIDE WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 MODEL 602 — CABIN DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36 MODEL 602 — CABIN MATS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37 MODEL 602 — CABIN HEATING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38 MODEL 602 — DRIVERS SEAT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39 SECTION F: DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41 DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42 MODEL 602 — DIESEL ENGINE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42 MODEL 602 — DIESEL TANK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43 MODEL 602 — FUEL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44 MODEL 602 — ACCELERATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45 PRINTED IN U.S.A.

1

908128/AP1099

MODEL 602 — ENGINE SUSPENSION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46 MODEL 602 — COOLING WATER RADIATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47 MODEL 602 — AIR INTAKE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48 MODEL 602 — EXHAUST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49 SECTION G: HYDRAULIC SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51 HYDRAULIC SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52 MODEL 602 — HYDRAULIC PUMP ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52 MODEL 602 — HYDRAULIC OIL TANK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53 MODEL 602 — HYDRAULIC OIL COOLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54 MODEL 602 — TRAVELING MOTORS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55 MODEL 602 — SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56 MODEL 602 — HYDRAULIC PUMP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57 MODEL 602 — TURNING MOTOR. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58 MODEL 602 — CONTROL VALVE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59 MODEL 602 — CONTROL VALVE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60 MODEL 602 — PILOT OIL SUPPLY UNIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61 MODEL 602 — DISTRIBUTION BLOCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62 MODEL 602 — SELECTION VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63 MODEL 602 — HAND LEVERS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64 MODEL 602 — DOZER BLADE VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65 MODEL 602 — TRAVELING PILOT VALVE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66 MODEL 602 — PILOT VALVE AUXILIARY HYDRAULICS . . . . . . . . . . . . . . . . . . . . . . . . . 67 MODEL 602 — BOOM CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68 MODEL 602 — STICK CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69 MODEL 602 — BUCKET CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70 MODEL 602 — BOOM OFFSET CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71 MODEL 602 — DOZER BLADE CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72 MODEL 602 — HYDRAULIC PUMP INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73 MODEL 602 — HYDRAULIC OIL COOLER INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . 74 MODEL 602 — TURNING MOTOR INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75 MODEL 602 — TRAVELING MOTOR INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76 MODEL 602 — CONTROL VALVE INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77 MODEL 602 — PILOT OIL SUPPLY UNIT INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . 78 MODEL 602 — BOOM OFFSET CYLINDER INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . 79 MODEL 602 — DOZER BLADE CYLINDER INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . 80 MODEL 602 — BOOM INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81 MODEL 602 — MOUNTING CLAM SHELL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82 MODEL 602 — HAND LEVER VALVE INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83 MODEL 602 — PILOT OIL VALVE INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84 SECTION H: ELECTRICAL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .85 ELECTRICAL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .86 MODEL 602 — ELECTRICAL INSTALLATION 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86 MODEL 602 — ELECTRICAL INSTALLATION 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87 MODEL 602 — CONTROL BOARD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88 MODEL 602 — RELAY BOX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89 MODEL 602 — RELAY BOX INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90 MODEL 602 — CHASSIS LIGHTS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91 MODEL 602 — WORKING LIGHT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92 MODEL 602 — BATTERY INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93 MODEL 602 — HORN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94 908128/AP1099

2

PRINTED IN U.S.A.

SECTION I: TOOL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .95 TOOL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .96 MODEL 602 — TOOL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96 SECTION J: DECALS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .97 DECALS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98 MODEL 602 — DECALS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98

PRINTED IN U.S.A.

3

908128/AP1099

908128/AP1099

4

PRINTED IN U.S.A.

SECTION A: UNDERCARRIAGE

SECTION A: UNDERCARRIAGE

UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 MODEL 602 — UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 MODEL 602 — SUPPORT ROLLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 MODEL 602 — TRACK TENSION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 MODEL 602 — TRACK ROLLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

PRINTED IN U.S.A.

5

908543/AP0300

MODEL 602 MINI-EXCAVATOR UNDERCARRIAGE MODEL 602 — UNDERCARRIAGE

ET6001000

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

908543/AP0300

6

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR UNDERCARRIAGE MODEL 602 — UNDERCARRIAGE Ref. No.

Part No.

Ref. No.

Part No.

1

162635

2

160979

UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . 1

24

651416

HB M16-2.0 X 70 C 10.9 ZO . . . . . . . . . . . . . . . . 2

TRACK TENSIONER. . . . . . . . . . . . . . . . . . . . . 2

25

651451

HLN INS M16-2.0 ZO . . . . . . . . . . . . . . . . . . . . . 2

3

160638

4

160865

NON RETURN VALVE . . . . . . . . . . . . . . . . . . . . 2

26

651491

SHCS HS M14-1.5 X 45 10.9 ZO D912 . . . . . . 36

SCREW SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . 2

28

656148

5

160977

SHCS HS 12-1.75X40 10.9 ZO. . . . . . . . . . . . . . 4

ROLLER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

29

651405

6

CS M12-1.7 X 30 C 10.9 ZO . . . . . . . . . . . . . . . . 6

160884

SUPPORTING ROLLER . . . . . . . . . . . . . . . . . . 2

30

651495

SHCS HS M16-1.5 X 40 10.9 ZO D912 . . . . . . 20

7

161029

TRAVELING GEAR . . . . . . . . . . . . . . . . . . . . . . 2

31

651393

CS M10-1.5 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

8

160978

SPROCKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

32

651472

SHCS HS M10-1.2 X 20 8.8 ZO D912 . . . . . . . . 9

9

160885

RUBBER CHAIN . . . . . . . . . . . . . . . . . . . . . . . . 2

33

651515

SHCS HS M8-1.2 X 20 8.8 ZO D912 . . . . . . . . . 8

10

162731

SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . 1

34

161625

LW SPRING B14 DIN7983 . . . . . . . . . . . . . . . . 36

Description

Qty. Req.

Description

Qty. Req.

11

162615

TURNTABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

35

161646

WASHER/GR A 15 DIN125 ZO. . . . . . . . . . . . . 36

12

162724

SPROCKET COVER . . . . . . . . . . . . . . . . . . . . . 1

36

161643

WASHER/ROUND HI-TENS DIN6916 . . . . . . . 10

13

162725

SPROCKET COVER . . . . . . . . . . . . . . . . . . . . . 1

37

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . . 9

14

162718

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

38

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 8

15

162719

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

39

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . . 9

16

162616

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

40

161637

WASHER/NORD-LOCK NL 16 STUCK . . . . . . 20

17

162726

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

41

161635

WASHER/NORD-LOCK NL 10 STUCK . . . . . . . 4

20

161417

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

43

160980

TENSION ROLLER . . . . . . . . . . . . . . . . . . . . . . . 1

21

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 1

44

160981

SPRINGS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

161416

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 1

45

160886

TENSION CYLINDER . . . . . . . . . . . . . . . . . . . . . 1

23

651418

HB M16-2.0 X 90 C 10.9 ZO . . . . . . . . . . . . . . 24

47

160945

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

7

908543/AP0300

MODEL 602 MINI-EXCAVATOR UNDERCARRIAGE MODEL 602 — SUPPORT ROLLER

ET6001001

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162720

2

162722

SHAFT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

162721

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162506

BEARING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

161572

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162491

RETAINING RING . . . . . . . . . . . . . . . . . . . . . . . 1

7

162927

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

651504

SHCS HS M5-0.8 X 16 8.8 ZO D912 . . . . . . . . . 3

9

161674

LOCKWASHER S5 . . . . . . . . . . . . . . . . . . . . . . 3

10

162492

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

11

160884

SUPPORT ROLLER ASSEMBLY . . . . . . . . . . . 1

Description

Qty. Req.

ROLLER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908543/AP0300

8

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR UNDERCARRIAGE MODEL 602 — TRACK TENSION

ET6001002

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162748

TENSION WHEEL . . . . . . . . . . . . . . . . . . . . . . . 1

9

162753

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

162749

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

162754

BUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

160982

ROD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

162755

GUIDE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162750

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

160985

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

160983

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162756

SPRING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

160983

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162757

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162751

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

162758

COTTER PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

162752

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162759

SLEEVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

Ref. No.

9

Part No.

Description

Qty. Req.

908543/AP0300

MODEL 602 MINI-EXCAVATOR UNDERCARRIAGE MODEL 602 — TRACK ROLLER

ET6001003

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162760

ROLLER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

162761

PILLOW BLOCK . . . . . . . . . . . . . . . . . . . . . . . . 1

3

162762

SHAFT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162750

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

160983

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

160983

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162763

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

10

PRINTED IN U.S.A.

SECTION B: DOZER BLADE

SECTION B: DOZER BLADE

DOZER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 MODEL 602 — DOZER BLADE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

PRINTED IN U.S.A.

11

908543/AP0300

MODEL 602 MINI-EXCAVATOR DOZER BLADE MODEL 602 — DOZER BLADE

ET6001005

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162636

DOZER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

162928

2

161191

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

10

161004

DOZER BLADE CYLINDER . . . . . . . . . . . . . . . . 1

3

161189

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161521

BUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

161190

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161581

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

5

161526

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

13

651477

SHCS HS M12-1.7 X 110 10.9 ZO D912. . . . . . . 4

6

161589

PIN SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

14

651449

HLN INS M12-1.7 ZO . . . . . . . . . . . . . . . . . . . . . 4

7

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 2

Description

908543/AP0300

Qty. Req.

Ref. No.

12

Part No.

Description

Qty. Req.

PROTECTION CAP. . . . . . . . . . . . . . . . . . . . . . .2

PRINTED IN U.S.A.

SECTION C: CHASSIS

SECTION C: CHASSIS

CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 MODEL 602 — CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 MODEL 602 — CHASSIS COVERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 MODEL 602 — CHASSIS LUBRICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 MODEL 602 — REAR WALL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 MODEL 602 — VALVE COVERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 MODEL 602 — COUNTERWEIGHT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 MODEL 602 — HOOD. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 MODEL 602 — HOSE COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 MODEL 602 — TANK COVER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

PRINTED IN U.S.A.

13

908543/AP0300

MODEL 602 MINI-EXCAVATOR CHASSIS MODEL 602 — CHASSIS

ET6002000

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162624

CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . . 2

2

162648

PIVOT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

162861

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

160939

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . . 5

4

162734

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

656148

SHCS HS 12-1.75X40 10.9 ZO . . . . . . . . . . . . . 10

5

161530

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

23

651471

PIN/SPRING M8 X 90 D1481 . . . . . . . . . . . . . . . 1

6

161003

BOOM OFFSET CYLINDER . . . . . . . . . . . . . . . 1

24

161550

BUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

160944

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

25

161588

PIN SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

8

160942

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

26

161587

PIN SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

161030

TURNING GEAR . . . . . . . . . . . . . . . . . . . . . . . . 1

27

161627

RIVET/BLIND A4 X 12 DIN7337 . . . . . . . . . . . . . 8

10

161411

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 1

28

162715

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 SHCS HS M10-1.2 X 30 8.8 ZO D912 . . . . . . . . 2

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

11

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 1

29

651475

12

161570

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

30

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . . 6

13

651444

HN SLTD M48-3 ZO . . . . . . . . . . . . . . . . . . . . . . 1

31

160409

REFLECTOR. . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

161683

PIN/SPLIT 8 X 80 ZO D94 . . . . . . . . . . . . . . . . . 1

32

162644

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

651418

HB M16-2.0 X 90 C 10.9 ZO . . . . . . . . . . . . . . 24

33

162858

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

161647

WASHER/ROUND HI-TENS 17 . . . . . . . . . . . . 24

34

656102

HN M10-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . . . 2

17

651479

SHCS HS M12-1.7 X 25 8.8 ZO D912 . . . . . . . . 2

35

161663

WASHER/GR A 10.5 ZO DIN9021 . . . . . . . . . . .2

18

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . 2

908543/AP0300

14

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR CHASSIS MODEL 602 — CHASSIS COVERS

ET6002005

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162627

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

162628

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

162629

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162630

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162631

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

651515

SHCS HS M8-1.2 X 20 8.8 ZO D912 . . . . . . . . 24

7

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . 24

8

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . 24

9

162015

RUBBER SEAL . . . . . . . . . . . . . . . . . . . . . . . . . 7

Description

PRINTED IN U.S.A.

Qty. Req.

15

908543/AP0300

MODEL 602 MINI-EXCAVATOR CHASSIS MODEL 602 — CHASSIS LUBRICATION

ET6002010

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161722

2

651509

LUBRICATION BLOCK . . . . . . . . . . . . . . . . . . . 1

8

161228

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

SHCS HS M6-1 X 30 8.8 ZO D912 . . . . . . . . . . 2

9

161468

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

3

161675

4

161412

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 2

10

161469

SLEEVE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 3

11

161453

5

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 3

12

161392

LUBRICATION TUBE (190 cm) . . . . . . . . . . . . . . 1

6

161461

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

13

161482

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

161392

LUBRICATION TUBE (90 cm) . . . . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

16

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR CHASSIS MODEL 602 — REAR WALL

ET6002015

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162632

REAR WALL . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

163204

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

2

162791

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . . 8

3

651460

FCHC HS M5-0.8 X 16 8.8 ZO D7991 . . . . . . . . 4

16

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . . 4

4

161611

NUT/CAGE M5 . . . . . . . . . . . . . . . . . . . . . . . . . 4

17

163206

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

162633

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

162746

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

161677

QUICKLOCK/HEXAGON. . . . . . . . . . . . . . . . . . 2

20

651488

SHCS HS M12-1.7 X 60 12.9 ZO D912 . . . . . . . 2

7

161619

WASHER/QUICK LOCK . . . . . . . . . . . . . . . . . . 2

21

162666

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161691

QUICKLOCK/LOWER . . . . . . . . . . . . . . . . . . . . 2

22

162654

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161626

RIVET/BLIND A3 X 12 DIN7337 . . . . . . . . . . . . 2

23

162656

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

651502

SHCS HS M5-0.8 X 10 8.8 ZO D912 . . . . . . . . . 1

24

162785

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

651473

SHCS HS M10-1.2 X 25 8.8 ZO D912 . . . . . . . . 6

25

162655

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 6

26

162819

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161641

WASHER/GR 10.5 ZO . . . . . . . . . . . . . . . . . . . 6

27

162820

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

Ref. No.

17

Part No.

Description

Qty. Req.

908543/AP0300

MODEL 602 MINI-EXCAVATOR CHASSIS MODEL 602 — VALVE COVERS

ET6002020

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162742

VALVE COVER . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

162860

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

2

162793

FRAME. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . . 3

3

162203

BAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

161660

WASHER/GR A 6.4 ZO DIN125 . . . . . . . . . . . . . 5

4

162072

BALL AND SOCKET . . . . . . . . . . . . . . . . . . . . . 1

24

161062

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162389

CLAMP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

25

161187

CABLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

160882

HINGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

26

162604

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162675

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

27

651457

HLN INS M6-1.0 8 Z0 . . . . . . . . . . . . . . . . . . . . . 2

8

162716

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

28

161929

NIPPLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

9

656094

CS M8-1.2 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

29

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . . 2

10

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 8

30

162691

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

11

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 7

31

161358

RUBBER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

12

161678

HN M6-1.0 8 ZO . . . . . . . . . . . . . . . . . . . . . . . . . 6

32

161666

WASHER/GR A 6.4 ZO DIN9021 . . . . . . . . . . . .8

13

161616

NUT/CAGE M8. . . . . . . . . . . . . . . . . . . . . . . . . . 2

33

656047

HN M6-1.0 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

161064

HANDLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

34

651463

FCHC HS M6-1.0 X 20 8.8 ZO D7991 . . . . . . . . 4

15

651459

FCHC HS M14-2.0 X 16 8.8 ZO D7991 . . . . . . . 2

35

161614

NUT/CAGE M6 . . . . . . . . . . . . . . . . . . . . . . . . . . 4

16

656116

HN M4-.7 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

36

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . .1

17

161061

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

37

651422

CS M5-0.8 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 1

18

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

38

162787

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

161058

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

39

162788

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

908543/AP0300

18

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR CHASSIS MODEL 602 — COUNTERWEIGHT

ET6002025

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162622

COUNTERWEIGHT . . . . . . . . . . . . . . . . . . . . . . 1

11

161642

2 3

161653

WASHER/ROUND HI-TENS 21 DIN6916 . . . . 12

12

161188

CABLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

162866

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

13

162604

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161057

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

656047

HN M6-1.0 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

161062

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161929

NIPPLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

651506

SHCS HS M6-1 X 16 8.8 ZO D912 . . . . . . . . . . 3

16

162745

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 5

17

162794

RETAINER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

161621

LW SPRING 6 DIN7980 . . . . . . . . . . . . . . . . . . . 3

18

160644

REFLECTOR. . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

651479

SHCS HS M12-1.7 X 25 8.8 ZO D912 . . . . . . . . 2

19

161627

RIVET/BLIND A4 X 12 DIN7337 . . . . . . . . . . . . . 4

10

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . 2

20

163208

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

PRINTED IN U.S.A.

Qty. Req.

19

Description

Qty. Req.

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . . 2

908543/AP0300

MODEL 602 MINI-EXCAVATOR CHASSIS MODEL 602 — HOOD

ET6002030

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162658

2

162667

HOOD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

656100

HN M5-.8 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161064

HANDLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

3

162716

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

651459

FCHC HS M14-2.0 X 16 8.8 ZO D7991 . . . . . . . 2

4

160882

HINGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

656116

HN M4-.7 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

162675

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161061

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

651517

SHCS HS M8-1.2 X 30 8.8 ZO D912 . . . . . . . . . 4

16

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 2

7

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 6

17

651514

SHCS HS M8-1.2 X 16 8.8 ZO D912 . . . . . . . . . 2

8

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

18

162016

RUBBER PROTECTOR (265 cm). . . . . . . . . . . . 1

9

161204

PNEUMATIC SPRING . . . . . . . . . . . . . . . . . . . . 2

19

162476

RUBBER PROTECTOR (130 cm). . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

20

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR CHASSIS MODEL 602 — HOSE COVER

ET6002035

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162623

HOSE COVER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

162713

RUBBER PROTECTOR (96 cm) . . . . . . . . . . . . 1

3

651472

SHCS HS M10-1.2 X 20 8.8 ZO D912 . . . . . . . . 3

4

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 3

5

161663

WASHER/GR A 10.5 ZO DIN9021 . . . . . . . . . . 3

6

161610

NUT/CAGE M10 . . . . . . . . . . . . . . . . . . . . . . . . 3

Description

PRINTED IN U.S.A.

Qty. Req.

21

908543/AP0300

MODEL 602 MINI-EXCAVATOR CHASSIS MODEL 602 — TANK COVER

ET6002040

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162634

TANK COVER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

651472

SHCS HS M10-1.2 X 20 8.8 ZO D912 . . . . . . . . 5

3

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 5

4

161663

WASHER/GR A 10.5 ZO DIN9021. . . . . . . . . . . 5

5

162743

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

161615

NUT/CAGE M8. . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

8

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 4

9

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

Description

908543/AP0300

Qty. Req.

22

PRINTED IN U.S.A.

SECTION D: BOOM

SECTION D: BOOM

BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 MODEL 602 — BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 MODEL 602 — STICK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25 MODEL 602 — CONNECTING LINK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

PRINTED IN U.S.A.

23

908543/AP0300

MODEL 602 MINI-EXCAVATOR BOOM MODEL 602 — BOOM

ET6003000

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162646

2

160926

BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

160938

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

162733

3

160927

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

651444

HN SLTD M48-3 ZO . . . . . . . . . . . . . . . . . . . . . . 1

4 5

160928

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

22

161683

PIN/SPLIT 8 X 80 ZO D94. . . . . . . . . . . . . . . . . . 1

160929

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

25

161002

BOOM CYLINDER . . . . . . . . . . . . . . . . . . . . . . . 1

7

161551

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . . . 12

26

161048

PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162069

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

27

161190

PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

162865

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

28

163205

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161554

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . . . . 8

29

651449

HLN INS M12-1.7 ZO . . . . . . . . . . . . . . . . . . . . . 1

12

162066

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

30

161589

PIN SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

15

161411

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 1

31

161526

BUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 1

32

161582

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

17

161689

WASHER SB70 . . . . . . . . . . . . . . . . . . . . . . . . . 2

33

163207

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

161531

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

34

651448

HLN INS M10-1.5 ZO . . . . . . . . . . . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

24

Description

Qty. Req.

PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR BOOM MODEL 602 — STICK

ET6003005

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162647

2

161688

STICK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

160467

QUICK COUPLER. . . . . . . . . . . . . . . . . . . . . . . . 1

WASHER SB60 . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

161481

3

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161529

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

21

161454

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161581

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

22

160932

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161528

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

23

161405

COTTER PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

160937

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

161588

PIN SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

162733

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

30

160999

STICK CYLINDER. . . . . . . . . . . . . . . . . . . . . . . . 1

8

651444

HN SLTD M48-3 ZO. . . . . . . . . . . . . . . . . . . . . . 1

31

161190

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

Qty. Req.

Description

Qty. Req.

9

161683

PIN/SPLIT 8 X 80 ZO D94 . . . . . . . . . . . . . . . . . 1

33

163205

10

161411

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 2

34

651449

HLN INS M12-1.7 ZO . . . . . . . . . . . . . . . . . . . . . 2

11

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

35

161526

BUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

160468

QUICK COUPLER . . . . . . . . . . . . . . . . . . . . . . . 1

36

161589

PIN SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

13

160459

DUST CAP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

37

162649

STICK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161452

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

38

REFER TO FACTORY

15

161505

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

39

REFER TO FACTORY

18

160458

DUST PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

40

REFER TO FACTORY

PRINTED IN U.S.A.

25

908543/AP0300

MODEL 602 MINI-EXCAVATOR BOOM MODEL 602 — CONNECTING LINK

ET6003010

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160905

CONNECTING LINK . . . . . . . . . . . . . . . . . . . . . 1

12

161672

2 3

160906

CONNECTING LINK . . . . . . . . . . . . . . . . . . . . . 1

13

651494

SHCS HS M16-1.5 X 30 12.9 ZO D912 . . . . . . . 2

160904

CONNECTING LINK . . . . . . . . . . . . . . . . . . . . . 1

15

160998

BUCKET CYLINDER. . . . . . . . . . . . . . . . . . . . . .1

4 5

161688

WASHER SB60 . . . . . . . . . . . . . . . . . . . . . . . . . 4

16

160934

PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161527

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

17

651519

SHCS HS M8-1.2 X 90 8.8 ZO D912 . . . . . . . . . 1

6 7

161411

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 2

18

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . .1

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

19

160933

PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

160932

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

161529

BUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

9

161405

COTTER PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

161550

BUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

10

161047

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

161588

PIN SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

11

160974

PIN COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

908543/AP0300

Qty. Req.

26

Description

Qty. Req.

LOCKWASHER S16 . . . . . . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

SECTION E: CABIN

SECTION E: CABIN

CABIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28 MODEL 602 — CABIN MOUNTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28 MODEL 602 — CABIN FRAME 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29 MODEL 602 — CABIN FRAME 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30 MODEL 602 — CABIN FRAME 3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31 MODEL 602 — CABIN CABLES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 MODEL 602 — FRONT WINDSHIELD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33 MODEL 602 — CABIN WINDOWS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34 MODEL 602 — SLIDING SIDE WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 MODEL 602 — CABIN DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36 MODEL 602 — CABIN MATS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37 MODEL 602 — CABIN HEATING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38 MODEL 602 — DRIVERS SEAT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

PRINTED IN U.S.A.

27

908543/AP0300

MODEL 602 MINI-EXCAVATOR CABIN MODEL 602 — CABIN MOUNTING

ET6004000

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160711

2

651403

CUSHION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

8

160714

SUPPORT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

HB M12-1.7 X 100 C 8.8 ZO . . . . . . . . . . . . . . . 4

9

160715

SUPPORT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

3 4

161643

WASHER/ROUND HI-TENS DIN6916. . . . . . . . 4

10

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . . 4

651396

CS M10-1.5 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . 6

11

651449

HLN INS M12-1.7 ZO . . . . . . . . . . . . . . . . . . . . . 4

5

651393

CS M10-1.5 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . 2

12

656102

HN M10-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . . . 4

6

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . 12

13

162855

CABIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

7

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 8

Description

908543/AP0300

Qty. Req.

28

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR CABIN MODEL 602 — CABIN FRAME 1

ET6004005

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162765

CABIN FRAME . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

656149

2 3

161085

WIPER MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

162924

WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

161084

WIPER BLADE HOLDER . . . . . . . . . . . . . . . . . 3

22

162737

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

162795

WIPER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

162006

RADIO . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161086

CLIPS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

162839

ANTENNA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162796

WATER HOSE (190 cm) . . . . . . . . . . . . . . . . . . 1

25

162766

STORAGE BOX . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

161087

NOZZLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

26

162840

SPEAKERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

160481

ASHTRAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

27

162799

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

162869

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

28

162035

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

10

162797

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

29

162736

EDGE PROTECTION (110 cm). . . . . . . . . . . . . . 1

11

160488

ILLUMINATION . . . . . . . . . . . . . . . . . . . . . . . . . 1

30

651457

HLN INS M6-1.0 8 Z0 . . . . . . . . . . . . . . . . . . . . . 2

12

162798

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

31

162767

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

160716

WINDSHIELD WASHER . . . . . . . . . . . . . . . . . . 1

32

162768

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

CS M6-1.0 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

14

656092

CS M6-1.0 X 12 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

33

162769

15

161921

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

34

162036

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

16

161922

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

35

162770

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161924

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

36

162771

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

37

162925

WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

161923

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

162607

MIRROR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

29

908543/AP0300

MODEL 602 MINI-EXCAVATOR CABIN MODEL 602 — CABIN FRAME 2

ET6004010

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162018

RUBBER PROTECTOR (240 cm) . . . . . . . . . . . 1

16

651428

CS M6-1.0 X 50 C 8.8 ZO . . . . . . . . . . . . . . . . . . 1

2 3

162018

RUBBER PROTECTOR (460 cm) . . . . . . . . . . . 1

17

162924

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

161949

RUBBER PROTECTOR (170 cm) . . . . . . . . . . . 1

18

162801

DOOR LOCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162600

RUBBER BUFFER . . . . . . . . . . . . . . . . . . . . . . . 2

19

162802

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

5

162862

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

20

162803

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162925

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

162804

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

7

162800

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

22

162805

RUBBER SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

656100

HN M5-.8 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

160986

BAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162857

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

161089

HANDLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

10

160526

LOCK, L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

25

162789

RUBBER BUFFER . . . . . . . . . . . . . . . . . . . . . . . 1

11

160527

LOCK, R. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

26

162862

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

162029

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

27

161974

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162863

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

28

162670

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

30

162824

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

14

161843

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

15

651425

CS M6-1.0 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . . 3

908543/AP0300

30

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR CABIN MODEL 602 — CABIN FRAME 3

ET6004015

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162772

SHIELD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162870

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2 3

162044

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

15

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . . 5

162806

GUTTER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162810

NOZZLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

162807

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

162869

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

6

162036

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

18

160715

SUPPORT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

162808

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

160714

SUPPORT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

162809

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

651403

HB M12-1.7 X 100 C 8.8 ZO . . . . . . . . . . . . . . . . 4

Description

Qty. Req.

Description

Qty. Req.

9

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

21

161643

WASHER/ROUND HI-TENS DIN6916 . . . . . . . . 4

10

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

22

651449

HLN INS M12-1.7 ZO . . . . . . . . . . . . . . . . . . . . . 4

11

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

23

160711

CUSHION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

12

656048

HN M8-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . 2

24

161964

SILICON GLUE . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162773

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

25

PRINTED IN U.S.A.

31

908543/AP0300

MODEL 602 MINI-EXCAVATOR CABIN MODEL 602 — CABIN CABLES

ET6004020

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160987

MAIN WIRING HARNESS . . . . . . . . . . . . . . . . . 1

2

160988

SECONDARY WIRING HARNESS . . . . . . . . . . 1

3

162811

CABLE TIE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

908543/AP0300

Qty. Req.

32

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR CABIN MODEL 602 — FRONT WINDSHIELD

ET6004025

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160495

FRONT WINDSHIELD . . . . . . . . . . . . . . . . . . . . 1

11

160494

PVC-WASHERS . . . . . . . . . . . . . . . . . . . . . . . . . 4

2 3

162602

LOWER WINDSHIELD FRAME. . . . . . . . . . . . . 1

12

161951

EDGE PROTECTION . . . . . . . . . . . . . . . . . . . . . 1

162603

UPPER WINDSHIELD FRAME . . . . . . . . . . . . . 1

13

162606

SUN VISOR. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162033

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

162868

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

5

651466

SCREW FCHC HS M8-1.2 X 20 8.8 ZO D7991 2

15

161964

SILICON GLUE . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161941

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

7

160640

RUBBER WASHER . . . . . . . . . . . . . . . . . . . . . . 4

17

160641

PVC-WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

160639

RUBBER WASHER . . . . . . . . . . . . . . . . . . . . . . 4

18

162601

RUBBER PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161668

WASHER/GR A 8.4 ZO DIN134 . . . . . . . . . . . . 4

19

160989

FRONT WINDSHIELD ASSEMBLY . . . . . . . . . . 1

10

161618

NUT/HEX DOMED CAP M8 . . . . . . . . . . . . . . . 4

Description

PRINTED IN U.S.A.

Qty. Req.

33

Description

Qty. Req.

908543/AP0300

MODEL 602 MINI-EXCAVATOR CABIN MODEL 602 — CABIN WINDOWS

ET6004030

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160496

UPPER FRONT WINDSHIELD . . . . . . . . . . . . . 1

9

162018

2 3

161080

FRONT WINDSHIELD . . . . . . . . . . . . . . . . . . . . 1

10

160990

LEFT SIDE WINDOW . . . . . . . . . . . . . . . . . . . . . 1

161091

PVC WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . 2

11

161082

SIDE WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

160640

RUBBER WASHER . . . . . . . . . . . . . . . . . . . . . . 2

12

161396

RUBBER PROTECTOR (130 cm). . . . . . . . . . . . 1

5

160639

RUBBER WASHER . . . . . . . . . . . . . . . . . . . . . . 2

14

161083

REAR WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161404

HANDLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

15

161964

SILICON GLUE . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162812

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

8

656048

HN M8-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . 2

17

161949

RUBBER PROTECTOR (87 cm) . . . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

34

Description

Qty. Req.

RUBBER PROTECTOR (175 cm). . . . . . . . . . . . 1

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR CABIN MODEL 602 — SLIDING SIDE WINDOW

ET6004035

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160991

SLIDING WINDOW ASSEMBLY . . . . . . . . . . . . 1

2

161093

SLIDING WINDOW . . . . . . . . . . . . . . . . . . . . . . 1

3

160992

WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

160642

LOCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

35

908543/AP0300

MODEL 602 MINI-EXCAVATOR CABIN MODEL 602 — CABIN DOOR

ET6004040

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1

162776

DOOR FRAME. . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

160993

2

162777

DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162923

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

160525

LOCK L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161098

LOCK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162864

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

651424

CS M6-1.0 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 3

5

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . 2

17

162813

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

6

161096

HANDLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

651457

HLN INS M6-1.0 8 Z0 . . . . . . . . . . . . . . . . . . . . . 3

7

160713

KEY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

19

162737

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

8

160712

COVER L . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

162778

DOOR ISOLATION . . . . . . . . . . . . . . . . . . . . . . . 1

9

161097

TIE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

162814

DOOR ISOLATION . . . . . . . . . . . . . . . . . . . . . . . 1

10

161396

RUBBER PROTECTOR (440 cm) . . . . . . . . . . . 1

22

162779

CABIN DOOR ASSEMBLY . . . . . . . . . . . . . . . . . 1

23

161974

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

162824

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11 12

161078

DOOR WINDOW . . . . . . . . . . . . . . . . . . . . . . . . 1

908543/AP0300

36

LOWER DOOR WINDOW. . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR CABIN MODEL 602 — CABIN MATS

ET6004045

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160994

2

160995

RUBBER FLOOR MAT . . . . . . . . . . . . . . . . . . . 1

6

162782

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

RUBBER FLOOR MAT . . . . . . . . . . . . . . . . . . . 1

7

162783

3

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

162780

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

162816

ROOF COVER MAT . . . . . . . . . . . . . . . . . . . . . . 1

4

162781

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161937

FIXING STRIP. . . . . . . . . . . . . . . . . . . . . . . . . . 13

5

162815

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

11

162673

VELCRO STRAP. . . . . . . . . . . . . . . . . . . . . . . . . 7

Description

PRINTED IN U.S.A.

Qty. Req.

37

Description

Qty. Req.

908543/AP0300

MODEL 602 MINI-EXCAVATOR CABIN MODEL 602 — CABIN HEATING

ET6004050

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161077

2

162764

CAB HEATER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162064

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

CAB HEATING BRACKET . . . . . . . . . . . . . . . . . 1

17

160860

3

162605

HOSE COVER. . . . . . . . . . . . . . . . . . . . . . . . . . . 2

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

18

161423

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4 5

162015

RUBBER SEAL (70 cm). . . . . . . . . . . . . . . . . . . 1

19

161424

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

20

161470

6

REDUCTION JOINT . . . . . . . . . . . . . . . . . . . . . . 2

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 4

21

161484

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

22

161102

NOZZLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

8

161615

NUT/CAGE M8. . . . . . . . . . . . . . . . . . . . . . . . . . 4

23

161446

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

9

651424

CS M6-1.0 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

25

161463

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 4

26

161504

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161660

WASHER/GR A 6.4 ZO DIN125. . . . . . . . . . . . . 4

27

160950

BALL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

12

162854

HOSE COVERING (65 cm) . . . . . . . . . . . . . . . . 1

28

161477

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162835

STRAP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

29

161445

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

14

161393

CAB HEATING HOSE (45 cm). . . . . . . . . . . . . . 1

30

161496

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161393

CAB HEATING HOSE (60 cm). . . . . . . . . . . . . . 1

32

161323

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 2

908543/AP0300

38

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR CABIN MODEL 602 — DRIVERS SEAT

ET6004055

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

656048

2

162738

HN M8-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . 8

21

162214

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

DRIVER SEAT . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

161834

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

656001

4

161676

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

23

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . . 2

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . 20

24

162048

5

161661

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 8

25

651460

FCHC HS M5-0.8 X 16 8.8 ZO D7991 . . . . . . . 16

6

161615

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . 4

26

161805

TUBE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

160407

CONSOLE/CONTROL LEVERS . . . . . . . . . . . . 1

27

162210

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

160408

CONSOLE/CONTROL LEVERS . . . . . . . . . . . . 1

28

162211

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161730

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

29

162212

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

651517

SHCS HS M8-1.2 X 30 8.8 ZO D912 . . . . . . . . . 8

30

162213

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 ARMREST. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

11

161831

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

31

160532

12

160611

PNEUMATIC SPRING . . . . . . . . . . . . . . . . . . . . 1

32

160533

ARMREST. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161848

QUICK FIX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

33

161728

SEAT BELT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

651390

HB M10-1.5 X 120 C 8.8 ZO . . . . . . . . . . . . . . . 1

34

651507

SHCS HS M6-1 X 20 8.8 ZO D912 . . . . . . . . . . . 6

15

161651

WASHER 20 . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

35

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . . 6

16

161868

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

36

161666

WASHER/GR A 6.4 ZO DIN9021 . . . . . . . . . . . . 6

17

161403

BALL KNOB . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

37

161361

MICRO SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . 1

38

162674

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

39

161628

SCREW/PAN HEAD TAP . . . . . . . . . . . . . . . . . . 2

19

651448

HLN INS M10-1.5 ZO. . . . . . . . . . . . . . . . . . . . . 1

20

161947

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

39

908543/AP0300

908543/AP0300

40

PRINTED IN U.S.A.

DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42 MODEL 602 — DIESEL ENGINE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42 MODEL 602 — DIESEL TANK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43 MODEL 602 — FUEL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44 MODEL 602 — ACCELERATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45 MODEL 602 — ENGINE SUSPENSION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46 MODEL 602 — COOLING WATER RADIATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47 MODEL 602 — AIR INTAKE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48 MODEL 602 — EXHAUST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49

PRINTED IN U.S.A.

41

SECTION F: DIESEL ENGINE

SECTION F: DIESEL ENGINE

908543/AP0300

MODEL 602 MINI-EXCAVATOR DIESEL ENGINE MODEL 602 — DIESEL ENGINE

ET6005000

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161114

2

425-36108

DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . 1

14

425-36119

VALVE COVER SEAL . . . . . . . . . . . . . . . . . . 1

VENTILATOR FAN . . . . . . . . . . . . . . . . . . . 1

15

425-36120

3

425-36109

OIL PAN . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

BELT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

425-36121

DRAIN PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1

4 5

425-36110

GENERATOR . . . . . . . . . . . . . . . . . . . . . . . 1

17

425-36122

PRE-HEATER . . . . . . . . . . . . . . . . . . . . . . . . 1

425-36111

THERMO SWITCH . . . . . . . . . . . . . . . . . . . 1

18

425-36112

WATER PUMP . . . . . . . . . . . . . . . . . . . . . . . 1

6

425-34683

THERMO SWITCH . . . . . . . . . . . . . . . . . . . 1

19

425-36113

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

160427

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

425-36114

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

425-34635

OIL FILTER . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

425-36123

INJECTION VALVE . . . . . . . . . . . . . . . . . . . . 4

9

425-36115

FUEL FILTER . . . . . . . . . . . . . . . . . . . . . . . 1

22

425-36126

FUEL PUMP . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

425-36091

FUEL FILTER . . . . . . . . . . . . . . . . . . . . . . . 1

23

425-36125

STARTER . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

425-36116

OIL PRESSURE SWITCH . . . . . . . . . . . . . . 1

24

425-36124

INJECTION PUMP . . . . . . . . . . . . . . . . . . . . 1

12

425-36117

STOP SOLENOID . . . . . . . . . . . . . . . . . . . . 1

25

161112

ENGINE GASKETS 4TNE98 . . . . . . . . . . . .1

13

425-36118

CYLINDER HEAD SEAL . . . . . . . . . . . . . . . 1

908543/AP0300

Description

Qty. Req.

42

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR DIESEL ENGINE MODEL 602 — DIESEL TANK

ET6005005

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162626

DIESEL TANK . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161673

2 3

161059

STRAINER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161658

WASHER/GR A 4.3 ZO DIN125 . . . . . . . . . . . . . 6

161060

TANK COVER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

160844

HOSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4 5

656016

CS M12-1.7 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . 4

16

162926

SCREW MOUNT. . . . . . . . . . . . . . . . . . . . . . . . . 1

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . 4

17

162504

HOSE CLAMP. . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

161645

WASHER/GR. A 13 DIN7349 ZO . . . . . . . . . . . 4

18

162929

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162786

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

20

161429

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161415

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

161278

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

9

161427

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

161425

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

161418

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161104

TRANSMITTER . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

161423

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

162867

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

25

161065

KEY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

43

Description

Qty. Req.

LOCKWASHER S4 . . . . . . . . . . . . . . . . . . . . . . . 6

908543/AP0300

MODEL 602 MINI-EXCAVATOR DIESEL ENGINE MODEL 602 — FUEL SYSTEM

ET6005010

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

425-36115

2

425-36091

3

162661

4

651519

5

161676

908543/AP0300

Ref. No.

Part No.

FUEL FILTER . . . . . . . . . . . . . . . . . . . . . . . 1

6

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . 1

FUEL FILTER . . . . . . . . . . . . . . . . . . . . . . . 1

7

162617

HOSE (120 cm). . . . . . . . . . . . . . . . . . . . . . .1

HOSE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161391

HOSE (50 cm). . . . . . . . . . . . . . . . . . . . . . . . 1

SHCS HS M8-1.2 X 90 8.8 ZO D912. . . . . . 1

9

161391

HOSE (140 cm). . . . . . . . . . . . . . . . . . . . . . .1

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . 1

10

162504

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 4

Description

Qty. Req.

44

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR DIESEL ENGINE MODEL 602 — ACCELERATOR

ET6005015

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160755

CABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

162487

WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

2

162747

THROTTLE CONTROL LEVER. . . . . . . . . . . . . 1

9

162505

BALL AND SOCKET . . . . . . . . . . . . . . . . . . . . . . 1

3

162398

HANDLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

651457

HLN INS M6-1.0 8 Z0 . . . . . . . . . . . . . . . . . . . . . 1

4

162351

BRAKE DISC . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

651514

SHCS HS M8-1.2 X 16 8.8 ZO D912 . . . . . . . . . 4

5

162349

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 4

6

162350

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161668

WASHER/GR A 8.4 ZO DIN134 . . . . . . . . . . . . . 4

7

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

14

162073

YOKE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

Ref. No.

45

Part No.

Description

Qty. Req.

908543/AP0300

MODEL 602 MINI-EXCAVATOR DIESEL ENGINE MODEL 602 — ENGINE SUSPENSION

ET6005020

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162639

ENGINE CARRIER . . . . . . . . . . . . . . . . . . . . . . 1

11

651483

SHCS HS M12-1.7 X 35 10.9 ZO D912 . . . . . . . 4

2

162640

ENGINE CARRIER . . . . . . . . . . . . . . . . . . . . . . 1

12

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . 12

3

162637

ENGINE CARRIER . . . . . . . . . . . . . . . . . . . . . . 1

13

161645

WASHER/GR. A 13 DIN7349 ZO . . . . . . . . . . .16

4

162638

ENGINE CARRIER . . . . . . . . . . . . . . . . . . . . . . 1

14

651391

CS M10-1.5 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . 8

5

162659

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

15

656148

SHCS HS 12-1.75X40 10.9 ZO . . . . . . . . . . . . . . 8

6

162660

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

651449

HLN INS M12-1.7 ZO . . . . . . . . . . . . . . . . . . . . . 4

7

160903

HYDRO SUSPENSION . . . . . . . . . . . . . . . . . . . 4

17

162008

CABLE, GROUND. . . . . . . . . . . . . . . . . . . . . . . . 1

8

651475

SHCS HS M10-1.2 X 30 8.8 ZO D912 . . . . . . . 24

18

651514

SHCS HS M8-1.2 X 16 8.8 ZO D912 . . . . . . . . . 2

9

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . 32

19

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 2

10

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . 32

20

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . . 2

Description

908543/AP0300

Qty. Req.

Ref. No.

46

Part No.

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR DIESEL ENGINE MODEL 602 — COOLING WATER RADIATOR

ET6005025

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

425-36127

RADIATOR . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

2

425-36128

RADIATOR CAP . . . . . . . . . . . . . . . . . . . . . 1

16

162387

SEAL (47 cm) . . . . . . . . . . . . . . . . . . . . . . . . 1

3

425-36129

COOLING WATER HOSE . . . . . . . . . . . . . . 1

17

162645

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

425-36130

COOLING WATER HOSE . . . . . . . . . . . . . . 1

18

651485

SHCS HS M12-1.7 X 45 10.9 ZO D912 . . . . 1

5

425-36131

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 4

19

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . 3

6

425-36171

EXPANSION CONTAINER . . . . . . . . . . . . . 1

20

161641

WASHER/GR 10.5 ZO . . . . . . . . . . . . . . . . . 3

7

425-36172

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

162641

AIR GUIDING . . . . . . . . . . . . . . . . . . . . . . . . 1

8

162643

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

162642

AIR GUIDING . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 2

9

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . 10

23

162020

RUBBER PROTECTOR (110 cm) . . . . . . . . 1

10

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . 12

24

161949

RUBBER PROTECTOR (32 cm) . . . . . . . . . 1

11

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . 14

25

162017

RUBBER PROTECTOR (20 cm) . . . . . . . . . 1

12

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . 2

26

162020

RUBBER PROTECTOR (60 cm) . . . . . . . . . 1

13

161615

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . 4

27

656016

CS M12-1.7 X 30 C 8.8 ZO. . . . . . . . . . . . . . 2

HOSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

28

656105

CS M8-1.2 X 25 C 8.8 ZO. . . . . . . . . . . . . . . 2

14

PRINTED IN U.S.A.

47

908543/AP0300

MODEL 602 MINI-EXCAVATOR DIESEL ENGINE MODEL 602 — AIR INTAKE

ET6005030

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

425-36136

2

651516

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

425-36138

AIR FILTER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

SHCS HS M8-1.2 X 25 8.8 ZO D912. . . . . . 6

11

162619

3

161676

NUT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . 6

12

425-36098

DUST INDICATOR . . . . . . . . . . . . . . . . . . . . 1

4 5

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . 6

13

425-36135

SUCTION HOSE. . . . . . . . . . . . . . . . . . . . . .1

656048

HN M8-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . 4

14

425-36132

AIR SUCTION HOSE . . . . . . . . . . . . . . . . . . 1

6 7

160897

HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

425-36134

MUFFLER (RESONATOR) . . . . . . . . . . . . . . 1

160898

CAP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162611

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 4

8 9

160899

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 1

17

160892

SUCTION HOSE. . . . . . . . . . . . . . . . . . . . . .1

425-36137

AIR FILTER . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

163210

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 1

908543/AP0300

Description

Qty. Req.

48

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR DIESEL ENGINE MODEL 602 — EXHAUST

ET6005035

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

2

425-36139

MUFFLER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

425-34652

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

161109

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

651515

SHCS HS M8-1.2 X 20 8.8 ZO D912 . . . . . 4

7

656048

HN M8-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . 8

8

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . 12

9

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . 12

PRINTED IN U.S.A.

49

908543/AP0300

908543/AP0300

50

PRINTED IN U.S.A.

HYDRAULIC SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52 MODEL 602 — HYDRAULIC PUMP ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52 MODEL 602 — HYDRAULIC OIL TANK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53 MODEL 602 — HYDRAULIC OIL COOLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54 MODEL 602 — TRAVELING MOTORS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55 MODEL 602 — SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56 MODEL 602 — HYDRAULIC PUMP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57 MODEL 602 — TURNING MOTOR. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58 MODEL 602 — CONTROL VALVE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59 MODEL 602 — CONTROL VALVE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60 MODEL 602 — PILOT OIL SUPPLY UNIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61 MODEL 602 — DISTRIBUTION BLOCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62 MODEL 602 — SELECTION VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63 MODEL 602 — HAND LEVERS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64 MODEL 602 — DOZER BLADE VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65 MODEL 602 — TRAVELING PILOT VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66 MODEL 602 — PILOT VALVE AUXILIARY HYDRAULICS . . . . . . . . . . . . . . . . . . . 67 MODEL 602 — BOOM CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68 MODEL 602 — STICK CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69 MODEL 602 — BUCKET CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70 MODEL 602 — BOOM OFFSET CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71 MODEL 602 — DOZER BLADE CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72 MODEL 602 — HYDRAULIC PUMP INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . 73 MODEL 602 — HYDRAULIC OIL COOLER INSTALLATION . . . . . . . . . . . . . . . . . . 74 MODEL 602 — TURNING MOTOR INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . 75 MODEL 602 — TRAVELING MOTOR INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . 76 MODEL 602 — CONTROL VALVE INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . 77 MODEL 602 — PILOT OIL SUPPLY UNIT INSTALLATION. . . . . . . . . . . . . . . . . . . . 78 MODEL 602 — BOOM OFFSET CYLINDER INSTALLATION . . . . . . . . . . . . . . . . . . 79 MODEL 602 — DOZER BLADE CYLINDER INSTALLATION . . . . . . . . . . . . . . . . . . 80 MODEL 602 — BOOM INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81 MODEL 602 — MOUNTING CLAM SHELL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82 MODEL 602 — HAND LEVER VALVE INSTALLATION . . . . . . . . . . . . . . . . . . . . . . 83 MODEL 602 — PILOT OIL VALVE INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . 84

PRINTED IN U.S.A.

51

SECTION G: HYDRAULIC SYSTEM

SECTION G: HYDRAULIC SYSTEM

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — HYDRAULIC PUMP ASSEMBLY

ET6005040

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161014

COUPLING . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

162652

PUMP CARRIER . . . . . . . . . . . . . . . . . . . . . . . . 1

3

651475

SHCS HS M10-1.2 X 30 8.8 ZO D912 . . . . . . . 12

4

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . 12

5

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . 12

6

651495

SHCS HS M16-1.5 X 40 10.9 ZO D912 . . . . . . . 2

7

161672

LOCKWASHER S16 . . . . . . . . . . . . . . . . . . . . . 2

8

162486

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

908543/AP0300

Qty. Req.

52

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — HYDRAULIC OIL TANK

ET6006000

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162625

2

160816

HYDRAULIC OIL TANK . . . . . . . . . . . . . . . . . . . 1

18

160996

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

656016

3

161573

CS M12-1.7 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

161382

PRESSURE SWITCH . . . . . . . . . . . . . . . . . . . . . 1

4 5

161485

REDUCER BUSHING . . . . . . . . . . . . . . . . . . . . 2

21

161278

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

161568

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . . 4

6

160949

AIR FILTER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

161645

WASHER/GR. A 13 DIN7349 ZO . . . . . . . . . . . . 4

7

162672

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

24

161414

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 6

25

161436

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 6

26

161418

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

10

161397

OIL STRAINER . . . . . . . . . . . . . . . . . . . . . . . . . 1

27

161423

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

11

161433

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

28

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

12

161475

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

29

161443

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

13

651475

SHCS HS M10-1.2 X 30 8.8 ZO D912 . . . . . . . . 4

30

161427

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 4

31

161430

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . 4

32

161511

NON RETURN VALVE . . . . . . . . . . . . . . . . . . . . 1

16

160975

HYDRAULIC OIL FILTER ASSEMBLY . . . . . . . 1

33

161425

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161067

HYDRAULIC OIL FILTER . . . . . . . . . . . . . . . . . 1

34

160948

OIL LEVEL GLASS . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

53

Description

Qty. Req.

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — HYDRAULIC OIL COOLER

ET6006005

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161172

8

161472

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

2

651515

SHCS HS M8-1.2 X 20 8.8 ZO D912 . . . . . . . . . 4

3

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 4

9

161488

COMPRESSION SLEEVE. . . . . . . . . . . . . . . . . . 2

10

161500

4

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

COMPRESSION NUT . . . . . . . . . . . . . . . . . . . . .2

11

161005

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161433

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

161513

NON RETURN VALVE . . . . . . . . . . . . . . . . . . . . 1

6 7

161473

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

13

161499

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161494

REDUCTION JOINT . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

HYDRAULIC OIL COOLER . . . . . . . . . . . . . . . . 1

908543/AP0300

54

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — TRAVELING MOTORS

ET6006010

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161029

TRAVELING MOTORS . . . . . . . . . . . . . . . . . . . 2

2

161498

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

3

161429

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

160908

HYDRAULIC MOTOR . . . . . . . . . . . . . . . . . . . . 1

6

160914

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

160913

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

55

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — SWIVEL JOINT

ET6006015

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162731

SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

161432

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

3

161491

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

4

161437

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

5

161447

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

6

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

161450

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

160925

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

56

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — HYDRAULIC PUMP

ET6006020

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161013

2

161433

HYDRAULIC PUMP ASSEMBLY. . . . . . . . . . . . 1

8

651485

SHCS HS M12-1.7 X 45 10.9 ZO D912 . . . . . . . 4

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . . 4

3 4

161506

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

10

162621

HYDRAULIC GEAR PUMP . . . . . . . . . . . . . . . . . 1

161586

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

11

162653

HYDRAULIC PISTON PUMP . . . . . . . . . . . . . . . 1

5

161414

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

160907

SEAL KIT, COMPLETE . . . . . . . . . . . . . . . . . . . . 1

6

162651

FLANGE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161054

SEAL KIT, PISTON PUMP . . . . . . . . . . . . . . . . . 1

7

163211

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161055

SEAL KIT, GEAR PUMP . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

57

Description

Qty. Req.

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — TURNING MOTOR

ET6006025

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160873

TURNING MOTOR . . . . . . . . . . . . . . . . . . . . . . 1

14

161451

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

162705

HYDRAULIC MOTOR . . . . . . . . . . . . . . . . . . . . 1

15

161447

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

3

162707

TURNING MOTOR . . . . . . . . . . . . . . . . . . . . . . 1

16

161443

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

4

161429

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161590

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

5

161446

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

18

161585

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

6

161425

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

161445

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

7

161418

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

160875

BRAKE VALVE MANDREL . . . . . . . . . . . . . . . . . 2

8

161423

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

160876

BRAKE VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

22

160877

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

10

161459

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

160880

SEAL KIT, DRIVE MOTOR . . . . . . . . . . . . . . . . . 1

11

161509

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

24

160879

SEAL KIT, TURNING MOTOR. . . . . . . . . . . . . . . 1

12

161310

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

25

160874

DRIVE PINION . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161498

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

Ref. No.

58

Part No.

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — CONTROL VALVE

ET6006030

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161006

2

651473

VALVE BLOCK. . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

161460

REDUCTION JOINT . . . . . . . . . . . . . . . . . . . . . . 3

SHCS HS M10-1.2 X 25 8.8 ZO D912 . . . . . . . . 3

17

161450

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

3

161669

4

161501

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 3

18

161514

MEASURE JOINT . . . . . . . . . . . . . . . . . . . . . . . . 3

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

21

161503

5

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161443

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

22

161452

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

23

161492

REDUCER BUSHING . . . . . . . . . . . . . . . . . . . . . 1

7

161478

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

160972

BALL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161474

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

25

161432

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

10

161458

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

26

160887

CORK WASHER . . . . . . . . . . . . . . . . . . . . . . . . . 3

11

161585

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

27

161464

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

162386

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . .11

28

161507

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

13

161498

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

29

161430

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

161449

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

30

161508

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161447

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

31

161431

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

59

Description

Qty. Req.

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — CONTROL VALVE

ET6006033

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161031

2

161032

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161040

SECTION, ADDITIONAL HYDRAULICS. . . . . . . 1

SECTION, BUCKET. . . . . . . . . . . . . . . . . . . . . . 1

11

161041

SECTION, DRIVE STRAIGHT . . . . . . . . . . . . . . 1

3

161033

SECTION, BOOM . . . . . . . . . . . . . . . . . . . . . . . 1

12

161042

SECTION, SLEW . . . . . . . . . . . . . . . . . . . . . . . . 1

4 5

161034

SECTION, DRIVE RIGHT . . . . . . . . . . . . . . . . . 1

13

161043

SECTION, DOZER BLADE . . . . . . . . . . . . . . . . . 1

161035

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161044

SECTION, TURN. . . . . . . . . . . . . . . . . . . . . . . . . 1

6 7

161036

SECTION, DRIVE LEFT . . . . . . . . . . . . . . . . . . 1

15

161045

SECTION, IN . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161037

SECTION, BOOM . . . . . . . . . . . . . . . . . . . . . . . 1

16

161360

PRESSURE RELIEF VALVE, SECONDARY . . . 7

8

161038

SECTION, BUCKET STICK . . . . . . . . . . . . . . . . 1

17

161359

PRESSURE RELIEF VALVE, PRIMARY. . . . . . . 3

9

161039

SECTION, ADJUSTING . . . . . . . . . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

60

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — PILOT OIL SUPPLY UNIT

ET6006035

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160594

2

161567

PILOT OIL SUPPLY UNIT . . . . . . . . . . . . . . . . . 1

8

161443

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161448

3

160437

ACCUMULATOR . . . . . . . . . . . . . . . . . . . . . . . . 1

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161450

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162672

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 2

11

161514

MEASURE JOINT . . . . . . . . . . . . . . . . . . . . . . . . 1

12

160571

6

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 2

13

SOLENOID SWITCH. . . . . . . . . . . . . . . . . . . . . . 2

160572

7

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

61

Description

Qty. Req.

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — DISTRIBUTION BLOCK

ET6006040

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162730

DISTRIBUTION BLOCK. . . . . . . . . . . . . . . . . . . 1

2

651473

SHCS HS M10-1.2 X 25 8.8 ZO D912 . . . . . . . . 8

3

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 8

4

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . 8

5

162744

CONSOLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161489

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

7

161449

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161447

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

62

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — SELECTION VALVE

ET6006045

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160763

SELECTION VALVE. . . . . . . . . . . . . . . . . . . . . . 1

2

161427

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

3

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

651511

SHCS HS M6-1 X 50 8.8 ZO D912 . . . . . . . . . . 2

5

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 2

6

161660

WASHER/GR A 6.4 ZO DIN125 . . . . . . . . . . . . 4

7

161678

HN M6-1.0 8 ZO. . . . . . . . . . . . . . . . . . . . . . . . . 2

10

160438

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

63

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — HAND LEVERS

ET6006055

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161180

CONTROL LEVER . . . . . . . . . . . . . . . . . . . . . . . 1

7

160487

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2 3

161179

CONTROL LEVER . . . . . . . . . . . . . . . . . . . . . . . 1

8

160486

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161437

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

9

160463

JOYSTICK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

651507

SHCS HS M6-1 X 20 8.8 ZO D912 . . . . . . . . . . 8

10

160469

HANDLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

5

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 8

11

160470

BELLOWS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161660

WASHER/GR A 6.4 ZO DIN125. . . . . . . . . . . . . 8

Description

908543/AP0300

Qty. Req.

64

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — DOZER BLADE VALVE

ET6006060

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

2

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

9

160918

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 4

10

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . . 1

4

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

11

651483

SHCS HS M12-1.7 X 35 10.9 ZO D912 . . . . . . . 1

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

5

161615

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . 4

12

161764

KNOB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

160912

CONTROL LEVER. . . . . . . . . . . . . . . . . . . . . . . 1

13

162027

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

14

160947

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161049

LEVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

65

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — TRAVELING PILOT VALVE

ET6006065

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

2

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

11

160918

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

3 4

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 4

12

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . . 2

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

13

651483

SHCS HS M12-1.7 X 35 10.9 ZO D912 . . . . . . . 2

5

161615

NUT/CAGE M8. . . . . . . . . . . . . . . . . . . . . . . . . . 4

14

160658

KNOB WITH RED SWITCH . . . . . . . . . . . . . . . . 1

6

160760

CONTROL LEVER . . . . . . . . . . . . . . . . . . . . . . . 2

15

162027

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

16

161450

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

18

161443

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

Description

Qty. Req.

Description

Qty. Req.

9

160930

HAND LEVER, TRAVELING . . . . . . . . . . . . . . . 1

19

161764

KNOB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

10

160931

HAND LEVER, TRAVELING . . . . . . . . . . . . . . . 1

20

160947

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

908543/AP0300

66

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — PILOT VALVE AUXILIARY HYDRAULICS

ET6006070

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

1

161154

CONTROL LEVER. . . . . . . . . . . . . . . . . . . . . . . 1

2

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

3

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 4

4

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

5

161615

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . 4

6

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

7

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161443

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

10

160918

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

160947

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

67

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — BOOM CYLINDER

ET6007000

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161002

2

160924

BOOM CYLINDER . . . . . . . . . . . . . . . . . . . . . . . 1

10

161205

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

PISTON ROD . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

162397

3

161026

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

651514

SHCS HS M8-1.2 X 16 8.8 ZO D912 . . . . . . . . . 2

4 5

161052

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 2

161023

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 2

6

162481

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

162784

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

7

161498

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

161650

WASHER/GR A 19 ZO DIN125 . . . . . . . . . . . . . . 2

8

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 2

17

651467

PIN/SPRING M5 X 30 D1481 . . . . . . . . . . . . . . . 1

9

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

18

161010

CYLINDER HOUSING. . . . . . . . . . . . . . . . . . . . .1

Description

908543/AP0300

Qty. Req.

68

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — STICK CYLINDER

ET6007005

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1

160999

STICK CYLINDER . . . . . . . . . . . . . . . . . . . . . . . 1

6

162481

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

161017

PISTON ROD. . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

161498

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

3

161025

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 2

4

161022

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

5

161051

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161011

CYLINDER HOUSING . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

69

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — BUCKET CYLINDER

ET6007010

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160998

BUCKET CYLINDER . . . . . . . . . . . . . . . . . . . . . 1

2

161016

PISTON ROD . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

161024

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161050

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161021

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162481

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 2

Description

Qty. Req.

9

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

10

161498

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

11

161008

CYLINDER HOUSING . . . . . . . . . . . . . . . . . . . . 1

908543/AP0300

70

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — BOOM OFFSET CYLINDER

ET6007015

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161003

2

161430

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

3

161018

PISTON ROD. . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161022

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161027

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161051

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162481

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

160967

THROTTLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

160968

THROTTLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 1

11

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 1

12

161445

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

13

161009

CYLINDER HOUSING . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

BOOM OFFSET CYLINDER . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

71

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — DOZER BLADE CYLINDER

ET6007020

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161004

DOZER BLADE CYLINDER. . . . . . . . . . . . . . . . 1

8

161430

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

2

162650

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161019

PISTON ROD . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

651473

SHCS HS M10-1.2 X 25 8.8 ZO D912 . . . . . . . . 2

10

161028

GLAND . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

4

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 2

11

161020

PISTON ROD . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . 2

12

162481

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 2

13

161053

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162928

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

14

161012

CYLINDER HOUSING. . . . . . . . . . . . . . . . . . . . .1

Description

908543/AP0300

Qty. Req.

Ref. No.

72

Part No.

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — HYDRAULIC PUMP INSTALLATION

ET6008000

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161007

SUCTION HOSE (80 cm) . . . . . . . . . . . . . . . . . 1

2

163209

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Description

Qty. Req.

19

161283

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

20

161284

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

47

161349

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

73

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — HYDRAULIC OIL COOLER INSTALLATION

ET6008005

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

45

161338

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

46

161339

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

74

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — TURNING MOTOR INSTALLATION

ET6008010

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

13

161238

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

14

161350

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

15

161277

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

16

161322

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

17

161324

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

18

161329

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

75

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — TRAVELING MOTOR INSTALLATION

ET6008015

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

38

161279

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 4

48

161334

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 4

49

161253

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

50

161254

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

51

161255

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

52

161256

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

76

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — CONTROL VALVE INSTALLATION

ET6008020

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

7

161236

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 4

8

161351

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

77

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — PILOT OIL SUPPLY UNIT INSTALLATION

ET6008025

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

5

161276

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

14

161350

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

29

161227

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

30

161225

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

31

161230

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

33

161285

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

34

161286

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

35

161287

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

36

161251

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

908543/AP0300

78

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — BOOM OFFSET CYLINDER INSTALLATION

ET6008030

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

43

161311

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

44

161314

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

79

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — DOZER BLADE CYLINDER INSTALLATION

ET6008035

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

40

161313

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

53

161315

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

Description

908543/AP0300

Qty. Req.

80

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — BOOM INSTALLATION

ET6008040

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

9

161345

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

24

161333

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 2

16

162474

HOSE COVERING (70 cm) . . . . . . . . . . . . . . . . 1

25

161341

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 2

17

162474

HOSE COVERING (120 cm) . . . . . . . . . . . . . . . 1

37

161330

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 2

18

162612

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . . . . 2

38

161279

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 2

19

162502

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

39

161280

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

20

162483

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

41

161281

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 4

22

161331

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 6

42

161282

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

23

161332

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

81

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — MOUNTING CLAM SHELL

ET6008045

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161452

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

161505

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

160972

BALL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

160468

QUICK COUPLER. . . . . . . . . . . . . . . . . . . . . . . . 1

3

161498

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

160459

DUST CAP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162856

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

26

161342

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 2

5

161449

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

27

161343

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

6

160724

QUICK COUPLER . . . . . . . . . . . . . . . . . . . . . . . 1

28

161344

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

7

160458

DUST PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

Ref. No.

82

Part No.

Description

Qty. Req.

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — HAND LEVER VALVE INSTALLATION

ET6008050

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161224

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . 12

2

161479

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

3

161465

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

161443

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

161276

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . 10

6

162854

HOSE COVERING (80 cm) . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

83

908543/AP0300

MODEL 602 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 602 — PILOT OIL VALVE INSTALLATION

ET6008055

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

2

161236

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 4

3

161237

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

4

161223

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 3

5

161276

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . 10

6

161238

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

Description

908543/AP0300

Qty. Req.

84

PRINTED IN U.S.A.

ELECTRICAL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86 MODEL 602 — ELECTRICAL INSTALLATION 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86 MODEL 602 — ELECTRICAL INSTALLATION 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87 MODEL 602 — CONTROL BOARD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88 MODEL 602 — RELAY BOX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89 MODEL 602 — RELAY BOX INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90 MODEL 602 — CHASSIS LIGHTS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91 MODEL 602 — WORKING LIGHT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92 MODEL 602 — BATTERY INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93 MODEL 602 — HORN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94

PRINTED IN U.S.A.

85

SECTION H: ELECTRICAL SYSTEM

SECTION H: ELECTRICAL SYSTEM

908543/AP0300

MODEL 602 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 602 — ELECTRICAL INSTALLATION 1

ET6009000

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161105

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

2

162851

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

162848

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161387

RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

86

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 602 — ELECTRICAL INSTALLATION 2

ET6009005

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

1

161106

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

2

162849

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

162850

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161732

SOCKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161361

MICRO SWITCH . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

87

908543/AP0300

MODEL 602 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 602 — CONTROL BOARD

ET6009010

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160744

CONTROL BOARD . . . . . . . . . . . . . . . . . . . . . . 1

18

161376

FUSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

2 3

160535

CONTROL BOARD . . . . . . . . . . . . . . . . . . . . . . 1

19

161374

FUSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161364

FUSE BOX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

162836

FUSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161375

FUSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

21

161365

BUZZER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

5

161377

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

162845

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161378

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

161384

LAMP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

161372

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

161383

LAMP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161996

FRAME. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

25

162846

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

9

161380

IGNITION SWITCH ASSEMBLY . . . . . . . . . . . . 1

26

161385

RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

162841

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

27

161111

RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

162842

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

28

161386

RELAY BRACKET . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

Qty. Req.

Description

Qty. Req.

12

161107

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

29

162838

FUSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162843

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

30

162847

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162844

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

31

161858

FUSE HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161369

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

32

160713

KEY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

161370

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

33

161368

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

17

162837

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908543/AP0300

88

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 602 — RELAY BOX

ET6009015

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162717

2

161613

RELAY PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

160889

RELAY. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

NUT/CAGE M6 . . . . . . . . . . . . . . . . . . . . . . . . . 4

13

160821

3

RELAY. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161660

WASHER/GR A 6.4 ZO DIN125 . . . . . . . . . . . . 4

14

160891

RELAY. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 4

15

163014

FUSE HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

651424

CS M6-1.0 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . 12

16

162025

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

161614

NUT/CAGE M6 . . . . . . . . . . . . . . . . . . . . . . . . . 4

17

651422

CS M5-0.8 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

7

162727

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

656047

HN M6-1.0 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

8

161659

WASHER/GR A 5.3 ZO DIN125 . . . . . . . . . . . . 4

19

656100

HN M5-.8 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

161674

LOCKWASHER S5 . . . . . . . . . . . . . . . . . . . . . . 4

20

651457

HLN INS M6-1.0 8 Z0 . . . . . . . . . . . . . . . . . . . . . 6

11

161103

RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

651456

HLN INS M5-.8 8 ZO . . . . . . . . . . . . . . . . . . . . . . 2

Description

PRINTED IN U.S.A.

Qty. Req.

89

Description

Qty. Req.

908543/AP0300

MODEL 602 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 602 — RELAY BOX INSTALLATION

ET6009020

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161616

NUT/CAGE M8. . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

162608

CLAMP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

651517

SHCS HS M8-1.2 X 30 8.8 ZO D912 . . . . . . . . . 1

4

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 1

5

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 1

6

161105

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

90

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 602 — CHASSIS LIGHTS

ET6009025

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161381

2

161367

HALOGEN LAMP. . . . . . . . . . . . . . . . . . . . . . . . 1

3

160883

LIGHT COVER. . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

INTEGRATED LIGHT . . . . . . . . . . . . . . . . . . . . 1

4

161614

NUT/CAGE M6 . . . . . . . . . . . . . . . . . . . . . . . . . 4

5

651506

SHCS HS M6-1 X 16 8.8 ZO D912 . . . . . . . . . . 4

6

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 4

7

161666

WASHER/GR A 6.4 ZO DIN9021 . . . . . . . . . . . 4

8

162390

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

9

651501

SHCS HS M4-0.7 X 30 8.8 ZO D912 . . . . . . . . . 2

PRINTED IN U.S.A.

91

908543/AP0300

MODEL 602 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 602 — WORKING LIGHT

ET6009030

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160951

2

161367

HALOGEN LAMP . . . . . . . . . . . . . . . . . . . . . . . . 1

3

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 1

4

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . 2

5

161108

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

6

162002

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162852

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

WORKING LIGHT . . . . . . . . . . . . . . . . . . . . . . . 1

908543/AP0300

92

PRINTED IN U.S.A.

MODEL602 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 602 — BATTERY INSTALLATION

ET6009035

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162468

2

162735

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 1

4

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . 1

5

162818

CABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162817

CABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

BATTERY. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

93

908543/AP0300

MODEL 602 MINI-EXCAVATOR ELECTRICAL SYSTEM MODEL 602 — HORN

ET6009040

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161366

HORN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

651515

SHCS HS M8-1.2 X 20 8.8 ZO D912 . . . . . . . . . 1

3

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 1

4

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 1

Description

908543/AP0300

Qty. Req.

94

PRINTED IN U.S.A.

SECTION I: TOOL KIT

SECTION I: TOOL KIT

TOOL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96 MODEL 602 — TOOL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96

PRINTED IN U.S.A.

95

908543/AP0300

MODEL 602 MINI-EXCAVATOR TOOL KIT MODEL 602 — TOOL KIT

ET6010000

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161989

2

161990

SCREW DRIVERS AND WRENCHES . . . . . . . 1

3

161991

HAMMER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161992

GREASE GUN . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161988

TOOL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

TOOL ORGANIZER . . . . . . . . . . . . . . . . . . . . . . 1

908543/AP0300

96

PRINTED IN U.S.A.

SECTION J: DECALS

SECTION J: DECALS

DECALS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98 MODEL 602 — DECALS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98

PRINTED IN U.S.A.

97

908543/AP0300

MODEL 602 MINI-EXCAVATOR DECALS MODEL 602 — DECALS

ET6010005

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162668

2

161981

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161969

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

18

161987

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3 4

162670

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

19

161982

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

161985

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

161974

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

162827

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

21

162824

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161986

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

162669

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162831

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

161970

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

162823

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

161976

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162671

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

25

162825

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161965

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

26

161967

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

11

162449

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

28

162013

ID-PLATE (BIG) . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

162452

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

30

162832

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162451

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

31

162833

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162450

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

32

162834

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

162822

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

33

162657

DECAL SET. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

161966

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908543/AP0300

98

PRINTED IN U.S.A.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

160407 160408 160409 160427 160437 160438 160458

39 39 14 42 61 63 25 82 25 82 64 25 25 82 64 64 29 64 64 29 33 33 34 36 30 30 39 39 88 61 61 61 39 7 33 34 33 34 33 35 19 66 28 31 36 36 88 28 31 28 31 29 82 88 45 66 63 53 89 43 38 7 58 58 58 58 58 58 58 18 20 91 7 8 7 7 89 89 48 48 48 48 46 26 26 26

7 8 31 7 3 10 18 7 13 11 9 19 12 10 10 11 8 8 7 11 11 1 1 3 10 11 31 32 2 12 13 1 12 3 8 5 7 4 17 4 18 14 1 23 8 7 32 8 19 9 18 13 6 1 1 6 1 2 13 15 17 4 1 25 20 21 22 24 23 6 4 3 6 11 9 45 12 14 17 6 7 8 7 3 1 2

160907 160908 160912 160913 160914 160918

57 55 65 55 55 65 66 67 68 56 24 24 24 24 66 66 25 26 26 26 25 24 14 14 14 7 65 66 67 53 53 38 92 71 71 82 26 53 7 7 7 7 7 9 9 9 10 10 9 30 32 32 33 34 35 35 36 37 37 53 26 70 25 69 24 68 14 71 12 72 54 73 70 71 68 69 72 57 52 70 69 71 72 72 70 69

12 5 6 7 6 9 11 10 2 8 2 3 4 5 9 10 22 8 19 16 6 19 3 8 7 47 14 20 11 34 6 27 1 8 9 2 11 16 5 8 2 43 44 3 5 6 5 6 12 23 1 2 19 10 1 3 13 1 2 18 15 1 30 1 25 1 6 1 10 1 11 1 11 13 18 10 14 1 1 2 2 3 9 11 5 4

160459 160463 160467 160468 160469 160470 160481 160486 160487 160488 160494 160495 160496 160525 160526 160527 160532 160533 160535 160571 160572 160594 160611 160638 160639 160640 160641 160642 160644 160658 160711 160712 160713 160714 160715 160716 160724 160744 160755 160760 160763 160816 160821 160844 160860 160865 160873 160874 160875 160876 160877 160879 160880 160882 160883 160884 160885 160886 160889 160891 160892 160897 160898 160899 160903 160904 160905 160906

PRINTED IN U.S.A.

160924 160925 160926 160927 160928 160929 160930 160931 160932 160933 160934 160937 160938 160939 160942 160944 160945 160947 160948 160949 160950 160951 160967 160968 160972 160974 160975 160977 160978 160979 160980 160981 160982 160983

160985 160986 160987 160988 160989 160990 160991 160992 160993 160994 160995 160996 160998 160999 161002 161003 161004 161005 161007 161008 161009 161010 161011 161012 161013 161014 161016 161017 161018 161019 161020 161021 161022

Part No. 161023 161024 161025 161026 161027 161028 161029 161030 161031 161032 161033 161034 161035 161036 161037 161038 161039 161040 161041 161042 161043 161044 161045 161047 161048 161049 161050 161051 161052 161053 161054 161055 161057 161058 161059 161060 161061 161062 161064 161065 161067 161077 161078 161080 161082 161083 161084 161085 161086 161087 161089 161091 161093 161096 161097 161098 161102 161103 161104 161105 161106 161107 161108 161109 161111 161112 161114 161154 161172 161179 161180 161187 161188 161189 161190 161191 161204

99

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

71 68 70 69 68 71 72 7 55 14 60 60 60 60 60 60 60 60 60 60 60 60 60 60 60 26 24 65 70 69 71 68 72 57 57 19 18 43 43 18 20 18 19 18 20 43 53 38 36 34 34 34 29 29 29 29 30 34 35 36 36 36 38 89 43 86 90 87 88 92 49 88 42 42 67 54 64 64 18 19 12 12 24 25 12 20

4 5 3 3 3 5 10 7 1 9 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 10 26 8 4 5 6 4 13 13 14 4 19 2 3 17 15 24 5 14 11 25 17 1 12 2 11 14 3 2 5 7 24 3 2 6 9 15 22 11 11 1 6 1 12 5 4 27 25 1 1 1 2 1 25 12 3 4 27 31 2 9

161205 161223 161224 161225 161227 161228 161230 161236

68 84 83 78 78 16 78 77 84 84 75 84 78 76 76 76 76 78 83 84 75 43 53 76 81 81 81 81 73 73 78 78 78 58 79 80 79 80 75 38 75 75 81 81 81 81 76 74 74 81 82 82 82 81 73 75 78 77 18 60 60 39 87 88 88 94 91 92 88 88 88 88 88 88 88 88 88 88 91 53 88 88 88 88 86 44

10 4 1 30 29 8 31 7 2 3 13 6 36 49 50 51 52 5 5 5 15 21 21 38 38 39 41 42 19 20 33 34 35 12 43 40 44 53 16 32 17 18 37 22 23 24 48 45 46 25 26 27 28 9 47 14 14 8 31 17 16 37 5 3 21 1 2 2 33 15 16 7 19 4 18 5 6 9 1 20 24 23 26 28 4 8

161237 161238 161251 161253 161254 161255 161256 161276 161277 161278 161279 161280 161281 161282 161283 161284 161285 161286 161287 161310 161311 161313 161314 161315 161322 161323 161324 161329 161330 161331 161332 161333 161334 161338 161339 161341 161342 161343 161344 161345 161349 161350 161351 161358 161359 161360 161361 161364 161365 161366 161367 161368 161369 161370 161372 161374 161375 161376 161377 161378 161380 161381 161382 161383 161384 161385 161386 161387 161391

NUMERICAL INDEX

602

908543/AP0300

602 Part No. 161392 161393 161396 161397 161403 161404 161405 161411

161412

NUMERICAL INDEX

161414 161415 161416 161417 161418 161422

161423

161424 161425 161426

161427 161429 161430 161432 161433 161436 161437 161443

161445 161446 161447 908543/AP0300

Page No.

Ref. No.

44 16 16 38 38 34 36 53 39 34 25 26 14 24 25 26 7 12 16 68 69 70 71 72 53 57 43 7 7 43 53 58 14 16 24 25 26 68 69 70 71 38 43 53 58 38 43 53 58 43 53 55 58 61 63 65 66 67 43 53 63 43 55 58 53 71 72 56 53 54 57 53 56 64 53 58 61 66 67 83 38 58 71 38 58 56

9 7 12 14 15 12 10 10 17 6 23 9 10 15 10 6 21 7 4 8 8 8 10 6 24 5 8 22 20 23 26 7 11 5 16 11 7 9 9 9 11 18 24 27 8 19 22 33 6 10 28 4 9 7 3 7 7 6 9 30 2 20 3 4 31 2 8 2 11 5 2 25 4 3 29 16 8 18 9 4 29 19 12 23 5 5

Part No.

161448

161449 161450 161451 161452 161453 161454 161459 161461 161463 161465 161468 161469 161470 161472 161473 161475 161477 161479 161481 161482 161484 161485 161488 161489 161491 161494 161496 161498

161499 161500 161504 161505 161506 161509 161511 161513 161514 161521 161526 161527 161528 161529 161530 161531 161550 161551 161554 161567 161568 161570 161572 161573 161581 161582 161585 161586 161587 161588 161589 161590 161610

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

58 62 56 61 66 67 62 82 56 61 66 58 25 82 16 25 58 16 38 83 16 16 38 54 54 53 38 83 25 16 38 53 54 62 56 54 38 55 58 68 69 70 82 54 54 38 25 82 57 58 53 54 61 12 12 24 25 26 25 25 26 14 24 14 26 24 24 61 53 14 8 53 12 25 24 58 57 14 14 25 26 12 24 25 58 21

15 8 6 9 8 7 7 5 7 10 16 14 14 1 11 21 10 6 25 3 9 10 20 8 6 12 28 2 20 13 21 4 9 6 3 7 30 2 13 7 7 10 3 13 10 26 15 8 3 11 32 12 11 11 5 31 35 5 5 3 20 5 18 24 21 7 11 2 5 12 5 3 12 4 32 18 4 26 25 24 22 6 30 36 17 6

161611 161613 161614

17 89 18 89 91 22 38 39 47 65 66 67 18 90 33 17 19 7 17 14 19 39 7 7 7 14 28 39 46 52 53 62 72 92 17 47 14 17 19 28 7 28 31 43 46 53 7 14 68 39 19 43 89 18 38 63 64 89 18 20 20 31 39 44 48 53 54 61 65 66 67 68 90 14 21 22 18 39 91 15 18 22 38 46 47 49

4 2 35 6 4 6 8 6 13 5 5 5 13 1 10 7 8 34 9 27 19 39 41 40 39 30 6 18 10 5 15 4 5 4 13 20 19 16 11 10 36 3 21 6 13 23 35 16 16 15 2 14 8 23 11 6 6 3 11 8 16 11 5 6 4 9 4 6 4 4 4 14 5 35 5 4 32 36 7 8 29 9 7 20 11 9

100

161615

161616 161618 161619 161621 161625 161626 161627 161628 161635 161637 161640

161641 161642

161643 161645 161646 161647 161650 161651 161653 161658 161659 161660

161661

161663 161666 161667

Part No.

161668 161669

161670

161672 161673 161674 161675

161676

161677 161678 161683 161688 161689 161691 161722 161728 161730 161732 161764 161805 161831 161834 161843 161848 161858 161868 161921

Page No.

Ref. No.

93 94 33 45 7 14 17 21 22 28 46 52 53 62 72 92 14 17 19 43 46 47 53 57 65 66 26 52 43 8 89 16 18 19 38 39 63 64 89 91 7 15 18 20 22 38 39 44 45 46 47 48 49 53 54 61 65 66 67 68 90 94 17 18 63 14 24 25 25 26 24 17 16 39 39 87 65 66 39 39 39 30 39 88 39 29

3 4 9 13 37 21 12 4 3 7 9 4 14 3 4 3 18 15 10 5 12 19 22 9 10 12 12 7 13 9 9 3 22 7 10 35 5 5 4 6 38 7 10 7 8 6 4 5 12 19 10 3 8 8 3 5 3 3 3 13 4 3 6 12 7 14 22 9 2 4 17 8 1 33 9 4 12 19 26 11 22 14 13 31 16 15

PRINTED IN U.S.A.

Part No.

Page No.

Ref. No.

161922 161923 161924 161929

29 29 29 18 19 37 33 39 30 34 47 33 31 33 34 98 98 98 98 98 30 36 98 98 98 98 98 98 98 96 96 96 96 96 88 92 29 46 98 15 38 20 47 30 30 34 47 47 89 65 66 30 33 29 29 31 31 39 38 24 18 45 18 39 39 39 39 39 45 45 45 47 18 91 68 45 98 98 98 98 93 81 81 20 68 69

16 18 17 28 15 10 6 20 3 17 24 12 24 15 15 10 16 26 17 23 27 23 20 24 2 19 4 6 18 5 1 2 3 4 8 6 23 17 28 9 4 18 25 1 2 9 23 26 16 13 15 12 4 28 34 6 2 24 16 12 4 14 3 27 28 29 30 21 5 6 4 16 5 8 11 3 11 14 13 12 1 16 17 19 6 6

161937 161941 161947 161949 161951 161964 161965 161966 161967 161969 161970 161974 161976 161981 161982 161985 161986 161987 161988 161989 161990 161991 161992 161996 162002 162006 162008 162013 162015 162016 162017 162018 162020 162025 162027 162029 162033 162035 162036 162044 162048 162064 162066 162072 162073 162203 162210 162211 162212 162213 162214 162349 162350 162351 162387 162389 162390 162397 162398 162449 162450 162451 162452 162468 162474 162476 162481

PRINTED IN U.S.A.

Part No.

162483 162486 162487 162491 162492 162502 162504 162505 162506 162600 162601 162602 162603 162604 162605 162606 162607 162608 162609 162611 162612 162615 162616 162617 162619 162621 162622 162623 162624 162625 162626 162627 162628 162629 162630 162631 162632 162633 162634 162635 162636 162637 162638 162639 162640 162641 162642 162643 162644 162645 162646 162647 162648 162649 162650 162651 162652 162653 162654 162655 162656 162657 162658 162659 162660 162661 162666 162667 162668 162669 162670 162671 162672 162673 162674 162675 162691 162705

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

70 71 72 81 52 45 8 8 81 43 44 45 8 30 33 33 33 18 19 38 33 29 90 24 48 81 7 7 44 48 57 19 21 14 53 43 15 15 15 15 15 17 17 22 7 12 46 46 46 46 47 47 47 14 47 24 25 14 25 72 57 52 57 17 17 17 98 20 46 46 44 17 20 98 98 30 98 98 53 61 37 39 18 20 18 58

6 7 12 20 8 8 6 10 19 17 10 9 4 4 18 2 3 26 13 3 13 19 2 9 16 18 11 16 7 11 10 1 1 1 1 1 1 2 3 4 5 1 5 1 1 1 3 4 1 2 21 22 8 32 17 1 1 2 37 2 6 2 11 22 25 23 33 1 5 6 3 21 2 1 22 28 3 9 7 4 11 38 7 5 30 2

162707 162713 162715 162716

58 21 14 18 20 89 7 7 8 8 8 7 7 7 89 62 7 56 24 25 14 93 29 29 36 39 18 22 62 19 17 45 9 9 9 10 9 9 9 9 9 9 9 9 9 10 10 10 10 38 29 29 29 29 29 29 29 31 31 36 36 36 36 37 37 37 37 68 17 43 18 18 30 17 18 19 29 29 29 29 29 30 30 30 30 30

3 2 28 8 3 1 14 15 1 3 2 12 13 17 7 1 10 1 20 7 4 2 29 22 19 2 1 5 5 16 19 2 1 2 4 4 7 8 9 10 11 13 14 15 16 1 2 3 7 2 1 25 31 32 33 35 36 1 13 1 2 20 22 3 4 6 7 15 24 7 38 39 25 2 2 17 4 6 10 12 27 7 18 19 20 21

162805 162806 162807 162808 162809 162810 162811 162812 162813 162814 162815 162816 162817 162818 162819 162820 162822 162823 162824

30 31 31 31 31 31 32 34 36 36 37 37 93 93 17 17 98 98 30 36 98 98 98 98 98 98 98 38 88 88 88 29 29 88 88 88 88 88 88 88 86 87 87 86 92 38 83 28 82 30 14 18 14 30 30 30 36 24 19 43 33 29 31 31 36 29 30 29 30 43 8 12 72 43 89 17 24 25 17 24 19 73 48 57 42 49

22 3 5 7 8 16 3 7 17 21 5 8 6 5 26 27 15 8 30 24 21 25 5 7 30 31 32 13 20 17 29 24 26 10 11 13 14 22 25 30 3 2 3 2 7 12 6 13 4 9 33 21 20 5 26 13 4 10 3 12 14 9 17 14 14 21 17 37 6 16 7 8 7 18 15 14 28 33 17 33 20 2 18 7 8 3

162717 162718 162719 162720 162721 162722 162724 162725 162726 162727 162730 162731 162733 162734 162735 162736 162737 162738 162742 162743 162744 162745 162746 162747 162748 162749 162750 162751 162752 162753 162754 162755 162756 162757 162758 162759 162760 162761 162762 162763 162764 162765 162766 162767 162768 162769 162770 162771 162772 162773 162776 162777 162778 162779 162780 162781 162782 162783 162784 162785 162786 162787 162788 162789 162791 162793 162794 162795 162796 162797 162798 162799 162800 162801 162802 162803 162804

101

162825 162827 162831 162832 162833 162834 162835 162836 162837 162838 162839 162840 162841 162842 162843 162844 162845 162846 162847 162848 162849 162850 162851 162852 162854 162855 162856 162857 162858 162860 162861 162862 162863 162864 162865 162866 162867 162868 162869 162870 162923 162924 162925 162926 162927 162928 162929 163014 163204 163205 163206 163207 163208 163209 163210 163211 425-34635 425-34652

NUMERICAL INDEX

602

908543/AP0300

602 Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

425-34683 425-36091

42 42 44 48 42 42 42 42 42 42 42 42 44 42 42 42 42 42 42 42 42 42 42 42 47 47 47 47 47 48 48 48 48 48 48 49 47 47 39 46 7 28 28 28 31 7 7 7 14 18 89 36 38 89 30 30 14 24 25 24 39 12 24 25 28 31 46 7 89 18 29 36 45 89 18 26 31 36 39 93 18 20 17 39 18 33

6 10 2 12 2 3 4 5 18 19 20 9 1 11 12 13 14 15 16 17 21 24 23 22 1 2 3 4 5 14 15 13 1 9 10 2 6 7 14 14 31 5 4 2 20 29 24 23 15 37 17 16 9 5 15 16 13 21 8 34 19 14 29 34 11 22 16 25 21 27 30 18 10 20 36 18 15 5 23 4 15 12 3 25 34 5

651467 651471 651472

68 14 7 21 22 17 62 72 14 46 52 53 12 14 19 46 65 66 47 57 17 7 26 7 52 91 17 8 19 91 39 64 16 63 20 45 46 68 7 15 49 54 94 48 20 39 90 26 44 18 39 47 65 66 67 43 47 53 18 19 89 31 34 39 48 49 29 18 31 38 47 18 20 30 89 14 28 22 31 45 47 18 20 7 14 46

17 23 32 3 2 11 2 3 29 8 3 13 13 17 9 11 11 13 18 8 20 26 13 30 6 9 10 8 6 5 34 4 2 4 17 11 18 12 33 6 6 2 2 2 6 10 3 17 4 20 3 9 2 2 2 4 27 19 33 14 18 12 8 1 5 7 14 18 10 5 12 9 10 8 19 34 12 7 9 7 28 16 14 28 22 15

656149

29

20

NUMERICAL INDEX

425-36098 425-36108 425-36109 425-36110 425-36111 425-36112 425-36113 425-36114 425-36115 425-36116 425-36117 425-36118 425-36119 425-36120 425-36121 425-36122 425-36123 425-36124 425-36125 425-36126 425-36127 425-36128 425-36129 425-36130 425-36131 425-36132 425-36134 425-36135 425-36136 425-36137 425-36138 425-36139 425-36171 425-36172 651390 651391 651393 651396 651403 651405 651416 651418 651422 651424 651425 651428 651444 651448 651449

651451 651456 651457

651458

651459 651460 651463 651466 908543/AP0300

651473 651475

651477 651479 651483 651485 651488 651491 651494 651495 651501 651502 651504 651506 651507 651509 651511 651514

651515

651516 651517 651519 656001

656016 656047 656048

656092 656093

656094 656100 656102 656105

656116 656148

102

Part No.

Page No.

Ref. No.

PRINTED IN U.S.A.

TORQUE SPECIFICATIONS NOTE:

Use these torque values when tightening GEHL hardware (excluding: Locknuts and Selftapping, Thread Forming and Sheet Metal Screws) unless specified otherwise.

All torque values are in Lb-Ft except those marked with an * which are Lb-In (For metric torque value Nm, multiply Lb-Ft value by 1.355 or Lb-In value by 0.113) (To convert Nm to Lb–Ft multiply by 0.738)

Unified National Thread

Grade 2

Grade 5

Dry

Lubed

Dry

Lubed

Dry

Lubed

8-32 8-36

19* 20*

14* 15*

30* 31*

22* 23*

41* 43*

31* 32*

10-24 10-32

27* 31*

21* 23*

43* 49*

32* 36*

60* 68*

45* 51*

1/4-20 1/4-28

66* 76*

50* 56*

9 10

75* 86*

12 14

9 10

5/16-18 5/16-24

11 12

9

17 19

13 14

25

18 20

3/8-16 3/8-24

20 23

15 17

30 35

23 25

45 50

35

7/16-14 7/16-20

32 36

24 27

50 55

35 40

70 80

55 60

1/2-13 1/2-20

50 55

35 40

75 90

55 65

110 120

80 90

9/16-12 9/16-18

70 80

55 60

110 120

80 90

150 170

110 130

5/8-11 5/8-18

100 110

75 85

150 180

110 130

220 240

170 180

3/4-10 3/4-16

175 200

130 150

260 300

200 220

380 420

280 320

7/8-9 7/8-14

170 180

125 140

430 470

320 360

600 660

460 500

1-8 1-14

250 270

190 210

640 710

480 530

900 1000

680 740

Metric Course Thread

Grade 8.8

8.8

Grade 10.9

Grade 8

10.9

Grade 12.9

12.9

Dry

Lubed

Dry

Lubed

Dry

Lubed

M6-1

8

6

11

8

13.5

10

M8-1.25

19

14

27

20

32.5

24

M10-1.5

37.5

28

53

39

64

47

M12-1.75

65

48

91.5

67.5

111.5

82

M14-2

103.5

76.5

145.5

108

176.5

131

M16-2

158.5

117.5

223.5

165.5

271

200



Gehl Company 143 Water Street, P.O. Box 179, West Bend, WI 53095-0179, U.S.A.

908539/AP1099

1999 GEHL Company. All rights reserved.

Printed in U.S.A.