GEHL Mini-excavator 272-292 Parts Manual(908540) - PDF DOWNLOAD

Mini-excavator

PARTS MANUAL

CONSTRUCTION

272-292

Form No.

908540

Introduction When ordering service parts, specify the correct part number, full description, quantity required, the unit model number and serial number.

The Mini-excavator model and serial numbers are on a plate located on the lower left front outer side of the cabin (from the driver’s perspective).

OUR Company reserves the right to make changes or improvements in the design or construction of any part of the unit without incurring the obligation to install such changes on any previously delivered units.

To ensure continued safe operation, replace damaged or worn-out parts with genuine Factory service parts, BEFORE attempting to operate this equipment.

Refer to the abbreviations table located on this page for the various fastener descriptions.

In the exploded view parts list, Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in that section. Refer to the Table of Contents for locations of specific assemblies.

NOTE: The following abbreviations may be used herein:

AR ASSD ASSY CB CCW CP CS CTR CW DEG DIA FCHC FCS FHMS FL FLN FLS FW GA GR HD HLN HJN HN HS INCL INS JT LG LH LN LW M MM/mm NF PB PTO RH RHMS RPM RT SERR SHCS SHSS SN SQ SQSS T TFS THMS THRD WLDMT ZO #

– As Required – Assembled – Assembly – Carriage Bolt – Counterclockwise – Cotter Pin – Cap Screw (Hexagon Head) – Center – Clockwise – Degree – Diameter – Flanged Cap Screw – Flat Head Machine Screw – Flanged – Flanged Lock Nut (Hexagon) – Flanged Lock Screw (Hexagon) – Flat Washer – Gauge – Grade – Hard or Head – Hex Lock Nut – Hex Jam Nut – Hex Nut – Includes – Joint – Large – Left Hand – Lock Nut – Lock Washer – Metric – Millimeter – National Fine – Plow Bolt – Power Take Off – Right Hand – Round Head Machine Screw – Revolutions Per Minute – Right – Serrated – Socket Head Cap Screw – Socket Head Set Screw – Serial Number or Slotted Nut – Square – Square Head Set Screw – Tooth or Teeth – Thread Forming Screw – Truss Head Machine Screw – Thread – Weldment – Zinc Oxide Plating – Number

Table of Contents SECTION A: UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5 UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 MODEL 272 — UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 MODEL 292 — UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 MODELS 272-292 — TRACK TENSION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 MODELS 272-292 — TRACK ROLLER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 SECTION B: DOZER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 DOZER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 MODELS 272-292 — DOZER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 SECTION C: CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15 CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16 MODELS 272-292 — CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 MODELS 272-292 — CHASSIS COVERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 MODELS 272-292 — CHASSIS LUBRICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 MODELS 272-292 — HOOD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 SECTION D: TILT FRAME . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21 TILT FRAME . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22 MODELS 272-292 — TILT FRAME . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 MODELS 272-292 — ISOLATION MATS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 MODELS 272-292 — VALVE COVER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 SECTION E: BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25 BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26 MODELS 272-292 — BOOM. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26 MODELS 272-292 — STICK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28 SECTION F: CABIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31 CABIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32 MODELS 272-292 — CABIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 MODELS 272-292 — FRAME . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33 MODELS 272-292 — RADIO KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34 MODELS 272-292 — CABLES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 MODELS 272-292 — FRONT WINDSHIELD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36 MODELS 272-292 — LOWER FRONT WINDSHIELD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38 MODELS 272-292 — UPPER FRONT WINDSHIELD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39 MODELS 272-292 — SIDE WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40 MODELS 272-292 — REAR WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41 MODELS 272-292 — CABIN DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42 MODELS 272-292 — LOWER RIGHT SIDE WINDOW. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44 MODELS 272-292 — SLIDING SIDE WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45 MODELS 272-292 — DRIVERS SEAT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46 MODELS 272-292 — CAB HEATING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47 SECTION G: DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49 DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .50 MODELS 272-292 — DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 MODELS 272-292 — ENGINE SUSPENSION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51 MODELS 272-292 — COOLING WATER RADIATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52 PRINTED IN U.S.A.

1

908540/AP0300

MODELS 272-292 — AIR INTAKE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53 MODELS 272-292 — EXHAUST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54 MODELS 272-292 — FUEL LINE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55 MODELS 272-292 — ACCELERATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56 MODELS 272-292 — DIESEL TANK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57 SECTION H: HYDRAULIC SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .59 HYDRAULIC SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60 MODELS 272-292 — HYDRAULIC PUMP ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60 MODELS 272-292 — HYDRAULIC OIL TANK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61 MODELS 272-292 — HYDRAULIC PUMP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62 MODELS 272-292 — HYDRAULIC OIL COOLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63 MODELS 272-292 — HYDRAULIC MOTOR 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64 MODELS 272-292 — HYDRAULIC MOTOR 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65 MODELS 272-292 — TRAVEL MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66 MODELS 272-292 — TRAVELING MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67 MODELS 272-292 — CONTROL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68 MODELS 272-292 — CONTROL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69 MODELS 272-292 — PILOT OIL SUPPLY UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70 MODEL 272 — SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71 MODEL 292 — SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72 MODELS 272-292 — TURNING MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73 MODELS 272-292 — TURNING MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74 MODELS 272-292 — TURNING MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75 MODELS 272-292 — VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76 MODELS 272-292 — SELECTION VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77 MODELS 272-292 — TRAVELING CHECK VALVE HYDRAULICS . . . . . . . . . . . . . . . . . . . 78 MODELS 272-292 — ADDITIONAL CHECK VALVE HYDRAULICS . . . . . . . . . . . . . . . . . . 79 MODELS 272-292 — HAND LEVERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80 MODEL 272 —DOZER BLADE VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81 MODEL 292 —DOZER BLADE VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82 MODELS 272-292 — DOZER BLADE CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83 MODELS 272-292 — BOOM OFFSET CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84 MODELS 272-292 — BOOM CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85 MODELS 272-292 — STICK CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86 MODELS 272-292 — BUCKET CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87 MODEL 292 — TILT CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88 MODELS 272-292 — HYDRAULIC PUMP INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . 89 MODELS 272-292 — HYDRAULIC OIL COOLER INSTALLATION . . . . . . . . . . . . . . . . . . . 90 MODELS 272-292 — PILOT VALVE INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91 MODELS 272-292 — HAND LEVER INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92 MODELS 272-292 — PILOT OIL SUPPLY UNIT INSTALLATION . . . . . . . . . . . . . . . . . . . . . 93 MODEL 272 — TRAVELING GEAR INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94 MODEL 292 — TRAVELING GEAR INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95 MODELS 272-292 — TURNING MOTOR INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . 96 MODELS 272-292 — BOOM OFFSET CYLINDER INSTALLATION . . . . . . . . . . . . . . . . . . . 97 MODELS 272-292 — TILT CYLINDER INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98 MODEL 272 — DOZER BLADE INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99 MODEL 292 — DOZER BLADE INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100 MODELS 272-292 — BOOM INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101 MODELS 272-292 — ADDITIONAL HYDRAULIC INSTALLATION . . . . . . . . . . . . . . . . . . 102

908540/AP0300

2

PRINTED IN U.S.A.

SECTION I: ELECTRICAL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .103 ELECTRICAL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .104 MODELS 272-292 — ELECTRICAL INSTALLATION 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 104 MODELS 272-292 — ELECTRICAL INSTALLATION 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105 MODELS 272-292 — BATTERY INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106 MODELS 272-292 — CONTROL BOARD. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 107 MODELS 272-292 — RELAY BOX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108 MODELS 272-292 — HEADLIGHTS 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109 MODELS 272-292 — HEADLIGHTS 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110 MODELS 272-292 — HORN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 111 SECTION J: TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .113 TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .114 MODELS 272-292 — TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 114 SECTION K: DECALS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .115 DECALS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .116 MODEL 272 — DECALS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116 MODEL 292 — DECALS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117

PRINTED IN U.S.A.

3

908540/AP0300

908540/AP0300

4

PRINTED IN U.S.A.

SECTION A: UNDERCARRIAGE

SECTION A: UNDERCARRIAGE

UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 MODEL 272 — UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 MODEL 292 — UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 MODELS 272-292 — TRACK TENSION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 MODELS 272-292 — TRACK ROLLER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

PRINTED IN U.S.A.

5

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR UNDERCARRIAGE MODEL 272 — UNDERCARRIAGE

ET2720100

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

908540/AP0300

6

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR UNDERCARRIAGE MODEL 272 — UNDERCARRIAGE Ref. No.

Part No.

1

162523

UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . 1

18

651413

CS M16-2.0 X 60 F 10.9 ZO . . . . . . . . . . . . . . . 16

2

160795

TRACK TENSIONING . . . . . . . . . . . . . . . . . . . . 2

19

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 12

3

160794

TRACK ROLLER ASSEMBLY . . . . . . . . . . . . . . 8

20

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 16

4

160710

SPROCKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

21

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . 12

5

162330

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

22

651483

SHCS HS M12-1.7 X 35 10.9 ZO D912 . . . . . . 18

6

162332

CHAIN GUIDANCE . . . . . . . . . . . . . . . . . . . . . . 4

23

161653

WASHER/ROUND HI-TENS 21 DIN6916 . . . . . 16

7

162329

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

656143

LW REG M20 ZO . . . . . . . . . . . . . . . . . . . . . . . 16

8

162331

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

25

161647

WASHER/ROUND HI-TENS 17 . . . . . . . . . . . . 16

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

9

160638

NON RETURN VALVE . . . . . . . . . . . . . . . . . . . . 2

26

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 12

10

162527

SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . 1

27

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 1

11

162522

TURNTABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

28

161417

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

160723

TRAVEL GEAR . . . . . . . . . . . . . . . . . . . . . . . . . 2

29

161578

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

13

160737

RUBBER TRACK . . . . . . . . . . . . . . . . . . . . . . . . 1

30

651395

CS M10-1.5 X 30 C 10.9 ZO . . . . . . . . . . . . . . . . 4

14

656148

SHCS HS 12-1.75X40 10.9 ZO . . . . . . . . . . . . 18

31

656090

CS M10-1.5 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . 4

15

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . 18

32

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . . 4

16

651391

CS M10-1.5 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . 8

33

161624

LW SPRING B12 DIN 7982. . . . . . . . . . . . . . . . 18

17

161617

NUT/HEX DOMED CAP M20 . . . . . . . . . . . . . 16

34

162032

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

PRINTED IN U.S.A.

7

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR UNDERCARRIAGE MODEL 292 — UNDERCARRIAGE

ET2720105

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

908540/AP0300

8

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR UNDERCARRIAGE MODEL 292 — UNDERCARRIAGE Ref. No.

Part No.

Ref. No.

Part No.

1

162319

2

160795

UNDERCARRIAGE . . . . . . . . . . . . . . . . . . . . . . 1

27

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 1

TRACK TENSIONING . . . . . . . . . . . . . . . . . . . . 2

28

161417

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

160794

4

160710

TRACK ROLLER ASSEMBLY . . . . . . . . . . . . . . 8

29

161578

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

SPROCKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

30

162318

5

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

162330

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

31

160791

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162332

CHAIN GUIDANCE . . . . . . . . . . . . . . . . . . . . . . 4

32

160792

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

162346

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

33

160790

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

162331

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

34

161638

NUT/GROOVE SLEEVE SECURING M55X2. . . 2

9

160638

NON RETURN VALVE . . . . . . . . . . . . . . . . . . . . 2

35

162026

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

10

162323

SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . 1

36

651430

CS M8-1.2 X 12 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

Description

Qty. Req.

Description

Qty. Req.

11

162522

TURNTABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

37

160784

TILT CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

160723

TRAVEL GEAR . . . . . . . . . . . . . . . . . . . . . . . . . 2

38

162321

CYLINDER COVER . . . . . . . . . . . . . . . . . . . . . . 1

13

160737

RUBBER TRACK . . . . . . . . . . . . . . . . . . . . . . . . 2

39

162479

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

656148

SHCS HS 12-1.75X40 10.9 ZO . . . . . . . . . . . . 18

40

161411

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 2

15

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . 20

41

161416

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

16

651391

CS M10-1.5 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . 8

42

651439

HB M8-1.2 X 80 C 8.8 ZO . . . . . . . . . . . . . . . . . . 1

17

161617

NUT/HEX DOMED CAP M20 . . . . . . . . . . . . . 16

43

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . . 5

18

651493

SHCS HS M16-1.5 X 55 10.9 ZO D912 . . . . . . 16

44

161624

LW SPRING B12 DIN 7982. . . . . . . . . . . . . . . . 18

19

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . 12

45

161624

LW SPRING B12 DIN 7982. . . . . . . . . . . . . . . . 18

20

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . 18

46

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . . 4

21

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . 12

47

162483

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

22

651483

SHCS HS M12-1.7 X 35 10.9 ZO D912 . . . . . . 18

48

651395

CS M10-1.5 X 30 C 10.9 ZO . . . . . . . . . . . . . . . . 4

23

161653

WASHER/ROUND HI-TENS 21 DIN6916 . . . . 16

49

656090

CS M10-1.5 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . 4

24

656143

LW REG M20 ZO . . . . . . . . . . . . . . . . . . . . . . . 16

50

162320

WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

25

161647

WASHER/ROUND HI-TENS 17. . . . . . . . . . . . 16

51

162473

HOSE COVERING (30 cm). . . . . . . . . . . . . . . . . 1

26

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . 12

PRINTED IN U.S.A.

9

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR UNDERCARRIAGE MODELS 272-292 — TRACK TENSION

ET2720110

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162337

2

162336

ROLLER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161562

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

SHAFT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161563

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

162342

4

162341

CONNECTING LINK L . . . . . . . . . . . . . . . . . . . . 1

15

162344

SPRING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

CONNECTING LINK R . . . . . . . . . . . . . . . . . . . 1

16

162484

5

162340

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

6

162339

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

7

162343

CYLINDER TUBE . . . . . . . . . . . . . . . . . . . . . . . 1

19

162024

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

8

162338

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

162492

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162507

BEARING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

21

162488

COTTER PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

10

162491

RETAINING RING . . . . . . . . . . . . . . . . . . . . . . . 2

22

161655

COTTER PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161572

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

23

160796

ROLLER ASSEMBLY . . . . . . . . . . . . . . . . . . . . . 1

12

161569

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908540/AP0300

Qty. Req.

10

Description

Qty. Req.

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161624

LW SPRING B12 DIN 7982 . . . . . . . . . . . . . . . . . 4

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR UNDERCARRIAGE MODELS 272-292 — TRACK ROLLER

ET2720115

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162333

2

162334

ROLLER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

162335

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

162506

BEARING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

161572

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

162491

RETAINING RING . . . . . . . . . . . . . . . . . . . . . . . 2

7

162490

RETAINING RING . . . . . . . . . . . . . . . . . . . . . . . 2

8

162492

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

160794

TRACK ROLLER ASSEMBLY . . . . . . . . . . . . . . 1

Description

Qty. Req.

SHAFT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

11

908540/AP0300

908540/AP0300

12

PRINTED IN U.S.A.

SECTION B: DOZER BLADE

SECTION B: DOZER BLADE

DOZER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 MODELS 272-292 — DOZER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

PRINTED IN U.S.A.

13

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR DOZER BLADE MODELS 272-292 — DOZER BLADE

ET2720120

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162209

2

160811

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

3

160813

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

160812

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161537

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

161682

PIN/SPLIT 6.3 X 63 ZO D94 . . . . . . . . . . . . . . . 4

7

161411

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 2

8

161416

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

13

160835

DOZER BLADE CYLINDER. . . . . . . . . . . . . . . . 1

Description

Qty. Req.

DOZER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . 1

908540/AP0300

14

PRINTED IN U.S.A.

SECTION C: CHASSIS

SECTION C: CHASSIS

CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 MODELS 272-292 — CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 MODELS 272-292 — CHASSIS COVERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 MODELS 272-292 — CHASSIS LUBRICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 MODELS 272-292 — HOOD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

PRINTED IN U.S.A.

15

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR CHASSIS MODELS 272-292 — CHASSIS

ET2720200

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162188

2

160815

CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 1

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

4

161636

WASHER/NORD-LOCK NL 12 STUCK . . . . . . . 6

23

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . 12

5

160776

6

160759

SWIVEL DRIVE/MOTOR GEAR . . . . . . . . . . . . 1

24

162525

SWING BRACKET . . . . . . . . . . . . . . . . . . . . . . . 1

BOOM OFFSET CYLINDER . . . . . . . . . . . . . . . 1

25

651405

8

CS M12-1.7 X 30 C 10.9 ZO . . . . . . . . . . . . . . . . 2

161528

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

26

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . . 2

9

161570

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

27

651443

HN SLTD M36-4 ZO . . . . . . . . . . . . . . . . . . . . . . 1

10

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 1

28

162345

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

11

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 1

29

161682

PIN/SPLIT 6.3 X 63 ZO D94 . . . . . . . . . . . . . . . . 1

12

162485

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

30

160814

PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162480

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

31

651470

PIN/SPRNG M8 X 80 D1481 . . . . . . . . . . . . . . . 1 CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

LOCKWASHER . . . . . . . . . . . . . . . . . . . . . . . . . 24

14

162202

COUNTERWEIGHT . . . . . . . . . . . . . . . . . . . . . . 1

32

656001

15

162348

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

33

160409

REFLECTOR. . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

651499

SHCS HS M16-1.5 X 60 10.9 ZO D912 . . . . . . . 2

34

161627

RIVET/BLIND A4 X 12 DIN7337 . . . . . . . . . . . . 16

17

651495

SHCS HS M16-1.5 X 40 10.9 ZO D912 . . . . . . . 2

35

160644

REFLECTOR. . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

18

160736

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

36

651451

HLN INS M16-2.0 ZO . . . . . . . . . . . . . . . . . . . . . 4

19

161646

WASHER/GR A 15 DIN125 ZO . . . . . . . . . . . . 24

37

162486

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 1

908540/AP0300

16

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR CHASSIS MODELS 272-292 — CHASSIS COVERS

ET2720205

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

1

162195

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

161948

RUBBER PROTECTOR . . . . . . . . . . . . . . . . . . 3

3

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 9

4

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 9

5

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 9

6

162196

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162476

RUBBER PROTECTOR . . . . . . . . . . . . . . . . . . 1

8

162387

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

161943

PVC-EDGE PROTECTION . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

17

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR CHASSIS MODELS 272-292 — CHASSIS LUBRICATION

ET2720210

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161722

2

651425

CS M6-1.0 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

3

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 2

4

161411

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 2

5

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

6

161461

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

7

161392

LUBRICATION TUBE. . . . . . . . . . . . . . . . . . . . . 1

8

161392

LUBRICATION TUBE. . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

LUBRICATION BLOCK . . . . . . . . . . . . . . . . . . . 1

9

161468

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

10

161469

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

11

161401

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161660

WASHER/GR A 6.4 ZO DIN125. . . . . . . . . . . . . 2

908540/AP0300

18

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR CHASSIS MODELS 272-292 — HOOD

ET2720225

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1

162190

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

162194

2

161805

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

13

160402

HOOD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 LOCK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

651393

CS M10-1.5 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . 2

14

651503

SHCS HS M5-0.8 X 12 8.8 ZO D912 . . . . . . . . . 3

4

161610

NUT/CAGE M10 . . . . . . . . . . . . . . . . . . . . . . . . 2

15

161674

LOCKWASHER S5 . . . . . . . . . . . . . . . . . . . . . . . 3

5

162206

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

160400

LOCK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162205

HINGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

162047

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

7

651396

CS M10-1.5 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . 5

18

161659

WASHER/GR A 5.3 ZO DIN125 . . . . . . . . . . . . . 3

8

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 5

19

160643

KEY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161663

WASHER/GR A 10.5 ZO DIN9021 . . . . . . . . . . 9

20

162476

RUBBER PROTECTOR . . . . . . . . . . . . . . . . . . . 2

10

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . 2

21

162315

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

19

908540/AP0300

908540/AP0300

20

PRINTED IN U.S.A.

SECTION D: TILT FRAME

SECTION D: TILT FRAME

TILT FRAME . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 MODELS 272-292 — TILT FRAME . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 MODELS 272-292 — ISOLATION MATS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 MODELS 272-292 — VALVE COVER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

PRINTED IN U.S.A.

21

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR TILT FRAME MODELS 272-292 — TILT FRAME

ET2720215

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160653

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

651434

HB M8-1.2 X 45 C 8.8 ZO . . . . . . . . . . . . . . . . . . 4

2

651446

SHSS M8 X 12 45H CP . . . . . . . . . . . . . . . . . . . 4

17

161643

WASHER/ROUND HI-TENS DIN6916 . . . . . . . . 4

3

160596

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

18

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . . 2

4

162034

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

19

162046

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 6

20

160612

PNEUMATIC SPRING . . . . . . . . . . . . . . . . . . . . .1

6

161663

WASHER/GR A 10.5 ZO DIN9021. . . . . . . . . . . 2

21

656004

HB M8-1.2 X 55 C 8.8 ZO . . . . . . . . . . . . . . . . . . 1

7

160711

CUSHION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

23

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . . 2

8

651477

SHCS HS M12-1.7 X 110 10.9 ZO D912 . . . . . . 2

24

161945

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161936

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

25

162375

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161875

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

26

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . . 1

11

651395

CS M10-1.5 X 30 C 10.9 ZO . . . . . . . . . . . . . . . 4

27

161946

SPACER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

12

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . 4

28

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 2

13

162200

CAB MOUNT L. . . . . . . . . . . . . . . . . . . . . . . . . . 1

29

651426

CS M6-1.0 X 35 C 8.8 ZO . . . . . . . . . . . . . . . . . . 1

14

162201

CAB MOUNT R . . . . . . . . . . . . . . . . . . . . . . . . . 1

30

651457

HLN INS M6-1.0 8 Z0 . . . . . . . . . . . . . . . . . . . . . 1

15

162026

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

31

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . .2

Description

908540/AP0300

Qty. Req.

Ref. No.

22

Part No.

Description

Qty. Req.

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR TILT FRAME MODELS 272-292 — ISOLATION MATS

ET2720220

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1

162198

TILTABLE FRAME . . . . . . . . . . . . . . . . . . . . . . . 1

14

162314

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

161948

RUBBER PROTECTOR . . . . . . . . . . . . . . . . . . 4

15

162020

RUBBER PROTECTOR . . . . . . . . . . . . . . . . . . . 1

3

161943

PVC-EDGE PROTECTION . . . . . . . . . . . . . . . . 3

16

160842

RUBBER MAT . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162476

RUBBER PROTECTOR . . . . . . . . . . . . . . . . . . 1

17

161879

TOOL BOX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162305

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

18

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

6

162306

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

19

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . . 4

7

162307

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

20

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . . 2

8

162308

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

21

162376

FOOT REST . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162309

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

22

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . . 4

10

162310

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

23

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 4

11

162311

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

24

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

12

162312

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

25

161615

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . . 4

13

162313

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

23

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR TILT FRAME MODELS 272-292 — VALVE COVER

ET2720230

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162193

HOOD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

160402

LOCK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

162301

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

19

651503

SHCS HS M5-0.8 X 12 8.8 ZO D912 . . . . . . . . . 3

3

162302

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

20

161674

LOCKWASHER S5 . . . . . . . . . . . . . . . . . . . . . . . 3

4

162303

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

21

161659

WASHER/GR A 5.3 ZO DIN125 . . . . . . . . . . . . . 3

5

162304

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . 1

22

162203

BAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161948

RUBBER PROTECTOR. . . . . . . . . . . . . . . . . . . 3

23

162072

BALL AND SOCKET . . . . . . . . . . . . . . . . . . . . . .1

7

162189

HINGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . . 1

8

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

25

162389

CLAMP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

9

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 9

26

161611

NUT/CAGE M5 . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161663

WASHER/GR A 10.5 ZO DIN9021. . . . . . . . . . 13

27

162478

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 LOCKWASHER S5 . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

11

656048

HN M8-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . 4

28

161674

12

162353

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

29

161659

WASHER/GR A 5.3 ZO DIN125 . . . . . . . . . . . . . 1

13

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . 5

30

162192

HOSE COVER. . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162352

LOCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

31

161943

PVC-EDGE PROTECTION . . . . . . . . . . . . . . . . . 1

15

162047

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

32

161616

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . . 3

16

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 4

33

160643

KEY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . 4

908540/AP0300

24

PRINTED IN U.S.A.

SECTION E: BOOM

SECTION E: BOOM

BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26 MODELS 272-292 — BOOM. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26 MODELS 272-292 — STICK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

PRINTED IN U.S.A.

25

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR BOOM MODELS 272-292 — BOOM

ET2720300

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

908540/AP0300

26

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR BOOM MODELS 272-292 — BOOM Ref. No.

Part No.

2

162524

BOOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

161410

WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

3

160758

BOOM CYLINDER. . . . . . . . . . . . . . . . . . . . . . . 1

19

651443

HN SLTD M36-4 ZO . . . . . . . . . . . . . . . . . . . . . . 1

5

160734

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

651439

HB M8-1.2 X 80 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

6

160735

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . . 2

7

160732

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

161557

HOSE CLAMP. . . . . . . . . . . . . . . . . . . . . . . . . . 13

9

160727

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

161554

HOSE CLAMP. . . . . . . . . . . . . . . . . . . . . . . . . . . 3

10

160728

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

25

651427

HB M6-1.0 X 35 C 8.8 ZO . . . . . . . . . . . . . . . . . 32

11

160726

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

27

161411

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 1

12

160729

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

28

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 1

13

160730

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

29

162066

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

15

161542

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

33

161682

PIN/SPLIT 6.3 X 63 ZO D94 . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

Ref. No.

27

Part No.

Description

Qty. Req.

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR BOOM MODELS 272-292 — STICK

ET2720305

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

908540/AP0300

28

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR BOOM MODELS 272-292 — STICK Ref. No.

Part No.

Ref. No.

Part No.

1

160719

2

160721

STICK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

651439

HB M8-1.2 X 80 C 8.8 ZO . . . . . . . . . . . . . . . . . . 3

CONNECTING LINK . . . . . . . . . . . . . . . . . . . . . 1

22

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . . 3

3 4

160722

CONNECTING LINK . . . . . . . . . . . . . . . . . . . . . 1

23

161411

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 5

160720

CONNECTING LINK . . . . . . . . . . . . . . . . . . . . . 1

24

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 5

5 6

160756

BUCKET CYLINDER . . . . . . . . . . . . . . . . . . . . . 1

25

161682

PIN/SPLIT 6.3 X 63 ZO D94 . . . . . . . . . . . . . . . . 3

160757

BUCKET STICK CYLINDER . . . . . . . . . . . . . . . 1

26

160972

BALL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

160803

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

27

160862

QUICK COUPLER. . . . . . . . . . . . . . . . . . . . . . . . 1

8

160802

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

28

160725

QUICK COUPLER. . . . . . . . . . . . . . . . . . . . . . . . 2

9

160808

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

29

160724

QUICK COUPLER. . . . . . . . . . . . . . . . . . . . . . . . 1

10

160733

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

30

160458

DUST PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 DUST CAP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

Qty. Req.

Description

Qty. Req.

11

160731

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

31

160459

12

160732

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

33

161471

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

15

161539

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

38

161407

WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

161536

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

39

651442

HN SLTD M30-3.5 ZO . . . . . . . . . . . . . . . . . . . . . 1

162235

STICK ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . 1

17

161533

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

40

18

161686

LOCKWASHER B50 D7993. . . . . . . . . . . . . . . . 6

41

REFER TO FACTORY

19

651443

HN SLTD M36-4 ZO. . . . . . . . . . . . . . . . . . . . . . 2

42

REFER TO FACTORY

20

162489

COTTER PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

43

REFER TO FACTORY

PRINTED IN U.S.A.

29

908540/AP0300

908540/AP0300

30

PRINTED IN U.S.A.

CABIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 MODELS 272-292 — CABIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 MODELS 272-292 — FRAME . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33 MODELS 272-292 — RADIO KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34 MODELS 272-292 — CABLES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 MODELS 272-292 — FRONT WINDSHIELD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36 MODELS 272-292 — LOWER FRONT WINDSHIELD . . . . . . . . . . . . . . . . . . . . . . . . . 38 MODELS 272-292 — UPPER FRONT WINDSHIELD . . . . . . . . . . . . . . . . . . . . . . . . . . 39 MODELS 272-292 — SIDE WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40 MODELS 272-292 — REAR WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41 MODELS 272-292 — CABIN DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42 MODELS 272-292 — LOWER RIGHT SIDE WINDOW. . . . . . . . . . . . . . . . . . . . . . . . . 44 MODELS 272-292 — SLIDING SIDE WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45 MODELS 272-292 — DRIVERS SEAT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46 MODELS 272-292 — CAB HEATING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47

PRINTED IN U.S.A.

31

SECTION F: CABIN

SECTION F: CABIN

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — CABIN

ET2720400

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162475

CABIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

651489

SHCS HS M12-1.7 X 65 10.9 ZO D912 . . . . . . . 4

3

651483

SHCS HS M12-1.7 X 35 10.9 ZO D912 . . . . . . . 4

4

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . 8

5

161664

WASHER/GR A 13 ZO DIN9021 . . . . . . . . . . . . 4

Description

Qty. Req.

6

160716

WINDSHIELD WASHER . . . . . . . . . . . . . . . . . . 1

10

161995

SLIDE TERMINAL . . . . . . . . . . . . . . . . . . . . . . . 2

908540/AP0300

32

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — FRAME

ET2720405

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162221

CABIN FRAME . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

161921

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

161844

GUTTER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

17

161780

STEP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

160526

LOCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

18

161776

LOCK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

160527

LOCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

19

161779

LOCK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

160488

ILLUMINATION . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

162216

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162219

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

162217

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162220

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

161784

SPACER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

162215

ROOF ISOLATION. . . . . . . . . . . . . . . . . . . . . . . 1

23

162029

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 SCREW/C'SUNK HD M5 X 16 DIN966 ZO . . . . . 4

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

9

162477

FIXING STRIP . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

161634

10

161770

LOCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11

25

161843

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

11

161949

RUBBER PROTECTOR (220 cm) . . . . . . . . . . . 1

26

162035

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

161950

RUBBER PROTECTOR . . . . . . . . . . . . . . . . . . 1

27

162036

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

13

161924

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

28

161660

WASHER/GR A 6.4 ZO DIN125 . . . . . . . . . . . . . 2

14

161923

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

29

162037

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

15

161922

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

30

162031

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

33

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — RADIO KIT

ET2720410

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162222

RADIO CONSOLE . . . . . . . . . . . . . . . . . . . . . . . 1

7

162007

RUBBER ANTENNA . . . . . . . . . . . . . . . . . . . . . .1

2 3

162006

RADIO . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

656163

CS M5-0.8 X 10 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

161944

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

161659

WASHER/GR A 5.3 ZO DIN125 . . . . . . . . . . . . . 2

4

162005

SPEAKER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

10

162050

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

161838

HARNESS WIRING . . . . . . . . . . . . . . . . . . . . . . 1

11

162044

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

6

161839

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

13

162223

RADIO KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908540/AP0300

Qty. Req.

34

Description

Qty. Req.

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — CABLES

ET2720415

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162517

2

161841

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

3

162012

PLASTIC HOSE . . . . . . . . . . . . . . . . . . . . . . . . . 4

4

161842

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

5

161847

CONNECTION. . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

160529

WIRING HARNESS KIT. . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

35

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — FRONT WINDSHIELD

ET2720420

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

908540/AP0300

36

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — FRONT WINDSHIELD Ref. No.

Part No.

1

160495

FRONT WINDSHIELD . . . . . . . . . . . . . . . . . . . . 1

11

161941

WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

2

161785

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161951

EDGE PROTECTION . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

3

161786

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161957

WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161938

WIPER MOTOR ASSEMBLY. . . . . . . . . . . . . . . 1

14

656048

HN M8-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

161939

WIPER BLADE HOLDER . . . . . . . . . . . . . . . . . 1

15

162033

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

161940

WIPER BLADE . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . . 4

7

160641

PVC-WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . 2

17

161618

NUT/HEX DOMED CAP M8 . . . . . . . . . . . . . . . . 4

8

160640

RUBBER WASHER . . . . . . . . . . . . . . . . . . . . . . 4

18

651466

SCREW FCHC HS M8-1.2 X 20 8.8 ZO D7991 . 2

9

160639

RUBBER WASHER . . . . . . . . . . . . . . . . . . . . . . 6

20

160497

WINDSHIELD KIT . . . . . . . . . . . . . . . . . . . . . . . . 1

10

160494

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

PRINTED IN U.S.A.

37

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — LOWER FRONT WINDSHIELD

ET2720425

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161772

LOWER FRONT WINDSHIELD . . . . . . . . . . . . . 1

2

161771

NOZZLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161964

SILICON GLUE . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908540/AP0300

Qty. Req.

38

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — UPPER FRONT WINDSHIELD

ET2720430

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160489

UPPER FRONT WINDSHIELD . . . . . . . . . . . . . 1

2

161964

SILICON GLUE . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

39

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — SIDE WINDOW

ET2720435

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160739

SIDE WINDOW . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

161964

SILICON GLUE . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908540/AP0300

Qty. Req.

40

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — REAR WINDOW

ET2720440

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160738

REAR WINDOW . . . . . . . . . . . . . . . . . . . . . . . . 1

2

161964

SILICON GLUE . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

41

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — CABIN DOOR

ET2720445

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

908540/AP0300

42

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — CABIN DOOR Ref. No.

Part No.

1

161777

DOOR FRAME. . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

160491

DOOR LOCK COVER/RT . . . . . . . . . . . . . . . . . . 1

3

161778

DOOR WINDOW . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161779

LOCK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161396

RUBBER PROTECTOR . . . . . . . . . . . . . . . . . . 4

15

161925

SQUARE NUT. . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162018

RUBBER PROTECTOR . . . . . . . . . . . . . . . . . . 4

16

656092

CS M6-1.0 X 12 C 8.8 ZO . . . . . . . . . . . . . . . . . . 1

7

160492

DOOR HANDLE. . . . . . . . . . . . . . . . . . . . . . . . . 1

17

162045

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

8

161788

KEY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

18

162042

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

161942

DOOR HANDLE KIT . . . . . . . . . . . . . . . . . . . . . 1

19

162031

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

160490

TRAP LOCK/RT . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

160493

CABIN DOOR ASSEMBLY . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

Ref. No.

43

Part No.

Description

Qty. Req.

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — LOWER RIGHT SIDE WINDOW

ET2720450

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160740

LOWER RIGHT SIDE WINDOW . . . . . . . . . . . . 1

2

161396

RUBBER PROTECTOR. . . . . . . . . . . . . . . . . . . 1

Description

908540/AP0300

Qty. Req.

44

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — SLIDING SIDE WINDOW

ET2720455

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162224

WINDOW, LOWER GLASS . . . . . . . . . . . . . . . . 1

2

160742

WINDOW, FRONT SLIDING GLASS. . . . . . . . . 1

3

160741

WINDOW, REAR GLASS . . . . . . . . . . . . . . . . . 1

4

160642

LOCK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162225

SLIDING WINDOW ASSEMBLY . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

45

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — DRIVERS SEAT

ET2720460

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

656048

2

162218

HN M8-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . . . . 8

17

161403

BALL KNOB. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

DRIVER SEAT . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

161640

3

656001

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . . 1

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

19

651448

HLN INS M10-1.5 ZO . . . . . . . . . . . . . . . . . . . . . 1

4 5

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . 20

20

161947

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 6

21

162214

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

6

161615

NUT/CAGE M8. . . . . . . . . . . . . . . . . . . . . . . . . . 4

22

161834

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

7

160407

CONSOLE/CONTROL LEVERS . . . . . . . . . . . . 1

23

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . .2

8

160408

CONSOLE/CONTROL LEVERS . . . . . . . . . . . . 1

24

162048

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

9

161730

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

25

651460

FCHC HS M5-0.8 X 16 8.8 ZO D7991 . . . . . . . 16

10

651517

SHCS HS M8-1.2 X 30 8.8 ZO D912 . . . . . . . . . 8

27

162210

PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161831

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

28

162211

PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

12

160611

PNEUMATIC SPRING . . . . . . . . . . . . . . . . . . . . 1

29

162212

13

161848

QUICK FIX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

30

162213

PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

651390

HB M10-1.5 X 120 C 8.8 ZO . . . . . . . . . . . . . . . 1

31

160533

ARMREST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161651

WASHER 20 . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

32

160532

ARMREST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

161868

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

33

161728

SEAT BELT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908540/AP0300

46

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR CABIN MODELS 272-292 — CAB HEATING

ET2720465

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160406

2

162516

Ref. No.

Part No.

CAB HEATER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161424

WASHER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

TURNABLE AIR OUTLET . . . . . . . . . . . . . . . . . 2

18

161429

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 BALL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

3

161660

WASHER/GR A 6.4 ZO DIN125 . . . . . . . . . . . . 3

19

160950

12

161389

HOSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

20

161477

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161389

HOSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

21

161445

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162064

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . . . . 4

22

161436

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

160860

HOSE COVER . . . . . . . . . . . . . . . . . . . . . . . . . . 2

28

161476

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

161423

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

47

908540/AP0300

908540/AP0300

48

PRINTED IN U.S.A.

DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 MODELS 272-292 — DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 MODELS 272-292 — ENGINE SUSPENSION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51 MODELS 272-292 — COOLING WATER RADIATOR . . . . . . . . . . . . . . . . . . . . . . . . . 52 MODELS 272-292 — AIR INTAKE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53 MODELS 272-292 — EXHAUST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54 MODELS 272-292 — FUEL LINE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55 MODELS 272-292 — ACCELERATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56 MODELS 272-292 — DIESEL TANK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57

PRINTED IN U.S.A.

49

SECTION G: DIESEL ENGINE

SECTION G: DIESEL ENGINE

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR DIESEL ENGINE MODELS 272-292 — DIESEL ENGINE

ET2720500

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160754

2

425-36086

DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . 1

14

425-35492

VENTILATOR . . . . . . . . . . . . . . . . . . . . . . . 1

15

425-35506

3

425-34688

WATER PUMP . . . . . . . . . . . . . . . . . . . . . . . 1

BELT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

425-34703

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4 5

425-34635

OIL FILTER . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

425-34661

THERMO SWITCH . . . . . . . . . . . . . . . . . . . . 1

425-36085

OIL PRESSURE SWITCH . . . . . . . . . . . . . . 1

18

425-34704

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6 7

425-34683

THERMO SWITCH . . . . . . . . . . . . . . . . . . . 1

19

425-34715

FUEL INJECTOR . . . . . . . . . . . . . . . . . . . . . 3

160427

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

425-34713

FUEL PUMP . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

425-35925

STOP SOLENOID . . . . . . . . . . . . . . . . . . . . 1

21

425-34636

FUEL FILTER . . . . . . . . . . . . . . . . . . . . . . . . 1

9

425-34753

OIL PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

160752

STARTER . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

160753

CYLINDER HEAD SEAL . . . . . . . . . . . . . . . 1

23

162391

GENERATOR . . . . . . . . . . . . . . . . . . . . . . . . 1

11

160750

VALVE COVER SEAL . . . . . . . . . . . . . . . . . 1

24

160747

INJECTION PUMP . . . . . . . . . . . . . . . . . . . . 1

12

160751

OIL PAN. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

25

162231

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161737

SEALANT . . . . . . . . . . . . . . . . . . . . . . . . . . 1

26

162234

BELT TENSION ADJUSTMENT . . . . . . . . . . 1

908540/AP0300

Description

Qty. Req.

50

Description

Qty. Req.

PREHEATER . . . . . . . . . . . . . . . . . . . . . . . . 3

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR DIESEL ENGINE MODELS 272-292 — ENGINE SUSPENSION

ET2720505

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162394

ENGINE CARRIER . . . . . . . . . . . . . . . . . . . . . . 1

9

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 7

2

162392

ENGINE CARRIER . . . . . . . . . . . . . . . . . . . . . . 1

10

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 8

3

162395

ENGINE CARRIER . . . . . . . . . . . . . . . . . . . . . . 1

11

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 7

4

162393

ENGINE CARRIER . . . . . . . . . . . . . . . . . . . . . . 1

12

651395

CS M10-1.5 X 30 C 10.9 ZO . . . . . . . . . . . . . . . . 4

5

651393

CS M10-1.5 X 25 C 8.8 ZO . . . . . . . . . . . . . . . 16

13

161641

WASHER/GR 10.5 ZO . . . . . . . . . . . . . . . . . . . . 4

6

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . 20

14

656094

CS M8-1.2 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . . . 1

7

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . 16

15

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . . 1

8

160645

HYDRO SUSPENSION . . . . . . . . . . . . . . . . . . . 4

16

162008

CABLE, GROUND. . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

Ref. No.

51

Part No.

Description

Qty. Req.

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR DIESEL ENGINE MODELS 272-292 — COOLING WATER RADIATOR

ET2720510

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162381

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

161666

WASHER/GR A 6.4 ZO DIN9021 . . . . . . . . . 3

2

162382

RADIATOR BRACKET . . . . . . . . . . . . . . . . 1

19

161943

PVC-EDGE PROTECTION. . . . . . . . . . . . . . 1

3

162482

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

161948

RUBBER PROTECTOR . . . . . . . . . . . . . . . . 2

4

161643

WASHER/ROUND HI-TENS DIN6916 . . . . 4

21

425-36167

EXPANSION CONTAINER . . . . . . . . . . . . . . 1

5

651449

HLN INS M12-1.7 ZO . . . . . . . . . . . . . . . . . 2

22

161856

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 1

6

162204

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

162357

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 2

7

162191

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24 25

425-36092

PROTECTION GRID . . . . . . . . . . . . . . . . . . 1

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . 12

Description

Qty. Req.

Ref. No.

8 10

425-36093

WATER COOLER . . . . . . . . . . . . . . . . . . . . 1

26

Part No.

Description

Qty. Req.

HOSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

160746

RADIATOR CAP . . . . . . . . . . . . . . . . . . . . . 1

27

651458

HLN INS M8-1.2 8 ZO. . . . . . . . . . . . . . . . . . 6

12

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . 10

30

425-34687

COOLING WATER HOSE. . . . . . . . . . . . . . . 1

13

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . 4

31

425-34686

COOLING WATER HOSE. . . . . . . . . . . . . . . 1

14

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . 4

32

425-34853

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 4

15

161614

NUT/CAGE M6 . . . . . . . . . . . . . . . . . . . . . . 3

33

162501

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 2

34

161390

HOSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

656149

CS M6-1.0 X 16 C 8.8 ZO . . . . . . . . . . . . . . 3

17

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . 3

908540/AP0300

52

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR DIESEL ENGINE MODELS 272-292 — AIR INTAKE

ET2720515

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1

425-36168

HOUSING CLAMP . . . . . . . . . . . . . . . . . . . 1

11

162385

2

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . 4

12

425-36098

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 DUST INDICATOR . . . . . . . . . . . . . . . . . . . . 1

3

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . 4

13

425-36099

AIR INTAKE HOSE . . . . . . . . . . . . . . . . . . . . 1

4

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . 4

14

425-36100

AIR INTAKE HOSE . . . . . . . . . . . . . . . . . . . . 1

5

651457

HLN INS M6-1.0 8 Z0 . . . . . . . . . . . . . . . . . 1

15

425-36101

MUFFLER . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

160849

HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

425-36159

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 4

7

160851

DUST CAP . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161660

WASHER/GR A 6.4 ZO DIN125 . . . . . . . . . . 1

8

425-36094

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 1

18

162229

SUCTION HOSE . . . . . . . . . . . . . . . . . . . . . 1

9

425-36095

AIR FILTER . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

162230

HOSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

425-36097

AIR FILTER . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

53

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR DIESEL ENGINE MODELS 272-292 — EXHAUST

ET2720520

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

425-36105

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . 10

2

425-36106

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

160749

EXHAUST MANIFOLD . . . . . . . . . . . . . . . . . 1

4

162358

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 2

11

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . 4

5

160859

MUFFLER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

425-34652

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

425-36103

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 2

13

656048

HN M8-1.2 ZO. . . . . . . . . . . . . . . . . . . . . . . . 4

7

656094

CS M8-1.2 X 30 C 8.8 ZO . . . . . . . . . . . . . . 2

14

160745

TUBE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . 10

15

160848

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 1

908540/AP0300

Description

Qty. Req.

Ref. No.

54

Part No.

Description

Qty. Req.

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR DIESEL ENGINE MODELS 272-292 — FUEL LINE

ET2720525

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1

162228

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . 1

2

651391

CS M10-1.5 X 20 C 8.8 ZO . . . . . . . . . . . . 4

10

160844

HOSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . 4

11

160844

HOSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . 4

12

161391

HOSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162233

HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162504

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . 4

6

425-34636

FUEL FILTER . . . . . . . . . . . . . . . . . . . . . . . 1

14

425-36091

FUEL FILTER . . . . . . . . . . . . . . . . . . . . . . . . 1

7

651438

HB M8-1.2 X 70 C 8.8 ZO . . . . . . . . . . . . . . 1

15

425-35973

FUEL FILTER ASSEMBLY . . . . . . . . . . . . . . 1

8

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

55

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR DIESEL ENGINE MODELS 272-292 — ACCELERATOR

ET2720530

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160755

2

162207

THROTTLE CONTROL LEVER. . . . . . . . . . . . . 1

11

160657

SPRING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

162398

HANDLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

162355

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162349

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

5

162351

BRAKE DISC . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

162487

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

162350

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162505

BALL AND SOCKET . . . . . . . . . . . . . . . . . . . . . .1

7

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 2

17

161660

WASHER/GR A 6.4 ZO DIN125 . . . . . . . . . . . . . 1

8

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 2

18

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . . 1

9

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

19

651457

HLN INS M6-1.0 8 Z0 . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

CABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908540/AP0300

56

Ref. No.

Part No.

10

161733

Description

Qty. Req.

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR DIESEL ENGINE MODELS 272-292 — DIESEL TANK

ET2720535

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160818

GAS-OIL STORAGE TANK . . . . . . . . . . . . . . . . 1

8

161659

WASHER/GR A 5.3 ZO DIN125 . . . . . . . . . . . . . 6

2

160436

STRAINER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

162347

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

3

160401

TANK COVER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

651402

CS M10-1.5 X 50 C 8.8 ZO . . . . . . . . . . . . . . . . . 3

4

161867

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . . 3

5

160403

KEY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161663

WASHER/GR A 10.5 ZO DIN9021 . . . . . . . . . . . 3

6

160536

TRANSMITTER . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162379

ISOLATION MAT . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162040

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Description

PRINTED IN U.S.A.

Qty. Req.

Ref. No.

57

Part No.

Description

Qty. Req.

908540/AP0300

908540/AP0300

58

PRINTED IN U.S.A.

HYDRAULIC SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60 MODELS 272-292 — HYDRAULIC PUMP ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . 60 MODELS 272-292 — HYDRAULIC OIL TANK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61 MODELS 272-292 — HYDRAULIC PUMP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62 MODELS 272-292 — HYDRAULIC OIL COOLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63 MODELS 272-292 — HYDRAULIC MOTOR 1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64 MODELS 272-292 — HYDRAULIC MOTOR 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65 MODELS 272-292 — TRAVEL MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66 MODELS 272-292 — TRAVELING MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67 MODELS 272-292 — CONTROL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68 MODELS 272-292 — CONTROL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69 MODELS 272-292 — PILOT OIL SUPPLY UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70 MODEL 272 — SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71 MODEL 292 — SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72 MODELS 272-292 — TURNING MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73 MODELS 272-292 — TURNING MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74 MODELS 272-292 — TURNING MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75 MODELS 272-292 — VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76 MODELS 272-292 — SELECTION VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77 MODELS 272-292 — TRAVELING CHECK VALVE HYDRAULICS . . . . . . . . . . . . . 78 MODELS 272-292 — ADDITIONAL CHECK VALVE HYDRAULICS . . . . . . . . . . . . 79 MODELS 272-292 — HAND LEVERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80 MODEL 272 —DOZER BLADE VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81 MODEL 292 —DOZER BLADE VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82 MODELS 272-292 — DOZER BLADE CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83 MODELS 272-292 — BOOM OFFSET CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84 MODELS 272-292 — BOOM CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85 MODELS 272-292 — STICK CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86 MODELS 272-292 — BUCKET CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87 MODEL 292 — TILT CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88 MODELS 272-292 — HYDRAULIC PUMP INSTALLATION . . . . . . . . . . . . . . . . . . . . 89 MODELS 272-292 — HYDRAULIC OIL COOLER INSTALLATION . . . . . . . . . . . . . 90 MODELS 272-292 — PILOT VALVE INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . 91 MODELS 272-292 — HAND LEVER INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . 92 MODELS 272-292 — PILOT OIL SUPPLY UNIT INSTALLATION . . . . . . . . . . . . . . . 93 MODEL 272 — TRAVELING GEAR INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . 94 MODEL 292 — TRAVELING GEAR INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . 95 MODELS 272-292 — TURNING MOTOR INSTALLATION . . . . . . . . . . . . . . . . . . . . . 96 MODELS 272-292 — BOOM OFFSET CYLINDER INSTALLATION . . . . . . . . . . . . . 97 MODELS 272-292 — TILT CYLINDER INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . 98 MODEL 272 — DOZER BLADE INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99 MODEL 292 — DOZER BLADE INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . 100 MODELS 272-292 — BOOM INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101 MODELS 272-292 — ADDITIONAL HYDRAULIC INSTALLATION . . . . . . . . . . . . 102

PRINTED IN U.S.A.

59

SECTION H: HYDRAULIC SYSTEM

SECTION H: HYDRAULIC SYSTEM

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — HYDRAULIC PUMP ASSEMBLY

ET2720540

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160863

COUPLING . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

161954

PUMP BRACKET . . . . . . . . . . . . . . . . . . . . . . . . 1

5

651396

CS M10-1.5 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . 6

6

651393

CS M10-1.5 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . 2

7

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 8

8

161640

WASHER/GR A 10.5 ZO . . . . . . . . . . . . . . . . . . 8

9

651480

SHCS HS M12-1.7 X 30 10.9 ZO D912 . . . . . . . 2

10

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . 2

11

Description

Qty. Req.

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

908540/AP0300

60

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — HYDRAULIC OIL TANK

ET2720600

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162208

2

161414

HYDRAULIC OIL TANK . . . . . . . . . . . . . . . . . . . 1

22

656102

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

23

161429

3

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

160706

HYDRAULIC OIL FILTER ASSEMBLY . . . . . . . 1

24

162062

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

160707

HYDRAULIC OIL FILTER ELEMENT . . . . . . . . 1

25

162197

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

160816

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

26

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

6

161573

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

27

161615

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . 10

30

161503

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . 12

31

161456

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

Description

Qty. Req.

HN M10-1.2 ZO . . . . . . . . . . . . . . . . . . . . . . . . . 3

9

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . 12

32

161492

REDUCER BUSHING . . . . . . . . . . . . . . . . . . . . . 1

10

161485

REDUCER BUSHING . . . . . . . . . . . . . . . . . . . . 2

33

162500

NON RETURN VALVE . . . . . . . . . . . . . . . . . . . . 1

11

161568

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

34

161500

COMPRESSION NUT . . . . . . . . . . . . . . . . . . . . . 1

12

160949

AIR FILTER . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

35

162493

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162494

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

36

160709

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

160439

OIL LEVEL GLASS . . . . . . . . . . . . . . . . . . . . . . 1

37

160708

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

162495

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

38

161492

REDUCER BUSHING . . . . . . . . . . . . . . . . . . . . . 1

16

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

39

160972

BALL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161415

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

40

161498

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

651396

CS M10-1.5 X 30 C 8.8 ZO . . . . . . . . . . . . . . . . 2

41

161397

OIL STRAINER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

651402

CS M10-1.5 X 50 C 8.8 ZO . . . . . . . . . . . . . . . . 3

42

656163

CS M5-0.8 X 10 C 8.8 ZO . . . . . . . . . . . . . . . . . . 6

20

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 5

43

161665

WASHER/GR A 5.3 ZO DIN9021 . . . . . . . . . . . . 6

21

161663

WASHER/GR A 10.5 ZO DIN9021 . . . . . . . . . . 8

PRINTED IN U.S.A.

61

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — HYDRAULIC PUMP

ET2720605

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160778

HYDRAULIC PUMP ASSEMBLY . . . . . . . . . . . . 1

9

161669

2

161585

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

10

162237

HYDRAULIC PUMP . . . . . . . . . . . . . . . . . . . . . . 1

3

161431

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

11

162316

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161471

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

12

162238

HYDRAULIC PUMP . . . . . . . . . . . . . . . . . . . . . . 1

5

161493

REDUCTION JOINT . . . . . . . . . . . . . . . . . . . . . 3

13

160878

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162359

FLANGE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161450

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

7

161565

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161514

MEASURE JOINT . . . . . . . . . . . . . . . . . . . . . . . . 3

8

651475

SHCS HS M10-1.2 X 30 8.8 ZO D912 . . . . . . . . 4

Description

908540/AP0300

Qty. Req.

Ref. No.

62

Part No.

Description

Qty. Req.

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . . 4

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — HYDRAULIC OIL COOLER

ET2720610

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

1

160864

2

656001

HYDRAULIC OIL COOLER . . . . . . . . . . . . . . . . 1 CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

3

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 4

4

161667

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

5

161464

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

63

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — HYDRAULIC MOTOR 1

ET2720611

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162130

HYDRAULIC MOTOR . . . . . . . . . . . . . . . . . . . . 1

17

162146

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2 3

162131

ORIFICE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

162147

SPRING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

162132

HUB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

162148

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162133

BALL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

162149

RETAINING RING . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162134

SPRING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

21

162150

BRAKE DISC. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162135

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

22

162151

BACKUP RING . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162136

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

162152

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

8

162137

SEAL RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

162153

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

9

162138

BEARING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

25

162154

BACKUP RING . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

162139

SHAFT MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . 1

26

162155

PIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

11

162140

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

27

162156

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

Qty. Req.

Description

Qty. Req.

12

162141

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

28

162157

VALVE PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162142

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

29

162158

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

14

162143

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

30

162159

SPRING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

15

162144

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

31

162160

BEARING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162145

CYLINDER BLOCK . . . . . . . . . . . . . . . . . . . . . . 1

32

162161

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

908540/AP0300

64

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — HYDRAULIC MOTOR 2

ET2720612

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162162

2

162163

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

13

162174

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

162175

3

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

162164

SPRING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

15

162176

PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162165

SPRING SEAT . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

162177

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

162166

SPOOL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

162178

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

6

162167

ORIFICE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

18

162179

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

162168

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

162180

VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

162169

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

162181

HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162170

SPRING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

162182

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

10

162171

SPOOL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

162183

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

162172

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

23

162184

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

162173

ORIFICE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

24

162185

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

PRINTED IN U.S.A.

Qty. Req.

65

Description

Qty. Req.

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — TRAVEL MOTOR

ET2720613

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162529

2

162530

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

162537

GEAR KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

11

162538

HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3 4

162264

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

162539

RETAINING RING . . . . . . . . . . . . . . . . . . . . . . . . 1

162531

COVER SET . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162125

BEARING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5 6

162532

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162126

RETAINING RING . . . . . . . . . . . . . . . . . . . . . . . . 1

162533

PAD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

162127

SPACER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

7 8

162534

SUN GEAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162128

LIFETIME SEAL . . . . . . . . . . . . . . . . . . . . . . . . . 1

162535

PLANETARY KIT . . . . . . . . . . . . . . . . . . . . . . . . 1

17

162129

9

CENTERING RING . . . . . . . . . . . . . . . . . . . . . . .1

162536

RETAINING RING . . . . . . . . . . . . . . . . . . . . . . . 4

18

162130

HYDRAULIC MOTOR . . . . . . . . . . . . . . . . . . . . .1

Description

908540/AP0300

Qty. Req.

66

Description

Qty. Req.

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — TRAVELING MOTOR

ET2720614

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160723

TRAVEL MOTOR . . . . . . . . . . . . . . . . . . . . . . . . 1

2

161508

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

3

161501

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

Qty. Req.

4

162497

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

162130

HYDRAULIC MOTOR . . . . . . . . . . . . . . . . . . . . 1

6

162186

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162187

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161585

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

9

161590

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

67

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — CONTROL VALVE

ET2720615

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160841

CONTROL VALVE . . . . . . . . . . . . . . . . . . . . . . . 1

12

161509

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

2 3

651473

SHCS HS M10-1.2 X 25 8.8 ZO D912 . . . . . . . . 3

13

162386

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161669

LOCKWASHER S10 . . . . . . . . . . . . . . . . . . . . . 3

14

162499

REDUCTION JOINT . . . . . . . . . . . . . . . . . . . . . . 6

4

160887

CORK WASHER . . . . . . . . . . . . . . . . . . . . . . . . 3

15

161508

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

6

161501

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

16

161498

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

161443

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

17

162497

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

161496

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

161585

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

19

161456

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

10

162498

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

161451

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161590

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

Description

908540/AP0300

Qty. Req.

68

Description

Qty. Req.

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — CONTROL VALVE

ET2720620

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161031

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162372

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

162365

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

162373

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

162366

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

162364

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162367

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161045

SECTION IN . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162368

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162363

SCREW MOUNT. . . . . . . . . . . . . . . . . . . . . . . . . 3

6

162369

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161360

PRESSURE RELIEF VALVE, SECONDARY . . . 7

7

162370

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161359

PRESSURE RELIEF VALVE, PRIMARY. . . . . . . 2

8

162371

SECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162362

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

Ref. No.

69

Part No.

Description

Qty. Req.

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — PILOT OIL SUPPLY UNIT

ET2720625

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160572

2

162519

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

162518

HALF COVERS . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRESSURE RELIEF VALVE KIT . . . . . . . . . . . . 1

11

160594

PILOT OIL SUPPLY UNIT . . . . . . . . . . . . . . . . . . 1

3

162520

5

162521

CONNECTION KIT . . . . . . . . . . . . . . . . . . . . . . 1

12

161567

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

SHUTTLE VALVE KIT . . . . . . . . . . . . . . . . . . . . 1

13

160437

6

162521

ACCUMULATOR . . . . . . . . . . . . . . . . . . . . . . . . . 1

SHUTTLE VALVE KIT . . . . . . . . . . . . . . . . . . . . 1

14

161426

7

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

162471

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

15

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 2

8

160571

SOLENOID SWITCH . . . . . . . . . . . . . . . . . . . . . 1

16

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 2

9

160571

SOLENOID SWITCH . . . . . . . . . . . . . . . . . . . . . 1

17

656105

CS M8-1.2 X 25 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

Description

908540/AP0300

Qty. Req.

70

Description

Qty. Req.

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 272 — SWIVEL JOINT

ET2720630

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162526

2

161463

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

3

161446

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

4

161427

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

5

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

161429

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161450

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162528

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

71

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 292 — SWIVEL JOINT

ET2720635

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162322

SWIVEL JOINT . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

161463

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

3

161428

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

161431

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

5

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

6

161429

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

161444

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

8

161446

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162324

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908540/AP0300

Qty. Req.

72

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — TURNING MOTOR

ET2720636

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

161426

2

161590

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

161445

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

8

161429

3

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

161509

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162423

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

4

161446

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

10

161425

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161467

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161418

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161496

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

161423

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

73

Description

Qty. Req.

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — TURNING MOTOR

ET2720637

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162259

PINION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

162269

2 3

162260

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

162270

O-RING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2

162261

NILOS RING . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162271

GEAR RIM. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162262

BEARING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162272

GEAR UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162263

GEARBOX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

162273

PLANETARY GEAR UNIT . . . . . . . . . . . . . . . . . . 1

6

162264

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162274

SUN GEAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162265

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

162275

FLANGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

8

162266

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

162276

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

9

162267

BEARING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

162277

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

10

162268

NUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

162278

HYDRAULIC MOTOR . . . . . . . . . . . . . . . . . . . . .1

Description

908540/AP0300

Qty. Req.

74

Description

Qty. Req.

DRIVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — TURNING MOTOR

ET2720640

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

2

162279

MOTOR HOUSING KIT . . . . . . . . . . . . . . . . . . . 1

7

162286

MOTOR SHAFT ASSEMBLY. . . . . . . . . . . . . . . 1

Description

Qty. Req.

29

162281

BASE PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

35

162283

RELIEF VALVE ASSEMBLY . . . . . . . . . . . . . . . 1

50

162280

BASE PLATE ASSEMBLY . . . . . . . . . . . . . . . . . 1

51

162282

PLUG ASSEMBLY KIT . . . . . . . . . . . . . . . . . . . 1

52

162284

VALVE KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

53

162285

CYLINDER BLOCK ASSEMBLY . . . . . . . . . . . . 1

54

162287

BEARING ASSEMBLY. . . . . . . . . . . . . . . . . . . . 1

55

162288

BRAKE ASSEMBLY. . . . . . . . . . . . . . . . . . . . . . 1

56

162289

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

57

162290

VALVE KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

75

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — VALVE

ET2720645

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160764

2

651426

CONTROL VALVE . . . . . . . . . . . . . . . . . . . . . . . 1

8

161474

CS M6-1.0 X 35 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

9

161448

3

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 2

10

162247

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161666

WASHER/GR A 6.4 ZO DIN9021. . . . . . . . . . . . 2

11

162239

HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

12

162240

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

6

162496

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

162248

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

161443

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Description

908540/AP0300

Qty. Req.

76

Description

Qty. Req.

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — SELECTION VALVE

ET2720655

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162241

2

162242

STOP SOLENOID . . . . . . . . . . . . . . . . . . . . . . . 1

8

160763

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

161427

3

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

162243

STOP SOLENOID . . . . . . . . . . . . . . . . . . . . . . . 1

10

161450

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

4

162244

PIPE SUPPORT . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162245

MAGNETIC REEL . . . . . . . . . . . . . . . . . . . . . . . 1

12

161443

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

6

162246

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

651428

CS M6-1.0 X 50 C 8.8 ZO . . . . . . . . . . . . . . . . . . 2

...................................... 1

14

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . . 2

7

Description

PRINTED IN U.S.A.

Qty. Req.

77

Description

Qty. Req.

SELECTION VALVE . . . . . . . . . . . . . . . . . . . . . . 1

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — TRAVELING CHECK VALVE HYDRAULICS

ET2720660

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162374

BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

160931

HAND LEVER, TRAVELING . . . . . . . . . . . . . . . . 1

2 3

162448

RUBBER BUSHING. . . . . . . . . . . . . . . . . . . . . . 1

13

160930

HAND LEVER, TRAVELING . . . . . . . . . . . . . . . . 1

161615

NUT/CAGE M8. . . . . . . . . . . . . . . . . . . . . . . . . . 4

14

161764

KNOB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

4

656093

CS M8-1.2 X 16 C 8.8 ZO . . . . . . . . . . . . . . . . 12

15

160658

KNOB WITH RED SWITCH . . . . . . . . . . . . . . . . 1

5

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . 12

16

162027

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

6

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . 12

17

656017

CS M12-1.7 X 35 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

7

160912

CONTROL LEVER . . . . . . . . . . . . . . . . . . . . . . . 2

18

161670

LOCKWASHER S12 . . . . . . . . . . . . . . . . . . . . . . 2

8

161439

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

19

161642

WASHER/GR A 13 ZO . . . . . . . . . . . . . . . . . . . . 2

9

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

20

160918

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161450

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

21

160947

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Description

908540/AP0300

Qty. Req.

78

Description

Qty. Req.

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — ADDITIONAL CHECK VALVE HYDRAULICS

ET2720665

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1

161154

CONTROL LEVER. . . . . . . . . . . . . . . . . . . . . . . 1

9

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

10

161514

MEASURE JOINT . . . . . . . . . . . . . . . . . . . . . . . . 1

3

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 4

11

160918

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

12

160947

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161615

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . 4

15

162377

FOOTREST. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

651513

SHCS HS M8-1.2 X120 8.8 ZO D912 . . . . . . . . . 1

7

161439

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

17

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 2

8

161450

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

79

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — HAND LEVERS

ET2720670

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160762

CONTROL LEVER . . . . . . . . . . . . . . . . . . . . . . . 1

2

160761

CONTROL LEVER . . . . . . . . . . . . . . . . . . . . . . . 1

3

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

4

651507

SHCS HS M6-1 X 20 8.8 ZO D912 . . . . . . . . . . 8

5

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 8

6

161660

WASHER/GR A 6.4 ZO DIN125. . . . . . . . . . . . . 8

8

160486

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 JOYSTICK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

9

160463

10

160469

HANDLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

160470

BELLOWS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908540/AP0300

80

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 272 —DOZER BLADE VALVE

ET2720675

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162292

PRESSURE LIMITING VALVE. . . . . . . . . . . . . . 1

16

162398

2 3

162293

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

17

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 5

162294

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 5

Description

Qty. Req.

Description

Qty. Req.

HANDLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162295

VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

162378

VALVE COVER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162296

KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

6

162297

KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

161615

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . . 4

7

162298

HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

161429

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

162299

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

161463

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

9

160777

DOZER BLADE VALVE . . . . . . . . . . . . . . . . . . . 1

24

161427

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

10

162300

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

25

161446

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

651428

CS M6-1.0 X 50 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

26

161566

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 2

27

161357

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

13

161660

WASHER/GR A 6.4 ZO DIN125 . . . . . . . . . . . . 2

28

160651

THROTTLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

29

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

651466

SCREW FCHC HS M8-1.2 X 20 8.8 ZO D7991 . 2

15

162354

DOZER BLADE LEVER. . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

81

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 292 —DOZER BLADE VALVE

ET2720680

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162292

PRESSURE LIMITING VALVE. . . . . . . . . . . . . . 1

17

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . . 6

2

162293

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

18

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 6

3

162294

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

162380

VALVE COVER . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162295

VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 4

5

162296

KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

21

161615

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . . 4

6

162297

KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

22

161429

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162298

HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

161463

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

8

162326

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

161427

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

9

160793

DOZER BLADE VALVE . . . . . . . . . . . . . . . . . . . 1

25

161446

ELBOW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

10

162300

PLATE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

26

161566

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

651428

CS M6-1.0 X 50 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

27

161357

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

12

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 2

28

160651

THROTTLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161660

WASHER/GR A 6.4 ZO DIN125. . . . . . . . . . . . . 2

29

162325

LEVER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

651466

SCREW FCHC HS M8-1.2 X 20 8.8 ZO D7991. 2

30

161903

HANDLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

15

162354

DOZER BLADE LEVER . . . . . . . . . . . . . . . . . . . 1

31

161448

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

16

162398

HANDLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908540/AP0300

82

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — DOZER BLADE CYLINDER

ET2720700

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160835

Description

Qty. Req.

DOZER BLADE CYLINDER . . . . . . . . . . . . . . . 1

Ref. No.

Part No.

10

161566

Description

Qty. Req.

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

162361

CYLINDER HOUSING . . . . . . . . . . . . . . . . . . . . 1

11

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 2

3

160839

PISTON ROD. . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161416

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

4

160838

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161357

CONNECTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

160837

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

160866

TUBE BURST COVER . . . . . . . . . . . . . . . . . . . . 2

6

162481

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161429

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

160843

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

162360

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161538

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

19

162041

SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

83

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — BOOM OFFSET CYLINDER

ET2720705

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

1

160759

2

162249

BOOM OFFSET CYLINDER . . . . . . . . . . . . . . . 1 CYLINDER HOUSING . . . . . . . . . . . . . . . . . . . . 1

3

160775

PISTON ROD . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

160770

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162250

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162251

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

160768

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

162481

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

160782

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

20

161538

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

21

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . 1

22

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 1

23

161427

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

908540/AP0300

84

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — BOOM CYLINDER

ET2720710

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160758

Ref. No.

Part No.

BOOM CYLINDER. . . . . . . . . . . . . . . . . . . . . . . 1

11

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 2 PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

Description

Qty. Req.

Description

Qty. Req.

2

162254

CYLINDER HOUSING . . . . . . . . . . . . . . . . . . . . 1

12

161422

3

160774

PISTON ROD. . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161463

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

160771

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162397

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162252

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

651514

SHCS HS M8-1.2 X 16 8.8 ZO D912 . . . . . . . . . 2

6

162253

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . . 2

7

160767

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

17

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 2

8

162481

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

18

162236

SHIELD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

160783

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

19

161650

WASHER/GR A 19 ZO DIN125. . . . . . . . . . . . . . 2

10

161537

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

651468

PIN/SPRING M8 X 70 D1481 . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

85

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — STICK CYLINDER

ET2720715

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160757

2

162256

BUCKET STICK CYLINDER . . . . . . . . . . . . . . . 1

8

162481

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

CYLINDER HOUSING . . . . . . . . . . . . . . . . . . . . 1

9

160782

SEAL KIT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3 4

160773

PISTON ROD . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161537

BUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

160770

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 2

5 6

162257

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161422

PROTECTION CAP. . . . . . . . . . . . . . . . . . . . . . .2

162255

BUSHING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161463

7

FITTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

160766

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908540/AP0300

Qty. Req.

86

Description

Qty. Req.

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — BUCKET CYLINDER

ET2720720

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

160756

2

162258

BUCKET CYLINDER . . . . . . . . . . . . . . . . . . . . . 1

10

161537

BUSHING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

CYLINDER HOUSING . . . . . . . . . . . . . . . . . . . . 1

11

161412

LUBRICATION FITTING . . . . . . . . . . . . . . . . . . . 2

3

160772

PISTON ROD. . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161422

PROTECTION CAP . . . . . . . . . . . . . . . . . . . . . . 2

4 5

160769

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161463

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

160765

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

162495

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162481

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

160972

BALL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

160781

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

161401

SET SCREW . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

PRINTED IN U.S.A.

Qty. Req.

87

Description

Qty. Req.

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 292 — TILT CYLINDER

ET2720725

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160784

Description

Qty. Req.

TILT CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

160786

PISTON ROD . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

160787

PISTON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

160788

GLAND. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

160789

SEAL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

160785

CYLINDER TUBE . . . . . . . . . . . . . . . . . . . . . . . 1

7

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908540/AP0300

88

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — HYDRAULIC PUMP INSTALLATION

ET2720800

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162291

HOSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

162071

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . . . . 2

3

162427

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

4

162428

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

5

162435

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

6

162412

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

7

162404

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

8

162436

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

9

162422

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

89

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — HYDRAULIC OIL COOLER INSTALLATION

ET2720805

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162443

Description

Qty. Req.

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

908540/AP0300

90

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — PILOT VALVE INSTALLATION

ET2720810

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161236

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 4

2

162446

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 5

3

161351

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 3

4

161354

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

5

161350

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

91

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — HAND LEVER INSTALLATION

ET2720815

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162444

2

162401

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

7

162399

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 2

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

8

162403

3

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

162406

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

9

161230

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

4

162400

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 3

10

161227

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

5

162402

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

11

161351

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 2

6

162405

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

12

162011

HOSE COVERING . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908540/AP0300

Qty. Req.

92

Description

Qty. Req.

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — PILOT OIL SUPPLY UNIT INSTALLATION

ET2720820

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161354

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

2

161227

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

3

162413

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

93

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 272 — TRAVELING GEAR INSTALLATION

ET2720825

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162429

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 4

2

162415

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

6

162425

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 4

7

162411

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

8

162414

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

9

162407

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

10

162409

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

908540/AP0300

Qty. Req.

94

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 292 — TRAVELING GEAR INSTALLATION

ET2720830

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

1

161465

TEE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

7

162426

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 4

8

162410

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

9

161239

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

10

162408

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

11

162429

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 4

12

162415

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

13

162409

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

95

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — TURNING MOTOR INSTALLATION

ET2720835

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162420

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

2

162437

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

3

162447

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

4

161277

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

5

162438

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

6

161223

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

7

162423

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

908540/AP0300

Qty. Req.

96

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — BOOM OFFSET CYLINDER INSTALLATION

ET2720840

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162416

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

2

162445

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

Description

PRINTED IN U.S.A.

Qty. Req.

97

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — TILT CYLINDER INSTALLATION

ET2720845

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161244

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

2

161232

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 4

3

160667

NON RETURN VALVE . . . . . . . . . . . . . . . . . . . . 1

4

161426

FITTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Description

908540/AP0300

Qty. Req.

98

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 272 — DOZER BLADE INSTALLATION

ET2720850

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161261

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

2

162418

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

Description

PRINTED IN U.S.A.

Qty. Req.

99

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODEL 292 — DOZER BLADE INSTALLATION

ET2720855

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161261

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

2

162417

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

Description

908540/AP0300

Qty. Req.

100

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — BOOM INSTALLATION

ET2720860

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162433

2

162434

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

8

162421

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 2

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

9

162424

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 2

3 4

162430

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 2

10

162431

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

162503

HOSE CLAMP . . . . . . . . . . . . . . . . . . . . . . . . . . 4

11

162432

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . . 1

6

162502

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

12

162474

HOSE COVERING (220 cm). . . . . . . . . . . . . . . . 1

7

651434

HB M8-1.2 X 45 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

Description

PRINTED IN U.S.A.

Qty. Req.

101

Description

Qty. Req.

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR HYDRAULIC SYSTEM MODELS 272-292 — ADDITIONAL HYDRAULIC INSTALLATION

ET2720865

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

4

162442

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

5

162440

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

6

162439

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

7

162441

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

8

162419

HIGH PRESSURE HOSE . . . . . . . . . . . . . . . . . 1

Description

908540/AP0300

Qty. Req.

102

PRINTED IN U.S.A.

ELECTRICAL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 104 MODELS 272-292 — ELECTRICAL INSTALLATION 1 . . . . . . . . . . . . . . . . . . . . . . . 104 MODELS 272-292 — ELECTRICAL INSTALLATION 2 . . . . . . . . . . . . . . . . . . . . . . . 105 MODELS 272-292 — BATTERY INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . 106 MODELS 272-292 — CONTROL BOARD. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 107 MODELS 272-292 — RELAY BOX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108 MODELS 272-292 — HEADLIGHTS 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109 MODELS 272-292 — HEADLIGHTS 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110 MODELS 272-292 — HORN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 111

PRINTED IN U.S.A.

103

SECTION I: ELECTRICAL SYSTEM

SECTION I: ELECTRICAL SYSTEM

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR ELECTRICAL SYSTEM MODELS 272-292 — ELECTRICAL INSTALLATION 1

ET2720900

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160743

2

162472

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 2

3

161997

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

4

162002

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

5

161995

SLIDE TERMINAL . . . . . . . . . . . . . . . . . . . . . . . 3

6

162002

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

161363

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161379

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 1

11

161732

SOCKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

MAIN WIRING HARNESS . . . . . . . . . . . . . . . . . 1

908540/AP0300

104

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR ELECTRICAL SYSTEM MODELS 272-292 — ELECTRICAL INSTALLATION 2

ET2720901

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Description

Qty. Req.

Ref. No.

Part No.

Description

Qty. Req.

1

160743

MAIN WIRING HARNESS . . . . . . . . . . . . . . . . . 1

7

2

161998

FUSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

3

161997

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

14

4

162001

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

162003

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

5

162002

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

161858

FUSE HOUSING . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162470

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

PRINTED IN U.S.A.

105

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 160646

SEAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR ELECTRICAL SYSTEM MODELS 272-292 — BATTERY INSTALLATION

ET2720905

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162468

BATTERY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

162328

CARRIER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

162226

CABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162227

CABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

651458

HLN INS M8-1.2 8 ZO . . . . . . . . . . . . . . . . . . . . 1

10

656100

WASHER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908540/AP0300

Qty. Req.

106

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR ELECTRICAL SYSTEM MODELS 272-292 — CONTROL BOARD

ET2720910

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160744

CONTROL BOARD . . . . . . . . . . . . . . . . . . . . . . 1

9

161380

2

160535

CONTROL BOARD . . . . . . . . . . . . . . . . . . . . . . 1

10

161368

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

161364

FUSE BOX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

160713

KEY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161374

FUSE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161398

PLUG. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161369

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161849

WIRING HARNESS. . . . . . . . . . . . . . . . . . . . . . . 1

6

161370

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

15

161373

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

161372

SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162469

COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161996

FRAME . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Description

PRINTED IN U.S.A.

Qty. Req.

Ref. No.

107

Part No.

Description

Qty. Req.

IGNITION SWITCH ASSEMBLY . . . . . . . . . . . . . 1

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR ELECTRICAL SYSTEM MODELS 272-292 — RELAY BOX

ET2720915

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160890

RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

160821

RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

160891

RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

160889

RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

651505

SHCS HS M5-0.8 X 20 8.8 ZO D912 . . . . . . . . . 4

7

161665

WASHER/GR A 5.3 ZO DIN9021. . . . . . . . . . . . 4

10

162199

RELAY COVER . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

11

162388

RUBBER PROTECTOR. . . . . . . . . . . . . . . . . . . 1

12

651424

CS M6-1.0 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 2

13

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 2

14

161666

WASHER/GR A 6.4 ZO DIN9021. . . . . . . . . . . . 2

908540/AP0300

108

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR ELECTRICAL SYSTEM MODELS 272-292 — HEADLIGHTS 1

ET2720920

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161381

2

161367

HALOGEN LAMP. . . . . . . . . . . . . . . . . . . . . . . . 1

3

160883

LIGHT COVER. . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

INTEGRATED LIGHT . . . . . . . . . . . . . . . . . . . . 1

4

161614

NUT/CAGE M6 . . . . . . . . . . . . . . . . . . . . . . . . . 4

5

651424

CS M6-1.0 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 4

6

161675

LOCKWASHER S6 . . . . . . . . . . . . . . . . . . . . . . 4

7

161666

WASHER/GR A 6.4 ZO DIN9021 . . . . . . . . . . . 4

8

162390

CABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

PRINTED IN U.S.A.

109

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR ELECTRICAL SYSTEM MODELS 272-292 — HEADLIGHTS 2

ET2720925

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

160537

HEADLIGHT HOUSING . . . . . . . . . . . . . . . . . . . 1

2

161367

HALOGEN LAMP . . . . . . . . . . . . . . . . . . . . . . . . 1

3

161379

WIRING HARNESS . . . . . . . . . . . . . . . . . . . . . . 2

4

161995

SLIDE TERMINAL . . . . . . . . . . . . . . . . . . . . . . . 2

5

161997

SLIDE TERMINAL . . . . . . . . . . . . . . . . . . . . . . . 2

6

162002

PLUG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908540/AP0300

Qty. Req.

110

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR ELECTRICAL SYSTEM MODELS 272-292 — HORN

ET2720930

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

161366

HORN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2

161616

NUT/CAGE M8 . . . . . . . . . . . . . . . . . . . . . . . . . 1

3

656001

CS M8-1.2 X 20 C 8.8 ZO . . . . . . . . . . . . . . . . . 1

4

161676

LOCKWASHER S8 . . . . . . . . . . . . . . . . . . . . . . 1

5

161661

WASHER/GR A 8.4 ZO . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

111

908540/AP0300

908540/AP0300

112

PRINTED IN U.S.A.

SECTION J: TOOLS

SECTION J: TOOLS

TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 114 MODELS 272-292 — TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 114

PRINTED IN U.S.A.

113

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR TOOLS MODELS 272-292 — TOOLS

ET2721010

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

1

162467

2

161990

SCREW DRIVERS AND WRENCHES . . . . . . . 1

3

161991

HAMMER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

4

161992

GREASE GUN . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

161988

TOOL KIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

Qty. Req.

TOOL ORGANIZER . . . . . . . . . . . . . . . . . . . . . . 1

908540/AP0300

114

PRINTED IN U.S.A.

SECTION K: DECALS

SECTION K: DECALS

DECALS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116 MODEL 272 — DECALS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116 MODEL 292 — DECALS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117

PRINTED IN U.S.A.

115

908540/AP0300

MODELS 272-292 MINI-EXCAVATOR DECALS MODEL 272 — DECALS

ET2721000

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162457

2

161981

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

19

161986

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

20

161970

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

3 4

161985

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

21

162452

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161982

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

22

162451

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162459

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

162450

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162460

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

162449

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162455

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

25

162013

ID-PLATE (BIG) . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161974

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

26

161984

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161987

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

29

162456

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161967

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

30

162454

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161966

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

31

161975

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161969

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

32

162465

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161965

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

33

162317

DECAL SET. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

16

162453

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

35

162463

DECAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

908540/AP0300

Qty. Req.

116

Description

Qty. Req.

PRINTED IN U.S.A.

MODELS 272-292 MINI-EXCAVATOR DECALS MODEL 292 — DECALS

ET2721005

∗ Reference numbers marked with an asterisk (*) indicate that the individual parts of the assembly are listed later in this section. Refer to the Table of Contents for locations of specific assemblies.

Ref. No.

Part No.

Ref. No.

Part No.

1

162457

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

16

162453

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

2 3

161981

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

19

161986

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

161985

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

20

161970

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

4

161982

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

21

162452

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

5

162461

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

22

162451

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

6

162462

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

23

162450

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

7

162455

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

24

162449

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

8

161974

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

26

161984

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

9

162458

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

29

162456

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

10

161987

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

30

162454

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

11

161967

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

31

161975

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

12

161966

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

32

162465

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

13

161969

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

33

162327

DECAL SET . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

14

161965

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

35

162464

DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

Description

PRINTED IN U.S.A.

Qty. Req.

117

Description

Qty. Req.

908540/AP0300

908540/AP0300

118

PRINTED IN U.S.A.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

160400 160401 160402

19 57 19 24 57 47 46 46 16 50 57 70 61 29 29 80 80 80 80 33 39 43 43 43 43 37 37 37 33 33 35 46 46 107 57 110 70 70 70 70 22 46 22 7 9 37 37 37 45 19 24 16 51 105 81 82 22 56 78 98 61 61 61 61 7 9 22 107 32 29 29 29 29 7 9 67 29 29 27 27 27 27 27 29 27 29

16 3 13 18 5 1 7 8 33 7 2 13 14 30 31 9 10 11 8 5 1 11 12 7 20 10 1 20 3 4 6 32 31 2 6 1 8 9 1 11 3 12 20 9 9 9 8 7 4 19 33 35 8 14 28 28 1 11 15 3 3 4 37 36 4 4 7 11 6 1 4 2 3 12 12 1 29 28 11 9 10 12 13 11 7 12

160733 160734 160735 160736 160737

29 27 27 16 7 9 41 40 44 45 45 104 105 107 54 52 50 54 50 50 50 50 50 56 29 87 29 86 27 85 16 84 80 80 77 76 87 86 85 84 87 84 86 85 87 86 85 84 16 81 62 87 84 86 85 9 88 88 88 88 88 88 9 9 9 82 7 9 11 7 9 10 29 29 29 14 14 14 16 16 61 57 108 14 83 83

10 5 6 18 13 13 1 1 1 3 2 1 1 1 14 11 24 10 11 12 22 10 1 1 5 1 6 1 3 1 6 1 2 1 8 1 5 7 7 9 4 4 4 4 3 3 3 3 5 9 1 7 12 9 9 37 1 6 2 3 4 5 33 31 32 9 3 3 9 2 2 23 8 7 9 2 4 3 30 2 5 1 2 13 1 5

160838 160839 160841 160842 160843 160844

83 83 68 23 83 55 55 54 53 53 54 47 29 60 63 83 62 109 68 108 108 108 78 78 79 78 78 78 79 61 47 29 61 87 79 96 92 93 92 98 91 95 98 99 100 96 91 91 92 91 93 81 82 83 104 107 111 109 110 107 107 107 107 107 107 104 110 107 109 47 47 52 55 18 18 43 44 61 107 18 87 46 29 27 9 14

4 3 1 16 7 10 11 15 6 7 5 15 27 1 1 14 13 3 4 4 1 3 7 20 11 13 12 21 12 12 19 26 39 15 1 6 10 2 9 2 1 9 1 1 1 4 5 3 11 4 1 27 27 13 9 3 1 2 2 10 5 6 7 15 4 10 3 9 1 12 13 34 12 7 8 4 2 41 13 11 16 17 38 16 40 7

160403 160406 160407 160408 160409 160427 160436 160437 160439 160458 160459 160463 160469 160470 160486 160488 160489 160490 160491 160492 160493 160494 160495 160497 160526 160527 160529 160532 160533 160535 160536 160537 160571 160572 160594 160596 160611 160612 160638 160639 160640 160641 160642 160643 160644 160645 160646 160651 160653 160657 160658 160667 160706 160707 160708 160709 160710 160711 160713 160716 160719 160720 160721 160722 160723 160724 160725 160726 160727 160728 160729 160730 160731 160732

PRINTED IN U.S.A.

160738 160739 160740 160741 160742 160743 160744 160745 160746 160747 160749 160750 160751 160752 160753 160754 160755 160756 160757 160758 160759 160761 160762 160763 160764 160765 160766 160767 160768 160769 160770 160771 160772 160773 160774 160775 160776 160777 160778 160781 160782 160783 160784 160785 160786 160787 160788 160789 160790 160791 160792 160793 160794 160795 160796 160802 160803 160808 160811 160812 160813 160814 160815 160816 160818 160821 160835 160837

160848 160849 160851 160859 160860 160862 160863 160864 160866 160878 160883 160887 160889 160890 160891 160912 160918 160930 160931 160947 160949 160950 160972 161154 161223 161227 161230 161232 161236 161239 161244 161261 161277 161350 161351 161354 161357 161363 161364 161366 161367 161368 161369 161370 161372 161373 161374 161379 161380 161381 161389 161390 161391 161392 161396 161397 161398 161401 161403 161407 161410 161411

119

Part No.

161412

161414 161415 161416 161417 161418 161422

161423 161424 161425 161426

161427

161428 161429

161431 161436 161439 161443 161444 161445 161446

161448

161450

161451

Page No.

Ref. No.

18 27 29 7 9 16 83 84 85 86 87 61 61 9 14 83 7 9 73 16 18 27 29 84 85 86 87 47 73 47 73 61 70 71 72 73 76 77 78 79 79 80 88 98 71 77 81 82 84 72 47 61 71 72 73 81 82 83 62 72 47 78 79 68 76 77 72 47 73 71 72 73 81 82 68 71 76 78 81 82 62 71 77 78 79 68

4 27 23 27 27 10 11 21 11 11 11 2 17 41 8 12 28 28 11 11 5 28 24 22 12 12 12 16 12 17 10 16 14 5 5 1 5 11 9 6 9 3 7 4 4 9 24 24 23 3 18 23 6 6 8 22 22 15 3 4 22 8 7 7 7 12 7 21 7 3 8 4 25 25 8 7 9 11 29 31 14 8 10 10 8 20

NUMERICAL INDEX

272/292

908540/AP0300

272/292 Part No.

Page No.

Ref. No.

161456

61 68 18 71 72 81 82 85 86 87 63 95 73 18 18 29 62 76 47 47 61 61 61 62 68 73 61 68 61 67 68 61 67 68 68 73 62 79 16 29 29 14 85 86 87 83 84 29 27 27 27 10 10 62 81 82 83 70 61 10 16 10 11 61 7 9 62 67 68 67 68 73 19 24 52 109 23 46 61 78 79 81 82 24 111 7

31 19 6 2 2 23 23 13 13 13 5 1 5 9 10 33 4 8 28 20 10 32 38 5 18 6 40 16 34 3 6 30 2 15 12 3 15 10 8 17 16 5 10 10 10 9 20 15 15 24 23 13 14 7 26 26 10 12 11 12 9 11 5 6 29 29 2 8 9 9 11 2 4 26 15 4 25 6 27 3 5 21 21 32 2 17

161461 161463

161464 161465 161467 161468 161469 161471 161474 161476 161477 161485 161492

NUMERICAL INDEX

161493 161496 161498 161500 161501 161503 161508 161509 161514 161528 161533 161536 161537

161538 161539 161542 161554 161557 161562 161563 161565 161566 161567 161568 161569 161570 161572 161573 161578 161585 161590 161610 161611 161614 161615

161616 161617 908540/AP0300

Part No. 161618 161624

161627 161634 161636 161638 161640

161641 161642

161643 161646 161647 161650 161651 161653 161655 161659

161660

161661

161663

161664 161665 161666

161667

Page No.

Ref. No.

9 37 7 9 9 10 16 33 16 9 19 24 24 46 51 55 60 51 16 22 22 22 78 22 52 16 7 9 85 46 7 9 10 19 24 24 34 57 18 33 47 53 56 80 81 82 7 9 16 22 23 37 46 51 52 53 54 55 56 61 70 78 79 79 81 82 85 111 19 22 24 57 61 32 61 108 52 76 108 109 7 9 17 22 23 51

17 17 33 44 45 18 34 24 4 34 10 17 24 18 7 4 8 13 26 12 18 26 19 17 4 19 25 25 19 15 23 23 22 18 21 29 9 8 12 28 3 17 17 6 13 13 21 21 20 28 24 16 5 11 26 3 9 9 8 9 15 6 4 17 20 20 17 5 9 6 10 13 21 5 43 7 18 4 14 7 32 46 5 23 19 15

120

Part No.

161669

161670

161674 161675

161676

161682

161686 161722 161728 161730 161732 161733 161737 161764 161770 161771 161772 161776 161777 161778 161779 161780 161784 161785 161786 161788 161805 161831 161834 161838 161839 161841

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

52 63 7 9 19 22 24 51 55 57 60 61 62 68 7 9 16 32 60 78 19 24 24 18 52 56 76 77 80 81 82 108 109 7 9 16 17 23 24 46 51 52 53 54 55 56 61 63 70 78 79 81 82 85 111 14 16 27 29 29 18 46 46 104 56 50 78 33 38 38 33 43 43 33 43 33 33 37 37 43 19 46 46 34 34 35

14 4 26 26 8 5 16 6 3 12 7 20 9 3 15 15 23 4 10 18 15 20 28 3 17 18 3 14 5 12 12 13 6 20 20 21 4 23 9 4 10 13 4 8 8 7 8 3 16 5 3 18 18 16 4 6 29 33 25 18 1 33 9 11 10 13 14 10 2 1 18 1 3 19 14 17 22 2 3 8 2 11 22 5 6 2

161842 161843 161844 161847 161848 161849 161856 161858 161867 161868 161875 161879 161903 161921 161922 161923 161924 161925 161936 161938 161939 161940 161941 161942 161943

35 33 33 35 46 107 52 105 57 46 22 23 82 33 33 33 33 43 22 37 37 37 37 43 17 23 24 52 34 22 22 46 17 23 24 52 33 33 37 60 37 38 39 40 41 116 117 116 117 116 117 116 117 116 117 116 117 116 117 116 117 116 117 116 117 116 117 116 117 116 117 114 114 114 114 32 104 110 107 104 105 110 105 105 104 104

4 25 2 5 13 14 22 16 4 16 10 17 30 16 15 14 13 15 9 4 5 6 11 9 9 3 31 19 3 24 27 20 2 2 6 20 11 12 12 2 13 4 2 2 2 14 14 12 12 11 11 13 13 20 20 8 8 31 31 2 2 4 4 26 26 3 3 19 19 10 10 5 2 3 4 10 5 4 8 3 3 5 2 4 4 6

161944 161945 161946 161947 161948

161949 161950 161951 161954 161957 161964

161965 161966 161967 161969 161970 161974 161975 161981 161982 161984 161985 161986 161987 161988 161990 161991 161992 161995 161996 161997 161998 162001 162002

PRINTED IN U.S.A.

Part No.

162003 162005 162006 162007 162008 162011 162012 162013 162018 162020 162024 162026 162027 162029 162031 162032 162033 162034 162035 162036 162037 162040 162041 162042 162044 162045 162046 162047 162048 162050 162062 162064 162066 162071 162072 162125 162126 162127 162128 162129 162130 162131 162132 162133 162134 162135 162136 162137 162138 162139 162140 162141 162142 162143 162144 162145 162146 162147 162148 162149 162150 162151 162152 162153 162154 162155 162156 162157 162158 162159 162160 162161 162162 162163 162164 162165 162166 162167 162168

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

105 110 105 34 34 34 51 92 35 116 43 23 10 9 22 78 33 33 43 7 37 22 33 33 33 57 83 43 34 43 22 19 24 46 34 61 47 27 89 24 66 66 66 66 66 64 66 67 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 64 65 65 65 65 65 65 65

5 6 15 4 2 7 16 12 3 25 6 15 19 35 15 16 23 30 19 34 15 4 26 27 29 7 19 18 11 17 19 17 15 24 10 24 14 29 2 23 13 14 15 16 17 1 18 5 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 1 2 3 4 5 6 7

162169 162170 162171 162172 162173 162174 162175 162176 162177 162178 162179 162180 162181 162182 162183 162184 162185 162186 162187 162188 162189 162190 162191 162192 162193 162194 162195 162196 162197 162198 162199 162200 162201 162202 162203 162204 162205 162206 162207 162208 162209 162210 162211 162212 162213 162214 162215 162216 162217 162218 162219 162220 162221 162222 162223 162224 162225 162226 162227 162228 162229 162230 162231 162233 162234 162235 162236 162237 162238 162239 162240 162241 162242 162243 162244 162245 162246 162247 162248 162249 162250 162251 162252 162253 162254 162255

65 65 65 65 65 65 65 65 65 65 65 65 65 65 65 65 65 67 67 16 24 19 52 24 24 19 17 17 61 23 108 22 22 16 24 52 19 19 56 61 14 46 46 46 46 46 33 33 33 46 33 33 33 34 34 45 45 106 106 55 53 53 50 55 50 29 85 62 62 76 76 77 77 77 77 77 77 76 76 84 84 84 85 85 85 86

8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 6 7 1 7 1 7 30 1 12 1 6 25 1 10 13 14 14 22 6 6 5 2 1 1 27 28 29 30 21 8 20 21 2 6 7 1 1 13 1 5 4 5 1 18 19 25 5 26 40 18 10 12 11 12 1 2 3 4 5 6 10 13 2 5 6 5 6 2 6

162256 162257 162258 162259 162260 162261 162262 162263 162264

86 86 87 74 74 74 74 74 66 74 74 74 74 74 74 74 74 74 74 74 74 74 74 74 75 75 75 75 75 75 75 75 75 75 75 75 89 81 82 81 82 81 82 81 82 81 82 81 82 81 82 81 81 82 24 24 24 24 23 23 23 23 23 23 23 23 23 23 19 62 116 9 9 9 9 72 9 72 82 82 117 106 7 7 9 7

2 5 2 1 2 3 4 5 3 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 2 50 29 51 35 52 53 7 54 55 56 57 1 1 1 2 2 3 3 4 4 5 5 6 6 7 7 8 10 10 2 3 4 5 5 6 7 8 9 10 11 12 13 14 21 11 33 30 1 50 38 1 10 9 29 8 33 3 7 5 5 8

PRINTED IN U.S.A.

162265 162266 162267 162268 162269 162270 162271 162272 162273 162274 162275 162276 162277 162278 162279 162280 162281 162282 162283 162284 162285 162286 162287 162288 162289 162290 162291 162292 162293 162294 162295 162296 162297 162298 162299 162300 162301 162302 162303 162304 162305 162306 162307 162308 162309 162310 162311 162312 162313 162314 162315 162316 162317 162318 162319 162320 162321 162322 162323 162324 162325 162326 162327 162328 162329 162330 162331

121

Part No. 162332 162333 162334 162335 162336 162337 162338 162339 162340 162341 162342 162343 162344 162345 162346 162347 162348 162349 162350 162351 162352 162353 162354 162355 162357 162358 162359 162360 162361 162374 162375 162376 162377 162378 162379 162380 162381 162382 162385 162386 162387 162388 162389 162390 162391 162392 162393 162394 162395 162397 162398 162399 162400 162401 162402 162403 162404 162405 162406 162407 162408 162409 162410 162411 162412 162413 162414 162415 162416 162417 162418 162420 162421 162422 162423 162424 162425 162426

Page No.

Ref. No.

9 7 9 11 11 11 10 10 10 10 10 10 10 10 10 16 9 57 16 56 56 56 24 24 81 82 56 52 54 62 83 83 78 22 23 79 81 57 82 52 52 53 68 17 108 24 109 50 51 51 51 51 85 56 81 82 92 92 92 92 92 89 92 92 94 95 94 95 95 94 89 93 94 94 95 97 100 99 96 101 89 73 96 101 94 95

8 6 6 1 2 3 2 1 8 6 5 4 3 7 15 28 7 10 15 4 6 5 14 12 15 15 12 23 4 6 18 2 1 25 21 15 19 14 19 1 2 11 13 8 11 25 8 23 2 4 1 3 14 3 16 16 7 4 2 5 8 7 6 3 9 10 10 13 8 7 6 3 8 2 12 1 2 2 1 8 9 9 7 9 6 7

NUMERICAL INDEX

272/292

908540/AP0300

272/292 Part No.

Page No.

Ref. No.

162427 162428 162429

89 89 94 95 101 101 101 101 101 89 89 96 96 90 92 97 91 96 78 116 117 116 117 116 117 116 117 116 117 116 117 116 117 116 117 116 117 117 116 116 117 117 116 117 116 117 114 106 107 105 70 104 9 101 32 17 19 23 33 24 9 16 83 84 85 86 87 52 9 10 16 16 56 10 29 11 10 11 10 11 61 61 61 87 76 67

3 4 1 11 3 10 11 1 2 5 8 2 5 1 1 2 2 3 2 24 24 23 23 22 22 21 21 16 16 30 30 7 7 29 29 1 1 9 5 6 5 6 35 35 32 32 1 1 16 6 7 2 51 12 1 7 20 4 9 27 39 13 6 10 8 8 6 3 47 16 12 37 15 21 20 7 10 6 20 8 35 13 15 14 6 4

162430 162431 162432 162433 162434 162435 162436 162437 162438 162443 162444 162445 162446 162447 162448 162449 162450

NUMERICAL INDEX

162451 162452 162453 162454 162455 162456 162457 162458 162459 162460 162461 162462 162463 162464 162465 162467 162468 162469 162470 162471 162472 162473 162474 162475 162476 162477 162478 162479 162480 162481

162482 162483 162484 162485 162486 162487 162488 162489 162490 162491 162492 162493 162494 162495 162496 162497 908540/AP0300

Part No. 162498 162499 162500 162501 162502 162503 162504 162505 162506 162507 162516 162517 162518 162519 162520 162521 162522 162523 162524 162525 162526 162527 162528 162529 162530 162531 162532 162533 162534 162535 162536 162537 162538 162539 425-34635 425-34636 425-34652 425-34661 425-34683 425-34686 425-34687 425-34688 425-34703 425-34704 425-34713 425-34715 425-34753 425-34853 425-35492 425-35506 425-35925 425-35973 425-36085 425-36086 425-36091 425-36092 425-36093 425-36094 425-36095 425-36097 425-36098 425-36099 425-36100 425-36101 425-36103 425-36105 425-36106 425-36159 425-36167 425-36168 651390 651391 651393 651395

651396

Page No.

Ref. No.

68 68 68 61 52 101 101 55 56 11 10 47 35 70 70 70 70 70 7 9 7 27 16 71 7 71 66 66 66 66 66 66 66 66 66 66 66 50 50 55 54 50 50 52 52 50 50 50 50 50 50 52 50 50 50 55 50 50 55 52 52 53 53 53 53 53 53 53 54 54 54 53 52 53 46 7 9 55 19 51 60 7 9 22 51 19

17 10 14 33 33 6 4 13 16 4 9 2 1 10 2 3 5 6 11 11 1 2 24 1 10 9 1 2 4 5 6 7 8 9 10 11 12 4 21 6 12 17 6 31 30 3 16 18 20 19 9 32 14 15 8 15 5 2 14 25 10 8 9 10 12 13 14 15 6 1 2 16 21 1 14 16 16 2 3 5 6 30 48 11 12 7

122

Part No.

651402 651405 651413 651424 651425 651426 651427 651428 651430 651434 651438 651439 651442 651443 651446 651448 651449 651451 651457 651458

651460 651466 651468 651470 651473 651475 651477 651480 651483 651489 651493 651495 651499 651503 651505 651507 651513 651514 651517 656001

656004 656017 656048

Page No.

Ref. No.

Part No.

Page No.

Ref. No.

60 61 57 61 16 7 108 109 18 22 76 27 77 81 82 9 22 101 55 9 27 29 29 16 27 29 22 46 52 16 22 53 56 9 22 23 27 29 46 52 79 106 46 37 81 82 85 16 68 62 22 60 7 9 32 32 9 16 16 19 24 108 80 79 85 46 7 9 16 17 23 46 51 54 56 63 79 81 82 111 22 78 24 37 46 54

5 18 11 19 25 18 12 5 2 29 2 25 13 11 11 36 16 7 7 42 21 21 39 27 19 19 2 19 5 36 30 5 19 43 31 20 22 22 23 27 18 8 25 18 14 14 20 31 2 8 8 9 22 22 3 2 18 17 16 14 19 5 4 16 15 10 19 19 32 3 18 3 9 11 9 2 2 17 17 3 21 17 11 14 1 13

656090

7 9 43 23 24 53 61 78 51 54 106 61 24 52 56 61 70 7 9 7 9 52 34 61

31 49 16 22 13 2 26 4 14 7 10 22 8 12 14 7 17 24 24 14 14 16 8 42

656092 656093

656094 656100 656102 656105

656143 656148 656149 656163

PRINTED IN U.S.A.

TORQUE SPECIFICATIONS NOTE:

Use these torque values when tightening GEHL hardware (excluding: Locknuts and Selftapping, Thread Forming and Sheet Metal Screws) unless specified otherwise.

All torque values are in Lb-Ft except those marked with an * which are Lb-In (For metric torque value Nm, multiply Lb-Ft value by 1.355 or Lb-In value by 0.113) (To convert Nm to Lb–Ft multiply by 0.738)

Unified National Thread

Grade 2

Grade 5

Dry

Lubed

Dry

Lubed

Dry

Lubed

8-32 8-36

19* 20*

14* 15*

30* 31*

22* 23*

41* 43*

31* 32*

10-24 10-32

27* 31*

21* 23*

43* 49*

32* 36*

60* 68*

45* 51*

1/4-20 1/4-28

66* 76*

50* 56*

9 10

75* 86*

12 14

9 10

5/16-18 5/16-24

11 12

9

17 19

13 14

25

18 20

3/8-16 3/8-24

20 23

15 17

30 35

23 25

45 50

35

7/16-14 7/16-20

32 36

24 27

50 55

35 40

70 80

55 60

1/2-13 1/2-20

50 55

35 40

75 90

55 65

110 120

80 90

9/16-12 9/16-18

70 80

55 60

110 120

80 90

150 170

110 130

5/8-11 5/8-18

100 110

75 85

150 180

110 130

220 240

170 180

3/4-10 3/4-16

175 200

130 150

260 300

200 220

380 420

280 320

7/8-9 7/8-14

170 180

125 140

430 470

320 360

600 660

460 500

1-8 1-14

250 270

190 210

640 710

480 530

900 1000

680 740

Metric Course Thread

Grade 8.8

8.8

Grade 10.9

Grade 8

10.9

Grade 12.9

12.9

Dry

Lubed

Dry

Lubed

Dry

Lubed

M6-1

8

6

11

8

13.5

10

M8-1.25

19

14

27

20

32.5

24

M10-1.5

37.5

28

53

39

64

47

M12-1.75

65

48

91.5

67.5

111.5

82

M14-2

103.5

76.5

145.5

108

176.5

131

M16-2

158.5

117.5

223.5

165.5

271

200



Gehl Company 143 Water Street, P.O. Box 179, West Bend, WI 53095-0179, U.S.A.

908540/AP0300



2000 GEHL Company. All rights reserved.

Printed in U.S.A.