Gehl 120 MX Mix-All Service Parts Manual 901533 - PDF DOWNLOAD

-=

=== =

Form No.

901533

Replaces

=,901089

11M ix-All" Mixer

Service Parts Manual

-= = = =

<l

[~l$

120MX - INTRODUCTION _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ Mr. Dealer: Give complete information when ordering service parts. Always give complete part numbers and also complete part description.

The model number and serial number should always be given. Numbers for the Mixer are stamped on a plate located on the Rear Frame Member below the Concentrate Hopper. Hammer Mill numbers are located on the Left Frame Sheet. Hay Feeder numbers are located on the Roller Cover and Swinging Auger Feeder numbers are located on the right side of the Pivot Frame.

"Right" and "Left" are determined from a position standing at the rear of the Mixer and looking toward the Drawbar Hitch. The Mill Feeder is on the "right" side and the Mixer Unloading Conveyor on the "left" side.

NOTE: You will find common hardware such as nuts, bolts, etc. listed but not illustrated in parts lists in this manual. Hardware listed with the particular part is for mounting purposes and is not included when the part is ordered for replacement.

Gehl Company reserves the right to make changes or improvements in the design or construction of any part without incurring the obligation to install such changes on any unit previously delivered.

Table of Contents Page Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

2 Decal Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4 Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

5 Frame . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7 Tank and Hopper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-10 Mixer Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 Power Take-Off Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-13 Unloading Conveyor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-15 Conveyor Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-18 Mill Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 Mill Frame and Blower . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20-21 120SAF Feeder Trough . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22-23 120SAF Feeder Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-26 150HF Hay Feeder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27-29 150HF Hay Feeder Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30-31 150PBF Feeder Head (Used after Serial No. 1410) ; ........... 32-34 150PBF Feeder Head (Used before Serial No. 1411) .......... 35-38 150PBF Feed Conveyor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39-41 Accessories ......... . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42-43 150PBF Hydraulic Feeder Head . . . . . . . . . . . . . . . . . . . . . . . . 44-46 150PBF Hydraulic Feed Conveyor . . . . . . . . . . . . . . . . . . . . . . 48-49 Hydraulic Unloading Conveyor . . . . . . . . . . . . . . . . . . . . . . . . . . 50-51 Hydraulic Conveyor Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52-53 120SAF Hydraulic Feeder Trough . . . . . . . . . . . . . . . . . . . . . . . . 54-55 120SAF Hydraulic Feeder Drive . . . . . . . . . . . . . . . . . . . . . . . . 56-57 150HF Hydraulic Hay Feeder . . . . . . . . . . . . . . . . . . . . . . . . . . 58-59 Hydraulic System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60-61 Folding Conveyor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62-63 Hopper. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 64 Winch. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 65 Selector Valve. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 65 120MX/120SAF Hydraulic Motor. . . . . . . . . . . . . . . . . . . . . . . .. 66 120SAF/ 150HF Flow Control Valve . . . . . . . . . . . . . . . . . . . . . .. 66 150HF Hydraulic Motor. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 67 Selector Valve. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 67 120MX Hydraulic Motor. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 68 150HF Hydraulic Motor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 68 Universal Drives. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69-70 Hitch Jack .......... '.' . . . . . . . . . . . . . . . . . . . . . . . . . . .. 71 Numerical Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72-78 Parts lists in this manual contain various abbreviations. Below is an explanation of these abbreviations.

2

HN HJN .

HLN· SN . eN WN .

Hexagon Nut Hexagon Jam Nut Hexagon Lock Nut Slotted Nut Castellated Nut Wing Nut

PW LW

Plain Washer Lock Washer

.

ILW . Internal Tooth Lock Washer ELW· External Tooth Lock Washer L.H.· Left·Hand Thread NF . National Fine Thread S·L Self.Locking DPT Double Pitch Tooth

Decal locations are shown to assist in application of new decals in the event of damage to the decal or refinishing of the machine. Check below for their locations.

Surfaces must be free from dirt, dust, grease and other foreign material before applying decals. To apply decals, remove the smaller portion of the decal backing paper and apply this part of the exposed adhesive backing to the clean surface in respective position. Peel other portion of the backing paper off slowly and apply decal.

The Decal Set Number for 120MX is 600158. The set includes the following Decals:

1 2 3 4 5

6 7 8 9 10 11 12 13 14 15

047974 041070 053370 053456 053351 - 042298 050263 - 053374 - 049062 041069 041065 - 053461 - 049262 - 049453 050202

Fast, Slow High, Low Direction Arrow Gehl Mix-All Universal Drive Instructions Lubricate Every 5 Hours Shear Bolts Be Careful and Chain Instructions Gehl - 21" Important Important - Keep Belts Tight Clutch Pin Instructions Adjust Chain 120 (Two Places) Caution

16 17 18 19 20 21 22 23 24 25 26 27

- 053369 - 053354 - 042614 - 053359 - 053366 - 041066 - 041067 - 041073 - 053514 - 053513 - 052134 - 053890 - 052162

Gehl (5 x 46) - (Two Places) Be Careful - (Two Places) Do Not Operate Below Horizontal Raise Flap Grease Arrow Do Not Remove 6, 7, 8, 9, 10 - (Two Places) 1, 2, 3, 4, 5 - (Two Places) Weights and Measurements (without Electronic Scale) Caution Remove Before Operating .

Instructions Caution High - Neutral - Low

DECAL LOCATIONS _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __

-

NOTE: Always order Decals by set number. DO NOT order Decals separately.

4

IMPORTANT: Alwavs observe safety rules shown on Decals. . ,.

120MX - TRANSMISSION (USED AFTER SERIAL #6926*) _ _ _ _ __ *Refer to existing page for 120 Mixer Transmission before Serial #6927. Assembled Transmission 047692 Is replaced by Transmission 058657 which can be identified by Its larger (2-7/8" 0.0.) relubable Bearing on top of Transmission. BE SURE to order correct Internal parts to match Transmission being serviced.

10

'.,

3 25 2\

22 23

15

\,'''~.

2(\'l.,.\\~/ '

•

~~

~I

~

~:7' -1··~~jPj1~~ 6

I

1~ t

IB

2 I

20

!=:2 ,~\

~~//~~ ".

.~-

15

14 16 29

';'--23

~~

~

2J ~ 16 @)-12

®---14 Ref. No.

Part No. 058657

2 3 4 5 6 7 8 9 10 II 12 13 14 15

Part Name

No. Req.

Transmission - Assembled ........

Consists of: 4H42 Set Collar ......................

650217 SHSS 3/8 x 3/4 ................

7H73 Shim Washer ............. As Req'd 17HI40 Shim Washer ................... I 17HI42A Transmission Gear (l4T) ......... I 17H238 Bearing Bushing ................. 2 D932A Washer ........................ I Blll62B Bearing Retainer ................ I 044500 Transmission Drive Gear (14T) .... 2 047620 Cover Gasket ................... I 047693 Transmission Cover ............. I 650428 HHCS 5fl6 x 5/8 (LW) ......... 4 047694 Transmission Drive Shaft I-I / 4 x 13-15 fl6 ............... I 655533 Woodruff Key 5/ 16 x 1-1/4 ...... I 047697 Bearing Cover Gasket ............ I 047698 Bearing Cover .................. I 650428 HHCS 5/16 x 5/8 (LW) ......... 3 047852 Oil Seal ........................ I 047853 Retaining Ring .................. 2

Ref. No.

Part No.

16 047854 17 051425

18 19 20 21 22 23 24 25 26 27 28 29

655020 655533 051427 570023 650487 058501 058503 570016 058658 655537 061528 075060 520000 520001 520054 520064 520153 520201

'.

Part Name

No. Req.,

Retaining Ring .................. 2 Conveyor Drive Shaft I x 10-7/8 ..................... I Cotter Pin 3/ 16 x I-I / 2 ......... I Woodruff Key 5fl6 x 1-1/4 ..... '. I Conveyor Shaft Bearing .......... I Grease Fitting ................. I HHCS 5fl6 x I (LW) ........... 4 Ball Bearing (2-7/8 0.0.) ......... I Transmission Housing ........... I Relief Fitting ................... I Mixer Drive Shaft ............... ' I Woodruff Key 5/16 x 1-1/4 ...... I Shim Washer ................... 4 Shim Washer ................... 4 Lock Nut ...................... I Lock Washer ................... I Bearing Cup .................... 2 Ball Bearing .................... I Bearing Lock Collar ............. I Bearing Cone ................... 2

4.

120MX - TRANSMISSION

17

"

t I

19

WARNING - Order By Part Number - Do Not Use Illustration Reference Numbers

~

~30

S--29

0 - - 11 16

\~\~\f\\=r= 9435

6

3220

,./"

t==.

I ,/

I

I' I

I 1

//

Ref. No.

No. Req.

Ref. No.

Washer ................... .

(Used after Serial No. 2610) 4H42 Set Collar ................. .

650217 SoL Soc. Hd. Set Screw 3/8 x 3/4 .. 1 7H73 Shim Washer ............. As req.

17Hl42A Transmission Gear (l4T) ........ 1 17H144 Conveyor Shaft Bearing ........ 1 (Used before Serial No. 2611) (Includes Two 17H238 Bushing) 051427 Conveyor Shaft Bearing ....... .

(Used after Serial No. 2610) (Includes Two 17H238 Bushing) 570023 Grease Fitting. . . . . . . . . . . . .. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 LW 654024 17H238 Bearing Bushing .............. 2 H267 Shim Washer ................ 1 H267 A Shim Washer ................ 1 (Two req'd. before Serial No. 2611) (One req'd. after Serial No. 2610 and before SeriaJ. No. 3212) Washer. . . . . . . . . . . . . . . . . . .. 1 D932A C14121 Bearing Retainer. . . . . . . . . . . . .. 1 (Used before Serial No. 2611) B11162B Bearing Retainer . . . . . . . . . . . . .. 1 (Used after Serial No. 2610) 044110 Retaining Ring ............... 2 044500 Transmission Drive Gear (l4T) . . .. 2 044645 Gear Spacer ................ 1 047549 Transmission Housing .......... 1 570016 Relief Fitting . . . . . . . . . . . . .. 1 047620 Cover Gasket .............. '.' 1 047692 Transmission Assembled ........ 1 652012 Hex. Hd. Mach. Bolt 1/2 x 67l 3 (3) 1/2 HN 653018 - (3) 1/2 PW 654009 (3) 1/2 LW 654030

17

Part No. lOE20

2 3 4 5

6 7 8

9 10

11 12 13 14 15 16

Part Name

29 25

~ 21 .. ' ..'

• .

22

Part No.

Part Name

No. Req.

047693 Transmission Cover . . . . . . . . . . .. 1 650023 Hex. Hd. Cap Screw 5/16 x 5/8.. 4 (4) 5/16 LW 654024 660004 Pipe Plug - 1/2 ............ 1 18 047694 Transmission Drive Shaft 1~ x 13-15/161 655533 Woodruff Key 5/16 x 1 HRD... 1 Mixer Drive Shaft ............ 1 19 047695 655021 Cotter Pin 3/16 x B~ ..... , 1 655533 Woodruff Key 5/16 x 1 HRD. .. 1 20 047696 Conveyor Drive Shaft 1 x 10-7/8 .. 1 (Used before Serial No. 2611) 655020 Cotter Pin 3/16 x 17l . . . . .. 1 655507 Woodruff Key 5/16 x l . . . . .. 2 051425 Conveyor Drive Shaft 1 x 10·7/8 .. 1 (Used after Serial No. 2610) 655020 Cotter Pin 3/16 x 17l ........ 1 655533 Woodruff Key 5/16 x 1 HRD . .. 1 655537 Woodruff Key 5/16x I~HRD .. 1 21 047697 Bearing Cover Gasket .......... 1 22 047698 Bearing Cover. . . . . . . . . . . . . . .. 1 650023 Hex. Hd. Cap Screw 5/16 x 5/8.. 3 (3) 5/16 LW 654024 23 047852 Oil Seal . . . . . . . . . . . . . . . . . . .. 1 24 047853 Retaining Ring .............. 2 25 . 047854 Retaining Ring .............. 2 26 520000 Lock Nut .................. 1 27 52000 1 Lock Washer ................ 1 28 520054 Bearing Cup ................ 2 Bearing. . . . . . . . . . . . . . . . . . .. 2 29 520064 30 520085 Bearing Collar . . . . . . . . . . . . .. 1 31 520201 Bearing Cone .......... " . . .. 2

5

120MX - FRAME: _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ Additional Parts Required For Mixer With Scale

5 4

Used before Serial No. 2611

26

•

~4

15

29~ 31

WARNING . Order By Part Number . Do Not Use Illustration Reference Numbers 30

19

2~~

~ ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

•

_ _ _ _ _ _ _ _ _ _ _ _:-:---_-=-:---::-_ _ _ _ 120MX - FRAME Ref. Part No. Ref. Part No. No. No. Part Name Req, No. No. Part Name Req. 26 620005 Retaining Ring ................. 1 1 6HI75 Conveyor Hold-Down Spring........ 1 2 6HI76 Hold-Down Spring Hook .......... 1 (Used before Serial No. 2611) 051909 Retaining Ring ................. 1 3 RI3033D A Hitch Jack .................. -.. 1 (Used before Serial No. 2611) (Used after Serial No. 2610) 051908 8 Hitch Jack .................... 1 27 620028 Conveyor Rest Grommet .......... 4 (Used after Serial No. 2610) Additional Parts Required For 4 040253 Mixer Tank Support - Side ......... 2 Mixer Without Scale 650060 Hex.Hd.Cap Screw 3/8 xl ...... .4 28 17H340A Drawbar Clip - Lower............. 1 650062 Hex.Hd.Cap Screw 3/8 x 1-1/4 ... .4 29 M12234 Washer ...................... 2 (6) 3/8 HN 653010 - (2) 3/8 HLN 653075 30 R13139A Drawbar Clip - Upper............. 1 (12) 3/8 PW 654006 - (6) 3/8 LW 654026 650144 Hex.Hd.Cap Screw 5/8 x 1-3/4 .... 2 5 040428 Mixer Tank Support - Side ......... 2 (2) 5/8 HN 653021 - (2) 5/8 LW 654032 31 051609 Axle Spindle .................. 2 650060 Hex.Hd.Cap Screw 3/8 xl ...... .4 650062 Hex.Hd.Cap Screw 3/8 x 1-1/4 ... .4 (Used after Serial No. 2610) (6)3/8 HN 653010 . (2)3/8 HLN 653075 655013 Cotter Pin 1/8 x 2 ............. 2 650106 Hex.Hd.Cap Screw 1/2 x 1-1/4 .... 8 (12) 3/8 PW 654006 - (6) 3/8 LW 654026 6 042161 WheeIHub.................... 2 650406 Hex.Hd.CapScrew3/4xl-I/2 .... 2 (Includes One 042162 (8) 1/2 HN 653018 - (2) 7/8 NF SN 653102 and One 520054) (8) 1/2 LW 654030 - (2) 3/4 LW 654034 Bearing Cup ................... 2 Additional Parts Required For 7 042162 8 042163 Bearing Cone. . . . . . . . . . . . ...... 2 Mixer With Scale 9 042826 Transmission Shim Washer ......... 3 (Used after Serial No. 2610) 10 047890 Axle Spacer. .................. 2 32 13E24 Roll Pin 1/4x 1-1/2 ...... " ..... 2 11 047895 Conveyor Post ................. I (Used before Serial No. 3212) 650060 Hex.Hd.Cap Screw 3/8 xl ....... 6 33 051404 Scale Mounting Screw 5/16 x 1 Gr. 5 .. 2 (Used before Serial No. 3212) (6) 3/8 HN 653018 - (6) 3/8 PW 654006 (6) 3/8 LW 654030 34 052010 Scale Axle Support .............. 2 12 047900 Conveyor Post Brace ............. 1 650062 Hex.Hd.Cap Screw 1/2 x 3-1/4 .... 8 650104 Hex.Hd.Cap Screw 1/2 xl ....... 1 650122 Hex.Hd.Cap Screw 1/2 x 3-1/4 .... 2 650119 Hex.Hd.Cap Screw 1/2 x 2-3/4 .... 1 (8) 3/8 HN 653010 _(2) 1/2 HN 653018 (2) 1/2 HN 653018 - (1) 1/2 PW 654009 (4) 1/2 PW 654009 _(8) 3/8 LW 654026 (2) 1/2 LW 654030 (2) 1/2 LW 654030 13 047901 Conveyor Rest. ................ 1 35 052014 Scale Spindle .................. 2 650122 Hex.Hd.Cap Screw 1/2 x 3-1/4 .... 2 655013 Cotter Pin 1/8 x 2............. 2 (2) 7/8 NF SN 653102 (2) 1/2 HLN 653077 - (2) 1/2 PW 654009 14 048059 Grease Seal ................... 2 36 052016 Drawbar Support - Upper .......... 1 15 048060 Drop Center Wheel ............. 2 650406 Hex.Hd.Cap Screw 3/4 x 4-1/2 Gr.5: 2 (For 11.00 x 15 Tires) (2) 3/4 HN 653026 _(2) 3/4 LW 654034 16 04806_6 Screen Support ................ 1 37 052018 Drawbar Support - Lower.......... 1 650025 Hex.Hd.Cap Screw 5/16 x 3/4 .... 5 38 052019 Drawbar Support Cover ........... 1 (5) 5/16 HN 653007 - (5) 5/16 LW 654024 39 052023 Drawbar Scale Reinforcement ....... 1 17 048067 Brace ....................... 1 40 052036 Shim ....................... 4 18 048068 Screen Stop ................... 2 41 052050 Drawbar Mounting Pad ........... 2 650028 Hex.Hd.Cap Screw 5/16 xl ...... 4 42 052051 Scale Indicator ................. 1 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 43 052052 Power Cord ................... 1 19 048740 Drawbar ..................... 1 44 052053 Mounting Bracket. .............. 1 (Used before Serial No. 2611) 45 052055 Ind'lca tor Ad ap ter PI ug .......... . 1 051596 Drawbar ..................... 1 46 052137 Scale Mounting ................ 1 (Used after Serial No. 2610) (Used before Serial No. 3212) 650104 Hex.Hd.Cap Screw 1/2 x 1 ...... 12 47 052140 Mounting Clamp................ 2 650106 Hex.Hd.Cap Screw 1/2 x 1-1/4 .... 4 (Used before Serial No. 3212) (1J» 1/2 HN 653018 - (16) 1/2 LW 654030 48 058615 Insulation Clamp ............ .' .. 1 20 048745 Main Frame ................... 1 (Used after Serial No. 6218) (Used before Serial No. 2611) 49 058616 Insulation Clamp ............... 1 655013 Cotter Pin 1/2 x 2 ............ 2 (Used after Serial No. 6218) 051419 Main Frame ................... 1 50 600798 Female Power Connector .......... 1 (Used after Serial No. 2610) 650013 Cotter Pin 1/8 x 2 ............ 2 650062 Hex.Hd.Cap Screw 3/8 x 1-1/4 .... 4 650106 Hex.Hd.Cap Screw 1/2 x 1-1/4 .... 8 (4) 3/8 HN 653010 - (8) 1/2 HN 653018 ATo Service Jack Latch, Order Latch Service Kit (4) 3/8 PW 654006 - (8) 1/2 PW 654009 Number 620009: (4) 3/8 LW 654026 - (8) 1/2 LW 654030 For Replacement, Order 051908 e/One 051909 and One 052340.

21 049242 Washer ...................... 2 (Used before Serial No. 2611) B To Service Jack Latch, Order Latch Service Kit 22 520054 Bearing Cup ........... '.' ..... 2 'Number 900989.

23 520201 Bearing Cone. . . . . . . . . . ........ 2 C For Replacement, Order 051419 w/(2) M12234, (2) 24 550041 Wheel Bolt .................. 12 (2) 051609, (8) 650106, (2) 650406, (8) 654030 25 550075 Dust Cap..................... 2 and (2) 654034.

7

120MX - TANK and HOPPER _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __

29 45 10

22

~

~28

~12

"'-58 43

~31 20

~/ 42

y~

39W

.. / ....

16

I 49

40

C

41

35 Used Before Serial No. 2611

B

li///// .

47--t

i

11

Q- 21

---:._ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 120MX - TANK and HOPPER No. Req.

Ref. No.

Dust Collector Elbow ......... .

(Used before Serial No. 2611) 051587 Dust Collector Elbow .......... 1 (Used after Serial No. 2610) 17H163A Auger Seal. . . . . . . . . . . . . . . . .. 1 17H179A Hopper Guard Clip .. . . . . . . . . .. 2 650023 Hex. Hd. Cap Screw 5/16 x5/8.. 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 17H180A Hopper Guard Catch .......... 1 650023 Hex. Hd. Cap Screw 5/16 x 5/8.. 1 (1) 5/16 HLN 653073 17H190A Clean-Out Cover Gasket ....... .

17H338 Hopper Cover Catch ......... .

650028 Hex. Hd. Cap Screw 5/16 x l . . 1 (1) 5/16 HN 653007 - (1) 5/16 HLN 653073 (1) 5/16 PW 654004 17H394 Hopper Cover Hinge .......... 1 650267 Truss Head Screw 5/16 x 5/8 .. 8 (8) 5/16 HN 653007 - (8) 5/16 LW 654024 17H418 Washer. . . . . . . . . . . . . . . . . . .. 1 17H419 Set Collar .................. 1 650201 Soc. Hd. Set Screw 5/16 x 5/16.. 2 H474 Cover Hold-Down Spring .. . . . . .. 1 650005 Hex. Hd. Cap Screw 1/4 x 3/4 .. 2 (2) 1/4 HLN 653071 - (2) 1/4 PW 654002 H8228 Outlet Cover Hinge . . . . . . . . . . . .

650267 Truss Head Screw 5/16 x 5/8 .. 5 (5) 5/16 HN 653007 - (5) 5/16 LW 654024 B1l335 Bearing Retainer . . . . . . . . . . .. 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 2 (2) 5/16 HN 653007 - (2) 1/4 PW 654002 (2) 5/16 LW 654024 040126 Inspection Window . . . . . . . . . . .. 2 040127 Window Gasket .............. 2 040184 Slide Control .. . . . . . . . . . . . . .. 1 650201 Soc. Hd. Set Screw 5/16 x 5/16.. 2 040197 Inspection Window Frame ...... 2 040258 Cover Spacer ................ 1 040271 Mixer Cover Clip . . . . . . . . . . .. 4 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 040272 Shut-Off Slide .............. 1 040274 Crank Plate ................ 2 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 PW 654004 (4) 5/16 LW 654024 040275 Outlet Cover ............... .

040276 Mixer Auger Support ......... .

650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 040292 Concentrate Hopper Cover .... .. 1 040294 Hopper Guard .............. 1 040310 Mixer Paddle ................ 2 040311 Agitator Paddle .............. 1 040316 Clean-Out Cover ............ " 1 040317 Slide Control Crank . . . . . . . . .. 2 040319 Conveyor Hanger Arm . . . . . . . . .. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 3 (3) 5/16 HN 653007 - (3) 5/16 LW 654024 040460 Crank Bracket - Front . . . . . . . . .. 1 650269 Truss Head Screw 5/16 x 3/4 .. "2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 040461 Crank Bracket - Rear .......... 2 650269 Truss Head Screw 5/16 x 3/4 .. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024

32

Ref. No.

Part No.

1

6H14D

2 3

4 5 6

7 8 9 10 11 12

13 14 15 16 17 18 19 20

21 22 23 24 25 26 27 28 29 30 31

Part Name

33

34

35 36 37 38

39 40

41 42

43

45 46 47

48 49

50

Part No.

Part Name

No. Req.

042054 Trough Cover . . . . . . . . . . . . . . .. 1 650023 Hex. Hd. Cap Screw 5/16 x 5/8.. 8 (2) 5/16 HN 653007 - (8) 5/16 PW 654004 (2) 5/16 LW 654024 042137 Mixer Cover - Right ........ " 1 650003 Hex. Hd. Cap Screw 1/4 x 5/8 .. 16 (16)1/4 HN 653005 - (16) 1/4 PW 6.54002 (16) 1/4 LW 654022 042139 Mixer Cover - Left ............ 1 650003 Hex. Hd. Cap Screw 1/4 x 5/8 " 15 (15) 1/4 HN 653005 - (15) 1/4 PW 654002 (15) 1/4 LW 654022 042373 Sealer Plate .......... -...... 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 044674 Spline Coupling ..... ,. . . . . . . .. 1 047687 Discharge Conveyor . . . . . . . . .. 1 655533 Woodruff Key 5/16 x 1 HRD . .. 1 047737 Mixer Cover - Center .......... 1 650003 Hex. Hd. Cap Screw 1/4 x 5/8 .. 8 (8) 1/4 HN 653005 - (4) 5/16 WN 653094 (8) 1/4 PW 654002 - (8) 1/4 LW 654022 047738 Mixer Tube Guide ............ 3 655016 Cotter Pin 3/16 x l . . . . . . .. 3 (6) 1/2 HN 653018 - (3) 1/2 PW 654009 047829 Dust Collector Clamp .......... 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 2 (3) 5/16 HN 653007 - (2) 5/16 PW 654004 (3) 5/16 LW 654024 047832 Blower Pipe (27%) ............ 1 (Used before Serial No. 2611) 047838 Mixer Tube. . . . . . . . . . . . . . . . .. 1 (Used before Serial No. 6226) 058637 Mixer Tube. . . . . . . . . . . . . . . . .. 1 (Used after Serial No. 6225) 650025 Hex.Hd.Cap Screw 5/16 x 3/4. . .. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 048018 Ladder. . . . . . . . . . . . . . . . . . . " 1 650025 Hex.Hd.Cap Screw 5/16 x 3/4. . .. 2 650028 Hex.Hd.Cap Screw 5/16 xl. . . .. 2 (4) 5/16 HN 653007 - (2) 5/16 PW 654004 (4) 3/8 LW 654026 049079 Mixer Cover lid. . . . . . . . . . . . . .. 1 049086 Cover Seal . . . . . . . . . . . . . . . . . . 1 049093 Mixer Auger (Includes Two 040310 and One 040311) 650060 Hex.Hd.Cap Screw 3/8 xl. . . . .. 4 650106 Hex.Hd.Cap Screw 1/2 x 1-1/4. .. 2 (4) 3/8 HN 653010 - (2) 1/2 HN 653018 (4) 3/8 LW 654026 - (2) 1/2 LW 654030 04911 0 Inlet Pipe . . . . . . . . . . . . . . . . . .. 1 650005 Hex.Hd.Cap Screw 1/4 x 3/4 ... , 4 (4) 1/4 HN 653005 - (8) 1/4 PW 654002 049124 Dust Collector. . . . . . . . . . . . . . .. 1 (Used before Serial No. 2611) 051590 Dust Collector. . . . . . . . . . . . . . . .

(Used after Serial No. 2610) 049136 Mixer Tank. . .. . . . . . . . . . . .. .. 1 650025 Hex.Hd.Cap Screw 5/16 x 3/4. . .. 2 650028 Hex.Hd.Cap Screw 5/16 xl. . . .. 3 650062 Hex.Hd.Cap Screw 3/8 x 1-1/4 . " 8 (4) 5/16 HN 653007 - (8) 3/8 HN 653010 (3) 5/16 PW 654004 - (16) 3/8 PW 654006 (4) 5/16 LW 654024- (8) 3/8 LW 654026

(Parts List Continued On Next Page)

9

120MX - TANK and HOPPER _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ Ref. No. 51

52

53

No. Req.

Ref. No.

Part No.

049138 Intake Trough .............. 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 5 650005 Hex. Hd. Cap Screw 1/4 x 3/4 .. 4 (4) 1/4 HN 653005 - (9) 5/16 HN 653007 (8) 1/4 PW 654002 - (5) 5/16 PW 654004 (4) 1/4 LW 654022 - (9) 5/16 LW 654024 049472 Pivot Bracket . . . . . . . . . . . . . . .. 2 650269 Truss Head Screw 5/16 x 3/4 .. 4 (4) 5/16 HN 653007 - (4) 5/16 PW 654004 (4) 5/16 LW 654024 050161 Pivot Bracket Spacer .......... 2 (Used before Serial No. 2611)

54

051585

Part No.

Part Name

55 56 57 58 59

Part Name

No. Reg.

Blower Outlet ............. .

(Used after Serial No. 2610) 652021 Carriage Bolt 1/4 x 1/2 ......

(4) 1/4 HN 653005 - (4) 1/4 PW 654002 (4) 1/4 LW 654022 052041 Tape .................... " (Used after Serial No. 2610) 052048 Self-Drilling Fastener ..........

(Used after Serial No. 2610) Ball Bearing ................

520063 520084 Bearing Collar ....... . . . . . ..

650340 Spline Coupling Bolt 1/2 x 4 (1) 1/2 HN 653018 - (1) 1/2 LW 654030

4 2 2 1 1 1

120MX - MIXER DRIVE _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ Ref. No. 6

7 8

1\ ~

9

16 ~

f

16 No. Req. Conveyor Drive Sprocket (16T) ..... 1 (Used before Serial No. 3458) H8016 Conveyor Drive Sprocket (20T) ..... 1 (Used after Serial No. 3457) 650210 Soc.Hd.Set Screw 3/8 x 5/16 ... 1 H275 Bearing Retainer ............... 4 652026 Carriage Bolt 5/16 x 3/4 ........ 6 (6) 5/16 HN 653007 - (6) 5/16 LW 654024 H7838 Pl Bearing Retainer .............. .4 (Used before Serial No. 2611) H8334 Bearing Retainer ............... 4 (Used after Serial No. 2610) 652047 Carriage Bolt 3/8 x 1. .......... 6 (6) 3/8 HN 653010 - (6) 3/8 LW 654026 H7846 Bearing Retainer ............... 2 652029 Carriage Bolt 5/16 xL ......... 3 (3) 5/16 HN 653007· (3) S/16 LW 654024 H8254 Chain Tightener Sprocket (17T) ..... 1 650150 Hex.Hd.Cap Screw 5/16 x 2·3/4 ... 1 (1) 5/8 HN 653021· (3) 5/8 PW 654012 (1) 5/8 LW 654032 17H185

2

3

4

5

10

17 18

19 20

21 22 23 24

Part No. VI01l7 B1l221 040638

No. Part Name Req. Intake Conveyor Key 5/16 x 5/16 x 4 .1 Driven Sprocket Key 5/16 x 5/16 x 2 .2 Universal Joint Key 1/4 x 1/4 x 1-1/4 .2 (One req'd before Serial No. 2611) 044226B Universal Joint. ................ 1 570004 Grease Fitting ............... 2 650203 Soc.Hd.Set Screw 5/16 x 3/8 ..... 2 650206 Soc.Hd.Set Screw 5/16 x 1/2 ..... 2 047907 Intake Conveyor................ 1 047937 Sprocket (20T -32T) ............. 1 650212 Soc.Hd.Set Screw 3/8 x 3/8 ...... 1 650214 Soc.Hd.Set Screw 3/8 x 1/2 ...... 1 047941 Mixer Drive Shaft 1-1/4 x 39-3/16 .... 1 047957 Bearing Bracket ................ 1 650028 Hex.Hd.Cap Screw 5/16 xl ...... 4 (4) 5/16 HN 653007 - (8) 5/16 PW 654004 (4) 5/16 LW 654024 047995 Guard Bracket - Right Upper ....... 1 047997 Guard Bracket - Right Lower ....... 1 650025 Hex.Hd.Cap Screw 5/16 x 3/4..... 1 650028 Hex.Hd.Cap Screw 5/16 xl ...... 1 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654004 049100 Mixer Drive Guard .............. 1 650012 Hex.Hd.Cap Screw 1/4 x 1-1/2 .... 2 650028 Hex.Hd.Cap Screw 5/16 xl ...... 1 (2) 1/4 HN 653005 - (7) 5/16 HN 653007 (1) 5/16 HLN 653073 - (2) 1/4 LW 654022 (7) 5/16 LW 654024 049104 PTO Shield ................... 1 049105 Guard Bracket - Left Lower ........ 1 (Used before Serial No. 2611) 052038 Guard Bracket· Left Lower ........ 1 (Used after Serial No. 2610) 650025 Hex.Hd.Cap Screw 5/16 x 3/4 .... 2 (2) 5/16 HN 653007· (2) 5/16 LW 654024 049106 Guard Cover .................. 1 500082 Chain (No. 50) of 70 Links Including One (500057) Connector Link .... 1 (Used before Serial No. 3458) 500179 Chain (No. 50) of 72 Links Including One (500057) Connector Link .... 1 (Used after Serial No. 3457) 520063 Ball Bearing ................... 3 520065 Ball Bearing ................... 2 520084 Bearing Collar . . . . . . . . . . . . . . . . . 2 520085 Bearing Collar ................. 2 A For Replacement, Order H8334.

• See Pap;e 70 for Universal Drive Service Parts.

_ _ _ _ _ _ _ _ _ _ _ _ _ _ 120MX - POWER TAKE-OFF DRIVE ADDITIONAL PARTS REQUIRED FOR 1000 RPM PTD DRIVE

(Used before Serial No. 2611) 18

~

15

~ 10

;.., 'I

44 6

~28

~t.,~' 21,//

.

f1"

' /- 5

)......

. . j ....... '\-<•.. .",;.<.-.

11 \

i\ :\

.;#I/f,"r.~W:;;:;;;;;>

1- \, ", 1

:,,::.

.

":,',

.. ,'

(Parts List Begins On Next Page) WARNING - Order By Part Number - Do Not Use Illustration Reference Numbers

33

.P

ADDITIONAL PARTS REQUIRED FOR 540 RPM PTD DRIVE ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

11

120MX - POWER TAKE-OFF DRIVE _ _ _ _ _ _ _ _ _ _ _ _ __ Ref. No.

Part No.

No. Req.

Part Name

13H24

Clutch Lift Pin

2

13E29

Clutch Spring ............... .

3

13H55

Shim Washer ................

4

4

13E56

Clutch Spacer

1

5

13E60

Driven Sheave Key ........... .

6

13E61 Bearing Housing . . . . . . . . . . . . ..

650206 Soc. Hd. Set Screw 5/16 x 1/2 ..

2 2

7

13E62 Belt Take-Up Screw ....... ;..

(2) 3/4 HN 653026 - (1) 3/4 HJN 653051 (2) 3/4 LW 654014

2

8

17H208

9

D316 Set Collar ................. .

650214 Soc. Hd. Set Screw 3/8 x 1/2 ..

10

H6098A

Clutch Key 3/8 x 3/8 x 1?2 ..... .

11

040012

Mill Driven Sheave (4.8 Dia.)

12

040092 Drive Sheave Clutch ......... .

SoL Soc. Hd. Set Screw 3/8 x 3/8 650213 SoL Soc. Hd. Set Screw 3/8 x 3/4 650217

13

040175

Main Drive· Sprocket (16T) ..... .

(Includes 040179 Bushing)

14

040179

Drive Sprocket Bushing

15

044116

16

17

Safety Flange Key 1/4 x 1/4 x 2 ..

047874

047878

19

047879

20

047880

Part No.

Part Name

21

048098

PTO Drive Shaft 1-5/8 x 40-7/16

22

051963

23

051967

24

051968

25

051969

26

051970

Mill Guard Spacer ............

(Used after Serial No. 2610)

27

500159

Chain (No. 60) of 71 Links Including One (500160) Connector Link and One (500161) Offset Link (Used before Serial No. 2611) Chain (No. 60) of 70 Links Including One (500160) Connector Link and One (500161) Offset Link ....

(Used after Serial No. 2610)

No. Req.

Guard Extension . . . . . . . . . . .. 1 (Used After Serial No. 2610) (2) 5/16 HN 653007 - (2) 5/16 HLN 653073 (4) 5/16 PW 654004 - (2) 5/16 LW 654024

Pivot Bracket - Front ......... .

(Used after Serial No. 2610) 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 650028 Hex. Hd. Cap Screw 5/16 x I " 2 (2) 5/16 HN 653007 - (2) 5/16 HLN 653073 (6) 5/16 PW 654004 - (2)5/16 LW 654024 Guard Bracket - Lower ....... .

(Used after Serial No. 2610)

Pivot Bracket - Rear ......... .

(Used after Serial No. 2610) 652029 Carriage Bolt 5/16 xl ..... . (l) 5/16 HN 653007 - (l) 5/16 LW 654024

500220

2

....... .

047590 Bearing Support ..............

650060 Hex. Hd. Cap Screw 3/8 x l . .

(8) 3/8 HN 653010 - (4) 3/8 PW 654006 (8) 3/8 LW 654026

051971

12

. . . . . . . . . . . . ..

Latch ................... .

(Used after Serial No. 2610) 650339 Rd.Hd.Mach.ScrewNo.1224x1/2 2 (2) No. 1224 HN 653001 (2) No. 1224 LW 654019

051959 18

............... 1

Ref. No.

Mill Drive Guard ........... .

(Used before Serial No. 2611) Mill Drive Guard .. . . . . . . . . ..

(Used after Serial No. 2610) Guard Bracket - Upper ... • . . ..

(Used before Serial No. 2611) Guard Bracket - Upper ....... .

(Used after Serial No. 2610)

1 8

28

520098

Ball Bearing

................

2

29

520099

Bearing Collar

... . . . . . . . . . ..

2

30

520188

Ball Bearing

................

2

31

540007

Retaining Ring

32

540035

Snap Ring ................. .

..............

2

ADDITIONAL PARTS REQUIRED FOR 540 RPM TRACTOR PTO DRIVE ............

1

34 . D316 Set Collar ..................

650214 Soc. Hd. Set Screw 3/8 x 1/2 ..

1 1

33 1 1

Clutch Shifter Pin

.35

H7028

Washer. . . . . . . . . . . . . . . . . . ..

1

36

C14118 Chain Tightener Sprocket (1ST) 650148 Hex. Hd. Cap Screw 5/8 x 2* ..

(1) 5/8 HN 653021 - (4) 5/8 PW 654012 (1) 5/8LW 654032

1 1

37

040011 A

1

Guard Bracket - Lower ....... .

(Used before Serial No. 2611)

Guard Support ............. .

(Used before Serial No. 2611) 051966 Guard Bracket • Front ......... .

(Used after Serial No. 2610) 650028 Hex. Hd. Cap Screw 5/16 xl ... 2 (3) 5/16 HN 653007 • (2) 5/16 PW 654004 (2) 5/16 LW 654024

13E23

053017 38

0400S 7

Mill Drive Sheave (24 Dia.) ......

(Used before Serial No. 3212) Mill Drive Sheave (24 Dia.) ......

(Used after Serial No. 3211) Powerband Belt ............. .

(Parts Lilt Continued On Next Page)

1

_ _ _ _ _ _ _ _ _ _ _ _ _ _120MX - POWER TAKE-OFF DRIVE Ref. No.

Part No.

Part Name

No. Req.

39

040145 Safety Flange ................. 1 650012 Hex.Hd.Cap Screw 1/4 x 1.1/2 .... 1 (1) 1/4 HN 653005· (1) 1/4 LW 654022

40

048291 Chain Tightener Bracket . . . . . . . . . . 1 652026 Carriage Bolt 5/16 x 3/4 ....... .4 (4) 5/16 HN 653007· (4) 5/16 LW 654024

41

048763 Universal Joint w/sq. Shaft ........ 1 570004 Grease Fitting .......... , ..... 1

42

048764 Universal Joint w/sq. Tube ........ 1 570004 Grease Fitting ............... 1 570014 Grease Fitting ............... 1

Ref. No.

Part No.

Part Name

No. Req.

57

048140 Idler Bracket . . . . . . . . . . . . . . . . . . 1 650060 Hex.Hd.Cap Screw 3/8 xl ....... 2 (2) 3/8 HN 653010· (2) 3/8 PW 654006 (2) 3/8 LW 654026

58

048145

59

048764 Universal Joint w/sq. Tube ........ , 1 570004 Grease Fitting . . . . . . . . . . . . . . . 1 570014 Grease Fitting ................ 1

60

048850 D 056147

Additional Parts Required For 1000 RPM Tractor PTO Drive

Jack Shaft 1 x 6 x 9/16 ........... 1

Chain (No. 60) of 48 Links Including One (042299) Connector Link .... 1 (Used before Serial No. 6226) Chain (No. 60) of 48 Links Including One (042299) Connector Link .... 1 (Used after Serial No. 6225)

43

13E24

Clutch Lift Pin ................. 1

61

44

H275 Bearing Retainer .............. .4 650025 Hex.Hd.Cap Screw 5/16 x 3/4..... 3 .652026 Carriage Bolt 5/16 x 3/4......... 3 (6) 5/16 HN 653007· (6) 5/16 LW 654024

049091 Universal Joint w/sq. Shaft ......... 1 570004 Grease Fitting ............... 1

62

049318

63

049319

64

05 1924

Bearing Bracket Shim . . . . . . . . . . . . 2 (Used after Serial No. 2610)

65

056141

Idler Sprocket (l5T) ............ 1 (Used after Serial No. 6225)

66

500225 E

Chain (No. 60) of 52 Links Including One (042299) Connector Link .... 1 (Used before Serial No. 6226) Chain (No. 60) of 52 Links Includirg One (042299) Connector Link .... 1 (Used after Serial No. 6225)

45

H728B

Spacer ...................... 1

46

D932A

Washer ...................... 2 (Used after Serial No. 2610)

47

H7126

Washer .. , ................... 4 (Six req'd. before Serial No. 2611)

48

BIl21

Safety Flange Key 5/16 x 5/16 x 2 ... 1

49

C14070

Washer ...................... 2 (Used after Serial No. 2610)

50

040209

Mill Drive Sheave (13 Dia.) ......... 1

51

040861 8

52

53

Safety Flange .. . . . . . . . . . . . . . . . 1 (Used before Serial No. 6226) 056143 Safety Flange .......... . . . . . . . 1 (Used after Serial No. 6225) 650012 Hex.Hd.Cap Screw 1/4 x 1·1/2 .... 1 (1) 1/4 HN 653005· (1) 1/4 LW 654022

040865 051098

Clutch Shifter Pin ............... 1 (Used before Serial No. 2611) Clutch Shifter Pin ............... 1 (Used after Serial No. 2610)

54

040868

Chain Tightener Sprocket Spacer . . . . 1

55

040875

Powerhand Belt ................ 1

56

048139 Bearing Support ............... 1 650025 Hex.Hd.Cap Screw 5/16 x 3/4..... 4 (4) 5/16 HN 653007· (4) 5/16 PW 654004 (4) 5/16 LW 654024

Bearing Bracket ................ 1 (Used before Serial No. 2611) 051921 Bearing Bracket . . . . . . . . . . . . . . . . 1 (Used after Serial No. 2610) 650060 Hex.Hd.Cap Screw 3/8 xl ....... 2 (2) 3/8 HN 653010· (2) 3/8 PW 654006 (2) 3/8 LW 654026

056148

040864 c

Mixer Drive Sprocket (16T) ........ 1 (Used before Serial No. 6226) 056139 Mixer Drive Sprocket (16T) ........ 1 (Used after Serial No. 6225) 650200 Soc.Head Set Screw 5/16 x 1/4 .... 1 650203 Soc.Head Set Screw 5/16 x 3/8 .... 1

Bearing Support ............... 1 (Used before Serial No. 2611) 051920 Bearing Support ............... 1 (Used after Serial No. 2610) 650109 Hex.Hd.Cap Screw 1/2 x 1·1/2 .... 4 (4) 1/2 HN 653018· (4) 1/2 PW 654009 (4) 1/2 LW 654030

67

520063

Ball Bearing ................... 2

68

520084

Bearing Collar ................. 2

A For Replacement, Order 053017.

8 For Replacement, Order 056143.

c For Replacement, Order 056139.

D For Replacement, Order 056147.

E For Replacement, Order 056148.

NOTE: See Page 70 for Universal Drive Service Parts.

13

120MX ~ UNLOADING CONVEYOR __________________

Used before Serial No. 2611

~2

•

~

~ 28

33---t1!J

2r

(01

~

Used before Serial No. 4897

5-V~~

I

I 32

~

~~ .

20

37~;'

~

"AI

~2 d

~~.

ll~t~ ~~

23

13

11\--8

3&~~

31

Part No. 2

3 Ref. No. 1

14

Part No.

Part Name

No. Req.

6H112 Conveyor Bearing ............... 1 570003 Grease Fitting ; .............. 1 650062 Hex.Hd.Cap Screw 3/8 x 1-1/4 .... 2 (2) 3/8 HN 653010 - (2) 3/8 LW 654026

4 5

7H115

28

Part Name

No. Req.

Conveyor Cap Hinge ............. 1 (Used before Serial No. 2611) 17H333 Conveyor Cap Hinge ............. 1 (USed after Serial No. 2610) 650001 Hex.Hd.Cap Screw 1/4 x 1/2 ..... 3 650021 Hex.Hd.Cap Screw 5/16 x 1/2 .... 2 (3) 1/4 HN 653005 - (2) 5/16 HN 653007 (3) 1/4 PW 654002 - (2) 5/16 PW 654004 (3) 1/4 LW 654022 - (2) 5/16 LW 654024 6H158 Stop Dog . . . . . . . . . . . . . . . . . . . . 1 (Used before Serial No. 2611) 051936 StoE_Ratchet. ................. 1 (Used after Serial No. 2610) 6H160 Conveyor Collar Spacer ........... 2 (Three req'd before Serial No. 2611) 6H165AA Conveyor Lift Pulley ............. 1 (Used before Serial No. 4897)

_______________________________ 120MX Ref. No. 6

7 8 9 10 11 12 13

14 15 16 17

18

19 20

21

22

23 24 25

Part No.

Part Name

No. Req.

Hanger Cord Pulley . . . . . . . . . . . . . 1 (Used before Serial No. 3212) 052828 Hanger Cord Pulley . . . . . . . . . . . . . 1 (Used after Serial No. and before Serial No. 4897) 053900 Lift Pulley . . . . . . . . . . . . . . . . . . . 2 (Used after Serial No. 4896) Idler Gear Spacer . . . . . . . . . . . . . . . 1 6H178 Drain Plug ...... . . . . . . . . . . . .. I 6H183 Washer . . . . . . . . . . . . . . . . . . . . . . 4 D932A Shim Washer . . . . . . . . . . . . . . . . . . 2 H7126 Washer . . . . . . . . . . . . . . . . . . . . . . I H7163 Washer . . . . . . . . . . . . . . . . . . . . . . 1 H8054 (Used after Serial No. 3211) Conveyor Bearing. . . . . . . . . . . . . . . 1 D9048 (Used before Serial No. 3212) 570003 Grease Fitting . . . . . . . . . . . . . . . I 053891 Ball Bearing . . . . . . . . . . . . . . . . . . 1 (Used after Serial No. 3211) Ul 0 102 Idler Gear Bushing . . . . . . . . . . . . .. 2 U10104 Set Collar . . . . . . . . . . . . . . . . . . . . 1 650196 Soc.Hd.Set Screw 1/4 x 5/16 ..... 1 650201 Soc.Hd.Set Screw 5/16 x 5/16 .... 1 B11162 Shim Washer . . . . . . . . . . . . . . . . . . 3 BI1335 Bearing Retainer . . . . . . . . . . . . . . . 2 (Used after Serial No. 3211) 650025 Hex.Hd.Cap Screw 5/16 x 3/4..... 2 (2J 5/16 HN 653007 - (2) 5/16 LW 654024 040117 Conveyor Driven Gear (17T) ....... 1 (Used before Serial No. 3212) 650204 S-L Soc. Hd.Set Screw 5/16 x 3/8 .. 2 053938 Conveyor Driven Gear (17T). . . . . . . . 1 (Used after Serial No. 3211) 650204 S-L Soc.Hd.Set Screw 5/16 x 3/8 .. 2 040118 Idler Gear (17T) . . . . . . . . . . . . . . . 1 (Includes Two UlOI02 Bushings) 570002 Grease Fitting . . . . . . . . . . . . . . . 1 040323 Hanger Cord Hook .

1 (Used before Serial No. 4897) 056145 Pulley Bracket . . . . . . . . . . . . . . . . . 1 (Used after Serial No. 4896) 650341 Hex.Hd.Cap Screw 5/16 x 1-3/4 GrS. 1 650487 Hex.Hd.Cap Screw 5/16 x 1 Gr. 5 .. 1 . (2) 5/16 HLN 653015 - (1) 5/16 PW 654004 040219 Conveyor Housing . . . . . . . . . . . . . . 1 (Used before Serial No. 2611) 051928 0 Conveyor Housing . . . . . . . . . . . . . . 1 (Used after Serial No. 2610 and before Serial No. 3212) 053833 Conveyor Housing . . . . . . . . . . . . . . 1 (Used after Serial No. 3211) 040229 Conveyor Housing End . . . . . ...... 1 (Used before Serial No. 2611) 051978 Conveyor Housing End . . . . . . . . . . . 1 (Used after Serial No. 2610) 650028 Hex.Hd.Cap Screw 5/16 xl ...... 4 (4) 5/16 HN 653007 - (8) 5/16 PW 654004 (4) 5/16 LW654024 040234 Conveyor Gear Guard . . . . . . . . .... 1 650023 Hex.Hd.Cap Screw 5/16 x 5/8 ..... 4 (4) 5/16 HN 653007 - (2) 5/16 LW 654024 040244 Conveyor Collar . . . . . . . . . . . . . . . 1 650047 Hex.Hd.Cap Screw 5/16 x 4 ...... 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 040245 Conveyor Ratchet Bracket - Right .... 1 (Used before Serial No. 2611) 051940 Conveyor Ratchet Bracket . . . . . . . . . 2 (Used after Serial No. 2610) 6H 166AB

Ref. No.

Part No.

26

O4Q246

27 28

29 30 31

32

33

34

35

36

37 38

UNLOADING CONVEYOR Part Name

No. Req.

Conveyor Ratchet Bracket - Left ..... 1 (Used before Serial No. 2611) 040278 Ratchet . . . . . . . . . . . . . . . . . . '.' . 1 040323 Conveyor Cap . . . . . . . . . . . . . . . . . 1 (Used before Serial No. 2611) 051980 Conveyor Cap . . . . . . . . . . . . . . . . . 1 (Used after Serial No. 2610, and before Serial No. 4897) 058783 Conveyor Cap . . . . . . . . . . . . . . . . . 1 (Used after Serial No. 4896) 040445 Hinge Spacer. . . . . . . . . . . . . . . . . . 2 (Used before Serial No. 2611) 040459 Conveyor Gear Shield . . . . . . . . . . . . 1 650005 Hex.Hd.Cap Screw 1/4 x 3/4 ..... 3 1/4 HLN 653071 - (3) 1/4 PW 654002 040517 Conveyor Housing Base . . . . . . . . . . . 1 (Used before Serial No. 3212) 053846 Conveyor Housing Base . . . . . . . . . . . 1 (Used after Serial No. 3211) 040644 Conveyor Hanger Cord (32 ft.) ...... 1 (Used before Serial No. 4897) 053906 Conveyor Cable (30 ft.) . . . . . . . . . . . 1 (Used after Serial No. 4896) 040908 U-Bolt . . . . . . . . . . . . . . . . . . . . . . 1 (Used after Serial No. 3211, and before Serial No. 4897) 056146 Swivel Pulley Bracket . . . . . . . . . . . . I (Used after Serial No. 4896) 570014 Grease Fitting . . . . . . . . . . . . . . . 1 650341 Hex.Hd.Cap Screw 5/16 x 1-3/4 GrS 1 650545 Hex.Hd.Cap Screw 5/16 x 1-1/4Gr.5. 1 650594 Hex.Hd.Cap Screw 1/2 x 3-1/4 Gr.5. 1 (2) 5/16 HLN 653075 - (1) 1/2 HN 653018 (1) 1/2 HJN 653044 - (2) 1/2 PW 654009 (1) 1/2 LW 654030 048111 Conveyor Shaft End 1 x 12-3/4 ..... 1 (Used before Serial No. 2611) 051935 Conveyor Shaft End 1 x 15 . . . . . . . . 1 (Used after Serial No. 2610) 048292 Conveyor . . . . . . . . . . . . . . . . . . . . 1 (Used before Serial No. 2611) 655533 Woodruff Key 5/16 xl HRD ..... 1 051925 Conveyor . . . . . . . . . . . . . . . . . . . . 1 (Used after Serial No. 2610 and before Serial No. 655533 Woodruff Key 5/16 xl HRD ..... 1 058700 Conveyor . . . . . . . . . . . . . . . . . . . . 1 (Used after Serial No. 650028 Cotter Pin 1/4 x 1-1/2 . . . . . . . . . 1 655533 Woodruff Key 5/16 xl HRD ..... 1 051982 Conveyor Assembled . . . . . . . . . . . . 1 (Used after Serial No. 2610 and before Serial No. 058699 Conveyor Assembled . . . . . . . . . . . . 1 (Used after Serial No. 052046 Plastic Plug . . . . . . . . . . . . . . . . . . . 3 (Used after Serial No. 2610) 052120 Spout Extension . . . . . . . . . . . . . . . 1 (Used after Serial No. 2610) 650267 Truss Head Screw 5/16 x 5/8 ..... 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024

(3J

A For Replacement, Order 901037.

B For Replacement, Order 052828.

C For Replacement, Order 053938.

o For Replacement, Order 053833 w/One 053848.

E For Replacement;Order 053846 w/One 053848.

15

120MX - CONVEYOR DRIVE _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ Used before Serial No. 2611

44

9

\ - 5,.33

~

••

il

'

/2

r6

-30 ®-13

8--5 54

33~ ~ .. ()

3

•

,""" _,'

~~ ~ 1#

.

11

.... 32 ,,~ ~ ~

64'--.

61

""'i

34~

,,-it 37

14

"--..

.1

1

~46

2h~

~

51

:

I, ~

~

~ ~

16~

~,//

/

64

52

63

~

.

.~

"

,;}v?

l~"< \~

~tif~"

56

t~~'~21~' ~~, 42-t:l ~ ~ .

II

~

~

Y

~~

~7

7

~~31

35

~

39

•

•

~O

~

/

\~

~7' .~

~ ~ ~ ~3 -

4 '{ -

64

"'I &:~

11

6D

48

~

15

0"16

%~

24~21 8>4 13---®

@-43

. WARNING • Order By Part Number - Do Not Use Illustration Reference Numbers

18

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

16

36

S-l/

26 ~

19

~'

~\ II

'fJl'vJ

~

~

@.o58 ~/ ~ --A5

,,~ U"

44

6~~.

-,

.~VCI \~

I,

•

r~

~

56

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 120MX . CONVEYOR DRIVE

No. Req.

Ref. No.

Part No.

7H73

Drive Gear Shim ............... 2

22

BI1028

Bearing Bracket Shim (16 Ga.) ...... ·2 (Used before Serial No. 2611)

2

6H130

Conveyor Pivot Bearing ........... 2 23

BII028A

3

6H136A

Pivot Retainer Spacer ............ 1

Bearing Bracket Shim (20 Ga.) . , ..... 2 (Used before SerialNo. 2611)

4

17H140

Shim Washer .................. 5

24

5

6H 171 Brake Drum. . . . . . . . . . . . . . . . . . . 1 650060 Hex.Hd.Cap Screw 3/8 xl ....... 4 (4) 3/8 LW 654026

B11029A Bearing Retainer ................. 6 652025 Carriage Bolt 5/16 x 3/4 ......... 4 (4).5/16 HN 653007 - (4) 5/16 LW 654024

25

Bl1156

6

17Hl85

Conveyor Drive Sprocket (I6T) ..... 1 (Two req'd. before Serial No. 2611) 650210 Soc.Hd.Set Screw 3/8 x 5/16 ..... 1

26

Bl1335 Bearing Retainer...................2 652026 Carriage Bolt 5/16 x 3/4 ......... 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024

7

H217

Shift Lever Dog ................ 1

27

M12074

Shifter Lock Space!: ............... 2

8

9H247

Bearing Bushing . . . . . . . . . . . . . . . . 1

28

040015

Conveyor Drive Gear ............... 2 (Used before Serial No. 2611)

9

9H251

Chain Tightener Block ........... 1 (Used before Serial No. 2611) Chain Tightener Block ........... 1 (Used after Serial No. 2610 and before Serial No. 6226) Spacer ...................... 1 (Used after Serial No. 6225) Shifter Spring ................. 1

29

040016

Sliding Clutch .................... 1

30

040119 Conveyor Drive Gear (17T) ......... .1 650207 SoL Soc.Hd.Set Screw 5/16 x 1/2... .1

31

040214 Shifter Lock . . . . . . . . . . . .. . . . . . 1 650066 Hex.Hd.Cap Screw 3/8 x 1-3/4 .... 2 (2) 3/8 HN 653010 - (2) 3/8 PW 654006 (2) 3/8 LW 654026

32

040242 Conveyor Pivot Bracket - Right ..... 1 650028 Hex.Hd.Cap Screw 5/16 xl ...... 2 650106 Hex.Hd.Cap Screw 1/2 x 1-1/4 .... 1 (2) 5/16 HN 653007 - (1) 1/2 HN 653018 (2) 1/2 HLN 653077 - (2) 1/4 PW 654009 (2) 5/16LW 654024

33

040243 Conveyor Pivot Bracket - Left ...... 1 650028 Hex.Hd.Cap Screw 5/16 xl ..... 2 650106 Hex.Hd.Cap Screw 1/2 x 1-1/4 .... 1 (2) 5/16 HN 653077 - (1) 1/2 HN 653018 (2) 1/2 HLN 653077 - (2) 1/4 PW 654009 (2) 5/!6 LW 654024

Ref. No.

Part No.

052436 M12070

Part Name

10

A262

11

H275 Bearing Retainer ............... 4 652026 Carriage Bolt 5/16 x 3/4 ........ 6 (6) 5/16 HN 653007 - (6) 5/16 LW 654024

Part Name

No. Req.

Drive Sprocket Key 5/16x 5/16 x 1-1/41

12

17H361

Washer ...................... 1 (Used after Serial No. 6225)

13

D932A

Washer ...................... 6

14

0936 Shifter Clamp - Right ............ 1 570002 Grease Fitting ............... 1 .650028 Hex.Hd.Cap Screw 5/16 xl ...... 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024

15

D937

Shifter Clamp - Left ............. 1

16

H6053

Shifter Pivot Bushing ............ 5

34

040273 Set Collar .................... 2 650200 Soc.Hd.Set Screw 5/16 x 1/4 ..... 2

17

H7125 Bearing Retainer ............... 2 652026 Carriage Bolt 5/16 x 3/4 ........ 4 (4) 5/16 HN 653007 - (4)5/16 LW 654024

35

040431 Clutch Shifter ............... : . 1 650029 Hex.Hd.Cap Screw 5/16 x 1-1/4 ... 1 (1) 5/16 HN 653007 - (1) 5/16 PW 654004 (1) 5/16 LW 654024

36

040727

Pivot Bracket Spacer ............. 2

37

040728

Drive Gear Spacer .............. 1

38

042115 Conveyor Shaft - Rear 1 x 24-1/4 .... 1 655020 Cotter Pin 3/16 x 1-1/2 ......... 1 655533 Woodruff Key 5/16 xl HRD ..... 1

39

042118 Conveyor Drive Guard ........... 1 650025 Hex.Hd.Cap Screw 5/16 x 3/4 .... 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024

18

H8016

Sprocket (20T) ................ 1 (Used after Serial No. 2610) 650201 Soc.Hd.Set Screw 5/16 x 5/16 .... 1

19

H8315 Set Collar .................... 3 650195 Soc.Hd.Set Screw 1/4 x 1/4 ...... 3

20

D9048C

21

Bearing...................... 3 (Includes D9139A Bushing) 570012 Grease Fitting ............... 2 570001 Grease Fitting ................ 1

D9139A

Bearing Bushing ................ 3

(Parts List Continued On Next Page)

17

120MX· CONVEYOR DRIVE

Ref. No.

Part No.

Part Name

No. Req.

40

042121 Gear Cover ................... 1 (4) 5/16 HN 653007 - (4) 5/16 PW 654004 (4) 5/16 LW 654024

41

042123 Conveyor Drive Shaft 1 x 23-1/2 ..... 1 570004 Grease Fitting ............... 1 655020 Cotter Pin 3/16 x 1-1/2 ......... 1 655533 Woodruff Key 5/16 xl HRD ..... 1

42

042166 500069

047030

Chain (No. 50) of 42 Unks Including One (500057) Connector Link .... 1 (Used before Serial No. 2611) Chain (No. 50) of 44 Unks Including One (500057) Connector Link .... 1 (Used after Serial No. 2610 and before Serial No. 3212) Chain (No. 50) of 45 Unks Including One (500057) Connector Unk .... 1 (Used after Serial No. 3211)

No. Req.

Ref. No.

Part No.

51

047887

52

047889 Shifter Extension ............... I 650028 Hex.Hd.Cap Screw 5/16 x I ...... I 650029 Hex.Hd.Cap Screw 5/16 x 1-1/4 ... I (2) 5/16 HLN 653073 - (2) 5/16 PW 654004

53

048020 Brake Lever ................... I (I) 3/8 HLN 653075

54

048026

Spacer ...................... I

55

048116

Bearing Bracket Shim ............ 2 (Used before Serial No. 2611)

56

048135

Idler Bracket. ................. I (Used before Serial No. 6226) 058664 Chain Tightener Bracket .......... I (Used after Serial No. 6225) 652049 Carriage Bolt 3/8 x 1-1/2 ........ 1 (1) 3/8 HN 653010 - (I) 3/8 LW 654026

Part Name

Bearing Bracket ................ 1 (Used before Serial No. 2611) 051998 Bearing Bracket ... _ ............ 1 (Used after Serial No. 2610) 652029 Carriage Bolt 5/16 x I .......... 4 (4) 5/16 HN 653007 - (4)-5/16 PW 654004 (4) 5/16 LW 654024

43

042239

Transfer Gear (l4T) ............. 2

44

042350 Brake Band ................... 2 652047 Carriage Bolt 3/8 xl. .......... 1 (1) 3/8 HLN 653075

45

042359 Brake Bracket ................. 1 652026 Carriage Bolt 5/16 x 3/4 ........ 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024

57

048138

Conveyor Pivot . . . . ............ I

46

042630

Clutch ...................... 1

58

049426

Pivot Retainer Spacer . . . . . . . . . . . . I

47

047781

Conveyor Support .............. 1 (Includes One 9H257 Bushing) 650060 Hex.Hd.Cap Screw 3/8 xl ....... 2 650106 Hex.Hd.Cap Screw 1/2 x 1-1/4 .... 8 (8) 5/16 HN 653007 • (4) 3/8HN 653010 (8) 1/2 HN 653018 - (4) 3/8 PW 654006 (8) 1/2 PW 654009· (8) 5/16 LW 654024 (2) 3/8 LW 654026· (8) 1/2 LW 654030

59

051605

Driven Gear (l6T) . . . . . . . . . . . . . . 1 (Used after Serial No. 2610)

60

051607

Drive Gear (20T) . . . . . . . . . . . . . . . 1 (Used after Serial No. 2610)

61

051999

62

052000

63

520063

Ball Bearing ................... 1

64

520084

Bearing Collar . . . . . . . . . . . . . . . . . 1

48

047789 Conveyor Drive Shaft 1 x 28·9/16 .... 1 655507 Woodruff Key 5/16 xl ......... 2 655512 Tapered Key 5/16 xl .......... 1

49

04 7790 Shifter Handle ................. 1 650028 Hex.Hd.Cap Screw 5/16 xl ...... 2 (2) 5/16 HLN 653073· (2) 5/16 PW 654004

50

04 7886 Shifter Bracket . . . . . . . . . . . . . . . . 1 650028 Hex.Hd.Cap Screw 5/16 xl ...... 1 650062 Hex.Hd.Cap Screw 3/8 x 1.1/4 .... 2 (1) 5/16 HN 653007· (2) 3/8 HN 653010 (4) 5/16 PW 654004· (2) 3/8 PW 654006 (1) 5/16 LW 654024· (2) 3/8 LW 654026

Support Bracket - Right. .......... 1 (Used after Serial No. 2610) 650025 Hex.Hd.Cap Screw 5/16 x 3/4..... 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024

Support Bracket· Left ........... 1 (Used after Serial No. 2610) 650025 Hex.Hd.Cap Screw 5/16 x 3/4 .... 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

18

120MX - CONVEYOR DRIVE (USED AFTER SERIAL #6926*) _ _ _ __ • .2 *Refer to existing pages for 120MX Conveyor Drive parts before Serial #6927.

10~

®--8

&/

11~ 6 __ L'd'

..

4·

).

(}-5 3

43

1

l}--14

42

~l 22

44

H{ai>a 8.c=::8

53

@--18

@-39

36

WARNING • Order By Part Number • Do Not Use Illustratit)n Reference Numbers ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

.8.

120MX - CONVEYOR DRIVE (USED AFTER SERIAL #6926*) No. Req.

Ref. No.

Drive Gear Shim ................ 2 Conveyor Drive Gear (17T) ....... I SHSS-SL 5/16 x 5/16 ......... I Conveyor Pivot ................. I Conveyor Pivot Right Bracket .... I . HHCS 5/16 x I (HN, LW) ..... 2 HHCS 1/2 x 1-1/4 (HLN,2PW) ................ I Conveyor Pivot Bearing .......... 2 6HI30 Conveyor Pivot Left Bracket ...... I 6HI35B HHCS 5/16 x I (HN, LW) ..... 2 650487 650106 H H CS I / 2 x I-I / 4 (HLN,2PW) ................

Pivot Bearing Spacer ............ I 6HI36A Shim Washer ............. As Req'd 17HI40 Brake Drum .................... I 6HI71 HHCS 3/8 x I (LW) ........... 4 650490 Brake Band ..................... 2 6HI72 (2) 5/16 HLN Pivot Bracket Spacer ............ 6 6HI82 Conveyor Drive Sprocket. ........ I 17HI85 SHSS 3/8 x 5/ 16 .............. I 650210 Shift Lever Dog ................. I H217 Bearing Bushing ................. I 9H247 Shifter Spring ................... I A262 Bearing Retainer ................ 4 H275 650687 CB 5/ 16 x 3/4 (HN, LW) ....... 6 Washer (Idler) .................. I 17H361 Washer ........................ 6 D932A Shifter Right Clamp ............. I D936 570002 Grease Fitting ................ I 650487 HHCS 5/16 x I (HN, LW) ..... 2 Shifter Left Clamp .............. I D937 H6053 Shifter Pivot Bushing ............ 5 Bearing Retainer ................ 2 H7125 CB 5/ 16 x 3/4 (HN, LW) ....... 4 650687 H8315 Set Collar .......... , ... , ., ..... 2 SHSSI/4xl/4 ............... 2 650195 D9048C Bearing ........................ 3 570001 Grease Fitting ................ I 570012 Grease Fitting ................ 2 D9139A Bearing Bushing ................. 4 BII029A Bearing Retainer ................ 6 650687 CB 5/ 16 x 3/4 (HN, LW) ....... 4 BII156 Drive Sprocket Key 5/16 Sq. x 1-1/4 .............. I Bearing Retainer ................ 2 BII335 CB 5/ 16 x 3/4 (HN, LW) ....... 2 650687 MI2074 Spacer ......................... 2 040016 Sliding Clutch .................. I 040214 Shifter Lock .................... I 650579 HHCS 3/8 x 1-3/4 (HN, LW, PW) .............. 2 Set Collar ...................... 2 040273 650200 SHSS 5/16 x 1/4 .............. 2 Clutch Shifter ................... I 040431 650545 HHCS 5/16 x 1-1/4 (HN, LW, PW) ..............

34 35

Ref. No.

Part No.

I 2

7H73 6HI14D 650202 6HI20E 6HI21E 650487 650106

3 4

5 6

7 8 9 10 II 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

l8b

Part Name

Part No.

Part Name

No. Req.

040728 Drive Gear Spacer. ..............

042115 Conveyor Rear Drive Shaft .......

655020 Cotter Pin 3/ 16 x 1-1/2 ........

655533 Woodruff Key 5/ 16 x I Conveyor Drive Guard ...........

36 042118 650486 HHCS 5/16 x 3/4 (HN, LW) ...

37 042121 Gear Cover .....................

(4) 5/ 16 HN, LW, PW Conveyor Drive Shaft ............

38 042123 570004 Grease Fitting ................

655020 Cotter Pin 3/ 16 x 1-1/2 ........

Woodruff Key 5/ 16 x I ........

655533 Transfer Gear (l4T) .............

39 042239 40 042630 Clutch .........................

41 047030 Chain (No. 50) of 45 Links Inciuding One 500057 Connector Link & One 500058 Offset Link .....

42 047781 Conveyor Support. .... '" .......

650490 HHCS 3/8 x I (HN, LW, 4 PW) .............

650495 H H CS I / 2 x I-I / 4 (HN, LW, PW) ..............

43 047790 Shifter Handle ..................

650487 HHCS 5/ 16 x I (HLN, PW) ....

44 047886 Shifter Bracket ..................

HHCS 5/16 x I 650487 (HN, LW, 4 PW) .............

650491 H H CS 3/8 x 1-1/4 (HN, LW, PW) ..............

Shifter Extension ................

45 047889 HHCS 5/ 16 x I (HLN, PW) ....

650487 650545 HHCS 5/16 x 1-1/4 (HLN, PW) .................

Driven Gear (l6T) ...............

46 051605 47 051607 Drive Gear (20T) ................

48 051998 Bearing Bracket .................

CB 5/ 16 x I (HN, LW, PW) ....

650573 Support Right Bracket ...........

49 051999 650486 HHCS 5/16 x 3/4 (HN, LW, PW) ..............

Support Left Bracket ............

50 052000 HHCS 5/16 x 3/4 650486 (HN, LW, PW) ..............

Conveyor Drive Shaft ............

51 058659 Tapered Key 5/ 16 x I ..........

655512 Conveyor Drive Sprocket (20T) ...

52 058662 Chain Tightener Bracket .........

53 058664 CB 3/8 x 1-1/4 (HN, LW) ......

650773 Shear Bolt 1/4 x 1-1/2 ...........

54 061683A Ball Bearing .....' ...............

55 520063 Bearing Lock Collar .............

56 520084

........

I I I I I 4 I I I I I 2 I

2 8 I 2 I

2 I I I I I I 4 I 2 I 2 I I I I I I 4 4

A For replacement Shear Bolt, order Kit #900016, containing 8 Bolts.

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 120MX . . MILL CYLINDER WARNING· Order By Part Number· Do Not Use Illustration Reference Numbers

Row No. I 22 - Spacers 5/8" Wide 22 - 2E4D Hammers Row No. 2 22 - Spacers 5/8" Wide 22 - 2E4D Hammers

2

Row No. 3 II - Spacers 5/8 ' Wide 22 - Spacers 5/16" Wide 22 - 2E4D Hammers

Note'" Hammers in spaces marked 1-2-3-4-5 are assembled in opposite position to 6-1-8-9-10-11.

Ref. No ..

1 2

3

4 5 6 7

No. Req.

Ref. No.

2E4DA Hammer. . . . . . . . . . . . . . . . . . . . 66 040007 Cylinder Bearing Housing - Front .. 1 570012 Grease Fitting. . . . . . . . . . . . .. I 650062 Hex. Hd. Cap Screw 3/8 x 1~ .. 6 650227 Sq. Hd. Set Screw 5/16 x 1~ .. 2 (6) 3/8 HLN 653075 - (2) 5/16 HJN 653034 040008 Cylinder Bearing Housing - Rear 1 570002 Grease Fitting. . . . . . . . . . . . .. 1 650060 Hex. Hd. Cap Screw 3/8 x 1 4 650064 Hex. Hd. Cap Screw 3/8 x Hi 2 (6) 3/8 HLN 653075 040009 Cylinder Collar - Front .... ; . .. 1 040010 Cylinder Collar - Rear .......... 1 040050 Cylinder Shaft Nut - Front ...... 1 650198 Sol Soc. Hd. Set Screw 1/4 x 3/8 1 040051 Cylinder Shaft Nut - Rear ...... 1 650198 S-L Soc. Hd. Set Screw 1/4 x 3/8 1

8 9 10

Part No.

Part Name

11 12 13 14 IS 16 17 18

Part No.

Part Name

No. Req.

040052 Hammer Spacer .............. 22 ·040054 Cylinder Plate Spacer .......... 11 040055 Hammer Shaft 5/8 x 20-3/16 .... 3 655018 Cotter Pin 3/16 x 1-1/4 ........ 6 (3) 5/8 PW 654012 040056 Hammer Stop 5/16 x 20 ......... 6 655004 Cotter Pin 1/8 x 3/4 ......... 12 040057 Hammer Spacer. .............. 55 042315 Cylinder Key 3/8 x 3/8 x 19-3/8 ..... 1 044498 Cylinder Plate ................ 12 044507 Ball Bearing .................. I 047567 Cylinder Assembled ............. 1 047568 Cylinder Shaft 2-1/4 x 37-3/4 ...... 1 655522 Tapered Key 3/8x 2-1/2 ........ 1 520198 Ball Bearing '" ............... I AHammers are packaged in sets of 66. To order set of (66) 2E4D Hammers, specify set number 2E34.

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

19

120MX - MILL FRAME and BLOWER, _ _ _ _ _ _ _ _ _ _ _ _ __ Used Before Serial No. ~~11

12

-t.-f 14

~-2 &-1

4 37

24

L .

J.0l

.,

I

.

21

"

WARNING • Order By Part Number . Do Not Use Illustration Reference Numbers

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

20

_ _ _ _ _ _ _ _ _ _ _ _ _ _120MX - MILL FRAME and BLOWER No. Req.

Ref. No.

Blower Rim Tightener . . . . . . . . .. 1 Rim Tightener Bolt 3/8 x 8~ .... 1 (1) 3/8 HN 653010 - (1) 3/8 LW 654026 040021 Main Frame Side - Left ....... .

(Used after Serial No. 2610) 040025 Screen Cover Bracket .......... 2 (Used after Serial No. 2610) 040026 Blower Side - Front ......... .

(Used before Serial No. 2611) Blower Side - Front . . . . . . . . .. 1 051576 (Used after Serial No. 2610) Hex. Hd. Cap Screw 5/16 x 5-1/2. 1 650361 (1) 5/16 HN 653007 - (1) 5/16 LW654024 Blower Outlet ............. .

040030 (Used before Serial No. 2611) 040038 Throat Plate ................ 1 Carriage Bolt 1/2 x 1~ ...... 4 652082 (4) 1/2 HN 653018 - (4) 1/2 PW 654009 (4) 1/2 LW 654030 040046 Conveyor Spout .............. 1 040058 Screen Guide - Front .......... 1 650185 Flat Hd. Mach. Screw 5/16 xl.. 3 650186 Flat Hd. Mach. Screw 5/16 x 1~ 1 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 Screen Support .............. 1 040060 040066 Cylinder Inspection Cover . . . . .. 2 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 040068 Screen Cover Lock ............ 2 040069 Screen Cover Lock Bolt ........ 2 040081 Pivot Bushing . . . . . . . . . . . . .. 2 040102 Frame Support Bolt 3/8 x 21-5/8 6 (6) 3/8 HN 653010 - (2) 3/8 PW 654006 (6) 3/8 LW 654026 Main Frame Hood ............ 1 042039 (Used after Serial No. 2610) 042129 Blower Fan ................ 3 042171 A Blower Fan Bolt 3/8 x 1 - Gr. 5 .. 6 (6) 3/8 HN 653010 - (6) 3/8 LW 654026 042281 Screen Cover Seal ............ 1 042291 Cylinder Cover .............. 1 650060 Hex. Hd. Cap Screw 3/8 xl ... 5 650062 Hex. Hd. Cap Screw 3/8 x 1~ .. 1 (6) 3/8 HN 653010 - (6) 3/8 LW 654026 042304 Screen Guide - Rear . . . . . . . . .. 1 650185 Flat Hd. Mach. Screw 5/16 xl.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 047569 Blower Inlet ................ 1 Hex. Hd. Cap Screw 5/16 x 3/4.. 7 650025 650267 Truss Head Screw 5/16 x 5/8 .. 6 (13) 5/16 HN 653007 - (13) 5/16 LW 654024 047574 Blower Side - Rear ............ 1 (Used before Serial No. 2611) 051579 Blower Side - Rear ............ 1 (Used after Serial No.261O)

24

Ref. No.

Part No.

1 2

5H63 5H74

3 4 5

6 7

8 9

10 11 12 13 14 15 16 17 18 19 20

21 22

23

Part Name

25 26 27 28 29

30 31 32

33 34 35 36 37 38

Part No.

Part Name

No. Req.

047579 Blower Side Support .......... 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 3 650267 Truss Head Screw 5/16 x 5/8 .. 4 (7) 5/16 HN 653007 - (7) 5/16 LW 654024 047581 Main Frame Assembled ....... .

(Used before Serial No. 2611) 047582 Main Frame Side - Front ..... .

(Used after Serial No. 2610) 047583 Main Frame Side - Rear ........ 1 (Used after Serial No. 2610) 047584 Main Frame Side - Right ........ 1 (Used after Serial No. 2610) 047585 Blower Rim ................ 1 (Used before Serial No. 2611) 051582 Blower Rim ................ 1 (Used after Serial No. 2610) 047587 Blower Fan Assembled . . . . . . .. 1 047588 Blower Spider ... . . . . . . . . . .. 1 045955 Screen - 3/32 ..............•.

056102 Screen -7/64 ............... .

040106 Screen - 1/8 ................ .

040107 Screen - 3/16 ............... .

040108 Screen - 1/4 ................ .

040109 Screen - 5/16 ............... .

040110 Screen - 3/8 ................ .

040111 Screen - 1/2 ................ .

040735 Screen - 5/8 ................ .

040112 Screen - 3/4 ................ .

040113 Screen - 1 . . . . . . . . . . . . . . . . . . .

040114 Screen - 1-1/4 ............... .

040115 Screen - 1-1/2 ............... .

040116 Screen - 2 .................. .

047576 Screen Support Rod 1/2 x 22. . . . .. 1 (1) 1/2 HLN 653077 047594 Screen Cover. . . . . . . . . . . . . . . .. 1 650060 Hex.Hd.Cap Screw 3/8 xl. . . . .. 2 (2) 3/8 HLN 653075 - (2) 3/8 PW 654006 050166 Dortite Strip. . . . . . . . . . . . . . . .. 1 (Used after Serial No. 2610) 051403 Main Frame Bolt 5/16 x 3/4 Gr. 5 ... 28 (Used after Serial No. 2610) (28) 5/16 HLN 653073 051404 Main Frame Bolt 5/16 x 1 Gr. 5 . . .. 4 (Used after Serial No. 2610) (4) 5/16 HLN 653073 052121 Clamp. . . . . . . . . . . . . . . . . . . .. 1 (Used after Serial No. 2610) 652026 Carriage Bolt 5/16 x 3/4 . . . . . .. 3 (3) 5/16 HN 653007 - (3) 5/16 PW 654004 (3) 5/16 LW 654024 AFor Replacement, Order 650397.

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

21

120SAF - FEEDER TROUGH _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ 56

35 ,

,

/1

\

........

~

Y

,, I ,

..,

26

~

",~-',

"V 11

I

./

,•

I!"

IP

I

- "

\~

'"" •

..",

\",~

"

II

.J

.-----

21

28

9

Ref. No.

1 2 3

4

5

6 7

22

Part

No. Req.

Ref. No.

19E27 Trough Lock Bushing .......... 2 6H 183 Drain Plug . . . . . . . . . . . . . . . . " 1 9H251 Chain Tightener Block . . . . . . . . .. 1 650124 Hex. Hd. Cap Screw 1/2 x 3~ .. 1 (1) 1/2 HN 653018 • (2) 1/2 PW 654009 (1) 1/2 LW 654030 H275 Bearing Retainer. . . . . . . . . . . . .. 2 652026 Carriage Bolt 5/16 x 3/4 ...... 3 (3) 5/16 HN 653007 .(3) 5/16 LW 654024 9H349 Universal Joint w/Sq. Shaft ...... 1 570004 Grease Fitting . . . . . . . . . . .. 1 650042 Hex. Hd. Cap Screw 5/16 x 2~ .. 1 (1) 5/16 HLN 653073 9H370 4lck Segment .............. 2 9H371 Spring Segment .............. 1

8

No.

Part Name

9 10 11 12

13 14

Part No.

Part Name

No. Req.

9H373 Handle Stop ................ 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 2 (2) 5/16 HN 653007 • (2) 5/16 LW 654024 9H374 Lock Segment Cord (3/16 x 90) .. 1 17H387 Lock Segment Spring .......... 1 D932A Washer. . . . . . . . . . . . . . . . . . •. 3 D936 Shifter Clamp • Right .......... 1 570002 Grease Fitting .. . . . . . . . . .. 1 650028 Hex. Hd. Cap Screw 5/16 x 1 2 (2) 5/16 HN 653007 • (2) 5/16 LW 654024 D937 Shifter Clamp· Left .......... 1 D975B Drive Shaft Bearing ......... ~ .. 2 (Includes H8352A Bushing) 570002 Grease Fitting ............ 2

(Parts List Continued On Next Page)

_ _ _ _ _ _ _-.,.....,....,--_ _ _ _ _ _ _ _ 120SAF - FEEDER TROUGH Ref. No. 15 16 17 18 19 20 21 22 23

24 25 26 27 28 29

30 31 32 33 34 35 36 37 38 39

40

41

42

43

Part No.

No. Part Name

Req.

H8054 Washer . . . . . . . . . . . . .......... 1 H8352A Bearing Bushing ................ 3 09117 Washer . . . . . . . . . . . . . . . . . . . . . . 1 UlO063 lift Handle Spring .............. 1 B11285 Spring . . . . . . . . . . . . . . . . . . . . . . 1 B11296 Washer . . . . . . . . . . . . . . . . . . . . . . 1 B11400 Spacer . . . . . . . . . . . . . . . . . . . . . . 1 S16174 SetCollar . . . . . . . . . . . . . . . . . . . . l 650201 Soc.Hd.Set Screw 5/16 x 5/16 .... 1 040166 Conveyor . . . . . . . . . . . . . . . . . . . . 1 (Used before Serial No. 2467) 054188 Conveyor Assembled ............. 1 (Used after Serial No. 2466) 655533 Woodruff Key 5/16x 1 HRD ..... 1 040171 Conveyor Driven Sprocket (45T) .. 1 650204 Sol Soc. Hd. Set Screw 5/16 x 3/8 2 040174 Trough Lift Spring ............ 1 040492 Convevor Shaft ................ 1 (Used before Serial No. 2467) 655507 Woodruff Key 5/16 xl ......... 1 040494 Trough Hood ................. 1 650021 Hex.Hd.Cap Screw 5/16 x 1/2 .... 2 (2) 5/16 HLN 653073 040495 Trough End Cover .............. 1 650025 Hex.Hd.Cap Screw 5/16 x 3/4 ... .4 (4) 5/16 LW 654024 040502 Universal Joint w/ Sq. Tube ........ 1 570004 Grease Fitting . . . . . . . . . . . . . .. 1 650034 Hex.Hd.Cap Screw 5/16 x 1-3/4 ... 1 (1) 5/16 HLN 653073 lift Support Shaft 1 x 17-1/8 ....... 1 040503 650068 Hex.Hd.Cap Screw 3/8 x 2 ....... 1 (1) 3/8 HLN 653075 040504 Uft Support Tube .............. 1 {l)5/16 HLN 653073 - (l) 5/16 PW 654004 040515 lift Handle ................... 1 650028 Hex.Hd.Cap Screw 5/16 xl ...... 2 (2) 5/16 HLN 653073 - (2) 5/16 PW 654004 040532 Conveyor Trough End ........... 1 650023 Hex.Hd.Cap Screw 5/16 x 5/8 .... 3 (3) 5/16 LW 654024 040535 Trough End Extension ........... 1 040536 Pivot Rod . . . . . . . . . . . . . . . . . . . . 2 040693 Conveyor Drive Sprocket (l6T) ..... 1 650322 Sol Soc.Hd.Set Screw 1/4 x 5/16... 1 040733. Shim . . . . . . . . . . . . . . . . . . . . . . . 1 040736 Pivot Shaft 1/2 x 7-3/8 ........... 1 655016 Cotter Pin 3/16 xi. ........... 2 041147 Trough Side - Right Front ......... 1 (Includes 040536) 650267 Truss Head Screw 5/16 x 5/8 ..... 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 041148 Trough Side - Right Rear .......... 1 (Includes 040536) 650267 Truss Head Screw 5/16 x 5/8 ..... 2 650269 Truss Head Screw 5/16 x 3/4 ...... 1 (3) 5/16 HN 653007 - (1) 5/16 PW 654004 (3) 5/16 LW 654024 041912 Trough Lock Bracket . . . . . . . . . . . . 1 650029 Hex.Hd.Cap Screw 5/16 x 1-1/4 ... 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 041981 Auger Scraper ................. 1 650269 Truss Head Screw 5/16 x 3/4 ..... 5 650285 Rd.Hd.Mach.ScrewNo.1024x 1/2 2 653003 Hex.Mach. Screw Nut - No. 1024 .. 2 (5) 5/16 HN 653007 - (2) 10 PW 654054 (2) 3/16 LW 654020 - (5) 5/16 LW 654024 042094 Universal Drive Guard - Inside ....... 1 650029 Hex.Hd.Cap Screw 5/16 x 1-1/4 ... 1 (l) 5/16 HLN 653073 - (2) 5/16 PW 654004

Ret. No. 44 45

46 47

48 49

50

51 52 53

54

55 56

57

58 59

60 61 62 63

Part No.

No. Part Name

Req.

042097 Universal Drive Guard - Outside ...... 1 650326 Hex.Hd.Cap Screw 5/16 x 4-1/2 ... 1 (l) 5/16 HLN 653073 - (2) 5/16 PW 654004 047869 lift Support Segment ............ 1 650131 Hex.Hd.Cap Screw 1/2 x 4-1/2 .... 1 650323 Hex.Hd.Cap Screw 1/2 x 5 ....... 1 (2) 1/2 HLN 653077 lift Support .................. 1 04 7870 650075 Hex.Hd.Cap Screw 3/8 x 2-3/4 .... 1 (l) 3/8 HLN 653075 047989 Transport Support - Upper ........ 1 650025 Hex.Hd.Cap Screw 5/16 x 3/4 ..... 2 650104 Hex.Hd.Cap Screw 1/2 xl ....... 2 (2) 5/16 HN 653007 - (2) I/Z HLN 653077 (2) 5/16 LW 654024 - (2) 1/2 PW 654009 047990 Transport Support - Lower ......... 1 650104 Hex.Hd.Cap Screw 1/2 xl ....... 2 (2) 1/2 HLN 653077 - (2) 1/2 PW 654009 048001 Conveyor Trough ............... 1 650028 Hex.Hd.Cap Screw 5/16 xl ...... 2 650285 Rd.Hd.Mach.ScrewNo.1024x 1/2 .. 2 .

653003 Hex.Mach. Screw Nut - No. 1024 ... 2 (4) 5/16 HN 653007 - (2) 3/16 LW 654020 (4) 5/16 LW 654024 048004 Trough Side - Left Front .......... 1 650267 Truss Head Screw 5/16 x 5/8 ..... 2 (2) 5/16 HN 653007 - (6) 5/16 PW 654004 (2) 5/16 LW 654024 048008 Driven Clutch ................. 1 650213 Sol Soc.Hd.Set Screw 3/8 x 3/8 ... 1 048009 Clutch Lever .................. 1 650029 Hex.Hd.Cap Screw 5/16 x 1-1/4 ... 1 (l) 5/16 HLN 653073 - (l) 5/16 PW 654004 048012 Shaft Guard - Lower. . . . . . . . . . . . . 1 650025 Hex.Hd.Cap Screw 5/16 x 3/4 .... 3 (3) 5/16 HN 653007 - (6) 5/16 PW 654004 (3) 5/16 LW 654024 048013 Shaft Guard - Lower. . . . . . . . . . . . . 1 650021 Hex.Hd.Cap Screw 5/16 x 1/2 .... 3 650290 Sheet Metal Screw No. 14 x 1/2 ... 2 (3) 5/16 LW 654024 048015 Handle . . . . . . . . . . . . . . . . . . . . . . 1 650029 Hex.Hd.Cap Screw 5/16 x 1-1/4 ... 1 (l) 5/16 HN 653007 - (l) 5/16 LW 654024 048172 Trough Side - Left Rear ......... 1 650267 Truss Head Screw 5/16 x 5/8 ..... 7 (7) 5/16 HN 653007 - (7) 5/16 PW 654004 (7) 5/16 LW 654024 048264 Conveyor Drive Shaft 1 x 36-3/16 .... 1 (Used before Serial No. 1336) 051364 Conveyor Drive Shaft 1 x 36-3/16 .... 1 (Used after Serial No. 1335) 655020 Cotter Pin 3/16 x 1-1/2 ......... 1 650597 Woodruff Key 3/16 x 3/4 ....... 1 655533 Woodruff Key 5/16 xl HRD ..... 1 650026 Hex.Hd.Cap Screw 5/16 x 3/4 L.H.. 1 048265 Drive Clutch (Includes H8352A) ..... 1 570002 Grease Fitting ............... 1 049307 Conveyor Guard ............... 1 650023 Hex.Hd.Cap Screw 5/16 x 5/8 .... 6 (6) 5/16 HN 653007 - (6) 5/16 PW 654004 (6) 5/16 LW 654024 500221 Chain (No. 41) of 66 links Including One (500043) Connector Link .... 1 520063 Ball Bearing . . .'. . . . . . . . . . . . . . . 1 Bearing Collar . . . . . . . . . . . . . . . . . 1 520084 666000 Steel Ball . . . . . . . . . . . . . . . . . . . . 1 NOTE: See Page 64 for SAF Hoppers.

23

· 120SAF - FEEDER DRIVE _ _ _ _ _ _ _-::--_ _ _ _ _ _ _ __ WARNING - Order By Part Number - Do Not Use Illustration Reference Numbers

30

1.

29

\,

~

.~

? .J ./34 1.-J

<t:6'.

47~.

23

•

..

74

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

24

.--' .~ 10-~

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 120SAF - FEEDER DRIVE

Ref. No. 1

2 3 4

5

6 7 8 9 10

11 12 13 14 15 16 17 18 19 20 21

22 23 24

25 26 27 28 29 30

31

No. Req.

Ref. No.

13E24 Roll Pin 1/4 x B~ ............ 3 6H40 Conveyor Driven Sheave (9 Dia.) .. 1 650203 Soc. Hd. Set Screw 5/16 x 3/8 " 1 3E42A Variable Sheave Key 5/16 x 5/16 x 3 2 (One req'd. before Serial No. 1336) 7H73 Washer. . . . . . . . . . . . . . . . . . .. 4 (Used after Serial No. 1805) 5E77 Belt Tightener Pulley .......... 2 652085 Carriage Bolt 1/2 x 2 ........ 2 (2) 1/2 HJN 653044 - (4) 1/2 PW 654009 (2) 1/2 LW 654030 3E126A Conveyor Driven Sheave (11 Dia.) .. 1 650206 Soc. Hd. Set Screw 5/16 x 1/2 .. 2 H217 Throw-Out Lever Dog .. . . . . . . .. 1 A262 Lever Dog Spring ............ 1 H267 Shim Washer ................ 1 H275 Bearing Retainer. . . . . . . . . . . . .. 6 652026 Carriage Bolt 5/16 x 3/4 ...... 9 (9) 5/16 HN 653007 - (9) 5/16 LW 654024 9H322 Variable Control Sheave ........ 1 9H324 Sheave Flange ....... . . . . . .. 2 650204 Sol Soc. Hd. Set Screw 5/16 x 3/8 2 650206 Soc. Hd. Set Screw 5/16 x 1/2 .. 2 9H325 Variable Drive Belt " . . . . . . . . .. 1 17H325 Spacer. . . . . . . . . . . . . . . . . . .. 2 (One req'd. before Serial No. 1336) 9H332 Adjusting Nut . . . . . . . . . . . . .. 1 9H365 Bearing Take-Up Bolt .......... 1 (2) 5/16 HN 653007 17H386 Take-Up Angle .............. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024 D932A Washer. . . . . . . . . . . . . . . . . . .. 10 H6053 Shift Pivot Bushing . . . . . . . . . . .. 2 H8054 Washer. . . . . . . . . . . . . . . . . . .. 2 D9048C Pivot Bearing .. . . . . . . . . . . . . .. 4 (Includes D9139A Bushing) 570002 Grease Fitting ..... . . . . . .. 1 570005 Grease Fitting . . . . . . . . . . .. 1 570012 Grease Fitting ............ 2 D9139A Bearing Bushing .............. 4 UlOl17 Variable Sheave Key 5/16 x 5/16 x 4 2 BI1029A Bearing Retainer. . . . . . . . .. . . .. 8 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 8 652029 Carriage Bolt 5/16 x l . . . . .. 4 652033 Carriage Bolt 5/16 x 1% ....... 4 (16) 5/16 HN 653007 - (16) 5/16 LW 654024 B11335 Bearing Retainer . . . . . . . . . . . . .. 2 652029 Carriage Bolt 5/16 x I . . . . .. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 040081 Pivot Bushing . . . . . . . . . . . . . . .. 2 040562 Sheave Flange . . . . . . . . . . . . .. 1 570014 Grease Fitting . . . . . . . . . . .. 1 040563 Pivot Flange ................ 1 570006 Grease Fitting ... . . . . . . . .. 1 040571 Shifter Clamp . . . . . . . . . . . . .. 2 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 040581 Shifter Stop ................ 1 650005 Hex. Hd. Cap Screw 1/4 x 3/4 .. 2 (2) 1/4 HN 653005 - (2) 1/4 PW 654002 (2) 1/4 LW 654022 040595 Drive Shaft - Upper 1 x 10% .... 1 655533 Woodruff Key 5/16 xl HRD. . .. 1 655020 Cotter Pin 3/16 x 1% ........ 1

32

Part No.

Part Name

33 34 35 36 37 38 39 40

41 42 43 44 45 46 47 48

49 50 51 52

53 54

55 56 57

Part No.

Part Name

No. Req.

Pivot Bearing Spacer .......... 4 (Two req'd. before Serial No. 1336) (Three req'd. after Serial No. 1335 and before Serial No. 1806) 040611 Drive Gear Guard ............ 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 LW 654024 040630 Shifter Shim ................ 2 040983 Conveyor Drive Gear (14T) ...... 2 040984 Driven Gear (19T) ............ 2 042350 Brake Band ................ 2 650048 Carriage Bolt 3/8 x 1Y<I ••• : •• " 1 (1) 3/8 HLN 653075 044257 Variable Drive Spring .......... 1 044258 Spring Retainer .............. 1 044653 Shifter Link - Upper .......... 1 650028 Hex. Hd. Cap Screw 5/16 x I . . 3 (3) 5/16 HN 653007 - (5) 5/16 PW 654004 (3) 5/16 LW 654024 047622 V-Belt. . . . . . . . . . . . . . . . . . .. 2 04 7924 Pivot Flange ................ 1 047925 Brake Drum ................ 1 650028 Hex. Hd. Cap Screw 5/16 x 1 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 047926 Bearing Support .............. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 (3) 5/16 HN 653007 - (3) 5/16 LW 654024 047942 Bearing Plate ................ 1 652026 Carriage Bolt 5/16 x 3/4 ...... 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 047945 Shifter Handle .............. 1 04 7948 Shifter Support .............. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024 047949 Variable Driven Shaft 1 x 20 1 655020 CotterPin3/16xl% ........ 1 655513 WoodruffKeyl/4xlHRD ..... 1 655533 Woodruff Key 5/16 xI HRD. . .. 1 047950 Pivot Support - Lower ........ " 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 7 (7) 5/16 HN 653007 - (7) 5/16 LW 654024 047951 Gear Cover .............. " 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 04 7952 Pivot Drive Shaft 1 x 19% ...... 1 655020 CotterPin3/16xl% ........ 1 655533 Woodruff Key 5/16 x 1 HRD . .. 1 047953 Shifter Link - Lower .......... 1 650028 Hex. Hd. Cap Screw 5/16 x I I (1) 5/16 HN 653007 - (1) 5/16 PW 654004 (1) 5/16 LW 654024 047955 Sheave (5 Dia.) .............. 1 650203 Soc. Hd. Set Screw 5/16 x 3/8 .. 1 650206 Soc. Hd. Set Screw 5/16 x 1/2 " 1 047962 Shifter Bearing Housing ........ 1 04 7964 Idler Arm .................. 1 655020 Cotter Pin 3/16 x 1% ........ 1 047968 Variable Support - Rear ........ 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 3 (3) 5/16 HN 653007 - (3) 5/16 LW 654024 047969 Variable Belt Guard . . . . . . . . .. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024 040603

(Parts list Continued On Next Page)

25

120SAF - FEEDER DRIVE _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ Ref. No. 58 59 60

61

62 63 64 65 66

67 68

69 70 71 72 73

74

No. Req.

Ref. No.

047970 A Pivot Support ............ " 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 8 (8) 5/16 HN 653007 - (8) 5/16 LW 654024 047971 Variable Drive Shaft .......... 1 570002 Grease Fitting .......... " 1 047972 Lever Dog Housing .......... " 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 047973 Pivot Support - Right .......... 1 650062 Hex. Hd. Cap Screw 3/8 x 1% " 1 652026 Carriage Bolt 5/16 x 3/4 ...... 1 (2) 5/16 HN 653007 - (1) 3/8 HN 653010 (1) 3/8 PW 654006 - (2) 5/16 LW 654024 (1) 3/8 LW 654026 047975 Ball Bearing ................ 1 047979 Chain (12 Links) . . . . . . . . . . .. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 (1) 5/16 HN 653007 - (3) 5/16 LW 654024 04 7980 Guard . . . . . . . . . . . . . . . . . . . . 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (3) 5/16 HN 653007 - (3) 5/16 LW 654024 047983 Guard Bracket .............. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024 047985 Pivot Brace ................ 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 650029 Hex. Hd. Cap Screw 5/16 x 1% .. 1 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 047986 Sheave Bracket .............. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 047987 Idler Pivot - Rear ............ 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 PW 654004 (4) 5/16 LW 654024 047988 Guard Bracket .............. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024 048000 Sheave (7 Dia.) .............. 1 650203 Soc. Hd. Set Screw 5/16 x 3/8 .. 1 048020 Brake Lever ................ 1 (1) 3/8 HLN 653075 048026 Spacer. . . . . . . . . . . . . . . . . . .. 1 048033 Pivot Support - Upper . . . . . .

1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 8 650028 Hex. Hd. Cap Screw 5/16 x l . . 1 (12) 5/16 HN 653007 - (12) 5/16 LW 654024 048034 Variable Crank .............. 1 (4) 5/8 HJN 653047

75 76 77 78

Part No.

Part Name

79 80 81 82 83

84 85

86 87 88 89 90 91 92 93 94 95

Part No.

Part Name

048036 Control Segment - Right ........ 1 048037 Control Segment - Left ........ 1 048038 Pivot Support - Upper . . . . . . . . .. 1 048039 Brace . . . . . . . . . . . . . . . . . . . . 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 048040 Shifter Pivot ................ 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 048043 Spacer. . . . . . . . . . . . . . . . . . .. 2 048044 Brace ..... . . . . . . . . . . . . . .. 1 650025 Hex.Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 048045 Pivot Bracket .............. " 1 048046 Variable Support - Front ........ 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 1 (3) 5/16 HN 653007 - (3) 5/16 LW 654024 048047 Spacer ................... .

650038 Hex. Hd. Cap Screw 5/16 x 2% ..

(1) 5/16 HN 653007 - (1) 5/16 LW 654024 048048 Shifter Pivot - Left ............ 1 650062 Hex. Hd. Cap Screw 3/8 x 1% .. 1 652026 Carriage Bolt 5/16 x 3/4 ...... 2 (2) 5/16 HN 653007 - (1) 3/8 HN 653010 (1) 3/8 PW 654006 - (2) 5/16 LW 654024 (1) 3/8 LW 654026 048061 Guard ................... .

650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 048732 Guard Bracket - Right ......... .

650025 Hex. Hd. Cap Screw 5/16 x 3/4 ..

(1) 5/16 HN 653007 - (1) 5/16 LW 654024 048733 Guard Bracket - Left ......... .

650025 Hex. Hd. Cap Screw 5/16 x 3/4 ..

(1) 5/16 HN 653007 - (1) 5/16 LW 654024 048734 Drive Shaft Bearing Bracket .. . . .. 1 652026 Carriage Bolt 5/16 x 3/4 ...... 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 048735 Trough Pivot Frame. . . . . . . . . . .. 1 048757 Pivot Support - Upper. . . . . . . . . .. 1 650060 Hex.Hd.Cap Screw 3/8 xl. . . . .. 3 (3) 3/8 HN 653010 - (3) 3/8 LW 654026 520009 Thrust Bearing. . . . . . . . . . . . . . .. 1 520063 Ball Bearing. . . . . . . . . . . . . . . . .. 4 520084 Bearing Collar . . . . . . . ........ , 4 540024 Retaining Ring .............. , 1 AFor Replacement, Order 053815.

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

26

No. Req.

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 150HF - HAY FEEDER

25

WARNING - Order By Part Number - Do 59

55

(Parts List Begins On Next Page) ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

21

150HF - HAY FEEDER _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ Ref. No.

No. Req.

Part No.

Part Name

7H73

Washer. . . . . . . . . . . . . . . . . . ..

2

2

5E77 Belt Tightener Pulley ......... .

650121 Hex. Hd. Cap Screw 1/2 x 3 ..

(1) 1/2 HLN 653018 - (3) 1/2 PW 654009 (1) 1/2 LW 654030

3

9H202A Drive Sprocket (l4T) .......... 2 650322 Sol Soc. Hd. Set Screw 1/4 x 5/16 2

4

17H238

Pivot Arm Bushing ............

5

9H255 Driven Sprocket (28T) ......... .

650211 Sol Soc. Hd. Set Screw 3/8 x 5/16

Ref. No.

Part No.

Part Name

No. Req.

24

040635 Hopper Bottom .............. 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 4 650029 Hex. Hd. Cap Screw 5/16 x 1!4 .. 2 (6) 5/16- HN 653007 - (6) 5/16 PW 654004 (6) 5/16 LW 654024

25

040640

26

040661 Roller - Upper ..............

655533 Woodruff Key 5/16 xl HRD .. "

1 1

27

040676

2

Hinge Spacer ............... .

2 Roller Equalizer ........ . . . . ..

(Includes H8352A Bushing) 570009 Grease Fitting ............

4

6

9H300

Hair Pin Cotter ............. .

28

040681

7

9H359

Driven Sheave (7 Dia.) ......... .

29

8

D932A

Washer. . . . . . . . . . . . . . . . . . ..

2

040685 Bumper Support Angle . . . . . . .. 2 650269 Truss Head Screw 5/16 x 3/4 " 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024

9

H6053

Safety Handle Spacer ..........

5

30

10

H7846 Bearing Retainer. . . . . . . . . . . . .. 4 652026 Carriage Bolt 5/16 x 3/4 ...... 6 (6) 5/16 HN 653007 - (6) 5/16 LW 654024

040686 Spring Stop ................ 2 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024

31

040699 Drive Bearing Bracket - Inside .... 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024

32

040710 Roller Lift Segment - Front ..... .

650271 Truss Head Screw 5/16 x 1 (1) 5/16 HN 653007 - (l) 5/16 PW 654004 (l) 5/16 LW 654024

33

040711 Roller Lift Segment - Rear ...... 1 650269 Truss Head Screw 5/16 x 3/4 1 (l) 5/16 HN 653007 - (1) 5/16 PW 654004 (l) 5/16 LW 654024

34

040810

11

H8315 Set Collar ..................

650195 Soc. Hd. Set Screw 1/4 x 1/4 ..

2 2

12

H8352A

Equalizer Bushing

............

4

13

B11242

Lift Arm Bushing

. . . . . . . . . . ..

3

14

M12118

Spring Rod Washer

15

R13055

Pivot Arm Spacer

16

C14125

Spacer

17

040170 Hinge ....................

652136 Carriage Bolt 1/4 x 5/8 ......

(8) 1/4 HN 653005 - (8) 1/4 LW 654022

18

19

................... .

040496

Idler Pivot ................. .

(Used before Serial No. 8451) 051370 Idler Pivot ................. .

(Used after Serial No. 8450) 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (7) 5/16 HN 653007 - (2) 5/16 LW 654024 040466 Drive Sheave (5 Dia.) ......... .

650206 Soc. Hd. Set Screw 5/16 x 1/2 ..

655513 Woodruff Key 1/4 x 1 HRD .....

040500

Equalizer Spring . . . . . . . . . . . . ..

2

21

040568

Safety Handle Spacer ..........

2

22

040571 Lift Arm Clamp ...... . . . . . . .. 2 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024

23

040630

Shifter Shim ................

047810

Shifter Safety Pivot ........... .

(Used before Serial No. 8451) Shifter Safety Pivot ........... .

(Used after Serial No. 8450)

35

041165

Bearing Bracket Spacer

36

042000

Belt Tightener Spring ......... .

37

042133 Spring Guide ................ 2 650028 Hex. Hd. Cap Screw 5/16 x l . . 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024

38

042135

39

042136 Roller Adjustment Pin . . . . . . . . ..

655016 Cotter Pin 3/16 xl ........ "

1 8

20

28

Roller Lift Arm ............. .

6

Washer. . . . . . . . . . . . . . . . . . .. 2 (One req'd. before Serial No. 8451)

(Parts List Continued On Next Page)

1 1

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 150HF - HAY FEEDER Ref. No.

Part No.

No, Req.

Part Name

40

042140 Spring Rod . . . . . . . . . . . . . . .• 1 650028 Hex. Hd. Cap Screw 5/16 x l i (1) 5/16 HN 653007 - (1) 5/16 PW 654004 (1) 5/16 LW 654024 655006 Cotter Pin 1/8 x l . . . . . . . . .. 1

41

042142

42

042145

43

44

Ref. No.

042147 A Pivot Arm - Rear ............. .

(Used before Serial No. 8451) (Includes One 17H238 and One H8352A Bushing) 570002 Grease Fitting.. . . . . . . . . . . . ..

570008 Grease Fitting. . . . . . . . . . . . ..

051573 Pivot Arm - Rear . . . . . . . . . . ..

(Used after Serial No. 8450) (Includes One 17H238 and One H8352A Bushing) 570002 Grease Fitting. . . . . . . . . . . . ..

570008 Grease Fitting. . . . . . . . . • . . ..

No. Req.

047814 Bearing Gusset .............. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 650269 Truss Head Screw 5/16 x 3/4 .. 2 (4) 5/16 HN 653007 - (4) 5/16 LW 654024

52

047815 Bearing Support .............. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024

53

047816 Feeder Drive Shaft 1 x 5* ......

650597 Woodruff Key 3/16 x 3/4 HRD '.

655533 Woodruff Key 5/16 xl HRD. . ..

1 1 1

54047817c

044308

Safety Pivot Spacer . . . . . . . . . . ..

(Used after Serial No. 8450)

1

46

047623 Variable Drive Belt .. . . . . . . . . ..

650039 Hex. Hd. Cap Screw 5/16 x 2~ ..

(2) 5/16 HN 653007

1 1

47

047804

Side Plate - Front

............

1

48

047806

Side Plate - Rear

. . . . . . . . . . ..

1

49

047807 Guard .................... 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024

50

047812 Safety Handle . . . . . . . . . . . . .. 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 1 650034 Hex. Hd. Cap Screw 5/16 x 1 1 650036 Hex. Hd. Cap Screw 5/16 x 2 .. 1 (3) 5/16 HLN 653073 - (5) 5/16 PW 654004

1

047818 B

56

047948 Shifter Support .............. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024

57

048089 Roller - Lower ..............

650597 Woodruff Key 3/16 x 3/4 HRD ..

655513 Woodruff Key 1/4 xl HRD ....

58

048367 Sprocket (28T) .............. 1 650211 S-L Soc. Hd. Set Screw 3/8 x 5/16 1

59

053319

1 1

45

Belt Guide. . . . . . . . . . . . . . . . ..

1 1 1

55 1 1 1

042183 Crusher Roller Cover .......... 1 650023 Hex. Hd. Cap Screw 5/16 x 5/8.. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 8 650269 Truss Head Screw 5/16 x 3/4 .. 3 (12) 5/16 HN 653007 - (12) 5/16 LW 654024

*..

Part Name

51

Spring Pivot Rod ............. .

Pivot Arm - Front ............

(Includes One 17H238 and One H8352A Bushing) 570003 Grease Fitting. . . . . . . . . . . . ..

Grease Fitting. . . . . . . . . . . . ..

570005

Part No.

Drive Guard ................ 1 (Used before Serial No. 8976) 053317 Drive Guard ................ 1 (Used after Serial No. 8975) 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024

Chain Guard ................

(Used after Serial No. 8975) 650005 Hex. Hd. Cap Screw 1/4 x 3/4 ,..

(2) 1/4 HN 653005 - (2) 1/4 PW 654002 (2) .1/4 LW 654022

1 1 1

1 2

60

500222

Chain (No. 41) of 45 Links Including One (500043) Comiector Link and One (500044) Offset Link .... 1

61

500223

Chain (No. 41) of 47 Links Including One (500043) Connector Link and One (500044) Offset Link .... 1

62

520063

Ball Bearing

....'............

2

63

520084

Bearing Collar

. . . . . . . . . . . . •.

1

64

620041 Stem Bumper . . . . . . . . . . . . . . ..

AFor Replacement, Order Part Number 051573.

B For Replacement, Order 053317 cFor Replacement, Order 056762.

2

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

29

150HF - HAY FEEDER DRIVE _ _ _ _ _ _ _ _ _ _ _ _ _ _ __

(1 36.

,

35

(}-25

'f" '"

~.."

68

tr-6 1-7

69 ~ ~:¥,

~.,~

9/'

/

0- 45

, /' ,

I l-'

WARNING - Order By Part Number - Do Not Use Illustration Reference Numbers

Ref. No. 1 2 3 4

5 6 7 8 9

30

Part No.

Part Name

No. Req.

RollPinl/4xl~ ............ 1 13E24 6H40 Driven Sheave (9 Dia.) . . . . . . . . .. 1 3E42A Variable Sheave Key 5/16 x 5/16 x 3 2 5E77 Belt Tightener Pulley .......... 2 652085 Carriage Bolt 1/2 x 2 ........ 2 (2) 1/2 HIN 653044 - (4) 1/2 PW 654009 (2) 1/2 LW 654030 3E126A Driven Sheave (11 Dia.) ...•.... 1 H217 Throw-Out Lever Dog .. . . . . . . .. 1 A262 Lever Dog Spring ............ 1 H267 Shim Washer ................. 1 H275 Bearing Retainer. . . . . . . . . . . . .. 6 652026 Carriage Bolt 5/16 x 3/4 ...... 9 (9) 5/16 HN 653007 - (9) 5/16 LW 654024

Ref. No. 10 11 12 13 14 15 16 17

Part No.

Part Name

No ..

Req.

9H322 Variable Control Sheave ........ 1 9H324 Sheave Flange. . . . . . . . . . . . . . .. 2 650204 Sol Soc. Hd. Set Screw 5/16 x 3/8 2 650206 Soc. Hd. Set Screw 5/16 x 1/2 .. 2 9H325 Variable Drive Belt .. . . . . . . . . .. 1 17H325 Bearing Spacer .............. 2 9H332 Adjusting Nut . . . . . . . . . . . . .. 1 9H365 Bearing Take-Up Bolt .......... 1 (2) 5/16 HN 653007 17H386 Take-Up Angle .............. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024 D932A Washer ................•...

(Parts Lilt Continued On Next Page)

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 150HF - HAY FEEDER DRIVE No. Req.

Ref. No.

Shifter Pivot Bushing .......... I (Two req'd. before Serial No. 845 I) H8054 Washer ................... , 2 UIOII7 Variable Sheave Key 5/16 x. 5iI6 x 4 2 B11335 Bearing Retainer . . . . . . . . . . .. 2 652029 Carriage Bolt 5/16 xl. . . . . . .. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 040081 Pivot Bushing . . . . . . . . . . . . . . .. 2 Sheave Flange ............... , 1 040562 570014 Grease Fitting . . . . . . . . . . .. 1 040571 Lift Arm Clamp ............. , 2 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN653007 - (4)5/16 LW 654024 040581 Shifter Stop ................ 1 650005 Hex. Hd. Cap Screw 1/4 x 3/4 .. 2 (2) 1/4 HN 653005 - (2) 1/4 PW 654002 (2) 1/4 LW 654022 040630 Shifter Shim ................ 2 044257 Variable Drive Spring ......... .

044258 Spring Retainer ............. .

044653 Shifter Link - Upper ......... .

650028 Hex. Hd. Cap Screw 5/16 x I ..

(I) 5/16 HN 653007 - (I) 5/16 PW 654004 (1) 5/16 LW 654024 047622 V-Belt. . . . . . . . . . . . . . . . . . .. 2 047926 Variable Housing - Lower. . . . . . .. I 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 (3) 5/16 HN 653007 - (3) 5/16 LW 654024 047942 Bearing Plate ................ 1 652026 Carriage Bolt 5/16 x 3/4 ...... 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 047945 Shifter Handle .............. I 047949 Variable Driven Shaft I x 20 I 655020 Cotter Pin 3/16 x 1~ ........ 1 655513 Woodruff Key 1/4 x 1 HRD. . .. 1 047950 Mounting Bracket - Lower ...... 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 7 (7) 5/16 HN 653007 - (7) 5/16 LW 654024 047951 Gear Cover . . . . . . . . . . . . . . .. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 047953 Shifter Link - Lower ......... .

650028 Hex. Hd. Cap Screw 5/16 xl ..

(1) 5/16 HN 653007 - (l) 5/16 PW 654004 (1) 5/16 LW 654024 047955 Sheave (5" Dia.) . . . . . . . . . . . . .. 1 650203 Soc. Hd. Set Screw 5/16 x 3/8 .. 1 650206 Soc. Hd. Set Screw 5/16 x 1/2 .. 1 047962 Shifter Bearing Housing ........ 1 047964 Idler Arm .................. 1 655020 Cotter Pin 3/16 x 1~ ........ 1 047968 Variable Support - Rear ........ 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 3 (3) 5/16 HN 653007 - (3) 5/16 LW 654024 047969 Variable Belt Guard ........... .

650025 Hex. Hd. Cap Screw 5/16 x 3/4 ..

(1l5/16 HN 653007 - (1) 5/16 LW 654024 047970 Pivot Support. . . . . . . . . . . . . . .. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 8 (8) 5/16 HN 653007 - (8) 5/16 LW 654024 047971 Variable Drive Shaft 1 x 30-1/8 1 570002 Grease Fitting. . . . . . . . . . . . .. 1 047972 Lever Dog Housing ..... ' . . . . . .. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024

46

Ref. No.

Part No.

18

H6053

19 20 21 22 23 24 25

26 27

28 29

30 31 32 33 34 35 36 37

38 39 40 41 42 43 44 45

Part Name

47 48 49 50 51 52

53 54 55

56 57 58 59 60 61 62 63 64 65

66 67

68 69 70

Part No.

Part Name

No. Req.

047973 Pivot Support - Right .......... 1 650062 Hex. Hd. Cap Screw 3/8 x 1~ .. 1 Carriage Bolt 5/16 x 3/4 ...... 2 652026 (2) 5/16 HN 653007 - (l) 3/8 HN 653010 (1) 3/8 PW 654006 - (2) 5/16 LW 654024 (1) 3/8 LW 654026 047975 Ball Bearing ................ 1 047980 Driven Sheave Guard .......... 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (3) 5/16 HN 653007 - (3) 5/16 LW 654024 047983 Guard Bracket ............. .

650025 Hex. Hd. Cap Screw 5/16 x 3/4 ..

(1) 5/16 HN 653007 - (1) 5/16 LW 654024 047985 Pivot Brace ................ 1 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 650025 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 047986 Sheave Bracket .............. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 047987 Idler Pivot Rear .............. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 PW 654004 (4) 5/16 LW 654024 047988 Guard Bracket ............. .

650025 Hex. Hd. Cap Screw 5/16 x 3/4 ..

(1) 5/16 HN 653007 - (I) 5/16 LW 654024 048000 Feeder Drive Sheave (7 Dia.) 1 650203 Soc. Hd. Set Screw 5/16 x 3/8 .. 1 048033 Pivot Support - Upper .. . . . . . . ... I 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 8 650028 Hex. Hd. Cap Screw 5/16 x l . . I (12) 5/16 HN 653007 - (12) 5/16 LW 654024 048034 Variable Speed Crank .......... I (4) 5/8 HJN 653047 048036 Control Segment - Right ....... .

048037 Control Segment - Left ....... .

048038 Pivot Support - Upper ......... .

048039 Brace ................... .

650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 048040 Shifter Pivot ............... .

650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 " (4) 5/16 LW 654024 048043 Spacer. . . . . . . . . . . . . . . . . . .. 2 048044 Brace .................... I. 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 048045 Pivot Bracket . . . . . . . . . . . . . . . .

048046 Variable Support - Front ....... .

650025 Hex. Hd. Cap Screw 5/16 x 3/4 ..

650028 Hex. Hd. Cap Screw 5/16 x I ..

(3) 5/16 HN 653007 - (3) 5/16 LW 654024 048047 Spacer ................... .

650038 Hex. Hd. Cap Screw 5/16 x 2~ ..

(1) 5/16 HN 653007 - (1) 5/16 LW 654024 048048 Shifter Pivot - Left .. . . . . . . . . .. 1 650062 Hex. Hd. Cap Screw 3/8 x 1~ .. 1 652026 Carriage Bolt 5/16 x 3/4 ...... 2 (2) 5/16 HN 653007 - (I) 3/8 HN 653010 (1) 3/8 PW 654006 - (2) 5/16 LW 654024 (1) 3/8 LW 654026 520063 Ball Bearing ................ 4 520084 Bearing Collar . . . . . . . . . . . . .. 4 540024 Retaining Ring ............... 1 AFor Replacement, Order 053815.

31

80

(

26

Drive Parts Mixer. Convehyorpower Bale d W en Require.

Mounted.

Feeder IS

32

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 150PBF - FEEDER HEAD (Used After Serial No. 1410) Ref. No.

2 3 4 5 6 7

8 9 10

II 12 13 14 15 16 17 18 19

20 21 22 23

24

25 26

27 28 29

No. Req.

Ref. No.

Belt Tightener Pulley (4-5/8 Dia.) 5E77 652084 Carriage Bolt 1/2 x 2~ ..... .

(I) 1/2 HLN 653077 - (l) 1/2 PW 654009 17H 140 Shim Washer . . . . . . . . . . . . . . . . 5 9EI76 Key 1/4 x 3/8 x 1~ .......... 1 17H295A Conveyor Sprocket (6T) ........ 1 17H319A Sheave . . . . . . . . . . . . . . . . . . . . 1 9H346 Spring. . . . . . . . . . . . . . . . . . .. 2 Hinge . . . . . . . . . . . . . . . . . . . . 1 17H394 650269 Truss Head Screw 5/16 x 3/4 .. 8 (8) 5/16 HN 653007 - (4) 5/16 PW 654004 (8) 5/16 LW 654024 H6053 Pivot Bushing - 9/32 .......... 2 H7163 Idler Arm Spacer . . . . . . . . . . . . 1 H7794A Sheave (I5 Dia.) . . . . . . . . . . . . .. 1 650207 Sol Soc. Hd. Set Screw 5/16 x 1/2 2 H7846 Bearing Retainer . . . . . . . . . . . ... 8 652026 Carriage Bolt 5116 x 3/4 ...... 12 (12) 5/16 HN 653007 - (12) 5/16 LW 654024 H8016 Conveyor Drive Sprocket (20T) 1 (Used after Serial No. 10lD) H8334 Bearing Retainer . . . . . . . . . . . . .. 4 652046 Carriage Bolt 3/8 x 3/4 ...... 6 (6) 3/8 HN 6530lD - (6) 3/8 LW 654026 D9048C Bearing (Includes D9139A Bushing). 2 ............ 2 570003 Grease Fitting D9139A Bearing Bushing . . . . . . . . . . . . . . 2 BI lD29A Bearing Retainer. . . . . . . . . . . . .. 4 652029 Carriage Bolt 5/16 x I . . . . .. 8 (8) 5/16 HN 653007 - (8) 5/16 LW 654024 B11242 Pivot Bushing - 7/32 .......... 3 S16174 Set Collar . . . . . . . . . . . . . . . . . . 1 650201 Soc. Hd. Set Screw 5/16 x 5/16.. 1 040563 Pivot Flange . . . . . . . . . . . . . . . . 2 570006 Grease Fitting ... . . . . . . . .. 2 652029 Carriage Bolt 5/16 x l . . . . .. 8 (8) 5/16 HN 653007 - (8) 5/16 LW 654024 040603 Bearing Spacer . . . . . . . . . . . . . . 2 040614 Magnet Hole Cover .... . . . . . . .. 1 650264 Truss Head Screw 1/4 x 3/4 . . .. 6 (6) 1/4 HN 653005 - (6) 1/4 LW 654022 Hinge . . . . . . . . . . . . . . . . . . . . 1 042865 . 650269 Truss Head Screw 5/16 x 3/4 7 (7) 5/16 HN 653007 - (7) 5/16 LW 654024 043525 Cover Lock Rod . . . . . . . . . . . . . .

(Used after Serial No. 1010) 655005 Cotter Pin 1/8x 1 ......... .

(2) 3/8 HN 6530lD 048182 Idler Pulley . . . . . . . . . . . . . . . .

650117 Hex. Hd. Cap Screw 1/2 x 2~ (l) 1/2 HN 653018 - (1) 1/2 PW 654009 (1) 1/2 LW 654030 048183 Powerband BeIt . . . . . . . . . . . . . .

048205 Cover Extension . . . . . . . . . . . . . .

048225 Spring Link . . . . . . . . . . . . . . . .

650271 Truss Head Screw 5/16 x 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024 048227 Spring Adjustment Bracket ...... 1 652046 Carriage BaIt 3/8 x 3/4 ...... 2 (2) 3/8 HN 653010 - (2) 3/8 LW 654026 048228 Linkage Bar . . . . . . . . . . . . . . . .

650028 Hex. Hd. Cap Screw 5/16 xl ..

652029 Carriage BaIt 5/16 xl ..... .

(2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024

30

Part No.

Part Name

31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48

49 50

51 52 53 54

55

56 57

Part No.

Part Name

No. Req.

048229 Cylinder Clutch Handle ....... .

650028 Hex. Hd. Cap Screw 5/16 xl ..

652029 Carriage Bolt 5/16 xl ..... .

(2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 048232 Cylinder Handle Bracket ........ 1 652026 Carriage Bolt 5/16 x 3/4 ...... 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 048248 Conveyor Shaft 1 x 26-3/8 ...... 1 655513 Woodruff Key 1/4 xI HRD .... 1 048249 Conveyor Jack Shaft 1 x 27-1/8 1 655533 Woodruff Key 5/16 xI HRD. . .. 1 048283 Sheave (11% Dia.) ............ 1 650207 Sol Soc. Hd. Set Screw 5/16 x 1/2 2 ............ 1 048284 Sheave (4% Dia.) 650201 Soc. Hd. Set Screw 5/16 x 5/16.. 1 650203 Soc. Hd. Set Screw 5/16 x 3/8 .. 1 048339 Baffle Bracket - Left .......... 1 048753 Idler Sheave Spacer .......... " 1 049145 Baffle Bracket .............. 1 049371 Spring Pin 5/16 x 174 .......... 1 050480 Gear Guard Bracket . . . . . . . . .. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 050482 Apron Drive Sprocket (11 T) 650195 Soc. Hd. Set Screw 1/4 x 1/4 .. 1 051934 Sickle Section . . . . . . . . . . . . .. 16 654539 Oval Hd. Rivet No. 5~ x 1/2 .. 32 052057 Cylinder . . . . . . . . . . . . . . . . . . 1 655533 Woodruff Key 5/16 x 1 HRD . .. 1 655537 Woodruff Key 5/16 x 1% HRD .. 1 052061 Knife - Righ t . . . . . . . . . . . . . . " 8 650060 Hex. Hd. Cap Screw 3/8 x 1 16 (16) 3/8 LW 654026 052062 Knife Holder - Right .......... 8 052063 Knife - Left . . . . . . . . . . . . . . . . 8 650060 Hex. Hd. Cap Screw 3/8 x 1 16 (16) 3/8 LW 654026 052064 Knife Holder - Left . . . . . . . . . . .. 8 052066 Throat Plate Bracket .......... 2 652046 Carriage Bolt 3/8 x 3/4 ...... 8 (8) 3/8 HN 6530lD - (4) 3/8 PW 654006 (8) 3/8 LW 654026 052067 Throat Plate Support .......... 1 052068 Throat Plate Inner . . . . . . . . . . . . 1 652046 Carriage Bolt 3/8 x 3/4 ...... 4 (4) 3/8 HN 653010 - (4) 3/8 PW 654006 (4) 3/8 LW 654026 052069 Apron Drive Gear (12T) ........ 1 650214 Soc. Hd. Set Screw 3/8 x 1/2 .. 1 052070 Apron Drive Gear (60T) ........ 1 650214 Soc. Hd. Set Screw 3/8 x 1/2 " 1 052071 Sprocket (96T) . . . . . . . . . . . . . . 1 650206 Soc. Hd. Set Screw 5/16 x 1/2 .. 1 052073 Filler ......... . . . . . . . . . .. 2 650184 Flat Head Screw 5/16 x 3/4 .. " 4 (4) 5/16 HN 653007 - (4) 5/16 PW 654004 (4) 5/16 LW 654024 052084 A Tightener Arm. . . . . . . . . . . . . . .. 1 (Used before Serial No. 057662 Tightener Arm . . . . . . . . . . . . . . . .

(Used after Serial No. 052090 Cylinder Jack Shaft 1 x 28% ...... 1 655513 Woodruff Key 1/4 xI HRD .... 1 655533 Woodruff Key 5/16 xl HRD ... 1 052109 Sheave Guard . . . . . . . . . . . . . . .. 1

(Parts List Continued On Next Page)

33

150PBF - FEEDER HEAD..,--_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ (Used After Serial No. 1410) Ref. No. 58 59 60

61 62 63 64

65 66

67 68 69

70 71 72 73 74 75 76 77

78

79

80

No. Req.

Ref. No.

052110 Side Guard - Lower ............ 1 652026 Carriage Bolt 5/16 x 3/4 . . . . . .. 1 (3) 5/16 HN 653007 - (3) 5/16 LW 654024 052112 Side Guard ................. .

Carriage Bolt 5/16 x 3/4 652026 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 052116 Belt Guide. . . . . . . . . . . . . . . . . .. 1 Carriage Bolt 5/16 xl, . . . . . . .. 2 652029 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 052130 Belt ............ :. . . . . . . . .. 1 052131 IdlerSheave ................. 1 Carriage Bolt 1/2 x 2. . . . . . . . .. 1 652150 (1) 1/2 HN 653018 - (1) 1/2 LW 654030 052132 Belt. . . . . . . . . . . . . . . . . . . . . .. 1 052144 Belt Guide - Upper. . . . . . . . . . . .. J 652026 Carriage Bolt 5/16 x 3/4 . . . . . .. 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 052145 Belt Guide - Lower. . . . . . . . . . . .. 1 052146 Belt Retainer ................ 1 650025 Hex.Hd.Cap Screw 5/16 x 3/4. . .. 1 (1) 5/16 HN 653007 - (1) 5/16 PW 654004 (1) 5/16 LW 654024 Sheave ...................... 1 052422 650208 Soc.Hd.Set Screw 5/16 x 3/4 .... 2 052585 Belt Retainer. . . . . . . . . . . . . . . .. 1 053024 Tightener Bracket ............ , 1 (Used after Serial No. 1010) 650028 Hex.Hd.Cap Screw 5/16 xl. . . .. 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024 053760 Cylinder Assembled ........... , 1 655533 Woodruff Key 5/16 xl HRD .... 2 655537 Woodruff Key 5/16 x B4 HRD. .. 1 053761 Rake - Right ................ , 7 650028 Hex.Hd.Cap Screw 5/16 xl .... 14 (14) 5/16 LW 654024 053762 Rake - Left. . . . . . . . . . . . . . . . .. 7 650028 Hex.Hd.Cap Screw 5/16 xl ..... 14 (14) 5/16 LW 654024 05.3763 Side Sheet - Front . . . . . . . . . . . .. 1 053764 Side Sheet - Rear . . . . . . . . . . . . .. 1 655008 Cotter Pin 1/8 xl % ......•.. , 1 655020 Cotter Pin 3/16 x 1~ . . . . . . . .. 1 053766 Throat Plate - Middle .......... , 1 053767 Throat Sheet - Lower . . . . . . . . . .. 1 650060 Hex.Hd.Cap Screw 3/8 xl. . . . .. 6 (6) 3/8 SN 653010 - (6) 3/8 LW 654026 053768 Feed Release - Front. . . . . . . . . . .. 1 652026 Carriage Bolt 5/16 x 3/4 ...... 2 (2) 5/16 HN 653007- (2) 5/16 PW 654004 (2) 5/16 LW 654024 053769 Feed Release - Rear . . . . . . . . . . .. 1 652026. Carriage Bolt 5/16 x 3/4 ...... 2 (2) 5/16 HN 653007 -(2) 5/16 PW 654004 (2) 5/16 LW 654024 053770 Cover. . . . . . . . . . . . . . . . . . . . .. 1 650025 Hex.Hd.Cap Screw 5/16 x 3/4· .. , 9 (9) 5/16 HN 653007 - (9) 5/16 PW 654004 (9) 5/16 LW 654024 053778 Hopper Cover ......... , . . . . .. 1

81

Part No.

Part Name

Part No.

Part Name

053779 Hopper Front - Upper. . . . . . . . . .. 1 650261 Truss Head Screw 1/4 x 1/2 . . . .. 6 (6) 1/4 HN 653005 - (6) 1/4 LW 654022 82 053780 Hopper Rear - Upper. . . . . . . . . • .. 1 83 053781 Hopper Side - Upper. . . . . . . . . . .. 1 650001 Hex.Hd.Cap Screw 1/4 x 1/2 .. ., 6 (6) 1/4 HN 653005 - (6) 1/4 LW 654022 84 053784 Hopper Front - Lower. . . . . . . . . .. 1 650261 Truss Head Screw 1/4 x 1/2 . . . .. 2 650263 Truss Head Screw 1/4 x 3/4 . . . .. 2 (4) 1/4 HN 653005 - (4) 1/4 LW 654022 85 053787 Hopper Rear - Lower........... , 1 650261 Truss Head Screw 1/4 x 1/2 . . . .. 2 650263 Truss Head Screw 1/4 x 3/4 . . . .. 2 (4) 1/4 HN 653005 - (4) 1/4 LW 654022 .86 053788 Hopper Side - Lower ........... , 1 650005 Hex.Hd.Cap Screw 1/4 x 3/4 .... 4 (4) 1/4 HN 653005 - (4) 1/4 LW 654022 87 053790 Slide Handle. . . . . . . . . . . . . . . .. 1 88 053793 Slide Handle Support .......... 2 650025 Hex.Hd.Cap Screw 5/16 x 3/4. . .. 4 (4) 5/16 HN 653007 - (4) 5/!6 LW 654024 89 053794 Slide Arm .................. 2 650025 Hex.Hd.Cap Screw 5/16 x 3/4 ... 2 650028 Hex.Hd.Cap Screw 5/16x 1 ..... 2 (4) 5/16 HLN 653073 90 053795 'Hopper Slide ................ 1 91 053798 Slide Clamp. . . . . . . . . . . . . . . . .. 2 92 053799 Cover lift H anile . . . . . . . . . . . .. 1 93 053802 Handle Guide Bracket. . . . . . . . . .. 1 650025 Hex.Hd.Cap Screw 5/16 x 3/4 . .. 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 94 053803 Handle Lift Bracket . . . . . . . . . . .. 1 650025 Hex.Hd.Cap Screw 5/16 x 3/4 ... 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 95 053806 Shredder Knife . . . . . . . . . . . . . .. 4 652048 Carriage Bolt 3/8 x 1. . . . . . . . .. 8 (8) 3/8 HN 653010 - (8) 3/8 PW 654006 (8) 3/8 LW 654026 96 053807 Feed Release Seal ............. 2 97 053808 Conveyor Chain Seal ........... 1 650269 Truss Head Screw 5/16 x 3/4 . . .. 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024 98 053809 Gear Guard. . . . . . . . . . . . . . . . .. 1 652026 Carriage Bolt 5/16 x 3/4 . . . . . .. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 99 053896 Hopper Guard. . . . . . . . . . . . . . .. 1 100 054556 Side Sheet Support ............ 1 (Used after Serial No. 1910) 101 500051 Chain (No. 41) of 108 Links Including One (500043) Connector Link ...

102 500179 Chain (No. 50) of 72 Links Inlcuding One (500057) Connector Link. .. 1 (Used after Serial No. 1010) 103 520063 Ba:1l Bearing . . . . . . . . . . . . . . . .. 4 104 520065 Ball Bearing . . . . . . . . . . . . . . . .. 2 105 520084 Bearing Collar . . . . . . . . . . . . . . .. 4 106 520085 Bearing Collar. . . . . . . . . . . . . . .. 2 A For Replacement, Order 057662.

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

34

No. Req.

No. 1411)

71

WARNING Not Use Illustration • Ord., ByRPfiart Number . D eerence N 0

U

sed before Ser,d No.IllI

L~ ~~A~

II

81

~

gms On Next Page)

~ '(

11

IS

~20 ~

II

S7~

Mixer Conveyor .

Required Wh Dnve Parts Feeder is Moen Power Bale unted.

Used before Serial

(Parts ListSe .

11~ ~

81;W umb",

No. 1211

35

150PBF - FEEDER HEAD _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ (Used Before Serial No. 1411) Ref. No. 1

2 3 4 5

6 7 8 9 10

11 12 13 14 15 16 17 18 19 20 21

22 23

24 25 26

27

Part No.

Part Name

No. Req.

Magnet . . . . . . . . . . . . . . . . . . . .

(Used after Serial No. 111 0) 650263 Truss Head Screw 1/4 x 3/4 . . .. 6 (6) 1/4 HN 653005 . (6) 1/4 LW 654022 5 E77 Bel t Tightener Pulley (4·5/8 Dia.) ..

652084 Carriage Bolt 1/2 x 2"- ..... .

(1) 1/2 HLN 653077 . (1) 1/2 PW 654009 17H140 Shim Washer ................ 4 Keyl/4x3/8xl"- .......... 1 9E176 16E200 Belt. . . . . . . . . . . . . . . . . . . . .. 1 (Used before Serial No. 1111) 052130 Belt. . . . . . . . . . . . . . . . . . . . .. 1 (Used after Serial No. 1110) H267 Shim Washer ................ 1 17H295A Conveyor Sprocket (6T) ........ 1 17H319A Sheave . . . . . . . . . . . . . . . . . . . . 1 (Used after Serial No. 111 0) 9H346 Spring. . . . . . . . . . . . . . . . . . .. 2 (One req'd. before Serial No. 1111) H6053 Pivot Bushing· 9/32 .......... 2 H7163 Idler Arm Spacer. . . . . . . . . . . . .. 1 (Two req'd. before Serial No. 1111) H7794A Sheave (15 Dia.) . . . . . . . . . . . . .. 1 650206 Soc. Hd. Set Screw 5/16 x 1/2 .. 2 H7846 Bearing Retainer . . . . . . . . . . . . .. 8 652026 Carriage Bolt 5/16 x·3/4 ...... 12 (12) 5/16 HN 653007 . (12) 5/16 LW 654024 H8016 Conveyor Drive Sprocket (20T) 1 (Used after Serial No. 111 0) D9048C Bearing (Includes D9139A Bushing) 2 570003 Grease Fitting ............ 2 D9139A Bearing Bushing .............. 2 B11029A Bearing Retainer . . . . . . . . . . . . .. 4 652029 Carriage Bolt 5/16 x l . . . . .. 8 (8) 5/16 HN 653007 . (8) 5/16 LW 654024 B11242 Pivot Bushing· 7/32 .......... 3 B11399 Chain . . . . . . . . . . . . . . . . . . . . 1 (U sed after Serial No. 1110) (2) 1/4 HLN 653071 B11433A Grain Hopper Hook ......... .

(Used after Serial No. 1110) R13227 Bearing Retainer.. . . . . . . . . . . .. 4 (Used before Serial No. 1111) H8334 Bearing Retainer. . . . . . . . . . . . .. 4 (Used after Serial No. 111 0) 652046 Carriage Bolt 3/8 x 3/4 ...... 6 (6) 3/8 HN 653010 . (6) 3/8 LW 654026 S16174 SetCollar . . . . . . . . . . . . . . . . . . 1 650201 So·c. Hd. Set Screw 5/16 x 5/16 1 040563 Pivot Flange ................ 2 570006 Grease Fitting ............ 2 652029 Carriage Bolt 5/16 x l . . . . .. 2 (8) 5/16 HN 653007 . (8) 5/16 LW 654024 040603 Bearing Spacer .............. 2 042865 Hinge . . . . . . . . . . . . . . . . . . . . 1 652069 Truss Head Screw 5/16 x 3/4 .. 7 (7) 5/16 HN 653007· (7) 5/16 LW 654024 043525 Cover Lock Rod ............ .

(Used after Serial No. 1110) 655005 Cotter Pin 1/8 xl ......... .

(2) 3/8 HN 653010 044777 Roll Pin 5/16 x 2 ........... .

3H60

Ref. No.

Part No.

28

048178

29

30

31 32

33

34

35

36 37

38

39 40

41

Part Name

Apron Drive Gear (12T) ....... .

(Used before Serial No. 1111) 052069 Apron Drive Gear (12T) ....... .

(Used after Serial No. 1110) 650214 Soc. Hd. Set Screw 3/8 x 1/2 .. 1 048179 Apron Driven Gear (48T) . . . . .. 1 (Used before Serial No. 1111) 052070 Apron Driven Gear (60T) " ....

(Used after Serial No. 1110) 650214 Soc. Hd. Set Screw 3/8 x 1/2 ..

048182 Idler Pulley ............... .

650117 Hex. Hd. Cap Screw 1/2 x 2"- ..

(1) 1/2HN 653018 . (1) 1/2 PW 654009 (1) 1/2 LW 654030 048183 Powerband Belt .............. 1 048195 Knife Holder· Right .......... 8 (Used before Serial No. 1111) 052062 Knife Holder· Right .......... 8 (Used after Serial No. 1110) 048202 Throat Sheet . Upper ......... .

(Used before Serial No. 1111) 052065 Throat Plate Middle ......... .

(Used after Serial No. 1110) 048203 A Throat Sheet· Lower ......... .

(Used before Serial No. 1111) 052118 Throat Sheet· Lower ......... .

(Used after Serial No. 111 0) 650060 Hex. Hd. Cap Screw 3/8 x 1 6 (6) 3/8 HN 653010 . (6) 3/8 LW 654026 048204 Cover ................... .

(Used before Serial No. 1111) 052091 Cover ................... .

(Used after Serial No. 111 0) 652026 Carriage Bolt 5/16 x 3/4 ...... 9 (9) 5/16 HN 653007· (2) 5/16 PW 654004 (9) 5/16 LW 654024 048205 Cover Extension ............. .

048220 Tightener Arm ............. .

(Used before Serial No. 1111) 052084 Tightener Arm ............. .

(Used after Serial No. 1110) 048223 8 Side Guard . Lower ......... .

(Used before Serial No. 1111) 05211 0 Side Guard· Lower ......... .

(Used after Serial No. 1110) 652026 Carriage Bolt 5/16 x 3/4 ...... 1 (3) 5/16 HN 653007· (3) 5/16 LW 654024 048225 Spring Link ................. 1 650271 Truss Head Screw 5/16 x I I (1) 5/16 HN 653007· (1) 5/16 LW 654024 048226 Chain (No. 40) of 87 Links Including One (500037) Connector Link and One (500038) Offset Link (Used before Serial No. 1111) 500051 Chain (No. 41) of 108 Links Including One (500043) Connector Link .. 1 (Used after Serial No. 1110) 048227 Spring Adjustment Bracket ...... 1 652046 Carriage Bolt 3/8 x 3/4 ...... 2 (2) 3/8 HN 653010 . (2) 3/8 LW 654026

(Parts List Continued On Next Page)

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

36

No. Req.

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 150PBF - FEEDER HEAD (Used Before Serial No. 1411) Ref. No. 42

43

44 45

46

47 48 49

50

51

52 53

54 55

No. Req.

Ref. No.

048228 Linkage Bar . . . . . . . . . . . . . . . . 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 1 652029 Carriage Bolt 5/16 xl ...... 1 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 048229 Cylinder Clutch Handle ....... .

650028 Hex. Hd. Cap Screw 5/16 x I ..

652029 Carriage Bolt 5/16 x I ..... .

(2) 5/16 HN 653007 - (1) 5/16 PW 654004 (2) 5/16 LW 654024 048232 Cylinder Handle Bracket ....... .

652026 Carriage Bolt 5/16 x 3/4 ...... 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 048234 Sheave (3~ Dia.) ............ 1 (Used before Serial No. 1211) 650206 Soc. Hd. Set Screw 5/16 x 1/2 ..

052422 Sheave ..... : ............. .

(Used after Serial No. 1210) 650208 Soc. Hd. Set Screw 5/16 x 3/4 ., 2 048247 Apron Drive Sprocket (12T) . . .. 1 (Used before Serial No. 1111) 650195 Soc. Hd. Set Screw 1/4 x 1/4 ..

050482 Apron Drive Sprocket (11 T) (Used after Serial No. 1110) 650195 Soc. Hd. Set Screw 1/4 x 1/4 .. 1 048248 Conveyor Shaft 1 x 2'6-3/8 ...... 1 655505 Woodruff Key 1/4 x l . . . . .. 1 048249 Conveyor Jack Shaft 1 x 27-1/8 1 655507 Woodruff Key 5/16 x l . . . . .. 2 048250 Cylinder Jack Shaft 1 x 27-5/8 . . .. 1 (Used before Serial No. 1111) 655505 Woodruff Key 1/4 xl ..... .

655507 Woodruff Key 5/16 xl ..... .

052090 Cylinder Jack Shaft 1 x 28~ (Used after Serial No. 1110) 655505 Woodruff Key 1/4 x l . . . . .. 1 655507 Woodruff Key 5/16 x l . . . . .. 2 048251 c Gear Guard . . . . . . . . . . . . . . . . 1 (Used before Serial No. 1111) 052106 Gear Guard ............... .

(Used after Serial No. 111 0) 652026 Carriage Bolt 5/16 x 3/4 ...... 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 048254 Sheave Guard ............... .

(Used before Serial No. 1111) 052109 Sheave Guard. . . . . . . . . . . . . . .. 1 (Used after Serial No. 111 0) 048259 Baffle . . . . . . . . . . . . . . . . . . . .

(Used before Serial No. 1111) 048262 Filler . . . . . . . . . . . . . . . . . . .. 2 (Used before Serial No. 1111) 052073 Filler . . . . . . . . . . . . . . . . . . .. 2 (Used after Serial No. 111 0) 650184 Flat Head Screw 5/16 x 3/4 ... , 4 (4) 5/16 HN 653007 - (4) 5/16 PW 654004 (4) 5/16 LW 654024 048283 Sheave (11 ~ Dia.) ............ 1 650207 SoL Soc. Hd. Set Screw 5/16 x 1/2 2 048284 Sheave (4~ Dia.) . . . . . . . . . . .. 1 650201 Soc. Hd. Set Screw 5/16 x 5/16.. 1 650203 Soc. Hd. Set Screw 5/16 x 3/8 .. 1

56

Part No.

Part Name

57

58

59

60 61

62 63

64

65 66 67

68

Part No.

Part Name

No. Req.

Side Sheet - front ........... .

(Used before Serial No. 1111) 052147 Side Sheet - Front ........... .

(Used after Serial No. 1110) and before Serial No. 1211) 052787 Side Sheet - Front ........... .

(Used. after Serial No. 1210) 048286 Side Sheet - Rear ........... .

(Used before Serial No. 1111) 655008 Cotter Pin 1/8 x 1~ ........ 1 052148 Side Sheet - Rear ............ 1 (Used after Serial No. 1110) 655008 Cotter Pin 1/8 x 1~ ........ 1 048333 Belt Retainer . . . . . . . . . . . . .. 1 (Used before Serial No. 1211) 052585 Belt Retainer ............... .

(Used after Serial No. 1210) 048335 Side Guard ............... .

(Used before Serial No. 1111) 052112 Side Guard ............... .

(Used after Serial No. 1110) 652026 Carriage Bolt 5/16 x 3/4 ...... 2 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 048339 Baffle Bracket - Left ......... .

048415 E Cylinder ................. .

(Used before Serial No. 1111) 655507 Woodruff Key 5/16 x l . . . . .. 1 655508 Woodruff Key 5/16 x 1~ 1 052057 Cylinder ............... . .. 1 (Used after Serial No. 1110) 655507 Woodruff Key 5/16 x 1 655508 Woodruff Key 5/16 x 1~ 048418 Rake . . . . . . . . . . . . . . . . . . . . 14 650028 Hex. Hd. Cap Screw 5/16 xl .. 28 (28) 5/16 LW 654024 048422 Knife Holder - Left . . . . . . . . . . .. 8 (Used before Serial No. 1111) 052064 Knife Holder - Left . . . . . . . . . . .. 8 (Used after Serial No. 1110) 048423 Sprocket (80T) ............. .

(Used before Serial No. 1111) 650206 Soc. Hd. Set Screw 5/16 x 1/2 .. 1 052071 Sprocket (96T) .............. 1 (Used after Serial No. 111 0) 650206 Soc. Hd. Set Screw 5/16 x 1/2 .. 1 048459 Tightener Pulley Spacer ........ 1 (Used before Serial No. 1111) 048753 Idler Sheave Spacer ........... .

049097 Conveyor Drive Guard ......... .

(Used before Serial No. 1111) 052116 Belt Guide . . . . . . . . . . . . . . . . .. 1 (Used after Serial No. 111 0) 652026 Carriage Bolt 5/16 x 3/4 ...... 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 049108° Gear Guard Bracket . . . . . . . . .. 1 (Used before Serial No. 1111) 050480 Gear Guard Bracket ......... .

(Used after Serial No. 1110) (2) 5/16 HN 653007 - (2) 5/16 LW 654024 048285

(Parts List Continued On Next Page)

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

37

150PBF - FEEDER HEAD lUsedBefore Serial No. 1411)

No. Req.

Ref. No.

Part No.

Belt Retainer ............... .

(Used before Serial No. 1111) 052146 Belt Retainer ............... .

(Used after Serial No. 111 0) 650025 Hex. Hd. Cap Screw 5/16 x 3/4 ..

(1) 5/16 HN 653007 - (1) 5/16 PW 654004 (1) 5/16 LW 654024 049145 Baffle Bracket . . . . . . . . . . . . .. 1 049147 E Cylinder Assembled . . . . . . . . .. 1 (Used before Serial No. 1111) ......... .

052056 E Cylinder Assembled (Used after Serial No. 1110) 049464 Retarder Knife .............. 2 (Used before Serial No. 1111) 051972 Shredder Knife .............. 4 (Used after Serial No. 111 0) 652046 Carriage Bolt 3/8 x 3/4 ...... 4 652048 Carriage Bolt 3/8 x l . . . . . . .. 8 (8) 3/8 HN 653010 - (8) 3/8 PW 654006 (8) 3/8 LW 654026 049465 Knife - Right ................ 8 (Used before Serial No. 1111) 052061 Knife - Right ................ 8 (Used after Serial No. 111 0) 650060 Hex. Hd. Cap Screw 3/8 x 1 " 16 (16) 3/8 LW 654026 049466 F Sickle Section .............. 16 (Used before Serial No. 1111) 051934 Sickle Section ....•......... 16 (Used after Serial No. 1110) 654539 Oval Hd. Rivet No. 5* x 1/2 .. 32 049476 Knife - Left ................ 8 (Used before Serial No. 1111) 052063 Knife - Left ................ 8 (Used after Serial No. 1110) 650060 Hex. Hd. Cap Screw 3/8 xl .. 16 (16) 3/8 LW 654026 052066 Throat Plate Bracket .......... 2 (Used after Serial No. 111 0) 652046 Carriage Bolt 3/8 x 3/4 ...... 8 (8) 3/8 HN 653010 - (4) 3/8 PW 654006 (8) 3/8 LW 654026 052067 Throat Plate Support .......... 1 (Used after Serial No. 1110) 052068 Throat Plate Inner ............ 1 (Used after Serial No. 1110) 652046 Carriage Bolt 3/8 x 3/4 ...... 4 (4) 3/8 HN 653010 - (4) 3/8 PW 654006 (4) 3/8 LW 654026 052083 Sheave ................... .

(Used after Serial No. 1110 and before Serial No. 1211) 650208 Soc. Hd. Set. Screw 5/16 x 3/4 .. 1 052092 Cover Slide - Right ............ 1 (Used after Serial No. 1110 and before Serial No. 1211) 052783 Slide - Right ................ 3 (Used after Serial No. 1210) 652020 Carriage Bolt 1/4 x 1/2 ...... 6 (6) 1/4 HN 653005 - (6) 1/4 LW 654022 052093 Cover Assembled . . . . . . . . . . .. 1 (Used after Serial No. III 0 and before Serial No. 1211) 052779 Cover Assembled ........... .

(Used after Serial No. 1210) 052131 Idler Sheave ................ 1 (Used after Serial No. 1110) 652085 Carriage Bolt 1/2 x 2 ....... .

(1) 1/2 HN 653018 - (1) 1/2 LW 654030

83

052132

Ref. No.

Part No.

69

049131

70 71

72

73

74

75

76

77 78

79

80

81

82

38

Part Name

Part Name

No. Req.

Belt ..................... .

(Used after Serial No. 111 0) 84 052135 Cover Slide - Left ........... .

(Used after Serial No. 111 0 and before Serial No. 1211) 85 052142 Feed Release ................ 2 (Used after Serial No. 111 0) 652026 Carriage Bolt 5/16 x 3/4 ...... 4 (4) 5/16 HN 653007 - (4) 5/16 PW 654004 (4) 5/16 LW 654024 86 052144 Belt Guide - Upper ......... .

(Used after Serial No. 1110) 652026 Carriage Bolt 5/16 x 3/4 ...... 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16LW 654024 .

87 052145 Belt Guide - Lower ........... .

(Used after Serial No. 111 0) 88 052207 Grain Hopper ............... .

(Used after .Serial No. 1110) 89 052212 Inlet Hopper Assembled .' .....

(Used after Serial No. 1110 and before Serial No. 1211) 052771 Grain Hopper Assembled ....... .

(Used after Serial No. 1210) 652022 Carriage Bolt 1/4 x 3/4 ...... 8 (8) 1/4 HN 653005 - (8) 1/4 PW 654002 (8) 1/4 LW 654022 Hopper Cover ............. .

90 052214 (Used after Serial No. 1110 and before Serial No. 1211) 052778 Hopper Cover ............. .

(Used after Serial No. 1210) 650023 Hex. Hd. Cap Screw 5/16 x 5/8.. 3 (3) 5/16 HN 653007 - (3) 5/16 PW 654004 (3) 5/16 LW 654024 Inlet Hopper Bolt ........... .

91 052215 (Used after Serial No. 1110) (2) 5/16 HN 653007 - (2) 5/16 LW 654024 Vertical Guard .............. 2 92 052216 (Used after Serial No. 1110) Guard Retainer .............. 1 93 052217 (Used after Serial No. 1110) 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 94 052782 Cover Strap Bracket . . . . . . . . .. 1 (Used after Serial No. 1210) 652024 Carriage Bolt 5/16 x 1/2 ...... 2 (1) 5/16 HLN 653073 - (1) 5/16 WN 653093 95 052784 Brace Assembled .......... " 1 (Used after Serial No. 1210) 96 053024, Tightener Bracket ............ 1 (Used after Serial No. 1110) 650028 Hex. Hd. Cap Screw 5/16 x l . . 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024 97 053087 Hopper Spacer .............. 1 (Used after Serial No. 1110) 98 500179 Chain (No. 50) of 72 Links Including One (500057) Connector Link ..

(Used after Serial No. 1110) 99 520063 Ball Bearing ................ 4 100 520065 Ball Bearing ................ 2 101 520084 Bearing Collar ..... . . . . . . . .. 4 (Two req'd. before Serial No. 1111) 102 520085 Bearing Collar ......... . . . .. 2 AFor Replacement, Order 052118.

B For Replacement, Order 050478.

C Por Replacement, Order 053809.

DPor Replacement, Order 050480.

E Por Replacement, Order 053760.

P Por Replacement, Order 051934.

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 150PBF - FEED CONVEYOR 45

42

55 5

Used before Serial No. 1111 ~--------------

57

lo-l 60' 5.1 ~~ 5&:

.

42

Q

59~ 38

21

WARNING • Order By Part Number . Do Not Use Illustration Reference Numbers

3

. 1.

47

(PaI1l List aagin,On Ntxt .,-" ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS·

91

150PBF - FEED C O N V E Y O R - - - - - - - - - - - - - -_ _ __ No. Req.

Ref. No.

Part No.

Spring . . . . . . . . . . . ........ .

(Used before Serial No. 1111) 2 9H370 Lock Segment .............. 2 3 9H374 Lock Segment Cord - 3/16 x 90 1 4 17H387 Lock Segment Spring .......... 1 5 H6053 Pivot Bushing - 9/32 . . . . . . . . . . 4 (Two req'd. before Serial No. 1111) 6 H8010 Lift Roller Bushing - 9/16 ...... 2 7 H8048 Pivot Bushing - 29/32 . . . . . . . . . . 1 (Used before Serial No. 1111) 8 H8054 Washer . . . . . . . . . . . . . . . . . . . .

(Used after Serial No. 1110) 9 B11242 Pivot Bushing - 7/32 .......... 2 (Used before Serial No. 1111) 10 BI1285 Spring . . . . . . . . . . . . . . . . . . . .

(Used after Serial No. 1110) 11 SI6024 Spring. . . . . . . . . . . . . . . . . . .. I 12 040614 Magnet Hole Cover .. . . . . . . . . .. I (Used before Serial No. IIII and after Serial No. 1410) 650263 Truss Head Screw 1/4 x 3/4 . . .. 6 (6) 1/4 HN 653005 - (6) 1/4 LW 654022 13 042865 Hinge . . . . . . . . . . . . . . . . . . . . 2 650267 Truss Head Screw 5/16 x 5/8 14 650271 Truss Head Screw 5/16 x I .... 3 (17) 5/16 HN 653007 - (17) 5/16 LW 654024 14 048175 Conveyor Sprocket Spacer ...... I 15 048176 Idler Journal . . . . . . . . . . . . . . . . I 16 048177 A Chain Slide ................ I (Used before Serial No. 1411) ............... .

053804 Chain Slide (Used after Serial No. 1410) 650274 Truss Head Screw 5/16 x I ~ 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 17 . 048180 Flap Pivot . . . . . . . . . . . . . . . . . .

18 048184 Conveyor Sprocket (6T) ....... . ........... .

570014 Grease Fitting 650156 Hex. Hd. Cap Screw 5/8 x 4~ ..

(1) 5/8 HN 653021 - (2) 5/8 PW 654012 (I) 5/8 LW 654032 19 048185 Lift Tube . . . . . . . . . . . . . . . . . .

650068 Hex. Hd. Cap Screw 3/8 x 2 I (1) 5/16 HLN 653073 - (I) 3/8 HLN 653075 (I) 5/16 PW 654004 20 048187 Pivot Lift Bracket - Rear ....... .

(Used before Serial No. 1111) 050484 Pivot Lift Bracket - Rear ....... .

(Used after Serial No. 1110) 652026 Carriage Bolt 5/16 x 3/4 ...... 7 (7) 5/16 HN 653007 - (7) 5/16 PW 654004 (7) 5/16 LW 654024 2f: 048188 Pivot Lift Bracket - Front ..... .

(Used before Serial No. 1111) 050483 Pivot Lift Bracket - Front ..... .

(Used after Serial No. 1110) 652026 Carriage Bolt 5/16 x 3/4 ...... 6 (6) 5/16 HN 653007 - (6) 5/16 PW 654004 (6) 5/16 LW 654024 22 048189 Lift Support . . . . . . . . . . . . . . . . I 650056 Hex. Hd. Cap Screw 3/8 x 3/4 .. 4 (4) 3/8 HN 653010 - (4) 3/8 LW 654026 23 048192 Lift Rod ......... ........ .

650066 Hex. Hd. Cap Screw 3/8 x 1* (1) 3/8 HLN 653075

24

048196 8

Ref. No.

Part No. 17H349

40

Part Name

Part Name

No. Req.

Conveyor Table Lift . . . . . . . . . .

(Used before Serial No. 1111) 655032 Cotter Pin 1/4 x 2* ........ 2 050476 Conveyor Table Lift . . . . . . . . . . 1 (Used after Serial No. 1110) 655032 Cotter Pin 1/4 x 2* ........ 2 25 048200 Side Sheet Extension . . . . . . . . . . 2 (Used before Serial No. 1111) 050475 Side Sheet Extension . . . . . . . . . . 2 (Used after Serial No. 1110) 652026 Carriage Bolt 5/16 x 3/4 ...... 8 (8) 5/16 HN 653007 - (4) 5/16 PW 654004 (8) 5/16 LW 654024 26.048201 Extension Reinforcement ...... ,. 4 652029 Carriage Bolt 5/16 x l . .. . .. 16 (16) 5/16 HN 653007 - (16) 5/16 LW 654024 27 048206 Flap ...... , . . . . . . . . . . . . . .. I 28 048207 Flap Extension . . . . . . . . . . . . . . 3 650269 Truss Head Screw 5/16 x 3/4 .. 6 (6) 5/16 HN 653007 - (3) 5/16 PW 654004 (6) 5/16 LW 654024 29 048209 Transport Extension - Front ..... .

(Used before Serial No. 1411) 053776 Transport Extension - Front ..... .

(Used after Serial No. 1410) 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 30 048210 Transport Extension - Rear ..... .

(Used before Serial No. 1411) 053777 Transport Extension - Rear ..... .

(Used after Serial No. 1410) 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 31 048211 Transport Panel - Front ........ 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 650109 Hex. Hd. Cap Screw 1/2 x 1~ .. 2 (2) 5/16 HN 653007 - (2) 1/2 HJN 653044 (2) 5/16 LW 654024 32 048213 Transport Panel - Rear ....... .

(Used before Serial No. 1411) 053775 Transport Panel - Rear ....... .

(Used after Serial No. 1410) 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 PW 654004 (4) 5/16 LW 654024 33 048214 Latch Bracket - Front . . . . . . . . . . 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 3 (3) 5/16 HN 653007 - (3) 5/16 LW 654024 34 048215 Latch Bracket - Rear . . . . . . . . . .

650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 3 (3J 5/16 HN 653007 - (3) 5/16 LW 654024 35 048216 Transport Latch. . . . . . . . . . . . .. 2 (Used before Serial No~ 1411) 053774 Transport Latch ........ . . . . .. 2 (Used after Serial No. 1410) 36 048217° Transport Handle . . . . . . . . . . . .

(Used before Serial No. 1411) 053771 Transport Handle . . . . . . . . . . . .

(Used after Serial No. 1410) 655006 Cotter Pin 1/8 x l . . . . . . . . .. 2 650028 Hex. Hd. Cap Screw 5/16 x l . . 2 (2) 5/16 HN 653007 - (4) 5/16 PW 654004 (2) 5/16 LW 654024

(Parts List Continued On Next Page)

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 150PBF - FEED CONVEYOR Ref. No.

Part No.

37

048233

38 39

40 41

42

43 44

45

47

No. Req.

Conveyor Handle Bracket ..... .

(Used before Serial No. 1111) 048235 Idler Arm ................. .

(Used before Serial No. 1111) 655020 Cotter Pin 3/16 x Ih ........ 1 1 048239 Pivot Bracket .............. " (Used before Serial No. 1111) 052096 Pivot Bracket ............... .

(Used after Serial No. 1110) 655020 Cotter Pin 3/16 x 1h ........ 1 652026 Carriage Bolt 5/16 x 3/4 ...... 4 (4) 5/16 HN 653007 - (4) 5/16 PW 654004 (4) 5/16 LW 654024 048240 Spring Holder ............. .

(Used before Serial No. 1111) 048241' Linkage Bar ............... .

(Used before Serial No. 1111) 052099 Linkage Bar ................ 2 (Used after Serial No. 1110) 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 1 652029 Carriage Bolt 5/16 xl .... " 3 (4) 5/16 HN 653007 - (4) 5/16 PW 654004 (4) 5/16 LW 654024 048243 i Conveyor Handle ........... .

(Used before Serial No. 1111) 052101 Conveyor Handle ........... .

(Used after Serial No. 1110) 570002 Grease Fitting ........... .

650213 Sol Soc. Hd. Set Screw 3/8 x 3/8 048246 Conveyor Handle Extension ..... .

(Used before Serial No. 1111) 048255 Guard Bracket .............. 2 (Used before Serial No. I III) 052114 Guard Bracket ............. .

(Used after Serial No. 1110) 652026 Carriage Bolt 5/16 x 3/4 ..... .

04825~ 5/b~a~NH~~~~~7. ~ ~2?5!~~ .L~ ~~:~~4

(Used before Serial No. I Ill) Grain Hopper ............... .

(Used after Serial No. 141'0) 048267 Conveyor Chain ............. .

Includes: 500005 Plain Link .... . . . . . . . . . . . . 82 049320 Attachment Link .......... 13 048268 Conveyor Table .............. 1 655008 Cotter Pin 1/8 x 1% ........ 2 053175

46

Part Name

Ref. No.

Part No.

Part Name

No. Req.

Grain Hopper Bracket .. . . . . . . .. 2 (Used before Serial No. 1111 and after Serial No. 1410) 49 048429 Pivot Bracket Cap ........... .

(Used before Serial No. 1111) 50 049089 Conveyor Shifter. Stop ......... .

(Used before Serial No. 1111) 51 049144 Lift Roller. . . . . . . . . . . . . . . . .. 2 650029 Hex. Hd. Cap Screw 5/16 x 1% .. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 52 049146 Flap Retainer. . . . . . . . . . . . . . .. 1 53 050205 Seal .................... " 1 (Used after Serial No. 1110) 652136 Carriage Bolt 1/4 x 5/8 ...... 4 (4) 1/4 HN 653005 - (4) 1/4 PW 654002 (4) 1/4 LW 654022 54 050485 Spring Support ............. .

(Used after Serial No. 1110) 55 052074 Tightener Arm Assembled ..... .

(Used after Serial No. 1110) 655019 CotterPin3/16xlh ........ 1 652029 Carriage Bolt 5/16 x l . . . . .. 1 (1) 5/16 HLN 653073 56 052078 Pivot Bracket - Outer ......... . .

(Used after Serial No. 1110) 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 57 052079 Pivot Bracket - Inner ......... .

(Used after Serial No. 1110) .

650025 Hex. Hd. Cap S~rew 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 58 052082 Pivot Bracket Support ......... .

(Used after Serial No. 1110) 652026 Carriage Bolt 5/16 x 3/4 ...... 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 59 052163 Shifter Plate ............... .

(Used after Serial No. 1110) 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024 60 052164 Shifter Plate Brace ........... .

(Used after Serial No. 1110) 61 666000 Deten t Ball ............... .

(Used after Serial No. 1110) A For Replacement, Order 053804.

B For Replacement, Order 050476.

C For Replacement, Order 053774.

DPor Replacement, Order 053771.

E For Replacement, Order 053175.

48

048396

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

41

120MX - ACCESSORIES _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __

14

17

~

3

7 9

13

0-'

5

Ref. No. 1

2 3 4 5 6 7 8 9 10 11

12 13 14

42

Part No.

Part Name

No. Req.

Bagger. . . . . . . . . . . . . . . . . . ..

6H2A 650005 Hex. Hd. Cap Screw 1/4 x 3/4 ..

(2) 1/4 HN 653005 - (2) 1/4 LW 654022 Bag Lock . . . . . . . . . . . . . . . . . .

6H9 6E27 Bagger Shutter Support ........

6H75 Wagon Box Spout ............

650056 Hex. Hd. Cap Screw 3/8 x 3/4 ..

(2) 3/8 HN 653010 - (4) 3/8 PW 654006 6J78 Wagon Box Spout Pivot ........

6HI08A Bagger Shutter ..............

650001 Hex. Hd. Cap Screw 1/4 x 1/2 ..

(2) 1/4 HN 653005 - (2) 1/4 LW 654022 6H128 Wagon Box Spout Inlet ........

6H129 Attachment Clamp ............

650036 Hex. Hd. Cap Screw 5/16 x 2 ..

(2) 5/16 HN 653007 6H133 Wagon Box Spout Assembled ....

6H134A Bagger Assembled ............

040250 Conveyor Housing Extension 650025 Hex. Hd. Cap Screw 5/16 x 3/4..

(4) 5/16 HN 653007 - (8) 5/16 PW 654004 (4) 5/16 LW 654024 040860 Clip. . . . . . . . . . . . . . . . . . . . ..

042188 Hopper Magnet ..............

043658 Bagger Extension Pipe . . . . . . . . ..

1 2

Ref. No. 15 16 17

Part No.

Part Name

No. Req.

043991 Trough Cover . . . . . . . . . . . . . . .. 1 048099 Conveyor Extension . . . . . . . . .. 1 048102 Conveyor Coupling .. . . . . . . . . .. 1 2 650034 Hex. Hd. Cap Screw 5/16 x 1% ., 2 1 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 2 1~ 049049 Fender - Right .............. 1 2 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 3 (3) 5/16 HN 653007 - (2) 5/16 PW 654004 2 (3) 5/16 LW 654024 1 19 049053 Fender - Left . . . . . . . . . . . . . . .. 1 2 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 3 (3) 5/16 HN 653007 - (2) 5/16 PW 654004 1 (3) 5/16 LW 654024 1 20 049056 Fender Support .............. 2 1 650056 Hex. Hd. Cap Screw 3/8 x 1% .. 4 (4) 3/8 HN 653010 - (8) 3/8 PW 654006 1 (4) 3/8 LW 654026 1 21 052054 Audible Alarm................. 1 1 22 052152 Attachment Adapter .......... 1 4 650021 Hex. Hd. Cap Screw 5/16 x 1/2.. 4 650301 Truss Head Screw 5/16 x 1/2 .. 4 (8) 5/16 HN 653007 - (8) 5/16 PW 654004 4 (8) 5/16 LW 654024 1 23 052158 Adapter Support . . . . . . . . . . .. 2 1 24 650350 Bagger Bolt 5/16 x B4 . . . . . . .. 2 (6) 5/16 HN 653007 - (4) 5/16 PW 654004 ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 120MX • ACCESSORIES

15

\

9

MO LASSES Po TT ACHMENT Ref. No. 1

2 3 4 5 6

7 8 9 10 11

12 13 14 15

16

Part No.

No. Req.

Ref. No.

7H120 Pump Drive Belt •............. 1 Spring A162 1 17H260 Strainer ..................... 1 17H270 Driven Sheave (4 Dia.) . . . . .. . . . . 1 650206 Soc. Hd. Set Screw 5/16 x 1/2 .. 1 17H271 Suction Hose (78") ..... ~ . ; .... 1 Discharge Hose (90") 17H273 1 A571 Hose Connection .............. 2 H6046 Spring Clip .................. 1 650040 Hex. Hd. Cap Screw 5/16 x 2~ .. 1 (2) 5/16 HN 653007 H6053A Pivot Bushing . . . . . .. . . . . . . . . . 2 H7123 Shifter Clamp ................ 1 040277 Drive Sheave (3 Dia.) .......... 1 650201 Soc. Hd. Set Screw 5/16 x 5/16 . 1 041142 Discharge Pipe· Front (17'~' ..... 1 041143 Discharge Pipe· Rear (21·3 8") .... 2 049379 Discharge Pipe Base . . . . . . . . . . . . 2 049380 Molasses Pump Base 1 650062 Hex. Hd. Cap Screw 3/8 x 1% •. 2 (2) 3/8 HN 653010 • (4) 3/8 PW 654006 (2) 3/8 LW 654026 049383 Shifter Clamp Bracket . . . . . . . . . . 1 650060 Hex. Hd. Cap Screw 3/8 xl .... 2 (2) 3/8 HN 653010 • (2) 3/8 LW 654026

17

Part Name

.................... ..........

..........

Part No.

Part Name

No. Req.

049384 aook Bolt ..................

(1) 1/2 HN 653018· (2) 1/2 PW 654009 655006 Cotter Pin 1/8x 1 .........• 18 049385 Pivot Bracket· Front ...........

650060 Hex. Md. Cap Screw 3/8 xl ....

(2) 3/8 HN .653010 . (2) 3/8 LW 654026 19 049386 Belt Guard .............. '.' ..

20 049390 .Hook Bolt Sleeve ..............

Belt Guide ..................

21 . 049398 22 056060A Hose Clamp (1 ~ 1.0.) ...........

23 580065 Molasses Pump ................

650062 Hex.Hd.Cap Screw 3/8 x 1% •...

(2) 3/8 HN 653010· (2) 3/8 LW 654026 24 580066 Spray Nozzle ................

25 660010 90: Elbow· 3/4 ..•....•.•..•• 26 660014 90 RedUCing Elboy!· 3/4 x 1/2 •.•.

27 660021 .90° Street Elbow· 3/4 ...........

28 660024 Reducing Tee .3/4 x 314 to.1/2 ....

29 660027 Pipe Coupling· i/2 ............

30 660041 Pipe Nipple· 3/4 x 12 ......•...

31 660045 Reducing Bushing· 1/2 to 1/4 •..•.

32 660056 45° Elbow· 3/4

..............

1 1 1 2 1 1 1 4 1 2 2

1 1 2

1 2 1 2 1

A For Replacement, Order 055335.

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

43

150PBF - HYDRAULIC FEEDER HEAD _ _ _ _ _ _ _ _ _ _ _ __

31 ,

•

" ?"--... n

~

41

Mixer Conveyor Drive Parts Required When Power Bale Feeder is Mounted.

WARNING - Order By Part Number - Do Not Use Illustration Reference Numbers

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

44

61

i

_ _ _ _ _ _ _ _ _ _ _ _ _ 150PBF - HYDRAULIC FEEDER HEAD t

Ref. No. 2 3 4

5 6 7

8 9

10 11 12 13 14 15

16 17 18

19

20 21

22 23 24 25 26

27

Part No.

Part Name

No. Req.

Ref. No.

Part No.

Part Name

No. Req.

17H 140 Shim Washer ................ 4 28 048232 Cylinder Handle Bracket ........ 1 Key 1/4 x 3/8 x 1h .......... 1 652026 Carriage Bolt 5/16 x 3/4 ...... 4 9E176 17H295A Conveyor Sprocket (6T) ........ 1 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 9H346 Spring. . . . . . . . . . . . . . . . . . .. 1 29 048248 Conveyor Shaft 1 x 26-3/8 ...... 1 H6053 Pivot Bushing - 9/32 .......... 2 655513 Woodruff Key 1/4 x 1 HRD . . . . 1 H7846 Bearing Retainer. . . . . . . . . . . . .. 8 30 048249 Conveyor Jack Shaft 1 x 27-1/8 1 652026 Carriage Bolt 5/16 x 3/4 ...... 12 655533 Woodruff Key 5/16 xI HRD .. " 1 (12) 5/16 HN 653007 - (12) 5/16 LW 654024 31 048283 Sheave (11~ Dia.) ............ 1 H8010 Bushing. . . . . . . . . . . . . . . . . . .. 1 650207 Soc. Hd. Set Screw 5/16 x 1/2 .. 2 H8016 Conveyor Drive Sprocket (20T) .. 1 32 048284 Sheave (4~ Dia.) ... . . . . . . . .. 1 (Used after Serial No. 1010) 650201 Soc. Hd. Set Screw 5/16 x 5/16.. 1 H8334 Bearing Retainer. . . . . . . . . . . . .. 4 650203 Soc. Hd. Set Screw 5/16 x 3/8 .. 1 652046 Carriage Bolt 3/8 x 3/4 ...... 6 33 048333 Belt Retainer . . . . . . . . . . . . . . .. 1 (6) 3/8 HN 653010 - (6) 3/8 LW 654026 (Used before Serial No. 1211) D9048C Bearing (Includes D9139A Bushing) 2 052585 Belt Retainer ............... .

570003 Grease Fitting .......... " 2 (Used after Serial No. 1210) D9139A Bearing Bushing .............. 2 34 048339 Baffle Bracket - Left .......... 1 BI1029A Bearing Retainer. . . . . . . . . . . . .. 4 35 048418 Rake .................... 14 652029 Carriage Bolt 5/16 xl ...... 8 (Used before Serial No. 1411) (8) 5/16 HN 653007 - (8) 5/16 LW 654024 053761 Rake - Right ................ 7 B11242 Pivot Bushing - 7/32 .......... 3 (Used after Serial No. 1410) S16174 Set Collar .................. 1 650028 Hex. Hd. Cap Screw 5/16 xI .. 14 650201 Soc. Hd. Set Screw 5/16 x 5/16.. 1 (14) 5/16 LW 654024 040563 Pivot Flange ................ 2 36 048753 Idler Sheave Spacer . . . . . . . . . . .. 1 570006 Grease Fitting . . . . . . . . . . .. 2 37 048947 Flow Control To Motor Hose - 60" 1 652029 Carriage Bolt 5/16 x l . . . . .. 2 38 049073 Hydraulic Motor (Char-Lynn). . . . .. 1 (8) 5/16 HN 653007 - (8) 5/16 LW 654024 650056 Hex.Hd.Cap Screw 3/8 x 3/4 . . .. 4 040603 Bearing Spacer .............. 2 (4) 3/8 LW 654026 Hinge .................... 1 056203 Hydraulic Moto~ (Ross). . . . . . . . .. 1 042865 650269 Truss Head Screw 5/16 x 3/4. . .. 7 650056 Hex.Hd.Cap Screw 3/8 x 3/4 ... _ 4 (4) 3/8 LW 654026 (7) 5/16 HN 653007 - (7) 5/16 LW 654024 043525 Cover Lock Rod. . . . . . . . . . . . . .

39 049074 Motor To By-Pass Hose - 24'~ . . . . .. 1 (Used after Serial No. 1010) 40 049145 Baffle Bracket .............. " 1 655005 Cotter Pin 1/8x 1 ..........

41 050480 Gear Guard Bracket. . . . • . . . . . .. 1 (2) 3/8 HN 653010 650025 Hex.Hd.Cap Screw 5/16 x 3/4 . " 1 044777 Roll Pin 5/16 x 2 ............

(2) 5/16 HN 653007 - (2) 5/16 LW 654024 (Used before Serial No. 1411) 42 050480 Apron Drive &procket (lIT). . . . . .. 1 Spring Pin 5/16 x H4 ......... . 6 5 0 1 9 5 Soc.Hd.Set Screw 1/4x 1/4 ... " 1 049371 (Used after Serial No. 1410) 43 051934 Sickle Secti"on ................ 16 048092 Coupling .................. 1 654539 Oval Head Rivet - No. 5~ x 1/2 .. 32 650201 Soc. Hd. Set Screw 5/16 x 5/16.. 2 44 051972 Shredder Knife. . . . . . . . . . . . . . .. 4 048182 Idler Pulley . . . . . . . . . . . . . . .. 1 (Used before Serial No. 1411) 650117 Hex. Hd. Cap Screw 1/2 x 2h .. 1 053806 Shredder Knife .......... ~ ..... 4 (1) 1/2 HN 653018 - (1) 1/2 PW 654009 (Used after Serial No. 1410) (1) 1/2 LW 654030 652048 Carriage Bolt 3/8 xl.. . . . . . . .. 8 048183 Powerband Belt ..............

(8) 3/8 HN 653010 - (8) 3/8 PW 654006 048205 Cover Extension ......... '. .. . .

(813/8 LW 654026 048225 Spring Link ................

45 052056 Cylinder Assembled . . . . . . . . . . .. 1 650271 Truss Head Screw 5/16 x l . . . .

(Used before Serial No. 1411) (1) 5/16 HN 653007 - (1) 5/16 LW 654024 053760 Cylinder Assembled ............ .

048227 Spring Adjustment Bracket ...... I (Used after Serial No. 1410) Carriage Bolt 3/8 x 3/4 ...... 2 655533 Woodruff Key 5/16 xI HRD. . .. 2 652046 (2) 3/8 HN 653010 - (2) 3/8 LW 654026 655537 Woodruff Key 5/16 x 1~ HRD. .. 1 048228 linkage Bar ................

46 052057 Cylinder. . . . . . . . . . . . . . . . . . .. 1 650028 Hex. Hd. Cap Screw 5/16 x I . .

655533 Woodruff Key 5/16 xl HRD. . .. 2 652029 Carriage Bolt5/16"x1 ......

655537 WoodruffKey5/16xl~HRD ...

2 (2) 5/16 HN 653007 - (2) 5/16 PW'654004 47 052061 Knife - Right. , . . . . . . . . . . . . . .. 8 650060 Hex.Hd.Cap Screw 3/8 xl. ..... 16 (2) 5/16 LW 654024 048229 Cylinder Clutch Handle ........

(16) 3/8LW 654026 650028 Hex. Hd. Cap Screw 5/16 x I " 48 052062 Knife Hold.}r - Right. . . . . . . . . . . . 1 652029 Carriage Bolt 5/16 x I ......

49 052063 Knife - Left. ........ " . . . . . . .. 8 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 650060 Hex.Hd.Cap Screw 3/8 x 1. • . . .. 16 (16) 3/8 LW 654026 (2) 5/16 LW 654024 50 052064 Knife Holder - Left ............ 1 ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

45

150PBF - HYDRAULIC FEEDER HEAD _ _ _ _ _ _ _ _ _ _ _ __

No. Req.

Ref. No.

Part No.

Throat Plate - Middle ..... , . . . .. 1 (Used before Serial No. 1411) 053766 Throat Plate - Middle ............ 1 (Used after Serial No. 1410) 052066 Throat Plate Bracket ........... 2 652046 Carriage Bolt 3/8 x 3/4 . . . . . . .. 8 (8) 3/8 HN 653010 - (4) 3/8 PW 654006 (4) 3/8 LW 654026 052069 Apron Drive Gear (12T) . . . . . . . .. 1 650214 Soc.Hd.Set Screw 3/8 x 1/2 . . . .. 1 052070 Apron Drive Gear (60T) . . . . . . . .. 1 650214 Soc.Hd.Set Screw 3/8 x 1/2 .... , 1 052071 Sprocket (96T) ............. ~ .. 1 650206 Soc.Hd.Set Screw 5/16 x 1/2 . . .. 1 052073 Filler . . . . . . . . . . . . . . . . . . . . .. 2 650184 Flat Head Screw 5/16 x 3/4 . . . .. 4 (4) 5/16 HN 653007 - (4) 5/16 PW 654004 (4J 5/16 LW 654024 052084 Tightener Arm. . . . . . . . . . . . . . .. 1 (Used before Serial No. 2511) 057662 Tightener Arm ............... .

(Used after Serial No. 2510) 05209 i Cover ..................... .

(Used before Serial No. 1411) 053770 Cover ............. _......... .

(Used after Serial No. 1410) 652026 Carriage Bolt 5/16 x 3/4 . . . . . .. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 052109 Sheave Guard. . . . . . . . . . . . . . .. 1 052110 Side Guard - Lower .......... 1 652026 Carriage Bolt 5/16 x 3/4 ...... 1 (3) 5/16 HN 653007 - (3) 5/16 LW 654024 052112 Side Guard. . . . . . . . . . . . . . . . .. 1 652026 Carriage Bolt 5/16 x 3/4 . . . . . .. 2 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 052118 Throat Sheet - Lower. . . . . . . . . .. 1 (Used before Serial No.1411) 053767 Throat Sheet- Lower .......... .

(Used after Serial No. 1410) .

650060 Hex.Hd.Cap Screw 3/8 xl. . . . .. 6 (6) 3/8 HN 653010 - (6) 3/8LW 654026 052142 Feed Release ................ 2 (Used before Serial No. 1411) 053768 Feed Release - Front .......... .

(Used after Serial No. 1410) 652026 Carriage Bolt 5/16 x 3/4 ........ 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 052147 - Side Sheet - Front. . . . . . . . . . . . .. 1 (Used before Serial No. 1211) 052787 Side Sheet - Front ., ......... " 1 (Used after Serial No. 1210) and before Serial No.1411) 053763 Side Sheet - Front . . . . . . . . . . . .. 1 (Used after Serial No. 1410)

68

052148

Ref. No.

Part No.

51

052065

52

55 56 57 58

59

60

62 63 64 65

66

67

Part Name

69

70 71

72

73

74

75 76 77 78 79 80 81 82 83

Part Name

Side Sheet - Rear ............. .

(Used before Serial No. 1411) 655008 Cotter Pin 1/8 x 1~ .......... .

053764 Side Sheet - Rear ............. .

(Used after Serial No. 1410) 655008 .cotter Pin 1/8 x 1~ ......... .

655020 Cotter Pin 3/16 x 1~ ........ .

052174c Forque Arm ............... .

650029 Hex.Hd.Cap Screw 5/16 x 1~ ... .

(1) 5/16 HN 653007 - (1) 5/16 PW 654004 (1) 5/16 LW 654024 652175 CylioderJack Shaft 1 x 25-7/8 .... .

655513 Woodruff Key 1/4 x IHRD .... .

052176 Release Cord ............... .

650294 Hex.Hd.Self-Tapping Screw 1/4 x 3/8 .............. .

(1) 1/4 PW 654002 053024 Tightener Bracket ............ .

(Used after Serial No. 1010) 650028 Hex.Hd.Cap Screw 5/16 xl. . . .. 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024 053762 Rake - Left . . . . . . . . .. . . . . . . .. 7 (Used after Serial No. 1410) 650028 Hex.Hd.Cap Screw 5/16 xl ..... 14 (14) 5/16 LW 654024 053769 Feed Release - Rear ........... .

(Used after Serial No. 1410) 652026 Carriage Bolt 5/16 x 3/4 .. , . . . .. 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 053807 Feed Release Seal ............. 2 (Used after Serial No. 1410) 053808 Conveyor Chain Seal. ............ 1 650269 Truss Head Screw 5/16 x 3/4 . . .. 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024 054556 Side Sheet Support ............ I (Used after Serial No. 500051 Chain (No. 41) of 108 Links Including One (500043) Connector Link .... 1 500179 Chain (No. 50) of 72 Links Including One (500057) Connector Link. .. 1 (Used after Serial No. 1010) 520063 Ball Bearing. . . . . . . . . . . . . . . . . . . 4 520065 Ball Bearing. . . . . . . . . . . . . . . . . . . 2 520084 Bearing Collar . . . . . . . . . . . . . . . . . 4 Bearing Collar . . . . . . . . . . . . . . .. 2 520085

AFor Repfacement, Order 053760.

B For Replacement, Order 057662. c For Replacement, Order 056201.

NOTE: For Hopper parts see Page 64.

NOTE: For Hydraulic Motor Service Parts, see Pages 66, 67, and 68.

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

46

No. Req.

47

150PBF - HYDRAULIC FEED CONVEYOR _ _ _ _ _ _ _ _ _ __ WARNING - Order By Part Number - Do Not Use Illustration Reference Numbers

1 39

~

7

17

ALWAYS GWE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

48

_ _ _ _ _ _ _ _ _ _--150PBF - HYDRAULIC FEED CONVEYOR Ref. No. 1 2 3 4 5 6 7

8 9 10

11 12

13

14 15 16 17 18

19

20

21

22

No. Req.

Ref. No.

Lock Segment ... . . . . . . . . . .. 2 9H370 9H374 Lock Segment Cord 3/16 x 90 . . .. 1 17H387 Lock Segment Spring .......... 1 H6053 Pivot Bushing - 9/32 .......... 2 H8010 Lift Roller Bushing - 9/16 ...... 2 S16024 Spring. . . . . . . . . . . . . . . . . . .. 1 042865 Hinge .................... 2 14 650269 Truss Head Screw 5/16 x 3/4 650271 Truss Head Screw 5/16 x l . . .. 3 (17) 5/16 HN 653007 - (17) 5/16 LW 654024 048175 Conveyor Sprocket Spacer ...... 1 048176 Idler Journal ................ 1 048177 A Chain Slide . . . . . . . . . . . . .. .. 1 (Used before Serial No. 1411) 053804 Chain Slide ............... '.

(Used after Serial No. 1410) 650274 Truss Head SCfew 5/16 x 1~ 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 048180 Flap Pivot .... . ....... " . . .. 1 048184 Conveyor Sprocket (6T) ........ 1 570014 Grease Fitting .......... " 1 650156 Hex. Hd. Cap Screw 5/8 x 4~ .. 1 (1) 5/8 HN 653021 . (2) 5/8 PW 654012 (1) 5/8 LW 654032 048185 . Lift Tube .................. 1 Hex. Hd. Cap Screw 3/8 x 2 1 650068 (I) 5/16 HLN 653073 - (1) 3/8 HLN 653075 (1) 5/16 PW 654004 048189 Lift Support ......... ,...... 1 650056 Hex. Hd. Cap Screw 3j8x 3/4 .. 4 (4) 3/8 HN 653010 - (4) 3/8 LW 654026 048192 Lift Rod .................. 1 1 650066 Hex. Hd. Cap Screw 3/8 x 1~ " (1) 3/8 HLN 653075 048201 Extension Reinforcement . . . . . . .. 4 ·652029 Carriage Bolt 5/16 xl ...... 15 (IS) 5/16 HN 653007 - (15) 5/16 LW 654024 048206 Flap .................... " 1 048207 Flap Extension .............. 3 650269 Truss Head Screw 5/16 x 3/4.. " 6 (6) 5/16 HN 653007 - (3) 5/16 PW 654004 (6) 5/16 LW 654024 .

048209 Transport Extension - Front ..... .

(Used before Serial No. 1411) 053776 TransportExtension - Front. . . . .. 1·· (Used after Serial No. 1410) 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 . (2) 5/16 LW 654024 048210 Transport Extension· Rear ..... .

(Used before Serial No. 1411) 053777 Transport Extension· Rear ..... , (Used after Serial No. 1410) 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 • (2) 5/16 LW 654024 048211 Transport Panel· Front ........ 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 650109 Hex. Hd. Cap Screw 1/2 x 1~ .. 2 (4) 5/16 HN 653007 - (2) 1/2 HJN653044 (4) 5/16 LW 654024 048213 Transport Panel ~. Rear ....... .

(Used before Serial No. 1411) 053775 Transport Panel - Rear ....... .

(Used after Serial No. ·1"410) 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 . (4) 5/16 PW 654004 (4) 5/16 LW 654024

23

Part No.

Part Name

24 25

26

27

28 29 30 31 32 33

34

35 36

37

38 39 40 41 42 43

Part No.

Part Name

No. Req.

048214 Latch Bracket· Front. . . . . . . . .. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 3 (3) 5/16 HN 653007· (3) 5/16 LW 654024 048215 Latch Bracket· Rear ......... .

650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 3 (3J 5/16 HN 653007 . (3) 5/16 LW 654024 048216 Transport Latch .............. 2 (Used before Serial No. 1411) 053774 Transport Latch .............. 2 (Used after Serial No. 1410) 048217c Transport Handle ........... .

(Used before Serial No. 1411) 053771· Transport Handle ........... .

(Used after Serial No. 1410) 655006 Cotter Pin 1/8 x l . . . . . . . . .. 2 650028 Hex. Hd. Cap Screw 5/16 xl. " 2 (2) 5/16 HN 653007 . (4) 5/16 PW 654004 (2) 5/16 LW 654024 048267 Conveyor Chain ............. . .

Includes: 500005· Plain Link ................ 82 049320 Attachment Link .......... 13 048268 Conveyor Table .............. 1 655008 Cotter Pin 1/8 x 1~ ........ 2 048968 . Flow Control ..... ; . . . . . . . . .. 1 650038 Hex. Hd. Cap Screw 5/16 x 2~.. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 049076 Flow Control to ByPass Hose· 60".. 2 049144 Lift Roller ................ " 2 650029 .. Hex. Hd. Cap Screw 5/16 x 1~.. 2 (2) 5/16HN 653007 . (2) 5/16 LW 654024 .049146 Flap Retainer ........ " .• . . . .. 1 050205 Seal. . . . . . . . . . . . . . . . . . . . .. 1 652136 Carriage Bolt 1/4 x 5/8 ...... 4 (4) 1/4 HN 653005 - (4) 1/4 PW 654002 (4) 1/4 LW 654022 050475 Side Sheet Ex,tension .......... 2 652026 Carriage Bolt 5/16 x 3/4 ...... 8 (8) 5/16 HN 653007 - (4) 5/16 PW 654004 (8) 5/16 LW 654024 050476 Conveyor Table Lift .......... 1 655032 Cotter Pin 1/4 x 2~ ........ 2 050483 Pivot Lift Bracket - Front . . . . .. ·1 652026 Carriage Bolt 5/16 x 3/4 ...... 6 (6) 5/16 HN 653007 . (6) 5/16 PW 654004 (6) 5/16 LW 654024 050484 Pivot Lift Bracket - Rear ....... ; 1 652026 Carriage Bolt 5/16 x 3/4 ...... 7 (7) 5/16 HN 653007 - (7) 5/16 PW 654004 . (7) 5/16 LW 654024 050485 Spring Support .............. 1 052114 Guard Bracket ....... . . . . . . . 1 652026 Carriage Bolt 5/16 x 3/4 ...... 1 (2) 5/16 HN 653007 • (2)5/16 LW654024 580058 Straight Adapter Union ......• , 1 580116 900 Adapter Union ... , ......... 3 620040 Sta Strap .................. 1 660079 Straight Street Tee ............ 1

AFor Replacement, Order 053804.

B For. Replacement, Order 053774.

C For Replacement, Order 053771.

49

120MX - HYDRAULIC UNLOADING CONVEYOR _ _ _ _ _ _ _ _ __

22

----IW ~ --()_

5

(Used Before Serial No. 4897 )

~

I

,.

21

I I

'<Itl~~11

ilO

..

.. 11~

S~\~'

3

!,

'-.. '.~

.

~f ~~

...........:....,~... ,

(Used Befm, Serio! No. 261

I ."

21'

w.:;)

l!J

I

6

(',

16

~~~---

IS'@

'5

II

"

II II II II II

\\

~~

~~"5

..-.'J,

Ii" :,,,"'.. ,

- "'-'if."...

8

?

'J~'}~\ 'lJ.

~2

~ ..

• 15

"", "'-10 \

18

1

12

~~

p",

WARNING - O,d" By Numb" - Do Not ~~ ~lIustration Referen~~e Numbers ~1-il .

~

2

18 24 33

31

Part Name

2

3

Ref. No. 1

50

Part No.

Part Name

No. Req.

6H112 Conveyor Bearing . . . . . . . . . . . . . . . 1 570003 Grease Fitting . . . . . . . . . . . . . . . 1 650062 Hex.Hd.Cap Screw 3/8 x 1-1/4 .... 2 (2) 3/8 HN 653010 - (2) 3/8 LW 654026

4 5

7H115

No Req

Conveyor Cap Hinge ............. 1 (Used before Serial No. 2611) 17H333 Conveyor Cap Hinge ............. 1 (Used after Serial No. 2610) 650001 Hex.Hd.Cap Screw 1/4 x 1/2 ..... 3 650021 Hex.Hd.Cap Screw 5/16 x 1/2 .... 2 (3) 1/4 HN 653005 - (2) 5/16 HN 653007 (3) 1/4 PW 654002 - (2) 5/16 PW 654004 (3) 1/4 LW 654022 - (2) 5/16 LW 654024 6H158 Stop Dog . . . . . . . . . . . . . . . . . . . . 1 (Used before Serial No. 2611) 051936 Stop Ratchet . . . . . . . . . . . . . . . . . 1 (Used after Serial No. 2610) 6H160 Conveyor Collar Spacer ........... 2 (Three req'd. before Serial No. 2611) 6H165AA Conveyor Lift Pulley ............ 1 (Used before Serial No. 4897)

_ _ _ _ _ _ _ _ _ _ 120MX -HYDRAULIC UNLOADING CONVEYOR Ref. No. 6

7 8 9 10 11

12

13

14 15

16 17 18

19 20 21

22

No. Req.

No. Req.

Ref. No.

Part No.

6H166AB Hanger Cord Pulley . . . . . . . . . . . . . 1 (Used before Serial No. 3212) 052828 Hanger Cord Pulley ............. 1 (Used after Serial No. 3211 and before Serial No. 4897) 053900 Lift Pulley . . . . . . . . . . . . . . . . . . . 2 (Used after Serial No. 4896) 6HI83 Drain Plug . . . . . . . . . . . . . . . . . . . 1 H7163 Washer . . . . . . . . . . . . . . . . . . . . . I H7165 Washer . . . . . . . . . . . . . . . . . . . . . 2 H80 I 0 Torque Arm Bushing ... . . . . . .... 1 040164 Hanger Cord Hook . . . . . . . . . . . . . . 2 (Used before Serial No. 4897) 046145 Pulley Bracket . . . . . . . . . . . . . . . . 1 (Used after Serial No. 4896) 650341 Hex.Hd.Cap Screw 5/16 x 1-3/4 Gr.5.1 650487 Hex.Hd.Cap Screw 5/16 x I Gr.5 (2) 5/16 HLN 653015 - (1) 5/16 PW 654004 040219 Conveyor Housing . . . . . . . . . . . . . . 1 (Used before Serial No. 2611) 051928 c Conveyor Housing . . . . . . . . . . . . . . 1 (Used after Serial No. 2610 and before Serial No. 3212) 053833 Conveyor Housing . . . . . . . . . . . . . . 1 (Used after Serial No. 3211) 040229 Conveyor Housing End ........... 1 (Used before Serial No. 2611) 051978 Conveyor Spout . . . . . . . . . . . . . . . 1 (Used after Serial No. 2610) 650060 Hex.Hd.Cap Screw 3/8 xl ...... 3 (3) 3/8 HN 653010 - (6) 3/8 PW 654006 (3) 3/8 LW 654026 040244 Conveyor Collar . , . . . . . . . . . . . . . 1 650047 Hex.Hd.Cap Screw 5/16 x 4 ..... 2 (2) 5/16 lIN 653007 - (2) 5/16 LW 654024 040245 Conveyor Ratchet Bracket - Right .... 1 (Used before Serial No. 2611) 051940 Conveyor Ratchet Bracket ......... 2 (Used after Serial No. 2610) 040246 Conveyor Ratchet Bracket - Left .... ·1 (Used before Serial No. 2611) 040278 Ratchet . . . . . . . . . . . . . . . . . . . . . 1 040323 Conveyor Cap . . . . . . . . . . . . . . . . . 1 (Used before Serial No. 2611) 051980 Conveyor Cap . . . . . . . . . . . . . . . . . 1 (Used after Serial No. 2610 and before Serial No. 6229) 058783 Conveyor Cap . . . . . . . . . . . . . . . . . 1 (Used after Serial No. 6228) 040445 Hinge Spacer . . . . . . . . . . . . . . . . . 2 (Used before Serial No. 2611) 040459 Conveyor Gear Shield ........... 1 650005 Hex Hd.Cap Screw 1/4 x 3/4 ..... 3 (3) 1/4 HLN 653071 - (3) 1/4PW 654002 040644 Conveyor Hanger Cord (32 ft.) ..... 1 (Used before Serial No. 4897) 053906 Conveyor Cable (30 ft.). . . ........ 1 (Used after Serial No. 4896) .

040908 U-Bolt .........•............ 1 (Used after SeriaJ No. 3211 and before Serial No. 4897) 056146 Swivel Pulley Bracket 1 (Used after Serial No. 4896) 570014 Grease Fitting 1 650341 Hex.Hd.Cap Screw 5/16 x 1-3/4 Gr.5 1 650545 Hex.Hd.Cap Screw 5/16 x 1-1/4 Gr.5 1 650594 Hex.Hd.Cap Screw 1/2 x 3-1/4 Gr.5 1 (2) 5/16 HLN 653075 - (1) 1/2 HN 653018 (1) 1/2 HJN 653044 - (2) 1/2 PW 654009 (1) 1/2 LW 654030

23

Conveyor . . . . . . . . . . . . . . . . . . . . I (Used before Serial No. 2611) 051931 Conveyor. . . . . . . . . . . . . . . . . . . . 1 (Used after Serial No. 2610 and before Serial No. 6229) 058702 Conveyor . . . . . . . . . . . . . . . . . . . . 1 (Used after Serial No. 6228) 048111 Conveyor Shaft End 1 x 12-3/4 ...... 1 (Used before Serial No. 2611) 051935 Conveyor Shaft End 1 x 15 ........ 1 (Used after Serial No. 2610) 650034 Hex.Hd.Cap Screw '5/16 x 1-3/4 ... 1 (1) 5/16 lIN 653007 - (1) 5/16 LW 654024 048112 Motor Attachment Clamp ......... 1 650029 Hex.Hd~Cap Screw 5/16 x 1-1/4 ... 1 (1) 5/16 HLN 653073 048113 .Conveyor Bearing. . . . . . . . . . . . . . . 1 570003 Grease Fitting . . . . . . . . . . . . . . . 1 650064 Hex.Hd;Cap Screw 3/8 x 1-1/2 .... 2 (2).3/8 HN 653010 - (2) 3/8 LW 654026 048115 Torque Arm . . . . . . . . . . . . . . . . . . 1 048118 0 Conveyor Housing Base ........... 1 (Used before Serial No. 3212) 053854 Conveyor Housing Base ........... 1 (Used after Serial No. 3211) 048125 Guard Bracket . . . . . . . . . . . . . . . . . 1 (1) 5/16 HN 653007 - (1) 5/16 PW 654004 (1) 5/16 LW 654024 048127 Motor Drive Guard . . . . . . . . . . . . . . 1 048132 E Torque Arm Bracket ............. 1 (Used before Serial No. 3212) .

053853 Torque Arm Bracket . . . . . . . . . . . . . 1 (Used after Serial No. 3211) 650029 Hex.Hd.Cap Screw 5/16 x 1-1/4 ... 1 650269 Truss Head Screw 5/16 x 3/4 ..... 3 (4) 5/16. lIN 653007 - (4) 5/16 PW 654004 (4) 5/16 LW 654024 048961 Hydraulic Motor (Char-Lynn) .....• 1 650056 Hex.Hd.Cap Screw 3/8 x 3/4 ..... 4 (4) 3/8 LW654026 056202 Hydraulic Motor (Ross) ........... 1 650056 Hex.Hd.Cap Screw 3/8 x 3/4 ..... 4 (4) 3/8 LW 654026 C~nveyor Assembled ............. 1 051996 (Used after Serial No. 2610 . and before Serial No. 6229) 058701 Conveyor Assembled ......... " .. 1 (Used after Serial No. 6228) 052120 Spout Entension . . . . . . . . . . . . . . . 1 (Used after Serial No. 2610) 650267 Truss Head Screw 5/16 x 5/8 ..... 4 (4) 5/16 lIN 653007 - (4) 5/16 LW 654024 053848 Bearing Adapter Spacer ......... , .. 1 (Used after Serial No~ 3211)

Part No.

Part Name

24

. 25 26

27 28

29 30 31

32

33

34

35

A

Part Name

048108

For Replacement. Order 901037.

B For Replacement, Order 052828.

C For Replacement, Order 053833 w/One 053848.

~ For Replacement, Order 053848 w/One 053854.

E For Replacement, Order 053853.

NOTE: Seepages 66, 67 and 68 for Hydraulic Motor Service

Part&

51

120MX - HYDRAULIC CONVEYOR DRIVE _ _ _ _ _ _ _ _ _ _ __ Used before Serial No. 2611··

40

2~ ~ 27

Ref. No. 1

Z 3 4 5 6 7 8 9

Part No.

Part Name

7H73 Drive Gear Shim . . .. . . . . . . . . .. 2 6H130 Conveyor Pivot Bearing ........ 2 6H136A Pivot Retainer Spacer . . . . . . . . . . 1 17H14d Shim Washer . . . . . . . . . . . . . . . . 1 6H171 Brake Drum . . . . . . . . . . . . . . . . 1 650060 Hex. Hd. Cap Screw 3/8 x 1 4 (4) 3/8 LW 654026 H217 Shift Lever Dog . . . . . . . . . . .. 1 A262 Shifter Spring . . . . . . . . . . . . .. 1 H275 Bearing Retainer. . . . . . . . . . . . .. 4 652026 Carriage Bolt 5/16 x 3/4 ...... 6 (6) 5/16 HN 653007 . (6) 5/16 LW 654024 .

D932A Washer. . . . . . . . . . . . . . . . . . .. 6 (Four req'd. before Serial No. 2611)

(Parts List Continued On Next Page)

5.2

No. Req.

~~~_ _ _ _ _ _ _ _ _ 120MX

Ref. Part No. No. No. Part Name Req. 10 D936 Shifter Clamp - Right .......... 1 570002 Grease Fitting . . . . . . . . . . .. 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 11 D937 Shifter Clamp - Left .......... 1 12 H6053 Shifter Pivot Bushing .......... 5 13 H6094 Hose Clamp ................ 1 650062 Hex. Hd. Cap Screw 3/8 x 1% .. 1 (1) 3/8 HLN 653075 - (1) 3/8 PW 654006 14 H8315 Set Collar .................. 2 650195 Soc. Hd. Set Screw 1/4 x 1/4 .. 2 15 D9048C Bearing....... . . . . . . . . . . . .. 1 (Includes D9139A Bushing) 570012 Grease Fitting ....... . . . .. 1 16 D9139A Bearing Bushing .............. 1 17 B11028 Bearing Bracket Shipl (16 Ga.) .... 2 (Used before Serial No. 2611) 18 BI1028A Bearing Bracket Shim (20 Ga.) . . .. i (Used before Serial No. 2611) 19 BI1029A Bearing Retainer. . . . . . . . . . . . .. 2 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 20 B11335 Bearing Retainer. . . . . . . . . . . . .. 2 652026 Carriage Bolt 5/16 x 3/4 ...... 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 21 M12074 Shifter Lock Spacer . . . . . . . . .. 2 22 040015 Conveyor Drive Gear .......... 2 (Used before Serial No. 2611) 23 040016 Sliding Clutch' .............. 1 24 040214 Shifter Lock ................ 1 650066 Hex. Hd. Cap Screw 3/8 x 1 2 (2) 3/8 HN 653010 - (2) 3/8 PW 654006 (2) 3/8 LW 654026 25 040273 Set Collar .................. 2 650200 Soc. Hd. Set Screw 5/16 x 1/4 .. 2 26 040431 Clutch Shifter ... .. . . . . . . . .. 1 650029 Hex. Hd. Cap Screw 5/16 x 1% .. 1 (1) 5/16 HN 653007 - (1) 5/16 PW 654004 (1) 5/16 LW 654024 27 040727 Pivot Bracket Spacer .......... 2 Drive Gear Spacer ............ 1 28 040728 29 042350 Brake Band ................ 2 (2) 5/16 HLN 653073 .............. 1 30 042359 Brake Bracket 652026 Carriage Bolt 5/16 x 3/4 ...... 1 (1) 5/16 HN 653007 - (1) 5/16 LW 654024 31 042630 Clutch ..... , . . . . . . . . . . . . .. 1 32 047789 Conveyor Drive Shaft 1 x 28-9/16 " 1 655507 Woodruff Key 5/16 x l . . . . .. 2 655512 Tapered Key 5/16 xl.. . . . . .. 1 33 047790 Shifter Handle .............. 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 2 (2) 5/16 HLN 653073 - (2) 5/16 PW 654004 34 047886 Shifter Bracket .............. 1 650028 Hex. Hd. Cap Screw 5/16 xl. .. 1 650062 Hex. Hd. Cap Screw 3/8 x 1% .. 2 (1) 5/16 HN 653007 - (2) 3/8 HN 653010 (4) 5/16 PW 654004 - (2) 3/8 PW 654006 (1) 5/16 LW.654024 - (2) 3/8 LW 654026 35 047887 Bearing Bracket ..............

(Used before Serial No. 2611) 051998 Bearing Bracket ..............

(Used after Serial No. 2610) 652029 Carriage Bolt 5/16 x l . . . . .. 4 (4) 5/16 HN 653007 - (4) 5/16 PW 654004 (4) 5/16 LW 654024 36 047889 Shifter Extension ............ 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 1 650029 Hex. Hd. Cap Screw 5/16 x 1%.. 1 (2) 5/16 HLN 653073 . (2) 5/16 PW 654004 37 048020 Brake Lever ................ 1 (1) 3/8 HLN 653075

* ..

- HYDRAULIC CONVEYOR DRIVE

Ref. Part No. No. 38 048026 39 048116 40

41

42 43

44

45

46 47

48 49 50 51

52

53

54 55 56 57

No Part Name Req Spacer. . . . . . . . . . . . . . . . . . .. 1 Bearing Bracket Shim .......... 2 (Used before Serial No. 2611) 048119 Conveyor Pivot Bracket - Right " 1 650028 Hex. Hd. Cap Screw 5/16 xl ... 2 650106 Hex. Hd. Cap Screw 1/2 x 1% .. 1 (2) 5/16 HN t?53007 - (1) 1/2 HN 653018 (2) 1/2 PW 654009 - (2) 5/16 LW 654024 (1) 1/2 LW 654030 048120 Conveyor Pivot Bracket - Left .... 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 2 650106 Hex. Hd. Cap Screw 1/2 x 1 % " 1 (2) 5/16 HN 653007 - (l) 1/2 HN 653018 (2) 1/2 PW 654009 - (2) 5/16 LW 654024 (1) 1/2 LW 654030 048138 Conveyor Pivot ................ 1 048359 A Conveyor Support . . . . . . . . . . . .. 1 (Used before Serial No. 6219) 058635 Conveyor Support. . . . . . . . . . . .. 1 (Used after Serial No. 6218) 650062 Hex.Hd.Cap Screw 3/8 x 1-1/4 ... 2 650106 Hex.Hd.Cap Screw 1/2 x 1-1/4 ... 6 (2) 3/8 HN 653010 - (6) 1/2 HN 653018 (2) 3/8 PW 654006 - (6) 1/2 PW 654009 (2) 3/8 LW 654026 - (6)'1/2 LW 654030 048738 Connector ................ " 2 650262 Truss Head Screw 1/4 x 5/8 . . . .. 1 650263 Truss Head Screw 1/4 x 3/4 . . . .. 2 (2) 1/4 HN 653005 - (l) 1/4 HLN 653071 (2) 1/4 LW 654022 048739 Valve Bracket . . . . . . . . . . . .. . .. 1 (Used before Serial No. 6219) 058634 Valve Bracket ............... . . (Used after Serial No. 6218) 650005 Hex.Hd.Cap Screw 1/4 x 3/4 .... 2 (2) 1/4 HN 653005 - (2) 1/4 LW 654022 048947 Valve to Motor Hose - 60" . . . . . . .. 2 048962 Selector Valve (Rounded) . . . . . . .. 1 650025 Hex.Hd.Cap Screw 5/16 x 3/4 '" 2 (2) 5/16 LW 654024 058594 Selector Valve (Square). . . . . . . . .. 1 650393 Hex.Hd.Cap Screw 5/16 x 3/4 Gr.5 2 (2) 5/16 LW 654004 049426 Pivot Retainer Spacer .......... 1 051605 Driven Gear (16T) ............. 1 (Used after Serial No. 2610) 051607 Driven Gear (20T) ............. 1 (Used after Serial No. 2610) 051999 Support Bracket - Right ........ .

(Used after Serial No. 2610) 650025 Hex.Hd.Cap Screw 5/16 x 3/4 . .. 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 052000 Support Bracket· Left . . . . . . . . .. 1 (Used after Serial No. 2610) 650025 Hex.Hd.Cap Screw 5/16 x 3/4 . .. 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 058631 Bracket Adapter .......•...... 1 (Used only with 058594 Valve) 650359 Hex.Hd.Cap Screw 5/16 x 2-3/4 Gr.5 2 650426 Hex.Hd.Cap Screw 1/4x I-I/4Gr.5 1 (2) 5/16 HN 653007 - (1) 1/4 HLN 653070 (1) 5/16 LW 654024 520063 Ball Bearing . . . . . . . . . . . . . . . .. 3 520084 Bearing Collar . . . . . . . . . . . . . . .. 3 580058 Straight Adapter Union ......... 2 (Used before Serial No. 5440) 660079 Straight Street Tee - 1/2 ........ .

APor Replacement, Order 011831 Note: See Palle. 85·&7 for Selector Valve ServIce Part..

53

120SAF - HYDRAULIC FEEDER TROUGH _ _ _ _ _ _ _ _ _ _ __

29

5

21

26

Ref. No. Ref. No. 1 2 3 4

5 6

54

Part No.

Part Name

No. Req.

19E27 Trough Lock Bushing . . . . . . . . . . 2 Washer. . . . .. . . . . . . . . . . . . .. 2 17H140 6H183 Drain Plug . . . . . . . . . . . . . . . . .. 1 9H251 Chain Tightener Block . . . . . . . . .. 1 650124 Hex. Hd. Cap Screw 1/2 x 3* .. 1 (1) 1/2 HN 653018 - (2) 1/2 PW 654009 (1) 1/2 LW 654030 H275 Bearing Retainer . . . . . . . . . . . . .. 2 652026 Carriage Bolt 5/16 x 3/4 ...... 3 (3) 5/16 HN 653007 - (3) 5/16 LW 654024 9H370 Lock Segment . . . . . . . . . . . . .. 2

7 8 9 10 11

12 13 14

Part No.

Part Name

No. Req.

9H371 Spring Segment . . . . . . . . . . . . . . 1 9H373 Handle Stop . . . . . . . . . . . . . . . . 1 650028 Hex. Hd.Cap Screw 5/16 x·l .. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 9H374 Lock Segment Cord (3/16 x 90) .. 1 17H387 Lock Segment Spring . . . . . . . . . . 1 D932A Washer. . . . . . . . . . . . . . . . . . .. 3 D975B Drive Shaft Bearing. . . . . . . . . . .. 2 (Includes H8352A Bushing) 570002 Grease Fitting . . . . . . . . . . .. 2 H8010 Torque Arm Bushing . . . . . . . . . . 1 H8352A Bearing Bushing . . . . . . . . . . . . . . 2

(Parts List Continued On Next Page)

_ _ _ _ _ _ _ _ _ _ _ _ 120SAF - HYDRAULIC FEEDER TROUGH Ref. No. 15 16 17 18 19 20

21 22 23 24 25 26 27 28 29 30 31 32 33

34

35

36

37

38

No. Req.

Ref. No.

D9117 Washer. . . . . . . . . . . . . . . . . . .. 1 Ul0063 Uft Handle Spring ............ 1 040166 Conveyor ................ " 1 655507 Woodruff Key 5/16 xI .... " 1 040171 Conveyor Driven Sprocket (45T) .. 1 650204 S·L Soc. Hd. Set Screw 5/16 x 3/8 2 040174 Trough Lift Spring ............ 1 040492 Conveyor Shaft .............. 1 655507 Woodruff Key 5/16 x l . . . . .. 1 650056 Hex. Hd. Cap Screw 3/8 x 3/4 .. 4 (4) 3/8 LW 654026 040494 Trough Hood . . . . . . . . . . . . . . .. 1 650021 Hex. Hd. Cap Screw 5/16 x 1/2.. 2 (2) 5/16 HLN653073 040495 Trough End Cover ............ 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 LW 654024 040503 Uft Support Shaft 1 x 17-1/8 ....

650068 Hex. Hd. Cap Screw 3/8 x 2 ..

(1) 3/8 HLN 653075 040504 Uft Support Tube . . . . . . . . . . . .. 1 (1) 5/16 HLN 653073 - (1) 5/16 PW 654004 040510 Conveyor Drive Shaft 1 x 38-1/8 .. 1 655502 Woodruff Key 3/16 x 3/4 .... 1 040515 Uft Handle ................ 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 2 (2) 5/16 HLN 653073 - (2) 5/16 PW 654004 040532 Conveyor Trough End . . . . .. . . .. 1 650023 Hex. Hd. Cap Screw 5/16 x 5/8 .. 3 (3) 5/16 LW 654024 040535 Trough End Extension ...... " 1 040536 Pivot Rod .................. 2 040693 Conveyor Drive Sprocket (I6T) 1 650322 SoL Soc. Hd. Set Screw 1/4 x 5/16 1 040733 Shim . . . . . . . . . . . . . . . . . . .. 1 040736 Pivot Shaft 1/2 x 7-3/8 ........ 2 655016 Cotter Pin 3/16 x l . . . . . . .. 2 041147 Trough Side - Right Front ...... 1 (Includes 040536) 650267 Truss Head Screw 5/16 x 5/8 .. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 041148 Trough Side - Right Rear . . . . . . .. 1 (Includes 040536) 650267 Truss Head Screw 5/16 x 5/8 .. 2 650269 Truss Head Screw 5/16 x 3/4 .. 1 (3) 5/16 HN 653007 - (1) 5/16 PW 654004 (3) 5/16 LW 654024 041912 Trough Lock Bracket .......... 1 650029 Hex. Hd. Cap Screw 5/16 x JlA.. 2 (2) 5/16 HN 653007 - (2) 5/16 PW 654004 (2) 5/16 LW 654024 041981 Auger Scraper . . . . . . . . . . . . .. 1 650269 Truss Head Screw 5/16 x 3/4 5 650285 Rd. Hd. Mach. ScrewNo.1024x 1/2 2 653003 Hex. Mach. Screw Nut· No. 1024 2 (5) 5/16 HN 653007 • (5) 3/16 PW 654000 (2) 3/16 LW 654020 • (2) 5/16 LW 654024 042085 Shaft Guard· Lower .......... 1 650021 Hex. Hd. Cap Screw 5/16 x 1/2.. 3 650290 Rd. Hd. Mach. ScrewNo.14x 1/2 2 (3) 5/16 LW 654024 047869 Uft Support Segment ..... ;.... 1 650131 Hex. Hd. Cap Screw 1/2 x 4* .. 1 650323 Hex. Hd. Cap Screw 1/2 x 5 1 (2) 1/2 HLN 653077

39

Part No.

Part Name

Part No.

Part Name

No. Req.

047870 Uft Support ................ 1 650075 Hex. Hd. Cap Screw 3/8 x 2% .. 1 (1) 3/8 HLN 653075 40 047989 Transport Support - Upper ...... 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 650104 Hex. Hd. Cap Screw 1/2 x l . . 2 (2) 5/16 HN 653007 • (2) 1/2 HLN 653077 (2) 1/2 PW 654009 - (2) 5/16 LW 654024 41 04 7990 Transport Support • Lower ...... 1 650104 Hex. Hd. Cap Screw' 112 x l . . 2 (2) 1/2 HLN 653077 • (2) 1/2 PW 654009 42 048004 Trough Side - Left Front . . . . . . .. 1 650267 Truss Head Screw 5/16 x 5/8 8 (8) 5/16 HN 653007 - (6) 5/16 PW 654004 (8) 5/16 LW 654024 43 048092 Coupling .................. 1 650035 Hex. Hd. Cap Screw 5/16 x 2 .. 1 650201 Soc. Hd. Set Screw 5/16 x 5/16.. 2 (1) 5/16 HLN 653073 44 048093 torque Arm ................ 1 650029 Hex. Hd. Cap Screw 5/16 x 1% .. 1 650056 Hex. Hd. Cap Screw 3/8 x 3/4 .. 4 (1) 5/16 HN 653007 -(1) 5/16 PW 654004 (1) 5/16 LW 654024 - (4) 3/8 LW 654026 45 048104 Control Support - Front ........ 1 (Used before Serial No. 1336) 048106 Control Bracket - Right ....... .

(Used after Serial No. 1335) 650269 Truss Head ·Screw 5/16 x 1/2 .. 2 (2) 5/16 HN 653007 46 048105 Control Support. Rear ........ 1 (Used before Serial No. 1336) 048107 Control Bracket - Left. . . . . . . . .. 1 (Used after serial No. 1335) 650269 Truss Head Screw 5/16 x 1/2 .. 2 (2) 5/16 HN 653007 47 048172 Trough Side - Left Rear ........ 1 650267 Truss Head Screw 5/16 x 5/8 7 (7) 5/16 HN 653007 - (7) 5/16 PW 654004 (7) 5/16 LW 654024 48 048371 Shaft Guard - Upper. . . . . . . . . . .. 1 49 048961 Hydraulic Motor (Char-Lynn). . . . .. 1 OR 056202 Hydraulic Motor (Ross). . . . . . . . .. 1 50 048966 Hydraulic Hose - 4* . . . . . . . . . . .. 1 51 048968 Flow Control ................ 1 650395 Hex.Hd.Cap Screw 1/4 x 2* .... .2 (2) 1/4 HN 653005· (2) 1/4 LW 654022 52 049060 Conveyor Trough. . . . . . . . . . . . .. 1 650028 Hex.Hd.Cap Screw 5/16 xl. . . .. 2 650285 Rd.Hd.Mach.Screw No. 1024 x 1/2 2 653003 Hex.Mach. Screw Nut· No. 1024 (4) 5/16 HN 653007 • (3) 3/16 LW 654020 (2) 5/16 LW 654024 53 049307 Conveyor Cover .............. 1 650021 Hex.Hd.Cap Screw 5/16 x 1/2. . •. 8 (8) 5/16 HN 653007· (8) 5/16 LW 654024 54 500221 Chain (No. 41) of 66 Links Including One (500043) Connector Link . •. 1 55 520063 Ball Bearing. . . . . . . . . . • . .. . . .. 1 Bearing Collar .. , . . . . . . . . . . . . •. 1 56 520084 45° Adapter Union ......•..... 1 57 580055 90° Adapter Union ............ 1 58 580116 (Three req'd. before Serial No. 1336) NOTE: SIIII PBfII66 for Flow Control Service Partund Hydraulic Motor Service Parts.page. 66, 67, and 68.

55

120SAF - HYDRAULIC FEEDER DRIVE_ _ _ _ _ _ _ _ _ _ _ __

16

_.--_ .. --

15

7--(l, I

1~,

Z--+ "

I 11

",,-

~ 13

WARNING - Order By Part Number - Do Not Use Illustration Reference Numbers

Used before Serial No. 1336

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

5&

_ _ _ _ _ _ _ _ _ _ _ _-120SAF - HYDRAULIC FEEDER DRIVE Ref. No.

Part No. D932A

2

Part Name

No. Req.

Washer. . . . . . . . . . . . . . . . . . ..

(Used after Serial No. 1335)

3

040563 Pivot Flange ................ 1 570006 Grease Fitting .......... " 1 Carriage Bolt 5/16 x 3/4 ...... 4 652026 (4) 5/16 HN 653007 - (4) 5/16 LW 654024

3

040603

4

042350 Brake Band ................

Carriage Bolt 3/8 x 1-1/4 . . . . ..

652048 (l) 3/8 HLN653075

2 1

047924 Pivot Flange ................

652028 Carriage Bolt 5/16 x l . . . . ..

(4) 5/16 HLN 653073

1 4

5

Ref. No.

Part No.

No. Req.

Part Name

13

048097 Pivot Support - Lower . . . . . . . . .. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 6 (6) 5/16 HN 653007 - (6) 5/16 PW 654004 (6) 5/16 LW 654024

14

048436 Pivot Support - Left Upper ...... 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 6 650060 Hex. Hd. Cap Screw 3/8 x 1 3 (9) 5/16 HN 653007 - (9) 5/16 LW 654024 (3) 3/8 HN 653010 - (3) 3/8 LW 654026

Pivot Bearing Spacer ... • . . .. .. 3 (Two req'd. before Serial No. 1336)

15048735

Trough Pivot Frame

. . . . . . . • ..

1

16

048757 Pivot Support - Upper . . . . . . . . .. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 3 (3) 5/16 HN 653007 - (3) 5/16LW 654024

17

048963

Motor to Return Tube Hose - 83" ..

(Used before Serial No. 1336) Motor to Return Tube Hose - 14W' (Used after Serial No. 1335)

1 1

6

Brake Drum ...... . . . . . . . . .. 1 047925 650028 Hex. Hd. Cap Screw 5/16 x l . . 4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 18

048964

7

047979 Chain (l2 Links) . . . . . . . . . . .. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024

Flow Control to ByPass Tube Hose -92" 1 (Used before Serial No. 1336)

19

048965

Flow Control to Relief Valve Hose-86" 2 (One req'd. before Serial No. 1336)

048020 Tightener. . . . . . . . . . . . . . . . . . (l) 3/8 HLN 653075

20

Hose Clamp ................ 2 048961 .. (j50032 Hex. Hd. Cap Screw 5/16 x B~ .. 1 (2), 5/16 HN 653007 - (3)5/16 PW 654004 (1) 5/l~ LW 654024

21

580058

.Straight Swivel Adapter Union ....

(Used aftei:Serial No. 1335)

22

620040

Sta Strap

23

660039

Street Elbow - 1/2 x 900 • . • • . • • • (Used after Serial No. 1335)

24

660079

Straight Street Tee - 1/2 ........

(Used after Serial No. 1335)

8

Spacer. . . . . . . . . . . . . . . . . . ..

1

9

048026

10

048091 Vertical Pivot Support ........ " 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 - (2) 5/16 LW 654024

11

12

·048966

048095 Pivot Support - Front .......... 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 8 (8) 5/16 HN 653007 - (8) 5/16 LW 654024 048096 Pivot Support - Rear .......... 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 8 (8) 5/16 HN 653007 - (8) 5/16 LW 654024

1

..................

2 ,

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

57

150HF - HYDRAULIC HAY FEEDER _ _ _ _ _ _ _ _ _ _ _ _ __ WARNING - Order By Part Number - Do Not Use Illustration Reference Numbers Used before Serial No. 8451

42

J,

11

22

27

37

~ 32

26

23 30

28

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

58

_ _ _ _ _ _ _ _ _ _ _ _ _ _150HF - HYDRAULIC HAY FEEDER Ref. No. 1

2 3 4

5 6 7

8 9 10 11 12 13 14

15 16 17 18 19 20 21

22

23

24 25

26

Part No.

Part Name

No. Req.

7H73 Washer. . . . . . . . . . . . . . . . . . .. 2 9H202A Drive Sprocket (14T) .......... 1 650322 S-LSoc. Hd. Set Screw 1/4 x 5/16 1 17H238 Pivot Arm Bushing ............ 2 9H255 Driven Sprocket (27T) . . . . . . . . .. 1 650211 SoL Soc. Hd. Set Screw 3/8 x 5/16 1 9H300 Hair Pin Cotter .............. 1 H6053 Spring Guide Bushing .......... 2 H8315 Set Collar . . . . . . . . . . . . . . . . . . . 2 650195 Soc. Hd. Set Screw 1/4 x 1/4 . .. 2 H8352A Equalizer Bushing ............ 4 B11242 Lift Arm Bushing ............ 2 040170 Hinge . . . . . . . . . . . . . . . . . . . . 1 652136 Carriage Bolt 1/4 x5/8 ...... 8 (8) 1/4 HN 653005 - (8) 1/4 LW 654022 040500 Equalizer Spring . . . . . .. . . . . . .. 2 040571 Lift Arm Clamp .. . . . . . . . . . . .. 2 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 • (4) 5/16 LW 654024 .

040630 Clamp Shim . . . . . . . . . . . . . . . . 2 040635 Hopper Bottom .............. 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 4 650029 Hex. Hd. (:ap Screw 5/16 x 1% " 2 (6) 5/16 HN 653007 • (6) 5/16 PW 654004 (6) 5/16 LW 654024 040640 Hinge Spacer ................. 1 040661 Roller· Upper .............. 1 655533 Woodruff Key 5/16 x IHRD ... 1 040676 Roller Equalizer .. . . . . . . . . . . .. 2 (Includes H8352A Bushing) 570009 Grease Fitting. . . . . . . . . .. . .. 4 040681 Roller Lift Arm .............. 1 040685 Bumper Support Angle ........ 2 2 650269 Truss Head Screw 5/16 x 3/4 (2) 5/16 HN 653007 • (2) 5/16 LW 654024 040686 Spring Stop ................ 2 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 • (4) 5/16 LW 654024 040710 Roller Lift Segment. Front " . . . . 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 1 (1) 5/16 HN 653007 . (1) 5/16 PW 654004 (1) 5/16 LW 654024 040711 Roller Lift Segment • Rear ...... 1 650269 Truss Head Screw 5/16 x 3/4 .. 1 (1) 5/16 HN 653007 . (1) 5/16 PW 654004 (1) 5/16 LW 654024 042133 Spring Guide ................ 2 650028 Hex. Hd. Cap Screw 5/16 x l . . 2 (2) 5/16 HN 653007 • (2) 5/16 PW 654004 (2) 5/16 LW 654024 042136 Roller Adjustment Pin .•.•..... ; 1 655016 Cotter Pin 3/16 xl. . . .. • . . .. 1 042145 Pivot Arm • Front (Includes One 17H238 and One H8352A Bushing) 1 570003 Grease Fitting. . • • • • • • • • • • •• 1 570005 Grease Fitting. • • • • • • • • • • • .• 1 042147 A Pivot Arm • Rear (Includes One 17H238 and One H8352A Bushing) 1 570002 Grease Fitting. • • • • • • • • • • • •• 1 570008 Grease Fitting. . • • • • • • • • • . •• 1

Ref. ·No. 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46

Part No.

Part Name

No. Req.

042183 Crusher Roller Cover .......... 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4 .. 11 (11) 5/16 HN 653007 • (11) 5/16 LW 654024 047804 Side Plate· Front ............ 1 047806 Side Plate· Rear . . . . . . . . . . . . .. 1 047807 Guard. . . . . . . . . . . . . . . . . . .. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 • (4) 5/16 LW 654024 048085 Torque Arm .....•.......... 1 650056 Hex. Hd. Cap Screw 3/8 x 3/4 .. 4 .

(4) 3/8 LW 654026 048086 Hydraulic Equalizer Pivot ....... .

650269 Truss Head Screw 5/16 x 3/4 .. 2 (2) 5/16 HN 653007· (2) 5/16 LW 654024 048089 Roller· Lower ......• . . . . . .. 1 655502 Woodruff Key 3/16 x 3/4 1 655505 Woodruff Key 1/4 x l . . . . .. 1 048092 Coupling . . . . . . . . . . . . . . . . . . 1 650202 Soc. Hd. Set Screw 5/16 x 5/16.. 2 048968 Flow Control . . . . . . . . . . . . . . .. 1 650368 Hex. Hd. Cap Screw 1/4 x 2% .. 2 (2) 1/4 HN 653005 . (2) 1/4 LW 654022 049072 Control Bracket .............. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2) 5/16 HN 653007 . (2) 5/16 LW 654024 049073 Hydraulic Motor (Char-Lynn). . . . .. 1 OR 056203 Hydraulic Motor (Ross) ........ .

049074 Flow Control to Motor· 24" . . . . .. 2 049075 Flow Control to Relief Valve Hose-41" 1 049076 Flow Control to ByPass Tube· 60': ;. 1 500223 Chain (No. 41) of 47 Links Including One (500043) Connector Link and One (500044) Offset Link . . . . .. 1 580055 45° Adapter Union ............ 1 (Used before Serial No. 8451) 580058 Straight Adapter Union ......... 2 580116 90° Adapter Union ............ 3 620041 Stem Bumper . . . . . . . . . . . . . . .. 2 660079 Straight Street Tee· 1/2 .... . . . .. 1 (Used after Serial No. 8450)

Additional Parts For Hvdraulic Hay Feeder· Swinging Auger Feeder Combination 47 48

049077 580055

Motor to Motor Hose -73" . . . . . .. 1 45° Adapter Union ............ 1 (Used after Serial No. 8450)

AFor Replacement, Order 051573.

NOTE: See Page 66 For Flow Control Servlc. Par", See P,,., 66, 67 ,nd 68 For Hydrsul/c Motor Servlc. P,rtI.

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

59

120MX - HYDRAULIC SYSTEM _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ WARNING - Order By Part Number - Do Not Use Illustration Reference Numbers

38

6

26

43

l~ ~~ 21

.

25

jl> ,

~

...

~~':J,

Used before Serial No. 2611

27

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

60

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 120MX - HYDRAULIC SYSTEM Ref. No. 1

2 3 4

Part No.

No. Part Name

Req.

I3HI6 B Drive Sprocket Key 3/8 x 3/8 x 2 .. .......... " H80l 0 Tube Clip Spjicer M12144 Breather Cap . . . . . . . . . . . . . . . .

048074 Drive Sprocket (45T) ..........

650212 Soc. Hd. Set Screw 3/8 x 3/8 ..

Ref. No.

1 2 1 1 1

23

1 1

25

24

(For 540 RPM Only) 048079 Drive Sprocket (26T) ..........

650212 Soc. Hd. Set Screw 3/8 x 3/8 ..

(For 1000 RPM Only) 5 6

7

8

9 10

11

12

13 14

15

16 17 18

19 20 21 22

048077 Driven Sprocket (I7T) . . . . . . .. 1 650207 SoL Soc. Hd. Set Screw 5/16 x 1/2 2 048081 Drive Chain Guard . . . . . . . . . . . . 1 (Used before Serial No. 2611) 052033 Drive Chain Guard . . . . . . . . . . . . 1 (Used after Serial No. 2610) 650021 Hex. Hd. Cap Screw 5/16 x 1/2.. 3 (3) 5/16 HN 653007 - (3) 5/16 LW 654024 048346 Hydraulic Reservoir . . . . . . . . .. 1 660003 Pipe Plug - 3/8 . . . . . . . . . . . . 1 048355 ByPass Tube . . . . . . . . . . . . . . . . 1 (Used before Serial No. 2611) 051611 ByPass Tube . . . . . . . . . . . . . . . .

(Used after Serial No. 2610) 048356 Return Tube . . . . . . . . . . . . . . . . 1 (Used before Serial No. 2611) 048357 Discharge Conveyor Return Tube 1 (Used before Serial No. 2611) 051612 Discharge Conveyor Return Tube 1 (Used after Serial No. 2610) 048437 Tube Clip . . . . . . . . . . . . . . . . . . 2 650029 Hex. Hd. Cap Screw 5/16 x 1% .. 2 (2) 5/16 HLN 653073 048440 Pump Take-Up Bracket ........ 1 650060 Hex. Hd. Cap Screw 3/8 x 1 2 (2) 3/8 HN 653010 • (1) 3/8 HLN 653075 (3) 3/8 PW 654006· (2).3/8 LW 654026 ......... 1 048441 Pump Support Bracket 650056 Hex. Hd. Cap Screw 3/8 x 3/4 2 (2) 3/8 HN 653010 • (2) 3/8 LW 654026 048442 Support Connector . . . . . . . . . . . . 1 650056 Hex. Hd. Cap Screw 3/8 x 3/4 .. 4 (4) 3/8 HN 653010 - (2) 3/8 PW 654006 (4) 3/8 LW 654026 048443 Pump Support . . . . . . . . . . . . . . 1 4 650060 Hex. Hd. Cap Screw 3/8 x 1 (4) 3/8 HN 653010 - (2) 3/8 PW 654006 (4) 3/8 LW 654026 048460 Hose Bracket .. . . . . . . . . . . . . .. 1 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 2 (2)5/16 HN 653007 • (2) 5/16 LW 654024 048948 Reservoir to Pump Hose ........ 1 048949 Pump To Relief Valve Hose 33". . .. 1 (Used before Serial No. 2611) 051614 Pump to Relief Valve Hose 30" . . .. 1 JUsed after &;rial No. 2610) 048950 45 Adapter Uruon '. . . . . . . . . . .. 1 048951 Straight Adapter Union ........ 1 048952 Tee Adapter Union . . . . . . . . . . .. 1 (Used before Serial No. 2611) 048953 "0" Ring . . . . . . . . . . . . . . . . . . 1

26

27

28 29

Part No.

Part Name

No. Req.

900 Male Adapter Elbow ....... . ~Used before Serial No. 2611) 051616 90 Male Adapter Elbow ....... .

(Used after Serial No. 2610) 048956 Female Run Tee . . . . . . . . . . .. 1 (Used before SerialNo. 2611) 048957 Male Connector . . . . . . . . . . . . . . 2 (Used before Serial No. 2611) 054850 Male Connector . . . . . . . . . . . . . . 1 (Used after Serial No. 2610) 048958 Female Connector . . . . . . . . .. 1 (Used before Serial No. 2611) ........... .

051619 Female Run Tee (Used after Serial No. 2610) 048960 Hydraulic Pump " . . . . . . . . . . .. 1 650060 Hex. Hd. Cap Screw 3/8 xl. . .. 2 (2) 3/8 HN 653010 - (4) 3/8 PW 654006 (2) 3/8 LW 654026 049048 Relief Valve . . . . . . . . . . . . . . . . 1 049066 Chain (No. 40) of 100 links Including One (500037) Connector link ... 1 048955

(For 540 RPM Mixer Only) 049078 30 31 32 33

34 35 36 37 38 39 40 41 42 43 44 45 46

049485 A

Chain (No. 40) of 90 links Including One (500037) Connector link .. 1

(For 1000 RPM Mixer Only)

Oil Filter . . . . . . . . . . . . . . . . . . 1 (Used after Serial No. 2610) 050067 Hydraulic Pump Key 3/16x 3/16 x 1-5/8 1 050142 Mill Drive Guard . . . . . . . . . . .. 1 (Used before Serial No. 2611) 050255 Clamp. . . . . . . . . . . . . . . . . . .. 2 (Used after Serial No. 2610) 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 (4) 5/16 HN 653007 • (4) 5/16 PW 654004 (4) 5/16 LW 654024 051615 Hose· 19% . . . . . . . . . . . . . . . . 1 (Used after Serial No. 2610) 052045 Female Connector . . . . . . . . . . . . 1 (Used after Serial No. 2610) 052472 Pipe Nipple - 1/2 x 4 .......... 1 ~Usedafter Serial No. 2610) 580055 45 Adapter Union . . . . . . . . . . .. 1 (Used after Serial No. 2610) 660010 Pipe Elbow· 3/4 x 900 . . • . • • • • 1 (Two r~'d. before Serial No. 2611) 660015 90° Street Elbow ·1/2 x 3/8 . . . . .. 1 (Used before Serial No. 5441) 660021 Street Elbow· 3/4 x 1-1/2 . . . . . . .. 1 (Used after Serial No. 2610) 660027 Pipe Coupling - 1/2 ............ 1 (Used after Serial No. 2610) 1 660060 Reducing Tee - 1/2 x 1/2 x 3/8 660076 Pipe Nipple. 3/4 x 1 1 (Used before Serial No. 2611) , 660077 Pipe Nipple - 3/4 x 3. . . . . . . . . . .. 1 660078 Pipe Nipple. 3/4 x 7-5/8 . . . . . . • .. 1 660081 90° Street Elbow - 3/4 x 1/2 . . . . .. 1

* ........ ..

AFor Replacement Cartridge, Order Part Number 048959.

• For Replacement, Order 056230.

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

61

120MX - FOLDING CONVEYOR _ _ _ _ _ _ _ _ _--:::========~

31

~

/(j,"

~

17 i

36

, I

i

19 •~

WARNING - Order By Part Number - Do 18 Not Use Illustration Reference Numbers

~' Part No. 4

5 Ref. No.' 1

2

3

62

No. Part Name Req. Set Collar .................... 1 (Used before Serial No. 6229) 650214 Soc.Hd.Set Screw 3/8 x 1/2 ...... 1 6H 112 Conveyor Bearing . . . . . . . . . . . . . . . 1 (Used before Serial No. 6229) 570003 Grease Fitting ............... 1 058686 Bearing Bracket ................ 1 (Used after Serial No. 6228) 650687 Carriage Bolt 5/16 x 3/4 Gr. 5 .... .4 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 H7126 Washer ...................... 2 '.

(Used before Serial No. 6229) Part No. 5J28A

6 7 8 9

10

H8054

Part Name

No. Req.

Washer ...................... 1 (Used before Serial No. 6229) H8330 Washer ...................... 2 (Used before Serial No. 6229) H8353 Washer ...................... 1 (Used before Serial No. Ul0014 Latch Spring - Rear .............. 1 Ul0014A Latch Spring - Upper ............. 1 650393 Hex.Hd.Cap Screw 5/16 x 3/4 Gr.5 ..1 (1) 5/16 HLN 653073 - (1) 5/16 PW 654004 Ul0014C Latch Spring - Lower ............ 1 650393 Hex.Hd.Cap Screw 5/16 x 3/4 Gr.5 .1 (1) 5/16 HLN 653073 - (1) 5/16 PW 654004 040908 U-Bolt ...................... 1 (Used before Serial No. 4897) 055096 U-Bolt ...................... 1 (Used after Serial No. 4896 and before Serial No. 6229)

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 120MX - FOLDING CONVEYOR Ref. No. 11

12

13 14

15

16

17 Ib

19 20 21 22

23 24

25

26

27 28

Part No. No. Ref. Part Name Req. No. Part Name Req. No. Winch Bracket. ................ 1 29 052568 Bearing Retainer ............... 2 650486 Hex.Hd.Cap Screw 5/16 x 3/4Gr.5 .4 (Used before Serial No. 3911) B11335 Bearing Ret:tiner ............... 2 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 (Used .after Serial No. 3910) 30 052570 _ Winch Bracket Flange ............ 1 650031 Hex.Hd.Cap Screw 5/16 x 1-1/2 . . .2 650486 Hex.Hd.Cap Screw 5/16 x 3/4 Gr.5.4 (2) 5/16 HN 653007 - (2) 5/16 LW 654024 650538 Truss Head Screw 5/16 x 3/4 Gr.5 .. 4 045335 (8) 5/16 HN 653007 - (8) 5/16 PW 654004 Ball Bearing .................. 1 (8) 5/16 LW 654024 (Used before Serial No. 3911) 053981 Ball Bearing .................. 1 31 052572 Pilot Pin ..................... 1 (Used after Serial No. 3910) 32 052582 Winch ...................... 1 045336 Bearing Collar ................. 1 650488 Hex.Hd.Cap Screw 3/8 x 3/4 ..... 3 (Used before Serial No. 3911) (3) 3/8 HN 653010 (1) 3/8 PW 654006 051925 Conveyor ............... " ... 1 (3) 3/8 LW 654024 (Used before Serial No. 6229) 33 052816 Conveyor Housing Extension ....... 1 655507 Woodruff Key 5/16 xl ......... 1 34 052821 Hinge Clamp - Center ............ 1 058700 Conveyor .... : ............... 1 --650321 . Hex.Hd.Cap Screw 5/16 x 2 Gr.5 ... 4 (Used after Serial No. 6228) (4) 5/16 HN 653007 - (3) 5/16 PW 654004 655028 Cotter Pin 1/4 x 1-1/2 ......... 1 (4) 5/16 LW 654024 655533 Woodruff Key 5/16 xl HRD ..... 1 35 052823 Latch Clamp - Center . : .......... 1 051978 Conveyor Housing End ........... 1 36 052824 Guide Latch Ctamp ............. 1 650393 Hex.Hd.Cap Screw 5/16 x 3/4 .... 4 .

650577 Hex.Hd.Cap Screw 5/I6x l-I/2Gr.5 4 (4) 5/16 HN 653007 - (8) 5/16 PW 654004 (4)5/16 HN 653007 - (4) 5/16 LW 654024 (4) 5/16 LW 654024 37 052825 Latch Guide .................. 1 051980 Conveyor Cap ................. 1 650642 Hex.Hd.Cap Screw 1/4 xl Gr.5 ... 1 (Used before Serial No. 6229) (1) 1/4 HN 653005 - (1) 1/4 HLN 653071 058783 Conveyor Cap ................. 1 38 053314 Tube Support Adapter............ 1 (Used after Serial No. 6228) (2) 5/16 HLN 653073 - (2) 5/16 PW 654004 052120 Spout Extension ............... 1 39 053322 Safety Latch .................. 1 650267 Truss Head Screw 5/16 x 5/8 ..... 4 40 053851 Bearing Spacer. ................ 3 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 41 053833 Conveyor Housing .............. 1 052536 Handle ..................... 1 42 053846 Conveyor Housing Base ........... 1 650400 Hex.Hd.Cap Screw 5/16 x 1 Gr.5 .. 1 43 053900 Uft Pulley ................... 2 (4) 5/16 HN 653007 - (4) 5/16 LW 654024 44 053901 Pivot Pin ..................... 1 052538 Handle Clamp ................. 1 (Used before Serial No~ 6229) 052543 Latch Handle - Front ............ 1 054124 Pivot Pin ..................... 1 655018 Cotter Pin 3/16 x 1-1/4 ......... 1 (Used after Serial No. 6228) 052546 Conveyor Latch - Front ........... 1 650341 Hex.Hd.Cap Screw 5/16x 1-3/4 Gr.5. 1 (2) 3/8 HN 653010 - (2) 3/8 HLN 653075 (1) 5/16 HLN 653073 - (1) 5/8 HLN 653078 052550 Conveyor Latch -Rear ........... 1 (1) 5/16 PW 654004 650642 Hex.Hd.Cap Screw 1/4 xI Gr.5 ... 1 45 05390 Pulley Jaw and Eye .............. 1 (1) 1/4 HN 653005 - (1) 3/8 HN 653010 (Used before Serial No. 4897) (1) 1/4 HLN 653071 - (1) 3/8 HLN 653075 056146 Pulley Swivel Bracket ............ 1 052552 Latch Handle - Rear ............. 1 (Used after Serial No. 4896) 655018 Cotter Pin 3/16 x 1-1/4 ......... 1 650341 Hex.Hd.Cap Screw 5/16 x 1-3/4 Gr5. 1 051555 Hanger Arm Brace - Rear .......... 1 650545 Hex.Hd.Cap Screw 5/I6x 1-1/4Gr5. 1 650486 Hex.Hd.Cap Screw 5/16 x 3/4 Gr.5 .2 650594 Hex.Hd.Cap Screw 1/2 x 3-1/4 Gr.5 .1 650430 Hex.Hd.Cap Screw 3/8 xI Gr.5 ... 1 (1) 1/2 HN 653018 - (1) 1/2 HJN 653044 (2) 5/16 HN 653007 - (1) 3/8 HN 653010 (2) 5/16 HLN 653075 - (2) 1/2 PW 654010 (1) 3/8 PW 654006 - (2) 5/16 LW 654024 (1) 1/2 LW 654030 (1) 3/8 LW 654026 46 053905 Wire Rope Thimble ............. 1 052556 Hanger Arm Brace - Front ......... 1 (Used before Serial No. 4897) 650486 Hex.Hd.Cap Screw 5/16 x 3/4 Gr.5 .2 47 053906 Conveyor Hanger Cable (30 ft.) ..... 1 650430 Hex.Hd.Cap Screw 3/8 xl Gr.5 ... 1 48 054011 Pivot Pin Bracket . . . . . . . . . . . . . . . 1 (2) 5/16 HN 653007 - (1) 3/8 HN 653010 49 055889 Retaining Ring ................. 1 (1) 3/8 PW 654006 - (2) 5/16 LW 654024 50 520062 Ball Bearing................... 1 (1) 3/8 LW 654026 (Used before. Serial No. 6229) 052558 Conveyor Extension ..........•.. 1 51 520084 Bearing Collar ................. 1 (Used before Serial No. 6229) (Used after Serial No. 6228) 058684 Conveyor Extension ............. 1 52 620035 Wire Rope Clamp ............... 1 (Used after Serial No. 6228) (Used before Serial No. 4897) 052561 Drive Pin ..................... 1 (Used before Serial No. 6229) 052563 Tube Support ................. 1 650487 Hex.Hd.Cap Screw 5/16 x 1 Gr.5 ... 1 NOTE: SH Page 65 for Winch Repair Parts.

650539 Truss Head Screw 5/16x 3/4 Gr.5 .. 4 (8) 5/16 HN 653007 (8) 5/16 LW 654024 ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

Part No. 045042

a

63

120MX - HOPPER _ _ _ _ _ _ _ _ _ _ _

~

_ _ _ _ _ _ _ __

SWINGING AUGER FEEDER CONNECTING CHUTE

15

19

~

16

11

.8

6

1

GRAVITY FEEDER

~ ~

HAY FEEDER

20

5

~~ 11 ~ 13

9

2

1

3

Ref. No. 1

2 3 4 5 6

7

8 9

10 11

12

64

Part No.

6

12

Part Name

No. Req.

Ref. No.

Part No.

Part Name

No. Req.

17HI98A Support Adjustment Bolt . . . . . . .. 1 13 040849 Feeder Support Tube .......... 1 (1) 3/8 HN 653010 14 040850 Support Lock Pin ............ 1 9H300 Hair Pin Cotter .............. 3 15 042180 Chute Cover ................ 1 H6053 Spacer. . . . . . . . . . . . . . . . . . .. 2 650025 Hex. Hd. Cap Screw 5/16 x 3/4 .. 11 040170 Hinge .................... 1 (11) 5/16 HN 653007 . (11) 5/16 LW 654024 ·652188 Carriage Bolt 1/4 x 5/8 ...... 8 16 047844 Hopper. . . . . . . . . . . . . . . . . . .. 1 17 047850 (8) 1/4 HN 653005 • (8) 1/4 LW 654022 Chute Side· Front ...•........ 1 040613 Shutter .................. .

18 047851 Chute Side· Rear ............ 1 19 048170 (1) 3/8 WN 653098· (1) 3/8 PW 654006 Baffle .................... 1 20 048337 040614 Magnet Hole Cover .. . . . . . . . . .. 1 Support Tube Bracket . . . . . . . . .. 1 650263 Truss Head Screw 1/4 x 3/4 . . .. 6 650028 Hex. Hd. Cap Screw 5/16 x l . . 2 (6) 1/4 HN 653005 . (6) 1/4 LW 654022 (2) 5/16 HN 653007· (2) 5/16 LW 654024 040635 Chute Bottom . . . . . . . . . . . . .. 1 ADDITIONAL PARTS FOR BALE TABLE WHEN 650025 Hex. Hd. Cap Screw 5/16 x 3/4.. 4 MOUNTED ON 120MX HYDRAULIC MIXER 650028 Hex. Hd. Cap Screw 5/16x 1 .. 2 (6) 5/16 HN 653007 . (4) 5/16 PW 654004 21 (6) 5/16 LW 654024 049098 Support Tube Bracket . . . • . . . . .. 2 040640 Hinge Spacer ................ 1 650036 Hex. Hd. Cap Screw 5/16 x 2 .. 1 040720 Gravity Feeder .............. 1 650113 Hex. Hd. Cap Screw 1/2 x 2 . . .. 1 (2) 5/16 WN 653094 - (2) 5/16 PW 6540Q4 (1) 5/16 HLN 653073 • (1) 1/2 HLN 653077 040836 Bale Chute . . . . . . . . . . . . . . . . .. 1 (1) 5/16 PW 654004 • (1) 1/2 PW 654009 652021 Carriage Bolt 1/4 x 1/2 ...... 10 22 049099 Support Tube Extension . . . . .. 1 (10) 1/4 HN 653005 • (10) 1/4 LW 654022 650113 Hex. Hd. Cap Screw 1/2 x 2 .. 1 040842 Bale Hopper .............•.. 1 (1) 1/2 HLN 653077 • (1) 1/2 PW 654009 040846 Hopper Support .......•...... 1 650028 Hex. Hd. Cap Screw 5/16 x l . . 2 (2) 5/16 HN 653007· (2) 5/16 LW 654024 ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

_____________________________________________ 120MX-WINCH

5

~

10

r

Ref. No.

1 2 3 4 5 6 7 8 9

Part No. 052582 601921 601922 601929 601930 601931 601932 601933 601934 601935

No. Req. Part Name Winch Assembled ......... ; .... 1 Latch Kit . . . . . . . . . . . . . . . . . .

1 Rope Keeper w/Handle Disc. . . . . .. I Ratchet Gear Assembled ......... 1 Brake Disc .................. I Pinion Shaft . . . . . ............ I Retaining Ring ............... I Ra tchet Bushing . . .. . . . . . . . . .. I . . .. . . . .. . . . I Pinion Bushing .

Winch Frame . . . . . . . . . .. . . . .. 1

Ref. No.

Part No.

10

601936 601937 601938 601939 602745

11

12 13

14

No. Part Name Req. Axle Nut ......••........... 1 Drum Assembled. . . . . . . . . . . ... 1 Frame Spacer •. .......... ' ... 1 Axle Bolt ................. .. 1 Handle Assembled. . . .. . . ...... 1

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _120MX ~ S~LECTOR VALVE

,

\

Ref. No.

1 2 3 4

Part No. 058594 058595 058596 058597 058598

3

No. Part Name Req. Selector Valve Assembled .. . . . . .. 1 ,Selector Valve Housing ~ • . . . . . . .. 1 Valve Spool. . . . . . . . . . . . . . . .. 1 . Re taining Ring . . . . . . . . . . . . . .• 2 "0" . Ring Seal. . . . .. .. . . . . . .. 2

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

65

120MX/12OSAF - HYDRAULIC M-OTOR _ _ _ _ _ _ _ _ _ _ _ __ CHAR-LYNN WARNING - Order By Part Number - Do Not Use Illustration Reference Numbers

Ref. No. 1 2

3 4 5 6 7 8 9 10 11

12 13 14 15

Part No. 048961 H251 049496 049497 049498 049499 049500 050021 A 050022 050023 050024 A 050025 050027 050028 050029 050030

Part Name

No. Req.

Hydraulic Motor Assembled .. . . .. . 1 Roll Pin 1/4 xl. . . . . . . . . . . . .. 4 Mounting Plate . . . . . . . . . . . . . . 1 Back-up Washer . . . . . . . . . . . . . . 1 Bearing Race . . . . . . . . . . . . . . . . 1 Thrust Washer . . . . . . . . . . . . . . 2 Housing and Spool ............ 1 Output Shaft ............ . . .. 1 "0" Ring Seal . . . . . . . . . . . . . . 1 Housing Plug . . . . . . . . . . . . . . . . 1 Housing . . . . . . . . . . . . . . . . .. 1 Drive . . . . . . . . . . . . . . . . . . .. 1 Spacer Plate . . . . . . . . . . . . . . . . 1 Gerotor Set . . . . . . . . . . . . . . . . 1 End Cap . . . . . . . . . . . . . . . . . . 1 Seal Washer . . . . . . . . . . . . . . . . 7

Ref. No.

Part No.

16 17 18 19 20 21 22

580089 580095 580096 650371 650372 654048 655505

Part Name

No. Req.

Oil Seal . . . . . . . . . . . . . . . . . . .. 1 Quad Seal . . . . . . . . . . . . . . . . . . 1 Quad Seal . . . . . . . . . . . . . . . . . . 1 Flanged 12 Pt. Screw 5/16 NF x 5/8 4 Flanged 12 Pt. Screw 5/16 NF x 1-5/8 7 Internal Tooth Lock Washer - 5/16.. 4 Woodruff Key 1/4 x l . . . . . . .. 1

A Not Sold As Separate Items.

NOTE: To Order Hydraulic Motor Repair Kit, Specify Part Number 050031.

12OSAF/150HF - FLOW CONTROL VALVE _ _ _ _ _ _ _ _ _ _ __

5

Closed

In Ref. No.

2 3 4

Part No.

Part Name

No. Req.

048968 Flow Control Valve Assembled . . ..

050037 Control Valve Body ... . . . . . ..

660080 Hex. Soc. Pipe Plug - 3/4 .... :.

050038 Meter Spool . . . . . . . . . . . . . . . .

050039 Spring. . . . . . . . . . . . . . . . . . ..

050040 Rotary Spool .. . . . . . . . . . . . . ..

650195 Soc. Hd. Set Screw 1/4 x 1/4 ..

1 1 2 1 1 1 1

Ref. No.

Part No.

Part Name

5 6 7 8 9 10 11

050041 050042 050043 050044 050045 050046 050047

Spool Handle . . . . . . . . . .. . . . " Snap Ring. . . . . . . . . . . . . . . . ..

"0" Ring . . . . . . . . . . . . . . . . . .

Orifice Plate . . . . . . . . . . . . . . . .

Snap Ring .. . . . .. . . " . . . . . . ..

Thumb Screw . . . . . . . . . . . . ..

Dial Plate . . . . . . . . . . . . . . . . . .

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

66

No. Req. 1 2 2 1 1 1 1

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 150HF - HYDRAULIC MOTOR 6

CHAR-LYNN

8 9

~lJ

WARNING - Order By Part Number - Do Not Use Illustration Reference Numbers

13

Ref. No.

Part No.

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

049073 H251 049496 049497 049498 049499 049500 050021 A 050022 050023 050024 A 050026 050027 050029 050030 050156

Part Name

,,~ ~J. 2,

No. Req.

Hydraulic Motor Assembled .. . . ..

Roll Pin 1/4 xl. . . . . . . . . . . . ..

Mounting Plate . . . . . . . . . . . . . .

Back-up Washer . . . . . . . . . . . . . .

Bearing Race . . . . . . . . . . . . . . . .

Thrust Washer . . . . . . . . . . . . . .

Housing and Spool ............

Output Shaft .. . . . . . . . . . . . . ..

"0" Ring Seal . . . . . . . . . . . . . .

Housing Plug . . . . . . . . . . . . . . . .

Housing . . . . . . . . . . . . . . . . ..

Drive . . . . . . . . . . . . . . . . . . ..

Spacer Plate . . . . . . . . . . . . . . . .

End Cap . . . . . . . . . . . . . . . . . .

Seal Washer .... -. . . . . . . . . . ..

Gerotor Set . . . . . . . . . . . . . . . .

1 4 1 1 1 2 1 1 1 1 1 1 1 1 7 1

14

~~~ -o~ .

Ref. No.

Part No.

Part Name

No. Req.

16 17 18 19.

20 21 22

580089 580095 580096 650371 650373 654048 655505

Oil Seal. . . . . . . . . . . . . . . . . . ..

Quad Seal . . . . . . . . . . . . . . . . . .

Quad Seal . . . . . . . . . . . . . . . . . .

Fhmged 12 Pt. Screw 5/16 NF x 5/8 Flanged 12 Pt. Screw 5/16 NF x 1* Internal Tooth Lock Washer - 5/16..

Woodruff Key 1/4 x l . . . . . . ..

1 1 1 4 7 4 1

A Not Sold

As Separate I terns.

NOTE: To Order Hydraulic Motor Repair Kit, Specify Part Number 050031.

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 120MX - SELECTOR VALVE 5

Ref. No. 1 2 3 4

Part No.

Part Name

No. Req.

048962 Selector Valve Assembled . . . . ..

050032 Seal. . . . . . . . . . . . . . . . . . . . ..

050033 Snap Ring . . . . . . . . . . . . . . . . ..

050034 Clevis . . . . . . . . . . . . . . . . . . . .

(1) 3/8 ELW 654042 050035 Clevis Pin . . . . . . . . . . . . . . . . . .

655002 Cotter Pin 3/32 x 5/8 ....... .

1 2 2 1

Ref. No.

Part No.

Part Name

No. Req.

5 500059'" Housing . . . . . . . . . . . . . . . . .. 1 6 500060'" Spool . . . . . . . . . . . . . . . . . . . . 1 7 580004 O-Ring. . . . . . . . . . . . . . . . . . .. 2 "'Not sold as separate items. Spools are factory honed to individual housing and are not interchangeable.

NOTE: To Order Sslector Valve Seal KIt, Specify Part Number 050036.

ALWAYS GIVE MODEL AND SERJAL NUMBER WHEN ORDERING SERVICE PARTS

67

120MX - HYDRAULIC MOTOR _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ ROSS

2

Ref. No.

Part No.

1 2 3 4 5 6 7 8 9 10

056202 602799 602800 602801 602802 602803 602804 602805 602806 602807 602808

'----

Ref. No.

No. Req.

Part Name

Hydraulic Motor Assembled . . . . . . . . 1 Special Screw 5/16 x 2-7(8 ......... 7 End Plate Assembled . . . . . . . . . . . . . 1 ,Washer . . . . . . . . . . . . . . . . . . . . . . 1 Seal Retainer . . . . . . . . . . . . . . . . . . 1 Rotor Seal . . . . . . . . . . . . . . . . . . . 2 Commutator Assembled. . . . . . . . . . . 1 Manifold . . . . . . . . . . . . . . . . . . . . . 1 Rotor Set . . . . . . . . . . . . . . . . . . . . I Spacer . . . . . . . . . . . . . . . . . . . . . . I Drive Link . . . . . . . . . . . . . . . . . . . I

11

12 13 14 15 16 17 18

Part No.

Part Name

-

--'>.

No. Req.

602809 Coupling Shaft. . . . . . . . . . . . . . . . . I Woodruff Key 1/4 x 1.......... I 655505 602810 Thrust Bearing. . . . . . . . . . . . . . . . . 1 Thrust Washer . . . . . . . . . . . . . . . . . 1 602811 Seal. . . . . . . . . . . . . . . . . . . . .... 1 602812 Spacer . . . . . . . . . . . . . . . . . . . . . . 1 602813 602814 Housing Assembled . . . . . . . . '" .... 1 (Includes 602815 and 602816) Needle Bearing . . . . . . . . . . . . . . . . . I 602815 602816 Retaining Ring . . . . . . . . . . . . . . . . . I

150 HF - HYDRAULIC MOTOR _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ '"" ___ ..........

"

ROSS

~~"~~'" Ref. No.

I

fJ'

3

" Part No.

11

,

........

.......

""

15

" ........

'~~",

.,oP,",-

~

'"

~~, ":_~ ~''-'~'' 5

16

__

Part Name

No. Req.

14

Ref. No.

Part No.

10 12 13

602811 602812 602813 602814

14 15 16 17 18

601815 602816 602817 602818 602819

"

{~

~>',."~~_j

",,"'-

___

~f).

Part Name

No. Req.

056203

Hydraulic Motor Assembled . . . . . . . . 1 Special Screw 5/16 x 2-7/8 ......... 7 End Plate Assembled . . . . . . . . . . . . . I Washer . . . . . . . . . . . . . . . . . . . . . . I 602801 Seal . . . . . . . . . . . . . . . . . . . . . . . . 2 602803 Commutator Assembled . . . . . . . . . . 1 602804 Manifold . . . . . . . . . . . . . . . . . . . . . I 602805 Spacer . . . . . . . . . . . . . . . . . . . . . . '1 602807 Coupling Shaft. . . . . . . . . . . . . . . .. I 602809 Woodruff Key 1/4 xl. ...... ; .. 1 655505 Thrust Bearing. . . . . . . . . . . . . . . . . 1 602810

i .~g~~~~ 3 4 5 6 7 8 9

68

11

Thrust Washer . . . . . . . . . . . . . . . . . I Seal . . . . . . . . . . . . . . . . . . . . . . . . I Spacer . . . . . . . . . . . . . . . . . . . . . . I Housing Assembled . . . . . . . . . . . . . I (Includes 601815 and 602816) Needle Bearing. . . . . . . . . . . . . . . . . 1 Retaining Ring . . . . . . . . . . . . . . . . . 1 Drive Link . . . . . . . . . . . . . . . .... 1 Rotor Set . . . . . . . . . . . . . . . . . . . . 1 Seal Retainer . . . . . . . . . . . . . . . . . 1

_ _ _ _ _ _ _.....,..-_ _ _ _ _ _ _ _ 120MX . UNIVERSAL DRIVES

MIXER WITH 540 R.P.M. MILL DRIVE

1 I I I

I

.......... .- .....

.... .- .......... ..- .............. ...... .("""',,-....---

I 22 ! 1~

..........

...............

.......... ..........

.,..,......---,-

..........

...............

...........-

...............

......... .... ..J

15

~ 18

~ .... ~

7

MIXER WITH 1000 R.P.M. MILL DRIVE

..,

I

I

I

I .)

.......... ..........

..........

~.

18

(Parts List Begins On Next Page)

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

.1

120MX - UNIVERSAL DRIVES _ _ _ _ _ _ _ _ _ _ _ _ _ _ __

17

Ref. No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14

70

Part No.

No. Req.

Ref. No.

044226 Universal Joint .............. 1 045425 Yoke ..... . . . . . . . . . . . . . .. 1 045426 Yoke . . . . . . . . . . . . . . . . . . .. 1 045427 Center Yoke ................ 1 045428 Bolt. . . . . . . . . . . . . . . . . . . . .. 1 655008 Cotter Pin 1/8 x 1~ ........ 1 04.8763 Universal Joint w/Sq. Shaft ...... 1 Universal Joint w/Sq. Tube ...... 1 048764 049091 Universal Joint w/Sq. Shaft ...... 1 Yoke and Shaft .............. 1 049287 049288 Female Guard ... . . . . . . . . . .. 1 049289 Yoke and Tube .............. 1 049290 Male Guard ................ 1 510096 Lock Pin .................. 1 510097 A Locking Pin w/Spring .......... 1

15 16 17 18 19 20 21 22 23 24 25 26 27

Part Name

Part No.

No. Part Name

Req.

510100 Bearing Retainer . . . . . . . . . . .. 2 510113 Center Cross Kit . . . . . . . . . . .. 2 510197 Center Cross Kit . . . . . . . . . . .. 1 510202 Nylon Bearing .............. 1 510203 B Lock Yoke - 21 Spline . . . . . . .. 1 510204 Lock Yoke Assembled . . . . . . . . .. 1 510205 Lock Pin Spring . . . . . . . . . . . . .. 1 510215 Centralizer Bearing ............ 1 510252 Lock Yoke Assembled . . . . . . .. 1 510253 Lock Yoke - 1-3/8 Spline . . . . .. 1 510306 Bushing w/Needles ............ 4 510307c Center Cross ................ 1 510308 Snap Ring .. . . . . . . . . . . . . . . .. 4 AFor Replacement, Order 053865.

BFor Replacement, Order 510204. c For Replacement, Order 510197.

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

-, i

{.l·,-4

1-5

I I

I

3

o I

~--6

14

@--15

#-19

~1

~

16

12 2

. I I 11 10

&-13

0 -

17

.~

~ Ref. No.

Part No.

1 2 3' 4 5 6 7 8 9 10

051908 9H253 C14070 055682 601940 601941 601942 601943 601944 601945 601946

~8~~-21

9

I

L__ No.

Req.

Ref. No.

Hitch Jack ...... ; . . . . . . . . . . . . 1 Washer . . . . . . . . . . . . . . . . . . . . . 1 Washer . . . . . . . . . . . . . . . . . . . ;. 2 Jack Handle Assembled ........... 1 Cap Washer . . . . . . . . . . . . . . . . . . . 1 Spinner Knob . . . . . . . .......... ' 1 Jack Handle . . . . . . . . . . . . . . . . . . 1 Handle Clip . . . . . . . . . . . . . . . . . . . 1 Handle Pin . . . . . . . . . . . . . . . . . . . 1 Jack Tube· Outer . . . . . . . . . . . . . . 1 Pull Ring ........ , ........... 1

11 12 13 ' 14 15 16 17 18 19 20 21'

Part Name

...J

Part No.

Part Name

No. Req.

601947 , Plunger Spring. . . . . . . . . . . .. .. .. 1 Plunger· 1/2 dia ..... , . , ........ 1 601948 Jack Screw 12·3/4 . . . . . . . . . . . . , . 1 601949 Sleeve. . . . . . . . . . . . . . . . . . . . . . . 1 601950 Roller Bearing .. ; . . . . . . . . . . . . . . 1 601951 Jack Nut. . . . . . . . . . . . . . . '. . . . . . 1 601952 Jack Tube . Inner. . . . . . . . . . . . . . . 1 601953 Re taining Ring. . . . . . . . . . . . . . . .. I 601954 "X" Washer. . . . . . . . . . . . . . . . . . . 1 601955 Steel Ball • 3/8 . . . . . . . . . . . . . . . . 1 666001 900989 ' Plunger Assembled ............. 1

ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS

71

120MX - NUMERICAL INDEX _ _ _ _ _ _ _ _ _ _ _ _ _ _ __

Part No. Page No. 6H2A ......... 42 2E4D ......... 19 6H9 ....... : .. 42 6H14D .......... 9 13H16 ......... 61 10E20 .......... 5 13E23 ......... 12 13E24 ... 7-13-25-30 13H24 ......... 12 6E27 ....... , .. 42 19E27 ....... 22-54 5J28A ......... 63 13E29 ......... 12 2E34 .......... 19 6H40 ........ 25-30 3E42A ....... 25-30 4H42 ........... 5 13H55 ......... 12 13E56 ......... 12 13E60 ......... 12 3H60 .......... 36 13E61 ......... 12 13E62 ......... 12 5H63 .......... 21 7H73 .. 5-17-25-28-59 5H74 ......... ; 21 6H75 .......... 42 5E77 ........ 25-28 30-33-36 6J78 .......... 42

100 6HI08A ........ 42 6H112 ..... 15-51-63 7H115 ....... 15-51 17H120 ........ 43 3E126A ...... 25-30 6H128 ......... 42 6H129 ......... 42 6HL30 ....... 17-52 6H133 ......... 42 6H134A ........ 42 6H136A ...... 17-52 17H140 .... 17-33-36 45-52-54 17H142A ........ 5 17HI44 ......... 5 6H158 ....... 15-51 6H160 ....... 15-51 A162 .......... 43 17H163A ....... 9 6H165A ...... 15-51 6H166A ...... 15-51 6H171 ....... 17-52 6H175 .......... 7 9E176 ....... 33-45 6H176 .......... 7 6H178 ......... 15 17HI79A ........ 9 17H180A ........ 9 6H183 ... 15-22-51-54 17H185 ...... 10-17 17H190A ........ 9 17H198A ....... 64

200

16E200 ........ 36

72

Page No.

Part No.

9H202A ...... 28-59 17H208 ........ 12 H217 ... .17-25-30-53 17H238 .... .5-28-59 9H247 ......... 17 H251 ........ 66-67 9H251 .. .17-22-54-67 9H253 ......... 71 9H255 ....... 28-59 17H260 ........ 43 A262 .... 17-25-30-53 H267 . . . . 5-25-30-36 H267A .......... 5 17H270 .. ; ..... 43 17H271 ........ 43 17H273 ........ 43 H275 ........ 10-13 17-22-25 30-53-54 17H295A ... 33-36-45

300

9H300 ..... 28-59-64 0316 .......... 12 17H319A ..... 33-36 9H322 ....... 25-30 9H324 ....... 25-30 17H325 ...... 25-30 9H332 ....... 25-30 17H333 ...... 15-51 17H338 ......... 9 17H340A ........ 7 9H346 ..... 33-36-45 9H349 ......... 40 9H359 ......... 28 17H361 ........ 17 9H365 ....... 25-30 9H370 ... 22-40-49-54 9H371 ....... 22-54 9H373 ....... 22-54 9H374 ... 22-40-49-54 17H386 ...... 25-30 17H387 .. 22-40-49-54 17H394 ....... 9-33

400

17H418 ......... 9 17H419 ......... 9 H474 ........... 9 A571 .......... 43

100

H728B ......... 13 D932A .... 5-13-15 17-22-25 28-30-53 54-57 0036 ...... 17-22-53 0937 ...... 17-22-53 D975B ....... 22-54

6000

H6046 ......... 43 H6053 ... 17-25-28-31 33-36-40-45 49-53-59-64 H6053A ...... 43-45 H6094 ......... 53 H6098A ....... , 12

Part No.

Page No.

1000 H7028 ......... 12 H7123 ......... 43 H7125 ..... 13-15-63 H7163 ... 15·33-36-51 H7165 ......... 51 H7794A ...... 33-36 H7838 ......... 10 H7846 ....... 10-28 33-36-45

8000

H801O ..... 40-45-49 51-54-61 H8016 10-17-33-36-45 H8048 ......... 40 H8054 ..... 15-23-25 30-31-36 H8228 .......... 9 H8254 ......... 10 H8315 ... 17-28-53-59 H8330 ......... 63 H8334 ... 10-33-36-45 H8352A .. 23-28-54-59 H8358 ......... 63

9000

D9048 ......... 15 D9048C .... 17-25-33 36-45-53 09117 ....... 23-55 09139 A .... 17-25-33 36-45-53

10000

Uloo14 ........ 63 UlOOI4A ....... 63 UlooI4C ....... 63 Ul0063 ...... 23-55 UlO102 ........ 15 UlOI04 ........ 15 Ul0117 ... 10-25-31

11000

B11028 ...... 17-53 Bll028A ..... 17-53 B11029A ... 17-25-33 36-45-53 B11156. ........ 17 BI1162 ........ 15 BI1162B ........ 5 B11221 ...... 10-13 B11242 .... 28-33-36 40-45-59 B11285 ...... 23-40 B11296 ........ 23 B11335 ..... 9-15-17 25-31-53-63 B11399 ........ 36 B11400 ........ 23 B11433A ....... 36

12000

MI2070 ......•. 17 MI2074 ...... 17-53 MI2118 ........ 28 M12144 ........ 61 M12234 ......... 7

13000

R13033D ........ 7

Part No.

Page No.

R13055 ........ 28 R13139A ........ 7 R13227 ........ 36

14000 C14070 ...... 13-71 C14118 ........ 12 C14121 ......... 5 C14125 ........ 28

16000 S 16024 . . . ... 40-49 S16174 .. 23-33-36-45

040000

040007 ........ 19 040008 ........ 19 040009 " ...... 19 040010 ........ 19 040011 ........ 12 040012 ........ 12 040015 ...... 17-53 040016 ...... 17-53 040021 ........ 21 040025 ........ 21 040026 ........ 21 040030 ........ 21 040038 ........ 21 040046 ........ 21 040050 ........ 19 040051 ........ 19 040052 ........ 19 040054 ........ 19 040055 " ...... 19 040056 ........ 19 040057 " ...... 19 040058 " ...... 21 040060 ........ 21 040066 ........ 21 040068 ........ 21 040069 " ...... 21 040081 " .. 21-25-31 040087 ........ 12 040092 ........ 12 040102 ........ 21 040106 ........ 21 040107 ........ 21 040108 ........ 21 040109 ........ 21 040110 " ...... 21 040111 ........ 21 040112 ........ 21 040113 ........ 21 040114 ........ 21 040115 ........ 21 040116 ........ 21 040117 ........ 15 040118 ........ 15 040119 ........ 17 040126 ......... 9 040127 ......... 9 040145 ........ 13 040164 ...... 15-51 040166 ...... 23-55 040170 .... 28-59-64 040171 ...... 23-55 040174 ...... 23-55 040175 ...... 12-13

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ '20MX - NUMERICAL INDEX

Part No.

Page No.

040179 · ....... 12 040184 ., "" , ,,9 040197 " " '. " ,9 040209 , , , , , , .. .13 040214 , ....... 17 040219 · ..... 15-51 040229 · .. , . , 15-51 040234 , .. , , ... 15 040242 · ....... 17 040243 · ....... 17 040244 · ..... 15"51 040245 · ..... 15-51 040246 · ..... 15-51 040250 ........ 42 040253 ... , ..... 7 040258 ., ....... 9 040271 ., ....... 9 040272 · ........ 9 040273 · ..... 17-53 040274 · .. , " ... 9 04027$ · . , ...... 9 040276 ......... 9 040277 ........ 43 040278 · ..... 15-51 040292 · .. ' ..... 9 040294 ......... 9 040310 ., ., ... '.. 9 040311 ......... 9 040316 ., ....... 9 040317 · .. , ..... 9 040319 · ...... , .9 040323 · ..... 15-51 040428 · .... , ... 7 040431 · ..... 15-53 040445 · ..... 15-51 040459 · ..... 15-51 040460 ......... 9 040461 ., ....... 9 040466 .. .. .. . . 28 040492 · ..... 23-55 040494 ...... 23-55 040495 · ..... 23-55 040496 · ....... 28 040500 · ..... 28-59 040502 · ....... 23 040503 · ..... 23-55 040504 · ..... 23-55 040510 · ....... 55 040515 · ..... 23-55 040517 · ....... 15 040532 .... 23·55 040535 · ..... 23·55 040536 ...... 23·55 040562 · ..... 23·31 ·040563 · ..... 25·33 36·45·57 040-568 ........ 28 040571 · .25·28·31·59 040581 · ..... 25·31 040595 · ....... 25 , 040603 · ..... 25·33 36·45·57 040611 · ....... 25 040613 •••.•••. 64 040614 .... 33-40·64,

Part No.

Page No.

040630 · .25-28-31-59 040635 , , , ,28-59-64 040638 , , , , , , , , 10 040640 " . 28-59-64 040644 · . , ... 15-51 040661 · ..... 28-59 040676 , ..... 28-59 040681 · ..... 28-59 040685 · ..... 28-59 040686 · ..... 28-59 040693 · ..... 23-55 040699 " " .... 28 040710 ...... 28-59 040711 · ..... 28-59 040720 ........ 64 040727 · ..... 17-53 040728 · ... 17-53 040733 · .... ,23-55 040735 · .... , .. 21 040736 ........ 23 040810 · ..... 28 040836 ...... 64 040842 ........ 64 040846 ........ 64 040849 ........ 64 040850 ........ 64 040860 ........ 42 040861 · ....... 13 040864 · ..... , . 13 040865 · ....... i3 040868 · ....... 13 040875 · ....... 13 040908 · ... 15-51-63 040983 ........ 25 040984 ........ 25

041000

041142 ........ 43 041143 ........ 43 041147 · ..... 23-55 041148 · ..... 23-55 041165 , ....... 28 041912 · ... 23-55 041981 · ..... 23-55

042000

042000 ........ 28 042039 · ....... 21 042054 ......... 9 042085 ........ 55 042094 ........ 23 042097 •....... 23 042115 · ....... 17 042118 · ....... 17 042121 · ....... 18 042123 · ....... 18 042129 · ....... 21 042133 · .... ,.28·59 042135 .... '.....28 042136 ...... 28.59 042137 ......... 9 042139 ...•..... 9 042140 ........ 29 041142 .........29 042145 · ..... 29·59 042147 • •••.• 29·59 042161 ....•••.. 7

Part No.

Page No.

042162 ....... , 7 042163 ........ 7 042166 , , , , , , , , 18 042171 , , , , .. , .21 042180 ........ 64 042183 · ..... 29-59 042188 ...... ,,42 042239 · ....... 18 042281 · ....... 21 042291 · .' ...... 21 042299 · ....... 13 042304 · .... , .. 21 042315 · ....... 19 042350 · ..... 18-25 53-57-63 042359 · ..... 18-53, 042373 ........ 9 042630 · ..... 18-53 042826 ........ 7 042865 · . , ... 33-36 4045-49

043000

043525 · , .. 33-3645 043658 ........ 42 043991 ........ 42

044000

044110 ........ 5 044116 · ....... 12 044226 · ..... 10-70 044257 , ..... 25-31 044258 · ..... 25-31 044308 · ... " .. 29 044498 · ....... 19 044500 · ....... 5 044507 ...... 19 044645 ........ 5 044653 · ..... 25-31 044674 ........ 9 044777 · ..... 3645

045000

045042 ........ 63 045335 ........ 63 045336 ........ 63 045425 " " .... 70 045426 ........ 70 045427 ....... '.70 045428 ........ 70 045955. .' ....... 21 046145 · ....... 51 .

047000

047030 · ....... 18 047549 · ........ 5 047567 · ....... 19 047568 · ....... 19 047569 · ....... 21 047574 ........ 21 047576 ........ 21 047579 · ....... 21 047581 · ....... 21 047582 · ....... 21 047583 · ....... 21 047584 ........ 21 047585 · ...... . 21 047587 · ...•... 21 047588 · ....... 21

Part No.

Page No.

047590 · , , , , , , , 12 047594 , , , , , , , ,21 047620 , , , , " , , ,5 047622 · , . , , ,25-31 047623 .... , ... 29 047687 ...... " .9 047692 · . , . " , , ,5 047693 · ........ 5 047694., ....... 5 047695 · ...... , .5 047696 · ..... " .5 047697 · ........ 5 047698 .' ....... 5 047737 ., .... " .9 047738 ......... 9 047781 · ....... 18 047789 · ..... 18-53 047790 · ..... 18-53 047804 · , . , .. 29-59 047806 · ... , .29-59 047807 · ..... 29-59 047810 ........ 28 047812 ........ 29 047814 " ...... 29 047815 ........ 29 047816 .. , ..... 29 047817 ........ 29 047818 ........ 29 047829 , ..... " .9 047832 .... " ... 9 047838 ......... 9 047844 ........ 64 047850 ........ 64 047851 ........ 64 047852 · ..... " .5 047853 · ........ 5 047854 · ........ 5 047869 · ..... 23-55 047870 · ..... 23-55 047874 · ....... 12 047878 · ....... 12 047879 · . , ..... 12 047880 · ....... 12 047886 · ..... 18-53 047887 · ..... 18-53 047889 · ..... 18-53 047890 ......... 7 047895 ...... " .7 047900 ......... 7 047901 ...... " .7 047907 · ....... 10 047924 · ..... 25·57 047925 · ..... 25·57 047926 ...... 25·31 047937 · ....... 10 047941 ........ :10 047942 · ..... 25·31 047945 · ..... 25·31 047948 · ..... 25·29 047949 · ..... 25·31 047950 ...... 25·31 047951 · ..... 25·31 047952 ........ 25 047953 · ..... 25·31 047955 25·31

120MX - NUMERICALINDEX _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __

Part No.

Page No.

047957 _ ....... 10 047962 · ..... 25-31 047964 · ..... 25-31 047968 · ..... 25-31 047969 · ..... 25-31 047970 · ..... 26-31 047971 · ..... 26-31 047972 · ..... 26-31 047973 · ..... 26-31 047975 · ..... 26-31 047979 · ..... 26-31 047980 · ..... 26-31 047983 · ..... 26-31 047985 · ..... 26-31 047986 · ..... 26-31 047987 · ..... 26-31 047988 · ..... 26-31 047989 · ..... 23-55 047990 · ..... 23-55 047995 · ....... 10 047997 · ....... 10

048000

048000 · ..... 26-31 048001 ........ 23 048004 · ..... 23-55 048008 ........ 23 048009 ........ 23 048012 · ........ 23 048013 ........ 23 048015 · ....... 23 048018 ......... 9 048020 · ..... 18-26 53-57-63 048026 · ..... 18-26 53-57-63 048033 · ..... 26-31 048034 · ..... 26-31 048036 · ..... 26-31 048037 · ..... 26-31 048038 · ..... 26-31 048039 '...... 26-31 048040 ...... 26-31 048043 · ..... 26-31 048044 ...... 26-31 048045 · ..... 26-31 048046 · ..... 26-31 048047 · ..... 26-31 048048 · ..... 26-31 048059 · .. , ..... 7 048060 ......... 7 048061 ., ...... 26 048066 ......... 7 048067 ., ....... 7 048068 ., ., " ... 7 048074 ...... -.. 61 048077 ........ 61 048079 · ....... til 048081 · ....... 61 048085 ... , ., .. 59 048086 ........ 59 048089 · ..... 29-59 048091 · ....... 57 048092 · ... 45-55-59 048093 · ....... 55 048095 · ....... '57

14

Part No.

Page No.

048096 · .... ···57 048097 · .... : .. 57 048098 · ....... 12 048099 ~ ....... 42 048102 ........ 42 048104 · ....... 55 048105 · ....... 55 048106 · ....... 55 048107 · .- ...... 55 048108 · ....... 51 048112 · ....... 51 048113 · ....... 51 048115 · ....... 51 048116 · ..... 18-53 048118 · ....... 51 048119 · ....... 53 048120 · ....... 53 048125 · ....... 51 048127 · ....... 51 048132 · ....... 51 048135 · ....... 18 048138 · ... 18-53-63 048139 · ....... 13 048140 · ....... l3 048145 · ....... 13 048170 ........ 64 048172 · ..... 23-55 048175 · ..... 40-49 048176 · ..... 40-49 048177 · ..... 40-49 048178 ........ 36 048179 ........ 36 048180 ...... 40-49 048182 ... 33-36-45 33-36-45 048183 048184 : : : ... 40-49 048085 · ... 36-40-49 048187 ........ 40 04818.8......... 40 048189 · ..... 40-49 048192 · ..... 40-49 048195 ........ 36 048196 ........ 40 048200 ........ 40 048201 · ..... 41-49 048202 ., ... , .. 36 048203 ........ 36 048204 . . . . . . . . 36 048205 · ... 33-36-45 048206 · ..... 40-49 048207 · ..... 40-49 048209 · ..... 40-49 048210 · ..... 40-49 048211 · ..... 40-49 048213 · ..... 40-49 048214 ...... 40-49 048215 ...... 40-49 048216 · ..... 40-49 048217 · ..... 40-49 048220 36 048223 :: :: :: :: 36 048225 · ... 33-36-45 048226 .. , ..... 36 048227 · ... 33-36-45 048228 · ... 33-37-45

Part No.

Page No.

048228 - ... 33-37-45 048232 · ... 33-37-45 048233 · ....... 41 048234 · ....... 37 048235 · ....... 41 048239 · ....... 41 048240 · ....... 41 048241 · ....... 41 048243 · ....... 41 048246 · ....... 41 048247 .. 37 048248 · ... 33-37-45 048249 · ... 33-37-45 048250 ....... '.37 048251 ........ 37 048254 ........ 37 048255 · ....... 41 048257 · ....... 41 048259 ........ 37 048262 ........ 47 048264 · ....... 23 048265 ........ 23 048267 · ..... 41-49 048268 · ..... 41-49 048283 · ... 33-37-45 048284 · ... 33-37-45 048285 ........ 37 048286 ........ 37 048291 · ....... 13 048292 · ....... 15 048333 · ..... 37-45 048335 ........ 37 048337 ........ 64 048339 · ... 33-37-45 048346 · ....... 61 048355 · ....... 61 048356 · ....... 61 048357 · ....... 61 048359 ........ 53 048367 · ....... 29 048371 · ....... 55 048396 · ....... 41 048415 ........ 37 048418 · ..... 37-45 048422 · ....... 37 048423 ., ... , .. 37 048429 ........ 41 048436 · ........ 57 048437 · ... '.... 61 048440 ........ 61 048441 · ....... 61 048442 · ....... 61 048443 · ....... 61 048459 ........ 37 048460 ........ 61 048732 .........26 048733 ........ 26 048734 ........ 26 048735 · ..... 26-57 048738 ........ 53 048739 · ....... 53 048740 " ....... 7 048745 ......... 7 048753 · ... 33-37-45 048757 ...... 26-57

Part No.

Page No.

048763 ; ..... 13-70 048764 · ..... 13-70 048850 · ....... 13 048947 ...... 45-54 048948 · ....... 61 048949 · ....... 61 048950 · ....... 61 048951 · ....... 61 048952 · ....... 61 048953 · ....... 61 048954 · ....... 61 048955 · ....... 61 048956 · ....... 61 048957 · ....... 61 048958 · ....... 61 048959 · ....... 61 048960 · ....... 61 048961 · ... 51-55-61 048962 · ..... 53-67 048963 · ....... 57 048964 · ....... 57 048965 · ....... 57 048966 · ..... 55-57 048967 · ....... 57 048968 · .49-55-59-66

049000

049048 ........ 61 049049 · ....... 42 049053 ........ 42 049056 · ....... .42 049060 · ....... 55 049066 · ....... 61 049067 ......... 9 049072 · ....... 59 049073 · ... 45-59-67 049074 ...... 45-59 049075 · ....... 59 049076 · ..... 49-59 049077 ........ 59 049078 · ....... 61 049079 ......... 9 049086 ......... 9 049089 · ....... 41 049091 · ..... 13-70 049093 · ...... 9-64 049097 " ...... 37 049098 " ...... 64 049099 .. " .... 64 049100 · ....... 10 049104 ........ 10 409105 ........ 10 049106 · ....... 10 049108 · .... , .. 37 049110 ......... 9 049124 ......... 9 049131 · ....... 38 049136 ......... 9 049138 · ....... 10 049144 ...... 41-47 049145 · ... 33-35-45 049146 ...... 41-49 049147 ........ 33 049242 ......... 7 049287 ........ 70 049288 · ....... 70

.

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 120MX - NUMERICAL INDEX

Part No.

Page No.

049289 ...... 67-70 049301 ...... 23-55 049318 · ....... 13 049319 · ....... 13 049320 ...... 41-49 049371 · ..... 33-45 049379 ........ 43 049380 · ....... 43 049384 ........ 43 049385 · ....... 43 049386 ........ 43 049390 ........ 43 049398 · ....... 43 049426 ...... 18-53 049464 ........ 38 049465 ........ 38 049466 ........ 38 049472 · ....... 10 049476 ........ 38 049485 · ....... 61 049496 ...... 66-67 049497 · ..... 66-67 049498 · ..... 66-67 049499 · ..... 66-67 049500 ...... 66-67

050000

050021 · ..... 66-67 050022 ...... 66-67 050023 · ..... 66-67 050025 · ..... 66-67 050026 ........ 67 050027 ...... 66-67 050028 ...... 66-67 050029 .. " .... 67 050030 ........ 67 050031 · ..... 66-67 050032 ........ 67 050033 · ....... 67 050034 . . . . . . . . 67 050035 ........ 67 050036 ........ 67 050037 ........ 66 050038 " ...... 66 050039 ........ 66 050040 ........ 66 050041 ........ 66 050042 ........ 66 050043 . . . . . . . . 66 '050044 ........ 66 050045 ........ 66 050046 . . . . . . . . 66 050047 ........ 66 050049 ........ 67 050060 ........ 67 050067 ........ 61 050142 ........ 61 050156 ........ 67 050161 · ....... 10 050166 . . . . . . . .21 050205 ...... 41-49 050255 · ....... 61 050475 ...... 40·49 050476 .... 40·41·49 050478 ........ 38

Part No.

Page No.

050480 .... 33-37-38 050483 · ..... 40-49 050484 · ..... 40-49 040485 · ..... 41-49

051000

051098 · ....... 13 051364 · ....... 23 051370 ........ 28 051403 · ....... 21 051404 ...... 7-21 051419 · ........ 7 051423 · ........ 5 051427 · ........ 5 051573 · ..... 29-59 051576 · ....... 21 051579 · ....... 21 051582 · .. , .... 21 051585 · ....... 10 051587 " ....... 9 051590 ....... , .9 051596 ......... 7 051605 · ..... 18-53 051607 · ..... 18-53 051609 " ....... 7 051611 · ....... 61 051612 · ....... 61 051614 · ....... 61 051615 · ....... 61 051616 · ....... 61 051619 · ....... 61 051908 · ...... 7-71 051909 · ........ 7 051920 · ....... 13 051921 · ....... 13 051924 ........ 13 051925 · ..... 15-63 051928 · ..... 15-51 051931 · ....... 51 051934 .... 33-38-45 051935 · ..... 15-51 051936 ...... 15-51 051940 ...... 15-51 051959 · ....... 12 051963 · ....... 12 051966 ........ 12 051967 · ....... 12 051968 ........ 12 051969 · ....... 12 051970 ........ 12 051971' ........ 12 051972 · ..... 38-45 051980 .... 15-51-63 051982 ........ 15 051996 " ...... 51 OS 1998 ...... 18-53 051999 ...... 18-53

052000 052000 ...... 18-53 052010 ......... 7 052014 ......... 7 052016 ......... 7 052018 ......... 7 052019 ......... 7 052033 · ....... 61

Page No.

Part No.

052036 7 052041 · ....... 10 052045 · ....... 61 052046 · ....... 15 052048 · ....... 10 052050 ......... 7 052052 ......... 7 052053 ......... 7 052054 ........ 42 052055 ......... 7 052056 · ..... 38-45 052057 · ... 33-37-45 052061 · ... 33-38-45 052062 · ... 33-36-45 052063 · ... 33-36-45 052064 · ... 33-37-45 052065 · ..... 36-46 052066 · ... 33-38-46 052067 · ... 33-38-46 052068 · ..... 33-46 052069 · ... 33-36-46 05'2070 .... 33-36-46 052071 · ... 33-37-43 052073 · ..... 37-46 052074 · ........ 41 052078 · ....... 41 052079 · ....... 41 052082 · ....... 41 052083 ........ 38 052084 · ... 33-36-46 052090 ...... 33-37 052091 · ..... 36-46 052092 ........ 38 052093 · ....... 38 052096 ........ 41 052099 ........ 41 052101 · ....... 41 053106 ...... 37-46 052109 · ... 33-37-46 052110 .... 34-36-46 052112 .... 34-37-46 052114 ...... 41-49 052116 ...... 34-37 052118 .... 36-3846 052120 .... 15-51-63 052121 · ....... 21 052130 ...... 34-36 052131 · ..... 34-38 052132 ...... 34-38 052135 ........ 38 052137 ......... 7 052140 ......... 7 052142 ...... 38-46 052144 ...... 34·38 052145 ...... 34-38 052146 ...... 34-38 052147 ...... 37·46 052148 ...... 37·46 052152 ........ 42 052158 ........ 42 052163 ........ 41 052164 ........ 41 052174 ........ 46 052175 ........ 46 a

•••••••

Part No.

Page No.

052176 · ....... 46 052212 ...... ··38 052215 ...... ··38 052216 ...... ··38 052217 ...... ··38 052340 ........ ·7 052422 · .... ·34-37 052436 · ....... 17 052472 · ...... ·61 052536 · ..... ··63 052538 ...... ··63 052543 · . " .. ··63 052546 " .... ··63 052550 · ..... ··63 052552 ...... ··63 052555 .... '.. ··63 052556 ..... ·,··63 052558 ...... ··63 052561 ...... ··63 052563 · . ······63 052568 · ..... ··63 052570 " .... ··63 052572 ...... ··63 052582 · .... ·63-65 052585 · .. ·34-37-45 052771 · ..... ··38 052778 · . " ····38 052779 · ..... ··38 052782 · ..... ··38 052783 · ..... ··38 052784····· .. ·38 052787 · .... ·37-46 052816 ........ 63 052821 · ..... ··63 052823 ....... '·63 052824······· ·63 052825 · ..... ··63 052828 · ..... 15-51

053000 053017 · ..... 12-13 053024 ... ·34-3.8-46 053087 ...... ··38 053175 · ...... '~ 41 053314 ....... ·63 053317 ........ 29 053319 ...... ··29 053322 ....... ·63 053760 ... ·34-45-46 053761 · .... ·34.45 053762 ...... 34-46 053763 ...... 34~46 053764 ...... 34~46 053766 ...... 34~46 053767 ...... 34-46 053768 ..... ·34-46 053769 ...... 34·46 053770····· ·34-46 053771 · .. ·40·41-49 053774 ...... 40·49 053775 ...... 40-49 053776 ...... 40·49 053777 ...... 40·49 053778 ........ 34 053779 ........ 34

75

120MX - NUMERICAL INDEX _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __

Part No.

Page No.

053780 .. " .... 34 053781 ........ 34 053784 ........ 34 053787 · ....... 34 053788 ........ 34 053790 ........ 34 053793 ........ 34 053794 ........ 34 053795 ........ 34 053798 ........ 34 053799 ........ 34 053802 ........ 34 053803 ........ 34 053804 · ..... 40·49 053806 · ..... 34·45 053807 · ..... 34·46 053808 ...... 34·46 053809 · ..... 34·46 053815 · ....... 31 053831 ........ 63 053833 · ... 15·51·63 053846 · ..... 15·63 053848 · ..... 15·51 053853 · ....... 51 053854 ........ 51 053865 ........ 70 053891 · ..... ".. 15 053896 ........ 34 053900 · ... 15·51·63 053904 ........ 63 053905 · ....... 63 053906 · ... 15·51·63 053938 · ....... 15 053981 ........ 63

054000

054011 ........ 63 054124 ........ 63 053556 ...... 3446 054850 · ....... 61

055000

055096 ........ 63 055385 · ....... 43 055682 · ........ 7 055889 ........ 63

056000

056060 ........ 43 056102 · ....... 21 056139 · ....... 13 056141 · ....... 13 056143 · ....... 13 0$6145 ........ 15 056146 .... 15·51·63 056147 · ....... 13 056148 · ....... 13 056201 ........ 46 056202 .... 51·55·68 056203 · ..... 45·59 056230 ........ 61 056762 ........ 29 057662 · ... 33~3446

058000

058482 ......... 7 058594 ...... 53·65 058595 · ....... 65 058596 ........ 65

76

Part No.

Page No.

058597 . .... , .. 65 058598 " ...... 65 058615 ......... 7 058616 ......... 7 058631 ........ 53 058634 · ....... 53 058635 · ....... 53 058637 · ........ 9 058664 · ....... 18 058684 .... .... 63 058686 ........ 63 058699 · ....... 15 058700 · ..... 15·63 058701 · ....... 51 058783 '" .15·51·63

500000

500005 ...... 4149 500037 · ....... 36 500038 " ...... 36 500043 · ... 23·29·34 36·46·55·59 500044 · ..... 29·59 50005i · ... 34·3646 500057 · ..... 10·18 34·38·46 500069 · ....... 18 500082 · ....... 10 500159 · ....... 12 ....... 12 500160 500161 · ....... 12 500179 · ..... 10·34 38·46 500220 · ....... 12 500221 · ..... 23·55 500222 ........ 29 500223 · ..... 29·59 500225 · ....... 13

510000

510096 ........ 70 510097 · ....... 70 510100 ........ 70 510113 · ....... 70 510197 · ....... 70 510202 · ....... 70 510203 · ....... 70 510204 ........ 70 510205 · ....... 70 510215 ........ 70 510252 ........ 70 510253 · ....... 70 510206 ........ 70 510307 · ....... 70 510308 ........ 70

052000

520000 ......... 5 520001 · ........ 5 520009 ........ 26 520054 ....... 5·7 520062 ........ 63 520063 · .10·13·18·23 26·29·31·34 38·45·53·55 520064 ......... 5 520065 · ..... 10·34 38·46·53

Part No.

Page No.

520084 •.... 10·13·18 23·26·29·31 34·3846·55·63 520085 5·10·34·38· 46 520098 · ....... 12 520099 · ....... 12 520188 · ....... 12 520198 · ....... 19 520201 ....... 5·7

540000

540007 · ....... 12 540024 · ..... 26·31 540035 · ....... 12

550000

550041 ......... 7 550075 ......... 7

570000

570001 · ....... 17 570002 · .1.5·17·19·22 23·25·26·29 3141·53·54·59 570003 · .15·29·33·36 45·51·59·63 570004 ...... 10·13 18·22·23 570005 · ... 25·29·59 570006 · ..... 25·33 36·45·57 570008 · ..... 29·59 570009....... 28·59 570012 · .17·19·25·53 570014 .... 13·15·25 314049·51 570016 · ........ 5 570023 · ........ 5

580000

580004 ........ 67 580055 · ..... 59·61 580058 ...... 49·53 55·57·59 580065 ........ 43 580066 ........ 43 580089 · ..... 66·67 580095 · ... , .66·67 580096 ...... 66·67 580116 .... 49·55·59

600000

600798 ......... 7

601000

601921 ........ 65 601922 ........ 65 60197.9 .... " .. 65 601930 ........ 65 601931 ........ 65 601932 ........ 65 601933 ........ 65 601934 ........ 65 601935 ........ 65 602936 ........ 65 601937 ........ 65 601938 ........ 65 601939 ........ 65 601940 ........ 71 601941 · ....... 71 601942 ........ 71

Part No.

Page No.

601943 · ....... 71 601944 · ...... ·71 601945 · .... ·65·71 601946 · ....... 71 601947 · ...... ·71 601948 · ....... 71 601949 · ...... ·71 601950 · ...... ·71 601951 · , ...... 71 601952 · ...... ·71 601953 · ...... ·71 601954 · ...... ·71 601955 · ...... ·71

602000

602799 ........ 68 602800 ........ 68 602801 ...... ·.68 602802 ...... ··68 602803 ···· .. ··68 602804 · ..... ··68 602805 ....... ·68 602806 · ..... ··68 602807 ...... ··68 602808 · ..... ··68 602809 ····· .. ·68 602810 ....... ·68 602811 · ..... ··68 602812 ....... ·68 602813 ........ 68 602814· ...... ·68 602815 ·· .. ···.68 602816 ........ 68 602817 ...... ··68 602818 ...... ··68 602819 · ..... ··68

620000

620005 ...... ···7 620009 · ....... ·7 620028 ........ ·7 620035 ., .... ··63 620040 ...... 49·57 620041 · .... ·29·59

650000

650001 · ·15·34·42·57 650003 ........ ·9 650005 · ... ·9·10·15 25·29·31 34-42·51·53 650008 ...... ··63 650012 ...... 10·13 650017 ........ 59 650021 · .. ·15·2342 51·55·61 650023 ... ·5·9·15·23 29·38·55 650025 · . 5·7·9·12·13 15·17·21·23 25·26·28·30 31·34·38·41 4246·49·53·54 57·59·61·63·64 650028 ... ·7·9·10·12 17·18·22·23·25 26·28·29·31·33 34-37·38·40·41

_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 120MX - NUMERICAL INDEX

Part No.

Page No.

65002845-46-49-53-54 (Cont.) 55-57-59-63-64 650029 ., .. 17-18-23 26-28-29-31 40-41-45~46

49-50-54-55 57-59-63-64 650031 ........ 63 650032 · ..... 57-63 650034 .. 23·29-42-51 650035 · ....... 55 650036 .... 29-42-64 650038 .... 26-31-49 650039 ........ 29 650040 ........ 43 650042 ........ 22 650047 ...... 15-51 650048 ........ 25 650056 .. 23-40-42-45 49-55-59-61 650060 ., ..7-9-12-13 17-19-21-26 33-34-36-38 43-45-46-51 52-57-61-63 650062 ....7-9-15-18 19-21-26-31 43-51-53-63 650064 ...... 19-51 650066 .. 17-40-49-53 650068 .. 23-40-49-53 650075 ...... 23-55 650104 ..... 7-23-55 650106 ., . 7-9-17-53 650109 .... 13-40·49 650113 ........ 64 650117 .... 33·36-45 650119 ......... 7 650121 · ....... 28 650122 ......... 7 650124 ...... 22-54 650131 ...... 23-55 650144 ......... 7 650148 ........ 12 650150 ........ 10 650156 ...... 40·49 650184 ...... 33·46 650185 ........ 21 650186 ........ 21 650195 .. 17·28-33·37 45·53·59·65 650196 ........ 15 650198 ........ 19 650200 .... 13·17·53 650201 .. 9·15·17·28 33·36·43·45·55 650202 ........ 59 650203 .... 10·13·25 26·31·33·45 650204 •..... 15·23 25·30·55 650206 .... 10·12·25 28·30·31·33 36·37·43·46 650207 .... 17·33·61

Part No.

Page No.

650208 · ... 34-37-38 650210 · ..... 10-17 650211 · ... 28·29-59 650212 · ..... 10-61 650213 · ... 12-23-41 650214 ...... 12-33 36-46-63 650217 · ...... 5-12 650227 · ....... 19 650261 ....... ; 34 650262 · ....... 53 650263 · .34-36-40-53 650264 ........ 33 650267 .... 9-15-21 23-40-51-55-63 650269 · ....9-10-23 28-29-33-34 46-49-5 I-55-59 650271 · ... 28-33-36 40-45-49 650274 " .... 40-49 650285 ...... 23-55 650290 " .... 23-55 650294 ........ 46 650301 " ...... 42 650321 .. " .... 63 650322 .. 23-28-55-59 650323 ........ 55 650326 ........ 23 650339 ........ 12 650340 ........ 10 650341 · ... 15-51-63 650350 ........ 42 650359 ........ 53 650360 ........ 63 650361 · ....... 21 650371 · ..... 66-67 650372 ........ 66 650373 " ...... 66 650393 ........ 53 650395 ........ 55 650397 ........ 21 650406 ......... 7 650426 ........ 53 650430 ........ 63 650486 ........ 63 650487 .... 15-51·63 650488 ........ 63 650538 ........ 63 650545 ...... 15·51 650577 ........ 63 650594 ...... 15-51 650597 .. 23·29·53·59 650642 ........ 63 650687 ........ 63

652000

652012 ......... 5 652020 . . . . . . . . 38 652021 ...... 10·64 652022 . . . . . . . . 38 652024 ........ 38 652025 ........ 17 652026 .. 10·13·17·18 21·25·26·28 30·31·33·34·36

Part No.

Page No.

65202637-38-40-41-45 (cont.) 46-49-53-54-57 652028 ....... ·57 652029 . ·10-12-18-25 31-33-34-36-37 40-41-45-49-53 652033 ..... , ··25 652046 ..... ·33-36 38-45-46 652047 " ... ·10-18 652048 . ·34-38-45-57 652049 ........ 18 652069 ..... ~. ·36 652082 ....... ·21 652084 .. " .... 36 652085 ····25-30-28 652118 ....... ·64 652122 ........ 63 652136 . ·28-40-49-59 652150 ........ 34

653000

653001 ........ 12 653003 " .... 23-55 653005 .. 9-10-13-15 25-28-31-33-34 36-38-40-41-42 49-51-53-55-59-64 653007 .. 9-10-11-12 13-15-17-18.

21-29-30-31 33-34-36-37 38-40-41-42 43-45-46-49 51-5~54-55

57·59·61·63·64 653010 ... ·7-9·12-13 15·17·18·21 36·38-40-42 43-45-46-49-51 53·57-61-63-64 653015 " .... 15-51 653018 .... 5-7-9-13 15-17-21-22 28-33-34-36 38·43·45·53·54 653021 ... ·12·40-49 653026 ...... ·7·12 653034 ........ 19 653038 ... ·15·51·63 653044 ... ·15·25·30 40-49·51 653047 ...... 26·31 653051 ........ 12 653070 ...... ··53 653071 ..... 9·15·36 51·53·63 653073 .... ·9·10·12 15·18·21·22 23·29·34·38 40-41-43-49·51 55·57·61·63·64 653075 .. ·7·18·19·21 23·25·26·40·49 53·55·57·61·63 653077 ...7·17·21·23

Part No.

Page No.

653093 ........ 23 653094 .... 9-10-64 653098 ........ 64 653102 ......... 7

654000 : 654000 ........ 23 654002 .. 9-10-15-25 31-38-41-46 49-51-64 654004 .. 9-10-12-13 15-17-18-21 23-28-29-31 33-34-36-37 38-40-41-42-45 46-49-51-53-55 57-59-61-63-64 654006 .. . .7-9-12-13 17-18-21-26 31-34-38-42-43 46-51-53-61-64 654009 .. 5-7-9-15-17 18-21-22-23 25-28-30-33 36-43-45-51 53-54-55-64 654012 .. 12-19-40-49 654014 ........ 12 654019 " ...... 12 654020 ...... 23-55 654022 " 9-10-13-15 25-28-31-33 34-36-38-40-41 42-49-51-53-55-59 654024 .. 5-7-9-10-12 13-15·17·18 20·21·23·25 26-28·29·30-31 33-34-36-37 -38 40·41·42·45-46 49-51-53·54-55 57·59-61·63-64 654026 . 7-9-10-12·13 15-17-18·21 23-26·33·3'4 36-38·40·42-43 45-46-49·51·52 53-55-57·61·63 654030 .... 5·7·9·15 18·21·22·25 28·30·33·34 36-38-45·53·54 654032 .... 12·46·49 654034 ......... 7 654042 ........ 67 654048 ...... 66·67 654054 ........ 23 654188 ........ 23 654539 .... 33·38-45

655000

655002 .......• 67 655004 ........ 10 655005 .... 33·36-45 655506 .. 29·40·43-49 655508 ...... 34-41 46·49.70

17

120MX - NUMERICAL INDEX _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __

Part No.

Page No.

655013 ......... 7 655016 ...... 9-23 28-55-59 655019 ........ 41 655020 .. 17-18-23-25 31-34-41-46 655021 ......... 5 655028 ...... 15-63 655032 ...... 40-49 655502 ........ 23 655505 .. 37-46-66-67 655507 .... 23-37-63 655508 ........ 37 655512 ...... 18-53 655513 .. 25-28-29-31 33-45-46-59 655522 ........ 19 655533 ...9-15-17-18 23-25-28-29 34-45-53-55 59-63 655537 ., 5-33-34-45 655522 ........ 19

660000

660003 ........ 61 660004 ...... , .. 5 660010 ...... 43-61 660014 ........ 43 660015 ........ 61 660021 ...... 43-61 660024 ........ 43 660027 ...... 43-61 660039 ........ 57 660041 ........ 43 660045 ........ 43 660056 ........ 43 660060 ........ 61 660076 ........ 61 660077 ........ 61 660078 ........ 61 660079 . .49-53-57-59 660080 ........ 66 660081 ........ 61 666000 . . . . . . 23-41 666001 ........ 71

900000 900989 ....... 7-71 901037 ........ 51

78