DOWNLOAD PDF Volkswagen Polo 2010-2015 Circuit Wiring Diagram Manual
From July 2011
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
CLICK HERE TO DOWNLOAD THE
Battery, Starter, Alternator, Voltage regulator, Onboard
supply control unit
A Battery
B Starter
C Alternator
C1 Voltage regulator
J519 Onboard supply control unit
J623 Engine control unit
S162 Fuse 1 (30), in battery fuse holder
S163 Fuse 2 (30), in battery fuse holder
S269 Fuse 11 (30), in battery fuse holder
T1e Single connector
T2r 2-pin connector, near dual-tone horns
T2s 2-pin connector
T3c 3-pin connector, on left in engine compartment
T6k 6-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T12a 12-pin connector, on left in engine compartment
T18a 18-pin connector
1 Earth strap, battery - body
507 Threaded connection (30), on battery fuse holder
Ignition/starter switch, X-contact relief relay, Onboard supply control unit
D Ignition/starter switch
J59 X-contact relief relay
J519 Onboard supply control unit
T6o 6-pin connector
T8c 8-pin connector
T18a 18-pin connector
B163
B172
Polo/Polo Sedan
Intermittent wiper switch, Rear wiper switch, Intermittent wiper regulator, Onboard supply control unit
E22 Intermittent wiper switch
E34 Rear wiper switch
E38 Intermittent wiper regulator
J519 Onboard supply control unit
T16b 16-pin connector
T16e 16-pin connector
T18a 18-pin connector
T18b 18-pin connector
T41a 41-pin connector
B506 Connection (convenience CAN bus, high), in interior wiring harness
B507 Connection (convenience CAN bus, low), in interior wiring harness
* Diagnostic connection
*2 Squareback
*3 Saloon
Polo/Polo Sedan
Fuel pump relay, Onboard supply control unit, Fuel supply relay
J17 Fuel pump relay
J519 Onboard supply control unit
J623 Engine control unit
J643 Fuel supply relay
T6b 6-pin connector, on left in engine compartment
T6f 6-pin connector
T10c 10-pin connector
T16b 16-pin connector
T18a 18-pin connector
B146 Positive connection 1 (87), in interior wiring harness
B165 Positive connection
B169 Positive connection 1 (30), in interior wiring harness
B492 Positive connection 3 (15), in interior wiring harness
0.5
Driver door contact switch, Front passenger door contact switch, Onboard supply control unit, Front interior light, Luggagecompartmentlight,Glovecompartmentlight,Front passenger reading light, Driver side reading light
F2 Driver door contact switch
F3 Front passenger door contact switch
J519 Onboard supply control unit
T2df 2-pin connector
T2dh 2-pin connector
T2w 2-pin connector
T2x 2-pin connector
T3b 3-pin connector
T5d 5-pin connector
T6m 6-pin connector
T6q 6-pin connector
T18a 18-pin connector
T21a 21-pin connector, in driver door
T21b 21-pin connector, in front passenger door
W1 Front interior light
W3 Luggage compartment light
W6 Glove compartment light
W13 Front passenger reading light
W19 Driver side reading light
277 Earth connection 3, in interior wiring harness
B219 Positive connection 4 (30a), in interior wiring harness
279 Earth connection 5, in interior wiring harness
284 Earth connection 6, in interior wiring harness
285 Earth connection 7, in interior wiring harness
606 Earth point, under the centre console near gear stick
* Saloon
*2 Diagnostic connection
Polo/Polo Sedan Current Flow
Luggage compartment light switch, Onboard supply control unit, Rear window wiper motor, Windscreen and rear window washer pump
F5 Luggage compartment light switch
J519 Onboard supply control unit
T2g 2-pin connector
T3k 3-pin connector
T4i 4-pin connector
T5c 5-pin connector, behind rear left side trim, near wheel arch
T5g 5-pin connector, behind rear left side trim, near wheel arch
T5h 5-pin connector, in rear lid
T5i 5-pin connector, in rear lid
T6q 6-pin connector
T12a 12-pin connector, on left in engine compartment
T18a 18-pin connector
V12 Rear window wiper motor
V59 Windscreen and rear window washer pump
98 Earth connection, in rear lid wiring harness
B498 Connection 1 (53c), in interior wiring harness
B605 Connection 1, in interior wiring harness
* Squareback
*2 Saloon
Switch and instrument illumination regulator, Headlight range control regulator, Rear lid remote release button, Airbag coil connector and return ring with slip ring, Horn plate, Onboard supply control unit, Button illumination bulb
E20 Switch and instrument illumination regulator
E102 Headlight range control regulator
E233 Rear lid remote release button
F138 Airbag coil connector and return ring with slip ring
H Horn plate
J519 Onboard supply control unit
L76 Button illumination bulb
T6c 6-pin connector
T6l 6-pin connector
T6p 6-pin connector
T6q 6-pin connector
T8e 8-pin connector
T41a 41-pin connector
109 Earth connection, in airbag wiring harness
286 Earth connection 8, in interior wiring harness
B116 Connection (58d), in interior wiring harness
* Saloon
Horn or dual tone horn, Onboard supply control unit
H1 Horn or dual tone horn
J301 Air conditioning system control unit
J519 Onboard supply control unit
J623 Engine control unit
T2bb 2-pin connector
T2bc 2-pin connector
T5f 5-pin connector
T6a 6-pin connector, on left in engine compartment
T6k 6-pin connector, on left in engine compartment
T16c 16-pin connector
T16e 16-pin connector
T18a 18-pin connector
12 Earth point, on left in engine compartment
132 Earth connection 3, in engine compartment wiring harness
B159 Connection (diagnosis), in interior wiring harness
B180 Connection (heated rear window), in interior wiring harness
D143 Connection (71), in engine compartment wiring harness
* Diagnostic connection
*2 Saloon
*3 Squareback
Polo/Polo Sedan
Reversing light switch, Onboard supply control unit, Driver side turn signal repeater bulb, Front passenger side turn signal repeater bulb
F4 Reversing light switch
J519 Onboard supply control unit
L131 Driver side turn signal repeater bulb
L132 Front passenger side turn signal repeater bulb
T2aa 2-pin connector
T4e 4-pin connector, in front passenger door
T5n 5-pin connector, in driver door
T6k 6-pin connector, on left in engine compartment
T6u 6-pin connector
T11b 11-pin connector, on left in engine compartment
T12g 12-pin connector, in driver door
T12h 12-pin connector, in front passenger door
T16b 16-pin connector
B152 Connection (LTS), in interior wiring harness
B153 Connection (RTS), in interior wiring harness
B182 Connection (RL), in interior wiring harness
* Saloon
*2 Squareback
*3 Only models with no rear fog light
Polo/Polo Sedan
ws = white
sw = black
ro = red
rt = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
vi = purple
ge = yellow or = orange
rs = pink
Onboard supply control unit
J519 Onboard supply control unit
J623 Engine control unit
SA45 Fuse 45 in fuse holder A
SA46 Fuse 46 in fuse holder A
SA47 Fuse 47 in fuse holder A
SA48 Fuse 48 in fuse holder A
SA49 Fuse 49 in fuse holder A
SA52 Fuse 52 in fuse holder A
T5d 5-pin connector
T5f 5-pin connector
T6b 6-pin connector, on left in engine compartment
T16b 16-pin connector
Polo/Polo Sedan
Onboard supply control unit
J519 Onboard supply control unit
SA10 Fuse 10 in fuse holder A
SA27 Fuse 27 in fuse holder A
SA28 Fuse 28 in fuse holder A
SA29 Fuse 29 in fuse holder A
SA30 Fuse 30 in fuse holder A
T6m 6-pin connector
T16e 16-pin connector
T18a 18-pin connector
B162 Connection (75a), in interior wiring harness
B188 Positive connection 5 (30), in interior wiring harness
B231 Positive connection 5 (30a), in interior wiring harness
* Diagnostic connection
Polo/Polo Sedan
Number plate light
SA1 Fuse 1 in fuse holder A
SA2 Fuse 2 in fuse holder A
SA16 Fuse 16 in fuse holder A
SA19 Fuse 19 in fuse holder A
SA20 Fuse 20 in fuse holder A
T2c 2-pin connector
T2d 2-pin connector
X Number plate light
B132 Connection (number plate lights), in interior wiring harness
B235 Positive connection 4 (15a), in interior wiring harness
B495 Positive connection 3 (58R), in interior wiring harness
T6k 6-pin connector, on left in engine compartment
T11c 11-pin connector, on left in engine compartment
B157 Positive connection 3 (15a), in interior wiring harness
D101 Connection 1 in engine compartment wiring harness
* Saloon *2 Squareback
Additional brake light bulb, Heated rear window
J623 Engine control unit
M25 Additional brake light bulb
T1m Single connector
T1n Single connector
T2di 2-pin connector
T5c 5-pin connector, behind rear left side trim, near wheel arch
T5g 5-pin connector, behind rear left side trim, near wheel arch
T5h 5-pin connector, in rear lid
T5i 5-pin connector, in rear lid
T11c 11-pin connector, on left in engine compartment
Z1 Heated rear window
50 Earth point, on left in luggage compartment
287 Earth connection, in rear lid feeder wiring harness
B185 Connection 2 (54), in interior wiring harness
D73 Positive connection (54), in engine compartment wiring harness
* Squareback
*2 Saloon
Light switch, Front and rear fog light switch, Fog light warning lamp, Light switch illumination bulb
E1 Light switch
E4 Headlight dipper and flasher switch
E23 Front and rear fog light switch
K17 Fog light warning lamp
L9 Light switch illumination bulb
T17a 17-pin connector
T41a 41-pin connector
238 Earth connection 1, in interior wiring harness
B493 Connection (75x), in interior wiring harness
* Only models with rear fog light
purple
orange
Rearleftfoglightbulb,Righttaillightbulb,Lefttaillightbulb, Rear left turn signal bulb, Rear right turn signal bulb, Left reversing light bulb, Right reversing light bulb, Left brake and tail light bulb, Right brake and tail light bulb
L46 Rear left fog light bulb
M2 Right tail light bulb
M4 Left tail light bulb
M6 Rear left turn signal bulb
M8 Rear right turn signal bulb
M16 Left reversing light bulb
M17 Right reversing light bulb
M21 Left brake and tail light bulb
M22 Right brake and tail light bulb
T6h 6-pin connector
T6j 6-pin connector
50 Earth point, on left in luggage compartment
295 Earth connection 10, in interior wiring harness
* Squareback
*2 Only models with no rear fog light
*3 Up to March 2014
Polo/Polo Sedan
Right tail light bulb, Left tail light bulb, Rear left turn signal bulb,Rearrightturnsignalbulb,Leftbrakeandtaillightbulb, Right brake and tail light bulb, Additional brake light bulb, Heated rear window
M2 Right tail light bulb
M4 Left tail light bulb
M6 Rear left turn signal bulb
M8 Rear right turn signal bulb
M21 Left brake and tail light bulb
M22 Right brake and tail light bulb
M25 Additional brake light bulb
T1m Single connector
T1n Single connector
T2di 2-pin connector
T4j 4-pin connector
T4k 4-pin connector
Z1 Heated rear window
50 Earth point, on left in luggage compartment
298 Earth connection 13, in interior wiring harness
299 Earth connection 14, in interior wiring harness
B640 Connection 3 (54), in interior wiring harness
* Saloon
Polo/Polo Sedan
Leftsidelightbulb,Rightsidelightbulb,Frontleftturnsignal bulb,Frontrightturnsignalbulb,Leftheadlightdippedbeam bulb, Left headlight main beam bulb, Right headlight dipped beam bulb, Right headlight main beam bulb
M1 Left side light bulb
M3 Right side light bulb
M5 Front left turn signal bulb
M7 Front right turn signal bulb
M29 Left headlight dipped beam bulb
M30 Left headlight main beam bulb
M31 Right headlight dipped beam bulb
M32 Right headlight main beam bulb
T10a 10-pin connector
T10b 10-pin connector
T11b 11-pin connector, on left in engine compartment
T12a 12-pin connector, on left in engine compartment
67 Earth point, on left of front cross member
85 Earth connection 1, in engine compartment wiring harness
Polo/Polo Sedan
Luggagecompartmentlightswitch,Leftreversinglightbulb, Right reversing light bulb, Number plate light
F5 Luggage compartment light switch
M16 Left reversing light bulb
M17 Right reversing light bulb
T2am 2-pin connector
T2an 2-pin connector
T2ao 2-pin connector
T2ap 2-pin connector
T2br 2-pin connector
T5b 5-pin connector, behind rear left side trim, near wheel arch
T5k 5-pin connector, behind rear left side trim, near wheel arch
X Number plate light
50 Earth point, on left in luggage compartment
218 Earth connection 1, in rear lid wiring harness
B609 Connection 5, in interior wiring harness
Q153 Connection (rear lid contact switch), in rear lid feeder
Q158 Connection (RL) in rear lid wiring harness
W11 Connection (58), in rear lid wiring harness
* Saloon
Polo/Polo Sedan
Immobiliser reader coil, Fuel gauge sender, Fuel gauge, Fuel system pressurisation pump, Coolant shortage indicator sender, Control unit in dash panel insert, Dash panel insert, Alternator warning lamp
D2 Immobiliser reader coil
G Fuel gauge sender
G1 Fuel gauge
G6 Fuel system pressurisation pump
G32 Coolant shortage indicator sender
J285 Control unit in dash panel insert
J362 Immobiliser control unit
K Dash panel insert
K2 Alternator warning lamp
K36 Coolant shortage warning lamp
K166 Door open warning lamp
T2a 2-pin connector
T2t 2-pin connector
T4a 4-pin connector
T6b 6-pin connector, on left in engine compartment
T11a 11-pin connector, on left in engine compartment
T32a 32-pin connector
327 Earth connection (sender earth), in engine compartment wiring harness
401 Earth connection (sender earth), in interior wiring harness
Polo/Polo Sedan
Oil pressure switch, Brake fluid level warning contact, Control unit in dash panel insert, Dash panel insert, Oil pressurewarninglamp,Leftturnsignalwarninglamp,Brake system warning lamp, Rear lid open warning lamp
F22 Oil pressure switch
F34 Brake fluid level warning contact
J285 Control unit in dash panel insert
J301 Air conditioning system control unit
J623 Engine control unit
K Dash panel insert
K3 Oil pressure warning lamp
K65 Left turn signal warning lamp
K118 Brake system warning lamp
K127 Rear lid open warning lamp
K132 Electronic power control fault lamp
T1f Single connector
T2u 2-pin connector
T11a 11-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T14a 14-pin connector, on left in engine compartment
T16c 16-pin connector
T32a 32-pin connector
67 Earth point, on left of front cross member
131 Earth connection 2, in engine compartment wiring harness
B229 Connection (high bus), in interior wiring harness
B230 Connection (low bus), in interior wiring harness
D159 Connection (high bus), in engine compartment wiring harness
D160 Connection (low bus), in engine compartment wiring harness
Polo/Polo Sedan
Rev. counter, Speedometer, Control unit in dash panel insert, Dash panel insert, Main beam warning lamp, Rear fog light warning lamp, Right turn signal warning lamp, Reserve fuel warning lamp, Dash panel insert illumination bulb
G5 Rev. counter
G21 Speedometer
J285 Control unit in dash panel insert
K Dash panel insert
K1 Main beam warning lamp
K13 Rear fog light warning lamp
K94 Right turn signal warning lamp
K105 Reserve fuel warning lamp
L10 Dash panel insert illumination bulb
T8a 8-pin connector
T32a 32-pin connector
* Only models with rear fog light
Convenience system
From July 2011
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
CLICK HERE TO DOWNLOAD THE
Battery, Starter, Alternator, Voltage regulator, Onboard supply control unit
A Battery
B Starter
C Alternator
C1 Voltage regulator
J519 Onboard supply control unit
J623 Engine control unit
S162 Fuse 1 (30), in battery fuse holder
S163 Fuse 2 (30), in battery fuse holder
S269 Fuse 11 (30), in battery fuse holder
T1e Single connector
T2r 2-pin connector, near dual-tone horns
T2s 2-pin connector
T3c 3-pin connector, on left in engine compartment
T6k 6-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T12a 12-pin connector, on left in engine compartment
T18a 18-pin connector
1 Earth strap, battery - body
507 Threaded connection (30), on battery fuse holder
Ignition/starter switch, Onboard supply control unit
D Ignition/starter switch
E19 Parking light switch
J519 Onboard supply control unit
T8c 8-pin connector
T18a 18-pin connector
T41a 41-pin connector
B163 Positive connection 1 (15), in interior wiring harness
B169 Positive connection 1 (30), in interior wiring harness
B172 Positive connection 4 (30), in interior wiring harness
B491
Onboard supply control unit
J301 Air conditioning system control unit
J519 Onboard supply control unit
R Radio
SA10 Fuse 10 in fuse holder A
SA18 Fuse 18 in fuse holder A
SA24 Fuse 24 in fuse holder A
SA28 Fuse 28 in fuse holder A
SA30 Fuse 30 in fuse holder A
SA53 Fuse 53 in fuse holder A
T6m 6-pin connector
T6u 6-pin connector
T8b 8-pin connector
T16c 16-pin connector
T18a 18-pin connector
B162 Connection (75a), in interior wiring harness
B608 Connection 4, in interior wiring harness
X-contact relief relay, Onboard supply control unit
E1 Light switch
J59 X-contact relief relay
J519 Onboard supply control unit
SA34 Fuse 34 in fuse holder A
SA38 Fuse 38 in fuse holder A
T6c 6-pin connector
T6o 6-pin connector
T6q 6-pin connector
T17a 17-pin connector
B170 Positive connection
B171
B188 Positive connection
B493 Connection (75x), in interior wiring harness
Onboard supply control unit
J519 Onboard supply control unit
J879 Control unit for interactive system
J917 Control unit for lighting and wiper functions
T5f 5-pin connector
T16b 16-pin connector
T16d 16-pin connector
T16i 16-pin connector
T18a 18-pin connector
238 Earth connection 1, in interior wiring harness
249 Earth connection 2, in interior wiring harness
278 Earth connection 4, in interior wiring harness
296 Earth connection 11, in interior wiring harness
606 Earth point, under the centre console near gear stick
B155 Connection 2 (DCt), in interior wiring harness
Tilting mechanism button, Anti-theft alarm and vermin repellentsystemcontactswitch,Onboardsupplycontrolunit
E223 Tilting mechanism button
F120 Anti-theft alarm and vermin repellent system contact switch
J234 Airbag control unit
J519 Onboard supply control unit
T2ba 2-pin connector, on bonnet
T6g 6-pin connector, on left in engine compartment
T6m 6-pin connector
T6p 6-pin connector
T6q 6-pin connector
T6u 6-pin connector
T16b 16-pin connector
T16e 16-pin connector
T18a 18-pin connector
T18b 18-pin connector
T21b 21-pin connector, in front passenger door
T50a 50-pin connector
67 Earth point, on left of front cross member
268 Earth connection 2, in front passenger side door wiring harness
286 Earth connection 8, in interior wiring harness
B165 Positive connection 2 (15), in interior wiring harness
B492 Positive connection 3 (15), in interior wiring harness
* Diagnostic connection *2 Saloon
Onboard supply control unit
J519 Onboard supply control unit
T5d 5-pin connector
T6c 6-pin connector
T6q 6-pin connector
T16b 16-pin connector
T18a 18-pin connector
* Squareback
*2 Saloon
Driversideinteriorlockingswitch,Driversidecentrallocking lock unit, Convenience system central control unit, Interior lock switch illumination bulb
E150 Driver side interior locking switch
F220 Driver side central locking lock unit
J393 Convenience system central control unit
L99 Interior lock switch illumination bulb
T4m 4-pin connector
T8h 8-pin connector
T12c 12-pin connector
T21a 21-pin connector, in driver door
T23a 23-pin connector
Interior monitoring switch, Rear lid contact switch, Convenience system central control unit
T5g 5-pin connector, behind rear left side trim, near wheel arch
T5h 5-pin connector, in rear lid
T5i 5-pin connector, in rear lid
T5k 5-pin connector, behind rear left side trim, near wheel arch
T12c 12-pin connector
T21a 21-pin connector, in driver door
T23a 23-pin connector
B207 Connection (convenience), in interior wiring harness
B611 Connection 7, in interior wiring harness
B641 Connection for interior monitoring in interior wiring harness
* Squareback
*2 Saloon
Window regulator switch in front passenger door, Front passenger side central locking lock unit, Convenience system central control unit, Window regulator switch illumination bulb
E107 Window regulator switch in front passenger door
F221 Front passenger side central locking lock unit
J393 Convenience system central control unit
L53 Window regulator switch illumination bulb
T4p 4-pin connector
T8j 8-pin connector
T12b 12-pin connector
T21b 21-pin connector, in front passenger door
T23a 23-pin connector
Polo Current Flow Diagram
= white
= red
= brown
grey
purple
purple
orange
Rear left central locking lock unit, Rear right central locking lock unit, Convenience system central control unit
F222 Rear left central locking lock unit
F223 Rear right central locking lock unit
J393 Convenience system central control unit
T6aa 6-pin connector
T6n 6-pin connector, in rear left door
T6r 6-pin connector, in rear right door
T6s 6-pin connector, in rear left door
T6v 6-pin connector, in rear right door
T6z 6-pin connector
T23a 23-pin connector
purple
yellow
orange
Rear window regulator isolation switch, Horn or dual tone horn, Anti-theft alarm system horn, Convenience system central control unit
E39 Rear window regulator isolation switch
H1 Horn or dual tone horn
H8 Anti-theft alarm system horn
J393 Convenience system central control unit
T2aw 2-pin connector
T2bb 2-pin connector
T2bc 2-pin connector
T6ab 6-pin connector
T6g 6-pin connector, on left in engine compartment
T12b 12-pin connector
T21a 21-pin connector, in driver door
T23a 23-pin connector
12 Earth point, on left in engine compartment
132 Earth connection 3, in engine compartment wiring harness
B111 Positive connection 1 (30a), in interior wiring harness
D143 Connection (71), in engine compartment wiring harness
Conveniencesystemcentralcontrolunit,Frontinteriorlight, Rear left reading light, Rear right reading light, Front passenger reading light, Driver side reading light, Light conductor for front centre console ambient lighting
E1 Light switch
J393 Convenience system central control unit
J917 Control unit for lighting and wiper functions
T2dq 2-pin connector
T3af 3-pin connector
T3d 3-pin connector
T12k 12-pin connector
T17a 17-pin connector
T23a 23-pin connector
W1 Front interior light
W11 Rear left reading light
W12 Rear right reading light
W13 Front passenger reading light
W19 Driver side reading light
W74 Light conductor for front centre console ambient lighting
B154 Connection 1 (DCt), in interior wiring harness
B583 Positive connection (58), in interior wiring harness
Driver vanity mirror contact switch, Front passenger vanity mirror contact switch, Ultrasonic sensor control unit, Convenience system central control unit, Front passenger side illuminated vanity mirror, Driver side illuminated vanity mirror
F147 Driver vanity mirror contact switch
F148 Front passenger vanity mirror contact switch
J347 Ultrasonic sensor control unit
J393 Convenience system central control unit
T2ax 2-pin connector
T2az 2-pin connector
T2e 2-pin connector
T2f 2-pin connector
T8d 8-pin connector
T12c 12-pin connector
W14 Front passenger side illuminated vanity mirror
W20 Driver side illuminated vanity mirror
277 Earth connection 3, in interior wiring harness
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
CLICK HERE TO DOWNLOAD THE
Front left window regulator switch, Rear left window regulator switch, in driver door, Rear right window regulator switch, in driver door, Front right window regulator switch in driver door, Convenience system central control unit, Window regulator switch illumination bulb
E40 Front left window regulator switch
E53 Rear left window regulator switch, in driver door
E55 Rear right window regulator switch, in driver door
E81 Front right window regulator switch in driver door
J393 Convenience system central control unit
L53 Window regulator switch illumination bulb
T4aq 4-pin connector
T4s 4-pin connector
T12b 12-pin connector
T21a 21-pin connector, in driver door
T23a 23-pin connector
R65 Positive connection (58), in driver door wiring harness
Convenience system central control unit, Left door warning lamp
J234 Airbag control unit
J301 Air conditioning system control unit
J393 Convenience system central control unit
J879 Control unit for interactive system
M27 Left door warning lamp
T2al 2-pin connector
T12c 12-pin connector
T16c 16-pin connector
T16d 16-pin connector
T21a 21-pin connector, in driver door
T50a 50-pin connector
205 Earth connection, in driver door wiring harness
B164 Connection (30, door warning light), in interior warning harness
B230 Connection (low bus), in interior wiring harness
= brown
grey
purple
= purple
= yellow
orange
= pink
Rear left window regulator switch, in door, Rear right window regulator switch, in door, Convenience system central control unit, Window regulator switch illumination bulb
E52 Rear left window regulator switch, in door
E54 Rear right window regulator switch, in door
J393 Convenience system central control unit
L53 Window regulator switch illumination bulb
T4q 4-pin connector
T4r 4-pin connector
T5c 5-pin connector, behind rear left side trim, near wheel arch
T6n 6-pin connector, in rear left door
T6r 6-pin connector, in rear right door
T12b 12-pin connector
T21a 21-pin connector, in driver door
T23a 23-pin connector
B116 Connection (58d), in interior wiring harness
B650 Connection 8, in interior wiring harness
* Squareback
*2 Saloon
Hazard warning lights button, Convenience system central control unit, Button illumination bulb
E229 Hazard warning lights button
J393 Convenience system central control unit
L76 Button illumination bulb
T6e 6-pin connector
T12c 12-pin connector
T16e 16-pin connector
T23a 23-pin connector
42 Earth point, next to steering column
279 Earth connection 5, in interior wiring harness
284 Earth connection 6, in interior wiring harness
285 Earth connection 7, in interior wiring harness
606 Earth point, under the centre console near gear stick
B215 Connection 2 (central locking), in interior wiring harness
* Diagnostic connection
*2 Saloon
Convenience system central control unit, Rear left window regulator motor, Rear right window regulator motor, Driver side window regulator motor, Front passenger side window regulator motor, Tank filler flap locking motor
J393 Convenience system central control unit
T2af 2-pin connector
T2da 2-pin connector
T2db 2-pin connector
T2dc 2-pin connector
T2dd 2-pin connector
T4d 4-pin connector, in driver door
T4e 4-pin connector, in front passenger door
T4f 4-pin connector, in rear right door
T4g 4-pin connector, in rear left door
T12b 12-pin connector
T12c 12-pin connector
T23a 23-pin connector
V26 Rear left window regulator motor
V27 Rear right window regulator motor
V147 Driver side window regulator motor
V148 Front passenger side window regulator motor
V155 Tank filler flap locking motor
Convenience system central control unit
J234 Airbag control unit
J301 Air conditioning system control unit
J393 Convenience system central control unit
J446 Parking aid control unit
J879 Control unit for interactive system
R Radio
T8b 8-pin connector
T12c 12-pin connector
T16a 16-pin connector
T16c 16-pin connector
T16d 16-pin connector
T16e 16-pin connector
T50a 50-pin connector
B159 Connection (diagnosis), in interior wiring harness
B214 Connection 1 (central locking), in interior wiring harness
B229 Connection (high bus), in interior wiring harness
287 Earth connection, in rear lid feeder wiring harness
B219 Positive connection 4 (30a), in interior wiring harness
B607 Connection 3, in interior wiring harness
* Squareback
Rear lid handle release button, Luggage compartment light switch, Contact switch in lock cylinder for rear lid, anti-theft alarm system and central locking system, Rear lid release motor, Luggage compartment light
E234 Rear lid handle release button
F5 Luggage compartment light switch
F124 Contactswitchinlockcylinderforrearlid,anti-theftalarmsystem and central locking system
J879 Control unit for interactive system
T2br 2-pin connector
T2bs 2-pin connector
T2bt 2-pin connector
T2bu 2-pin connector
T2df 2-pin connector
T5k 5-pin connector, behind rear left side trim, near wheel arch
T16d 16-pin connector
V139 Rear lid release motor
W3 Luggage compartment light
50 Earth point, on left in luggage compartment
218 Earth connection 1, in rear lid wiring harness
B609 Connection 5, in interior wiring harness
Q153 Connection (rear lid contact switch), in rear lid feeder
* Saloon
Immobiliser reader coil, Sliding sunroof adjustment regulator, Sliding sunroof adjustment control unit, Control unit in dash panel insert, Dash panel insert, Rear lid open warning lamp, Door open warning lamp
D2 Immobiliser reader coil
E139 Sliding sunroof adjustment regulator
J245 Sliding sunroof adjustment control unit
J285 Control unit in dash panel insert
K Dash panel insert
K127 Rear lid open warning lamp
K166 Door open warning lamp
R Radio
T2a 2-pin connector
T6bb 6-pin connector
T6bc 6-pin connector
T6bd 6-pin connector
T8a 8-pin connector
T8b 8-pin connector
T32a 32-pin connector
B178 Connection (speed signal), in interior wiring harness
1.6l engine , CCRA
From July 2011
Battery, Starter, Alternator, Voltage regulator, Onboard supply control unit
A Battery
B Starter
C Alternator
C1 Voltage regulator
J519 Onboard supply control unit
S162 Fuse 1 (30), in battery fuse holder
S163 Fuse 2 (30), in battery fuse holder
S164 Fuse 3 (30), in battery fuse holder
S180 Fuse 8 (30), in battery fuse holder
S267 Fuse 9 (30), in battery fuse holder
S269 Fuse 11 (30), in battery fuse holder
T1e Single connector
T2r 2-pin connector, near dual-tone horns
T2s 2-pin connector
T3c 3-pin connector, on left in engine compartment
T6k 6-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T12a 12-pin connector, on left in engine compartment
T18a 18-pin connector
1 Earth strap, battery - body
507 Threaded connection (30), on battery fuse holder
Ignition/starter switch, Onboard supply control unit, Fuel supply relay
D Ignition/starter switch
E2 Turn signal switch
J519 Onboard supply control unit
J643 Fuel supply relay
T8c 8-pin connector
T10c 10-pin connector
T16b 16-pin connector
T18a 18-pin connector
T41a 41-pin connector
B172 Positive connection 4 (30), in interior wiring harness
B491 Positive connection (75), in interior wiring harness
X-contact relief relay, Onboard supply control unit
J59 X-contact relief relay
J519 Onboard supply control unit
T5f 5-pin connector
T6o 6-pin connector
T11b 11-pin connector, on left in engine compartment
T18a 18-pin connector
Earth connection
in interior
606 Earth point, under the centre console near gear stick B492 Positive connection 3 (15), in interior wiring harness
B493 Connection (75x), in interior wiring harness
Onboard supply control unit
J519 Onboard supply control unit
T6ah 6-pin connector
T16b 16-pin connector
T16e 16-pin connector
T18a 18-pin connector
T18b 18-pin connector
B162 Connection (75a), in interior wiring harness
B506 Connection (convenience CAN bus, high), in interior wiring harness
B507 Connection (convenience CAN bus, low), in interior wiring harness
* Diagnostic connection
*2 Only models with cruise control system
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
CLICK HERE TO DOWNLOAD THE
Fuse 4 in fuse holder A, Fuse 5 in fuse holder A, Fuse 9 in fuse holder A, Fuse 10 in fuse holder A, Fuse 14 in fuse holder A, Fuse 16 in fuse holder A, Fuse 18 in fuse holder
SA4 Fuse 4 in fuse holder A
SA5 Fuse 5 in fuse holder A
SA9 Fuse 9 in fuse holder A
SA10 Fuse 10 in fuse holder A
SA14 Fuse 14 in fuse holder A
SA16 Fuse 16 in fuse holder A
SA18 Fuse 18 in fuse holder A
T6k 6-pin connector, on left in engine compartment
T11d 11-pin connector, on left in engine compartment
B171 Positive connection 3 (30), in interior wiring harness
B608 Connection 4, in interior wiring harness
Fuse 25 in fuse holder A, Fuse 32 in fuse holder A, Fuse 35 in fuse holder A, Fuse 36 in fuse holder A, Fuse 37 in fuse holder A, Fuse 40 in fuse holder A, Fuse 41 in fuse holder
E9 Fresh air blower switch
J127 Control and regulating unit for air conditioning system
SA25 Fuse 25 in fuse holder A
SA32 Fuse 32 in fuse holder A
SA35 Fuse 35 in fuse holder A
SA36 Fuse 36 in fuse holder A
SA37 Fuse 37 in fuse holder A
SA40 Fuse 40 in fuse holder A
SA41 Fuse 41 in fuse holder A
T3c 3-pin connector, on left in engine compartment
T5m 5-pin connector
T6al 6-pin connector
T6b 6-pin connector, on left in engine compartment
T10d 10-pin connector, behind dash panel, right
B218 Positive connection 6 (30), in interior wiring harness
* Only models with air conditioning system
*2 Only models with Climatronic
= blue
= grey
= purple vi = purple ge = yellow
= orange rs = pink
Engine control unit
J623 Engine control unit
SA45 Fuse 45 in fuse holder A
T6b 6-pin connector, on left in engine compartment
T80a 80-pin connector
D104 Positive connection 2 (30a), in engine compartment wiring harness
Engine control unit
E45 Cruise control system switch
E227 Cruise control system (CCS) SET button
J301 Air conditioning system control unit
J623 Engine control unit
T6k 6-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T11c 11-pin connector, on left in engine compartment
T16c 16-pin connector
T16e 16-pin connector
T41a 41-pin connector
T80a 80-pin connector
B159 Connection (diagnosis), in interior wiring harness
B185 Connection 2 (54), in interior wiring harness
B640 Connection 3 (54), in interior wiring harness
B683 Connection (CCS) in interior wiring harness
D73 Positive connection (54), in engine compartment wiring harness
* Diagnostic connection
*2 Squareback
*3 Saloon
*4 Only models with cruise control system
Engine control unit
J104 ABS control unit
J234 Airbag control unit
J301 Air conditioning system control unit
J500 Power steering control unit
J623 Engine control unit
T4ai 4-pin connector
T4i 4-pin connector
T11b 11-pin connector, on left in engine compartment
T16c 16-pin connector
T38a 38-pin connector
T50a 50-pin connector
T80a 80-pin connector
B229
(high
B230 Connection (low bus), in interior wiring harness
D159 Connection (high bus), in engine compartment wiring harness
D160 Connection (low bus), in engine compartment wiring harness
Brake light switch, Clutch pedal switch, Brake pedal switch, Engine control unit
E227 Cruise control system (CCS) SET button
F Brake light switch
F36 Clutch pedal switch
F47 Brake pedal switch
J623 Engine control unit
T4b 4-pin connector
T4c 4-pin connector
T6k 6-pin connector, on left in engine compartment
T11c 11-pin connector, on left in engine compartment
T41a 41-pin connector
T80a 80-pin connector
67 Earth point, on left of front cross member
131 Earth connection 2, in engine compartment wiring harness
B157 Positive connection 3 (15a), in interior wiring harness
D101 Connection 1 in engine compartment wiring harness
* Saloon *2 Squareback
Intake air temperature sender, Intake manifold pressure
sender, Cold start device relay, Engine control unit, Fuel pump for cold start
G42 Intake air temperature sender
G71 Intake manifold pressure sender
J41 Cold start device relay
J623 Engine control unit
T2bz 2-pin connector
T3c 3-pin connector, on left in engine compartment
T4t 4-pin connector
T9e 9-pin connector
T11c 11-pin connector, on left in engine compartment
T80a 80-pin connector
V263 Fuel pump for cold start
67 Earth point, on left of front cross member
85 Earth connection 1, in engine compartment wiring harness
Fuel pump relay, Engine control unit
J17 Fuel pump relay
J623 Engine control unit
T6b 6-pin connector, on left in engine compartment
T6f 6-pin connector
T80a 80-pin connector
B146
B163
B165
ws = white
= black
= red
red
= brown
Speedometer sender, Engine control unit, Ignition transformer, Spark plug connector, Spark plugs
G22 Speedometer sender
J623 Engine control unit
N152 Ignition transformer
P Spark plug connector
Q Spark plugs
T3n 3-pin connector
T4l 4-pin connector
T14a 14-pin connector, on left in engine compartment
T80a 80-pin connector
331 Earth connection, in injection system wiring harness
* Saloon
*2 Squareback
Enginespeedsender,Hallsender,Knocksensor1,Coolant temperature sender, Engine control unit
G28 Engine speed sender
G40 Hall sender
G61 Knock sensor 1
G62 Coolant temperature sender
J623 Engine control unit
T2bi 2-pin connector
T2ce 2-pin connector
T3l 3-pin connector
T3m 3-pin connector
T80a 80-pin connector
220 Earth connection (sender earth), in engine wiring harness
E46 Positive connection 1 (5 Volt) in injection system wiring harness
T11a 11-pin connector, on left in engine compartment
T14a 14-pin connector, on left in engine compartment
T80a 80-pin connector
E48 Connection (injectors), in injection system wiring harness
ws = white
= black
= red
= red
= brown
= green
= blue
= purple
= purple
yellow
Accelerator position sender, Accelerator position sender 2, Throttle valve drive for electric throttle, Throttle valve drive anglesender1forelectricthrottle,Throttlevalvedriveangle
sender 2 for electric throttle, Engine control unit
G79 Accelerator position sender
G185 Accelerator position sender 2
G186 Throttle valve drive for electric throttle
G187 Throttle valve drive angle sender 1 for electric throttle
G188 Throttle valve drive angle sender 2 for electric throttle
J623 Engine control unit
T6ad 6-pin connector
T6ae 6-pin connector
T11c 11-pin connector, on left in engine compartment
T80a 80-pin connector
Lambda probe, Lambda probe after catalytic converter, Engine control unit
G39 Lambda probe
G130 Lambda probe after catalytic converter
J217 Automatic gearbox control unit
J623 Engine control unit
T4ab 4-pin connector
T4u 4-pin connector
T6b 6-pin connector, on left in engine compartment
T80a 80-pin connector
T80b 80-pin connector
D197 Connection 5 (87a) in engine compartment wiring harness * Only models with automated manual gearbox
Radiator fan control unit, Radiator fan series resistor, Radiator fan
J293 Radiator fan control unit
N39 Radiator fan series resistor
T2dg 2-pin connector
T3s 3-pin connector
T4aa 4-pin connector
T6ak 6-pin connector
V7 Radiator fan
12 Earth point, on left in engine compartment
167 Earth connection 4, in engine compartment wiring harness
D136 Positive connection 2 (15a), in engine compartment wiring harness
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
CLICK HERE TO DOWNLOAD THE
Fuelgaugesender,Fuelgauge,Fuelsystempressurisation pump, Coolant shortage indicator sender, Control unit in dash panel insert, Dash panel insert, Alternator warning lamp, Heater warning lamp
G Fuel gauge sender
G1 Fuel gauge
G6 Fuel system pressurisation pump
G32 Coolant shortage indicator sender
J285 Control unit in dash panel insert
K Dash panel insert
K2 Alternator warning lamp
K11 Heater warning lamp
K31 Cruise control system warning lamp
K36 Coolant shortage warning lamp
K38 Oil level warning lamp
K43 Coolant temperature warning lamp (too cold)
T2t 2-pin connector
T4a 4-pin connector
T6b 6-pin connector, on left in engine compartment
T11a 11-pin connector, on left in engine compartment
T32a 32-pin connector
327 Earth connection (sender earth), in engine compartment wiring harness
401 Earth connection (sender earth), in interior wiring harness
Oil pressure switch, Brake fluid level warning contact, Rev. counter, Speedometer, Control unit in dash panel insert, Dash panel insert, Oil pressure warning lamp, Exhaust emissions warning lamp, Reserve fuel warning lamp, Brake system warning lamp
F22 Oil pressure switch
F34 Brake fluid level warning contact
G5 Rev. counter
G21 Speedometer
J285 Control unit in dash panel insert
K Dash panel insert
K3 Oil pressure warning lamp
K83 Exhaust emissions warning lamp
K105 Reserve fuel warning lamp
K118 Brake system warning lamp
K132 Electronic power control fault lamp
T1f Single connector
T2u 2-pin connector
T11a 11-pin connector, on left in engine compartment
T14a 14-pin connector, on left in engine compartment
T32a 32-pin connector
1.6l engine , CCRA,(2U4)
From July 2011
Battery, Starter, Alternator, Voltage regulator, Onboard supply control unit
A Battery
B Starter
C Alternator
C1 Voltage regulator
J519 Onboard supply control unit
S162 Fuse 1 (30), in battery fuse holder
S163 Fuse 2 (30), in battery fuse holder
S164 Fuse 3 (30), in battery fuse holder
S178 Fuse 6 (30), in battery fuse holder
S180 Fuse 8 (30), in battery fuse holder
S267 Fuse 9 (30), in battery fuse holder
S269 Fuse 11 (30), in battery fuse holder
T1e Single connector
T2r 2-pin connector, near dual-tone horns
T2s 2-pin connector
T3c 3-pin connector, on left in engine compartment
T6k 6-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T12a 12-pin connector, on left in engine compartment
T18a 18-pin connector
1 Earth strap, battery - body
507 Threaded connection (30), on battery fuse holder
Polo/Polo Sedan
Ignition/starter switch, X-contact relief relay, Onboard supply control unit
D Ignition/starter switch
E2 Turn signal switch
J59 X-contact relief relay
J217 Automatic gearbox control unit
J519 Onboard supply control unit
T6o 6-pin connector
T8c 8-pin connector
T9a 9-pin connector, on left in engine compartment
T12d 12-pin connector
T18a 18-pin connector
T41a 41-pin connector
T80b 80-pin connector
238 Earth connection 1, in interior wiring harness
B172 Positive connection 4 (30), in interior wiring harness
B491 Positive connection (75), in interior wiring harness
B493 Connection (75x), in interior wiring harness
D210 Connection (50), in engine compartment wiring harness
* Only models with driver and front passenger airbags
*2 Only models with multifunction steering wheel
*3 Only models with automated manual gearbox
Polo/Polo Sedan
Handbrake warning switch, Onboard supply control unit
F9 Handbrake warning switch
J301 Air conditioning system control unit
J519 Onboard supply control unit
T2b 2-pin connector
T5d 5-pin connector
T5f 5-pin connector
T16c 16-pin connector
T16e 16-pin connector
42 Earth point, next to steering column
249 Earth connection 2, in interior wiring harness
278 Earth connection 4, in interior wiring harness
279 Earth connection 5, in interior wiring harness
284 Earth connection 6, in interior wiring harness
285 Earth connection 7, in interior wiring harness
296 Earth connection 11, in interior wiring harness
606 Earth point, under the centre console near gear stick
* Diagnostic connection
*2 Saloon
Reversing light switch, Onboard supply control unit
F4 Reversing light switch
J519 Onboard supply control unit
T2aa 2-pin connector
T6ah 6-pin connector
T6k 6-pin connector, on left in engine compartment
T6u 6-pin connector
T11b 11-pin connector, on left in engine compartment
T16b 16-pin connector
T18a 18-pin connector
B182 Connection (RL), in interior wiring harness
B239 Positive connection 1 (50), in interior wiring harness
B492 Positive connection 3 (15), in interior wiring harness
* Only models with driver and front passenger airbags
*2 Only models with multifunction steering wheel
Onboard supply control unit
J519 Onboard supply control unit
T16b 16-pin connector
T16e 16-pin connector
T18b 18-pin connector
B506 Connection (convenience CAN bus, high), in interior wiring harness
B507 Connection (convenience CAN bus, low), in interior wiring harness
* Diagnostic connection
Polo/Polo Sedan
ws = white
= black
= red
= red
= brown
= green
= blue
= grey
= purple
= purple
= yellow
= orange
= pink
Onboard supply control unit
J519 Onboard supply control unit
SA10 Fuse 10 in fuse holder A
SA45 Fuse 45 in fuse holder A
SA46 Fuse 46 in fuse holder A
SA47 Fuse 47 in fuse holder A
SA48 Fuse 48 in fuse holder A
SA52 Fuse 52 in fuse holder A
T5d 5-pin connector
T5f 5-pin connector
T6b 6-pin connector, on left in engine compartment
T16b 16-pin connector
T18a 18-pin connector
B162 Connection (75a), in interior wiring harness
Onboard supply control unit
J519 Onboard supply control unit
SA27 Fuse 27 in fuse holder A
SA28 Fuse 28 in fuse holder A
SA29 Fuse 29 in fuse holder A
SA30 Fuse 30 in fuse holder A
SA41 Fuse 41 in fuse holder A
T6m 6-pin connector
T16e 16-pin connector
B170 Positive connection 2 (30), in interior wiring harness
B188 Positive connection 5 (30), in interior wiring harness
B231 Positive connection 5 (30a), in interior wiring harness
* Diagnostic connection
Fuse 5 in fuse holder A, Fuse 14 in fuse holder A, Fuse 18 in fuse holder A, Fuse 19 in fuse holder A, Fuse 20 in fuse holder A
SA5 Fuse 5 in fuse holder A
SA14 Fuse 14 in fuse holder A
SA18 Fuse 18 in fuse holder A
SA19 Fuse 19 in fuse holder A
SA20 Fuse 20 in fuse holder A
T6k 6-pin connector, on left in engine compartment
B163 Positive connection 1 (15), in interior wiring harness
B171 Positive connection 3 (30), in interior wiring harness
B235 Positive connection 4 (15a), in interior wiring harness
D104 Positive connection 2 (30a), in engine compartment wiring harness
Fuse 4 in fuse holder A, Fuse 9 in fuse holder A, Fuse 25 in fuse holder A, Fuse 32 in fuse holder A, Fuse 36 in fuse holder A, Fuse 37 in fuse holder A
E9 Fresh air blower switch
SA4 Fuse 4 in fuse holder A
SA9 Fuse 9 in fuse holder A
SA25 Fuse 25 in fuse holder A
SA32 Fuse 32 in fuse holder A
SA36 Fuse 36 in fuse holder A
SA37 Fuse 37 in fuse holder A
T5m 5-pin connector
T6b 6-pin connector, on left in engine compartment
T10d 10-pin connector, behind dash panel
Polo/Polo Sedan
Brake light switch, Clutch pedal switch, Brake pedal switch, Engine control unit
E227 Cruise control system (CCS) SET button
F Brake light switch
F36 Clutch pedal switch
F47 Brake pedal switch
J623 Engine control unit
T4b 4-pin connector
T4c 4-pin connector
T6k 6-pin connector, on left in engine compartment
T11c 11-pin connector, on left in engine compartment
T41a 41-pin connector
T80a 80-pin connector
67 Earth point, on left of front cross member
131 Earth connection 2, in engine compartment wiring harness
B157 Positive connection 3 (15a), in interior wiring harness
D101 Connection 1 in engine compartment wiring harness
* Only models with driver and front passenger airbags
*2 Only models with multifunction steering wheel
*3 Saloon
*4 Squareback
Polo/Polo Sedan
Starter motor relay, X contact relief relay 2, Engine control unit, Starter motor relay 2
J53 Starter motor relay
J301 Air conditioning system control unit
J339 X contact relief relay 2
J623 Engine control unit
J695 Starter motor relay 2
T9a 9-pin connector, on left in engine compartment
T9f 9-pin connector
T9g 9-pin connector
T10i 10-pin connector
T11d 11-pin connector, on left in engine compartment
T14a 14-pin connector, on left in engine compartment
T16c 16-pin connector
T80a 80-pin connector
B515 Positive connection 4 (87), in interior wiring harness
B608 Connection 4, in interior wiring harness
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
CLICK HERE TO DOWNLOAD THE
Polo/Polo Sedan
Fuel pump relay, Engine control unit, Fuel supply relay
J17 Fuel pump relay
J623 Engine control unit
J643 Fuel supply relay
T6b 6-pin connector, on left in engine compartment
T6f 6-pin connector
T10c 10-pin connector
T80a 80-pin connector
B146
B165
B169
Polo/Polo Sedan
Speedometer sender, Engine control unit, Ignition transformer, Spark plug connector, Spark plugs
G22 Speedometer sender
J217 Automatic gearbox control unit
J623 Engine control unit
N152 Ignition transformer
P Spark plug connector
Q Spark plugs
T3n 3-pin connector
T4l 4-pin connector
T14a 14-pin connector, on left in engine compartment
T80a 80-pin connector
T80b 80-pin connector
331 Earth connection, in injection system wiring harness
* Only models with automated manual gearbox
Polo/Polo Sedan
Enginespeedsender,Hallsender,Knocksensor1,Coolant temperature sender, Engine control unit
G28 Engine speed sender
G40 Hall sender
G61 Knock sensor 1
G62 Coolant temperature sender
J623 Engine control unit
T2bi 2-pin connector
T2ce 2-pin connector
T3l 3-pin connector
T3m 3-pin connector
T80a 80-pin connector
220 Earth connection (sender earth), in engine wiring harness
E46 Positive connection 1 (5 Volt) in injection system wiring harness
Intake air temperature sender, Intake manifold pressure sender, Engine control unit, Injector, cylinder 1, Injector, cylinder 2, Injector, cylinder 3, Injector, cylinder 4
G42 Intake air temperature sender
G71 Intake manifold pressure sender
J623 Engine control unit
N30 Injector, cylinder 1
N31 Injector, cylinder 2
N32 Injector, cylinder 3
N33 Injector, cylinder 4
T2bf 2-pin connector
T2bg 2-pin connector
T2bh 2-pin connector
T2cd 2-pin connector
T4t 4-pin connector
T14a 14-pin connector, on left in engine compartment
T80a 80-pin connector
E48 Connection (injectors), in injection system wiring harness
Polo/Polo Sedan
ws = white
= black
= red
= red
= brown
= green
= blue
grey
= purple
= purple
yellow
Accelerator position sender, Accelerator position sender 2, Throttle valve drive for electric throttle, Throttle valve drive anglesender1forelectricthrottle,Throttlevalvedriveangle
sender 2 for electric throttle, Engine control unit
G79 Accelerator position sender
G185 Accelerator position sender 2
G186 Throttle valve drive for electric throttle
G187 Throttle valve drive angle sender 1 for electric throttle
G188 Throttle valve drive angle sender 2 for electric throttle
J623 Engine control unit
T6ad 6-pin connector
T6ae 6-pin connector
T11c 11-pin connector, on left in engine compartment
T80a 80-pin connector
Polo/Polo Sedan
orange
Clutchpedalswitchforenginestart,Lambdaprobe,Lambda probe after catalytic converter, Engine control unit, Activated charcoal filter solenoid valve 1
F194 Clutch pedal switch for engine start
G39 Lambda probe
G130 Lambda probe after catalytic converter
J623 Engine control unit
N80 Activated charcoal filter solenoid valve 1
T2ab 2-pin connector
T2dj 2-pin connector
T4ab 4-pin connector
T4u 4-pin connector
T11a 11-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T80a 80-pin connector
D197 Connection 5 (87a) in engine compartment wiring harness
Engine control unit
J104 ABS control unit
J234 Airbag control unit
J301 Air conditioning system control unit
J500 Power steering control unit
J623 Engine control unit
T4ai 4-pin connector
T4i 4-pin connector
T11b 11-pin connector, on left in engine compartment
D160 Connection (low bus), in engine compartment wiring harness
Polo/Polo Sedan
Engine control unit
E45 Cruise control system switch
E227 Cruise control system (CCS) SET button
J104 ABS control unit
J301 Air conditioning system control unit
J623 Engine control unit
T6k 6-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T11c 11-pin connector, on left in engine compartment
T16c 16-pin connector
T16e 16-pin connector
T38a 38-pin connector
T41a 41-pin connector
T80a 80-pin connector
B159 Connection (diagnosis), in interior wiring harness
B185 Connection 2 (54), in interior wiring harness
B640 Connection 3 (54), in interior wiring harness
B683 Connection (CCS) in interior wiring harness
D73 Positive connection (54), in engine compartment wiring harness
* Only models with driver and front passenger airbags
*2 Only models with multifunction steering wheel
*3 Diagnostic connection
*4 Saloon
*5 Squareback
Polo/Polo Sedan
Engine control unit
J623 Engine control unit
T80a 80-pin connector
* From November 2010
*2 Only models with automated manual gearbox
Polo/Polo Sedan
= white
= black
= red
= red
= brown
Heater control unit, Fuel pre-heating heater element, Fuel preheating element 2, Fuel preheating element 3, Fuel preheating element 4
J65 Heater control unit
T3c 3-pin connector, on left in engine compartment
T5p 5-pin connector
T6ba 6-pin connector
Z66 Fuel pre-heating heater element
Z108 Fuel preheating element 2
Z109 Fuel preheating element 3
Z110 Fuel preheating element 4
purple
Polo/Polo Sedan
Radiator fan control unit, Radiator fan series resistor, Radiator fan
J293 Radiator fan control unit
N39 Radiator fan series resistor
T2dg 2-pin connector
T3y 3-pin connector
T4aa 4-pin connector
T6ak 6-pin connector
V7 Radiator fan
12 Earth point, on left in engine compartment
167 Earth connection 4, in engine compartment wiring harness
D136 Positive connection 2 (15a), in engine compartment wiring harness
* From November 2010
Polo/Polo Sedan
Immobiliser reader coil, Fuel gauge sender, Fuel gauge, Fuel system pressurisation pump, Coolant shortage indicator sender, Control unit in dash panel insert, Dash panel insert, Alternator warning lamp, Heater warning lamp
D2 Immobiliser reader coil
G Fuel gauge sender
G1 Fuel gauge
G6 Fuel system pressurisation pump
G32 Coolant shortage indicator sender
J285 Control unit in dash panel insert
J362 Immobiliser control unit
K Dash panel insert
K2 Alternator warning lamp
K11 Heater warning lamp
K31 Cruise control system warning lamp
K36 Coolant shortage warning lamp
K38 Oil level warning lamp
K43 Coolant temperature warning lamp (too cold)
T2a 2-pin connector
T2t 2-pin connector
T4a 4-pin connector
T6b 6-pin connector, on left in engine compartment
T11a 11-pin connector, on left in engine compartment
T32a 32-pin connector
327 Earth connection (sender earth), in engine compartment wiring harness
401 Earth connection (sender earth), in interior wiring harness
Polo/Polo Sedan
Oil pressure switch, Brake fluid level warning contact, Rev. counter, Speedometer, Control unit in dash panel insert, Dash panel insert, Oil pressure warning lamp, Exhaust emissions warning lamp, Reserve fuel warning lamp, Brake system warning lamp
F22 Oil pressure switch
F34 Brake fluid level warning contact
G5 Rev. counter
G21 Speedometer
J285 Control unit in dash panel insert
K Dash panel insert
K3 Oil pressure warning lamp
K83 Exhaust emissions warning lamp
K105 Reserve fuel warning lamp
K118 Brake system warning lamp
K132 Electronic power control fault lamp
T1f Single connector
T2u 2-pin connector
T8a 8-pin connector
T11a 11-pin connector, on left in engine compartment
T14a 14-pin connector, on left in engine compartment
T32a 32-pin connector
2.0l engine , CFEA
From July 2011
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
CLICK HERE TO DOWNLOAD THE
Battery, Starter, Alternator, Voltage regulator, Onboard supply control unit
A Battery
B Starter
C Alternator
C1 Voltage regulator
J519 Onboard supply control unit
S162 Fuse 1 (30), in battery fuse holder
S163 Fuse 2 (30), in battery fuse holder
S164 Fuse 3 (30), in battery fuse holder
S180 Fuse 8 (30), in battery fuse holder
S267 Fuse 9 (30), in battery fuse holder
S269 Fuse 11 (30), in battery fuse holder
T1e Single connector
T2r 2-pin connector, near dual-tone horns
T2s 2-pin connector
T3c 3-pin connector, on left in engine compartment
T6k 6-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T12a 12-pin connector, on left in engine compartment
T18a 18-pin connector
1 Earth strap, battery - body
507 Threaded connection (30), on battery fuse holder
Polo Current Flow Diagram
Ignition/starterswitch,Blockingdiode,X-contactreliefrelay, Onboard supply control unit
D Ignition/starter switch
E2 Turn signal switch
J29 Blocking diode
J59 X-contact relief relay
J519 Onboard supply control unit
T6ah 6-pin connector
T6o 6-pin connector
T8c 8-pin connector
T18a 18-pin connector
T41a 41-pin connector
B172 Positive connection 4 (30), in interior wiring harness
B491 Positive connection (75), in interior wiring harness
B762 Connection 1 (blocking diode), in interior wiring harness
B763 Connection 2 (blocking diode), in interior wiring harness
Onboard supply control unit, Fuel supply relay
J234 Airbag control unit
J519 Onboard supply control unit
J643 Fuel supply relay
T5f 5-pin connector
T6ah 6-pin connector
T10c 10-pin connector
T11b 11-pin connector, on left in engine compartment
T16b 16-pin connector
T18a 18-pin connector
T50a 50-pin connector
orange
Engine speed sender, Hall sender, Intake air temperature sender, Knock sensor 1, Coolant temperature sender, Intake manifold pressure sender, Engine control unit
G28 Engine speed sender
G40 Hall sender
G42 Intake air temperature sender
G61 Knock sensor 1
G62 Coolant temperature sender
G71 Intake manifold pressure sender
J623 Engine control unit
T2bi 2-pin connector
T2ce 2-pin connector
T3l 3-pin connector
T3m 3-pin connector
T4t 4-pin connector
T80a 80-pin connector
220 Earth connection (sender earth), in engine wiring harness
E46 Positive connection 1 (5 Volt) in injection system wiring harness
Polo Current Flow Diagram
= white
= black
= red
= red
= brown
= green
= blue
= grey
purple
= purple
= yellow
orange
= pink
Accelerator position sender, Accelerator position sender 2, Throttle valve drive for electric throttle, Throttle valve drive anglesender1forelectricthrottle,Throttlevalvedriveangle sender 2 for electric throttle, Engine control unit
G79 Accelerator position sender
G185 Accelerator position sender 2
G186 Throttle valve drive for electric throttle
G187 Throttle valve drive angle sender 1 for electric throttle
G188 Throttle valve drive angle sender 2 for electric throttle
J623 Engine control unit
T6ad 6-pin connector
T6ae 6-pin connector
T11c 11-pin connector, on left in engine compartment
T80a 80-pin connector
Brake light switch, Brake pedal switch, Electric drive main relay, Engine control unit
F Brake light switch
F47 Brake pedal switch
J104 ABS control unit
J437 Electric drive main relay
J623 Engine control unit
T4b 4-pin connector
T6ax 6-pin connector, on left in engine compartment
T6az 6-pin connector
T6k 6-pin connector, on left in engine compartment
T11c 11-pin connector, on left in engine compartment
T14a 14-pin connector, on left in engine compartment
T38a 38-pin connector
T80a 80-pin connector
B150 Positive connection 2 (30a), in interior wiring harness
B185 Connection 2 (54), in interior wiring harness
B640 Connection 3 (54), in interior wiring harness
T6a 6-pin connector, on left in engine compartment
T6b 6-pin connector, on left in engine compartment
T11a 11-pin connector, on left in engine compartment
T14a 14-pin connector, on left in engine compartment
T32a 32-pin connector
327 Earth connection (sender earth), in engine compartment wiring harness
401 Earth connection (sender earth), in interior wiring harness
* For models with interactive system
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
CLICK HERE TO DOWNLOAD THE
= white
Radiator fan control unit
J255 Climatronic control unit
J293 Radiator fan control unit
J301 Air conditioning system control unit
T4aa 4-pin connector
T6ak 6-pin connector
T11d 11-pin connector, on left in engine compartment
T16c 16-pin connector
T16g 16-pin connector
B608 Connection 4, in interior wiring harness
D136 Positive connection 2 (15a), in engine compartment wiring harness
ws = white
Radiator fan control unit
J255 Climatronic control unit
J293 Radiator fan control unit
J301 Air conditioning system control unit
T4aa 4-pin connector
T6ak 6-pin connector
T11d 11-pin connector, on left in engine compartment
T16c 16-pin connector
T16g 16-pin connector
= green
= blue
= grey
= purple
= purple ge = yellow or = orange rs = pink
High-pressure sender, Air conditioning system magnetic clutch, Air conditioner compressor regulating valve, Radiator fan, Right radiator fan
G65 High-pressure sender
J255 Climatronic control unit
J301 Air conditioning system control unit
N25 Air conditioning system magnetic clutch
N280 Air conditioner compressor regulating valve
T2cf 2-pin connector, near dual-tone horns
T2cg 2-pin connector, near compressor
T3s 3-pin connector
T3u 3-pin connector
T3v 3-pin connector
T11d 11-pin connector
T16c 16-pin connector
T16g 16-pin connector
V7 Radiator fan
V35 Right radiator fan
12 Earth point, on left in engine compartment
167 Earth connection 4, in engine compartment wiring harness
D167 Connection (fan stage I), in engine compartment wiring harness
D168 Connection (fan stage II), in engine compartment wiring harness
* Only models with Climatronic
Fuse 9 in fuse holder A, Fuse 14 in fuse holder A, Fuse 25 in fuse holder A, Fuse 35 in fuse holder A, Fuse 41 in fuse holder A
SA9 Fuse 9 in fuse holder A
SA14 Fuse 14 in fuse holder A
SA25 Fuse 25 in fuse holder A
SA35 Fuse 35 in fuse holder A
SA41 Fuse 41 in fuse holder A
T3c 3-pin connector, on left in engine compartment
T6b 6-pin connector, on left in engine compartment
T11a 11-pin connector, on left in engine compartment
B146 Positive connection 1 (87), in interior wiring harness
D202 Connection 6 (87a) in engine compartment wiring harness
Fuse 4 in fuse holder A, Fuse 7 in fuse holder A, Fuse 10 in fuse holder A, Fuse 36 in fuse holder A, Fuse 40 in fuse holder A
E9 Fresh air blower switch
J127 Control and regulating unit for air conditioning system
J500 Power steering control unit
SA4 Fuse 4 in fuse holder A
SA7 Fuse 7 in fuse holder A
SA10 Fuse 10 in fuse holder A
SA36 Fuse 36 in fuse holder A
SA40 Fuse 40 in fuse holder A
T4ai 4-pin connector
T5m 5-pin connector
T6al 6-pin connector
T10d 10-pin connector, behind dash panel, right
T11a 11-pin connector, on left in engine compartment
B135 Connection 1 (15a), in interior wiring harness
B162 Connection (75a), in interior wiring harness
B218 Positive connection 6 (30), in interior wiring harness
B493 Connection (75x), in interior wiring harness
* Only models with Climatronic
= white
= black
= red rt = red br = brown gn = green bl = blue gr = grey
li = purple
vi = purple
ge = yellow or = orange
rs = pink
Fuse 18 in fuse holder A, Fuse 32 in fuse holder A, Fuse 37 in fuse holder A, Fuse 45 in fuse holder A
SA18 Fuse 18 in fuse holder A
SA32 Fuse 32 in fuse holder A
SA37 Fuse 37 in fuse holder A
SA45 Fuse 45 in fuse holder A
T6b 6-pin connector, on left in engine compartment
B163 Positive connection 1 (15), in interior wiring harness
From July 2011 Polo/Polo Sedan
Air conditioning system , CCRA
Polo/Polo Sedan
Battery, Starter, Alternator, Voltage regulator, Onboard supply control unit
A Battery
B Starter
C Alternator
C1 Voltage regulator
J519 Onboard supply control unit
J623 Engine control unit
S162 Fuse 1 (30), in battery fuse holder
S163 Fuse 2 (30), in battery fuse holder
S164 Fuse 3 (30), in battery fuse holder
S180 Fuse 8 (30), in battery fuse holder
S267 Fuse 9 (30), in battery fuse holder
S269 Fuse 11 (30), in battery fuse holder
T1e Single connector
T2r 2-pin connector, near dual-tone horns
T2s 2-pin connector
T3c 3-pin connector, on left in engine compartment
T6k 6-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T12a 12-pin connector, on left in engine compartment
T18a 18-pin connector
1 Earth strap, battery - body
507 Threaded connection (30), on battery fuse holder
Ignition/starter switch, Onboard supply control unit
D Ignition/starter switch
E19 Parking light switch
J17 Fuel pump relay
J519 Onboard supply control unit
T6f 6-pin connector
T8c 8-pin connector
T18a 18-pin connector
T41a 41-pin connector
B163 Positive connection 1 (15), in interior wiring harness
B169 Positive connection 1 (30), in interior wiring harness
B172 Positive connection 4 (30), in interior wiring harness
B491 Positive connection (75), in interior wiring harness
Polo/Polo Sedan
Onboard supply control unit
E22 Intermittent wiper switch
J519 Onboard supply control unit
R Radio
SA10 Fuse 10 in fuse holder A
SA16 Fuse 16 in fuse holder A
SA18 Fuse 18 in fuse holder A
SA24 Fuse 24 in fuse holder A
SA36 Fuse 36 in fuse holder A
T5f 5-pin connector
T6u 6-pin connector
T8b 8-pin connector
T10d 10-pin connector, behind dash panel, right
T16b 16-pin connector
T18a 18-pin connector
T41a 41-pin connector
B162 Connection (75a), in interior wiring harness
Onboard supply control unit
J17 Fuel pump relay
J519 Onboard supply control unit
J623 Engine control unit
J879 Control unit for interactive system
T5d 5-pin connector
T5f 5-pin connector
T6f 6-pin connector
T6k 6-pin connector, in rear left of engine compartment
T16b 16-pin connector
T16d 16-pin connector
T16e 16-pin connector
T18a 18-pin connector
T80a 80-pin connector
B159 Connection (diagnosis), in interior wiring harness
B165 Positive connection 2 (15), in interior wiring harness
B492 Positive connection 3 (15), in interior wiring harness
* Diagnostic connection
*2 Saloon
Polo/Polo Sedan
Polo/Polo Sedan
Fresh air blower switch, Air conditioning system switch, Fresh air and air recirculation flap switch, Air conditioning system control unit, Air conditioning system switch
illumination bulb, Fresh air blower series resistor with overheating fuse, Fresh air blower, Fresh air and air recirculation flap control motor
E9 Fresh air blower switch
E30 Air conditioning system switch
E159 Fresh air and air recirculation flap switch
J301 Air conditioning system control unit
L43 Air conditioning system switch illumination bulb
N24 Fresh air blower series resistor with overheating fuse
T2bo 2-pin connector
T2bp 2-pin connector
T4w 4-pin connector
T5m 5-pin connector
T6as 6-pin connector
T10d 10-pin connector, behind dash panel, right
T11d 11-pin connector, on left in engine compartment
T16c 16-pin connector
V2 Fresh air blower
V154 Fresh air and air recirculation flap control motor
606 Earth point, under the centre console near gear stick
L78 Connection 1, in fresh air blower wiring harness
Air conditioning system control unit
J301 Air conditioning system control unit
J623 Engine control unit
T11b 11-pin connector, in rear left of engine compartment
T16c 16-pin connector
T16e 16-pin connector
T80a 80-pin connector
B180
B229
D159 Connection (high bus), in engine compartment wiring harness
D160 Connection (low bus), in engine compartment wiring harness
* Diagnostic connection *2 Saloon
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
CLICK HERE TO DOWNLOAD THE
ws = white
= black
= red
= red
= brown
= green
= blue
grey
purple
purple
yellow
orange
= pink
High-pressure sender, Air conditioning system control unit
G65 High-pressure sender
J301 Air conditioning system control unit
T3u 3-pin connector
T11d 11-pin connector, on left in engine compartment
T16c 16-pin connector
B608 Connection 4, in interior wiring harness
D136 Positive connection 2 (15a), in engine compartment wiring harness
Polo/Polo Sedan
Radiator fan control unit, Air conditioning system magnetic clutch, Radiator fan
J293 Radiator fan control unit
N25 Air conditioning system magnetic clutch
T2cf 2-pin connector, near dual-tone horns
T2cz 2-pin connector
T3s 3-pin connector
T4aa 4-pin connector
T6ak 6-pin connector
V7 Radiator fan
12 Earth point, on left in engine compartment
167 Earth connection 4, in engine compartment wiring harness
purple
purple
orange
Immobiliser reader coil, Control unit in dash panel insert,
Immobiliser control unit, Dash panel insert
D2 Immobiliser reader coil
J285 Control unit in dash panel insert
J362 Immobiliser control unit
K Dash panel insert
T2a 2-pin connector
T8a 8-pin connector
T32a 32-pin connector
42 Earth point, next to steering column
279 Earth connection 5, in interior wiring harness 606 Earth point, under the centre console near gear stick
From July 2011
Battery, Starter, Alternator, Voltage regulator, Onboard supply control unit
A Battery
B Starter
C Alternator
C1 Voltage regulator
J519 Onboard supply control unit
J623 Engine control unit
S162 Fuse 1 (30), in battery fuse holder
S163 Fuse 2 (30), in battery fuse holder
S164 Fuse 3 (30), in battery fuse holder
S180 Fuse 8 (30), in battery fuse holder
S267 Fuse 9 (30), in battery fuse holder
T1e Single connector
T2r 2-pin connector, near dual-tone horns
T2s 2-pin connector
T3c 3-pin connector, on left in engine compartment
T6k 6-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T18a 18-pin connector
1 Earth strap, battery - body
507 Threaded connection (30), on battery fuse holder
Ignition/starter switch, Onboard supply control unit
D Ignition/starter switch
E2 Turn signal switch
J519 Onboard supply control unit
SA26 Fuse 26 in fuse holder A
SA29 Fuse 29 in fuse holder A
T5d 5-pin connector
T8c 8-pin connector
T18a 18-pin connector
T18b 18-pin connector
T41a 41-pin connector
B163 Positive connection 1 (15), in interior wiring harness
B172 Positive connection 4 (30), in interior wiring harness
B188 Positive connection 5 (30), in interior wiring harness
X-contact relief relay, Radiator fan control unit
E2 Turn signal switch
J59 X-contact relief relay
J293 Radiator fan control unit
SA10 Fuse 10 in fuse holder A
SA16 Fuse 16 in fuse holder A
SA18 Fuse 18 in fuse holder A
SA36 Fuse 36 in fuse holder A
T4aa 4-pin connector
T6ak 6-pin connector
T6o 6-pin connector
T41a 41-pin connector
238 Earth connection 1, in interior wiring harness
249 Earth connection 2, in interior wiring harness
278 Earth connection 4, in interior wiring harness
606 Earth point, under the centre console near gear stick
B162 Connection (75a), in interior wiring harness
B491 Positive connection (75), in interior wiring harness
B493 Connection (75x), in interior wiring harness
Radiator fan control unit, Radiator fan series resistor, Radiator fan
J293 Radiator fan control unit
J623 Engine control unit
N39 Radiator fan series resistor
T2dg 2-pin connector
T3s 3-pin connector
T3y 3-pin connector
T4aa 4-pin connector
T6ak 6-pin connector
V7 Radiator fan
D167 Connection (fan stage I), in engine compartment wiring harness
D168 Connection (fan stage II), in engine compartment wiring harness
* Only models with 2.0l engine
*2 Only models with 1.6l engine
*3 see applicable current flow diagram for engine
brown
green
High-pressure sender, Right radiator fan
G65 High-pressure sender
T3u 3-pin connector
T3v 3-pin connector
T11d 11-pin connector, on left in engine compartment
V35 Right radiator fan
12 Earth point, on left in engine compartment
167 Earth connection 4, in engine compartment wiring harness
B608 Connection 4, in interior wiring harness
D136 Positive connection 2 (15a), in engine compartment wiring harness
* Only models with 2.0l engine
Centreventtemperaturesender,Footwellventtemperature sender, Evaporator output temperature sender, Climatronic control unit
G191 Centre vent temperature sender
G192 Footwell vent temperature sender
G263 Evaporator output temperature sender
J255 Climatronic control unit
T2ai 2-pin connector
T2ci 2-pin connector
T2cj 2-pin connector
T16e 16-pin connector
T16g 16-pin connector
T20a 20-pin connector
42 Earth point, next to steering column
243 Earth connection 1, in Climatronic wiring harness
279 Earth connection 5, in interior wiring harness 284 Earth connection 6, in interior wiring harness
Earth connection 7, in interior wiring harness
606 Earth point, under the centre console near gear stick
* Diagnostic connection
*2 Saloon
Fresh air and air recirculation flap switch, Dash panel temperature sensor, Climatronic control unit, Fresh air and air recirculation warning lamp, Fresh air regulator illumination bulb, Air conditioner compressor regulating valve, Temperature sensor blower
E159 Fresh air and air recirculation flap switch
G56 Dash panel temperature sensor
J255 Climatronic control unit
K114 Fresh air and air recirculation warning lamp
L16 Fresh air regulator illumination bulb
N280 Air conditioner compressor regulating valve
T2cf 2-pin connector, near dual-tone horns
T2cg 2-pin connector, near compressor
T11d 11-pin connector, on left in engine compartment
T12j 12-pin connector
T16e 16-pin connector
T16g 16-pin connector
T20a 20-pin connector
V42 Temperature sensor blower
B231 Positive connection 5 (30a), in interior wiring harness
B506 Connection (convenience CAN bus, high), in interior wiring harness
B507 Connection (convenience CAN bus, low), in interior wiring harness
B592 Connection 1, in Climatronic wiring harness
* Diagnostic connection
Potentiometer for temperature selection rotary knob,
Control and regulating unit for air conditioning system, Climatronic control unit, Fresh air blower
G267 Potentiometer for temperature selection rotary knob
J127 Control and regulating unit for air conditioning system
J255 Climatronic control unit
T6al 6-pin connector
T11d 11-pin connector, on left in engine compartment
T12j 12-pin connector
T16g 16-pin connector
V2 Fresh air blower
606 Earth point, under the centre console near gear stick
Potentiometer for temperature flap control motor, Potentiometer for footwell/defroster flap control motor, Potentiometer for air recirculation flap control motor, Climatronic control unit, Temperature flap control motor, Footwell and defroster flap control motor
G92 Potentiometer for temperature flap control motor
G114 Potentiometer for footwell/defroster flap control motor
G143 Potentiometer for air recirculation flap control motor
J255 Climatronic control unit
T6an 6-pin connector
T6ao 6-pin connector
T6ap 6-pin connector
T20a 20-pin connector
V68 Temperature flap control motor
V85 Footwell and defroster flap control motor
V154 Fresh air and air recirculation flap control motor
= white
Sunlight penetration photosensor, Potentiometer for defroster flap control motor, Climatronic control unit, Defroster flap control motor
G107 Sunlight penetration photosensor
G135 Potentiometer for defroster flap control motor
J255 Climatronic control unit
T2ch 2-pin connector
T6af 6-pin connector
T12j 12-pin connector
T16g 16-pin connector
T20a 20-pin connector
V107 Defroster flap control motor
= brown
= blue
grey
= purple
= purple
= yellow
= orange
= pink
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
CLICK HERE TO DOWNLOAD THE
ws = white sw = black ro = red
rt = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
vi = purple
ge = yellow or = orange
rs = pink
Rev. counter, Ambient temperature sensor, Speedometer, Control unit in dash panel insert, Dash panel insert, Alternator warning lamp
G5 Rev. counter
G17 Ambient temperature sensor
G21 Speedometer
J285 Control unit in dash panel insert
K Dash panel insert
K2 Alternator warning lamp
T2bn 2-pin connector
T6a 6-pin connector, on left in engine compartment
T6b 6-pin connector, on left in engine compartment
T8a 8-pin connector
T32a 32-pin connector
327 Earth connection (sender earth), in engine compartment wiring harness
401 Earth connection (sender earth), in interior wiring harness
Automated manual gearbox , CCRA
From July 2011
= white
black
red
red
= brown
green
= blue
grey
purple
purple
= yellow
orange
pink
Battery, Starter, Alternator, Voltage regulator, Onboard supply control unit
A Battery
B Starter
C Alternator
C1 Voltage regulator
J519 Onboard supply control unit
J623 Engine control unit
S162 Fuse 1 (30), in battery fuse holder
S163 Fuse 2 (30), in battery fuse holder
S270 Fuse 12 (30), in battery fuse holder
T1e Single connector
T2r 2-pin connector, near dual-tone horns
T2s 2-pin connector
T6k 6-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T18a 18-pin connector
1 Earth strap, battery - body
Polo Current Flow Diagram
Ignition/starter switch, Onboard supply control unit
D Ignition/starter switch
E2 Turn signal switch
J519 Onboard supply control unit
R Radio
T6c 6-pin connector
T8b 8-pin connector
T8c 8-pin connector
T16b 16-pin connector
T18a 18-pin connector
T41a 41-pin connector
B162 Connection (75a), in interior wiring harness
B172 Positive connection 4 (30), in interior wiring harness
B239 Positive connection 1 (50), in interior wiring harness
Automatic gearbox control unit, Gearbox hydraulic pump relay, Hydraulic pump for gearbox
J217 Automatic gearbox control unit
J510 Gearbox hydraulic pump relay
J623 Engine control unit
T2dp 2-pin connector
T4ar 4-pin connector
T6ax 6-pin connector, on left in engine compartment
T9a 9-pin connector, on left in engine compartment
T11d 11-pin connector, on left in engine compartment
T80b 80-pin connector
V387 Hydraulic pump for gearbox
238 Earth connection 1, in interior wiring harness
Earth connection 2, in interior wiring harness
278 Earth connection 4, in interior wiring harness
606 Earth point, under the centre console near gear stick
D210 Connection (50), in engine compartment wiring harness
Brake light switch, Brake pedal switch, Automatic gearbox control unit
F Brake light switch
F47 Brake pedal switch
J104 ABS control unit
J217 Automatic gearbox control unit
J623 Engine control unit
T4b 4-pin connector
T6g 6-pin connector, on left in engine compartment
T11c 11-pin connector, on left in engine compartment
T11d 11-pin connector, on left in engine compartment
T38a 38-pin connector
T80b 80-pin connector
B155 Connection 2 (DCt), in interior wiring harness
B157 Positive connection 3 (15a), in interior wiring harness
B185 Connection 2 (54), in interior wiring harness
B640 Connection 3 (54), in interior wiring harness
D73 Positive connection (54), in engine compartment wiring harness
D101 Connection 1 in engine compartment wiring harness
* Saloon
Polo Current Flow Diagram
Automatic gearbox control unit
J217 Automatic gearbox control unit
J623 Engine control unit
T6g 6-pin connector, on left in engine compartment
T6k 6-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T11d 11-pin connector, on left in engine compartment
T16e 16-pin connector
T80b 80-pin connector
B159 Connection (diagnosis), in interior wiring harness
B230 Connection (low bus), in interior wiring harness
D159 Connection (high bus), in engine compartment wiring harness
D160 Connection (low bus), in engine compartment wiring harness
D166 Connection (K-diagnosis wire), in engine compartment wiring harness
* Diagnostic connection
Handbrake warning switch, Automatic gearbox control unit, Clutch actuator valve, Selector lever valve 1, Selector lever valve 2, Selector lever valve 3
F9 Handbrake warning switch
J217 Automatic gearbox control unit
N255 Clutch actuator valve
N284 Selector lever valve 1
N285 Selector lever valve 2
N286 Selector lever valve 3
T2b 2-pin connector
T2dk 2-pin connector
T2dl 2-pin connector
T2dm 2-pin connector
T2dn 2-pin connector
T14b 14-pin connector, on left in engine compartment
T80b 80-pin connector
12 Earth point, on left in engine compartment
42 Earth point, next to steering column
80 Earth point, on centre of front cross member
279 Earth connection 5, in interior wiring harness
285 Earth connection 7, in interior wiring harness
331 Earth connection, in injection system wiring harness
B160 Connection (brake system monitor), in interior wiring harness
* From June 2012
= white
Gearbox input speed sender, Clutch position sender, Gear detection sensor, Automatic gearbox control unit
G182 Gearbox input speed sender
G476 Clutch position sender
G604 Gear detection sensor
J217 Automatic gearbox control unit
T2do 2-pin connector
T4as 4-pin connector
T4at 4-pin connector
T14b 14-pin connector, on left in engine compartment
T14c 14-pin connector, on left in engine compartment
T80b 80-pin connector
purple
purple
yellow
orange
Gearbox hydraulic pressure sender, Sensor 2 for gear detection, Automatic gearbox control unit
G270 Gearbox hydraulic pressure sender
G616 Sensor 2 for gear detection
J217 Automatic gearbox control unit
T3aa 3-pin connector
T4au 4-pin connector
T14c 14-pin connector, on left in engine compartment
T80b 80-pin connector 67 Earth point, on left of front cross member
Earth connection 1, in engine compartment wiring harness
Earth connection 2, in engine compartment wiring harness
Up to June 2012 *2 From June 2012
X-contact relief relay, Selector lever sensors control unit
J59 X-contact relief relay
J587 Selector lever sensors control unit
T3c 3-pin connector, on left in engine compartment
T6o 6-pin connector
T10k 10-pin connector
B169
B170 Positive connection
(30), in interior wiring harness
B188 Positive connection 5 (30), in interior wiring harness
B229 Connection (high bus), in interior wiring harness
B493 Connection (75x), in interior wiring harness
Starter motor relay, X contact relief relay 2, Starter motor relay 2
J53 Starter motor relay
J339 X contact relief relay 2
J623 Engine control unit
J695 Starter motor relay 2
T9a 9-pin connector, on left in engine compartment
T9f 9-pin connector
T9g 9-pin connector
T10i 10-pin connector
T14a 14-pin connector, on left in engine compartment
B515 Positive connection 4 (87), in interior wiring harness
B608 Connection 4, in interior wiring harness
Fuse 4 in fuse holder A, Fuse 10 in fuse holder A, Fuse 18 in fuse holder A, Fuse 32 in fuse holder A, Fuse 33 in fuse holder A, Fuse 39 in fuse holder A, Fuse 42 in fuse holder
SA4 Fuse 4 in fuse holder A
SA10 Fuse 10 in fuse holder A
SA18 Fuse 18 in fuse holder A
SA32 Fuse 32 in fuse holder A
SA33 Fuse 33 in fuse holder A
SA39 Fuse 39 in fuse holder A
SA42 Fuse 42 in fuse holder A
B163 Positive connection 1 (15), in interior wiring harness
B165 Positive connection 2 (15), in interior wiring harness
Operatingunitinsteeringwheel,Tiptronicswitchinsteering wheel to shift down, Multifunction buttons on left in steering wheel, Airbag coil connector and return ring with slip ring, Horn plate
E221 Operating unit in steering wheel
E439 Tiptronic switch in steering wheel to shift down
E440 Multifunction buttons on left in steering wheel
F138 Airbag coil connector and return ring with slip ring
H Horn plate
J234 Airbag control unit
J879 Control unit for interactive system
SA31 Fuse 31 in fuse holder A
T3ad 3-pin connector
T6be 6-pin connector
T8e 8-pin connector
T16d 16-pin connector
T41a 41-pin connector
T50a 50-pin connector
109 Earth connection, in airbag wiring harness
286 Earth connection 8, in interior wiring harness
B492 Positive connection 3 (15), in interior wiring harness
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
CLICK HERE TO DOWNLOAD THE
ws = white
Operatingunitinsteeringwheel,Tiptronicswitchinsteering wheel to shift up, Multifunction buttons on left in steering wheel, Multifunction buttons on right in steering wheel
E221 Operating unit in steering wheel
E438 Tiptronic switch in steering wheel to shift up
E440 Multifunction buttons on left in steering wheel
E441 Multifunction buttons on right in steering wheel
T3ae 3-pin connector
T8p 8-pin connector
* For models with interactive system
= blue
purple
purple
yellow
= orange
= pink
ws = white
Immobiliser reader coil, Rev. counter, Speedometer, Control unit in dash panel insert, Immobiliser control unit,
Dash panel insert
D2 Immobiliser reader coil
G5 Rev. counter
G21 Speedometer
J285 Control unit in dash panel insert
J362 Immobiliser control unit
K Dash panel insert
T2a 2-pin connector
T8a 8-pin connector
T32a 32-pin connector
= blue
= grey
= purple
= purple
= yellow
= orange
= pink
From July 2011
Battery, Starter, Alternator, Voltage regulator, Onboard supply control unit
A Battery
B Starter
C Alternator
C1 Voltage regulator
J519 Onboard supply control unit
J623 Engine control unit
S162 Fuse 1 (30), in battery fuse holder
S163 Fuse 2 (30), in battery fuse holder
S269 Fuse 11 (30), in battery fuse holder
T1e Single connector
T2r 2-pin connector, near dual-tone horns
T2s 2-pin connector
T3c 3-pin connector, on left in engine compartment
T6k 6-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T12a 12-pin connector, on left in engine compartment
T18a 18-pin connector
1 Earth strap, battery - body
507 Threaded connection (30), on battery fuse holder
Ignition/starter switch, Onboard supply control unit
D Ignition/starter switch
E19 Parking light switch
J59 X-contact relief relay
J519 Onboard supply control unit
T6o 6-pin connector
T8c 8-pin connector
T18a 18-pin connector
T41a 41-pin connector
B163 Positive connection 1 (15), in interior wiring harness
B165 Positive connection 2 (15), in interior wiring harness
B169 Positive connection 1 (30), in interior wiring harness
B172 Positive connection 4 (30), in interior wiring harness
B491 Positive connection (75), in interior wiring harness
B492 Positive connection 3 (15), in interior wiring harness
Onboard supply control unit
E1 Light switch
E22 Intermittent wiper switch
J519 Onboard supply control unit
SA10 Fuse 10 in fuse holder A
SA16 Fuse 16 in fuse holder A
SA20 Fuse 20 in fuse holder A
SA29 Fuse 29 in fuse holder A
T16e 16-pin connector
T17a 17-pin connector
T18a 18-pin connector
T41a 41-pin connector
B162 Connection (75a), in interior wiring harness
B170 Positive connection 2 (30), in interior wiring harness
B171 Positive connection 3 (30), in interior wiring harness
B188 Positive connection 5 (30), in interior wiring harness
B231 Positive connection 5 (30a), in interior wiring harness
* Diagnostic connection
purple
orange
Control unit in dash panel insert, Onboard supply control unit, Dash panel insert, Airbag warning lamp
J285 Control unit in dash panel insert
J519 Onboard supply control unit
K Dash panel insert
K75 Airbag warning lamp
T8a 8-pin connector
T16b 16-pin connector
T32a 32-pin connector
Connection (high bus), in interior wiring harness
B229
B230 Connection (low bus), in interior wiring harness
Onboard supply control unit
J519 Onboard supply control unit
T16b 16-pin connector
T16e 16-pin connector
T18a 18-pin connector
B159 Connection (diagnosis), in interior wiring harness * Diagnostic connection
Airbag coil connector and return ring with slip ring, Airbag control unit, Driver side airbag igniter, Front passenger side airbag igniter 1
F138 Airbag coil connector and return ring with slip ring
H Horn plate
J234 Airbag control unit
N95 Driver side airbag igniter
N131 Front passenger side airbag igniter 1
T2ad 2-pin connector
T2ae 2-pin connector
T3f 3-pin connector
T8e 8-pin connector
T41a 41-pin connector
T50a 50-pin connector
109 Earth connection, in airbag wiring harness
Anti-lock brake system (ABS)
From July 2011
purple
purple
yellow
orange
pink
Battery, Starter, Alternator, Voltage regulator, Onboard supply control unit
A Battery
B Starter
C Alternator
C1 Voltage regulator
J519 Onboard supply control unit
J623 Engine control unit
S162 Fuse 1 (30), in battery fuse holder
S163 Fuse 2 (30), in battery fuse holder
S176 Fuse 4 (30), in battery fuse holder
S179 Fuse 7 (30), in battery fuse holder
S268 Fuse 10 (30), in battery fuse holder
S269 Fuse 11 (30), in battery fuse holder
T1e Single connector
T2r 2-pin connector, near dual-tone horns
T2s 2-pin connector
T3c 3-pin connector, on left in engine compartment
T6k 6-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T12a 12-pin connector, on left in engine compartment
T18a 18-pin connector
1 Earth strap, battery - body
507 Threaded connection (30), on battery fuse holder
* Only models with automated manual gearbox
Ignition/starter switch, X-contact relief relay, Onboard supply control unit
B163 Positive connection 1 (15), in interior wiring harness
B165 Positive connection 2 (15), in interior wiring harness
B172 Positive connection 4 (30), in interior wiring harness
B239 Positive connection 1 (50), in interior wiring harness
B491 Positive connection (75), in interior wiring harness
B492 Positive connection 3 (15), in interior wiring harness
B493 Connection (75x), in interior wiring harness
Onboard supply control unit
J519 Onboard supply control unit
SA4 Fuse 4 in fuse holder A
SA10 Fuse 10 in fuse holder A
SA23 Fuse 23 in fuse holder A
SA26 Fuse 26 in fuse holder A
SA27 Fuse 27 in fuse holder A
SA29 Fuse 29 in fuse holder A
SA32 Fuse 32 in fuse holder A
T16e 16-pin connector
T18a 18-pin connector
B157 Positive connection 3 (15a), in interior wiring harness
B162 Connection (75a), in interior wiring harness
B169 Positive connection 1 (30), in interior wiring harness
B188 Positive connection 5 (30), in interior wiring harness
B231 Positive connection 5 (30a), in interior wiring harness
* Diagnostic connection
Handbrake warning switch, Onboard supply control unit
F9 Handbrake warning switch
J519 Onboard supply control unit
T2b 2-pin connector
T5d 5-pin connector
T16e 16-pin connector 42
606 Earth point, under the centre console near gear stick
* Diagnostic connection
Saloon
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
CLICK HERE TO DOWNLOAD THE
ws = white sw = black ro = red rt = red
br = brown gn = green bl = blue
= grey li = purple vi = purple ge = yellow
= orange
rs = pink
Onboard supply control unit
J519 Onboard supply control unit
T16b 16-pin connector
T16e 16-pin connector
T18a 18-pin connector
B159 Connection (diagnosis), in interior wiring harness
B229 Connection (high bus), in interior wiring harness
B230 Connection (low bus), in interior wiring harness
* Diagnostic connection
*2 Squareback
Rear right speed sensor, Front right speed sensor, Rear left speed sensor, Front left speed sensor, ABS control unit, Front right ABS inlet valve, Front right ABS outlet valve, Front left ABS inlet valve, Front left ABS outlet valve
G44 Rear right speed sensor
G45 Front right speed sensor
G46 Rear left speed sensor
G47 Front left speed sensor
J104 ABS control unit
N99 Front right ABS inlet valve
N100 Front right ABS outlet valve
N101 Front left ABS inlet valve
N102 Front left ABS outlet valve
T2bj 2-pin connector
T2bk 2-pin connector
T2bv 2-pin connector
T2bx 2-pin connector
T9a 9-pin connector, on left in engine compartment
T38a 38-pin connector
B510 Connection 1 (rear right speed sensor), in interior wiring harness
B511 Connection 2 (rear right speed sensor), in interior wiring harness
B512 Connection 1 (rear left speed sensor), in interior wiring harness
B513 Connection 2 (rear left speed sensor), in interior wiring harness
purple
= purple ge = yellow
= orange rs = pink
ABScontrolunit,ABSreturnflowpumprelay,ABSsolenoid
valve relay, ABS return flow pump
J104 ABS control unit
J105 ABS return flow pump relay
J106 ABS solenoid valve relay
T9a 9-pin connector, on left in engine compartment
T38a 38-pin connector
V39 ABS return flow pump
29 Earth point, near ..., near ABS control unit
Brake light switch, Brake pedal switch, ABS control unit, Rear right ABS inlet valve, Rear left ABS inlet valve, Rear right ABS outlet valve, Rear left ABS outlet valve
F Brake light switch
F47 Brake pedal switch
J104 ABS control unit
J623 Engine control unit
N133 Rear right ABS inlet valve
N134 Rear left ABS inlet valve
N135 Rear right ABS outlet valve
N136 Rear left ABS outlet valve
T4b 4-pin connector
T11b 11-pin connector, on left in engine compartment
T11c 11-pin connector, on left in engine compartment
T38a 38-pin connector
B185 Connection 2 (54), in interior wiring harness
B640 Connection 3 (54), in interior wiring harness
D73 Positive connection (54), in engine compartment wiring harness
D101 Connection 1 in engine compartment wiring harness
D159 Connection (high bus), in engine compartment wiring harness
D160 Connection (low bus), in engine compartment wiring harness
* Saloon
Rev. counter, Speedometer, Control unit in dash panel insert, Dash panel insert, Alternator warning lamp, ABS
warning lamp, Tyre Pressure Loss Indicator warning lamp
G5 Rev. counter
G21 Speedometer
J285 Control unit in dash panel insert
K Dash panel insert
K2 Alternator warning lamp
K47 ABS warning lamp
K220 Tyre Pressure Loss Indicator warning lamp
T8a 8-pin connector
T32a 32-pin connector
Coming home
From July 2011
Battery, Starter, Alternator, Voltage regulator, Onboard supply control unit
A Battery
B Starter
C Alternator
C1 Voltage regulator
J519 Onboard supply control unit
J623 Engine control unit
S162 Fuse 1 (30), in battery fuse holder
S163 Fuse 2 (30), in battery fuse holder
S269 Fuse 11 (30), in battery fuse holder
T1e Single connector
T2r 2-pin connector, near dual-tone horns
T2s 2-pin connector
T3c 3-pin connector, on left in engine compartment
T6k 6-pin connector, on left in engine compartment
T11b 11-pin connector, on left in engine compartment
T12a 12-pin connector, on left in engine compartment
T18a 18-pin connector
1 Earth strap, battery - body
507 Threaded connection (30), on battery fuse holder
B163 Positive connection 1 (15), in interior wiring harness
B165 Positive connection 2 (15), in interior wiring harness
B169 Positive connection 1 (30), in interior wiring harness
B172 Positive connection 4 (30), in interior wiring harness
B239 Positive connection 1 (50), in interior wiring harness
B491 Positive connection (75), in interior wiring harness
B492 Positive connection 3 (15), in interior wiring harness
Onboard supply control unit
E2 Turn signal switch
E20 Switch and instrument illumination regulator
J519 Onboard supply control unit
T6c 6-pin connector
T6l 6-pin connector
T16b 16-pin connector
T16e 16-pin connector
T18b 18-pin connector
T41a 41-pin connector
B116 Connection (58d), in interior wiring harness
B229 Connection (high bus), in interior wiring harness
B230 Connection (low bus), in interior wiring harness
B506 Connection (convenience CAN bus, high), in interior wiring harness
B507 Connection (convenience CAN bus, low), in interior wiring harness
* Diagnostic connection
Rev. counter, Speedometer, Control unit in dash panel insert, Onboard supply control unit, Dash panel insert, Main beam warning lamp, Alternator warning lamp, Rear fog light warning lamp, Dash panel insert illumination bulb
G5 Rev. counter
G21 Speedometer
J285 Control unit in dash panel insert
J519 Onboard supply control unit
K Dash panel insert
K1 Main beam warning lamp
K2 Alternator warning lamp
K13 Rear fog light warning lamp
L10 Dash panel insert illumination bulb
T8a 8-pin connector
T32a 32-pin connector
* Only models with rear fog light
Polo/Polo Sedan
Onboard supply control unit, Windscreen wiper motor
J301 Air conditioning system control unit
J519 Onboard supply control unit
T4o 4-pin connector
T5d 5-pin connector
T5f 5-pin connector
T6g 6-pin connector, on left in engine compartment
T12a 12-pin connector, on left in engine compartment
T16c 16-pin connector
T16e 16-pin connector
T18a 18-pin connector
T18b 18-pin connector
Windscreen wiper motor 42 Earth point, next to steering column
278 Earth connection 4, in interior wiring harness
279 Earth connection 5, in interior wiring harness
284 Earth connection 6, in interior wiring harness
285 Earth connection 7, in interior wiring harness
296 Earth connection 11, in interior wiring harness
606 Earth point, under the centre console near gear stick
* Diagnostic connection
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
