DOWNLOAD PDF CATERPILLAR W33 72 DRAGLINE BOOM HOIST CONTROL PANEL MANUAL

BI624253

CATERPILLAR INC.

BOOM HOIST CONTROL PANEL MANUAL W33/72 DRAGLINE Serial Number W2420 Part number 25052G7589B]

APRIL 2011

BI624253

INDEX

1. CIRCUIT DIAGRAMS 2. PARTS LIST AND CONTROL PANEL LAYOUT 3. MEIDEN INVERTER PARAMETER SETTINGS AND BOOM HOIST CONTROL PROFILE 4. MEIDEN INVERTER INSTRUCTION MANUAL 5. MEIDEN RELAY INTERFACE INSTRUCTION MANUAL 6. MEIDEN DYNAMIC BRAKING UNIT PARAMETER SETTINGS 7. MEIDEN DYNAMIC BRAKING UNIT INSTRUCTION MANUAL 8. TEST SHEET 9. STATEMENT OF CONFORMITY 10. EQUIPMENT MANUFACTURERS / SUPPLIERS’ CERTIFICATES OF CONFORMITY

BI624253

BI624253

BI624253

BI624253

BOOM HOIST CONTROL PANEL

PARTS LIST

Item No

DESCRIPTION

QTY. CIRCUIT DIAGRAM No.

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24

ENCLOSURE PLINTH VENT FAN &FILTER UNIT FILTER UNIT TRANSFORMER ISOLATER & SHAFT FUSE CARRIER (100A) 100A FUSE LINK FUSE CARRIER (20A) 4A FUSE LINK FUSE CARRIER (20A) 2A FUSE CARRIER 45KW INVERTER BREAKING UNIT OPTIONS BOARD DYNAMIC BRAKING RESISTOR 37KW CONTACTOR AUX. BLOCK FOR ABOVE 4KW CONTACTOR CONTROL RELAY BASE FOR ABOVE JOYSTICK CONTROLLER 4 HOLE CONTROL STATION POWER ON INDICATOR (GREEN) FAULT INDICATOR (RED) START BUTTON STOP BUTTON (STAY PUT)

1 N/A 1 N/A 1 N/A 1 N/A 1 T1 1 Q1 3 F1/F2/F3 3 F1/F2/F3 3 F4/F5/F6 3 F4/F5/F6 3 F7/F8/F9 3 F7/F8/F9 1 N/A 1 N/A 1 FITTED IN INVERTER 1 MOUNTED TO REAR OF ENCLOSURE 1 KM1 1 KM1 1 KM2 8 KA1‐8 8 KA1‐8 1 REMOTE FROM PANEL 1 REMOTE FROM PANEL 1 MOUNTED IN 23

25 26 27

1 1 1

MOUNTED IN 23 MOUNTED IN 23 MOUNTED IN 23

BI624253

MEIDEN INVERTER VT240S PARAMETER SETTINGS [APRIL 2011]

ALL PARAMETERS NOT MENTIONED REMAIN AT DEFAULT SETTINGS **PARAMETERS TO BE CHECKED PRIOR TO START UP *PARAMETERS TO BE MANIPULATED ON COMMISSIONING [IF REQUIRED] #PARAMETERS NOT TO BE ALTERED

NO. A01-0 A01-1 B00-0 B00-1 B00-3 B00-6 B00-7 B10-0 B10-1 B11-1 B11-3 B11-7 B18-0 B18-1 C03-1 C03-2 C03-3 C03-4 C03-7 C03-9 C04-0 C04-2 C04-3 C04-4 C11-0 C11-3 C15-2 C31-0 C31-1 C33-0 PSO4

DESCRIPTION * ACCELERATION TIME-1 * DECELERATION TIME-1 **INPUT VOLTAGE **V/F PATTERN **OUTPUT VOLTAGE **MOTOR RATED CURRENT **CARRIER FREQUENCY *ACCELERATION TIME-2 *DECELERATION TIME-2 *SPEED 1 *SPEED 2 *SPEED 3 #OVER CURRENT LIMIT #REGEN. CURRENT LIMIT #EMS #REVERSE RUN #F JOG #R JOG #RESET #CSEL #PROG #S0 #S1 #S2 #INITIAL MODE #MONITOR PARAMETER *SPD1 LEVEL #DBR #GROUND FAULT #PS04

VALUE

UNIT

COMMENT

2.0 15 3 1 415 70 4 300 300 15 30 100 300 300 0 2 0 0 0 6 16 3 4 5 2 0.00.1 10 1121 1 10

SECS. SECS. 401-415V 50HZ VOLTS AMPS KHZ SECS SECS % 7.5HZ % 15HZ % 50HZ % % DISABLE EMS INPUT RAISE INPUT PSI2 DISABLE F JOG DISABLE R JOG DISABLE RESET INPUT RAMP SELECT INPUT PSI6 ENABLE PROGRAM SPEEDS SPEED 1 INPUT PSI3 SPEED 2 INPUT PSI4 SPEED 3 INPUT PSI5 REMOTE MONITOR PARAMETER % 5HZ DBR USED OVER VOLT OFF ON SPD1 LEVEL ON OUTPUT

A05-2 SET TO 1 TO DISPLAY B AND C PARAMETER HARDWARE OPTIONS A05-0 SET TO 1 TO DISPLAY B AND C PARAMETER EXTENDED SETTINGS

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253

BI624253