Belarus 1221.4 with motor D-260.2S3A (100,0 kW) Parts Catalogue & Assembly Manual 1221.4-0000010-01

BELARUS 1221.4 with motor D-260.2S3 (100,0 kW) 1221.4-0000010-01 KDS

CATALOGUE OF PARTS AND ASSEMBLY UNITS

The catalogue was prepared by engineer of Department of Design and Experimental Works 1 (DDER-1) I.V. Razmyslovich. Basic data was provided by key specialists of DDER-1 of RUE “Minsk tractor works”.

Chief editor - I.N.Uss, Chief Designer of PA “MTW”, Director of Scientific and Technical Center of RUE “MTW”.

Executive editor– A.G. Stasilevich, Design manager for tractor production.

Publications Assistant — Y. M. Korotky, Head of Design Bureau of Maintenance Documentation.

RUE “Minsk Tractor Works” constantly works on improving the output goods and retains the right to change the design, technical data without prior notification of the customers.

Some designations, descriptions and figures in this catalogue may differ from actual ones on your tractor. For detailed information, contact your dealer and use information bulletins, published by PA “MTW” and regularly circulated among the consumers.

© RUE “Minsk Tractor Works”, 2009 All rights reserved. This book may not be reproduced or copied in full or in part without written permission of RUE “Minsk Tractor Works”.

2

CONTENTS Introduction ........................................................................................................................ 4 How to use this catalogue .................................................................................................4 Application ......................................................................................................................... 5 Index of groups and subgroups of catalogue assembly units and parts ......................... 6 Assembly units and parts ..................................................................................................9

3

INTRODUCTION The present catalogue contains the whole range of assembly units and parts for tractors “BELARUS-1221.4“. The tractor “BELARUS-1221.4“ is four-by-four general-purpose wheeled tractor of traction class 2.

The tractor “BELARUS-1221.4“ is equipped with the engine D-260.2S3 , produced by UP MMZ, with electronic control system, power 100,0 kW. The emission level of the engine corresponds to environmental requirements of stage IIIA. HOW TO USE THE CATALOGUE The catalogue consists of three parts: 1. Tractor assembly units and parts.

2. Standardized units (bearings, collars, rings).

3. Component list.

The assembly units and parts in Part I are divided into groups and subgroups according to functional attribute. This directory is well illustrated with axonometric figures of knocked-down tractor components. All parts in the figures have sequence numbers (figure numbers), ascending consequently in a clockwise direction. For ease of catalogue reference in search for necessary part the same sequence numbers are placed in column “Pos. No.” in the text part of the catalogue in ascending order from top downward. The figures referred to in the catalogue are well-done in the terms of art and let the user get acquainted with structure and configuration of parts and assembly units. They can serve as a manual for carrying out disassembling and assembling operations.

For example, the following record is given in the catalogue: “...240-1004100-

4

Connecting rod (13,20,21,37-39)”.

It means that assembly unit “Connecting rod” in the number of 4 pieces per diesel engine consists of the following parts: bushing (pos. 21), connecting rod (pos. 20), connectingrod bolt (pos. 13), connecting-rod cap (pos. 39), washer (pos. 38) and nut (pos. 37).

“Quantity” column gives number of assembly units and parts used in this subgroup (1004) per tractor.

Conventional seven-digit system of assembly unit and parts designation (after prefix) is applied for the tractors “BELARUS-1221.4“.

Prefixes A1, A2 and A3 that follow seven-digit part number mean that the design of these parts or assembly units has been changed, but is still interchangeable with the previously produced designs. Prefixes , 1, 2, , , , etc. mean that new part designs will not be interchangeable with parts of previously produced designs, but are interchangeable with each other within the range of one symbol.

Digit prefixes that follow the part or assembly unit number, e.g. 01, 02, 03, etc., describe part or assembly unit version (structural or climatic) and these parts are not interchangeable with each other.

For example, parts “240-1104300-01 (1st cylinder tube) and “240-1104300-02 (2nd cylinder tube)” have different structural variations and are not interchangeable.

Some parts, taken from previous tractor models, have alphanumeric designations. For example, “ 18-055- -01 O-ring”. Typical sizes of rolling-contact bearings, collars and rubber O-rings, as well as their mounting location and quantity per tractor are given in Part II “Standardized units “.

The list of assembly units and parts is given in Part III “Component list“ with the components listed in the ascending order of their identification numbers, containing reference 4

to figures and items numbers. It simplifies the search of the necessary component in the list, subject to knowing its identification.

APPLICATION The tractors “BELARUS-1221.4“ are intended for performance of various agricultural operations with mounted, semi-mounted and trailed machines and implements, for transport and loading operations, driving of fixed and agricultural machines. These tractors are delivered to the customers in the Republic of Belarus and abroad.

NOTE. The catalogue is designed in accordance with construction documentation. There may be some discrepancies in the catalogue due to the ongoing design development.

Adopted abbreviations and conventional notations: GOST – State Standard OST – Industry-specific standard TU – Technical Specifications TU RB – Technical Specifications of the Republic of Belarus MMZ – Minskiy Motornyi Zavod (Minsk Motor Plant) KDS – Catalogue of parts and assembly units KD – Catalogue of parts Russian (Cyrilic Alphabet) Symbols and Designations used in Catalogue and Corresponding English Equivalents Russian (Cyrilic Alphabet) Symbols A

;

1/8”

; 80 -… ; ; 80; ; ; 80 -…; ; ; 70 -… ; ; 125 ; ; 8 8

-70; 15

English Equivalents A B V G Gg D ZH Z I K; KG1/8” L M N P; 80P-… ; PR R; R80; R ; RP-70; S; 80S-…; S15 ; S U; 70U-…

H; HCHP C; C125 CH; SCH SH NMSH; NSH SHCH 8 SHP 8

Russian (Cyrilic Alphabet) Symbols 8 …

-114 ; 10; -3 -26 1/8” 75-

50

3/8”

5

English Equivalents SHP 8 …KZS… SCH-114B; SSH HCHP 10; HCHM TKRN-3 AMOVT HS-26 PKSH 1/8” R75-V3VR YAVAG AUSH ASH EMUSH US SHS F50 VK SHCK PK KG 3/8” DOT TD

INDEX OF GROUPS AND SUBGROUPS OF CATALOGUE ASSEMBLY UNITS AND PARTS Group 11

Subgroup

Fig.No

Name

Page Fuel system

1101 1108 1117 1109

11.1 11.2 11.3 11.4

1205

12.1

1301 1317

13.1 13.2

1601

1602 1602 1602

16.1 16.2 16.3 16.4 16.5 16.6

1701 1701 1701 1701 1701 1702 1701 1701 1701

17.1 17.2 17.3 17.4 17.5 17.6 17.7 17.8 17.9

1701

17.10

1701 1701 1702 1704 -25 1716 1737

17.11 17.12 17.13 17.14 17.15 17.16 17.17

1802

18.1

2203 2210

22.1 22.2

2300 2308 2302 2308

23.1 23.2 23.3 23.4

2401, 2403, 2407 2401 2409

24.1 24.1 24.2 24.3

2409

24.4

12 13

16 1601

17

18 22

23

24

27

Fuel tank Fuel supply control Fuel filter installation Air cleaner installation Gas exhaust system Muffler Cooling system Cooling unit 1520-1301009-01 Cooler installation 1523.4-1317010 Clutch Clutch installation 260.1-1005009 Clutch housing Clutch housing Clutch control Hydraulic booster Working cylinder Gear box (GB) Gear box (GB) ( 16 8) Gear box (GB). Primary shaft (16 8) Gear box (GB). Secondary shaft (16 8) Gear box (GB). Intermediate shaft. ( 16 8) Low gear shaft ( 16 8) GB control mechanism ( 16 8) Gear box (GB) ( 24 12) Gear box (GB). Primary shaft ( 12 24) Gear box (GB). Intermediate shaft ( 24 12) Gear box (GB).

Low gear and back draft shaft ( 24 12) Gear box (GB). Gear set shaft ( 24 12) Gear box (GB). Secondary shaft ( 24 12) GB control mechanism ( 24 12) Pump drive Gear-type oil pump Filter Distribution filter Drive of front driving axle Drive of front driving axle Cardan drive Cardan drive Guard Front driving axle Front driving axle Gear Differential Wheel-hub drive Rear axle

9 11 13 15 17 19 21 23 25 27 31 33 35 37 39 41 43 45 49 53 55 57 59 63 65 67 73 75 77 79 81 85 87 89 93 95 97

Rear axle. Differential. Final drives

101

Final drive (lubrication) Differential locking mechanism Wet-type differential locking mechanism

107 109 111

Drawbar hitch 2707

27.1 27.2

Drawbar hitch (configuration variants)

6

113

Group 28

Subgroup

Fig.No

2801

28.1

3003

30.1

3101 3104

31.1 31.2

3401 3407 3405 3407

34.1 34.2 34.3 34.4

3502, 3503 3502 3502 3503

35.1 35.2 35.3 35.4

3504, 3507

35.5

3504, 3507

35.6

3506 3506 3513 3514

35.7 35.8 35.9 35.10

3700 3700 3700 3724

37.1 37.2 37.3 37.4 37.5 37.6 37.7 37.8 37.9 37.10 37.11 37.12

30 31

34

35

37

3723 3723 3724 3724 3724 3724 3738 38 3805

38.1 38.2 38.3

39 3901 3912 3919

39.1 39.2 39.3

4202 4209 4209 4211 4216

42.1 42.2 42.3 42.4 42.5 42.6

4216

42.7

4216

42.8

42

Name

Page

Frame Semi-frame assembly Front axis Steering links Wheels and hubs Front driving wheels Rear driving wheels. Rear wheel hubs Steering control Steering column Hydrostatic steering control Hydraulic cylinder 50 25-200 Hydraulic tank Brakes Brakes. Brakes control Brakes (version) Wet brakes Wet brakes control Parking and emergency brake.

Parking and emergency brake control Parking and emergency brake. Parking and emergency brake control (for wet brakes) Pipelines and fittings of single wire trailer brakes’ air drive Pipelines and fittings of double wire trailer brakes’ air drive Ballon Break valve Electrical equipment Electrical equipment of engine Electrical equipment of transmission Electrical equipment of cabin Storage battery installation Head lamps installation Front lights installation Head lamps installation Front lights and head lamps installation Installation of back lights Installation of back lights Electrical equipment of heater Beacon installation Instruments

117 119 121 123 125 127 131 133 135 137 139 141 143 147 151 153 155 157 159 161 163 167 169 171 173 175 177 179 181

Dashboard

183

Tools and accessories Operator tool First aid kit Tool box

189 191 193

Power take-off (PTO) Rear PTO shaft. Reduction gear unit

195

Front PTO shaft.

Front PTO shaft. Reduction gear unit Drive pulley Rear PTO shaft control (for dry brakes) Rear PTO shaft control (for wet brakes)

201 203 207 209 211

Front PTO shaft control

7

213

Group

Subgroup 4235

Fig.No 42.9

4604 4605 4605 4605 4605 4605

4607 4607 036.50 -70 4634 4635 4635

46.1 46.2 46.3 46.4 46.5 46.6 46.7 46.7 46.7 46.7 46.7 46.8 46.9 46.10 46.11 46.12 46.13 46.14

192.000 5205 5208

52.1 52.2 52.3

6700 6702 6700 6708

67.1 67.2 67.3 67.4

46

4607

52

67

68 6800 6801 6800

81 82

84

87

68.1 68.2 68.3 68.4

Name Ballast Remote-cylinder hydraulic system Pump drive Hydraulically operated lift linkage Front lift linkage Bracket Upper link Lifting rod

Page 215 217 219 223 225 227 229

Hydraulic units and fittings

231

Hydraulic distributor valve control ( 70, RS 213 Mita) Housing and filter of hydraulic system Fast coupling Hydraulic distributor valve 70 Hydraulic hoist distributor Hydraulic hoist control Hydraulic hoist Screen wipers Front screen wiper Rear screen wiper Screen washer installation Tractor cabin Tractor cabin Cabin floor Panels Cabin doors Operator seat

251 253 257 259 263 265 269

Operator seat

289

Seat suspension Additional seat Heater 8101 81.1 Heater-cooler installation Cabin accessories 8201 82.1 Inside rear-view mirror 8201 82.2 Side rear-view mirror 8204 82.3 Sun visor Fin assembly 8400 84.1 Facing 8403 84.2 Front wings 8405 84.3 Foot step Control of FDA, DL, PTO shaft, lift linkage and reduction unit (electrics) Control of FDA, rear axle DL, rear PTO shaft and reduction 8700 87.1 unit (1221-8700250- ) 8700 87.2 Rear lift linkage control 8700 87.3 Control of DL and FDA 8700 87.4 Control of MMZ engine

8

271 273 275 277 283 285 287

295 299 301 303 305 307 309 313 315

317 321 323 325

Fig.11.1 Fuel tank

9

Group 11. Fuel system Subgroup 1101. Fuel tank Fig.No Pos.No 11.1 1 2 3 4 5 6 7 8 9 12 12 13 14 15 16 17 18 19 20 21 23 24 25 26 27 28 29 30 31 32 33 34 36 37

Assembly unit or part number 1221-1101690-01 6-6gx10.58.019 GOST 17473-80 OST 37.001.115-75 6-6 .6.019 GOST 5915-70 .265 -01 200-3806026 80-1101067 5-6g 16.58.019 GOST 1747380 1/8". 12.019 920-1101162-11 920-1101162-09 1221-1101530 14 -43-03 1221-1101680 1221-1101510 or 1221-1101510 1221-1101620 082-1103010 85-1101002 36-1101070 OST 37.001.115-75 8-6g 20.88.35.019 GOST 7796-70 11,112-100 GOST 3722-81 822-1101081 920-1101260 XC-61 70-110103512-6g 45.88.35.019 GOST 7796-70 12 OST 37.001.115-75 1221-1101130 10-6 .04.019 GOST 5916-70 10 OST 37.001.115-75 10-6g 25.88.35.019 GOST 7796-70 920-1101162-02

10

Q-ty 2 4 4 4 1 1 5 5

Name Clamp Screw Washer Nut Air pressure emergency sensor Gasket Washer Screw

1 1 1 2 4 4 2 1

Plug Pipe Pipe Fuel intake Washer Seal 6 Clamp Tank

1 1 1 1 1 1 1 2 1 2 1 8 8 4 12 12 8 1

Elbow Plug Pipe Chain Washer Bolt Ball Union body Filler neck Clamp Hose Bolt Washer Bracket Nut Washer Bolt Pipe

Fig.11.2. Fuel supply control

11

Group 11. Fuel system Subgroup 1108. Fuel supply control Fig.No Pos.No 11.2 1 2 3 5 6 7 8 11 12 13 14 18 19 20 21 23 24 25 26 28 29 31 32

Assembly unit or part number 2022 -1108015 2022 -1108020 1522-1108350 3022-1108003 80-1108028 80-1108178 80 -1108347 70-1601109-01 2522-6702066 2522-6702318 13.11.000 8-6g 45.88.35.019 8-6g 20.88.35.019 8-6g 25.88.35.019 6-6g 25.88.35.019 6-6 .6.019 8-6 .6.019 14 1,5-6 .04.019 2 12.019 GOST 397-79 6 8 EAAX-EXP0023 EAAX-EFT1743

Q-ty 1 1 1 1 1 1 1 2 2 1 1 2 2 1 2 2 2 2 2 2 5 1 1

12

Name Bracket Rod Handle Lever Washer Friction washer Disk spring Pin Bushing Blind plug Handle Bolt GOST 7795-70 Bolt GOST 7795-70 Bolt GOST 7795-70 Bolt GOST 7798-70 Nut GOST 5915-70 Nut GOST 5915-70 Nut GOST 5916-70 Forelock GOST 397-79 Washer OST 37.001.115-75 Washer OST 37.001.115-75 Electronic pedal Manual control sensor

Fig. 11.3 Fuel filter installation

13

Group 11. Fuel system Subgroup 1117. Fuel filter installation Fig.No Pos.No Assembly unit or part number 11.3 1 10-6g 30.88.35.019 2 10-6 .6.019 3 10.01.019 4 10 6 PreLine420

Q-ty 2 2 2 2 1

14

Name Bolt GOST 7796-70 Nut GOST 5915-70 Washer GOST 6958-78 Washer OST 37.001.115-75 Prefilter

Fig. 11.4 Air cleaner installation

15

Group 11. Fuel system Subgroup 1109. Air cleaner installation Fig.No Pos.No 11.4 1 2 3 4 5 6 7 8 9 10

Assembly unit or part number 260-1109005 260-1109010-01 260-1109400- -01 .10-03.019 .10-04.019 1522-1109025 260-1109009260-1109402 245-1008029 1522-1109020

Q-ty 1 1 1 2 4 2 1 1 1 1 1

16

Name Intake pipeline Air cleaner Pipe Binding screw clamp Binding screw clamp Clamp Tube Tube Tube Support Hose-component 70-81-60-0,2(2) TU 58.1051909-89

Fig. 12.1. Muffler

17

Group 12. Gas exhaust system Subgroup 1205. Muffler Fig.No

Pos.No

12.1 1 2 3 4 5

Assembly unit or part number 800-1205015800-1205130 800-1205015800-1205131 800-1205132 10 80-1205136

Q-ty 1 1 1 1 1 2 2

18

Name Muffler (1-5) Clamp (2-5) Muffler Joke Clamp Washer Nut

Fig. 13.1 Cooling unit 1520-1301009-01

19

Group 13. Cooling system Subgroup 1301. Cooling unit 1520-1301009-01 Fig.No

Pos.No

13.1

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

*

Assembly unit or part number 1520-1309080 * -61 1220-1302002 1520-1302003 85-1302071 1520-1302072 142-1303010 1221-1303004-01 80-1311002 80-1311003 80-1311004 80-1311006 1520-1303001

Q-ty

80 -1311010 80 -1311011 923-1311001 54.06.413 6-6g 40.88.35.019 8-6g 16.88.35.019 10-6g 18.88.35.019 6-6g 16.88.35.019 6-6 .6.019 8-6 .6.019 8.01.019 3,2 18.019

1 1 1 1 1 11 2 1 2 14 4 2 2 10 2 1 2 4 1 1 1

10 1520-1301.010 -01

1/4". 12.019 1523-1301001 2022-1301320

1 4 1 1 4 1 1 1 1 1 1 1 1

Interchanging accessories

20

Name Housing Clamp Bracket Tie-rod Shock absorber Bracket Hose Hose Clamp Bushing Plate Disk Hose (Hose 14 23-16 GOST 10362-76 (L=700±5) mm) Expansion tank Plug Bracket Spring Bolt GOST 7795-70 Bolt GOST 7796-70 Bolt GOST 7796-70 Bolt GOST 7798-70 Nut GOST 5915-70 Nut GOST 5915-70 Washer GOST 6958-78 Forelock GOST 397-79 Washer OST 37.001.115-75 Washer OST 37.001.115-75 Washer OST 37.001.115-75 Water radiator TU 4791-004-11943236-2006 Clamp "NORMA" TORRO 12-20/9-C6W Clamp "NORMA" TORRO 50-70/9-C6W * Plug TU 23.1.506-91 Plate Seal

Fig. 13.2 Cooler installation 1523.4-1317010

Group 13. Cooling system 21

Subgroup 1317. Cooler installation 1523.4-1317010 Fig.No

Pos.No

13.2

1 2 3 4 5 6 7 8 9 10 11 12

Assembly unit or part number 1523-13176001523.4-1317610 1523-1317620 2000-1317631 8-6g 16.88.35.019 8-6 .6.019 1/4". 12.019 1522-1317100

Q-ty 1 1 2 1 4 4 4 2 1 2 8 2

13

2

14

2

15

1

16

1

22

Name Air pipe Air pipe Air pipe Gasket Bolt GOST 7796-70 Nut GOST 5915-70 Washer OST 37.001.115-75 Plug TU 23.1.506-91 Charged air cooler Clamp "NORMA" GBS 61/20 W2 Clamp "NORMA" GBS 82/25 W2 Clamp "NORMA" GBS 101/25 W2 Silicon tube 75 100 red or Silicon tube "Sico Rubena" 270 003 152TPD 282 or Heat-resistant tube PR001-75-100-MA Silicon tube 75 100 blue or Silicon tube "Sico Rubena" 270 003 152TPD 282 or Heat-resistant tube PR001-75-100-PES Silicon tube 90 120 blue or Silicon tube "Sico Rubena" 270 003 153TPD 282 or Heat-resistant tube PR001-90-120-PES Silicon tube 50 100 red or Silicon tube "Sico Rubena" 270 003 194TPD 282 or Heat-resistant tube PR001-50-100-MA

TU

TU

TU

TU

Fig. 16. 1 Clutch installation 260.1-1005009

23

Group 16. Clutch Subgroup 1601. Clutch installation 260.1-1005009 Fig.No

Pos.No

Q-ty

Name

1 2 3 4 5 6

Assembly unit or part number 260.1-1005009 1520-1601085 85-1601090-B 1522-1601120 70-1601074 142-1601316 180205K1C17 85-1601130-01 70-1601138-01 2-4 8.32

1 1 1 1 6 3 1 2 2 48

7 8 9 10 11 12 13 14 15 16 17 18 19

1520-1601092 1520-1601123 85-16010933,2x18.019 85-1601108 85-1601096 85-1601094 85-1601083 85-1601097 1522-1601062 70-1601053 70-1601091 8x22.01

1 3 1 12 12 6 3 3 3 2 1 12 9

20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40

1522-1601051 1522-1601125 85-1601109-A 85-1601086 C 8.01.019 8 M8 16 30.01 M12x1,25 12 85-160107285-1601115 85-160111885-1601124 85-1601121 85-1601126 142-1601306 142-1601088 142-1601087142-1601314142-1601089

1 1 3 3 6 6 6 6 9 9 9 9 9 9 6 6 3 3 3 3 3

Clutch installation (1-40) Center plate (7, 36-40) Clutch disk (8-35) Backing plate (16-18, 21, 27) Bushing Cotter Bearing Driven disk (assembled with 5 and 6) Friction plate (enclosed into 4) Non-threaded fastener GOST 12642-80 (enclosed into 4) Center plate Thrust Pressure disk Forelock GOST 397-79 Washer Pin Release lever Spring Yoke Washer Bushing Damper Non-threaded fastener GOST 10299-80 (enclosed into 21) Hub (enclosed into 21) Backing plate (assembled with 19 and 20) Adjusting nut Lock washer Washer GOST 11371-78 Washer OST 37.001.115-75 Bolt GOST 7796-70 Non-threaded fastener GOST 10299-80 Nut GOST 5915-70 Washer OST 37.001.115-75 Sleeve Spring Insulating washer Plate Washer Bolt Release lever axis Bushing Release lever Spring Lock washer

16.1

24

Fig. 16.2. Clutch housing

25

Group 16. Clutch Subgroup 1601. Clutch housing Fig.No

Pos.No

16.2

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38

Assembly unit or part number * 80-1600010-03 80-1600010-08** 70-1601330 240-1002115 A19.01.100 80-1601015 240-1002082-A 240-1002085 8 M8 20 240-1002088A19.01.001 042-048-30-2-1 A19.01.003 80-1601335 020-025-30-1-6 80-1601337 305A 70-1601333 62 70-1601331 80-1601336 80-1601334 12 M12 35 20 70-4605036-03 10x25 80-1601343 80-1601342 M12 30 70-4605036 M20 1 1/4" 80-1601314 80-1601313 M8 25 M8 16 50-1601341 86-1802020 M8 35 2.2-38 58-1 048-052-25-2-4

Q-ty

Name

1 1 1 1 1 1 1 1 15 2 1 1 1 1 1 1 1 2 1 1 1 1 1 5 1 6 1 4 1 1 4 4 1 1 1 1 7 4 1 1 2 2 1

Clutch housing (1-20, 23-26, 29-34) Clutch housing (1-20, 23-26, 29-34) Gear(13-16) Throat (6-9) Cover (7, 8) Housing Gasket Net Washer Bolt Tube Plug Ring Spring ring Axis Ring Washer Bearing Ring Ring Gear Bushing Thrust washer Washer Bolt Washer Bolt Pin Gasket Cover Bolt Bolt Nut Plug Gasket Cover Bolt Bolt Cover Cage Bolt Collar Ring

*

For tractors with GB 16F 8R ** For tractors with GB 24F 12R

26

Fig. 16.3 Clutch housing

27

Group 16. Clutch Subgroup 1601. Clutch housing Fig.No

Pos.No

16.3

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38

*

Assembly unit or part number 80-1601030-01 80-1601040 80-1601050-01 2022-1601060* 80-1601070 85-1601150 80-1601160 80-1601180 50-1601180-A 80-1601190 85-1601215 50-1601022 50-1601218 10 30 10 85-1601203 986714KC17 50-1601185-A 1.1. 9.

M10 M10x3 /6gx25 85-1601172 80-1601173 240-1002055 80-1601319 115K5 105 76-1000921 80-1601318 M10 25 85-1601026 2.2-38x58-1 80-1601113-01 or 1222-1601113* 45* 80C-1601061 or 2022-1601061* 305 80-160135735 207 80-160107180-1601182 80-1601181 204A 47 80-1601356 70-3003032 3,2x25 80-160121980-4608024

Q-ty

Name

1 1 1 1 1 1 1 1 1 1 1 1 1 1 10 1 1 1 1 6 3 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1

Shifter bracket (12, 14) Sleeve (46-1 piece, 62) Shaft (16-18, 21, 22) Bushing (23 , 24*) Gear shaft(27-29) Shaft (1, 37, 40, 59, 60) Shaft (46-1 piece, 47-49, 50-1 piece, 51) Gear(30-33) Shifter (7-9) Yoke (53, 54) Shaft Blind plug Key Bolt Washer Yoke Thrust bearing Shifter Oiler Nut Stud Bracket Gasket Collar Washer Bearing Ring Bearing Plate Bolt Shaft Collar Shaft Shaft Ring Bushing Bushing Bearing Gear Ring Bearing Gear shaft Gear Axis Bearing Ring Thrust washer Nut Forelock Lever Ring

Variant for GB 24Fx12R

28

Fig. 16.3 Clutch housing

29

Group 16. Clutch Subgroup 1601. Clutch housing Fig.No

Pos.No

16.3

39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56

Assembly unit or part number 36-1601016 -611 85-1601111 020-025-30-1-6 85-1601099 10 M10 20 209A 50 80-1601083 80-1601086-A 664910E 80-1601021 112-1701343 70-1601114 80-1601191 50-4604046 1,0-

57 58 59 60 61 62 63 64 65 66

80-1601088-A 80-1601082 M12 35 12 80-1601091 80-1601041 80-1701045 80-1601092 80-1601089 M10x3 /6gx35

Q-ty

Name

1 1 1 2 1 1 1 2 1 1 1 2 1 1 2 1 1 150 mm 1 1 1 1 1 1 1 1 1 3

Housing Key 6 11 Shaft Ring Plate Washer Bolt Bearing Ring Washer Gear Bearing Shaft Clutch Pin Yoke Yoke bolt Wire

30

Gear Washer Bolt Washer Gasket Sleeve Nut Gasket Cover Stud

Fig. 16.4. Clutch control

31

Group 16. Clutch Subgroup 1602. Clutch control Fig.No

Pos.No

16.4 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

Assembly unit or part number 85-1602110 M12-35 12 3,2x18 12x32 80-160121950-3502203 85-1602112 M12x1,25 85-1602020M12 30 80-3503158-A 80-1602040A13.33.002 50-1602027 50-1602032 50-1602029 80-1602033 M16 1221-1602075

Q-ty 1 1 2 3 3 1 2 1 2 1 1 1 1 1 1 1 1 1 1 1

32

Name Rod (6, 7, 8) Bolt Washer Forelock Pin Lever Yoke Rod Nut Pedal Bolt Seal Pedal stem Case Thrust Spring Thrust washer Thrust bolt Nut Bracket

Fig. 16.5. Hydraulic booster

33

Group 16. Clutch Subgroup 1602. Hydraulic booster Fig.No

Pos.No

16.5 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

Assembly unit or part number 80-1602510 142-1602543 020-025-30-1-4 40 8 80-1602512 040-044-25-1-2 80 -1602046 80-1602513 6,350-100 18 80-1602514 80-1602521 25 80-3405044 5 16 80-1602511

Q-ty 1 2 4 4 8 2 2 1 1 1 1 1 1 4 1 1 1 1

34

Name Hydraulic booster Case Ring Bolt Washer Cover Ring Spring Piston Ball Ring Ring Lifter Bolt Spring Washer Ring Housing

Fig. 16.6. Working cylinder

35

Group 16. Clutch Subgroup 1602. Working cylinder Fig.No

Pos.No

16.6 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

Assembly unit or part number 1221 -1602550 80 -1602557 142-1602569 1221 -1602551 1221 -1602556 N14-102 (14x28x10) Simrit 85 EPDMV MOO 282 1221 -160251713 142-1602377 142-1602371 1221 -1602561 1221 -160256212x1,25 50-3502203 10 027-031-25-2-6 822-3503037

Q-ty

Name

1 1 1 1 1

Working cylinder Push rod Case Housing Piston

1

Collar

1 1 1 1 1 1 1 1 1 1 1

Distance bushing Ring Cap Valve Cover Rod Nut Yoke Nut Ring Threaded elbow

36

Fig. 17.1. Gear box (GB)

37

Group 17. Gear box (GB) Subgroup 1701. Gear box (GB) Fig.No

Pos.No

17.1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

Assembly unit or part number 112-1700010- -10

85-4608086-A 85-4608087 85-4608088

80-4608021

1221-1802094 1221-1802016 80-17013991221-1737099 70-4605036 50-100231880-1701025-

*

112-1701524 50-170145670-1701454 2-01

01-015 10 25 1/8”

31 32 33 34 35 36 37 38 39 40

*

80-1701252 80-1701026 80-1701034-01 80-1701204 1221-1802093 1221-18020893/8”

Q-ty

3 4 1 1 1 6 6 2 1 3 12 3 6 1 1 1 4 4 2 8 1 8 2 1 1 7 7 4 2 1 2 1 1 1 1 1 1 6 1 1

Name Gear box (GB) Bolt 16-6g 45.88.35.019 GOST 7796-70 Washer 16 OST 37.001.115-75 Gasket Indicator Plate Washer 6 OST 37.001.115-75 Bolt 6-6g 16.88.35.019 GOST 7798-70 Blind plug Ball 10,0-60 GOST 3722-81 Nut 10-6 .6.019 GOST 5915-70 Washer10 OST 37.001.115-75 Stud Bolt 10-6g 35.88.35.019 GOST 7796-70 Cover Gasket Union body Washer 20 OST 37.001.115-75 Bolt Eye-bolt Bolt 18-6g 55.88.35.019 GOST 7796-70 Housing Washer 18 OST 37.001.115-75 Stud Gasket Cover Bolt 12-6g 30.88.35.019 GOST 7796-70 Washer 12 OST 37.001.115-75 Pin Pin Plug Ring 027-032-30-1-4 GOST 18829-73/GOST 9833-73 Stud Gasket Sleeve Stud Nut 16-6 .6.019 GOST 5915-70 Shield Washer 10.01.019 GOST 11371-78 Joke Plug

When ordering as a spare part, 80-1701025- housing should be ordered.

38

Fig. 17.2. Gear box (GB). Primary shaft

39

Group 17. Gear box (GB) Subgroup 1701. Gear box (GB). Primary shaft Fig.No

Pos.No

17.2

Assembly unit or part number 1221 -1701020-

1 2 3 4 5 6 7 8

80C-1701060-A 80C-1701036

80C-1701035 80-1701045 80-1701056 80-1601082

9 10 11 12 13 14

1522C-1701048 80C-1701033 80C-1701060-A 1521-1701042

15 16 17 18 19 20 21 22 23 24 25 26 27

86-1802088 80C-1701032 80-1701053 1522C-1701052 1522C-1701054 80-3405044 80 -170106280 -170106480C-1701061 80 -1701063-

Q-ty 1 2 1 3 3 1 2 2 1 2 2 1 2 2 2 1 2 1 1 1 1 1 1 3 3 2 1 3 3

40

Name Gear shift group (1-21, 80-1701190-01; 80 -1701040) Synchro unit (23-28) Bushing Bolt 12-6g 30.88.35.019 GOST 7796-70 Washer 12 OST 37.001.115-75 Cover Nut Washer Bearing 409 GOST 8338-75 Washer Bearing 664910 TU RB 00234873.003-99 Gear Ring 2 60 GOST 13940-86 Bushing Synchro unit Gear Bearing 664913 TU RB 00234873.003-99 Elbow Shaft Throttle Gear Gear Bearing 309 GOST 8338-75 Spring Ball 7,938-100 GOST 3722-81 Ring Slide Pin Pin

Fig. 17.3. Gear box (GB). Secondary shaft

41

Group 17. Gear box (GB) Subgroup 1701. Gear box (GB). Secondary shaft Fig.No

Pos.No

17.3

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28

Assembly unit or part number 80-1701045 80-1701056 80-1701256 80-1701254 80-1701354 112-1701314 85-1702051 50-1702148-A 85-1702048 85-1702037112-1701316 80-1702108 85-170202980-1701348 112-1701312 80-170131380-1701141-

80-170125250-1701258 50-1701259

Q-ty

Name

1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 4 4 1 1 1-6 1-4

Nut Washer Bearing 7310 GOST 27365-87 Ring Bushing Washer Bearing 664714 GOST 24310-80 Gear Bolt 12-6g 25.88.35.019 GOST 7796-70 Washer Spring Pin Ball 10,0-60 GOST 3722-81 Shifter arm Clutch Wire 1,6GOST 3282-74 Bolt Yoke Bushing Gear Gear Sleeve Washer 10 OST 37.001.115-75 Bolt 10-6g 30.88.35.019 GOST 7796-70 Bearing 7712A GOST 27365-87 Shaft Gasket Gasket

42

Fig. 17.4. Gear box (GB). Intermediate shaft

Group 17. Gear box (GB) 43

Subgroup 1701. Gear box (GB). Intermediate shaft Fig.No

Pos.No

17.4

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 22 23 24 25 26 27 28 29 30 31 32 33 34

Assembly unit or part number 1221 -1701190112-1701200 112-1701230

80-1701151 80-1701047 80-1701186 70-1115012 48A-3801023 1522-1701214 80-1701213 1521-1701212 1522-1701216 80-1701217 1522-1701219 80-1701182 85-1702038 85-1702034 80-1701184 80-1702311 80-1702108 80-1704039 50-1702148-A 85-1702051

80-1701160 50-1701401 80-1701207 80-1701206 80-1701205

35 36 37 38 39 40 41 43 44 45

80-1701201 112-1701202 80-1701203 112-1701224 112-1701221 80-1701240

Q-ty 1 1 1 8 8 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 2 2 1 1 1 1 1 1 1 1 1 1

44

Name Intermediate shaft (9-16) Gear (28, 30-33, 35-40) Gear (28, 36, 37) Bolt 10-6g 30.88.35.019 GOST 7796-70 Washer 10 OST 37.001.115-75 Sleeve Nut Washer Bearing 311 GOST 8338-75 Clamp Pipe Gear Bushing Gear Gear Bushing Gear Bearing 3514 GOST 5721-75 Intermediate shaft Shifter arm Yoke Clutch Washer Bolt Ball 10,0-60 GOST 3722-81 Guide Spring Washer Bolt 12-6g 55.88.35.019 GOST 7795-70 Pin 2.4 8 GOST 3128-70 Shaft Ring 2 75 GOST 13940-86 Impeller Bushing Ring Plate Bearing 50215 GOST 8338-75/GOST 2893-82 Bushing Gear Bearing 864710 GOST 24310-80 Bushing Bearing 42210 GOST 8328-75 Gear Gear Bearing 692215 GOST 8328-75 Shaft

Fig. 17.5. Low gear shaft

Group 17. Gear box (GB) Subgroup 1701. Low gear shaft 45

Fig.No

Pos.No

17.5 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 * 37 38 39 39* 40 41 42 43 44 45 46 47 48

*

Assembly unit or part number 75-1701320 80-1701430 80-1701549 80-1701057 18-055240-1111103 85-1702042

85-1702041 85-1702043

85-1702049 85-1702039 85-1702051 85-1702046 85-1702045 80-1702108 85-1702035 85-1702305 12-23-668-A 50-1702048 BK12-41 85-1702027 85-1702301 80-1704039 50-1702148-A 112-1701343 112-1701351 80-1701346 80-1701346-01 1222-1701344 1025-1701344 80-1701340 80-1701306 86-1802052 52-2308097 80-1701053 80-1701311-A 80-1701420 54-31-472

Q-ty

Name

1 1 3 1 3 1 1 2 2 1 1 1 1 1 1 1 1 1 1 3 1 1 2 2 1 1 1 1 10 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1

Shaft (35, 37, 49, 51,52) Pipe Union body Union body O-ring Bolt Axis Bolt 8-6g 20.88.35.019 GOST 7796-70 Washer 8 OST 37.001.115-75 Rocking arm Ring 25 GOST 13940-86 Plate Washer 10 OST 37.001.115-75 Bolt 10-6g 20.88.35.019 GOST 7796-70 Ring 026-030-25-2-2 GOST 18829-73/GOST9833-73 Pin Shifter arm Bolt 12-6g 25.88.35.019 GOST 7796-70 Washer Ball 10,0-60 GOST 3722-81 Pin Shifter arm Bolt Wire 1,6GOST 3282-74 Shifter arm Ball 12,7-60 GOST 3722-81 Pin Spring Shim Switch Yoke Axis Guide Spring Clutch Gear Bearing 664910 TU RB 00234873.003-99 Bushing Bushing Ring 2 70 GOST 13940-86 Bushing Gear Gear Washer Bearing 12507 GOST 8328-75 Washer Nut Throttle Sleeve Pipe Spring ring

For tractors with an optional creeper mounting 46

Fig. 17.5. Low gear shaft

Group 17. Gear box (GB) Subgroup 1701. Low gear shaft 47

Fig.No

Pos.No

17.5

49 50 51 52 53 54 55

Assembly unit or part number 75-1701352 75-1701335 112-1701361 80-1701339 80-1701396 80-1701045

Q-ty 1 1 1 1 1 1 1

48

Name Bushing Shaft Gear Bushing Bearing 692309 Ring Nut

GOST 8328-75

Fig. 17.6. GB control mechanism

49

Group 17. Gear box (GB) Subgroup 1702. GB control mechanism Fig.No

Pos.No

17.6

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49

Assembly unit or part number 80-1702010 80C-1702080

Q-ty

Name

1 1

80 -170209080C-1702300 80C-1702060 80C-1702070

2 1 1 1 18 2 2 2 2 2 2 4 1 11 7 1 2 2 1 2 2 2 1 2 1 1 2 6 4 1 1 2 1 1 5 1 1 3 1 5 1 1 1 1 1 1 1 1 3 5 5

Control mechanism (1-20, 27, 28, 29-50) Housing (80 -1702090- , 24, 38, 48, 49, 52, 55, 56) Yoke (53, 54) Retainer (42-46) Shaft Shaft Washer 10 OST 37.001.115-75 Bolt 10-6g 35.88.35.019 GOST 7796-70 Ball Spring Yoke Pin 12 32 OST 37.001.163-75 Lever Forelock 3,2 18.019 GOST 397-79 Gasket Washer 6 OST 37.001.115-75 Bolt 6-6g 16.88.35.019 GOST 7798-70 Cover Washer Pin 12 55 OST 37.001.163-75 Housing Case Washer Bolt 10-6g 30.88.35.019 GOST 7796-70 Lever Handle Lever Housing Bolt 12-6g 35.88.35.019 GOST 7796-70 Washer 12 OST 37.001.115-75 Bolt Blind plug 28-10 9. GOST 3111-81 Cover Pin 8 16 GOST 3128-70 Gasket Bracket Bolt 10-6g 25.88.35.019 GOST 7796-70 Nut 16-6 .04.019 GOST 5916-70 Bolt Spring Guide Ball 10,0-60 GOST 3722-81 Bushing Breather Gasket Bushing Detent Spring Washer Housing Lever Bolt Wire 1,6GOST 3282-74

142-1702032 77.37.117 80C-1702074 80C-1702073 80-1702068

80-1702067 85-4619014 80-170207855-47-569-A 80C-1702075 75-1702600 70-1702125 75-1702500 80C-1702081

50-1702092 1221-1702025 80C-1702066 85-3503046

70-1703204 50-1702148-A 80-1704039 70-1703013 85-1702270 B50-3522023 80C-1702301 80C-1702303 80-1737113 80-1702098 80C-1702302 85-1702055 80-1702108

50

Fig. 17.6. GB control mechanism

51

Group 17. Gear box (GB) Subgroup 1702. GB control mechanism Fig.No

Pos.No

17.6

50 51 52 53 54 55 56 57 58 59

Assembly unit or part number 75-170205280C-1702083 80C-170209180C-1702092 80C-1702082 85-1702026

Q-ty

Name

1 3 1 2 4 1 1 2 12 4

Sector Key 6 10 GOST 24071-97 Shifter arm Yoke Cotter Shifter arm Gasket Bolt 10-6g 40.88.35.019 GOST 7796-70 Bolt 10-6g 30.88.35.019 GOST 7796-70 Bolt 6-6g 20.88.35.019 GOST 7798-70

52

Fig. 17.7 Gear box (GB) 1222-1700010-02/-05 (24F+12R)

53

Group 17. Gear box (GB) Subgroup 1701. Gear box (GB) (24F+12R) Fig.No

Pos.No

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Assembly unit or part number 1222-1700010-02 or 1222-1700010-05 with r/g M16x45 16 85-4608086-A 85-4608087 85-4608088 6 M6x16 80-4608021 027-032-30-1-4 20 1221-1737099 70-4605036 50-100231810 35 10 1221-2401011-02 80-17013991221-2401011-01 18 1222-1701025

21

112-1701524

2

22 23 24 25 26 27 28 29

50-1701456-A 70-1701454-A2-01 M12x30 12 01-015 10x25 3/8'' 80-1701525

1 1 7 9 4 4 1 1

30 31 32 33 34 35 36 37 39 40 41 42 43

80-1701026 1222-1701034 1222-1701071 1222-1701072 M12x60 1221-18020891221-1802093 1221-1802094 10 10 1/8”. 12.019 10,0-60 1221-1802016

1 1 2 2 2 1 1 3 6 3 1 1 1

17.7

Q-ty

Name

1 1 2 2 1 1 1 6 6 2 2 4 1 4 2 6 12 1 1 8 9 1

Gear box (GB) Gear box (GB) Bolt Washer Gasket Indicator Plate Washer Bolt Blind plug Ring Washer Union body Bolt Eye-bolt Bolt Washer Bolt Gasket Bolt Washer Housing Stud 18 3 /6g 45.66.019 GOST 22034-76 Gasket Cover Bolt Washer Adjusting pin Pin Plug Stud 20 3 /6g 65.66.019 GOST 22034-76 Gasket Sleeve Pin Washer Bolt Joke Shield Stud Washer Nut Plug Ball Cover

54

Fig. 17.8 Primary shaft Group 17. Gear box (GB) 55

Subgroup 1701. Gear box (GB). Primary shaft (24F+12R)

12 13 14 15 16 17 18 19

Assembly unit or part number 86-1802088 12 M12x30 1222-1701030 80-1701047 80-1701186 6-311A 1 1222-1701043 3KK 78x89x38E 1222-1701052 -C 114; 3.28434.3 * or 1222-1701400 1222K-1701054 1222-1701044 1222-1702088 50-170214810,0-60 1222-1702082 220-1702061 1,6- -C

20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40

80-1701045 80-1701056 309K 1222-1701049 1222-1701048 664913 1222-1701047 1222-1701042 1523-1701046 80-1701053 1523-1701032 2522-1802083 50-1601352 1222-1701393* 1222-1701390* 1222-1701392* 1222-1701396* 1222-1701397* 1222-1701398* 1222-1701394* ** 1222-1701033

Fig.No

Pos.No

17.8

1 2 3 4 5 6 7 8 9 10 11

*

Q-ty

Name

1 3 3 1 1 1 1 1 3 1 2 2 1 1 1 1 1 1 2 200 mm 1 1 1 1 1 1 1 1 1 1 1 2 1 2 2 1 3 3 3 1 0-3

Elbow Washer Bolt Sleeve Nut Washer Bearing Bushing Bearing Gear Synchro unit Synchro unit Gear Gear Yoke Spring Ball Shifter arm Bolt Wire

For synchro unit 1222-1701400 Selection

**

56

Nut Washer Bearing Washer Gear Bearing Bushing Gear Bushing Throttle Shaft-gear O-ring Adjusting pin Cone ring Lock ring Slide Spring Lifter Detent Clutch Washer

Fig. 17.9 Intermediate shaft

57

Group 17. Gear box (GB) Subgroup 1701. Gear box (GB). Intermediate shaft (24F+12R) Fig.No

Pos.No

Assembly unit or part number 1222-1701190

Q-ty

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21

M10x30 10 80-1701151 80-1701047 80-1701186 6-311A 1 1222-1701217 1222-1701213 1222K-1701219 3KK 78x89x38E 1222-1701214 1222-1701182 3514H 1222-1701218 1222-1701216 1222-1701046 50-170214810,0-60 1222-1702087 220-1702061 1,6- -C

22 23 24

1222-1702089 1523-1701212 GT-C 114; 3.28434.3 * or 1222-1701400 1222-1701393* 1222-1701390* 1222-1701392* 1222-1701396* 1222-1701397* 1222-1701398* 1222-1701394* ** 1222-1701223 1222-1701223-01** 1222-1701033** 1520-1702038 85-1702034 1520-1701184 80-1702311 80-1702108 10,0-60 80-1704039 85-1702051 12-6g 55.88.35.019

4 4 1 1 1 1 1 1 1 2 1 1 1 1 1 1 2 1 1 2 200 mm 1 1 1 1 2 2 1 3 3 3 1 0-4 0-3 0-3 1 1 1 1 1 1 1 1 1

17.9

25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43

*

1

For synchro unit 1222-1701400 Selection

**

58

Name Intermediate shaft (7-13,14-16,23,24,32,33) Bolt Washer Sleeve Nut Washer Bearing Gear Bushing Gear Bearing Gear Shaft-gear Bearing Gear Gear Bushing Spring Ball Shifter arm Bolt Wire Yoke Gear Synchro unit Synchro unit Cone ring Lock ring Slide Spring Lifter Detent Clutch Washer Washer Washer Shifter arm Yoke Clutch Washer Bolt Ball GOST 3722-81 Guide Washer Bolt GOST 7795-70

Fig. 17.10 Low gear and back draft shaft

59

Group 17. Gear box (GB) Subgroup 1701. Gear box (GB). Low gear and back draft shaft (24F+12R) Fig.No

Pos.No

17.10

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 37

**

Assembly unit or part number 75-1701320 80-1701310 1222-1702130-01 80-1701420 80-1701430 80-1701549 80-1701057 18-05518-051 240-1111103 12-22 80-3407720 1222-1702131-01 M8x20 8 25 85-1702041 85-1702042 85-1702043 10 M10x20 026-030-25-2-2 85-1702050 85-1702051 M12x25 85-1702045 80-1702108 1,6- -C 85-1702046 10,0-60 80-1704039 50-1702148** 50-1702048 12-23-66885-1702305 12,7-60 85-1702301 85-1702035 1222-1702027 112-1701343

Q-ty

Name

1 1 1 1 1 3 1 7 1 1 2 2 1 2 2 1 1 1 1 1 1 1 1 1 1 1 2 200 mm 1 3 1 1 0-5 1 1 1 1 1 1 1

Shaft (40-1 piece,53,55-58) Sleeve (3-1 piece, 49,50) Oil pipeline (7,7 ,8) Pipe Pipe Union body Union body O-ring Bolt Turning angle joint bolt Clamp with worm thread Oil pipeline Hose Bolt Washer Ring Rocking arm Axis Plate Washer Bolt Ring Shifter arm Washer Bolt Shifter arm Bolt Wire Pin Ball Guide Spring Shim Spring Pin Ball Axis Shifter arm Yoke Clutch

Selection

60

Fig. 17.10 Low gear and back draft shaft

61

Group 17. Gear box (GB) Subgroup 1701. Gear box (GB). Low gear and back draft shaft (24F+12R) Fig.No

Pos.No

17.10

38 39 40 41 42 43 44 45 46

*

Assembly unit or part number BK 12-41 1222-1701351 664910E 80-1701346 or * 80-1701346-01 70 1222-1701344 or 1025-1701344* 1520-1701340 80-1701306 12507KM

Q-ty 1 1 2 1 1 1 1 1 1 1 1

Variant with creeper

62

Name Switch Gear Bearing Bushing Bushing Ring Bushing Gear Gear Washer Bearing

Fig. 17.11 Gear set shaft

63

Group 17. Gear box (GB) Subgroup 1701. Gear box (GB). Gear set shaft (24F+12R) Fig.No

Pos.No

17.11 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

Assembly unit or part number 112-1701200 112-1701230 80-1701240 80-1701206 692215K1M 1222-1701221 2C75 2,4x8 1222-1701224 42210M 80-1701203 864710E 112-1701202 80-1701201 50215A 80-1701205 10 10 30 80-1701207-01 80-1701160

Q-ty 1 1 1 2 1 1 2 1 1 1 1 1 1 1 1 2 4 4 1 1

64

Name Gear(2,5,6,8,9,11-13,17) Gear(6,11,12) Shaft Ring Bearing Gear Ring Pin Gear Bearing Bushing Bearing Gear Bushing Bearing Plate Washer Bolt Bushing Shaft

Fig. 17.12 Secondary shaft

65

Group 17. Gear box (GB) Subgroup 1701. Gear box (GB). Secondary shaft (24F+12R) Fig.No

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

Assembly unit or part number 1222-1701050 80-170114080-1701045 1522-1701354 1522-1701254 1522-1701254-01 6-67512 2 1522-1701350 1222-1701353 664514 1222-17013141222-1702037 10,0-60 85-1702048 50-170214885-1702051 M12x25 1,6- -C

17 18 19 20 21 22 23 24 25 26 27 28 29 30

80-1702108 1222-1702029 1222-17013121222-1701313 1222-1701349 80-170114150-1701258 10 10 30 GT-D 109/116; 3.26299.3 1222-1701252 7712A 50-1701259 2025-1701033

Pos.No

17.12

Q-ty 1 1 1 1 5 5 1 1 1 2 1 1 1 1 1 1 1 200 mm 1 1 1 1 1 1 6 4 4 1 1 1 4 2

66

Name Shaft (27, inner race with rollers pos.No 28) Jack (22, bearing outer race pos.No 28) Nut Washer Washer Washer Bearing Bushing Washer Bearing Gear Shifter arm Ball Pin Spring Washer Bolt Wire Bolt Yoke Gear Gear Bushing Sleeve Gasket Washer Bolt Synchro unit Shaft-gear Bearing Gasket Bushing

Fig. 17.13 GB control mechanism

67

Group 17. Gear box (GB) Subgroup 1702. GB control mechanism (24F+12R) Fig.No 17.13

Pos.No

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50

Assembly unit or part number 1222-1702010 1222-1702080

Q-ty 1 1

6x10 16 1222-1702093 16 1222-1702096 3,2 25 2102-42161101222-1702130 1222-1702130-01 18-0551222-1702114 009-012-19-1-4

4 1 1 1 1 1 1 2 1 10 2 2 2 5 3 1 3 1 8 1 3 1 4 4 1 1 11 7 2 2 2 2 2 1 1 1 4 2 2 14 2 20 1 2 2 1 1 1 2 1 10

3,2x18 85-4619014 1222-1702092 12x32 12 35 12 2.2-25x42-1 18-051 RH 06101-012/00GA5 50 80-1702068 80-1702067 6 16 80 -1702073 80 -1702074 77.37.117 142-1702032 12x55 1222-1702070 80 -1702060 80-170207820 55-47-56980 -1702075 M10x35 10x40 10 80-4608057 1222-1702064 25 1222-1702048 85-1702051 80C-1702066 8x16 BK 12-41 50-1702048

68

Name Control mechanism Yoke housing (18-1 piece, 53-1 piece, 64 (2 200+200*=600 mm), 70-83) Key Washer Lever Washer Axis Forelock Cylinder Oil pipeline Oil pipeline O-ring Union body Ring Air pressure emergency sensor Forelock Washer Lever Pin Bolt Washer Collar Bolt Hydraulic distributor valve Washer Screw Gasket Cover Washer Bolt Lever Yoke Spring Ball Pin Shaft Shaft Housing Bolt Case Washer Bolt Bolt Washer Spring Bushing Ring Screw Washer Gasket Pin Switch Shim

Fig. 17.13 GB control mechanism

69

Group 17. Gear box (GB) Subgroup 1702. GB control mechanism (24F+12R) Fig.No 17.13

Pos.No 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 96 97 98

*

Assembly unit or part number 70-1703204 M16 50-170214880-1704039 10,0-60 70-1703013 28-10 1222-1702030 85-1702026 85-1702270 B50-3522023 85-1702055 80-1702108 1,6- -C 1222-1702055 1222-1702052 80-3401013 M10x20 1222-1702074 1222-1702081 1222-1702084 1222-1702086 1222-1702083 9,922-100 85-1702301 220-1702061 1222-1702109 1222-1702091 1222-1702107 1222-1702112 1222-1702105 941/20 M12 M12x30 50-1702092 M10 30 1222-1702610- 1 75-1702505 12-1 30 75-1702502 15.05.020 2022-17025001221-372492580-3723045 307 0.336.076 TU (red) 307 0.336.076 TU (yellow) 12 1,25-6 .6.019 GOST 5915-70 2022-1702090

Q-ty 1 1 2 1 1 1 2 1 1 1 1 2 3 (6 200+20 * 0) 1 1 3 3 1 1 1 1 1 5 1 5 1 1 1 1 1 1 1 2 4 2 1 1 2 4 1 1 1 1 2 1

Name Bolt Nut Spring Guide Ball Bushing Blind plug Cover Gasket Breather Gasket Lever Bolt Wire Lever Sector Washer Bolt Bushing Housing Shifter arm Shifter arm Shifter arm Ball Axis Bolt Shifter arm Yoke Retainer Axis Rocking arm Bearing Nut Bolt Bolt Bolt Lever Handle Switch Screw GOST 10621-80 Cover Handle Lever Harness Collar Light-emitting diode

1

Light-emitting diode

1

Nut

1

Bracket

For lockwiring of two bolts (pos. 76) of the yoke bracing (pos. 78) when assembling gear box

70

Fig. 17.13 GB control mechanism

71

Group 17. Gear box (GB) Subgroup 1702. GB control mechanism (24F+12R) Fig.No

Pos.No

17.13

99 100 101 102 103 104

Assembly unit or part number 2022-1702093 10 30 10 822-3502203 2022-1702094 85-3503046

Q-ty

Name

1 2 3 1 1 1

Bolt Bolt Nut Yoke Stud Bracket

72

Fig. 17.14. Pump drive

73

Group 17. Gear box (GB) Subgroup 1704. Pump drive Fig.No

Pos.No

17.14 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

Assembly unit or part number 80-1704010-A 80-1704040 80 -1704096M8 10 80-1704034 85-1601108 80-170401480-1704092 M12 75 25-00-00-02 80-1704093 3 /8” 80-1704016 80-1704015-A 10 10 30 80-1704030 80-1704050-A 80-1704033 8 M8 30 50-1702148-A 80-1704037 80-1704018 10 10 M10 25 2B18 80-1704041 1x100 10,0-60 80-1704039 80-1704038 030-025-30-1-4 80-170402080-1704021

Q-ty 1 1 1 1 1 1 1 2 4 1 1 2 1 1 7 7 1 1 1 2 2 2 1 1 1 1 1 1 1 1 1 1 1 2 1 1

74

Name Pump drive (1-10, 12, 15-34) Valve (20, 27-31) Clutch Bolt Washer Washer Bushing Plate Bolt Gear-type oil pump Gasket Plug Gasket Housing Washer Bolt Oil pipeline Filter Gasket Washer Bolt Spring Detent Plate Washer Washer Bolt Ring Housing Wire Ball Guide Plug Ring Shaft Cotter

Fig. 17.15. Gear-type oil pump

75

Group 17. Gear box (GB) Subgroup -25. Gear-type oil pump Fig.No

Pos.No

17.15

1 2 3 4 5 6 7 8 9 10 11

Assembly unit or part number 25-00-00-02 25-01-00 25-02-00 50-03-00 25-02-01 25-00-01 25-00-02 25-01-02 25-01-01 25-04-01 50-03-01 50-03-02 10x45 10 M10 45

Q-ty 1 1 1 1 1 1 1 2 1 1 1 1 2 4 4

76

Name Gear-type oil pump (1-11) Bottom cover (4,5) Top cover (1, 4) Driven gear (7, 8) Top cover Housing Drive gear Split bushing Bottom cover Axis Driven gear Bushing Pin Washer Bolt

Fig. 17.16. Filter

77

Group 17. Gear box (GB) Subgroup 1716. Filter Fig.No

Pos.No

17.16

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Assembly unit or part number 80-1716010 80-1716040 80-1716030 M5 80-1716033 80-1716032 80-1716034 80-1716031 059-065-36-2-4 80-1716024 80-1716080 80-1716050 80-1716041 15.081-100 80-1716060 022-025-19-1-4 80-1716016 80-1716020 10 10 30 80-1716018 066-071-30-1-4 80-1716015

Q-ty

Name

1 1 1 1 1 1 1 1 1 2 45 1 1 1 1 1 1 1 3 3 1 1 1

Filter (1-13, 15, 18-20) Filter pipe (9-12) Filter (1-5, 8-12) Nut Joke Washer Spring Piston Ring Ring Filter element Pipe Spring Ball Housing Ring Gasket Housing Washer Bolt Spring Ring Cover

78

Fig. 17.17. Distribution filter

79

Group 17. Gear box (GB) Subgroup 1737. Distribution filter Fig.No

Pos.No

17.17

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41

*

Assembly unit or part number

Q-ty

80-1737110

1

80-1028020 240-1 404030-A 80-1028080 240-1404140 240-1404017115-120-30-2-1 240-1404088 240-1404027 M12x1,25 37 -1407607240-1404033 240-1 404035-A 240-1404023 240-1404113 240-1404024 240-1404110 240-1404049 M10 70 10 50-1404075 1221-1737126 5 M8 30 8 1221-2401005 16-25 14x23-16 14 23-16 80-1737111 1 /8” 6h11x45 70-4801045 80-1737117 1221-1737114 80-1737113 80-1737118 80-1737112 50-1404059- 1 240-1404013240-140401214 240-14040192401404028 80-1028090240-1404118 017-022-30-1-4

1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 4 4 3 6 *

2 2 1 2 1 1 1 4 1 1 3 3 1 1 1 1 1 1 3 1 1 1 1 1

Upon demand

80

Name Distribution filter (1-13, 16-18, 24-31, 33-40) Rotor with axis (1, 2, 5-13, 34-40) Rotor sleeve (7-9) Rotor axis (34, 35, 37-40) Filter net (10, 12) Rotor housing Ring Cap nut Filter cap Nut Thrust washer Thrust ring Special nut Rotor sleeve Cover Rotor impeller Filter net Inner sleeve Bolt Washer Valve plug Washer Washer Bolt Washer Tube Clamp Hose L=750 (with hydraulic hoist) Hose L=960 (with draft control unit) Housing Plug Pin Spring Valve Plug Spring Spring Gasket Cap gasket Pipe Rotor axis Screw Housing cover Pin Nozzle Ring Ring

Fig. 18.1. Drive of front driving axle

81

Group 18. Drive of front driving axle Subgroup 1802. Drive of front driving axle Fig.No

Pos.No

18.1

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38

*

Assembly unit or part number 1221-1802030 1221-1802040 1221-18020651221-1802070 1221-1802023 1221-1802019 80-1701397 86-18020246-50306 86-1802043 206 1221-1802041 135 86-1802034 * 86-1802032 1221-1802032* 48 86-1802039 86-1802048 1221-1802031 86-1802047 1221-1802036 86-18020831221-1802333 86-1802038 86-1802046 86-18020351221-1802044 C62 86-1802049 1221-1802025 86-1802028 8020-1802026 1221-180201386-1802027 86-1802051 207 86-1802052 52-2308097 86-1802014.8 40.65 1,6-086-18020171221-1802042

Q-ty

Name

1 1 1 1 1 1 1 1 1 1 2 1 1 1 3-4 3-4 1 2 2 1 1 1 2 1 1 1 7 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1

Friction (1221-1802040, 8-22, 25) Gear(6, 7, 23, 24) Shaft (28, 30-36) Shaft (37, 38) Nut Washer Ring Bushing Bearing Bushing Bearing GOST 8338-75 Gear Ring GOST 13941-86 Thrust disk Driven disk S=1,8 mm Driven disk S=2 mm Ring GOST 13940-86 Guide Spring Piston Ring Drum Ring Ring Spring Sleeve Drive disk Bushing Ring GOST 13943-86 Ring Cage Bushing Half coupling Shaft Spring Washer Bearing GOST 8338-75 Washer Nut Bushing Pin GOST 14229-93 Wire L=140 mm Ring Shaft

Selection

82

Fig. 18.1. Drive of front driving axle

83

Group 18. Drive of front driving axle Subgroup 1802. Drive of front driving axle Fig.No

Pos.No

18.1

39 40 41

Assembly unit or part number 12-20/9 C6W 1221-180206085-3407470 RH 06101-012/00GA-AMP or

Q-ty

Name

1 1 1

Clamp «NORMA» Pipe line Union body Hydraulic distributor valve TU 213.201.01198

1

Hydraulic distributor valve TU RB 400051624.093-2004 Thread plug Bolt Washer OST 37.001.115-75 Pipe line Screw GOST 17473-80 Guide Gasket Switch Bolt Plug TU 23.1.506-91 O-ring Ring GOST 18829-73/GOST 9833-73 Lifter Cover Ring GOST 18829-73/GOST 9833-73 Bushing Elbow Pipe line

42 1 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

*

-6 /3.574

12.01

1221-1802091 18-051 1221-1802050 50-6g 50.58.019 8020-1802018 * 50-1702048 12-51 1520-1802088 1/8". 12.019 18-055019-022-19-2-2 8020-1802029 1221-1802016 011-016-30-2-4 1221-1802054 86-1802088 86-1802055

3 1 8 1 8 1 6 (max) 1 1 1 7 1 1 1 2 1 1 1

Selection

84

Fig. 22.1. Cardan drive

85

Group 22. Cardan drive Subgroup 2203. Cardan drive Fig.No

Pos.No

22.1 1 2 3 4 5 6 7 8 9 10 11 12

Assembly unit or part number 112-2203010 72-2203025PH 72-2203023 52-2203012 72-2203030-01 3102-2201037 34-2201043 69-2201 031-A 704702K3C10 72-2203022 112-2203018 86-2203047 20-2201024 M10 1-8

Q-ty 1 2 1 4 1 4 4 4 4 2 1 1 1 4

86

Name Cardan shaft (1, 3-10) Cross bar with bearings (3, 4, 6, 7) Flange Bolt Cross bar Deflector Lock ring Collar Bearing Yoke Pipe Slip yoke Gasket Hexagon nut DIN 985

Fig. 22.2 Guard

87

Group 22. Cardan drive Subgroup 2210. Guard Fig.No Pos.No Assembly unit or part number 22.2 1 2 3 4 5 6 7

Q-ty 8 8 8 1 1 1 1 2

52-2210012-A 52-2210015 1025-2210013 1025-2210015

8 9 10

2 1

1025-2210010

88

Name Bolt 8-6g 20.88.35.019 GOST 779670 Washer 8 OST 37.001.115-75 Washer 8.01.019 GOST 11371-78 Housing Bracket Housing Bracket Bolt 16-6g 50.88.35.019 GOST 779670 Washer 16 OST 37.001.115-75 Bracket

Fig. 23.1. Front driving axle

89

Group 23. Front driving axle Subgroup 2300, 2301. Front driving axle Fig.No 23.1

Pos.No

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40

Assembly unit or part number

Q-ty

Name

1222-2300020

1

1222-2300020-05

1

52-2302010 52-2303010- -01 822-2308005-02* 822-2308005-06** 822-2308005-03* 822-2308005-07** 1420-2301055 822-2301051-01 263212 52-2302019 52-2302038- 1 «MINTOR»TSS0G-1/8" 1.3. 9.

1420-2301054-01 40-3001022 1222-3000012 01-015 52-2303027

1 1

Front driving axle assembly (for 3 U=23,429) Front driving axle assembly (for 3 U=27,336) Gear (see Fig. 23.2) Differential (see Fig. 23.3)

1

Left wheel-hub drive (see Fig.23.4)

1

Right wheel-hub drive (see Fig.23.4)

1 1 2 1 1 1 1 1 2 1 8 16(m ax) 16(m ax) 2 1 36 14 4 4 2 2 2 2 2 2 2 6(max ) 10(m ax) 4 3 1 16 4 2 6 6 6 1 1 8(max ) 20(m ax)

Housing (8,9) Left hose Bearing TU RB 00234873.002-97 Gear Nut Breather Oiler GOST 19853-74 Housing Bushing Axis pin Adjusting pin Shim =0,5 mm

52-2303028 150-156-36-1-4 822-2301053-01 16 16-6g 45.88.35.019 1520-2308039 1027307 (31307) 822-2308100 1.2-38 58-1 2.2-38 58-1 075-080-30-1-4 1520-2308009 85-3407113 3/8" 52-2302021 52-2302022 055-063-46-1-4 1520-2308037 1520-2308037-01 16-6g 40.88.35.019 85-4607447 822-2308065-01 16-6 .6.019 1520-2308077 1520-2308079 1222-23010211222-23010221520-2308042 1520-2308042-01

*

For FDA 1222-2300020 For FDA 1222-2300020-05

**

90

with with

Shim =0,2 mm Ring GOST 18829-73/GOST9833-73 Right hose Washer OST 37.001.115-75 GOST 7796-70 Sleeve Bearing GOST 27365-87 Cage Collar GOST 8752-79/OST 3805146-78 Collar GOST 8752-79/OST 3805146-78 Ring GOST 18829-73/GOST 9833-73 Screw Nut Plug Shim =0,5 mm Shim =0,2 mm Ring GOST 18829-73/GOST 9833-73 Axis Axis Bolt GOST 7796-70 Cap Shaft Nut GOST 5915-70 Bushing Stud Right bracket Left bracket Shim =0,2 mm Shim =0,5 mm

Fig. 23.1. Front driving axle

91

Group 23. Front driving axle Subgroup 2300, 2301. Front driving axle Fig.No

Pos.No

23.1

41 42 43 44 45 46

Assembly unit or part number 089-095-36-1-4 12 12 -6g 35.88.019 72-2308018 72-2308031 3/4"

Q-ty 1 8 6 2 1 2

92

Name Ring GOST 18829-73/GOST 9833-73 Washer OST 37.001.115-75 Bolt GOST 7796-70 Bolt Washer Plug

Fig. 23.2 Gear

93

Group 23. Front driving axle Subgroup 2302. Gear Fig.No

Pos.No

23.2

1 2 3

4

5 6 7 8 9 10 11 12

*

Assembly unit or part number 52-2302010-

Q-ty 1

Name

52-2302030

1

52-23020157607 or 6-7607 52-230201652-2302026 52-2302026-01 52-2302026-02 52-2302026-03 52-2302026-04 52-2302026-05 52-2302026-06 52-2302026-07 52-2302026-08 7506 52-2302018 2.2-38 62-1/4 82-2302031 52-180207852-1802079 70-3003032 25.019

1

Gear set (1-12, 3 (Fig. 23.1)) Driven and drive gear assembly (1,3 (Fig. 23.1)) Drive gear

1

Bearing GOST 27365-87

1 * 2 2* 2* 2* 2* 2* 2* 2* 2* 1 1 2 1 1 1 1 1

Sleeve Adjusting washer =2,65 mm ( ) Adjusting washer =2,70 mm ( ) Adjusting washer =2,75 mm ( ) Adjusting washer =2,90 mm ( ) Adjusting washer =3,05 mm ( ) Adjusting washer =3,20 mm ( ) Adjusting washer =3,30 mm ( ) Adjusting washer =3,35 mm ( ) Adjusting washer =3,40 mm ( ) Bearing GOST 27365-87 Ring Collar GOST 8752-79/ OST 3805146-78 Blind plug Flange Washer Nut Forelock GOST 397-79

Selected at the bearing regulation

94

Fig. 23.3 Differential Group 23. Front driving axle Subgroup 2302. Gear 95

Fig.No

Pos.No

23.3 1 2 3 4 5 6 7 8 9 10 11 12 13 14

Assembly unit or part number 52-230301052-0203030 52-230301452-230301552-2303018 52-2303019 52-2303017 52-2303034 35-10 9.

52-2303021 52-2303023- 1-01 52-2303024-01 52-2303023- 1 52-2303032 52-2303013 52-2303026-

Q-ty 1 2 1 1 4 2 2 2 2 2 2 2 2 4 8 8

96

Name Differential (1-14) Gear(5-7) Box Box Satellite gear Axis Gear Gasket Blind plug GOST 3111-81 Cup Disk Disk Disk Plate Nut Bolt

Fig. 23.4 Wheel-hub drive.

97

Group 23. Front driving axle Subgroup 2308. Wheel-hub drive.

Fig.No

Pos.No

23.4

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 27 28 29 30 31 32 33 34 35

Assembly unit or part number ** 822-2308005-06 * 822-2308005-02 822-2308005-07** 822-2308005-03* 1520-2308024-20 1520-2308040-05** 1520-2308040* 1520-2308080 1521-2308020 1521-2308030 1521-2308050-05** 1521-2308050* 100 45 53609 1520-2308038 1520-2308062-05** 1520-2308062* 1520-2308053 1520-2308054 34,8 3 1520-2308059 1521-2308056 1520-2308011 2.8 25 1520-2308064 1521-2308016 10-6g 35.88.019 16 7514 2.2-100 125-1 1521-2308017 40-3103016 16-6 .6.019 16 1520-2308077 1520-2308074 1520-2308074-01 1520-2308079 1520-2308015 1520-2308034 «MINTOR» TSS0G-1/8" 1222-2308076 1222-2308077 1521-2308012 1521-2308031 1521-2308013 2007109 1520-2308061-05** 1520-2308061*

Q-ty

Name

1

Wheel-hub drive (1-60)

1

Wheel-hub drive (1-60)

2

Double hinge (43-50)

2

Housing (27, 29, 31-50)

2 2 2

Sleeve (36, 37 40) Cover (12-14) Pinion cage (6-11)

2

Hub (1-20)

2 2 2 2

Ring GOST 13941-86 Ring GOST 13940-86 Bearing GOST 24696-81 Ring Gear set Z=40 Gear set Z=44 Axis Washer Roller GOST 6870-81 Satellite gear Pinion cage Screw Pin GOST 3128-70 Gear Cover Bolt GOST 7796-70 Washer OST 37.001.115-75 Bearing GOST 27365-87 Collar GOST 8752-79/OST3805146-78 Flange Front wheel bolt Nut GOST 5915-70 Washer OST 37.001.115-75 Bushing Left lever Right lever Stud Housing Gasket Breather Right bracket Left bracket Bolt Locking plate Washer Bearing GOST 27365-87 GearZ=14 GearZ=17

2 6 12 156 6 2 6 6 2 2 20 20 2 2 2 16 16 16 12 1 1 16 2 2 2 1 1 2 2 2 4 2

**

For FDA 1222-2300020-05 For FDA 1222-2300020

*

98

Fig. 23.4 Wheel-hub drive.

Group 23. Front driving axle Subgroup 2308. Wheel-hub drive.

99

Fig.No

Pos.No

23.4

36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

Assembly unit or part number 2.2-45 65-1 100-105-30-2-4 1520-2308021 1520-2308021-01 1520-2308035 8-6g 30.88.35.019 032-036-25-2-4 1520-2308063-10 72-2203026-11 1520-2308066-01 704702 10 34-2201043-01 34-2201043-10 34-2201043-20 34-2201043-30 32-10 9.

1520-2308048 8-6g 25.88.35.019 1520-2308004 1520-2308003 80-1701045 80-1701056 7509 1520-2308002 095-100-30-1-4 3/8" 3/4"

Q-ty 2 2 20(max) 8(max) 2 8 16 2 2 4 2 16 16(max) 16(max) 16(max) 16(max) 2 2 8 2 2 2 2 2 2 2 2 2

100

Name Collar GOST 8752-79/OST 3805146-78 Ring GOST 18829-73/GOST 9833-73 Shim Shim Sleeve Bolt GOST 7796-70 Washer OST 37.001.115-75 Ring GOST 18829-73/GOST 9833-73 Yoke Cross bar Double yoke Bearing Lock ring Lock ring Lock ring Lock ring Blind plug GOST3111-81 Yoke Bolt GOST 7796-70 Cover Gasket Nut Washer Bearing GOST 27365-87 Sleeve Ring GOST 18829-73/GOST 9833-73 Plug Plug

Fig. 24.1 Rear axle. Differential. Final drives.

101

Fig. 24.1 . Rear axle. Differential. Final drives.

102

Group 24. Rear axle Subgroup 2401, 2403, 2407. Rear axle. Differential.

Final drives Fig.No 24.1 24.1

Pos.No

Assembly unit or part number

Q-ty

1221-2401010-05

1

1221 -2401010-05

1

1221-2401010-07

1

1221 -2401010-07 1221-2401015-05

1

1522-2403010-

1

1522-2403015-02

1

1221-2407060-02

1

1221 -2407060

1

1521-2407060

1

1523 -2407060-02

1

1221-2407060-03

1

1221 -2401060-01

1

1521-2407060-01

1

1523 -2407060-03

1

1221-2407540

2

1221-2407500

1

1221-2407500-02

1

1221-2407500-01

1

1221-2407500-03

1

1221-2407035- 1 1221-2407030 1221-2407130

2 2 2

103

Name Rear axle (With hydraulic hoist; z=27, Z=54; dry brakes) Rear axle (With hydraulic hoist; z=27, Z=54; wet brakes) Rear axle (With hydraulic hoist; z=24, Z=56; dry brakes) Rear axle (With hydraulic hoist; z=24, Z=56; wet brakes) Rear axle housing (25, 65, 66, 910) (With hydraulic hoist) Differential (2, 12, 14, 16, 17, 22, 78, 80-85) Differential housing (15, 79) Left sleeve (13, 20, 21, 68-71, 74-77) (z=27, Z=54; dry brakes) Left sleeve (13, 20, 74, 75, 77, 89) (z=27, Z=54; wet brakes) Left sleeve (13, 14, 20, 21, 74-77) (z=24, Z=56; dry brakes) Left sleeve (13, 74, 75, 77, 89) (z=24, Z=56; wet brakes) Right sleeve (13, 19-21, 68-71, 74-76) (z=27, Z=54; dry brakes) Right sleeve (13, 19-21, 74,75) (z=27, Z=54; wet brakes) Right sleeve (13, 19-21, 68-71, 74-76) (z=24, Z=56; dry brakes) Right sleeve (13, 19-20, 74, 75) (z=24, Z=56; wet brakes) Drive gear (57-59, 61) Left final drive (23, 26, 27, 29, 32, 33, 36, 37, 39, 41, 43-46, 52, 54-56) (dry brakes) Left final drive (23, 26, 27, 29, 32, 33, 36, 37, 39, 41, 43-46, 52, 54-56) (wet brakes) Right final drive (23, 24, 26, 27, 33, 36, 37, 39, 41, 43-46, 52, 54-56) (dry brakes) Right final drive (23, 24, 26, 27, 33, 36, 37, 39, 41, 43-46, 52, 54-56) (wet brakes) Pinion cage (42, 47-51, 53) Cover (38, 40) Sleeve (30, 60)

Group 24. Rear axle Subgroup 2401, 2403, 2407. Rear axle. Differential.

Final drives Fig.No

Pos.No

24.1 24.1

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

21

22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39

Assembly unit or part number 1221-2401028 12 12 35

Q-ty

Name

1 24

Gasket Washer Bolt (dry brakes) Bolt (wet brakes) Washer Bolt Bolt Washer Cover Gasket Cover Gasket Tight-fitting bolt 12 42 Ring Bearing Housing Driven gear Thrust washer Pin Shaft (dry brakes) Shaft (wet brakes) Gear (z=27, Z=54) Gear (z=24, Z=56) Bearing sleeve (dry brakes) Right bearing sleeve (wet brakes) Left bearing sleeve (wet brakes) Locking plate Semi-axle Right semi-axle tube (dry brakes) Right semi-axle tube (wet brakes)

24

80 -2407041 8 25 600-2401026 20 1221-2401026 50-24010271221-2401024 1221.1-2401025 50-1702092 1221-2407043 7216 1522-2403018-02 50-24030211220-2403049 01-015 1521-2407053-01 1221 -2407053-01 1221-2407052 1522-2407052 1221-2407042

14 7 4 2 4 1 1 1 1 12 2 2 1 1 2 2 1 1 2 2 2

1221 -2407042-01

1

1221 -2407042

1

50-2403023 1221-2407082 1221-2407018- -01 1221 -2407018-01

6 2 1 1

1221-2401016 10 25 10 70-1701300 1221-2407508-01 217 1221-2407552 1221-24070181221 -2407018 1 /8” 16 16 60 142-2407091 7218 2.2-90 120-1 1221-2407089

1 8 8 1 4 4 2 1 2 22 22 2 2 2 2

104

Housing Bolt Washer Magnetic plug 11/4 Pin Bearing Gasket Left semi-axle tube (dry brakes) Left semi-axle tube (wet brakes) Plug Washer Bolt Ring Bearing Collar Gasket

Group 24. Rear axle Subgroup 2401, 2403, 2407. Rear axle. Differential.

Final drives Fig.No

Pos.No

24.1 24.1

40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 79 80 81 82 83 84

Assembly unit or part number 1221-2407028 1221-24075031221-24075367217 1221-24075025336-24050501221-2407512 1221-2407504 54.38.619 1221-2407538 27, 8 3 1221-2407539 5336-24050351221-24075561221-2407506 1221-2407506-01 .8 45.65 1221-2407537 1221-2407507 70-4605036 55 5336-24050281221-2407542 1221-2407131 1221-2407541 1221-2407123 1221-2407122 1522-2407122 80-2401016 50-4605027 36-350203750-1601352 80 -2407039 125 115-120-30-1-4 2.2-52 75-1 1221-2407081 1221-2407056 1221-2407057 205-210-36-1-4 311 035-040-30-1-4 1521-2407053 1221 -2407053 1522-2403019-02 1522-2403048 1522-24030621522-240305729,8 3 1522-2403025-

Q-ty

Name

2 4 2 2 2 2 4 8 4 16 368 8 8 8 12 12 8 2 2 2 2 2 2 2 2 2 2 2 2 1 2 4 4 2 2 2 2 1-8 1-20 2 4 4 1 1 1 2 1 4 100 4

Cover Plate Pinion cage Bearing Epicycle hub Driven gear Pin Plate Ring Satellite gear washer Roller Distance washer Satellite gear Satellite gear axis Gasket 0,5 mm Gasket 0,2 mm Pin Washer Washer Bolt Ring Drive gear Bushing Sleeve Shaft Bushing Driven gear (z=27, Z=54) Driven gear (z=24, Z=56) Gasket Pin Bushing Pin (dry brakes) Pin (wet brakes) Ring (dry brakes) Ring (dry brakes) Collar (dry brakes) Cage (dry brakes) Gasket 0,5 mm Gasket 0,2 mm Ring Bearing Ring (dry brakes) Shaft (dry brakes) Shaft (wet brakes) Cover Semi-axle gear Cross bar Satellite gear Roller Satellite gear washer

105

Group 24. Rear axle Subgroup 2401, 2403, 2407. Rear axle. Differential. Final drives (wet brakes) Fig.No

Pos.No

24.1 24.1

85 86 87 88 89 90 91 92 93 94 96 102 103 104 106 107 108 109

Assembly unit or part number 12 50-4216024 2.2-25 42-1 1221-2407505 36-1702110 1,613.11.000-02 85-240108085-2401050 020-025-30-1-4 50-2401031 50-2401020 74-2401050 1221-2401019 1221-2400030 30 017-022-30-1-4 55

Q-ty

Name

12 1 2 24 2 2 1 1 1 1 1 1 1 1 1 2 1 1

Nut Bushing Collar Bolt Screw Wire (200 mm) Handle Lever Rack Ring Washer Shifter arm Lever Shaft Tube Bolt Ring Bolt

106

Fig. 24.2. Final drive (lubrication)

107

Group 24. Rear axle Subgroup 2401. Final drive (lubrication) Fig.No

Pos.No

24.2

1 2 3 4 5 6 7 8 9 10 11

Assembly unit or part number 86-1802088 1522-2407330 1522-2407317 70-4802046 1522-2407310 80-1737110 10 10 20 70-4802043 1221-2407288-02 1522-2407320

Q-ty 2 1 3 2 1 1 1 1 1 1 1

108

Name Elbow Oil pipeline Pipe Clamp Oil pipeline Filter Washer Bolt Clinch rivet Three-way pipe Oil pipeline

Fig. 24.3. Differential locking mechanism

Group 24. Rear axle 109

Subgroup 2409. Differential locking mechanism Fig.No

Pos.No

24.3

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

*

Assembly unit or part number * 70-240901070-2409010- -01 82P-2409050 70-2409015-A 70-3502040-01 or 70-3502040-04 70-2409028 70-2409020 * 70-2409020-01 70-2409018 70-2409021 70-24090308 M8 40 70-2409035-A6 12 M12x200* 1522-2409034 70-2409037 40 82P-2409036A 70-2409026020-025-30-1-4 54-06-448-A 70-2409027-A 70-2409033-

Q-ty

Name

1

Lockup clutch (1-9)

1 1

Adapter (10, 13-20) Clutch housing Brake disk

2 2

Release disk

1

Lock shaft

1 1 1 8 8 1 5

Pressure disk Diaphragm Diaphragm cover Washer Bolt Housing Washer

5

Bolt

1 1 1 1 1 1 1 1

Union body Ring Seal Adapter O-ring Spring Bushing Ring

If double-disk brakes are installed

110

Fig. 24.4. Wet-type differential locking mechanism

Group 24. Rear axle 111

Subgroup 2409. Wet-type differential locking mechanism Fig.No

Pos.No

24.4

1 2

3

4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28

*

Assembly unit or part number

Q-ty

80 -2409010

1

1221 -2409050 80 -2409002 50-170214880 -2409028 80 -2409028-01 80 -2409028-02 80 -2409028-03 80 -2409028-04 80 -2409028-05 80 -2409028-06 1221 -3502039 14 1221 -2409034 70-240903070-2409021 10 6 80 -2409037 80 -2409036 70-240903370-240902754-06-44870-2409026020-025-30-1-4 70-2409037 32-50/9 6W 70-2409020-02 80 -2409018 205-215-58-2-2 1221 -2409051 40 8 80 -2409016 2522-180203580 -2409015 80 -2409001

1 4 4 1 *

* * * * * 5 5 1 1 1 8 8 1 1 1 1 1 1 1 1 1 1 1 1 1 8 8 5 6 1 1

Selected during the installation for required gap.

112

Name Lockup coupling (1-3, 6, 7, 19, 20, 23-28) Adapter (5,8-18,21) Pin Spring Release disk (S=4,7 mm) Release disk (S=4,4 mm) Release disk (S=4,1 mm) Release disk (S=3,8 mm) Release disk (S=3,5 mm) Release disk (S=3,2 mm) Release disk (S=3,0 mm) Bolt Washer Cover Diaphragm cover Diaphragm Screw Washer Ring Seal Ring Bushing Spring Adapter Ring Union body Clamp «NORMA» Lock shaft Pressure disk Ring Gasket Bolt Washer Intermediate disk Drive disk Clutch housing Hub

Fig. 27.1. Drawbar hitch

Group 27. Drawbar hitch 113

Subgroup 2707. Drawbar hitch Fig.No

Pos.No

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38

Assembly unit or part number 1322-2707210 1321-2707014 1222-2707137 1321-27070111321-2707030 16 1220-4605506 18 6 6 6 921-2707068-02 20 20 1321-2707083921-2707068 12 921-2707068-03 1322-2707274 1322-2707211 1322-2707280 .6 30 61.05.005 61.05.004 1522-2707244 6,3 63 1321-2707070- -01 16 16 1522-2707243 1522-2707242 1522-2707079921-2707055 61.07.0011321-270705120 680-2707024 1321-27070701322-2707261

39

900-2707135

40

900-2707135-01

41

900-2707135-02

42 43 44 45

1322-2707261-01 1322-2707262-01 16 1322-2707262

27.1

Q-ty

Name

1 4 2 1 1 4 4 1 1 9 1 2 6 6 2 2 4 2 1 1 1 1 1 1 1 1 1 2 4 1 1 1 1 1 1 8 8 1 1 2 (maxi mum) 2 (maxi mum) 2 (maxi mum) 1 1 4 1

Drawbar hitch Bolt Plate Plate Pin Washer Bolt Bolt Washer Washer Nut Stud Nut Washer Joke Stud Bolt Stud Stabilizer Bushing Shield assembly Pin Chock Ring Stabilizer Forelock Plate Washer Nut Nut Washer Kingpin Yoke Forelock Bracket Washer Bolt Plate Side member

114

Plate

Plate

Plate Side member Bracket Bolt Bracket

Fig. 27.2. Drawbar hitch (configuration variants) Group 27. Drawbar hitch Subgroup 2707. Drawbar hitch (configuration variants) 115

Fig.No

Pos.No

27.2 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

Assembly unit or part number 1321-2707150- 1 1322-2707160 1322-27071301322-2707133 1322-2707120- 1 20 10 10 1522-2707126 1522-2707127 20 1523-2707146 1523-270714961.07.00150-4202146 1523-2707143 3,2 25 1522-27070791523-2707142 70-4235035 16 16 1321-2707144- 1 1321-27071401321-27070342 61.05.004 61.05.005 1321-2707030 1321-27071131322-2707165 1322-2707162-01 1322-2707180 1322-2707161 61.07.001 36

Q-ty 1 1 1 4 1 4 2 2 1 1 4 2 2 1 1 1 1 1 1 2 2 2 1 1 1 1 1 1 1 1 1 1 1 1 1

116

Name Rod (11-19, 25) Python (40-44, 46) Cross bar Bolt Joke Nut Bolt Washer Plate Axis Washer Washer Bolt Forelock Ring Lining Forelock Kingpin Joke Chain Nut Washer Rod Kingpin Forelock Ring Chock Pin Yoke Plate with python Pin Pin Thrust Forelock Forelock

Fig. 28.1 Semi-frame assembly

117

Group 28. Frame Subgroup 2801. Semi-frame assembly Fig.No

Pos.No

28.1 1 2 3 5 6 7 8 9 10 11 12 13 14 15 16 17

Assembly unit or part number 1520-2801015 M20 20 40-3001022 1520-2801016 1523-2801030 M16 70 16 M16 60 M16 70-2800016 1523-2801020 50-3913214 80-3919106 M16 32 M16 50 50-2800011

Q-ty

Name

1 2 2 2 1 1 2 24 4 2 4 1 2 2 10 4 4

Front beam (3, 5) Nut Washer Bushing Front beam Right spar Bolt Washer Bolt Nut Bolt Left spar Clamp Bracket Bolt Bolt Bushing

118

Fig. 30.1. Steering links

119

Group 30. Front axis Subgroup 3003. Steering links Fig.No

Pos.No

30.1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

Assembly unit or part number 822-3003010-01 822-3003020 822-3003020-01 1220-3003013-01 1220-3003011 1220-303013 822-3003022 822-3003022-01 2,0- -C 50-30030181220-3003028 1220-3003027 1220-3003021 1220-3003023 1220-3003024 1220-30030251220-3003029 M20x1,5 4x36

Q-ty 1 1 1 1 1 1 1 1 2 2 2 2 2 2 2 2 2 2 2

120

Name Steering link (1-16) Right hinge (822-3003022, 6-16) Left hinge (822-3003022-01, 6-16) Lock nut Pipe Lock nut Right hinge housing Left hinge housing Wire L=270 mm Plug Insert Insert Ball pin Insert Ring Case Ring Nut Forelock

Fig. 31.1 Front driving wheels

121

Group 31. Wheels and hubs Subgroup 3101. Front driving wheels Fig.No

Pos.No

31.1

1 2 3 4 5 6 7

Assembly unit or part number 1221-3101010-01 1221-3101010 W12-24-3101020-01 or 880.3101012-01 W12-24-3101035 W12-24-3101017 52-2301065 1221-3101011 1221-3101013 or 16 1.5-6 .10.019 40-3103017-01

Q-ty

Name

2

Wheel (tyre 420/70R24 assembly) (1-6) or Wheel (tyre 14.9R24 assembly) (1-6)

2

Wheel W12 24 (1, 2, 3, 4, 5)

2 2 12 12

Rim W12 24 with brackets Disk Washer Bolt Nut Nut GOST 5915-70 Tyre 420/70R24 or 14.9R24 Nut

12 2 16

122

Fig. 31.2 Rear driving wheels. Rear wheel hubs

123

Group 31. Wheels and hubs Subgroup 3104.Rear wheel hubs Subgroup 3107. Rear driving wheels Fig.No

Pos.No

31.2 1 2 3 4 5 6 7 8

Assembly unit or part number 1220-3104010 1220-3104012 1220-3104011 40-3104021 1220-3104012-01 20 70-4605036 70-3104019 * 1221-3107010 DW15L 38-3107020 or 8746.3107012 3

9 **

8 9 10

*

72-3107010 DW15L 38-3107020 or 8746.3107012 3 36-3104019

Q-ty

Name

2 1 1 8 1 6 6 2 2

Hub (1-7, 10) Insert Hub Bolt Insert Washer Bolt Special nut Wheel 18.4R38 (tyre assembly) (8, 9)

2

Wheel DW15L 38

2 2

Tyre 18.4R38 Wheel 16.9R38 (tyre assembly) (8, 9)

2

Wheel DW15L 38

2 7

Tyre 16.9R38 Nut

For tractors with FDA 1222-2300020-05 For tractors with FDA 1222-2300020

**

124

Fig. 34.1. Steering column

125

Group 34. Steering control Subgroup 3401. Steering column Fig.No

Pos.No

34.1

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48

Assembly unit or part number

Q-ty

Name

85-3401010

1

70-340105085-3401150 85-3401120 85-3401016 20 80-3401019 85-340115619 904700 17 50-3401064 50-3401063 M10 80-3401013 50-3401061-A M10 45 5x10 70-3401055 70-340105436 70-340107770-3401076 70-3401078 70-3401079 80-3401082 80-3401140 M16x1,5 50-3401091 80-3402015 80-3709025 80-3709026 80-3709024 50-4608057 85-3401175 600-3401012 70-3003032 8x28 600-3401160 50-3401062 85-3401067 70-3709012-A 4x25 85-3401011 85-3401001 50-13101581,6x12 18 85-3401014 38RPN-02.00.00/B or 822-3401140- 1 16 38RPN-01.00.00 or 70-3402015-

1 1 1 1 1 1 1 8 8 8 8 1 2 1 1 1 1 1 1 2 2 1 1 1 1 1 1 1 1 1 1 1 1 1 2 2 1 2 1 1 2 2 1 1 1 1 1 1

Steering column (1-21, 32-37, 39, 40, 42- 45) Shaft (15-17) Cardan (5-9, 12, 36, 37) Bracket Bushing Ring Washer Yoke Ring Bearing Oil-seal Cage Nut Washer Yoke Bolt Semi-circular key Intermediate shaft Shaft end extension Pin Shock absorber Bushing Nut Lock nut Cover Clamp Nut Washer Steering wheel Bushing Bushing Case Spring Shaft Washer Nut Non-threaded fastener Quadrant Cross bar Yoke Handle Forelock Screw Rod Spring Forelock Ring Detent Clamp

1 1

Washer Steering wheel

126

Fig. 34.2 Hydrostatic steering control

127

Group 34. Steering control Subgroup 3407. Hydrostatic steering control Fig.No

Pos.No

34.2 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

19

20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45

Assembly unit or part number 1221-340001085-3407107 1221-3407030 1221B-3407050 1221B-3407040 80B-3407012 8 M8 5000.04 70-3407164 M8 20 70-3506027 70-3407163 1221-3407200 5000.03 85-3407332-02 85-3407105-02 1221-3407090 80-3407157 or 1/2 OSPC160 N150G0030 or LAGC 160-10/200140M01-100 or SUB 160-140.200-1 80-3407134 1221-3407130 680-4607140-11 1221-3407140 40-4607033-A – 01 or 24 H.036.12.010 1321-3407018-01 1221-3407020 70-3407146 M8 30 M10 25 10 102-3407014 70-4607158 M8 40 017-022-30-1-4 M8x35 50-3405215 80-3407114 or 3/8 952-3407020 80-3407201 952-3407100-12 1221-34070101.1. 6.

M20x1,5 80-3405103

Q-ty

Name

1 1 1 1 1 1 7 1 2 1 1 5 1 1 2 1 1 1

Hydrostatic steering control Plate Oil pipeline Oil pipeline Oil pipeline Bracket Washer Nut Clamp with worm thread 25-40 Bracket Bolt Bushing Joke Hydraulic tank Clamp with worm thread 20-32 Hose Bolt Oil pipeline

5

Washer

1

Dosing pump

3 1 2 1

Union body Oil pipeline High pressure hose Valve

2

Washer

2 1 1 3 3 1 1 1 2 2 2 2 2

Blind plug Hose Oil pipeline Plate Bolt Bolt Washer Joke Gasket Bolt Ring Bolt Hydraulic cylinder

8

Washer

2 4 4 1 4 4 4

Adapter Bolt High pressure hose Three-way pipe Oiler Nut Lock washer

128

46

C20

4

Fig. 34.2 Hydrostatic steering control 129

Washer

Group 34. Steering control Subgroup 3407. Hydrostatic steering control Fig.No 34.2

Pos.No 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64

Assembly unit or part number 80-340510280-3405107 80-3405109 80-3405108 4x36 70-4605316 102-3405103 1222-23010211222-23010221221-3407010- -01 1520-2308079 1520-2308077 16 16 1221-3407101 70-4607158-01 80-3405112 1222 -3407100-07

Q-ty 4 8 8 8 4 4 4 1 1 1 4 4 4 4 1 1 2 1

130

Name Bushing Spherical bushing Hinge seal Seal cup Forelock Nut Pin Bracket Bracket Three-way pipe Stud Conical plug Washer Nut Bracket Gasket Reducing sleeve High pressure hose Ø 12,5 2

Fig. 34.3 Hydraulic cylinder 50 25-200

131

Group 34 Steering control Subgroup 3405. Hydraulic cylinder 50x25-200 Fig.No Pos.No 34.3 1 2 3 4 5 6 7 8 9 10 11 12 13 4 15 16 17

*

Assembly unit or part number 50-340521550-3405220 -25 42 50-3405218045-050-30-1-4 50-340522350-3405222 * 24 251797 L43 50-34 -20,5 025-028-19-1-4 50-3405228 24 223269 T20 25-33-5,7* 24 004792 PU6 25-33,6-6,5* .M8x10 50-3405224 50-340522124 223123 OMS-MR 25-32,3-3* 24 226044 SB 25-28-5,5*

Q-ty 1 1 2 4 1 2 1 1 1 1 1 1 1 1 1 1 1 2

Name Hydraulic cylinder 50x25-200 (2-16) Cylinder housing Bearing Ring Front cover Ring Piston Piston nut Piston seal Ring Backing ring Push rod seal Push rod collar Screw Captive nut Push rod Push rod seal Push rod guide

Sealing elements produced by Freudenberg Company (Germany)

132

Fig. 34.4. Hydraulic tank

133

Group 34. Steering control Subgroup 3407. Hydraulic tank Fig.No

Pos.No

34.4 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Assembly unit or part number 1221-3407200 50-4608027017-021-25-2-2 1221-3407210 075-080-30-1-4 A61-C06-A3 240-3707200 220-4608060 80-4608024 601T-1-06 320-4608082 320-4608083 320-4608085 80-3405044 320-4608081 2x12 50-4608057 220-4608051-01 6 M6 25 M6 16

Q-ty 1 1 1 1 2 1 1 1 2 1 1 1 1 1 2 1 1 1 6 4 2

134

Name Hydraulic tank (1-2) Plug Ring Tank Ring Filter Plug Sleeve Ring Filtering element Stem Ball valve Valve housing Spring Thrust washer Forelock Spring Cover Washer Bolt Bolt

Fig. 35.1. Brakes. Brakes control

135

Group 35. Brakes Subgroup 3502, 3503. Brakes. Brakes control Fig.No

Pos.No

35.1

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37

Assembly unit or part number 85-3502010-01 85-3502030 70-3503080 80-3503080 80-3503090 1221-3502035 85-3502040-01 or 85-3502040-04 85-3502036 77.38.163 22,225-100 M8 85-3502196 3,2x18 50-3502203 12x32 50-3502198 12 2.2-25x42-1 50-3503071 M12x35 M12x1,25 -611 70-3503017-A 70-3503019 70-3503018 5x36 50-3503015 85-3503046 M10x25 10 70-3503045 50-1605152 85-3503110-A 85-3503120-A A13.34.001 80-3503140 80-3503130 A13.33.002 80-3503158-A M12x30 50-3502202 1,6x300

Q-ty

Name

2 2 2 1 1 2

Brake (1-11,36,37) Pressure disk (3-11) Brake rod (16,19, 20) Right pedal (32, 33) Left pedal (30, 31) Housing

4

Brake disk

4 6 10 4 4 2 2 2 4 4 2 3 2 2 2 1 2 2 2 1 1 2 2 2 2 1 1 1 1 1 1 2 2 2 2

Pressure disk Spring Ball Nut Rod Forelock Yoke Pin Pin Washer Collar Washer Bolt Nut Key Lever Bolt Washer Forelock Shaft Bracket Bolt Washer Extender Spring Lever Lever Lining Left pedal Right pedal Lining Seal Bolt Case Wire

136

Fig. 35.2. Brakes (version)

137

Group 35. Brakes Subgroup 3502. Brakes (version) Fig.No

Pos.No

35.2

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

Assembly unit or part number 1522-3502010 70-3503080 85-3502030 1522-3502035 85-3502040-01 or 85-3502040-04 85-3502036 77.38.163 50-3502198 85-3502196 50-3502203 12x32 M12x1,25 70-3503018 70-3503019 3,2x18 M8 22,225-100 1522-35020371,6 300 50-3502202

Q-ty

Name

2 2 2 2

Brake (1-8, 12-17) Brake rod (9-11) Pressure disk (3-8, 12-14) Housing

6

Disk

4 6 4 4 2 2 2 2 2 2 4 10 2 2 2

Pressure disk Spring Pin Rod Yoke Pin Nut Washer Bolt Forelock Nut Ball Disk Wire Case

138

Fig. 35.3. Wet brakes

139

Group 35. Brakes Subgroup 3502. Wet brakes Fig.No

Pos.No

35.3

1 2 3 4 5

6

7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25

*

Assembly unit or part number

Q-ty

1221 -3502010-02

1

1221 -3502020-02

1

85-3502030-01 1221 -2409035 8 50-3502198 85-3502196 1522-3502015-07 80 -3502037

2 1 4 4 4 16 12

80 -3502037-01 80 -3502037-02 80 -3502037-03 80 -3502037-04 80 -3502037-05 80 -3502037-06 80 -3502037-07 12 32 10 6 80 -3502202 50-3502203 80 -3502204 1221 -3502051 3,2 18 1221 -2407059 115-120-30-2-2 22,225-100 85-3502036-01 77.38.163 25 3 /8” 1221 -3502035 1221 -2407059-01 1221-1802091 18-055-

* * * * * * *

2 8 8 2 2 2 2 2 1 2 10 4 6 6 4 1 1 2 2

Selected during the installation for required gap.

140

Name Right brake (2-14, 16-20,22,23) Left brake (1-20) Pressure disks (2, 3, 4, 7, 11, 14, 17-19) Housing Nut Pin Rod Disk Intermediate disk (S=3,0 mm) 2 pieces selection Intermediate disk (S=3,2 mm) Intermediate disk (S=3,4 mm) Intermediate disk (S=3,6 mm) Intermediate disk (S=3,8 mm) Intermediate disk (S=4,0 mm) Intermediate disk (S=4,2 mm) Intermediate disk (S=4,4 mm) Pin Bolt Washer Case Yoke Plate Gasket Forelock Sleeve cover (left) Ring Ball Pressure disk Spring Screw Plug Housing Sleeve cover (right) Plug O-ring

Fig. 35.4. Wet brakes control Group 35. Brakes 141

Subgroup 3503. Wet brakes control Fig.No

Pos.No

35.4 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21

*

Assembly unit or part number 70-3503080 12 1,25-6 .04.019 70-3503018 70-3503019 85-3503046 70-3503045 50-1605152 80-350315812-6g 30.88.35.019 12 12-6g 35.88.35.019 70-35030171221 -3503016-01 -611 50-3503071 1221 -3503015 85-350312080-3503140 80-3503130 1221 -3503110 * 1221 -3503110-01 1221 -3503016 36.019

Q-ty

Name

3 2 2 2 1 2 2 2 2 4 2 1 2 2 4 1 1 1 1

Rod (1-3) Nut GOST 5916-70 Washer Bolt Bracket Extender Spring Seal Bolt GOST 7796-70 Washer OST 37.001.115-75 Bolt GOST 7796-70 Lever Bushing Key 6 11 Washer Shaft Lever Left pedal Right pedal

1

Lever

1 2

Bushing Forelock GOST 397-79

For reversal brakes control

142

Fig. 35.5. Parking and emergency brake. Parking and emergency brake control.

143

Group 35.Brakes.

Subgroup 3504, 3507. Parking and emergency brake.

Parking and emergency brake control Fig.No

Pos.No

Assembly unit or part number 35.5 50-3502010-02 50-3502030-A 70-3503080 85-3507140* 85-3507240 85-3507150-01 85-3507150-03* 85-3507120-01 1 70-3504055* 70-3504055-01 2 70-3502040-01 or 70-3502040-04 3 50-35020364 8-6 .6.019 5 50-3502196 6 3,2 18.019 7 50-3502203 8 12 32 9 50-3502198 10 1,611 50-3502202 12 12 1,25-6 .04.019 13 70-3503017-A 14 70-3503018 15 70-3503019 16 12.019 17 70-3507122-01 18 70-3507132- -01 19 15 20 5.01.019 21 55-17-27 22 A13.19.002 23 A13.19.00124 85-3507130-01 25 50-1606026 26 70-3507024 27 10-6g 35.88.35.019 28 70-350702129 10 30 10-6 .6.019 31 12 32 85-3507141* 85-3507241 33 12-6gx40.88.35.019 34 70-3514107* 80-3514107 35 85-3507060 36 -611 37 12-6g 200.58.019* 1522-2409034-03 38 70-3507070-01 *During the installation of double-disk brakes

Q-ty

Name

1 1 1 1 1 1 1 1 1

Brake (2-11, 40-42) Pressure disk(3-9, 41, 42) Brake rod (12,14,15) Rod (7,12,32) Rod (7,12,32) Bracket (13,31,33-36,38,43) Bracket (13,31,33-36,38,43) Lever (16,17,20-26) Shaft

2

Brake disk

2 2 2 3 2 3 2 1 1 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 2 2 7 1

Pressure disk Nut GOST 5915-70 Rod Forelock GOST 397-79 Yoke Pin OST 37.001.163-75 Pin Wire GOST 3282-74 300 mm Case Nut GOST 5916-70 Lever Washer Bolt Forelock GOST 397-79 Rod Axis Ring GOST 13942-86 Washer GOST 6958-78 Spring Button Handle Lever Latch Axis Bolt GOST 7796-70 Quadrant Washer OST 37.001.115-75 Nut GOST 5915-70 Washer OST 37.001.115-75 Rod

1 1

Bolt GOST 7796-70 Lever

1 1 2 2 1

Shaft Key 6 11 Bolt GOST 7795-70 Bolt Bracket

144

Fig. 35.5. Parking and emergency brake. Parking and emergency brake control

145

Group 35.Brakes.

Subgroup 3504, 3507. Parking and emergency brake.

Parking and emergency brake control Fig.No

Pos.No

35.5

39 40 41 42 43

*

Assembly unit or part number * 12-6g 180.58.019 12-6g 200.58.019 50-3502035- 2 77.38.163 22,225-100 1221-3507072

Q-ty 3 3 1 3 3 1

During the installation of double-disk brakes

146

Name Bolt GOST 7795-70 Bolt GOST 7795-70 Housing Spring Ball GOST 3722-81 Bushing

Fig. 35.6. Parking and emergency brake. Parking and emergency brake control (for wet brakes)

147

Group 35. Brakes Subgroup 3504, 3507. Parking and emergency brake.

Parking and emergency brake control (for wet brakes) Fig.No

Pos.No

35.6

1 2 3 4 5 6 7 8 9 10 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41

Assembly unit or part number 85-3502030-01 1221 -3507140 70-3503080 85-3507120-01 1221 -3502039-01 14 8-6 .6.019 50-3502198 85-3502196 12 32 50-3502203 12 1,25-6 .6.019 70-3503018 70-3503019 1221 -3507060 12.019 70-3507122-01 70-3507132- -01 15 5.01.019 55-17-27 13.19.002 13.19.00185-3507130-01 50-1606026 70-3507024 10-6g 35.88.35.019 70-350702110 10-6 .6.019 12 3,2 18.019 1221 -3507141 12-6 .6.019 50-4616043 50-4616038 1221 -3507240 1221 -3504055 6-6g 12.88.35.019

80 -3502202 80 -3502204 1221 -3502051 50-1601352 80 -3502037 80 -3502037-01 80 -3502037-02 80 -3502037-03 42 80 -3502037-04 80 -3502037-05 80 -3502037-06 80 -3502037-07 * Selected during the installation for required gap

Q-ty 1 1 1 1 5 5 2 2 2 2 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 2 2 1 3 1 1 1 1 1 1 4 4 1 1 1 2 2 * * * * * * *

148

Name Pressure disks (3-7, 29, 44, 46, 47) Rod (30-34) Brake rod (8-10) Lever (13-14,17-23) Bolt Washer OST 37.001.115-75 Nut GOST 5915-70 Pin Rod Pin OST 37.001.163-75 Yoke Nut GOST 5916-70 Washer Bolt Lever Forelock GOST 397-79 Rod Axis Ring GOST 13942-86 Washer GOST 6958-78 Spring Button Handle Lever Latch Axis Bolt GOST 7796-70 Quadrant Washer OST 37.001.115-75 Nut GOST 5915-70 Washer OST 37.001.115-75 Forelock GOST 397-79 Rod Nut GOST 5915-70 Coupling Nut Rod Shaft Bolt GOST 7798-70 Washer OST 37.001.115-75 Case Plate Gasket Adjusting pin Intermediate disk (S=3,0 mm) Intermediate disk (S=3,2 mm) Intermediate disk (S=3,4 mm) Intermediate disk (S=3,6 mm) Intermediate disk (S=3,8 mm) Intermediate disk (S=4,0 mm) Intermediate disk (S=4,2 mm) Intermediate disk (S=4,4 mm)

Fig. 35.6. Parking brake. Parking brake control (for wet brakes)

149

Group 35. Brakes Subgroup 3504, 3507. Parking and emergency brake.

Parking and emergency brake control (for wet brakes) Fig.No

Pos.No

35.6

43 44 45 46 47

Assembly unit or part number 1522-3502015-07 22,225-100 1221 -3502034 77.38.163 85-3502036-01

Q-ty 4 5 1 3 2

150

Name Disk Ball GOST 3722-81 Cover Spring Pressure disk

Fig. 35.7. Pipelines and fittings of single wire trailer brakes’ air drive

151

Group 35. Brakes Subgroup 3506. Pipelines and fittings of single-wire trailer brakes air drive Fig.No

Pos.No

35.7

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34

*

Assembly unit or part number 1220-3506620 1221-3506510 85-3506150 1522 -3506050 * 923-3506020 70-3506023 70-3506033 014-017-19-2-4 70-3506028 80-3506024 70-3506022 1220-3506621 70-3506027 5000.02 70-1405013 16 8 70-6804011 1221-3506511 85-3506151 1522-3506022 012-015-19-2-4 1522-3506024 1522-3506023 1522 -3506051 1522-3521012 29.76.000 or 80-3521010 70-3521012 10 10 10 25 923-3506021* 50-3513015- * 80-3513050* 29.51.000 or 80-3512010 1522-3514033 85-3407332 1221-3506620 1221-3506610

Q-ty

Name

1 1 1 1 1 3 1 2 2 1 1 1 2 4 3 2 2 2 1 1 2(4*) 2(4*) 2(4*) 2(4*) 1 1

Pipe line (1,5,7) Pipe line (1,4,14) Pipe line (1,4,15) Pipe line (16-20) Pipe line (16-19,27) Nut Elbow Ring Coupling Coupling Union body Pipe line Bushing Clamp with worm thread 16-27 Hose Bolt Washer Holder Pipe line Pipe line Nipple Ring Coupling Nut Pipe Union body

1

Coupling head

1 2 2 2 1 1 1

Bracket Washer Nut Bolt Pipe Ballon Three-way pipe

1

Pressure regulator

1(2*) 1 1 1

Upon request

152

Elbow Coupling hose Pipe line Pipe line

Fig. 35.8. Pipelines and fittings of double wire trailer brakes’ air drive

153

Group 35. Brakes Subgroup 3506. Pipelines and fittings of double-wire trailer brakes air drive Fig.No

Pos.No

35.8

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38

*

Assembly unit or part number 1220-3506620 1221-3506510 1021-3506020 1025-3506540 1025-3506560-01 1025-3506560-02 1522-3514033 70-3506033 70-3506023 014-017-19-2-4 70-3506028 80-3506024 70-3506022 1220-3506621 70-3506027 -21 70-1405013 16 8 70-6804011 1221-3506511 012-015-019-2-4 1522-3506022 1522-3506023 1522-3506024 70-4802046* 1025-3506561-01 1522-3521513 64226-3521110 1025-3521511 10 10 10 25 80-3723045-01 64226-3521111 1025-3521512 25 1025-3506561-02 1025-3506550 1021-3506021 29.51.000 or 80-3512010 85-3407332 1221-3506620 1221-3506610

Q-ty

Name

1 1 1 1 1 1 1 2 3 2 2 1 1 1 2 2 1 * 2(3 ) 2(3*) 2 1 6 6 6 6 1 1 2 1 1 4 4 2 4 1 1 2 1 1 1

Pipe line (3, 6, 8) Pipe line (3 ,4, 5, 15) Pipe line (17-19, 34) Pipe line (3, 5, 33) Pipe line (17-19, 21) Pipe line (17-19, 32) Elbow Elbow Nut Ring Coupling Coupling Union body Pipe line Bushing Clamp Hose Bolt Washer Holder Pipe line Ring Nipple Captive nut Coupling Clamp Pipe Union body Coupling head Bracket Washer Nut Bolt Collar Coupling head Bracket Screw Pipe Pipe line Pipe

1

Pressure regulator

1 1 1

Coupling hose Pipe line Pipe line

For dry brakes

154

Fig. 35.9. Ballon

155

Group 35.Brakes Subgroup 3513. Ballon Fig.No 35.9

Pos.No 1 2 3 4 5 6 7 8 9 10 11

Assembly unit or part number 80-3513010 * 85-3513010 ** 80-3513015 *** 80-3513025 50-3513032 50-351302516 6 6 -43-01 50-3522023 85-3513110 50-4202146

Q-ty

Name

1 1 1 1 2(4*) 2(4*) 2(4*) 2(4*) 2(4*) 4(8*) 1(2*) 1(2*) 1(2*)

Ballon Ballon Three-way pipe Three-way pipe Clamp Bracket Washer Washer Nut Seal Gasket Valve Ring

*

Upon request For single-wire air drive *** For double-wire air drive **

156

Fig. 35.10. Break valve

157

Group 35.Brakes Subgroup 3514. Break valve Fig.No

Pos.No

35.10

1 2 3 4 5 6 7 8

9

10 11

*

Assembly unit or part number 80-3514012 10 10 40 85 -3514011 10 10 70 3,2 18 80-3514130 29.3514010 or 80-3514010 * 29.3514010-01 or 80-3514010-01* ** 29.3514010-02 or 803514010-02** 12 40 12

Q-ty

Name

2 4 2 1 1 2 2 1

Lug Washer Bolt Bracket Washer Bolt Forelock Rod

1

Break valve

1

Break valve

1

Break valve

1 2

Pin Washer

Upon request For double-wire air drive

**

158

Fig. 37.1 Electrical equipment of engine

159

Group 37. Electrical equipment Subgroup 3700. Electrical equipment of engine Fig.No 37.1

Pos.No 1 2 4 6 8 10 12 14 16 18 20 22 24 26 28 30 32 33 34 36 38 39 42 44 46 47 48 50 52 54 56 58 60 62

Assembly unit or part number 800-11085301221.4-3747020 1221.4-3759020 50-4607064 54.24.44570-3723042-02 70-3723035 80-3723045 80-3723045 822-3723044 822-3723001 1522-3721011 -59-6000-38 6-6g 16.88.35.019 8-6g 14.88.35.019 6-6g 20.58.019 5-6 .6.019 6-6 .6.019 8-6 .6.019 6.01.019 1221.4 -3724360 1221-372438080-3724381 80-3724383

3722.40 3845.10 3829.15 3759.10 3747.35 3721.15 3721.20

Q-ty

Name

1 1 1 1 1 1 4 3 16 3 2 2 1 2 4 4 6 2 1 4 1 1 1 4 6 8 4 1 1 1 1 1 1 1

Bracket Bracket Bracket Bushing Tip Bushing Tip Collar Collar Clamp Joke Plate Rubber tip Bolt GOST 7798-70 Bolt GOST 7798-70 Screw GOST 17473-80 Nut GOST 5915-70 Nut GOST 5915-70 Nut GOST 5915-70 Washer GOST 11371-78 Harness GOST 23544-84 Harness GOST 23544-84 Cable GOST 23544-84 Cable GOST 23544-84 Washer OST 37.001.115-75 Washer OST 37.001.115-75 Washer OST 37.001.115-75 Fuse block Air cleaner clogging sensor Air pressure emergency sensor Voltage transducer Glow plug relay Low pitch motorhorn High pitch motorhorn

160

Fig. 37.2 Transmission electrical equipment 161

Note to Fig. 37.1 Designation 1221-3700040- -04 1221-3700040- -06

Fig. 37.2 37.2

Note Complete version Version without pneumatic system

Group 37. Electrical equipment Subgroup 3700. Electrical equipment of transmission Fig.No 37.2

Pos.No

Assembly unit or part number

Q-ty 1221-3700040- 04

06

1 3 4 5 7 8 9 10

80-3723016 80-3723045-01 85-1702051 18-0551221.4-372431780-37240023843.15 3829.20

1 16 1 1 1 2 1

1 18 1 1 2 -

11

3829.30

1

1

12

3829.25

1

-

14 15 16

305- -40-35 1522-3843002 822-3723001

4 2

1 4 2

17

822-3723001

14 maximum

14 maximum

Q-ty

Q-ty

18 19

40

4 4

4 4

162

Name Bracket Collar Washer O-ring Harness Cable Rpm sensor Air pressure sensor Gear box oil pressure sensor Air pressure emergency sensor Pipe Gasket Joke Gasket Bolt Washer

Fig. 37.3. Cabin electrical equipment

163

Group 37. Electrical equipment Subgroup 3700. Cabin electrical equipment Fig.No 37.3

Pos.No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 25 25 26 27 28 29 30 31 32 33 35 36 37 38 39 40 41 42 43 44 45 46 47 48

Assembly unit or part number 70-3723042-01 80-3724351- 1 80-3723015 80-3723020 5205.10 5205.25 6 12 80-3723010 8724.31.06 14 8 8 80 -3724310-14 80-3801342 3710.40 80-3801327 80-37240353714.10 3710.30 3709.15 3709.25 10 11.3729 80 -3724010 5205.20 5205.30 5205.35 80-5205031 6 16 80-37242322-4 16 37.10.031 85-3723041-01 80-3724300- 1 5 5 80-3723038 16 85-3710032 85-3710025 14 3720.10 3829.15 1321-8700029 25 25 8 6

Q-ty

Name

4 1 1 1 1 1 5 9 1 4 1 1 1 1 1 1 2 2 1 2 1 1 1 1 1 1 1 1 1 5 2 1 4 4 4 1 11 11 3 3 1 1 1 1 1 2 1 1 1 3

Bushing Harness Duct Duct Parallel-motion windscreen wiper Brush with lever 660/600 Washer Screw Duct Working light Bolt Washer Nut Cable Shield Roadtrain indicator switch Blind plug Cable Cabin dome light 105 95 Working lights switch Fan switch Windscreen wiper switch Screw Additional resistance Harness Windscreen wiper Windscreen wiper lever 420 Windscreen wiper blade 460 Bracket Washer Bolt Harness Male screw Threaded rivet nut Joke Harness Nut Washer Joke Screw Lever Nut Washer Stop signal switch Air pressure emergency sensor Clamp Screw Screw Washer Nut

164

Fig. 37.3. Cabin electrical equipment

165

Group 37. Electrical equipment Subgroup 3700. Cabin electrical equipment Fig.No 37.3

Pos.No 50 51 52 53 54 55 56 57 58 59

Assembly unit or part number 80-3710012 3710.60 5 3738.10 80-3738001 80-6708904 20 80-372423180-372435380-3724233-

Q-ty 1 1 2 3 1 4 1 2 1 1

166

Name Bracket Hand brake light switch Washer Roadtrain lamp Bracket Gasket Bolt Harness Harness Harness

Fig. 37.4 Storage battery installation

167

Group 37 Electrical equipment Subgroup 3724. Storage battery installation Fig.No Pos.No 37.4 1 2 3 4 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35

Assembly unit or part number M8x20 M16x40 16 16 50-4607064 1221 -3724044 1221B-3703010-02 M8x30 1221 -3724041 -59-6000-38 54.24.445M8 923-3724042 1522-3703025 6 6 M6X16 M6 3737.15 M6x20 3703.26 1221 -3724075 80B-3703020 1221B-3703010 8 1221B-3703020-01 8 822-38013413722.55 1222.4-3722001 920-37243681222.4-3724045

Q-ty 6 2 2 2 4 1 1 4 1 3 2 12 1 1 4 4 2 2 1 2 2 1 2 1 10 1 2 1 1 1 1 1

168

Name Bolt Bolt Washer Washer Bushing Cable Container Bolt Cable Cap Cap Nut Cable Housing Washer Washer Bolt Nut Remote 24 V battery switch Bolt 12/120 storage battery Cable Clamp Container Washer Housing Washer Shield Fuse block Bracket Cable Cable

Fig. 37.5. Head lamps installation

Fig. 37.6. Front lights installation

169

Group 37. Electrical equipment Subgroup 3723. Head lamps installation Fig.No 37.5

Pos.No 1 2 3 4 5 6 7 8 9 10 11

Assembly unit or part number 5 5 3723.15 80-3723056 22 70-3723036-01 80-372402570-3723042-01 087101000 6 6

Q-ty 6 4 2 4 4 2 2 2 1 8 8

Name Nut Washer Connecting double-contact panel Plate Screw Cover Harness Bushing Head lamp Nut Washer

Group 37. Electrical equipment Subgroup 3723. Front lights installation Fig.No 37.6

Pos.No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

Assembly unit or part number 85-3712045 30.04.017-01 20 8 70-3723042-01 80-3724131 80-3712040 85-3712045-01 6 3712.10 6 18 70-3723042-02 80-3723040

Q-ty 1 4 4 4 2 1 1 1 4 4 2 4 4 1 1

170

Name Housing Cap Bolt Washer Bushing Harness Bracket Housing Nut Washer Front light with side repeater Washer Screw Bushing Bracket

Fig. 37.7. Head lamps installation

171

Note to Fig. 37.7 Designation 80-3700020 80-3700020 -01 80-3700020 -02

Note Remote head lamps Built-in head lamps Bracket-mounted head lamps

Group 37. Electrical equipment Subgroup 3723. Head lamps installation Fig.No

Pos.No

37.7

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

Assembly unit or part number 80-3700020 or 80-3700020 -01 or 80-3700020 -02 8703.302/01-02 8703.302/1-02 70-3723042-01 80-3724025 -01 80-3711013-02 8703.302/1-01 8703.302/01-01 80 -3724025 80-3711010 50 -8406037 16 50-3711014 80-3711013-03 70-3723036-01 80-3723056 22 5 5 14.3723 16 8 8 80-3724016

Q-ty 80-3700020 01 02

Name

1

Head lamps installation

1 1 2 2

2 4 4 4 4 2

172

1

1

4 2 1 1 1

2 1 2 4 4 4 4 2 4 4 4 2

1 1 2 2 4 4

2 4 4 4 4 2

Head lamp Head lamp Bushing Harness Bracket Head lamp Head lamp Harness Bracket Bolt Washer Seal Bracket Cover Plate Screw Nut Washer Panel Bolt Nut Washer Cable

Fig. 37.8. Front lights and head lamps installation

173

Group 37. Electrical equipment Subgroup 3724. Front lights and head lamps installation Fig.No

Pos.No

37.8 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

Assembly unit or part number * 82 -3700025-02 82 -3700025-03 ** 8724.304/011 ** 3712.10 925-3712025-01 70-3723042-02 920-372413292 -3724142 ** 520604 620604 920-3724131925-3712025 8-6g 20.88.35.019 GOST 7796-70 8.01.019 GOST 6958-78 OST 37.001.115-75 30.04.017-01 36-4603079- 2 920-3711011** 923-3724142** 920-3712021 920-3712013 920-3712010 920-3712022 10.019 6-6g 20.58.019 GOST 17475-80 6-6g 18.88.35.019 GOST 7798-70 6-6 .6.019 GOST 591570 OST 37.001.115-75 920-3712012 30.04.017 6-6g 18.58.019 GOST 17473-80 6.01.019 GOST 1137178

Q-ty

Name Front lights installation

2 2 1 3 1 1 1 1 1 1 8

Working light Front light with side repeater Bracket Bushing Harness Harness Male socket Female socket Harness Bracket Bolt

4 8 4 2 2 2 2 2 2 2 8 4

Washer Washer Cap Blind plug Bracket Harness Housing Joke Bracket Housing Male screw Screw

8

Bolt

8

Nut

8 2 4 4

Washer Bracket Cap Screw

4

Washer

*

Without working lights ** With working lights mounted on front lights’ brackets

174

Fig. 37.9. Installation of back lights

175

Group 37. Electrical equipment Subgroup 3724. Installation of back lights Fig.No 37.9

Pos.No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21

Assembly unit or part number 3716.10 85-3724163 920-3724163 3717.10 70-3723042-02 85-3724162 920-3724162 3723.10 10 25 10 10 10 50-3731011 3731.10 12 25 12 12 18 6 6 85-3716012 6 85-3716015

Q-ty 2 1 1 1 4 1 1 1 2 2 2 2 2 2 1 1 1 8 8 8 2 2 2

176

Name Back light Harness (with metal facing) Harness (with plastic facing) Number plate light Bushing Harness (with metal facing) Harness (with plastic facing) Trailer socket Bolt Nut Washer Washer Bracket Reflector Bolt Nut Washer Screw Nut Washer Bracket Washer Housing

Fig. 37.10. Installation of back lights

177

Group 37. Electrical equipment Subgroup 3724. Installation of back lights Fig.No

Pos.No

37.10 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28

Assembly unit or part number 82 -3700060 112.00.05-01 923-3716011 7303.3716 70-3723042-01 85-3724163 85-3724162 80-3724224 10x25 10 10 10 16 6 6 6 50-3731011 3202.3731 70-3723035 80-3724134 85-3716012 35 5 5 9-1 16 8 25 85-3716015

Q-ty

Name

1 1 1 2 4 1 1 1 2 2 2 2 4 10 8 10 2 2 1 1 2 3 3 3 1 4 4 4 2

Installation of back lights (1-28) Number plate light Bracket Back light Bushing Harness Harness Cable Bolt Nut Washer Washer Screw Nut Nut Washer Bracket Reflector Tip Cable Bracket Screw Nut Washer Socket Bolt Washer Screw Housing

178

Fig. 37.11. Electrical equipment of heater

179

Group 37. Electrical equipment Subgroup 3724. Electrical equipment of heater Fig.No 37.11

Pos.No 1 2 3

Assembly unit or part number 11.3729 80-3724353 147 -04.11

Q-ty 1 1 1

180

Name Additional resistor Harness Switch

Fig. 37.12. Beacon installation

181

Group 37. Electrical equipment Subgroup 3738. Beacon installation Fig.No

Pos.No

37.12 1 2 3 4 5 6 7 8 9 10 11 12 13

Assembly unit or part number 80-3738010 -2-12-0 25 6 6 6 320-3738005 343 -01.88 45 8 8 30.04.051 80-3723045 80-3724234

Q-ty 1 1 3 3 3 3 1 1 1 1 1 1 2 1

182

Name Beacon installation (1-13) Signal beacon Bolt Nut Washer Washer Bracket Switch Bolt Nut Washer Clamp Collar Harness

Fig.38.1 Dashboard

183

Group 38. Dashboard Subgroup 3805. Dashboard Fig.No Pos.No 38.1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28

Assembly unit or part number Q-ty 10-6 .6.019 GOST 5915-70 2 10 OST 37.001.115-75 2 8-6g 16.88.35.019 2 OST 37.001.115-75 2 8.01.019 GOST 11371-78 1 80-3805030 2 6-6g 16.88.35.019 GOST 7798-70 4 6-6 .6.019 GOST 5915-70 18 6.01.019 GOST 11371-78 10 OST 37.001.115-75 21 826-3805045 1 826-3805061 1 6-6g 16.58.019 GOST 17473-80 4 006-010-25-1-4 GOST 18829-73/ 2 GOST 9833-73 826-3805065 2 5-6g 20.58.019 GOST 17473-80 2 5.01.019 GOST 6958-78 2 OST 37.001.115-75 5 826-3805021 1 80-3805070 1 826-3805025 1 80-38050121 80-3805029 1 5-6g 16.58.019 GOST 17473-80 3 5-6 .6.019 GOST 5927-70 2 * 1 80-3709023 or 80-3709023- ** 1 3912.3769-01* or -1 ** 2. 6-6g 16.58.05 GOST 17473-80 2

*

With 3912.3769-01 switch ** With -1 switch

184

Name Nut Washer Bolt Washer Washer Bracket Bolt Nut Washer Washer Wall Cover Screw Ring Screw Screw Washer Washer Shield Panel Instruction plate Seal Seal Screw Nut Housing Underwheel switch Screw

Fig.38.2 Dashboard

185

Group 38. Dashboard Subgroup 3805. Dashboard Fig.No Pos.No 38.2 7 8 9 10 11 12 18 25 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55

Assembly unit or part number 6-6g 16.88.35.019 GOST 7798-70 6-6 .6.019 GOST 5915-70 6.01.019 GOST 11371-78 OST 37.001.115-75 826-3805045 826-3805061 OST 37.001.115-75 5-6 .6.019 GOST 5927-70 3741.10 3747.25 6-6g 12.58.019 GOST 17473-80 3747.40 3747.50 3747.30 3747.10 70-3723042-02 70-3723042-01 80-3805050-03 80-3805043 6-6g 25.58.019 GOST 17473-80 80-38050273722.10 6-6g 40.58.019 GOST 17473-80 80-38050373722.15 80-3805026 3722.35 80-3723048 3741.30 5-6g 20.58.019 GOST 17473-80 826-3724530 826.4-3724395826-3805013-01 50-4607064 80-3723043

186

Q-ty 4 18 10 21 1 1 5 2 1 1 13 1 4 1 1 2 1 1 2 2 1 1 2 1 1 1 1 1 1 2 1 1 1 1 1

Name Bolt Nut Washer Washer Wall Cover Washer Nut Glow plug block Starter relay Screw ut-out relay 20 Cut-in relay 30 Instrument power relay Turn indicator flasher Bushing Bushing Base Bracket Screw Instruction plate Fuse block Screw Instruction plate Fuse block Instruction plate Fuse block Bushing Additional resistor (CAN) Screw Harness Harness Instruction plate Bushing Joke

Fig.38.3 Dashboard

Group 38. Dashboard 187

Subgroup 3805. Dashboard Fig.No Pos.No Assembly unit or part number 38.3 18 OST 37.001.115-75 19 826-3805021 25 5-6 .6.019 GOST 5927-70 56 3813.35 57 3747.20 58 3710.10 59 3710.30 60 826-3710011 61 3709.20 62 3710.35 63 80-3801327 64 3710.55 65 80-3723038 66 5-6g 12.58.019 GOST 17473-80 67 3710.15 68 3813.40 69 3801.20 70 3803.20 71 4-6g 12.58.019 GOST 17473-80 72 4.01.019 GOST 11371-78 73 4 OST 37.001.115-75

Q-ty 5 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 2

188

Name Washer Shield Nut Integrated indicator (CAN) Alarm-relay Hazard light switch Working lights switch Jack for disconnect switches Dipswitch control Windscreen washer switch Blind plug Battery disconnect switch Joke Screw Starter switch with start lock Control panel Instrument cluster -6 CAN Warning light block Screw Washer Washer

Fig. 39.1 Operator tool

189

Group 39. Tools and accessories Subgroup 3901. Operator tool Fig.No 39.1

Pos.No 1 2 3

Assembly unit or part number 70-3901038 70-3901027 214

Q-ty 1 1 1

190

Name Wrench 41x46 Socket wrench S=27 32 Manometer

Fig. 39.2. First aid kit

191

Group 39. Tools and accessories Subgroup 3912. First aid kit Fig.No

Pos.No

39.2

1 2 3 4 5

Assembly unit or part number 70-3912153-A 70-3912152 70-3912151 6 70-3723033

Q-ty 1 1 1 3 3

192

Name Bracket Housing Cover Washer Joke

Fig. 39.3. Tool box

193

Group 39. Tools and accessories Subgroup 3919. Tool box Fig.No

Pos.No

39.3

1 2 3 4 5 6

Assembly unit or part number 50-8400018 70-3919110 M8x16 8 8 M8

Q-ty 4 1 2 2 2 2

194

Name Bumper Box Bolt Washer Washer Nut

Fig. 42.1 Rear PTO shaft. Reduction gear unit

195

Group 42. Power take-off (PTO) Subgroup 4202. Rear PTO shaft Fig.No

Pos.No

42.1

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47

Assembly unit or part number 1025-4202010 1025-4202020 70-420203070-4202083280 85-4202065 70-4202431 70-4202026 SKF K20 26 17 70-4202024 1025-4202036 1025-4202037 68 1025-4202003 309 100 C 45 8-1701392 80-1701379 80-1701384 80-1701375 80 77-1601373 77-1601067 165-170-36-2-4 1025-4202009 075-080-30-1-4 7,144-60 1025-4202006 1025-4202001 16-3 /6g 45 16 16 16 40 12 12 40 059-065-36-2-4 125-130-36-2-2 1025-4202007 1025-4202008 86-1802032 65 86-180203586-1802034 135 1025-4202004 1025-4202011 10 10 30 50

Q-ty

Name

1 1 1 1 1 1 3 3 6 3 1 1 1 1 1 1 1 1 1 2 2 1 1 16 1 1 1 4 1 1 4 8 4 4 5 5 1 1 1 5 2 1 2 1 1 1 1 14 5 1

Rear PTO shaft Reduction gear unit Crown gear Nut Bearing Pinion cage Pin Satellite gear axis Bearing Satellite gear Sun gear Clutch Ring Bushing Bearing Ring Ring Ring Thrust disk Drive disk Driven disk 05 Ring Spring support Spring Ring Piston Ring Ball Housing Gasket Stud Washer Nut Bolt Washer Bolt Ring Ring Piston Washer Driven disk Ring Drive disk Thrust disk Ring Gasket Cover Washer Bolt Ring

196

Fig. 42.1 Reduction gear unit

197

Group 42. Power take-off (PTO) Subgroup 4202. Rear PTO shaft Fig.No 42.1

Pos.No 48 49 50 51 52 53 54 55 56 57

*

Assembly unit or part number 1025-4202013 110 60310 2.2-75 100-1 1025-4202012 80-4202019* 80-4202019- -01 80-4202019- -02* 80-42020811321-4212180 50-4202065- -01 10 20

Q-ty 1 1 1 2 1 1 1 1 1 1 1 6

Upon request

198

Name Clutch Ring Bearing Collar Shaft Shaft end extension (8 splines) Shaft end extension (6 splines) Shaft end extension (21 splines) Plate Plate Cap Bolt

Fig. 42.2 Reduction gear unit

199

Group 42. Power take-off (PTO) Subgroup 4202. Rear PTO shaft Fig.No 42.2

Pos.No 1 2 3 4 5 6 7 8 9 10 11 12

Assembly unit or part number 70-420204470-4202043 50-420206650-420204661.03.002 50-4202068 12 1,25 210 1 110 90 50 7,938-100

Q-ty 1 1 1 1 1 1 1 1 1 1 1 1

200

Name Shaft Crown gear Sleeve Shift coupling Ring Screw Nut Bearing Ring Ring Ring Ball

Fig. 42.3. Front PTO shaft

201

Group 42. Power take-off (PTO) Subgroup 4209. Front PTO shaft Fig.No

Pos.No

42.3

1 2 3 4 5 6 7 8 9 10 11

Assembly unit or part number 1522-4209025 1522-4209017 1522-4209015 1522-4209015-01 10 1522-4209018 12 50 12 52-2203012 16 60 16

Q-ty 1 1 1 1 4 1 6 6 8 4 4

202

Name Reduction gear unit Flange Shaft Shaft Washer Spacer plate Screw Washer Bolt Bolt Washer

Fig. 42.4. Front PTO shaft. Reduction gear unit

203

Group 42. Power take-off (PTO) Subgroup 4209. Front PTO shaft. Reduction gear unit Fig.No

Pos.No

42.4 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52

Assembly unit or part number 1522-4209025 1521-4209042 204 209 1521-4209076 «MINTOR» TSS0G-1/8” 70-4202024 20 26 34 021-025-25-1-4 70-4202026 0 6-180306 1 1521-4209031 1521-4209028 464906 1521-4209029 180308AC23 40 1522-4209060 2.2-38x58-1 1522-4209027 70-420208350-17020461521-4209044 1521-4209034 1521-4209033 464607 1521-4209036 1521-4209032 038-046-46-1-4 12x32 3,2x18 8 50-3503063 1521-4209066 12 35 12 1521-4209040 11 1522-4209084 1522-4209082 1522-4209083 25 8 1521-4209086 1521-4209087 70-1601114 017-022-30-1-4 1521-4209056 1521-4209081 3/4" 1522-4209057 2522-4209149

Q-ty

Name

1 1 2 2 1 1 3 3 1 3 3 1 1 1 2 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 2 2 2 14 18 1 1 1 1 1 2 1 1 4

Reduction gear unit Gasket Ring Bearing Bushing Breather Satellite gear Bearing Ring Satellite gear axis Pin Bearing Washer Gear Bearing Bushing Bearing Ring Cover Collar Shaft Nut Bolt Washer Bushing Gear Bearing Washer Axis Ring Pin Forelock Washer Hub Plate Bolt Washer Lever Key Nut Pin Screw Bolt Washer Shaft Plate Pin Ring Plate Lever Plug Cover Stabilizer

204

53

80-4608073

2

Fig. 42.4. Front PTO shaft. Reduction gear unit

205

Bracket

Group 42. Power take-off (PTO) Subgroup 4209. Front PTO shaft. Reduction gear unit Fig.No

Pos.No

42.4

54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103

Assembly unit or part number 1522-4209041 1521-4209078 2.10x35 36 1/8" 3/8" 16 1521-4209037 3,2x18 16 80-4216100 50 20 210 1 90 1521-4209038 1521 -4209039 212 1 1522-4209046 1521-4209047 110 208 85-4202065 70-4202043 1522-4209026 80-42020172522-4209125-01 70-4202032 70-4202077 2522-4209125 85-4202033 68 85 1521-4209071 2.2-80 105-1 16 32 16 10 18 80-4202101 16 10 2022-4209200 12 80-4202019- -02 80-420208160310 2522-4209148 1521-4209072 0.65 10 25

Q-ty 1 2 1 1 1 1 5 1 1 1 1 2 4 1 2 1 2 1 1 1 3 1 1 1 1 1 1 1 1 1 1 1 1 1 1 4 2 7 1 2 11 1 2 1 1 1 2 1 1 6

206

Name Gasket Stabilizer Pin Pin Plug Plug Washer Bolt Forelock Washer Cylinder Ring Bolt Bearing Ring Cover Gasket Bearing Shaft Gear Ring Bearing Pinion cage Crown gear Housing Shaft Band Sun gear Bushing Band Drum Ring Ring Cover Collar Bolt Washer Bolt Cap Bolt Washer Guard Washer Shaft end extension Plate Bearing Pin Axis Pin Bolt

Fig. 42.5. Drive pulley

207

Group 42. Power take-off (PTO) Subgroup 4211. Drive pulley Fig.No

Pos.No

42.5

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32

Assembly unit or part number 40-4211010-01 40-4211035 40-4211040 40-4211050 40-4211065 40-4211052 2.2-50x70-1 ( 50 70) 40-4211043 36-1701061 211 1 40-4211047 40-4211079 311A 40-4211081 40-4211045 40-4211082 3 ” /8 3 /4” 40-4211037 -1/8"40-4211071 408 40-4211072 120-125-30-1-4 36-4211054 36-4211055 36-4211048 4x36 M20x1,5 40-3502084 40-3502083 40-4211075 M12 40 2.2-65x90-1 12 36-4211073 36-4211057

Q-ty 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 2 1 1 6 8 1 1 1 1 1 1 6 1 6 1 1

208

Name 8-spline drive pulley (1-34) Housing (12-22, 30-34) Shaft (3-6, 8, 10, 11) Hose (1-6, 8, 10, 11) Shaft (16-18, 22) Hose Collar Nut Washer Bearing Bushing Gasket Bearing Gasket Shaft Blind plug Plug Plug Housing Breather Shaft-gear Bearing Bushing Ring Gasket (0,5 mm) Gasket (0,2 mm) Sleeve Forelock Nut Washer Gasket Pulley assembly Bolt Collar Washer Jack Gasket

Fig. 42.6. Rear PTO shaft control (for dry brakes)

209

Group 42. Power take-off (PTO) Subgroup 4216. Rear PTO shaft control Fig.No

Pos.No

10 11 12

Assembly unit or part number 1025-4216005 85-4216135 18-051 18-055- or 14 3,2 18.019 GOST 397-79 6-6g 16.88.35.019 GOST 7798-70 OST 37.001.115-75 85-4216127 16 GOST 13940-86 "NORMA" TORRO 1220/9-C6W 80-3407720 85-4216121 1221-4216104

13 14 15

85-4216142 1221-4216055 1221-4216016

1 1 2

16

012-016-25-2-4 GOST 18829-73/GOST 9833-73 8.01.019 GOST 1137178 85-4216123 .6 30.65 GOST 1422993 85-4216124 1221-4216035 85-4216122 6-6g 40.88.35.019 GOST 7795-70 1221-4216101

2

Oil pipeline Housing Hose 10 18,5-1,6 GOST10362-76 L=(1200±10) mm Rod Tip Hose 10 18,5-1,6 GOST10632-76 L=(300±10) mm Ring

1

Washer

1 2

Lever Pin

1 1 1 2

Lock Tip Spool Bolt

1

Hose 10 18,5-1,6 GOST10362-76 L=(1000±10) mm

42.6 1 2 3 4 5 6 7 8 9

17 18 19 20 21 22 23 24

Q-ty

Name

1 2 8 16 1 2

Rear PTO shaft control Oil pipeline Bolt Ring Forelock Bolt

4 1 2 8

Washer Plate Ring Clamp

4 1 1

210

Fig. 42.7. Rear PTO shaft control (for wet brakes)

211

Group 42. Power take-off (PTO) Subgroup 4216. Rear PTO shaft control Fig.No

Pos.No

42.7 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

Assembly unit or part number 1025-4216005-01 3,2 18.019 GOST 397-79 85-4216135 1221-4216055 "NORMA" TORRO 12-20/9C6W 1221-4216104

Q-ty

6-6g 16.88.35.019 GOST 7798-70 OST 37.001.115-75 1221 -4216011 16 GOST 13940-86 80-3407720 18-051 18-055 or 14 85-4216121 012-016-25-2-4 GOST 18829-73/GOST983373 8.01.019 GOST 11371-78 1221 -4216012 1221-4216035 85-4216123 .6 30.65 GOST 14229-93 85-4216124 1221-4216016

1 1 2 1 8

Rear PTO shaft control Forelock Oil pipeline Tip Clamp

1 2

Hose10 18,5-1,6 GOST10362-76 L=(1200±10) mm Bolt

4 1 2 4 8 16 1 2

Washer Bracket Ring Oil pipeline Bolt Ring Housing Ring

1 1 1 1 2 1 2

Washer Rod Tip Lever Pin Lock Hose10 18,5-1,6 GOST10362-76 L=(300±10) mm Spool Bolt

1 2

24

85-4216122 6-6g 40.88.35.019 GOST 7795-70 1221-4216101

25

6.01.019 GOST 11371-78

2

23

Name

1

212

Hose10 18,5-1,6 GOST10362-76 L=(1100±10) mm Washer

Fig. 42.8. Front PTO shaft control

213

Group 42. Power take-off (PTO) Subgroup 4216. Front PTO shaft control Fig.No

Pos.No

42.8 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

Assembly unit or part number 1523-4218010 240-1111103 18-0551221-4216035 1221-4218014 1221-4216253 12-20/9-CGW 80-3723045-01 1221-4218016 1221-4216180 20 8 80-3407720 18-051 1221-4216055 10 20 10 10

Q-ty 1 2 6 3 2 1 2 4 2 1 2 2 4 6 1 1 1 1

214

Name Front PTO shaft control Bolt O-ring Tip Hose Bracket Clamp «NORMA» TORRO Collar Hose Plate with distributor Bolt Washer Oil pipeline Bolt Tip Bolt Washer Washer

Fig. 42.9. Ballast

215

Group 42. Power take-off (PTO) Subgroup 4235. Ballast Fig.No

Pos.No

42.9

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

Assembly unit or part number 80-4235011-A 1025-4235012 85-423502516 M16 45 70-4235030 1025-4235015-01 16 1521-4235011-A M16 40 M18 70-4605036 40-3502084 20 M20 1521-4235020 M16 50 1521-4535029 M16 60 1222-4235012

Q-ty

Name

8 2 1 46 2 1 1 2 2 4 4 2 1 3 3 1 38 2 2 2

Ballast weight (45 kg) Bolt Ear Washer Bolt Kingpin String Washer Ballast weight (40 kg) Bolt Nut Bolt Washer Washer Nut Bracket Bolt Bushing Bolt Plate

216

Fig. 46.1. Pump drive

217

Group 46. Remote-cylinder hydraulic system Subgroup 4604. Pump drive Fig.No

Pos.No

46.1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

Assembly unit or part number 85-4604010 36-1022070210A 85-4604017 B40 70-1108179 11,113-100 3 16 36-1022074 36-1022073 36-1022072 85-4604010M8 16 8 50-4604044 013-017-25-1-4 85-4604012 50-460403636-102205490 70-4604037 85-4604011 1,0x150 50-4604046 85-4604030

Q-ty 1 1 2 1 2 1 3 1 1 1 1 1 2 2 1 1 1 1 1 1 1 1 1 1 1

218

Name Pump drive (1-5, 11-14, 16-24) Handle (6-10, 15) Bearing Clutch Ring Washer Ball Pin Spring Detent Sleeve Handle Bolt Washer Plate Ring Bushing Sleeve Gasket Ring Gasket Gear Wire Bolt Yoke

Fig. 46.2. Hydraulically operated lift linkage

219

Group 46. Remote-cylinder hydraulic system Subgroup 4605. Hydraulically operated lift linkage Fig.No

Pos.No

46.2

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42

Assembly unit or part number 1220-4605510-05 1220-4605120 1223-4605530-04 1220-4605590 1220-4605610-01 1220-4605670 1220-4605695 1220-4605612-01 4x36 M16 1220-4605104 1220-4605107 1220-4605102 M24 1220-4605103 1220-4605102-01 50-4605084 1220-4605105 1220-4605091- 1 1220-4605091- 1-01 680-2707024 20 1220-4605504 12 M12 25 1220-4605503 80-2800016-01 16 1220-4605506 1220-4605507 1220-4605501-01 1220-4605502 A61.10.001-02 A61.05.004 A61.05.005 1220-4605501 M20x1,5 142-4605076 or 921-4605076 1220-4605675 M12 35 12 50-4605069 A61.07.002 M12 A61.02.100-03 A61.03.100 A61.02.003 1220-4605570 A61.02.100-04 A61.02.100-05 A61.03.002 A61.08.001-03 A61.05.100-05

Q-ty 1 2 2 1 2 1 1 1 6 4 4 4 2 2 2 2 2 2 1 1 8 8 2 5 4 2 2 16 6 2 1 2 1 1 1 1 2 2 1 1 1 1 1 1 1 1 1 1 1 1 2 2 1

220

Name Rear lift linkage (1-83) Stabilizer (1-8, 10) Rod (67, 78, 79, 81, 82) Top link (36-43) Lifting rod (19, 45-66, 68-70) Bracket (16, 30-35) Screw (39-43) Lifting rod (74-77) (upon request) Forelock Nut Bolt Clip Screw Nut Stabilizer Screw (LH) Pin Clip Right bracket Left bracket Bolt Washer Plate Washer Bolt Pin Bolt Washer Bolt Pin Bracket Bushing Pin Ring Chock Bracket Nut Pin Bracket Bolt Washer Bushing Spring Nut Screw Pipe Lock nut Screw with hinge Ø 32 (3 cat.)

Screw with hinge Ø 22,5 Screw with hinge Ø 25,7 (2 cat.)

Ring Chain (7 links) Chock with ring

Fig. 46.2. Hydraulically operated lift linkage

221

Group 46. Remote-cylinder hydraulic system Subgroup 4605. Hydraulically operated lift linkage Fig.No

Pos.No

46.2 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83

Assembly unit or part number 1220-4605693 A61.02.001-01 A61.02.001-02 1220-4605557 M16 40 1220-4605668A61.01.600 A61.01.016A61.01.400 A61.01.014 142-4605408 A61.01.017 016-021-30-2-4 142-4605031 142-4605404142-4605418142-4605421 142-4605413 A61.01.005 142-4605403 142-4605425 8110 1.3. 6.

142-4605415 142-4605402 142-4605407 1223-4605530-04 142-4605408 142-4605401 1220-4605615 50-3503071 A61.07.001 1220-4605084-01 1220-4605075 1220-4605422 1220-4605424 1220-460562070-4605316 5x36 1220-4605558 A61.05.100 1220-4605108 16

Q-ty 1 1 1 1 4 2 2 2 2 2 4 4 2 4 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 1 1 1 1 2 2 2 2 2 2

222

Name Pin Ø 31,75 (3 cat.)

Pin Ø 25 (2 cat.)

Pin Ø 22 Reducing bushing (to 2 cat.)

Bolt Clip Shaft Axis Yoke Handle Bolt Bushing Ring Ring Pin Cover Gasket Gear Axis Retainer Pipe Bearing Oiler Housing Bushing Pipe Rod Cap Retainer Yoke Washer Spring forelock Pin Screw Stabilizer Lock nut Yoke Nut Forelock Reducing bushing (to 2 cat.)

Chock Ear Washer

Fig. 46.3. Front lift linkage

223

Group 46. Remote-cylinder hydraulic system Subgroup 4606. Front lift linkage Fig.No

Pos.No

46.3

2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48

Assembly unit or part number 680-4607140-04 80-4607554 1522-4606550-01 1522-4606550 16 50 16 16 35 8 70-3407146 70-3506027 .036.83.140 70-4605036 20 20 50-4605027 54.38.619 16 45 45 1220-4606110 1220-4606014 1.3. 9.

680-4605037 5x36 50-4605076 70-3003032 4x36 1220-46060401220-4606150 61.07.001 18 50-4605030- -03 40-460703880-4607332 530-4614029 4600.03 680-4607140-05 1221-4607023 017-022-30-1-4 .036.65.000 2-02 40-4607032 .036.77.000 .036.83.010 680-4605037-01 1220-4606090 036.50 .20 50-4605018-

Q-ty

Name

1 2 1 1 2 1 10 2 2 2 4 1 2 2 2 4 4 8 1 1 1 2 2 4 2 2 2 1 2 2 2 1 7 1 4 2 2 1 1 1 2 1 1 2 1 2 1

High pressure hose Ø 10 1 armoured Bracket Pipe Pipe Bolt Nut Washer Bolt Washer Plate Bushing High pressure hose Ø 12,5 2 armoured Bolt Nut Washer Pin Lock ring Bolt Pin Bracket Axis Oiler Pin Forelock Pin Nut Forelock Upper link Lifting rod Forelock Washer Rod Washer Bolt Elbow Hydraulic cylinder 63 40 200 High pressure hose Ø 10 1 armoured Union body Ring Reduction valve Clamp bolt Breather High pressure hose Ø 10 1 armoured Pin Detent Right housing Bushing

224

Fig. 46.4. Bracket 225

Group 46. Remote-cylinder hydraulic system Subgroup 4606. Bracket Fig.No

Pos.No

46.4

1 2 3 4 5 6 7 8 9 10

Assembly unit or part number 1220-4606020 70-4605023 1220-4606013 65 1220-4606011 70-4605032 1220-4606020-01 12 12 25 40-4605023- 2

Q-ty

Name

1 1 1 1 1 2 1 4 4 2

Lever Shaft Lever Ring Bracket Bushing Lever Washer Bolt Washer

226

Fig. 46.5. Upper link 227

Group 46. Remote-cylinder hydraulic system Subgroup 4606. Upper link Fig.No

Pos.No

46.5

1 2 3 4 5 6 7 8 9 10 11

Assembly unit or part number 1220-4606042 61.05.000 61.10.001-02 40-4211082 2822-4606050 1220-4606043 2822-4606041 10 10 1220-4606044 61.02.003 61.03.200-01

Q-ty 1 1 1 1 1 1 1 1 1 1 1

228

Name Clip Chock Pin Blind plug Pipe Spring Sliding block Screw Nut Lock nut Screw

Fig. 46.6. Lifting rod

229

Group 46. Remote-cylinder hydraulic system Subgroup 4606. Lifting rod Fig.No

Pos.No

46.6 1 2 3 4

Assembly unit or part number 1220-4606150 1220-4606160 61.02.001 61.02.003 70-4605100

Q-ty 1 1 1 1 1

230

Name Lifting rod Screw Stabilizer Lock nut Yoke

Fig. 46.7 . Hydraulic units and fittings 231

Group 46. Hydraulic system Subgroup 4607. Hydraulic units and fittings Fig.No

Pos.No

46.7

Assembly unit or part number 1221-4600010 1221-4600015 1221-4607125 85-4607034 80-4607120 100-4607140-01 680-4607140-02 80-4607380 80-4607455 036.50 .10 or HP10-3MX0041AO

Q-ty

1 1 1 3 1 1 1 1 2 1 1 1 2 1 1 2 2 1 1 1 3

Hydraulic system Hydraulic system housing Pipe Union body High pressure hose 16 2 armoured.

High pressure hose 10 1 armoured.

High pressure hose 10 1 armoured Pipe Bolt Left housing Coupling Clamp -21 or Clamp "NORMA" TORRO 16-25/9-C6W Clamp -31 or "NORMA" TORRO 2540/9-C6W Hose Bolt Hose Clamp Clamp Union body Bracket Bracket Washer Bracket Union body Bracket Plate Joke Bushing Plate Plate Bracket Bracket Gasket Plate

2

Washer

59 60 62 63 64 65

3 1 2 1 2 1

66

4

68 69 71

5 3 3

Bolt 8-6g 40.88.35.019 GOST 7795-70 Bolt 8-6g 45.88.35.019 GOST 7795-70 Bolt 8-6g 25.88.35.019 GOST 7796-70 Bolt 8-6g 35.88.35.019 GOST 7796-70 Bolt 10-6g 25.88.35.019 GOST 7796-70 Bolt 10-6g 30.88.35.019 GOST 7796-70 Bolt 14 1,5-6g 45.88.35.019 GOST 779670 Nut 8-6 .6.019 GOST 5915-70 Nut 10-6 .6.019 GOST 5915-70 Washer 8.01.019 GOST 11371-78

1 2 3 4 5 7 12 14 19

1 1 1 1 1 2 2 1 1 5 5

Name

21

2

22

2

25 26 27 28 29 30 31 32 35 36 38 39 41 42 44 45 46 47 51 52 53 54

1221-4607011 40-4607037 80-4607012 80-4607013 80-4607013-01 80-4607016 80-4607014 80 -4607209 40-4607033- or 85-4607431 1221-4607070 1321-3407022 70-3407146 70-3407163-01 70-3506027 70-4607156 70-4607168 70-4607178 50-4607137 50-4608049 40-460702940-4607038- or 1/2

24

232

Fig. 46.7 . Hydraulic units and fittings 233

Group 46. Hydraulic system Subgroup 4607. Hydraulic units and fittings Fig.No 46.7

Pos.No

Assembly unit or part number

Q-ty

72

1

79

1

80

1

82 83

7 3 036.50 .20 or 10-4 0041 0

6

Name Washer 10.01.019 GOST 11371-78 Ring 021-024-19-2-2 GOST 18829-73/GOST 9833-73 Ring 027-032-30-1-4 GOST 18829-73/GOST 9833-73 Washer 8 OST 37.001.115-75 Washer 10 OST 37.001.115-75 Right housing Attaching plug

Optional equipment (upon request) Fig.No Pos.No Assembly unit or part number 46.7 9 680-4607140-06 37 85-4607511 53 40-460702956 .036.02.002 59 62 68 82

Q-ty

Name

4 2 2 4 2 4 2 6

High pressure hose Ø 10 1 armoured.

Bracket Plate Through adapter Bolt 8-6g 40.88.35.019 GOST 7795-70 Bolt 8-6g 25.88.35.019 GOST 7796-70 Nut 8-6 .6.019 GOST 5915-70 Washer 8 OST 37.001.115-74

234

)

Fig. 46.7 . Hydraulic units and fittings 235

Group 46. Hydraulic system Subgroup 4607. Hydraulic units and fittings Fig.No

Pos.No

46.7 1 2 3 8 9 10 11 13 16 17 19 20 21 22 23 25 26 28 30 32

35 37 39 45 47 48 49 50 53 55 56 57 58 59 61 63 64 67 68 70 73 75 76

Assembly unit or part number 1221-4600015 85-4604010 85-4604030 85-4604040 85-4607025 80-4607030 80-4607040-04 85-4607045 85-460706085-4607080952-4607080 85-4607100 85-4607105 80-460707580-4607260 80-4607260-01 80-4607375 80-4607380 85-4608010 61-030- 1 32 -3 or 32 -3 or 32 -3 or 32 -3 036.50 .10 or HP10-3MXA0 .036.12.010

36-102205440-4607032 40-4607033- -01 or 24 40-4607037 40-4607038- -01 or 1/2 50-3401092 50-4604044 50-4604046 50-460802750-4607031 50-460703270-460709650-4607097 50-4607099 70-3401093 70-4604037 70-4607144 70-4608033 80-4608019 80-4607063

Q-ty

Name

1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 3

Hydraulic system Pump drive Yoke Disengaging lever Pipe Bracket Bracket Pipe Pipe Pipe Union body Pipe Pipe Pipe Rod Rod Pipe Pipe Hydraulic system housing Pin

1

Gear-type pump

4 4 4 2 1 6

Left housing Coupling Blind plug Clamp -31 or "NORMA" TORRO 2540/9-C6W Gasket Clamp bolt

6

Washer

3

Bolt

14

Washer

1 1 1 1 1 1 1 4 1 3 1 12 3 1 1

Washer Plate Yoke bolt Plug Bolt Bracket Tube Gasket Cover Lever tip Gasket Washer Gasket Cover Hose

236

Fig. 46.7 . Hydraulic units and fittings 237

Group 46. Hydraulic system Subgroup 4607. Hydraulic units and fittings Fig.No

Pos.No

46.7

77 78 82 86 88 91 94 95 96 97 98 99 100 102 103 104 106 108 109 111 112 114

Assembly unit or part number 80-4607086 80-4607088 85-3407101 85-4607432 85-4608021 1221-1802091

Q-ty

Name

3 6 2 1 2 2 2 3 18 3 1 1 4 3 1 2 2 6 5 3 2 1

Lever Pin Tube Bracket Plug Thread plug Bolt 8-6g 16.88.35.019 GOST 7796-70 Bolt 8-6g 20.88.35.019 GOST 7796-70 Bolt 8-6g 25.88.35.019 GOST 7796-70 Bolt 8-6g 30.88.35.019 GOST 7796-70 Bolt 8-6g 35.88.35.019 GOST 7796-70 Bolt 8-6g 45.88.35.019 GOST 7795-70 Bolt 8-6g 65.88.35.019 GOST 7796-70 Bolt 10-6g 20.88.35.019 GOST 7796-70 Bolt 10-6g 30.88.35.019 GOST 7796-70 Bolt 10-6g 40.88.35.019 GOST 7796-70 Bolt 12-6g 35.88.35.019 GOST 7796-70 Nut 8-6 .6.019 GOST 5915-70 Nut 10-6 .6.019 GOST 5915-70 Stud 10 3 /6g 20.66.019 GOST 22034-76 Stud 10 3 /6g 35.66.019 GOST 22034-76 Ring 013-017-25-1-4 GOST 18829-73/GOST 9833-73 Ring 017-022-30-1-4 GOST 18829-73/GOST 9833-73 Ring 021-025-25-1-4 GOST 18829-73/GOST 9833-73 Ring 035-040-30-1-4 GOST 18829-73/GOST 9833-73 Forelock 3,2 18.019 GOST 397-79 Washer 8 OST 37.001.115-75 Washer 10 OST 37.001.115-75 Washer 12 OST 37.001.115-75 Distributor RS-213 Mita Wire 1,0GOST 3282-74 (250 mm) Right housing (packed into SPTA kit) Attaching plug

115

5

116

2

117

1

121 123 124 125 126 127

12 32 11 2 1 1 036.50 .20 or 10-4 0041 0

6

238

Fig. 46.7 . Hydraulic units and fittings 239

Fig. 46.7 . Hydraulic units and fittings

Group 46. Hydraulic system 240

Subgroup 4607. Hydraulic system 1221-4600010 Fig.No Pos.No Designation 46.7 1221-4600010 46.7 1 1221-4600015 3 85-4607034 4 3022-4607120 5 1221-4607125 7 952-4607140-04 8 80-4607380 10 80-4607455 036.50 .10 or 12 10-3 0041 0 13 100-4607140-01 15 16 17 80-3407720 18 1221-4607011 20 80-4607012 21 80-4607013 22 80-4607013-01 25 18-051 26 40-4607037 27 80-4607017 29 1221-4607070 30 85-4607431 31 70-4607156 32 70-4607168 34 50-4607137 40-4607033- or 35 24 36 50-4608049 37 40-460702940-4607038- or 38 1/2 40 70-1405112 41 70-3407146 43 70-3506027 44 80-3723045-01 48 51 55 56 62 64 68 036.50 .20 or 10-4 0041 0 or

Q-ty 1 1 1 1 1 1 1 1

2 2 2 1 1 1 1 2 3 1 2 1 1 1 2 1

Name Hydraulic system Hydraulic system housing Union body Three-way pipe Pipe High pressure hose 16 2 armoured Pipe Bolt Left housing Coupling High pressure hose 10 1 armoured Clamp -21 or "NORMA" TORRO 16-25/9-C6W Clamp -31 or "NORMA" TORRO 25-40/9-C6W Oil pipeline Hose Hose Clamp Clamp Bolt Bolt Bracket Union body Bracket Plate Plate Bracket

2

Washer

1 3

Gasket Plate

2

Washer

1 1 1 4 1 2 1 4 1 1 1

Clamp Plate Bushing Collar Bolt 8-6g 45.88.35.019 GOST 7795-70 Bolt 8-6g 35.88.35.019 GOST 7796-70 Bolt 12-6g 30.88.35.019 GOST 7796-70 Bolt 14 1,5-6g 45.88.35.019 GOST 7796-70 Ring 027-032-30-1-4 GOST 18829-73/9833-73 Washer 8.01.019 GOST 11371-78 Washer 10 OST 37.001.115-75 Right housing (packed into SPTA kit) Attaching plug

3

6

Group 46. Hydraulic system Subgroup 4607. Hydraulic system 1221-4600010 241

Fig.No Pos.No Designation 46.7 72 14 46.7 73 74 822-4801190 75 1221-4607101 76 1221-4607102 77 1221-4607103 78

Q-ty 6 6 2 2 1 1

1221-4607104

1

Name Washer Clamp with worm thread 12-22 Oil pipeline Union body Tube Hose10x18,5-1,6 GOST10362-76 L=(220±5) mm Tube Hose10x18,5-1,6 GOST10362-76 L=(850±5) mm Tube Hose10x18,5-1,6 GOST10362-76 L=(1920±5) mm

Optional equipment (upon request) Fig.No Pos.No Assembly unit or part number 46.7 24 680-4607140-06 46.7 28 .036.02.002 37 40-460702945 85-4607511 47 8-6g 40.88.35.019 69 58 66

Q-ty

Name

4 4 2 2 2 4 2 6

High pressure hose 10 1 armoured Through adapter Plate Bracket Bolt GOST 7795-70 Bolt 8-6g 20.88.35.019 GOST 7796-70 Nut 8-6 .6.019 GOST 5915-70 Washer 8 OST 37.001.115-75

242

Fig. 46.7 . Hydraulic units and fittings

243

Group 46. Hydraulic system Subgroup 4607. Hydraulic system housing 1221-4600015 Fig.No Pos.No Designation 46.7 1221-4600015 1 80-4604010 2 85-4604030 3 85-4604040 5 1221-4607030 6 80-4607040-04 8 1221-4607050 9 85-460706010 85-460708012 952-4607080 14 80-4607100 16 680-4607140-04 18 952-4607140 20 1221-4607260 21 1221-4607260-01 23 80 -4607375 25 85-4608010 26 61-030- 1 27 .036.12.010 28 036.50 .10 29 .036.83.040 32 -3 or 32 -3 or 31 32 -3 or 32 -3 32 70-1221 33 35 36-102205437 70-3401093 38 85-3407101 40 70-4604037 41 50-4604044 42 50-4604046 44 40-4607032 45 40-4607033- or 24 46 40-4607037 47 40-4607038- or 1/2 50 50-460703253 50-460709654 50-4607097 55 50-4607099 56 70-4607144 57 80-4607011 59 952-4607061 64 70-4608019 65 85-4608021 66 70-4608033 68 50-460802770 530-4614029 73 .036.04.011 80 81 82

Q-ty 1 1 1 1 1 1 1 1 1 2 1 1 1 1 2 1 1 3 4 4 3

Name Hydraulic system housing Pump drive Yoke Disengaging lever Bracket Bracket Pipe Pipe Pipe Union body Tube High pressure hose 10 1 armoured High pressure hose 16 2 armoured Rod Rod Pipe Hydraulic system housing Pin Blind plug Left housing High pressure hose 10 1 armoured

1

Gear-type pump

1 2 1 3 2 1 1 1 4 6 3

Distributor Clamp -26 or "NORMA" TORRO 25-40/9-C6W Gasket Lever tip Tube Gasket Plate Yoke bolt Clamp bolt Washer Bolt

12

Washer

1 1 4 1 6 1 2 1 2 3 1 4 1 2 4 20

Bracket Tube Gasket Cover Washer Hose Union body Cover Plug Gasket Plug Elbow Mail pipe adapter Bolt 8-6g 16.88.35.019 GOST 7796-70 Bolt 8-6g 20.88.35.019 GOST 7796-70 Bolt 8-6g 25.88.35.019 GOST 7796-70

244

Fig. 46.7 . Hydraulic units and fittings

245

Group 46. Hydraulic system Subgroup 4607. Hydraulic system housing 1221-4600015-02 Fig.No Pos.No Designation 46.7 83 89 90 91 93 95 96 98 99 101 103 104 105 24 106 108 111 114 115 116 120

Q-ty 4 4 1 2 2 4 5 3 2 6 1 1 1 2 1 4 30 12 2 3

Name Bolt 8-6g 30.88.35.019 GOST 7796-70 Bolt 10-6g 20.88.35.019 GOST 7796-70 Bolt 10-6g 30.88.35.019 GOST 7796-70 Bolt 10-6g 40.88.35.019 GOST 7796-70 Bolt 12-6g 35.88.35.019 GOST 7796-70 Nut 8-6 .6.019 GOST 5915-70 Nut 10-6 .6.019 GOST 5915-70 Stud 10 3 /6g 20.66.019 GOST 22034-76 Stud 10 3 /6g 35.66.019 GOST 22034-76 Forelock 3,2 18.019 GOST 397-79 Ring 013-017-25-1-4 GOST 18829-73/9833-73 Ring 017-022-30-1-4 GOST 18829-73/9833-73 Washer Washer 021-025-25-1-4 GOST 18829-73/9833-73 Ring 035-040-30-1-4 GOST 18829-73/9833-73 Washer 8.01.019 GOST 11371-78 Washer 8 OST 37.001.115-75 Washer 10 OST 37.001.115-75 Washer 12 OST 37.001.115-75 Wire 1,0GOST 3282-74 (150 mm)

246

Fig. 46.7 . Hydraulic units and fittings

247

Group 46. Hydraulic system Subgroup 4607. Hydraulic system housing 1221-4600015 Fig.No Pos.No Designation 46.7 1221-4600015 1 80-4604010 2 85-4604030 3 85-4604040 5 1221-4607030 6 80-4607040-04 8 1221-4607050 9 85-460706010 85-460708012 952-4607080 14 80-4607100 16 680-4607140-04 18 952-4607140 20 1221-4607260 21 1221-4607260-01 23 80 -4607375 25 85-4608010 26 61-030- 1 27 .036.12.010 28 036.50 .10 29 .036.83.040 32 -3 or 32 -3 or 31 32 -3 or 32 -3 32 70-1221 33 35 36-102205437 70-3401093 38 85-3407101 40 70-4604037 41 50-4604044 42 50-4604046 44 40-4607032 45 40-4607033- or 24 46 40-4607037 47 40-4607038- or 1/2 50 50-460703253 50-460709654 50-4607097 55 50-4607099 56 70-4607144 57 80-4607011 59 952-4607061 64 70-4608019 65 85-4608021 66 70-4608033 68 50-460802770 530-4614029 73 .036.04.011 80 81 82

Q-ty 1 1 1 1 1 1 1 1 1 2 1 1 1 1 2 1 1 3 4 4 3

Name Hydraulic system housing Pump drive Yoke Disengaging lever Bracket Bracket Pipe Pipe Pipe Union body Tube High pressure hose 10 1 armoured High pressure hose 16 2 armoured Rod Rod Pipe Hydraulic system housing Pin Blind plug Left housing High pressure hose 10 1 armoured

1

Gear-type pump

1 2 1 3 2 1 1 1 4 6 3

Distributor Clamp -26 or "NORMA" TORRO 25-40/9-C6W Gasket Lever tip Tube Gasket Plate Yoke bolt Clamp bolt Washer Bolt

12

Washer

1 1 4 1 6 1 2 1 2 3 1 4 1 2 4 20

Bracket Tube Gasket Cover Washer Hose Union body Cover Plug Gasket Plug Elbow Mail pipe adapter Bolt 8-6g 16.88.35.019 GOST 7796-70 Bolt 8-6g 20.88.35.019 GOST 7796-70 Bolt 8-6g 25.88.35.019 GOST 7796-70

248

Fig. 46.7 . Hydraulic units and fittings

249

Group 46. Hydraulic system Subgroup 4607. Hydraulic system housing 1221-4600015-02 Fig.No Pos.No Designation 46.7 83 89 90 91 93 95 96 98 99 101 103 104 105 24 106 108 111 114 115 116 120

Q-ty 4 4 1 2 2 4 5 3 2 6 1 1 1 2 1 4 30 12 2 3

Name Bolt 8-6g 30.88.35.019 GOST 7796-70 Bolt 10-6g 20.88.35.019 GOST 7796-70 Bolt 10-6g 30.88.35.019 GOST 7796-70 Bolt 10-6g 40.88.35.019 GOST 7796-70 Bolt 12-6g 35.88.35.019 GOST 7796-70 Nut 8-6 .6.019 GOST 5915-70 Nut 10-6 .6.019 GOST 5915-70 Stud 10 3 /6g 20.66.019 GOST 22034-76 Stud 10 3 /6g 35.66.019 GOST 22034-76 Forelock 3,2 18.019 GOST 397-79 Ring 013-017-25-1-4 GOST 18829-73/9833-73 Ring 017-022-30-1-4 GOST 18829-73/9833-73 Washer Washer 021-025-25-1-4 GOST 18829-73/9833-73 Ring 035-040-30-1-4 GOST 18829-73/9833-73 Washer 8.01.019 GOST 11371-78 Washer 8 OST 37.001.115-75 Washer 10 OST 37.001.115-75 Washer 12 OST 37.001.115-75 Wire 1,0GOST 3282-74 (150 mm)

250

Fig. 46.8. Hydraulic distributor valve control (

70, RS 213 Mita)

251

Group 46. Remote-cylinder hydraulic system Subgroup 4607. Hydraulic distributor valve control 70, RS 213 Mita) Fig.No

Pos.No

Assembly unit or part number

46.8 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26

3,2x18 70-4607144 C80-4607086 M8 A20-213A A61-030-A1 80-4607250 50-4607078-A 80-4607230 M12 30 12 M10 35 10 18 85-4607017 50-4607079-A1 8x30 C80-4607080-01 32 70-3401093 C80-4607090 C80-4607080 80-4607220 C80-4607261 1221-4607261 C80-4607261-01 1221-4607261-01 C80-4607088

Q-ty -70 6 9 3 3 3 1 4 1 2 2 1 1 3 1 2 2 1 1 3 1 1 1 2 1 -

252

Name RS 12 12 3 3 3 3 1 4 1 2 2 1 1 3 1 2 2 1 1 3 1 1 1 2 1 6

Forelock Washer Lever Nut Yoke Pin Shaft Bushing Shaft Bolt Washer Bolt Washer Ring Bracket Bushing Pin Lever Ring Lever tip Lever Lever Shaft Rod Rod Rod Rod Pin

Fig. 46.9. Housing and filter of hydraulic system

253

Group 46. Hydraulic system Subgroup 4607. Housing and filter of hydraulic system Fig.No Pos.No Designation 46.9 85-4608010 85-4608090 A28.04.10.000 1 A28.04.20.000-A1 2 635-1 or 3 3-25 4 5 8.20.004 6 A28.04.10.001 7 8.20.002 8 8.20.005 9 10 A28.04.00.001 11 12 24 or 40-460703313 85-4608021 14 85-4608089 15 85-4607034 16 85-4608057 17 50-4608059 18 50-4608063 19 50-4608062 20 11/4” 21 A61-C06-A3 22 85-4608091 23 50-1002450 24 25 36-1101067 26 50-3407069 29 85-460808630 85-460808731 85-460808833 34 35 36 37 38 85-4608022 39 40 85-4608018 41 42 43 85-4608025 44 80-4608073 45 85-460803146 85-4608016-A

Q-ty 1 1 1 1 2

Name Hydraulic system housing (1-49, 53, 54) Valve (22-26) Valve (4-9) Housing Ring 042-050-46-2-4 GOST 18829-73/GOST 9833-73

1

Filtering element Regotmas 635-1

1 1 1 1 1 2 1 4 1 1 1 1 1 1 1 2 1 1 1 1 2 2 1 1 1 1 6 3 1 5 30 1 1 1 1 23 1 1 1 1

Screw 6-6g 40.58.019 GOST 17475-80 Valve Valve housing Spring Washer Nut 6-6 .6.019 GOST 5915-70 Retainer Nut 6-6 .6.019 GOST 5915-70 Washer Plug Gasket Union body Spring Breather plug Filter Breather washer Plug Filter Valve Chain Ring 011-015-25-2-4 GOST 18829-73/GOST 9833-73 Ring Chock Seal Indicator Housing Bolt 20 DIN EN 1665-98 Stud 10 3 /6g 20.66.019 GOST 22034-76 Bolt 8-6g 80.88.35.019 GOST 7795-70 Bolt 8-6g 25.88.35.019 GOST 7796-70 Washer 8 OST 37.001.115-75 Cover Ring 130-135-30-1-4 GOST 18829-73/GOST 9833-73 Sleeve Ring 027-032-30-1-4 GOST 18829-73/GOST 9833-73 Bolt 8-6g 20.88.35.019 GOST 7796-70 Cover Bracket Gasket Hydraulic system housing

254

Fig. 46.9. Housing and filter of hydraulic system

255

Group 46. Hydraulic system Subgroup 4607. Housing and filter of hydraulic system Fig.No Pos.No Designation 46.9 1/2 or 47 40-4607038-A 48 70-4607163 49 50 51 52 53

50-4608049-01 70-4608033 70-4608019

Q-ty

Name

1

Washer

1 2 2 2 4 1 1 1

Plug Stud 10 3 /6g 35.66.019 GOST 22034-76 Nut 10-6 .6.019 GOST 5915-70 Bolt 10-6g 40.88.35.019 GOST 7796-70 Washer 10 OST 37.001.115-75 Gasket Gasket Cover

256

Fig. 46.10. Fast coupling

257

Group 46. Hydraulic system Subgroup 036.50 . Fast coupling Fig.No Pos.No Designation 46.10 036.50 .20 or 1 10-4 0041 0 or 036.50 .10 or 2 10-3 0041 0 or

Q-ty 1 1

Name Right housing Attaching plug Left housing Coupling

258

Fig. 46.11. Hydraulic distributor valve

70

259

Subgroup

Group 46. Hydraulic system 70. Hydraulic distributor valve

Fig.No Pos.No Designation 46.11 70-888-000-MMM20 2 70-8-0-M 70- 2 70-20 70-050 70-080 1 70-090 2 16.3.10.10 3 70-026 4 70-018-01 5 70-033 6 8 9 10 11 12 13 14 15 16 17 18

70-024 70-027 70-023 70-031 70-042

70-032 70-011 70-013

Hydraulic distributor valve

3 1 1 1 1 1 1 1 1 1 3

Distributor section (1-25, 45, 52, 53) Cover ( 70-080, 26, 47, 50) Cover ( 70-050, 46, 48, 49) Safety cock (27-44) Blind plug (27, 48, 54, 55) Pipe Spring Screw Disk Spring Ball 5,556-100 GOST 3722-81 Ring 017-020-19-2-2 GOST 18829-73/GOST 9833-73 Plug Spring Regulating valve Ring Plate Pin 6 18 OST 37.001.163-75 Forelock 2 40.019 GOST 397-79 Ring Housing Spool Ring 030-034-25-2-2 GOST 18829-73/GOST 9833-73 Ball 9,525-100 GOST 3722-81 Cage Ring 016-020-25-2-2 GOST 18829-73/GOST9833-73 Ring 009-012-19-1-4 GOST 18829-73/GOST 9833-73 Threaded bushing Disk Cover Ring 018-021-19-2-4 GOST18829-73/GOST9833-73 Ring Spring Valve Grinder Housing Ring 016-020-25-2-4 GOST 18829-73/GOST 9833-73 Spring Screw Union body Nut Cap Washer 6.01.019 GOST 11371-78 Ring 013-016-19-2-2 GOST18829-73/GOST9833-73 Ring Needle

1 1 1 1 2 2 3 1 1 1 1

70-014

1 1

22

1

23

1

24 25 26

70-016 70-018 70-012

27 28 29 30 31 32 33 34 35 36 37 38 39

1 1 1 1 1 1

-16/3 -103 70-059 70-053 70-076 70-057

40 41 42

1 1 1 2

70-058 70-4609037 70-05270-054 70-051

1 1 1 1 1 1 3

70-058-02 -16/3 -101

70

Name

1

1

19 20 21

Q-ty

1 1

260

Fig. 46.11. Hydraulic distributor valve

70

Group 46. Hydraulic system 261

Subgroup Fig.No Pos.No Designation 46.11 43 44 45 46

70-058-01 70-070 70-012-01

70. Hydraulic distributor valve Q-ty 1 1 1 1

47

2

48

2

49

70-036

1

50

2

52 53 54 55 56 57 58 59

4 4 1 1 4 8 8 1

60

70-081 70-058 70-037-02

70-038

2

70

Name Ring 028-032-25-2-2 GOST18829-73/GOST9833-73 Ring Bracket Cover Ring 036-040-25-2-2 GOST 18829-73/GOST 9833-73 Ring 021-024-19-2-4 GOST18829-73/GOST9833-73 Plug Ring 060-066-36-2-2 GOST 18829-73/GOST9833-73 or Ring 60,00-3,50 SIMRIT 72 NBR 872 Screw 5-6g 12.58.019 GOST 17473-80 Washer 5 OST 37.001.115-75 Blind plug Ring Stud Nut 10-6 .6.019 GOST 5915-70 Washer 10 OST 37.001.115-75 Branded instruction plate Non-threaded fastener 2 6.01.10 .05 GOST 1029980

262

Fig. 46.12. Hydraulic hoist distributor

263

Group 46. Hydraulic system Subgroup 4634. Hydraulic hoist distributor Fig.No Pos.No Designation 46.12 820-4634010 820-4634020A 1 820-4634021 2 3 4 5 6 7

2 A61-072 820-4634017 820-4634025A 820-4634025-A-01

8 9

820-4634022

80-4614058 820-4634013-

820-4634039 820-4634038

1 1 1 1 1 2 2 1 1 1 1

820-4634036 820-46340111

1 1 2

24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39

2 2

21 22 23

1 1 1 2 2 2

10 11 12 13 14 15 16 17 18 19 20

Q-ty 1 1 1

820-4634014 820-4634018-

75-082 820-4634033 820-4634012 820-4634024 820-4634026820-4634019 820-4634037 820-4634028 820-4634029 820-4634027 820-4634016

1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1

Name Distributor Valve (25-30) Plug Ring 017-020-19-2-6 GOST 18829-73/9833-73 or Ring 17,00-2,00 SIMRIT 72 NBR 872 Spring Ball 14,288-60 GOST 3722-81 Grinder Ring Ring Ring 068-072-25-2-6 GOST 18829-73/9833-73 or Ring 65,00-2,50 SIMRIT 72 NBR 872 Plug Ring 013-016-19-2-6 GOST 18829-73/9833-73 or Ring 13,00-2,00 SIMRIT 72 NBR 872 Ball 6,350-100 GOST 3722-81 Spring Plug 1/8" 12.019 TU 23.1.506-91 Cover Wiper seal 2-10 GOST 24811-81 Bolt 6-6g 16.88.35.019 GOST 7798-70 Washer 6 OST 37.001.115-75 Bushing Ring 010-014-25-2-2 GOST 18829-73/9833-73 Lifter Ring 021-024-19-2-6 GOST 18829-73/9833-73 or Ring 21,00-2,00 SIMRIT 72 NBR 872 Lock ring Housing Ring 064-068-25-2-6 GOST 18829-73/9833-73 or Ring 63,00-2,50 SIMRIT 72 NBR 872 Ring Valve Grinder Pin 2.3 14 GOST 3128-70 Ball 5,556-60 GOST 3722-81 Spring Thrust Spool Spring Valve Plug Thrust Spring Thrust Pin Spring

264

Fig. 46.13. Hydraulic hoist control

265

Group 46. Hydraulic system Subgroup 4635. Hydraulic hoist control Fig.No Pos.No Designation 46.13 820-4635020A 820-4635060 820-46350901 820-4635025 2 3 820-46350954 5 6 7 80B-1108347 8 80B-1108317 9 10 11 820-463510012 A13.11.000 13 80-4616070 14 820-4635082 15 16 17 80-1108028 18 80-1108178 Morse 900 or 19 23.588.1.1.2.00.01-01 20 21 22 820-4635080 23 820-4635075 24 25 820-4635034 26 820-463503327 28 820-4635046 29 820-4635070 30 820-4635069 31 820-4635030 32 820-463501533 820-4635016-B 34 820-463503235 820-4635049 36 820-4635063 37 820-4635065 38 39 820-4635024 40 820-4635023 41 820-4635022 42 820-463502643 820-463504444 820-463504345 46 47

Q-ty 1 1 1 1 1 1 4 4 4 2 4 8 4 2 2 1 1 1 7 2 2

Name Force sensor (38-42, 44, 49) Adder stage (16, 29, 30, 36, 37) Bracket (3, 6,7, 11, 17) Link Forelock 3,2 25.019 GOST 397-79 Bracket Washer 8 OST 37.001.115-75 Bolt 8-6g 20.88.35.019 GOST 7796-70 Nut 14 1,5-6 .6.019 GOST 5915-70 Disk spring Threaded rivet nut Nut 6-6 .6.019 GOST 5915-70 Washer 6.01.019 GOST 6958-78 Lever Handle Screw Thrust Nut 6-6H.019 TU 23.1.505-91 Forelock 3,2 18.019 GOST 397-79 Washer Friction washer

2

Rope

6 6 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 4 1 4 4 2

Bolt 6-6g 16.88.35.019 GOST 7798-70 Washer 6 OST 37.001.115-75 Lever Lever Ring 011-015-25-2-4 GOST 18829-73/9833-73 Shaft Bushing Ring 019-023-25-2-4 GOST 18829-73/9833-73 Joke Lever Detent Link Lever Shaft Bushing Forelock Spring Bracket Forelock 4 22.019 GOST 397-79 Nut Washer Spring Bushing Gasket Cover Washer 12 OST 37.001.115-75 Bolt 12-6g 30.88.35.019 GOST 7796-70 Ring 22 GOST 13940-86

266

Fig. 46.13. Hydraulic hoist control

267

Group 46. Hydraulic system Subgroup 4635. Hydraulic hoist control Fig.No Pos.No Designation 46.13 48 820-4635018 49 820-4635021 50 820-4635019 51 820-4635048 52

Q-ty 1 1 1 1 2

Name Pin Push rod Clip Rod Ring 027-032-30-1-4 GOST 18829-73/9833-73

268

Fig. 46.14. Hydraulic hoist

269

Group 46. Hydraulic system Subgroup 4635. Hydraulic hoist Fig.No Pos.No Designation 46.14 1221-4635010-03 1 2 3 4 5 6 40-4605023-A2 7 1221-4635013 8 1221-4635016 9 1221-4635014 10 11 820-4635091 BABSL 60-72-7 SIMRIT 12 72 NBR 902 13 820-4635115-01 14 820-4635083 15 16 1221-4635011 17 18 19 820-4634010 20 1221-4635012 21 820-4635085 22 23 24 820-4635125 25 820-4635039 26 820-4635088 27 A61.05.005 28 A61.05.004 29 30 80-4608021 31 M80-4616011 32 33 34 A61.10.001 35 3/8" 1221 -4625010 or 36 1221-4625010 37 820-4635084

Q-ty 1 2 2 2 4 4 2 1 2 1 2 2

Name Hydraulic hoist Washer 16 OST 37.001.115-75 Bolt 16-6g 75.88.35.019 GOST 7795-70 Forelock 5 36.019 GOST 397-79 Washer 12 OST 37.001.115-75 Bolt 12-6g 30.88.35.019 GOST 7796-70 Washer Left lever Pin Shaft Ring 079-085-36-2-2 GOST 18829-73/9833-73 Sleeve

2

Collar

2 2 2 1 14 2 1 1 1 2 10 1 1 4 1 1 1 1 4 4 4 1 1

Hose Union body Ring 012-015-19-2-4 GOST 18829-73/9833-73 Housing Washer 8 OST 37.001.115-75 Bolt 8-6g 40.88.35.019 GOST 7795-70 Distributor Right lever Bracket Bolt 8-6g 30.88.35.019 GOST 7796-70 Bolt 8-6g 20.88.35.019 GOST 7796-70 Cover Gasket Bushing Chock Ring Ring 027-032-30-1-4 GOST 18829-73/9833-73 Blind plug Stud Washer 20 OST 37.001.115-75 Nut 20-6 .6.019 GOST 5915-70 Pin Plug

2

Cylinder

2

Elbow

270

Fig. 52.1. Front screen wiper

271

Group 52. Screen wipers Subgroup 192.000. Front screen wiper Fig.No

Pos.No

52.1 1 2 3 4 5 6

Assembly unit or part number 192.000.010 787.000.030 192.090.010 6 6 16 70-1602037

Q-ty 1 1 1 4 2 4 1

272

Name Windscreen wiper (1, 2) Lever with brush Power gear group Washer Washer Bolt Bushing

Fig. 52.2. Rear screen wiper

273

Group 52. Screen wipers Subgroup 5205. Rear screen wiper Fig.No

Pos.No

52.2 1 2 3 4 5

Assembly unit or part number 240 240-5205300 31.5205400-01 240-5205015 230-5205440 240-5205712

Q-ty 1 1 1 1 1 1

274

Name Windscreen wiper (1-5) Lever Brush Reduction gear unit Switch Housing

Fig. 52.3 Screen washer installation

275

Group 52. Screen wipers Subgroup 5208. Screen washer installation Fig.No

Pos.No

52.3 1 2 4 5 6 7 8 10 11 13 17 18

Assembly unit or part number 1221.4 -5208010 70-3723042-01 80-3723045 82 -5208001 320-5208002 80-52080116-6g 16.88.35.019 6-6g 12.58.019 6-6 .6.019 6.01.019 6 5208.10 122.5208 000 -35

Q-ty 1 1 2 1 1 1 1 2 1 2 3 1 1

276

Name Screen washer installation Bushing Collar Bracket Pipe Flange Bolt GOST 7798-70 Screw GOST 17473-80 Nut GOST 5915-70 Washer GOST 11371-78 Washer OST 37.001.115-75 Fuel jet 1202.5208500-02 or .306549.001 Electrical washer TU 37.459.176-94

Fig. 67.1. Tractor cabin

277

Group 67. Tractor cabin Subgroup 6700. Tractor cabin Fig.No

Pos.No

67.1

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44

*

Assembly unit or part number 1221-6700010 80-6708210 80-6708900-01 3,2x18 21.054 M6 80-6708225 6 M6x16 A30.04.017 80-6700031- -01 85-6703056 80-6703012- 1 or 80-6703012A37.08.043 or A37.08.043-01 M8 25 8 8 80-3805030 80-67030111- 1 or 80-6703011180-6700018 80-6703105 M8 80-8201050 80-8201106A30.04.017-02 80-8201107 M8x16 A30.04.017-01 A37.08.017 80-670701080 -6707025- or 80-6707025- 4 1221-6700020 80-6708211- 1 or 80-670821180-6708215 A37.08.043-05 * 80-6700021-01 549-1305044 80-6707082 M6 12 6 80-6707075 A37.09.010 80-6707080 M6 20 M6 50

Q-ty

Name

1 1 2 10 4 22 6 24 32 10 1 1 2

Cabin assembly Rear frame (32-35) Glass assembly (13, 14, 19, 24, 45, 47-50) Forelock Air hoist Nut Bracket Washer Bolt Cap Right bracket Insert Glass

2 1 4 34 34 2 1

Seal Seal Bolt Washer Washer Bracket Glass

1 1 6 2 2 4 4 8 13 1 2

Seal L=4200 mm Handrail Nut Mirror Pipe Cap Washer Bolt Cap Seal Hinge

1

Roof assembly

1 1

Cabin (fabricated frame) Glass

1 1 1 2 1 2 14 1 1 1 1 1

Frame Seal Seal Gasket Facing Screw Washer Bracket Latch Handrail Screw Screw

Substitution for 80-6700026-02 is permitted

278

Fig. 67.1. Tractor cabin

279

Group 67. Tractor cabin Subgroup 6700. Tractor cabin Fig.No

Pos.No

67.1

45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89

Assembly unit or part number 80-6708903 8x65 80-6708902 M8 30 -202 1221-6708901- 1 or 1221-6708901A37.05.025 M6 25 A37.05.021 80-840402080-8404020- -01 80-8404014-A M6 25 85-8404040-A 80-8404032 80-8404031M6 16 80-8404034-A 80-6708975 80-6708904 37.01.041 80-6708961 M8x20 80-840401180-8404011- -01 80-8404013-A 80-6708970 M12x25 12 M12 12 80-6700029 16 1221-6700035 1221-6700035-01 80-6700163 80-6700160 80-6703105 130-5001364-B M16 4x36 M20 75 20 1221-6702300 1221-6702300-01 M16x45 16 85-6702068 80-6700031-

Q-ty

Name

4 4 4 10 2

Bushing Pin Hinge Bolt Seal Glass

2 1 2 1 1 1 2 10 2 4 2 6 2 2 2 2 4 22 1 1 2 2 6 6 6 6 4 12 1 1 4 4 1 4 4 4 4 4 1 1 6 6 2 1

280

Detent Screw Bracket Wing flap (left) Wing flap (right) Seal Bolt Splash guard Plate Spring Screw Plate Screw Gasket Bushing Washer Bolt Left wing Right wing Seal Handle Bolt Washer Nut Washer Bolt Washer Left support Right support Cage Vibroisolator Handrail Cushion Nut Forelock Bolt Washer Right bracket Left bracket Bolt Washer Bracket Bracket

Fig. 67.1. Tractor cabin

281

Group 67. Tractor cabin Subgroup 6700. Tractor cabin Fig.No

Pos.No

67.1

90 91 92 93 94

Assembly unit or part number M12x35 80-6708209 1221-670703770-6708189 80-6707013

Q-ty

Name

8 2 1 2 2

Bolt Handle Insert Axis Hinge

282

Fig.67.2. Cabin floor

283

Group 67. Tractor cabin Subgroup 6702. Cabin floor Fig.No Pos.No Designation 67.2 1 80-6700300 2 80-6702330 3 80-6702328-01 4 85-6700330 5 85-6700340 6 6.01.019 GOST 6858-78 7 OST 37.001.115-75 8 8-6g 25.88.35.019 GOST 7796-70 9 6702.337 1221-6700036 or 10 85-670003611 1-4 25.019 GOST 1144-80 12 37.10.031 13 80-6702111 14 1221 -6700050 15 80-8100100 16 1221-6700065 17 80-6700205 18 1221-6700050 19 1221-6700060 20 85-670004021 80-670219022 85-670239023 6-6g 16.88.35.019 GOST 7798-70 24 70-6702111 25 80-670246826 80-670231527 6.01.019 GOST 11371-78 28 8-6g 16.88.35.019 GOST 7796-70 29 80-6702310 30 80-6702348 80-6702348-01 31 6-6g 12.58.019 GOST 17473-80 32 80-6702085 80-6702243 or 33 80 -6702270 34 80-6702820 35 80-670037036 80-6702328 37 80-6702320 38 8-6g 40.88.35.019 GOST 7795-70 39 80-6700320 40 6-6gx20.88.35.019 GOST 7798-70 41 80-6700085

284

Q-ty 1 1 1 1 1 22 20 14 1

Name Panel Lining Side member Panel Panel Washer Washer Bolt Floor mat

1

Cover

28 28 1 1 1 1 1 1 1 1 1 1 19 2 1 1 10 4 1 1 1 4 1 1 1 1 1 1 1 2 1 5 1

Male screw Threaded rivet nut Clamp Lining installation Panel Lining Lining Lining Lining Control panel Cover Cover Bolt Elbow Gasket Panel Washer Bolt Floor piece Left clamp Right clamp Screw Cover Case (rubber) Case (vinyl-leather) Lining Housing Side member Lining Bolt Panel Bolt Bracket

Fig. 67.3. Panels

285

Group 67. Tractor cabin Subgroup 6700. Panels Fig.No

Pos.No

67.3

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19

Assembly unit or part number 6 M6 16 80-6702328 80-6702320 M8x40 8 M6 25 6 80-6700320 85-6700340 80-6700300 85-6700330 80-6702328-01 80-6702330 80-6702310 80-670231580-6702332 80-6702333- 2 80-6702 46980-6702 468-

Q-ty

Name

24 16 1 1 2 2 8 18 1 1 1 1 1 1 1 1 1 1 1 1

Washer Bolt Lining Side member Bolt Washer Bolt Washer Panel Panel Panel Panel Lining Side member Floor piece Panel Left floor mat Right floor mat Gasket Gasket

286

Fig. 67.4. Cabin doors

287

Group 67. Tractor cabin Subgroup 6708. Cabin doors Fig.No

Pos.No

67.4 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44

Assembly unit or part number 80-670801080-6708010- -01 80-6708013- 1 or 80-6708013A37.08.043-02 80-6708020- -01 8x30 80-6700021 80-670802037.03.022A37.03.012 37.03.022- -01 M8 25 8 8 80-6708014- 1 or 80-6708014A37.08.043-03 1-4x40 M6 35 6 80-6708610 80-6708619 80-6708618 80-6708602 M6 80-6708616 or 80-6708616-01 3,2x18 6 M6 16 80-6708603 1-4x25 80-610530180-6105304- 1 945.025.11.01.00 2x11,8 80-6105302 80-6105305 80-6105303 1-4x16 BM8 25 M8 16 80-610517080-6708812 80-6708812-01 M6x16 80-6105050 80-6105050-01 M6 45 80-6708813

Q-ty 1 1 2 2 1 2 2 1 2 4 2 12 12 12 2

Name Left door (1, 2, 5-7, 9-14) Right door (1-3, 5, 7, 9-14) Glass Seal L=2720mm Door Pin Profile Door Upper hinge Axis Lower hinge Bolt Washer Washer Glass

2 2 2 6 2 4 2 2 2

Seal Male screw Bolt Washer Handrail Bumper Spring Lining Nut

2

Lever

2 6 2 2 2 2 2 2 2 2 2 2 2 4 4 2 1 1 2 1 1 2 2

Forelock Washer Bolt Lining Male screw Button Bushing Cylinder mechanism Pin Spring Handle Lifter Male screw Screw Bolt Latch Cover (left) Cover (right) Screw Lock (left) Lock (right) Screw Bushing

288

Fig. 68.1 Operator seat

289

Group 68. Operator seat Subgroup 6800. Operator seat Fig.No

Pos.No

68.1

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47

Assembly unit or part number 80-6800010 80-6800010-01 «Grammer MSGS/721» 80 -68001108 61.01.014 80 -6801560 80 -6801240 16 70-4803023 80 -680159080 -6801521 80 -6801512 12 16 13 80 -6801033-01 80 -6801508 80 -6801519 80 -6801518 80 -680153010 10 80 -6801581 80 -6801570 22 80 -6801012 80 -6801004-01 80 -6801001 80 -6801003 80 -6801004 80 -6801002 80 -6801507 80 -6801033 80 -6801506 70-6801307 80 -6801023 80 -6801008 3,0-100 80 -6801152 80-6801550 80-6800104 70-680439470-6804391 010-015-30-2-3 80-6800110-01 -154 .6800010 -154 .6800010 20 80 -6801031 20 8 80-6800110 8

Q-ty

Name

1 1 1 1 1 1 1 2 1 1 4 4 8 2 1 2 2 2 6 6 2 1 2 1 1 1 1 1 1 1 2 1 5 1 1 22 1 1 1 4 4 4 1 1 1 11 1 4 15 1 10

Seat Seat Seat Case Handle Base Rope Screw Coupling Frame Thrust Bushing Bearing Washer Axis Foot step Sleeve Spring Washer Nut Pawl Frame Forelock Axis Hook Bracket Axis Hook Spring Quadrant Washer Axis Washer Nut Washer Ball Screw Panel Guide Wire rod Roller Ring Rail Seat Seat Bolt Enhancer Screw Washer Rail Washer

290

Fig. 68.1 Operator seat

291

Group 68. Operator seat Subgroup 6800. Operator seat Fig.No

Pos.No

68.1

48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66

Assembly unit or part number 80-6800120 80-6800103 80-6800102 70-4202431-01 80-6800101 70-6801082 80 -6801150 8 80-6801531 80-6809100-11 80 -6801505 80 -6801002-01 80 -6801507-01 80 -6801526 80 -6801528 80 -6801032 80-6800006 30 80 -6807200

Q-ty

Name

1 1 1 2 1 1 1 1 6 1 1 1 1 4 6 4 20 4 1

Guide Spring Lock Pin Handle Handle Handle Nut Bumper Shock absorber Shaft Spring Quadrant Bushing Axis Roller Button Bolt Bracket

292

Fig. 68.2 Operator seat

293

Group 68. Operator seat Subgroup 6804. Operator seat Fig.No

Pos.No

68.2 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27

Assembly unit or part number 80 -6800000 80 -6804000 80 -6804500 80 -6804003 80 -6804009 80 -6800106 80 -6804015 80 -6805001 80 -6805002 80 -6805500 26-04 80 -6805010 80 -6804040 16 6 6 14 80 -6804001 80 -680401380 -6804011 50-131015880 -6804080 80-6708011 25 70-6708189-01 80 -6804020 80 -6804007 80 -6804005 26-03

Q-ty 1 1 1 1 1 2 2 1 1 1 1 1 1 7 2 2 2 1 2 1 1 1 1 1 1 1 1 1 1

294

Name Seat Seat Case Wire rod Axis Bolt Bushing Cushion Frame Case Profile Base Support Screw Washer Washer Bolt Latch Spring Guide bar Spring Lever Hinge Forelock Axis Panel Cushion Frame Profile

Fig. 68.3 Seat suspension

295

Group 68. Operator seat Subgroup 6801. Seat suspension Fig.No

Pos.No

68.3 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50

Assembly unit or part number 80-6801500 80 -6800108 61.01.014 80 -6801560 80 -6801240 16 70-4803023 80 -680159080 -6801521 80 -6801512 12 16 13 80 -6801033 80 -6801508 80 -6801519 80 -6801518 80 -680153010 10 80 -6801581 80 -6801570 22 80 -6801012 80 -6801004-01 80 -6801001 80 -6801003 80 -6801004 80 -6801002 80 -6801507 80 -6801506 70-6801307 80 -6801023 80 -6801008 3,0-100 80 -6801152 80-6801550 80-6800104 70-680439470-6804391 010-015-30-2-3 80-6800110-01 20 80 -6801031 8 8 8 80-6800110 80-6800120 80-6800103 80-6800102 70-4202431-01 80-6800101

Q-ty

Name

1 1 1 1 1 2 1 1 4 4 8 4 1 2 2 2 6 6 2 1 2 1 1 1 1 1 1 1 1 5 1 1 22 1 1 1 4 4 4 1 15 1 5 19 14 1 1 1 1 2 1

Suspension Case Handle Base Rope Screw Coupling Frame Thrust Bushing Bearing Washer Axis Foot step Sleeve Spring Washer Nut Pawl Frame Forelock Axis Hook Bracket Axis Hook Spring Quadrant Axis Washer Nut Washer Ball Screw Panel Guide Wire rod Roller Ring Rail Bolt Enhancer Nut Washer Washer Rail Guide Spring Lock Pin Handle

296

Fig. 68.3 Seat suspension

297

Group 68. Operator seat Subgroup 6801. Seat suspension Fig.No

Pos.No

68.3

51 52 53 54 55 56 57 58 59 60 61 62 63

Assembly unit or part number 70-6801082 80 -6801150 80-6801531 80-6809100-11 80 -6801505 80 -6801002-01 80 -6801507-01 80 -6801526 80 -6801528 80 -6801032 80-6800006 30 80 -6807200

Q-ty

Name

1 1 6 1 1 1 1 4 6 4 20 4 1

Handle Handle Bumper Shock absorber Shaft Spring Quadrant Bushing Axis Roller Button Bolt Bracket

298

Fig. 68.4 Additional seat

299

Group 68. Operator seat Subgroup 6801. Additional seat Fig.No

Pos.No

68.4

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

Assembly unit or part number 6 6 6 30 1221-6809020 2522-6809012 16 2522-6809030 2522-6809011 2522-6809040 30.04.017 16 37.08.019-01 37.07.011 2522-6809060 2522-6809006 8 16 10 70-6700031 70-6700116 50-3711038

Q-ty

Name

6 6 10 4 1 20 8 2 2 2 2 2 1 1 1 1 6 6 2 2 2 2

Nut Washer Washer Bolt Base Clamp Screw Framework Cushion Case Cap Bolt Handrail seal Band Base Framework Washer Bolt Washer Holder Lining Head lamp support

300

Fig. 81.1. Heater-cooler installation

301

Group 81. Heater Subgroup 8101. Heater-cooler installation Fig.No

Pos.No

81.1

1 2 3 4 8 9 10 11 12 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 34 35 36 37 38 39 42

Assembly unit or part number 80-8101760 80-8101810-02 80-8101930 80-8104070 80-8101714-04 80-8101717 80-8101811 80-8101941 80-8101941-01 1522-8101012-03 3022-8101012 30.04.017-01 8101.001 8101.002 8-6g 20.88.35.019 8-6g 35.88.35.019 6-6g 16.88.35.019 6-6g 20.88.35.019 5-6g 10.58.019 5-6 .6.019 6-6 .6.019 8-6 .6.019 5.01.019 6.01.019 8.01.019

5000.03

Q-ty

Name

1 1 1 2 1 1 1 1 1 1 2 2 1 1 2 2 10 2 2 2 6 4 2 16 2 2 12 6 1 1 1 2 1 1 4

Cover Panel Case Filter Seal Bracket Lining Elbow Elbow Hose Pipe Cap Hose Hose Bolt GOST 7796-70 Bolt GOST 7796-70 Bolt GOST 7798-70 Bolt GOST 7798-70 Screw GOST 17473-80 Nut GOST 5915-70 Nut GOST 5915-70 Nut GOST 5915-70 Washer GOST 11371-78 Washer GOST 6958-78 Washer GOST 6958-78 Washer OST 37.001.115-75 Washer OST 37.001.115-75 Washer OST 37.001.115-75 Fan switch 0682164 Climate control block U003CF041E Cock 11 TU RB 03973223.008-2000 Handle 068407/0 Instruction plate 067060/1 Thermostat 068011/1 Clamp with worm thread 20-32

302

Fig. 82.1. Inside rear-view mirror

303

Group 82. Cabin accessories Subgroup 8201. Inside rear-view mirror Fig.No

Pos.No

82.1 1 2 3 4 5 6 7 8

Assembly unit or part number 80-8201090 80-8201035 M8 25 30.04.071 80 -8201025 M6 12 8 8 M8

Q-ty 1 1 1 1 1 2 1 1 1

304

Name Inside mirror installation (1-7) Inside rear-view mirror Bolt Clamp Bracket Screw Washer Washer Nut

Fig. 82.2. Side rear-view mirror

305

Group 82. Cabin accessories Subgroup 8201. Side rear-view mirror Fig.No

Pos.No

82.2 1 2 3 4 5 6

Assembly unit or part number 80-8201050 80-8201055 M8 8 8 A30.04.051 M8x40

Q-ty 1 2 2 2 2 2 2

306

Name Mirror (1-6) Side rear-view mirror Nut Washer Washer Clamp Bolt

Fig. 82.3. Sun visor

307

Group 82. Cabin accessories Subgroup 8204. Sun visor Fig.No

Pos.No

82.3 2 3 4

Assembly unit or part number 80 -8204010 6 6 M6

Q-ty 1 2 2 2

308

Name Sun visor (2-4) Washer Washer Nut

Fig. 84.1 Facing

309

Group 84. Fin assembly Subgroup 8400. Facing Fig.No

Pos.No

84.1

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48

Assembly unit or part number 1222-8400025 37.08.045 923-8401088 6-6 .6.019 6-6g 40.58.019 6.01.019 1523-8402420 1523-8401087 1222-8400015 950.3-8401090 1222-8402320 1523-8402318 923-8402410-01 WFS-4213 1523-8402322 6.01.019 950.3-8400050 90-8400070-01 950.3-8400101 8.01.019 8-6 .6.019 3.2 25.019 549 -1305044 923-8402410 1523-8402319 950.3-8400102 923-8400011 8.01.019 1221-8402420 1222-8402020 1222-8402310 950.3-8402318 1523-8402030 1523-8402041 822-8400080-03 1523-8402039 12.01.019 12 1.25-6 .6.019 5-6g 12.58.019 70-4803023 10 10-6g 30.88.35.019 70-3401093 923-8400033 10-6 .6.019 920-8400140

Q-ty

Name

1 1 1 24 44 2 12 1 1 1 1 1 1 2 6 1 29 1 1 1 18 50 26 8 6 2 1 1 4 30 1 1 1 1 1 2 2 2 1 2 4 2 4 4 10 6 10 1

Apron Seal Grill Nut GOST 5915-70 Washer OST 37.001.115-75 Screw GOST 17475-86 Washer GOST 11371-78 Joke Grill Mask Grill Side member Grill Lock Self-tapping screw Grill Washer GOST 6958-78 Clamp Rod Bracket Washer GOST 11371-78 Washer OST 37.001.115-75 Nut GOST 5915-70 Forelock GOST 397-79 Ring Lock Grill Bracket Detent Washer GOST 6958-78 Joke Hood Side member Grill Frame Bracket Control wire Bracket Washer GOST 11371-78 Nut GOST 5915-70 Screw GOST 17473-80 Coupling Washer OST 37.001.115-75 Bolt GOST 7796-70 Lever tip Stem Nut GOST 5915-70 Support

310

Fig. 84.1 Facing

311

Group 84. Fin assembly Subgroup 8400. Facing Fig.No

Pos.No

84.1

49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87

Assembly unit or part number 80-8402410 6-6g 16.88.35.019 1523-8402060 8-6g 20.88.35.019 1523-8402085 6-6g 14.88.35.019 1321-84020956-6g 20.88.35.019 923-8400060 1523-8400170 920-8400140-01 21054 80-6707096 923-8400140-01 923-8402095923-8400045 923-8400040 8-6g 30.88.35.019 923-8400031 1222.4-8402045 1221.4-8402070 923-8400033-01 1523-8402110 8-6g 40.88.35.019 6-6g 45.88.35.019 80-6708225 90-84000128-6g 45.88.35.019 1221.4-8400086 10-3p/6g 45.66.019 1221.3-8402090-01 1523-8402082 6-6g 25.88.35.019 1221.3-8402101 1221.3-8402102 1221.3-8402075 16.01.019 10.01.019 90-8400070

Q-ty 2 12 1 16 2 4 2 4 1 1 1 1 1 2 2 4 2 8 4 1 1 2 1 2 2 1 1 2 1 2 1 1 6 1 1 1 2 4 1

312

Name Lock Bolt GOST 7798-70 Arc Bolt GOST 7796-70 Bracket Bolt GOST 7798-70 Detent Bolt GOST 7798-70 Bracket Support Support Air hoist Axis Support Detent Hinge Support Bolt GOST 7796-70 Axis Stabilizer Rack Stem Plate Bolt GOST 7795-70 Bolt GOST 7795-70 Bracket Bracket Bolt GOST 7795-70 Stabilizer Stud GOST 22034-76 Arc Shell Bolt GOST 7798-70 Screen Seal Support Washer GOST 11371-78 Washer GOST 6958-78 Rod

Fig. 84.2 Front wings

313

Group 84. Fin assembly Subgroup 8403. Front wings Fig.No Pos.N o 84.2 1 2 3 4 5 6 7 8 9 10 11 12 13 14

Assembly unit or part number

Q-ty

Name

822-840301112 85 12 12 30 2022-8403015-01 M10 10 10 80-4616017 10 10 25 1221-8403014- -02 or 1221-8403014- 1-02 2022-8403015 2022-8403012

2 8 14 6 1 10 10 10 10 10 10 2 2 1 8

Base Bolt Washer Bolt Rack Nut Washer Washer d=21 mm Roller Washer d=30 mm Bolt Wing Wing Rack Bushing

314

Fig. 84.3 Foot step 315

Group 84. Fin assembly.

Subgroup 8405. Foot step.

Fig.No 84.3

Pos.No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

Assembly unit or part number 80-8405020- 2 10 50 10 10 80-8405010- 3 10 25 80-840503112 25 12 10.01.019 80-840503280-8405030-

Q-ty 1 4 8 6 1 2 1 1 4 8 1 1

80-8405030- -01

1

12 923-6200111 12 60 10 30 12 30 12.01.019

3 2 2 2 1 2

316

Name Foot step Bolt Washer Nut Foot step Bolt Bracket Bolt Washer Washer Bracket Bracket Bracket (for the foot step on the right side) Nut Bushing Bolt Bolt Bolt Washer

Fig. 87.1. Control of FDA, rear axle DL, rear PTO shaft and reduction unit (12218700250- ) 317

Group 87. Control of FDA, DL, PTO shaft, lift linkage and reduction unit (electrics) Subgroup 8700. Control of FDA, rear axle DL, rear PTO shaft and reduction unit (12218700250- ) Fig.No 87.1

Pos.No

Assembly unit or part number

1 2 3 4 5 6 7

1 50-1702048 1222-8700021 1221-8700022

1221-3724840-

8 9 10 11 12

Q-ty

10max 1 2 2 2 1 1

80-3723045 1222-3724850 1221-37249701221-3724960

25 1 1 1

13

1

14 15 16 17 18 19 20 21 22

2 2 2 2 1 1 1 1 1

1221-8700275 -32-01 1522-87002211522-8700222

23

5

24

1

25

80-3801021

3

26

1

27

1

28 29 29 30 31 32 33 34

1221-8700265 3747.40 3747.50 1522-8700221

1321-8700019

1 3 7 2 7 7 7 1

318

Name Switch 12-51 TU RB 37334210.004-97 Shim Pipe Clamp Bolt 8-6g 16.88.35.019 GOST 7796-70 Washer 8 OST 37.001.115-75 Harness Female socket 602602 OST 37.003.032-88 Collar Harness Harness Harness Fuse block -1 TU RB 03428193.095-97 Screw 6-6g 20.58.019 GOST 17473-80 Nut 6-6 .6.019 GOST 5915-70 Washer 6.01.019 GOST 6958-78 Washer 6 OST 37.001.115-75 Shield Seal Bracket Bushing Switch 12-1 642241.001 TU Warning light 12.3803-31 TU RB 300228919.037-2002 or Warning light 2202.3803-34 TU 37.003.1109-82 Switch 147 -01.17 TU RB 14795799.001-97 or Switch 147-01.17 TU 37.003.701-75 Switch socket Switch 150 -06.14 TU RB 14795799.001-97 or Switch 150-06.17 TU 37.003.701-75 Switch 147 -06.49 TU RB 1495799.001-97 or Switch 147-06.17 TU 37.003.701-75 Panel ut-out relay 20 Cut-in relay 30 Bracket Screw 6-6g 12.58.019 GOST 17473-80 Nut 6-6 .6.019 GOST 5915-70 Washer 6 OST 37.001.115-75 Clamp

Fig. 87.1. Control of FDA, rear axle DL, rear PTO shaft and reduction unit (12218700250- ) Group 87. Control of FDA, DL, PTO shaft, lift linkage and reduction unit 319

(electrics) Subgroup 8700. Control of FDA, DL, rear PTO shaft and reduction unit (1221-8700250) Fig.No 87.1

Pos.No 35 36 37 38

Assembly unit or part number 80-3724410-06 50-4607064 80-3805065

39 40 41 42 43 44 45 46 47

53

2 4 1 2 2

1221-8700290

30.04.017

48 48 49 50 51 52

Q-ty

1 2 2 2 4 2 4 2 2

70-3723042-02

1221-8700286 1221-8700280

1 1 1 1 1

12-2

1

320

Name Cable Screw 6-6g 20.58.019 GOST 17474-80 Bushing Screw Ring 006-010-25-1-4 GOST 18829-73/GOST 9833-73 Control panel Bolt 6-6g 16.88.35.019 GOST 7798-70 Bolt 6-6g 30.88.35.019 GOST 7798-70 Nut 6-6 .6.019 GOST 5915-70 Washer 6.01.019 GOST 6958-78 Washer 6.01.019 GOST 11371-78 Washer 6 OST 37.001.115-75 Cap Rivet nut 16 TU RB 161.01-2008 Bushing Nut 14 1,5-6 .6.019 GOST 5915-70 Washer 14 OST 37.001.115-75 Lever Bracket Switch 12-2 TU RB 07512465.017-94

Fig. 87.2. Rear lift linkage control

321

Group 87. Control of FDA, DL, PTO shaft, lift linkage and reduction unit (electrics) Subgroup 8700. Rear lift linkage control Fig.No 87.2

Pos.No 1 2 3 4 5 6 7 8 9 10 11

Assembly unit or part number 1221-3724895 80-3723045-01

1221-8700620 1221-8700620-01 1221-3724885

Q-ty 1 14 1 4 4 4 4 4 1 1 2

12

2

13

2

14

1

15

2

16 17 18 19 20 21

2 2 2 1 1 1

30.04.017 1221-3724890 80-6702402- -04 70-3723042-02

322

Name Harness Collar Control panel 0538201611 Screw 4-6g 10.58.019 GOST 17475-80 Nut 4 -6 .6.019 GOST 5915-70 Washer 4 .01.019 GOST 6958-78 Washer 4 OST 37.001.115-75 Button switch 145000 Bracket Bracket Harness Female socket 602604 OST 37.003.032-88 Male socket 502604 OST 37.003.032-88 Electronics assembly R 917004743 Bolt 6-6g 16.88.35.019 GOST 7798-70 Nut 6-6 .6.019 GOST 5915-70 Washer 6 OST 37.001.115-75 Cap Harness Plate Bushing

Fig.87.3 Control of DL and FDA Group 87.Control system 323

Subgroup 8700. Control of DL and FDA Fig.No Pos.No 87.3 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47

Assembly unit or part number Q-ty Name 1221.4-8700410 Control of DL and FDA 50-1702048 10(max) Shim 12-51 1 Switch 1222-8700021 1 Pipe 1221-8700022 2 Clamp 8-6g 16.88.35.019 GOST 7796-70 2 Bolt OST 37.001.115-75 2 Washer 1221-37248401 Harness 602602 OST 37.003.032 - 88 1 Female socket 1025-3724850 1 Harness 1221-3724860 1 Harness 50-4607064 1 Bushing 1022-8700290 1 Control panel 1221-8700265 1 Panel 6-6g 20.58.019 GOST 174744 Screw 80 80-3805065 2 Screw 006-010-25-1-4 2 Ring GOST 18829-73/GOST 9833-73 1221-8700275 1 Shield 70-3723042-01 1 Bushing 30.04.017 2 Cap 6-6g 16.88.35.019 GOST 7798-70 2 Bolt 6 OST 37.001.115-75 4 Washer 6.01.019GOST 11371-78 2 Washer M6x16 TU RB 161.01-2008 2 Rivet nut 6-6g 30.88.35.019 GOST 7798-70 2 Bolt 6-6 .6.019 GOST 5915-70 2 Nut 6.01.019GOST 6958-78 4 Washer 12.3803-41 3 Warning light 12.3803-31 or 2 Warning light 2202.3803-34 80-3801021 3 Switch socket 147 -06.49 or 1 Switch 147-06.17 150 -06.14 or 1 Switch 150-06.17 3 Cut-in relay 30 6-6g 12.58.019 GOST 174732 Screw 80 6-6 .6.019 GOST 5915-70 2 Nut 6 OST 37.001.115-75 2 Washer 1522-8700221 1 Bracket 5 OST 37.001.115-75 2 Washer 80-3801327 1 Blind plug 12-1 1 Switch 1025-8700430 1 Bracket 12-21 1 Switch 14 1,5-6 .6.019 GOST 5915-70 1 Nut 14 OST 37.001.115-75 1 Washer 1221-8700286 1 Lever 1025-37248351 Harness 1221-37248651 Harness 80-3723045-01 16 Collar

324

Fig.87.4 Control of MMZ engine

Group 87.Control system 325

Subgroup 8700. Control of MMZ engine Fig.No Pos.No 87.4 1 2 3 4 5 6

Assembly unit or part number 1221.4-87009101221.4-3724845 1221.4-37249611221.4-37249651221.4-870093880-3723045-01 4-6gx20.58.019

Q-ty 1 1 1 1 1 11 6

7

1

8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

1 1 1 4 4 1 1 2 2 2 2 4 4 4 4 1 1 5 6 5 5 3 1

4-6gx10.58.019 1221.4-87009164-6gx16.58.019 4-6 .6.019 4.01.019 3-6gx16.58.019 3-6 .6.019 3.01.019 3 1221.4-3724801 1221.4-87009308-6gx16.88.35.019 8-6 .6.019 8.01.019 8 1221.4-8700913 923-3723012

31 32 33

1 6-6gx14.58.019

4 4

6

326

Name Engine control Harness Harness Harness Bracket Collar Screw GOST 17474-80 Warning light 12.3803-31 or 2202.380334 Switch 12-1 Cigar lighter 116.3725 Information display 918013 Screw GOST 17473-80 Washer 4 OST 37.001.115-75 Panel Socket 25.038.100 Screw GOST 17473-80 Nut GOST 5927-70 Washer 4.01.019 GOST 11371-78 Washer 4 OST 37.001.115-75 Screw GOST 17473-80 Nut GOST 5927-70 Washer GOST 11371-78 Washer OST 37.001.115-75 Harness Bracket Bolt GOST 7796-70 Nut GOST 5915-70 Washer GOST 6958-78 Washer OST 37.001.115-75 Ring Clamp Series 1000 switching and protection unit Screw GOST 17473-80 Washer OST 37.001.115-75