• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
FOREWORD
This handbook has been compiled to assist you in properly operating and maintaining your Grove Crane.
Before placing the crane in service, take timetothoroughlyfamiliarize yourself with the contents of this manual. After all sections have been read and understood, retain the manual for future reference in a readily accessible location.
The Grove Crane has been designed for maximum performance with minimum maintenance. With proper care, years of trouble-free service can be expected.
Constant improvement and engineering progress makes it necessary that we reserve the right to make specification and equipment changes without notice.
Engine operating procedures and routine maintenance procedures are supplied in a separate manual with each crane, and should be referred to for detailed information.
Information in this manual does not replace federal, state, or local regulations, safety codes, or insurance requirements.
vi
The definitions of DANGER, CAUTION, and NOTE as used in this manual apply as follows.
DANGER
A DANGER NOTE 15 USED TO EMPHASIZE THAT If AN OPERATION, PROCEDURE, OR PRACTICE IS NOT FOLLOWED EXACTLY, DEATH OR INJURY TO PERSONNEL MAY RESULT.
CAUTIQN
A CAUTION IS USED TO EMPHASIZE THAT IF AN OPERATION, PROCEDURE, OR PRACTICE IS NOT FOLLOWED EXACTLY, EQUIPMENT DAMAGE MAY RESULT.
NOTE
A note is used to emphasize an important procedure or condition.
vii
TABLE
CONTENTS Page Section 1 - INTRODUCTION ..........•...................... 1-1 Section 2 - SAFETY PRECAUTIONS 2-1 GENERAL ......•..................................... 2-1 OPERATOR'S INFORMATION ..........•.•............... 2-2 OPERATOR'S QUALIFICATION ....•...........•.......... 2-3 ELECTROCUTION HAZARD ......•...............•...•.. 2-4 Set-Up and Operation . . . . . . . • • . . . . • • . . . . • . . . . . . . . . . 2-5 Electrocution Hazard Devices . . . . . . . . . . . . . . . . . . • • . . . . . 2-6 Electrical Contact 2-8 Special Operating Conditions and Equipment ............ 2-8 CRUSHING HAZARDS 2-9 TRAVEL OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . • . . . . . . . . 2-11 MAINTENANCE ........•...........•.................. 2-12 Service and Repairs . . . . . . . . . . . . . . . . . . . . . . • . . . . . . . . 2-13 Lubrication .....................•................. 2-13 Tires ........................................... 2-14 BATTERIES 2-14 ENGINE ............................................. 2-15 WORK PRACTICES 2-15 Crane Access . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-15 Job Preparation ................................... 2-15 COLD WEATHER OPERATION .......................... 2-16 Section 3-CAB CONTROLS AND INDICATORS ................ 3-1 viii ENGINE CONTROLS AND INDICATORS 3-1 Voltmeter 3-1 Ignition Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1 Oil Pressure Gauge 3-1 Tachometer/Hourmeter ...........................•.. 3-2 Engine Temperature Gauge ......•................... 3-2 Fuel Quantity Gauge . . . . . . . . . . . . . . • . . . . . . . . . . • . . . . . . 3-2 Foot Throttle Pedal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2 Engine Brake Switch . . . . . . . . . . . . . . . . • . . . . . . . . . . . . • . . 3-2 Engine Brake Select Switch • . . . . • . • . • . . . . . . • . . . . • . . . . 3-2 Engine Stop Light . . . . . . . . . . . . . . • • • • . . . . • . • . . . • • . • . . 3-2 Idle/Diagnostic Switch ...............•............... 3-6 Test Mode Switch . . . . . . . . . . . . • . . . . . . • . . . . • . . . . . . . . . 3-6 Fluid/Warning Light . . . . . . . • . . . . . . . . . • . . . . . . . . . . . . . . • 3-6 TRAVEL CONTROLS AND INDICATORS 3-6 Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . • 3-6 Air Pressure Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-(> Parking Brake Control 3-6
OF
• Thank you very much for reading the preview of the manual.
• You can download the complete manual from: www.heydownloads.com by clicking the link below
• Please note: If there is no response to CLICKING the link, please download this PDF first and then click on it.
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
CLICK HERE TO DOWNLOAD THE COMPLETE MANUAL
