6. DAILY
INSPECTION
Conduct a daily inspection in the sequence described below. If any abnormality or damage IS noted. contact the nearest dealerfor inspectionand servicing.
(11 Inspection
before
starting
the level of battery fluit 3) Check condition of anode (zinc elec- @Check trode) attached to anti-cavitation plate. (Optional) Retigbten if necessary. Check the level of battery fluid to WCII ,, is even with the specified line. If the t:,,l’ tery does not have a reference level ‘I I/h t fluid shouldbe 5 to 10 mm (0.20 to 0 .;<I in) abovethe plates.
engine
@Check fuel strainer for contaminall~l!l Check fuel filter for contaminallon .MW clogging, and filter cup for collectiw ‘!I water.
@Check outboard motor for proper “lstallatlon. I) Check that the clamp handle and stern bracket mounting bolts (optional parts) are properly tightened. Check mnsom mount for damage. NOTE: Be sure to tighten the clamp screw of the clamp handle by hand. Do not use a tool for tightening. Over-tightening of the clamp screw will damage the transom of the boat. propeller for damageand proper “lstallatlon. I) Ensure that the clutch lever IS in the “N” (Neutral) position. Then check propeller for damage whde turning slowly by hand. 2) Check propeller for proper installation, cotter pin for damage, and seals for oil leaks.
@Check
6
NOTES:
NOTE: Be sure to check the zinc electrode every week for corrosion. Replace if it is reduced to approximately 50% of original size. See p.24.
A If the fuel filter is clogged with dirt, 01 there is water in the filter cup, removB the nut from the bottom of the fi ter cup by turning it counterclockwise w!th a wrench. Clean both the filter and cup! A Also clean rhe inside of the fuel tank.
@Check fuel tank and hosesfor leak, 01 damage. @Check electrical connections for looseCheck carefully all surfacesof the fuel I~IIII nessor damage. for damage. Check the fuel hose E<~I Check high-tension cord and wire harness damage, loose connections or fuel leak;l& connectors for loosenessor rust. Check harnesssurfacefor scratchesor damage. NOTES: @Check condition of battery cablesand terminals(Optional) Check battery cable connections for looseness.cables for damageand terminals for rust.
. Replace the fuel hoses every two year,. A If damage or cracks are noted, replace the hoses immediately. . Replace the fuel tank every three years
