Cat 3508 Diesel Engine Service Manual – PDF DOWNLOAD

Page 206

3161 GOVERNOR

TESTING AND ADJUSTING housing with bracket assembly (10) as follows: Use a top cover bolt with three washers (as spacers under the bolt head) on it and put the bolt through the fixed diameter hole in the bracket. Fasten the bracket to the left side of the housing in the second threaded hole from the front. Put the dial indicator in the adjustable hole in the bracket assembly and position it so the indicator contact point (11) rests on the bolt head (12) of the torque control lever.

INSTALL DIAL INDICATOR

8.

Check to make sure the cam follower is on the base circle of the governor torque rise cam. See Systems Operation section for a description of the base circle.

9.

Move dial indicator (9) until it reads zero and fasten it in place.

10.

Turn the synchronizing pin out of the engine front drive housing a minimum of half-way. As the synchronizing pin is backed out, dial indicator (5) will follow the fuel control linkage movement until the fuel control linkage stop lever contacts the fuel setting screw. Dial indicator (5) now shows the torque rise fuel setting. Make sure the torque rise fuel setting is correct. If not, an adjustment is necessary.

11.

Look in the Fuel Setting and Related Information Fiche for the full load setting for the engine you are adjusting.

12.

Turn the synchronizing pin in until dial indicator (5) reads the full load fuel setting. The full load setting is a reference position and is a temporary setting used to adjust the torque rise cam position.

1. Synchronizing pin. 5. 6V3075 Dial Indicator. 6. Fuel setting cover. 5.

Put dial indicator (5) with the 5P7263 Contact Point in the 5P4814 Collet. Install dial indicator (5) and the collet in the threaded hole for plug (3). When the contact point seats against the fuel stop lever, slide the dial indicator in or out until it reads zero. Now tighten the collet just enough to hold dial indicator (5) at this position.

REMOVE GOVERNOR TOP COVER 7. Cover. 8. Gasket. 6.

Remove the bolts that hold cover (7) in position. Lift cover (7) off the governor and remove gasket (8).

The purpose of this procedure is to hold the fuel control linkage at the full load setting while the torque rise cam is adjusted.

INSTALL DIAL INDICATOR 9. 6V3075 Dial Indicator. 10. 9S228 Bracket Assembly. 11. 3S3269 Contact Point. 12. Bo8t. 7.

Install dial indicator (9) on the top of the governor 190

13.

Dial indicator (9) must read 1.00 + 0.05 mm, if it does not, an adjustment is needed. Loosen the bolt that holds the cam enough so the cam can be moved, but keep the bolt tight enough to provide a small drag on the cam.

14.

Slide the cam to cause the torque control lever and dial indicator contact to lift 1.00 + 0.05 mm.

15.

Tighten the bolt while the cam is held in place. This adjustment of 1.00 + 0.05 mm positions the torque control lever so the torque rise (additional fuel) begins to occur at the correct engine speed.


Turn static files into dynamic content formats.

Create a flipbook

Articles inside

Spacer Plates

2min
pages 391-392

Cylinder Liners

2min
pages 398-399

Crankshaft Main Bearings

4min
pages 393-395

Rear Gear Group

3min
pages 387-390

Front Balancer Group

1min
pages 385-386

Connecting Rod Bearings

1min
page 384

Bridge Dowels

2min
pages 382-383

Valves

1min
page 381

Cylinder Heads

4min
pages 377-380

Fuel Injectors

3min
pages 369-370

Fuel Injection Control Linkage

6min
pages 371-376

Rocker Shafts and Push Rods

4min
pages 366-368

Valve Covers

1min
page 365

Flywheel Housing

1min
pages 363-364

Front Drive Housing

4min
pages 358-361

Flywheel

1min
page 362

Crankshaft Rear Seal and Wear Sleeve

2min
pages 356-357

Crankshaft Vibration Damper

1min
page 353

Crankshaft Front Seal and Wear Sleeve

2min
pages 354-355

Oil and Water Pump Drive

1min
pages 350-352

Accessory Drive (Front

1min
pages 347-349

Hydramechanical Shutoff Drive

1min
pages 345-346

Governor Drive

3min
pages 328-331

Governor

1min
pages 326-327

Hydramechanical Shutoff Control

12min
pages 332-344

Aftercooler

2min
pages 322-325

Exhaust Manifolds

1min
page 321

Turbochargers

6min
pages 312-320

Oil Cooler

4min
pages 305-311

Oil Sequence Valves

1min
page 304

Oil Filter Housing

5min
pages 293-299

Oil Pan

2min
pages 300-303

Oil Pump

5min
pages 288-292

Fuel Priming Pump, Fuel Transfer Pump

4min
pages 283-287

Fuel Filter Housing

3min
pages 279-282

Water Pump

2min
pages 275-278

Water Temperature Regulators

1min
pages 272-274

Crankcase Breather

1min
pages 270-271

Gauge Panel

6min
pages 259-261

Manual Shutoff

3min
pages 257-258

3500 Industrial Engines

6min
pages 253-256

System Checks

1min
pages 243-244

Wiring Diagrams

9min
pages 247-252

Troubleshooting

4min
pages 239-242

Hydraulic Circuits, Later with an Alarm System

6min
pages 232-238

Hydraulic Circuits (Later

5min
pages 228-231

Shutoff Control Group

6min
pages 199-201

Air Intake Shutoff

5min
pages 206-208

3500 Series Engines

4min
pages 197-198

Electrical Switches

1min
page 210

Auxiliary Controls

2min
pages 192-196

Governor Installation

8min
pages 182-186

Governor Preparation

3min
page 181

Pneumatic Speed Setting Control Troubleshooting

3min
pages 178-179

Air Fuel Ratio Control Troubleshooting

7min
pages 176-177

Pneumatic Mid Speed Control

5min
pages 170-171

Air Fuel Ratio Control

4min
pages 167-168

Pneumatic Speed Control

3min
pages 165-166

Operation of the 3161 Governor

6min
pages 161-163

Governor Types

4min
pages 157-158

Caterpillar, 3161 Governor

2min
pages 155-156

Starting System Air Starting System...................................Deleted

4min
pages 152-154

Vibration Damper

1min
page 149

Flywheel and Flywheel Housing

4min
pages 146-147

Checking Crankshaft Deflection (Bend

1min
page 148

Valve Clearance

3min
pages 137-138

Pressure Cap Test

1min
page 142

Water Temperature Regulator Test

2min
page 144

Clearance Setting

2min
page 136

Bridge Adjustment Crankshaft Positions for Valve

2min
page 135

Air Fuel Ratio Control

1min
page 132

Engine Speed Measurement

2min
page 127

Injector Synchronization

2min
pages 123-124

Fuel Setting Adjustment

2min
page 126

Fuel Setting

2min
page 125

Fuel Timing

1min
page 122

Startup Procedure

1min
page 120

Camshaft Timing

2min
pages 118-119

Fuel Pressure

1min
page 116

Injector Test Sequence

9min
pages 110-115

Air Starting System

4min
pages 86-87

Leak Test for Injector Tester

1min
page 109

Contactor Switch (Water Temperature

4min
page 90

Camshafts

1min
page 85

Air Fuel Ratio Control

1min
pages 73-74

Woodward UG8 Lever Governors

2min
pages 71-72

Fuel Injection Control Linkage

1min
page 67

Fuel Injector

2min
pages 68-70

Fuel System

3min
pages 65-66

Systems Operation, 3500 Industrial Engines

1min
pages 61-62

Flywheel Housing Runout Alternators and Regulators.......................Deleted

11min
pages 53-60

Engine Design

1min
pages 63-64

Flywheel Housing Bore

1min
page 52

Flywheel

1min
page 47

Rear Gear Group

2min
pages 45-46

Upper Front Gear Group (7N4871

1min
page 44

Lower Front Gear Group

2min
pages 42-43

Connecting Rod and Main Bearing Journals

1min
page 38

Crankshaft Wear Sleeves and Seals

1min
page 40

Crankshaft

1min
page 39

Front Balancer Group (3508

1min
page 41

Pistons and Rings

1min
page 36

Water Pump

1min
page 31

Cylinder Block

1min
page 34

Oil Cooler Bypass and Cooling Jet Sequence Valves

1min
page 30

Oil Pump

1min
pages 26-27

Oil Filter Bypass Valve (Earlier

1min
page 28

Engine Design

5min
pages 5-7

Air Intake Shutoff

1min
pages 23-25

Camshafts

3min
pages 12-13

Oil Filter Bypass Valve (Later

1min
page 29

and Taperlock Studs

5min
pages 3-4

Fuel Injection Control Group

3min
page 10
Issuu converts static files into: digital portfolios, online yearbooks, online catalogs, digital photo albums and more. Sign up and create your flipbook.
Cat 3508 Diesel Engine Service Manual – PDF DOWNLOAD by www.heydownloads.com - Issuu