Sample M.E.D.S. Check Report

YOUR COMPANY LOGO HERE The

report provides you a detailed boat engine report including among other features vital system information, any

current active faults, engine run history, data parameter snapshot. This report will be the most comprehensive coverage of your boat engine's history, helping you understand what is occurring with your boat engine.

Table of contents: Pg. 2: System Information Pg. 3: Active Faults Pg. 4: Run time history Pg. 7: Persistent and Stored Fault HistoryPersistent Fault History Pg. 9: Data parameter snapshot Pg. 10: MEDS system ID

Boat Information: Owner: Joe Smith Address: 1563 Elm St.

Telephone: 256-451-1154 Email Address: jsmith@gmail.com Make & Model:

Test Center: Location: Technician: Signature:

The Page 1 of 10

report is a trademark of CDI Electronics, Inc. and is based on the

Marine Engine Diagnostic Software.

Test date 1/20/2013

YOUR COMPANY LOGO HERE

System Information System identification: Model Spec.

: E40DPLSUM

System Type

: Number of cylinders: 2 40 HP 2007 E-TEC I

Diagnostic Version

: 20011

Software Version

: 3030369

Serial # (Engine)

: 5162853

EMM Serial Number

: 8010047

Stored values: Engine Run Time

: 62:42:29

break-in time

: 0:02:23

Engine speed (Max)

: 5617 Rev/Min

EMM Temp (Max)

:

347°F ( 175°C)

Engine Temperature - Port (Max) :

137°F ( 58.2°C)

break-in mode Active

Run Time (EMM)

: 296:53:42

Run Time (No oil)

: 2:24:22

Oil Type Setting

: TC-W3

Engine Type

: Remote

Starter cycles

: 66

Crankshaft offset

: 0.5°

Idle Offset

: 110 Rev/Min

TPS Calibration

: 192

PDC Version

: 40L03296, Checksum = 10639

Fuel injector Serial Number

The Page 2 of 10

Location

Serial #

Injector #1 Injector #2

06153053988850 06153044071850

report is a trademark of CDI Electronics, Inc. and is based on the

Marine Engine Diagnostic Software.

Test date 1/20/2013

YOUR COMPANY LOGO HERE

Active Faults

No faults active

The Page 3 of 10

report is a trademark of CDI Electronics, Inc. and is based on the

Marine Engine Diagnostic Software.

Test date 1/20/2013

YOUR COMPANY LOGO HERE

Run time history

Engine RPM Profile RPM band

Time in band

% in band

0- 500 500-1000 1000-1500 1500-2000 2000-2500 2500-3000 3000-3500 3500-4000 4000-4500 4500-5000 5000-5500 5500-6000 6000-6500 6500-7000 7000-7500 7500+

0:14:07 37:28:49 3:05:48 1:01:13 0:32:29 0:07:16 0:03:48 0:01:41 0:02:41 0:01:53 0:00:30 0:00:02 0:00:00 0:00:00 0:00:00 0:00:00

0.6% 87.8% 7.3% 2.4% 1.3% 0.3% 0.1% 0.1% 0.1% 0.1% 0.0% 0.0% 0.0% 0.0% 0.0% 0.0%

Profile Time: 42:40:17

The Page 4 of 10

Engine Run Time: 62:42:29

report is a trademark of CDI Electronics, Inc. and is based on the

Marine Engine Diagnostic Software.

Test date 1/20/2013

YOUR COMPANY LOGO HERE Storing EMM Temperature Profile Temp (째C)

Run Time

%

-10 - 0 1 - 10 11 - 20 21 - 30 31 - 40 41 - 50 51 - 60 61 - 70 71 - 80 81 - 90 91 - 100 > 100

0:00:10 0:12:58 33:18:23 156:29:17 69:51:41 1:02:50 0:02:02 0:04:39 0:00:00 0:00:00 0:00:00 0:01:33

0.0% 0.1% 12.8% 59.9% 26.8% 0.4% 0.0% 0.0% 0.0% 0.0% 0.0% 0.0%

Profile Time : 261:03:33

Storing EMM Temperature Profile Temp (째C)

Run Time

%

-10 - 0 1 - 10 11 - 20 21 - 30 31 - 40 41 - 50 51 - 60 61 - 70 71 - 80 81 - 90 91 - 100 > 100

0:00:10 0:12:58 33:18:23 156:29:17 69:51:41 1:02:50 0:02:02 0:04:39 0:00:00 0:00:00 0:00:00 0:01:33

0.0% 0.1% 12.8% 59.9% 26.8% 0.4% 0.0% 0.0% 0.0% 0.0% 0.0% 0.0%

Profile Time : 261:03:33

The Page 5 of 10

report is a trademark of CDI Electronics, Inc. and is based on the

Marine Engine Diagnostic Software.

Test date 1/20/2013

YOUR COMPANY LOGO HERE Engine Temp profile Temp (째C)

Run Time

%

-10 - 0 1 - 10 11 - 20 21 - 30 31 - 40 41 - 50 51 - 60 61 - 70 71 - 80 81 - 90 91 - 100 > 100

0:33:04 0:00:00 0:07:14 2:17:50 596523:14:07 4:24:50 6:21:42 14:21:01 6:47:53 1:33:07 0:32:36 0:01:12

0.0% 0.0% 0.0% 0.0% 100.0% 0.0% 0.0% 0.0% 0.0% 0.0% 0.0% 0.0%

Profile Time : 596560:14:36

The Page 6 of 10

report is a trademark of CDI Electronics, Inc. and is based on the

Marine Engine Diagnostic Software.

Test date 1/20/2013

YOUR COMPANY LOGO HERE

Persistent and Stored Fault HistoryPersistent Fault History Persistent Fault History 91

42

34

12

13

47

38

48

Fuel pump open circuit fault

fault counts 7 Counts Time of last occurrence: 62 Run Hours Engine temp below normal - Port or single fault counts 1 Counts Time of last occurrence: 61 Run Hours Oil solenoid/injector open circuit fault counts 2 Counts Time of last occurrence: 61 Run Hours Throttle position sensor fault fault counts 3 Counts Time of last occurrence: 61 Run Hours Throttle position sensor below expected range fault counts 5 Counts Time of last occurrence: 61 Run Hours Air Temp (AT) sensor circuit fault fault counts 3 Counts Time of last occurrence: 61 Run Hours Oil pressure pulses not detected fault counts 16 Counts Time of last occurrence: 61 Run Hours Air Temp (AT) circuit below normal range fault counts 3 Counts Time of last occurrence: 61 Run Hours

Stored Fault Records # 38

Oil pressure pulses not detected

# 82

Occurrence counter: 2 times between engine hours 61:14 Cylinder #2 ignition primary open circuit Occurrence counter: 1 times between engine hours 61:23 -

The Page 7 of 10

61:16 61:23

report is a trademark of CDI Electronics, Inc. and is based on the

Marine Engine Diagnostic Software.

Test date 1/20/2013

YOUR COMPANY LOGO HERE # 41 # 91 # 21 # 81 # 42 # 34

Engine temp sensor fault - Port or single

Occurrence counter: 1 times between engine hours Fuel pump open circuit fault Occurrence counter: 8 times between engine hours Auto-Winterization Activated Occurrence counter: 2 times between engine hours Cylinder #1 ignition primary open circuit Occurrence counter: 2 times between engine hours Engine temp below normal - Port or single Occurrence counter: 1 times between engine hours Oil solenoid/injector open circuit Occurrence counter: 2 times between engine hours

61:13 -

61:14

61:16 -

62:26

61:40 -

61:45

61:17 -

61:23

61:13 -

61:14

61:14 -

61:16

Note: This control module does not store any additional freeze frame information beyond the information shown above.

Engine Run Time: 62:42:29

The Page 8 of 10

report is a trademark of CDI Electronics, Inc. and is based on the

Marine Engine Diagnostic Software.

Test date 1/20/2013

YOUR COMPANY LOGO HERE

Data parameter snapshot Reading Eng Speed TPS % TPS Sensor V VSystem VBattery Air Temp EMM Temp Engine Temp VIgnition Oil Freq Charge Amps Baro. Press.

Inj Time Low Oil Cnt

The Page 9 of 10

Value 0.00 RPM 0.30 % 0.64 V 12.0 V 13.0 V 28.8 째C 25.8 째C 40.5 째C 5.12 V 0.46 Cyc/Min 0.00 A 103 kPa 51.3 1.00 Pulses

Description Engine speed Throttle Position Throttle Position Sensor Volts Main System Voltage Battery Voltage Inlet Air Temperature Internal EMM Temperature Engine Temperature - Single Ignition Driver Voltage Oil Pulse Cycles Per Minute Battery Charge Current Barometric Pressure Reading Fuel Injection Duration.

Low Oil Pulses; SAFEs @ 6500

report is a trademark of CDI Electronics, Inc. and is based on the

Marine Engine Diagnostic Software.

Test date 1/20/2013

YOUR COMPANY LOGO HERE

MEDS system ID

Software Version

: MEDS 6.0 Reference Assembly (Aug 29 2012, 13:57:17)

Manufacturer

: CDI Electronics

Product

: USB-ECM Int. 534-0110C

Serial Number

: 12082015

Hardware adapter ID : 425250323332 (BRP232)

MEDSCheck version 05/30/2012 16:23:08

The Page 10 of 10

report is a trademark of CDI Electronics, Inc. and is based on the

Marine Engine Diagnostic Software.

Test date 1/20/2013