Maintenance and service

Storage and diSpoSal

1. tractor Storage

daily Storage

(1) Store the tractor after cleaning it. Especially, clean it thoroughly after harrowing or working in a wet field.

() Make sure to lower an implement.

(3) Store the tractor indoors if possible.

(4) If storing the tractor outside, cover it.

(5) For better startability, it is recommended to remove the battery from the tractor and keep it indoors in winter.

(6) If the outside temperature is below 0℃, add antifreeze or drain coolant completely to prevent the engine from freezing and bursting.

(7) Remove the key and store it separately.

long-term Storage

Clean the tractor thoroughly and store it as follows:

(1) Change engine oil with new oil and run the engine for 5 minutes to distribute oil to each part evenly.

(2) Drain coolant from the radiator. Then, make a label indicating "No Coolant" and fix it onto the steering wheel. If antifreeze is already added, it is not necessary to drain coolant.

(3) Add oil, fluid and fuel to each part according to the maintenance chart.

(4) Apply a thin film of grease of oil to body parts that are apt to rust.

(5) Check each bolt and nut for looseness and tighten any loose bolt and nut.

(6) Set the tire inflation pressure a little higher than the specification.

(7) Remove a weight. Detach or lower an implement.

(8) Chock the rear wheels.

(9) Remove the battery from the tractor or turn off its switch to cut power connection.

(10) Place wood blocks under the tires to protect them.

(11) Charge the battery every 2 months during long-term storage.

(12) Store it in a dry place to avoid rain or snow and cover the body.

USe after long-term Storage

Keep the following instructions when using the tractor after its longterm storage.

(1) Inspect the tractor thoroughly before driving it.

(2) To keep performance and life of the engine, idle the engine for approx. 30 minutes after starting it.

2. USage and diSpoSal

It is recommended to keep the followings to protect the environment:

(1) Avoid overloading work as it can lead to incomplete combustion and emissions that can pollute the air.

For engine lubrication, run the engine at 1.500 ~ .000 RPM for 5 to 10 minutes once a month.

Remove the key from the tractor and store it separately.

caUtion

If leaving the battery connected to the tractor, turn off its switch to cut electric power.

If wiring is damaged by rodents, its short circuit can start a fire.

() When changing oil, including engine oil, transmission fluid, hydraulic oil and coolant, be careful not to spill it and discard used oil according to the applicable law. Used oil should be treated with care and discarded properly as it can contaminate soil and water.

() When this or other machine's life is expired, do not neglect or discard it on your own, but contact your dealer so that the approved service provider can discard the machine according to the laws.