IPA – December 2022

DECEMBER 2022 PROMOTING

ISSUE 88 ON-SITE POWER & CO-GENERATION

www.wipmagazines.com

www.powermediagroup.co.uk

More transparency, more value.

With MWM Remote Asset Monitoring. www.mwm.net/ram

LOADBANKS for GENERATORS

THE TRUSTED NAME FOR LOAD TESTING

LOADBANK PACKAGES ■ ■ ■ ■

20kW to 7000kW Resistive Only Loadbanks Resistive / Reactive Loadbanks DC Loadbanks

SALES | SERVICE | RENTAL

Call today: +44(0) 1283 531 645

Crestchic Limited, Second Avenue, Centrum 100, Burton upon Trent, Staffordshire DE14 2WF, UK T: +44 (0)1283 531645 F: +44 (0)1283 510103 E: sales@crestchic.co.uk

www.crestchicloadbanks.com Sales & Rental Offices in : UK, North America, Singapore, Germany, Brazil, Netherlands, France, China and UAE

EDITOR’S NOTES

DECEMBER 2022

ASIA’S NATIONS EMBRACE THE CHALLENGE OF USING HYDROGEN

ISSUE #88 Publisher/Sales DIrector Neb Saric neb@wipmagazines.com Publishing & Events Director Richard Teasdale richard@wipmagazines.com Managing Editor Aidan Turnbull aidan@wipmagazines.com Accounts Executive Alison Williams accounts@wipmagazines.com Sales & Marketing Manager Sarah Hallows sarah@wipmagazines.com

Far East Sales Bob Liu Shanghai, China bob.liu@ronco.com.cn US Sales & Subscriptions Jelena Milojevic power@wipmagazines.com Austrian & German Agent Mario Dobresko power@wipmagazines.com Power Media International Group, The Courtyard, 30 Worthing Road, Horsham, West Sussex, RH12 1SL, UK Tel: +44 (0) 1403 888019 www.powermediagroup.co.uk © Independent Power Asia (ISSN 1468 7100)

The Association of Southeast Asian Nations (ASEAN) has acknowledged the significant challenges involved in matching energy demands with sustainable supply during the transition to a lower-carbon economy.

Reducing global greenhouse gas emissions is high on the global agenda and the national leaders are pledged to pursue alternative fuel pathways, shifting from fossil fuel–based energy systems toward greener energy sources.

Asia still a way to go to achieve a balance of economic growth, energy affordability and energy availability. Much of the future energy mix of emerging ASEAN countries will rely on fossil fuels to power economic development. However, there are pathways to ensure the future of economic development with sustainable energy use to harmonize economic growth, social well-being, and environmental sustainability.

Renewable energy is a leading solution.

Renewable or ‘green’ hydrogen has been championed as a clean HYDROGEN IS A energy source for the ASEAN region’s energy mix in the VERSATILE FUEL. IT foreseeable future.

Hydrogen is a versatile fuel that PRESENTS UNTAPPED can be produced from many POTENTIAL AS A CLEAN energy sources. It presents untapped potential as a clean ENERGY SOURCE.” energy source.

Currently, annual global production of hydrogen is around 120 million tons, of which two-thirds is pure hydrogen and one-third is mixed with other gases. Hydrogen can be produced from either fossil fuels or renewables.

Currently, about 95% of hydrogen is produced from coal and gas without carbon capture and sequestration/storage (CCS), known as ‘gray’ hydrogen.

Only small amounts are produced with CCS, known as ‘blue’ hydrogen. The gasification of coal can also be used to produce hydrogen, but in terms of its carbon footprint, this process emits roughly four times as much carbondioxide per kilogram (kg) of hydrogen as using natural gas feedstock. Around 5% of total hydrogen production is from renewables, or green hydrogen.

Two well-known processes to extract hydrogen fuel are steam methane reforming, mainly applied to extract hydrogen from fossil fuels, and electrolysis of water, applied to extract hydrogen from water using electricity. Steam methane reforming is the process used to harvest hydrogen from methane through high temperature steam at 700–1,000 degrees Celsius. Most hydrogen production occurs through this process, which is the most mature technology. What is clear is that demand for hydrogen is likely to accellerate.

“

AIDAN TURNBULL Managing Editor www.wipmagazines.com www.powermediagroup.co.uk

INDEPENDENT POWER ASIA

3

CONTENTS

DECEMBER 2022

16

3 03-10 LEADER AND NEWS FROM THE ASIA-PACIFIC REGION

12

15

1,500 KVA GENSET FOR A MANUFACTURER IN SRI LANKA TPL has supplied & installed containerized 1,500kVA Cummins generator.

15 TWO 1,650 KVA DIESEL GENSETS FOR CAMBODIA TEKSAN has successfully installed and commissioned two Teksan diesel gensets equipped with 1650kva Standby Perkins Engines / Leroy Somer alternators with synchronized system in September 2022.

16

2.4 MW GENERATOR FOR AN HQ IN QINGDAO, CHINA AKSA POWER GENERATION(CHINA) has been involved in the successful installation of a 2.4 MW generator in a ‘skyscraper’ headquarters building based in Qingdao, China

18 100 KW OF SOLID-OXIDE FUEL CELLS FOR SOUTH KOREA

SK Engineering & Construction Co., Ltd., has successfully deployed 100 kilowatts of these solid-oxide fuel cells (SOFC) powered solely by hydrogen in Ulsan, South Korea.

20

GAS GENSETS GENERATE ENERGY FROM KITCHEN WASTE

MWM distributor PAUWAY has provided three MWM TCG 2020 V20 biogas generating units (single unit output power of 2000kW) for a key project based in China. All of the energy generated will be “self-utilised and surplus electricity connected to grid power.”

21

CLASSIFIED DIRECTORY OF EQUIPMENT & SERVICES

22

ENGINE MANUFACTURERS GUIDE 4

INDEPENDENT POWER ASIA

20 Like and follow us on Facebook @powermediainternationalgroup Follow us on Twitter @PMI_WIP Follow our activity on LinkedIn Power Media International Group Ltd Visit us online at www.powermediagroup.co.uk Subcription to 27 power publications: 1 Year - £120 UK, £180 ROW | 2 Years - £192 UK, £280 ROW. Payment in full or credit/debit card information is required to process your order.

Subscription request must include subscriber name and email.

For new subscriptions or renewal, call +44 (0) 1403 888019.

Single copy price: £23.50 (including postage and packaging).

In addition to your subscription you will also recieve a FREE GIFT worth £100 (Worldwide Gen-Set & Cogeneration Directory), plus our Year Planner which includes all relevant global power industry events.

For customer service and address changes, call +44 (0) 1403 888019 or email power@wipmagazines.uk.com Content Licensing: For all content licensing, permissions, reprints / e-prints, please contact power@wipmagazines.com | Subject Line: Content Licensing Copyright: © 2021 Power Media International Group Ltd. All rights reserved.

www.wipmagazines.com www.powermediagroup.co.uk

NEWS

DECEMBER 2022

IN BRIEF

DATA CENTRE GENSETS FOR SOUTH KOREA A spokesman commented on the supply of four 4 KD3250UE gensets in October 2022: “We have commissioned 4 sets of KD3250UE generators and customised a master control panel to synchronize the generators for our data centre customer in Korea. Besides that, our Kohler Engineers supported our partner, Coastal Power, on the Site Acceptance Test and Integrated System Test . Kohler Engineers also provided hands-on training to Coastal Power at their workshop.”

The KD3250, 60 Hz Industrial Diesel Generators offer a Standby 3250/4062kVA and Prime Range 2950/3688kVA.

THREE 4.5MW GAS-POWERED GENSETS FOR A MANUFACTURING FACILITY IN NAKHON RATCHASIMA, THAILAND A biogas power plant located in Nakhon Ratchasima has taken delivery of 3 units of J420 Jenbacher gas engines - they offer a combined power output of 4.5MW. The plant is fuelled through the biogas provided by a nearby starch factory. The contract involved the purchase of three units J420 Jenbacher gas engines.

Based on proven Jenbacher Type 3 and Type 6 engine designs, the Series 4 gas engines are characterised by high power and efficiency. Advanced control and monitoring systems ensure easy maintenance as well as reliability and availability, reports the company.

A company spokesman comments: “Combining superb efficiency with an innovative engine concept, Type 4 units save fuel but don’t sacrifice flexibility or reliability. Type 4 is available in 50 and 60 Hz and has the flexibility to choose the gaseous fuel. This makes it an excellent option for more than ten different applications. There are more than two thousand Type 4 systems in use around the world. This is the best proof of their reliability and high availability. Reduced bearing wear also adds to the longevity of the unit.”

The engines can run on natural gas, biogas, landfill gas, sewage gas and coal mine methane.

NINE 150 MW DIESEL GENSETS FOR A NEW POWER PLANT LOCATED IN SREEPUR, BANGLADESH

12 GENERATORS FOR A DATA CENTRE IN CYBERJAYA, MALAYSIA A total of 12 Mitsubishi generator sets were finally hoisted up to 6th Floor for DC in Cyberjaya, Malaysia, in September 2022.

Cyberjaya is a city with a science park at the core.

It forms a key part of the Multimedia Super Corridor in Malaysia and is located in Sepang District, Selangor.

Cyberjaya is adjacent to, and has developed since the 1990s along with Putrajaya, Malaysia’s government seat. This city aspires to be known as the ‘Silicon Valley of Malaysia’.

“The installers finally completed the last delivery of MGS standby power units.

Thanks to our principal (MHIESA) for their immense www.wipmagazines.com www.powermediagroup.co.uk

support to make this project a successful one, “ commented a spokesman.

Ranging in capacity from 0.5 to 56,400 horsepower, Mitsubishi brand diesel engines offer a series of versatile power generating systems, reports the manufacturer.

Mitsubishi Heavy Industries Engine & Turbocharger, Ltd. has continually introduced upgraded its engine products since the inception of business in 1917, and now the MITSUBISHI MGS genset provides a higher generating power rating and more advanced control systems than ever before, with proven reliability based on the continued research and development.

MAN Energy Solutions will supply 9 × MAN 18V48/60TS engines with a total capacity of 150 MW for the new power plant construction in Sreepur, a city north of the capital Dhaka, Bangladesh.

Scheduled for completion in late 2023, the plant will be operated by independent power producer, B-R Powergen Limited (BRPL).

“Energy demand in Bangladesh is increasing by over 10% each year and we are pleased to once again contribute to the country’s reliable energy supply with the Sreepur project,” said Ghassan Saab, Head of Region Middle-East Africa, Power Plant Sales, MAN Energy Solutions.

MAN Energy Solutions has successfully commissioned three

other power plants in the cities of Chandpur, Thakurgaon and Narayanganj.

The Chandpur plant was successfully commissioned recently. The customer, Chandpur Power Generation, relies on a combination of 4 × MAN 18V51/60TS and 2 × MAN 20V45/60 engines, which feed a total of 125 MW into the national grid. Chandpur Power Generation is a subsidiary of Doreen Power.

Saab said: “In Chandpur, the plant operators have chosen a particularly innovative engine setup. The combination of our powerful 20V45/60 engines and the 18V51/60TS units with twostage turbocharging guarantees maximum fuel efficiency and a more compact plant design.”

INDEPENDENT POWER ASIA

5

NEWS

DECEMBER 2022

IN BRIEF

4 X 1875KVA BACKUP POWER PLANT FOR AMP CAPITAL Property company AMP Capital is developing a site at the Quay Quarter Towers in Sydney, NSW and has purchased 4 x 1875kVA standby diesel generators from ENERAQUE. The installed technology features a load shedding control system for multiple tenancies. There is a diesel fuel system comprising two 35,000-litre underground bulk storage tanks, two diesel transfer systems and a 1,000-litre day tank for each generator, 2 on level 7 and 2 on level 21.

Also installed are primary and secondary exhaust silencers for each generator and inlet and outlet attenuators to meet the low noise requirement of neighbours.

70 DIESEL GENERATORS INSTALLED AT SPECIFIC SEMICONDUCTOR MANUFACTURING LOCATIONS IN CHINA Rolls-Royce will provide 70 of its mtu Series 4000 engines, produced in Yulin by mtu Yuchai Power, the Chinese Joint Venture with Guangxi Yuchai Machinery Group Co. Ltd., for use in generator sets. These will be packaged and distributed by emergency power systems provider Hefei Calsion Electric System Co, Ltd. The gensets will be installed at multiple semiconductor manufacturing locations in China to ensure that chip production is not affected by power failures.

The rapid expansion of information technology applications such as artificial intelligence, cloud computing, big data and Internet of Things (IoT), has resulted in growing market demand for semiconductor products. In recent years, Chinese semiconductor enterprises have experienced a significant growth period due to the acceleration of domestic insourcing and the upgrade of industrial technologies.

The guarantee of continuous power supply is critical for semiconductor factories, as the manufacturing process is very sensitive. The products on the production line are at risk of being scrapped after even a few minutes of power disruption. The mtu engine-powered generator sets installed by Calsion will provide uninterrupted switching between diesel engines and grid power to deliver continuous loading capacity under high load conditions, helping to ensure the stable operation of production lines and special process systems such as safety, clean room, and cooling and pure water systems.

“With their excellent fuel efficiency and low emissions, mtu engines meet Stage III standards in China, and offer the advantages of superior performance, high reliability, as well as low operating costs. They also come standard with the strong technical design features and quality assurance that have made them the preferred choice for mission critical applications.”, said Lang Yun, Vice President, Stationary Power Solutions Greater China for the Power Systems division of Rolls-Royce.

1,000KW GENSETS SUPPLIED TO THE CEYLON BISCUITS LIMITED (CBL) FACTORY

Two 1,000 kW diesel generators (1000kW Perkins diesel generator, 1500RPM , Electronic , 1250kVA) - with Perkins engines and Leroy Somer alternators - have been supplied by Teksan to a factory belonging to Ceylon Biscuits Ltd, based in Ranala, Sri Lanka.

Local contractor Nativeway successfully installed and commissioned both of the 1 MW Teksan diesel generators which were fitted with Perkins-UK engines and Leroy Somer- France alternators.

A spokesman commented: “We have synchronized the Teksan generators with existing 3 nos. of 1 MW Cummins diesel generators, which are now completely controlled by customised Control modules.”

The 4012-46TWG2A units from Perkins each have a turbocharged and air-to-water charge-cooled, 12-cylinder diesel engine which offers a choice of temperate or tropical cooling. Its premium features provide exceptional power-to-weight ratio resulting in exceptional fuel consumption, reports the company. The 4012-46TWG engine has been developed using the latest engineering techniques and builds on the strengths of the already very successful 4012 Series family and addresses today’s uncompromising demands within the power genset industry. Developed from a proven heavy-duty industrial base these products are said to offer superior performance and reliability.

6

INDEPENDENT POWER ASIA

4.4MVA DIESEL GENERATOR FOR THERMOELECTRIC POWER PLANT

MARGEN recently supplied & commissioned a single unit 4 MVA generator in medium voltage 6.6 kV settings at a thermoelectric power plant.

This has been built in Thailand by the Toshiba Plant Systems & Services Corp (TPSC Engineering).

The unit features a black start function for activating the entire system and will also effectively support the auxiliaries in case of emergencies.

The supply is completed by a 10.000-litre fuel tank and

advanced command and control systems. The plant is run by Banpong Utilities Gas Co-generation Facilities EPC and is based in Ratchaburi, Thailand.

Ratchaburi Thermal Power Plant is a 1,440MW gas fired power project. The project has been developed since the site’s commissioning in October 2000. It is a steam turbine power plant. The power plant runs on dualfuel. The primary fuel being used to power the plant is natural gas. The plant can also run on Fuel Oil in case of gas shortages. www.wipmagazines.com www.powermediagroup.co.uk

Mitsubishi Power Generation Engines 6.4kw to 15000 kw

The Mitsubishi diesel engine line up for power generation comprises of engines from 6kw to 15000kw. These engines can be found in a multitude of applications including generator sets for stand-by or emergency power, prime power for peak loping or base load power.

We have a relentless focus on product quality and production management which makes us a reliable partner for our OEM’s.

The engines are built to last and with ease of maintenance in mind, with easy access points to key components.

DIAMOND DIESELS (UK) LIMITED

UNIT 4 BLACKBURN INDUSTRIAL ESTATE, ENTERPRISE WAY, SHERBURN IN ELMET, NORTH YORKSHIRE LS25 6NA PHONE: 0844 4996373 OR +44 1977 683690 FAX: 0844 4996363 OR +44 1977 683815 EMAIL: sales@diamonddiesels.co.uk UK DISTRIBUTOR FOR MITSUBISHI TURBOCHARGERS & ENGINES EUROPE B.V. SALES & SERVICE SUSIDARY OF MITSUBISHI HEAVY INDUSTRIES JAPAN.

WEB: www.diamonddiesels.co.uk

Noise control experts

Keeping your world clean, quiet, and safe. Dürr Universal is a global leader in the design and manufacture of inlet and exhaust systems for gas turbines and reciprocating engines in the OEM and retrofit markets. www.durr-universal.com Dürr Limited United Kingdom

Phone +44 1455 8944 88 Email solutions@universalaet.com

NEWS

DECEMBER 2022

CHINA CHOOSES PARTNERS FOR NATIONAL GRID TRANSFORMATION PROJECTS The International Renewable Energy Agency, IRENA, has signed a Memorandum of Understanding with the State Grid Corporation of China on grid and energy transformation in China and in developing countries, specifically to collaborate on grid enhancements, system flexibility, and sector-coupling in China and in IRENA’s clean energy corridor regions.

The agreement’s aim is to advance the global energy transformation towards a net-zero energy future particularly in developing countries, in the context of achieving the Paris Agreement objectives and the UN Sustainable Development Goals.

“The coming years are critical for the energy transition. To achieve a 1.5-degree world, the global energy system must align with the necessary decarbonisation pathway this decade. What we do now will significantly impact our collective ability to achieve a net-zero future,” comments Francesco La Camera, IRENA director-general.

Under the agreement, IRENA and SGCC will conduct joint activities and collaborative studies to enhance the flexible operation of power grids, decarbonisation of urban energy systems and facilitate grid development with a special focus on the application of smart grid and sector-coupling strategies.

Xin Baoan, president of SGCC, commented: “The installed capacity of renewables integrated to the State Grid system has reached a total of 710 GW, including 230 GW hydropower, 230 GW wind and 220 GW solar power.”

IN BRIEF MORE COAL-FIRED POWER PLANTS FOR CHINA

AUSTRALIA LOOKS FORWARD TO DEVELOPING A HYDROGEN + AMMONIA FUTURE TO OVERCOME PROJECTED ENERGY DEFICITS Energy Estate, part of a consortium of domestic and global energy players, has promised to accelerate the development of the integrated hydrogen and ammonia production and export facility in North Queensland, known as the ‘HyNQ – North Queensland Energy Project’.

The consortium, which includes Idemitsu Australia, a subsidiary of prominent energy supplier Idemitsu Kosan, and Queensland government-owned CS Energy, will continue with its study on the feasibility of generating and exporting green ammonia from the Port of Abbot Point near Bowen. ,Vincent Dyer, co-founder of Energy Estate, explains: “As evidenced by the recent announcements from COP27, the global push for decarbonised energy, in all its forms, is gathering pace, a key opportunity recognised by the Queensland government in its ‘Enabling Queensland’s hydrogen production and export opportunities’ report and by the broader energy community in the Asia-Pacific.

“This brings together a group of highly-respected energy companies, each focused both on the domestic opportunities for Queensland and key export markets of Japan and Korea will help accelerate the potential of HyNQ, a project leaning-in to the opportunity for the export of ‘sunshine gas’.”

HyNQ was initiated by Energy Estate in 2020 with the aim of developing a global-scale green ammonia facility utilising the natural resources of North Queensland and founded on a commitment to the community in which the project is based.

The project looks to harness the benefits of existing infrastructure, while drawing on the experienced workforce and supply chain of North Queensland. The consortium will fund the present pre-FEED activities, and if those results are successful, relevant FEED activities.

The project is looking to complete pre-FEED activities in Q3 2023, and if all proceeds well, go on to a final investment decision in late 2024 or early 2025. www.wipmagazines.com www.powermediagroup.co.uk

New sources suggest that provincial governments in China approved plans to build 8.63 gigawatts (GW) of new coal power plants in the first quarter of 2022 alone, making up approximately 46.5% of the total capacity approved.

According to a recent report, China will need to close nearly 600 coal-fired power plants over the next decade in order to reach its goal of net zero greenhouse gas emissions by 2060.

China has the greatest number of coal-fired power stations of any country or territory in the world.

As of 2022, there were 1,110 operational coal power plants on the Chinese Mainland. This was nearly four times the number of such power stations in India, which ranked second.

Datang Tuoketue is the largest operational coal power plant by capacity in China. The power station is located in Inner Mongolia and at 6.7 gigawatts is also the largest coal power plant in the world.

China has proven coal reserves which are equivalent to 34.9 times its annual consumption. With current consumption levels and excluding any reserves, it has about 35 years left.

China imports 62% of its coal from Indonesia. China and India together import roughly 80% of their coal. China accounted for 15% of total US coal exports in 2021.

INDEPENDENT POWER ASIA

9

NEWS

IN BRIEF

2GW ORDER FOR GUANGDONG GE Gas Power and Harbin Electric have a partnership to fulfill an order from Chinese state-owned power utility Shenzhen energy Group for power generation equipment for its Guangming combined cycle power plant, located in Shenzhen Guangming district of Guangdong province.

Powered by three GE 9HA.01 gas turbines, the plant is expected to deliver up to 2 GW of electricity to the most populous province in the country, population 126 million.

Plans are for the first unit to be operational by end of 2023, to coincide with the retirement of the Guangdong Shajiao coalfired power complex which is scheduled for 2025.

DECEMBER 2022

CHINA’S LARGE HIGH ALTITUDE AIR SHOWER OBSERVATORY PROJECT IS POWERED BY GENSETS FROM EUROPE China’s Large High Altitude Air Shower Observatory (LHAASO) Project, the cosmic ray detection facility located in the high mountains of Sichuan province, recently began scientific observation of very high-energy cosmic rays as it launched operations of its first set of detectors.

PRAMAC provided three mtu series gensets for power backup: the units are used in very strict conditions, at an altitude of 4410 m and for around 2,000 operational hours per year, guaranteeing maximum performances.

The gensets provided for this specific project are GCW1400 and GCW1120M: 1113 kVA diesel generator with MTU engine and Leroy Somer alternator, plus 1400 kVA diesel generators with mtu engine and Leroy Somer alternator.

The GCW1400 offers the following features: Power LTP 1400 kVA; Power PRP 1266 kVA; Frequency 50 Hz; Tension 400 V; Engine PERKINS 4012-46 TWG2A; Alternator MECCALTE ECO432L; Open Version; EDF connection network; Working in EJP; and Double electrical start.

The GCW1120M is equipped with a customised control panel; a special canopy ensures that noise levels should not exceed 65 dB(A) at 7 metres. It offers the following: Power LTP 1117 kVA; Power PRP 1015 kVA; Frequency 50 Hz; Tension 400 V; Engine MTU 16V2000G65; Alternator MECC ALTE ECO43 2L; Container 20’ noise level 65 +/-3 dB(A) @ 7 m; Automatic panel; a fuel tank with 1,000-litre capacity; and an engine water preheating system.

The Large High Altitude Air Shower Observatory (LHAASO) project is a new generation multi-component instrument, at an altitude of 4410 metres.

It’s role is to study the composition and the anisotropy of cosmic rays in the energy range between 10 and 10 eV, as well as to act as a wide aperture (one stereoradiant), continuously-operated gamma ray telescope in the energy range between 10 and eV.

CHINA’S SPACE STATION IS INVOLVED IN GENERATING ENERGY FROM ORBIT China’s space station is directly involved in a new project to collect solar power from space and send it to Earth in a highenergy microwave beam, according to a senior scientist.

The Chinese space station Tiangong - which means “Heavenly Palace” - became fully operational when the last major service module, Mengtian, docked this month. Some space scientists have suggested Tiangong - the largest infrastructure in orbit owned and run exclusively by a single country at present - can change the pace or direction of the space race.

Onboard systems will allow it to collect solar power from space and send it to Earth in a high-energy microwave beam to power military equipment or remote outposts.

The Space Solar Power Station (SSPS), a hotspot technology, is a space-based power generation system used to collect solar energy before converting it to electricity and then to microwaves. The sunlight is brighter outside the atmosphere and shines almost all day.

Next, the energy in microwaves will be transmitted and harvested by the receiving antenna either in space or on the Earth’s surface, which converts microwaves back to electricity. A research team from Xidian University has unveiled the world’s first full-chain, system-wide ground verification for space solar power station this month with its OMEGA-SSPS ground test verification system.

10

INDEPENDENT POWER ASIA

FOUR H-CLASS COMBINED CYCLE POWER PLANTS FOR CHINA

Siemens Energy is working to deliver a total of four H-class combined cycle power units to their power plants located in the Guangdong-Hong Kong-Macao Greater Bay Area in southern China.

The new and updated power plants will help meet the growing power demand in the region. In addition, with the one-hundredth unit sold, the projects also mark a milestone in the story of the SGT-8000H gas turbine.

Under the agreement with Guangdong Energy, Siemens Energy will deliver a 675MW

combined cycle power generation unit, including a SGT5-8000H gas turbine, a steam turbine, two generators and related auxiliary equipment, and long-term maintenance service for the plant in Guangzhou owned by Guangdong Yuehua Power Co. By 2023 the existing coalfired power plant will be upgraded to a modern, higher-efficiency gas-fired plant, reducing carbon dioxide emissions by more than 60 %. It is projected to generate 2.3 billion kWh of energy annually.

www.wipmagazines.com www.powermediagroup.co.uk

Compact. Smart. Efficient.

With our MWM container solutions, you have everything under one roof – precisely aligned with your needs. Benefit from our assistance in planning, configuring and installing comprehensive plant concepts. Thanks to digital possibilities such as a highly developed, secure data analysis, these steps can be tailored to maximize your profit.

Welcome to the future – with MWM Digital Power. www.mwm.net/en

GENSETS

DECEMBER 2022

1,500 KVA GENSET SUPPLIED TO A BABYWEAR MANUFACTURER IN TRINCOMALEE, SRI LANKA

T

PL has supplied & installed containerized 1,500kVA soundproof Cummins generator to Jay Jay Mills Lanka, Trincomalee factory.

The 1,500 kVA diesel generator was installed at the Jay Jay Mills Lanka factory in October 2022. The CUMMINS C1675D5A 1500 kVA Three Phase Open Diesel Generator offers the following benefits: Standby: 1675 kVA / 1340 kW - Prime: 1500 kVA / 1200 kW Driven by a Cummins KTA50-GS8, the set features a reliable alternator: the Stamford PI734D, Voltage: 380440V, Frequency: 50Hz, Amps Per Phase: 2412 and a key Control Panel: PowerCommand 3.3.

The KTA50-Series benefits from years of technical development and improvement to bring customers an innovative and future proof diesel engine which keeps pace with ever-changing generator set requirements, says Cummins.

Recognized globally for its performance under even the most severe climatic conditions, the KTA50-Series is widely acknowledged as one of the most robust and cost-effective diesel engine in its power range for the generator set market. Features include: * Pistons are dual Ni-resist, aluminium alloy, ground and shaped to compensate for thermal expansion, which assures a precise fit at all normal operating temperatures. *Coolpac integrated design - products are supplied complete with cooling package and air cleaner kit for a complete power package. Each component has been specifically developed and rigorously tested for G-Drive products, ensuring high performance, durability and

“

TPL HAS SUPPLIED & INSTALLED CONTAINERIZED 1,500KVA SOUNDPROOF CUMMINS GENERATOR TO JAY JAY MILLS LANKA, AT ITS TRINCOMALEE FACTORY. THE 1,500 KVA DIESEL GENSET WAS INSTALLED AT THE JAY JAY MILLS LANKA FACTORY IN OCTOBER 2022.”

12

INDEPENDENT POWER ASIA

reliability. *Aftercooler – Large capacity integral aftercoolers are supplied with cooling water separate from the engine jacket.

This provides cooler, denser intake air for more complete combustion and reduced engine stresses for longer life and low exhaust emissions. * Cooling System – A two pump, two loop system must be employed; i.e. the engine jacket is cooled by one radiator or heat exchanger and the aftercoolers are cooled by a separate radiator or heat exchanger.

An interesting aspect of the componetry includes the specification of the Stamford PI734D alternator. Newage Stamford industrial generators meet the requirements of BS EN 60034 and the relevant sections of other national and international standards such as BS5000, VDE 0530, NEMA MG1-32, IEC60034, CSA C22.2-100, AS1359.

The STAMFORD PI range of synchronous ac generators are brushless with a rotating field.

They are separately excited by the STAMFORD Permanent Magnet Generator (PMG). This is a shaft mounted, high frequency, pilot exciter which provides a constant supply of clean power via the Automatic Voltage Regulator (AVR) to the main exciter. The main exciter output is fed to the main rotor, through a full wave bridge rectifier, protected by surge suppression.

Looking at voltage regulators The PI range generators, complete with a PMG, are available with one of two AVRs. Each AVR has soft start voltage build up and built in protection against sustained over-excitation, which will de-excite the generator after a minimum of 8 seconds.

Underspeed protection (UFRO) is also provided on both AVRs. The

UFRO will reduce the generator output voltage proportional to the speed of the generator below a presettable level.

The MX341 AVR is two-phase sensed with a voltage regulation of ± 1 %. The MX321 AVR is 3 phase rms sensed with a voltage regulation of 0.5% rms.

The UFRO circuit has adjustable slope and dwell for controlled recovery from step loads. An over voltage protection circuit will shutdown the output device of the AVR, it can also trip an optional excitation circuit breaker if required.

As an option, short circuit current limiting is available with the addition of current transformers.

Both the MX341 and the MX321 need a generator mounted current transformer to provide quadrature droop characteristics for load sharing during parallel operation.

Provision is also made for the connection of the STAMFORD power factor controller, for embedded applications, and a remote voltage trimmer.

All generator stators are wound to 2/3 pitch. This eliminates triplen (3rd, 9th, 15th) harmonics on the voltage waveform and is found to be the optimum design for trouble-free supply of non-linear loads.

The 2/3 pitch design avoids excessive neutral currents which are sometimes seen with higher winding pitches. A fully connected damper winding reduces oscillations during paralleling. This winding, with the 2/3 pitch and carefully selected pole and tooth designs, ensures very low levels of voltage waveform distortion.

Standard generators feature a main stator with 6 ends brought out to the terminals, which are mounted on the frame at the non-drive end of the generator. www.cummins.com www.stamford-avk.com

www.wipmagazines.com www.powermediagroup.co.uk

TRUSTED KNOWLEDGE. TAILORED SOLUTIONS. If you have concerns about fuel quality, speak to an experienced IPU fuel expert about our industry-leading fuel and environmental managed services.

We can offer everything you need to keep your fuel in peak condition from environmental compliance through OFTEC surveys to subsequent remedial recommendations, installation of polishing systems and scheduled maintenance routines. And, as a leading OEM in fuel systems, we are in a unique position to design and manufacture the solution most tailored to your needs.

With decades of experience in the global Oil and Gas sector, operating in some of the world’s most demanding ATEX environments, we fully understand the hazards and challenges you may face – which is why you can rely on our pro-active and undiluted support at all times.

Crucial Expertise for Critical Applications.

OFTEC INSPECTIONS

REMEDIAL WORK

FUEL FILTRATION AND CONDITIONING

More details at www.ipu.co.uk IPU Group, Cygnus Way, West Bromwich, West Midlands, B70 0XB. Telephone +44 (0)121 511 0400

MEMBER

GAS GENERATOR SET

GXE, GRS Series

PowerLink Engine 10KW-350KW

Since 2012, PowerLink group has launched GXE, GRS series PowerLink gas gensets, powered by PowerLink, are equipped with cost-effective engine and high-quality spare parts, covering power range from 10kw to 350kw with open type, soundproof type, mini container type and container type for your selection. Our units are distributed in Europe, South America, Russia, Southeast Asia, the Middle East and other countries. They are providing continuous and stable power on the project sites, bringing excellent benefits to owners and investors.

www.powerlinkenergy.com | Tel: +44(0)1977 689100

GENSETS

DECEMBER 2022

TWO 1,650 KVA DIESEL-POWERED GENSETS BOUGHT

BY A BEVERAGE COMPANY IN CAMBODIA

T

EKSAN has successfully installed and commissioned two Teksan diesel gensets equipped with 1650kva Standby Perkins engines and Leroy Somer alternators with synchronized systems. These were installed in September 2022 for the IMB Inter Mattrid Beverage Company Ltd. in Cambodia.

The Model - 4012-46TAG2A engines are part of the Perkins 4000 Series engine family. They are manufactured for the power industry with focus on the heavy-duty industrial market.

The 46-litre, turbo charged air-to-water cooled, 12- cylinder 60 degree Vee form engine features exceptional power-to-weight ratio. This unit is recommended for a wide range of temperatures and has a jet cooling system for the pistons.

The module has been designed to display warnings, shutdowns & engine status information all on a back-lit LCD screen. Engine shutdown features include high engine temperature, low oil pressure, and low fuel level warning and much more.

With models from 6 to 16 cylinders, the 4000 Series diesel engines are considered the real powerhouse of electricity generation. Diesel models achieve regulated and unregulated emissions standards globally.

The ElectropaK diesel engines in the 4012 range come complete with radiator and air cleaner. Models in the range are either turbocharged and air-to-air chargecooled or turbocharged and air-to-water chargecooled.

Giving 1250-1880 kVA engine power, the 4012 range diesel engines include a model to suit a wide variety of power generation needs – prime or standby.

These engines have proven reliability in prime and standby installations in all of the key sectors.

The two Teksan diesel gensets have been installed as part of an initiative by the the Inter-Mattrid Beverage (Cambodia) Co Ltd. Its US$78 million brewery and beverage plant was recently approved by the Council for the Development of Cambodia (CDC).

The multi-million Dollar brewery is being constructed in Dei Ith commune’s Sdao Kanleng II village, Kien Svay district in Kandal province. The new brewery project is expected to create as many as 550 jobs.

“

IN SEPTEMBER 2022 TEKSAN SUCCESSFULLY INSTALLED AND COMMISSIONED TWO TEKSAN DIESEL GENSETS EQUIPPED WITH 1650KVA STANDBY PERKINS ENGINES AND SYNCHRONIZED SYSTEMS. THE PURCHASER WAS THE IMB INTER MATTRID BEVERAGE COMPANY LTD OF CAMBODIA.THE COMPANY IS CURRENTLY BUILDING A US$78 MILLION BREWERY IN THE COUNTRY.” www.wipmagazines.com www.powermediagroup.co.uk

An Inter-Mattrid Beverage sales representative has said the company is currently in the process of building the plant.

He said all employees are undergoing training in preparation for the facility’s launch.

“Beer is all the rage in our country, people like to drink. No matter what kind of party it may be, there must be beer, especially at large functions,” he told The Phnom Pehn Post newspaper.

According to the Ministry of Industry, Science, Technology and Innovation this will be the Kingdom’s 13th brewery/beverage plant.

Earlier in 2020, Cambodian Vattanac Brewery Co Ltd announced its plans to launch a new $87 million brewery in Phnom Penh, while Hanuman Beverages Co Ltd received the approval from Council for the Development of Cambodia for a $160.6 million brewery to be built in Kandal province’s Ang Snuol district.

The TEKSAN generator sets sold to Cambodia feature state of the art technology and have compliance with ISO 8528, ISO 3046, BS 5514, DIN 6271 standards.

These engines offer low fuel consumption, accurate speed setting and order, and mount to the fuel pump.

They also have the option of supply with mechanical or electronic type governors.

The new TEKSAN generators now protect protect the business interests of Inter-Mattrid Beverage by restoring normal power when the regular power grid is disrupted due

to bad weather, animal damage to power lines, a brownout, a blackout, or scheduled maintenance.

Proper sizing of diesel generators is critical to avoid low-load or a shortage of power. Sizing is complicated by the characteristics of modern electronics, specifically non-linear loads. In size ranges around 60 MW and above, an open cycle gas turbine is more efficient at full load than an array of diesel engines, and far more compact, with comparable capital costs.

For regular part-loading, even at these power levels, diesel arrays are sometimes preferred to open cycle gas turbines, due to their superior efficiencies, reports TEKSAN. Diesel generators can be utilized as standalone, emergency, standby, and peak shaving units because of their availability, quick start up, reliability, fast ramp up, durability, etc. www.teksan.com www.perkins.com

INDEPENDENT POWER ASIA

15

GENSETS

DECEMBER 2022

NEW 2.4 MW GENERATOR INSTALLED IN A QINGDAO SKYSCRAPER HEADQUARTERS, CHINA

A

KSA POWER GENERATION (CHINA) was recently involved in the successful installation of a 2.4 MW generator in a building being used as corporate headquarters in Qingdao, China.

Aksa Generators manufactures gasoline, diesel, natural gas powered gensets, marine generating sets, lighting towers and generating sets hardware.

The company is one of the biggest generating sets manufacturer of the world thanks to its continuous investments and technical developments.

The client - based at the Qingdao Landmark Center chose to develop the building as a mixed use development highrise structure in Qingdao, China.

The complex consists of 3 towers with the main tower being the Qingdao Landmark Tower which is a 327.3 m or 1,074 ft tall skyscraper under construction in Qingdao, China. Upon its completion in 2022, it will be the second tallest building in Qingdao behind the Haitian Center Tower 2 when complete.

The building is located in a complex - a group of buildings which are designed and built as set pieces reflecting a greater development. At 2.4MW the AKSA generator in the structure is capable of powering up to 1,000 homes by comparison.

The power provided by the genset is capable of running several data centre sections also housed in the structure, as well as the elevators, HVAC systems, fans, heaters, fire & security features including monitoring, floor-to-floor lighting, internet links, telecommunications and other audio-visual facilities in the tower.

Electrical systems in high-rise buildings like this are typically designed with multiple feeds and a large standby generation capacity.

The buildings in the Qingdao complex also include extensive cabling and routing, as well as inverters and batteries for backup power. Because of the high voltage of the electricity, they also feature the installation of solar panels and inverters on the roof and side areas.

The electricity supply to the skyscraper - both mains and bakcup sections - feed the emergency lights. It is possible to use the same voltage for different areas and this is done in some buildings in China, but it is not advisable.

A step-down transformer provided by the utility company reduces standard line potential to dual voltage systems, which pass through electric meters and master switches which record a subscriber’s usage. Different categories of use require different voltages, and each pair of voltage has a separate distribution system of

wiring. In addition, each pair is further broken down into circuits similar to those in a electrical distribution in a building found in the west.

The Qingdao Landmark Center’s step-down transformer converts standard line potential to dual voltage systems. These systems then pass through electric meters and master switches to record the subscriber’s usage. Two different voltages are required for various categories of use.

Each voltage pair is then separated into different circuits. The conduits are installed throughout the building, including in the common areas.

About Aksa Power Generation The company hit the headlines back in 2012 when it opened one of the largest genset factories in the world.

With this move Aksa secured its

place among the biggest genset companies in global market thanks to the new 100,000m² factory. In order to expand production and increase capacity, Aksa subsequently provided additional investment for factory plant in 2016. The second phase workshop is mainly used for sheet metal processing, reports the company.

The new factory produces 24,000 units of diesel gensets annually. In addition, it has 16 test rooms which are equipped with the latest technology and have totally 25 MVA test capacity.

Being one of the first manufacturers of natural gas generator sets of the world, Aksa Generators feels it has the technical edge when it comes to synchronized sets. www.aksapowergen.com

“

AKSA POWER GENERATION (CHINA) HAS BEEN INVOLVED IN THE SUCCESSFUL INSTALLATION OF A 2.4 MW GENERATOR IN A HEADQUARTERS BUILDING IN QINGDAO, CHINA. AT 2.4MW THE AKSA GENERATOR IS FULLY CAPABLE OF POWERING UP TO 1,000 HOMES, BY COMPARISON.

16

INDEPENDENT POWER ASIA

www.wipmagazines.com www.powermediagroup.co.uk

TOTAL CONTROL FROM EVERY PERSPECTIVE Anyone who knows gensets, knows that Mecc Alte is unrivalled for our knowledge and expertise worldwide. From alternators and controllers to an integrated generator system, we are the Power from Within. From prime power to standby power, data centre, renewables, telecoms and more, Mecc Alte delivers complete intelligent systems with digital AVR to identify fuel efficiencies and every component working perfectly together.

All backed up by the support and unbiased advice you only get from the world’s leading independent alternator specialists. Take 360° control. Talk to Mecc Alte.

The world’s largest independent producer of alternators 1 – 5,000kVA

FOR FURTHER INFORMATION VISIT WWW.MECCALTE.COM

FUEL CELLS

DECEMBER 2022

100 KW OF SOLID-OXIDE FUEL CELLS POWERED SOLELY BY HYDROGEN FOR ULSAN, SOUTH KOREA

B

loom Energy is behind the delivery of a consignment of 100kW hydrogen fuel cells to South Korea.

Bloom Energy has announced that, in collaboration with its Korean partner, SK Engineering & Construction Co., Ltd., an affiliate of SK Group, it has successfully deployed 100 kilowatts of these solid-oxide fuel cells (SOFC) powered solely by hydrogen in Ulsan, South Korea, generating zero-carbon onsite electricity.

Hydrogen fuel cells, which convert hydrogen into electricity through a non-combustion electrochemical process, are increasingly recognized by climate experts and governments across the globe as an essential tool for full decarbonization.

Bloom Energy first announced its initial plans to enter the commercial hydrogen market in July 2020, which includes an intended 1 megawatt hydrogen-powered Energy Server installation with SK E&C by 2022.

“This deployment marks a significant milestone not only for Bloom, but for the future of hydrogen-based power generation,” said KR Sridhar, founder, chairman and CEO of Bloom Energy.

“While Bloom’s hydrogen story started more than two decades ago, it’s now the right market timing to introduce hydrogen-powered solutions and help countries meet their net-zero emissions goals.

“We’re proud of our partnership with SK E&C. Together, we are well-positioned to play an important role in the global hydrogen economy.”

The SOFCs use hydrogen byproduct generated

by SK Advanced to create power without CO2 emissions.

The hydrogen-powered fuel cells are supplied, operated and maintained by Bloom Energy. Upon completion of the pilot project, Bloom Energy’s hydrogen SOFCs will support South Korea’s

18

INDEPENDENT POWER ASIA

Changwon RE100 initiative, as well as many other projects.

The RE100 is a global renewable energy initiative led by the Climate Group to accelerate the move toward zero-carbon electricity grids.

As reported in November 2020, Bloom Energy and SK E&C won a competitive bid for the Changwon RE100 to supply Bloom Energy’s hydrogen-powered SOFCs and hydrogen electrolyzers to an industrial complex there.

“Bloom’s state-of-the-art hydrogen fuel cell, which represents the pinnacle of power generation efficiency and safety, will allow us to provide clean electricity that will help Korea reach carbon neutrality by 2050,” said Jason Ahn, CEO of SK E&C. “We look forward to playing a leading role in the SK Group’s eco-friendly business expansion, as well as the Korean government’s Green New Deal and carbon neutrality policy.”

In addition, Bloom Energy intends to supply its solid-oxide electrolyzer cells (SOEC), which are designed to produce green hydrogen via solar and battery, to South Korea in 2022 as part of the RE100 project.

The green hydrogen produced by the SOEC, which is created through electrolysis by converting water and renewable electricity into hydrogen without carbon emissions, will be used to power the hydrogen SOFC.

How do Bloom Energy’s hydrogen fuel cells work?

Instead of precious metals, Bloom Energy’s fuel cells use wafers made from sand which are stained with proprietary ink.

As fuel passes over the sand wafers, it mixes with oxygen, creating a chemical reaction which produces electricity. The chemical reaction takes place at about 800 degrees Celsius (1,500 degrees Fahrenheit).

Dozens of countries have committed to net-zero emissions goals in the coming decades. Hydrogen is required to reach these deep decarbonization goals. It is estimated that 30% of energy-related CO2 emissions are hardto-abate with electricity alone, providing a massive opportunity for hydrogen.

The hydrogen economy is advancing across numerous sectors including power generation, transportation, industrial energy, building heat and power and feedstock.

Bloom Energy’s Solid Oxide technology is uniquely positioned - says the company - to accelerate both the production and the usage of hydrogen.

Bloom Energy’s Solid Oxide Fuel Cells (SOFC) have been deployed in 100s of applications across healthcare, data centres, critical manufacturing, retailers and more. www.bloomenergy.com

www.wipmagazines.com www.powermediagroup.co.uk

DIESEL GENERATORS

There's more to an Enrogen generator.

MADE IN BRITAIN

Our exclusively UK-based design, fabrication, and manufacturing process means Enrogen clients enjoy unparalleled product quality and support services.

EXPERIENCE THE ENROGEN DIFFERENCE . . . . . . . . . . . . .

Comprehensive Aftersales

EMAIL: MAIL@ENROGEN.COM

I

Premium Supply Partners

CALL US: +44 (0)1759 307070

. . . . . . . . . . . . .

Custom Made Generators

I

VISIT: WWW.ENROGEN.COM

GENSETS

DECEMBER 2022

GAS GENSETS GENERATE ENERGY FROM KITCHEN WASTE IN CHINA

M

WM’s recent projects in China show the company’s capabilities in producing energy from waste treatment projects.

MWM gas gensets offer many advantages in terms of sustainable and clean decentralised energy supply. In addition to natural gas, they can be operated with a variety of biogases and reliably generate electricity, heat and, if required, cooling.

As the population grows, so does the amount of waste.

At the same time, the challenges to disposing of it sensibly are increasing. In several recently installed projects in China, MWM gas gensets are helping to produce energy from kitchen waste.

Recently, the largest kitchen waste treatment project in China - ”Guangzhou Likeng comprehensive treatment plant” - was successfully connected to the grid for power generation.

The Likeng comprehensive treatment plant is currently the largest environmental protection project for kitchen waste treatment in China, with an average daily treatment capacity of about 1000 tons.

The project will treat about 350,000 tonnes of kitchen waste every year, with an estimated annual power generation of about 48 million kWh and a carbondioxide emission reduction of more than 15,000 tonnes per year.

The main processes of the project are “Pretreatment + Anaerobic digestion + Wastewater Treatment + Biogas Power Generation”. The kitchen waste containing a large amount of organic matter will produce biogas after anaerobic fermentation and decomposition. After purification by the pretreatment system, the biogas will enter the gas genset for power generation.

“

THE MWM GAS GENERATOR SETS OF THE TCG 2020 SERIES ARE PERFECTLY GEARED TO THE CHALLENGES OF A DYNAMIC MARKET ENVIRONMENT. IN THE OUTPUT RANGE OF 1,000–2,000 KWEL, THEY MEET THE HIGH REQUIREMENTS OF A BROAD RANGE OF APPLICATIONS.”

20

INDEPENDENT POWER ASIA

MWM distributor PAUWAY has provided three MWM TCG 2020 V20 biogas generating units (single unit output power of 2000kW) for the project.

All of the energy generated will be “self-utilised and surplus electricity connected to grid power.” PAUWAY is also in charge of the design and subsequent maintenance of all power systems for this project.

MWM supports sustainable development in Qingdao In Qingdao, China, kitchen waste will also be used to generate energy in the future.

Two flat trucks carrying MWM gas gensets recently drove into a domestic waste comprehensive treatment park in Qingdao, officially kicking off the onsite construction phase of MWM distributor PAUWAY’s Qingdao kitchen waste power generation project.

In the next month, PAUWAY’s engineers will be responsible for the installation and commissioning of the equipment and help ensure the smooth operation of Qingdao’s first kitchen waste treatment project.

PAUWAY has delivered two MWM TCG 2020 V16 gas gensets for the project according to customer needs and field visits.

The power generation of a single generator unit is 1.56mW. After the units are put into operation, they

will meet the power demand in the park, and all the surplus power will be connected to the grid. It is estimated that the annual on-grid power will be about 25 million kWh, thus reducing carbon emissions by more than 3300 tons and saving about 666,667m2 of landfill land.

This waste comprehensive treatment park is an important part of Qingdao’s environmental sanitation infrastructure.

It undertakes the task of waste disposal in the main urban area and high-tech zone and has the important function of ensuring the normal operation of the city.

After the completion of the project, the daily treatment of waste can reach 500 tons, which will make up for the shortboard of waste terminal treatment capacity in Qingdao, and the waste treatment level will reach “domestic leading”, which will effectively promote the sustainable development of green and low-carbon in the city.

The MWM gas generator sets of the TCG 2020 series are perfectly geared to the challenges of a dynamic market environment. In the output range of 1,000–2,000 kWel, they meet the high requirements of a broad range of applications and guarantee efficiency, reliability, flexibility & environmental sustainability, together with low lifecycle costs and high profitability. www.mwm.net www.wipmagazines.com www.powermediagroup.co.uk

Old Station Close, Shepshed, Leicester, LE12 9NJ, UK

Winding. Rewinding. Supply.

Service. Repair.

* *

Cabel UK Limited CMF Technology Park Maresfield Road Oakham LE15 7FW E: info@cabeluk.com T: +44 (0)1572 755 168 www.cabeluk.com

2!+%2 %-%1'7 '14//) )3 666 %-%1'7 '14//) )3

Part of the Mecc Alte Group

#+,2 0# -.,2'"# 0,0 ) -,3#. /,)10',+/ $,. 0&# .#) +" +#.%4 * .(#0/ '#/#) / #+#. 0'+% +'0/

0#-,3#./,)10',+/ !,* 333 %#+,2

"#/( %#+,2 0#-,3#./,)10',+/ !,*

Your partners in Temporary Power Distribution

Heating & cooling thermal management technologies

www.hotstart.com

> Purchase and Hire > Temporary Power Products > Energy Management Tool > Electric Vehicle Chargers

T: 01543 574 111 E: enquiries@idesystems.co.uk W: www.idesystems.co.uk

Alternators Made in Italy

Viale del Lavoro, 30 - 37040 Arcole (VR) Italy T. +39 045 7639201 - F.+39 045 7639202 info@linzelectric.com - www.linzelectric.com

8. PDQXIDFWXUHU RI WKH 3(5(*5Ζ1( UDQJH RI HQJLQH SUH KHDWHU VROXWLRQV

ENERGY WHERE NEEDED INNOVATIVE SOLUTIONS COGENERATION

STATIC GAS THERMAL

CYCLE PLUS

GEN SET POWER PLANT

x

SHORT BREAK STORAGE

SOLAR CYCLE

OIL & GAS

::: SUHKHDW FR XN

MARGEN s.p.a.

Via Dino Ferrari, 50 - 41053 Maranello (MO) - Italy +39 0536 94.36.15 info@margen.it www.margen.it

# " ! # ' ! $ Ɵ " ! &) - ! "! &) % Ɵ - Ɵ " ( 6:*4 & Ɵ * " Ɵ " & ! & ! ! ! Ɵ !& ! ! !( ! & ( ;55 +1, 272 929 9831 ( .! ! ! "Ɵ ) $$$)! ! ! "Ɵ )

7HO

VDOHV#SUHKHDW FR XN

6DOHV#SUHKHDW FR XN SUHKHDW FR XN

Advertise in this section for 1 year in all 27 publications for $5%13)2% )- 3()2 as little as £65p/m.

2%#3).- &.1 7%!1

)- !++

Leaders in complete power solutions Hire, Sales, Service & Maintenance, Contingency Planning, including 24/7 Emergency Response

Loadbanks and associated services for datacentre commissioning in Europe.

Tel: +44 (0) 20 3034 0553 contact@rentaload.com www.rentaload.com

'LHVHO )XHO +HDWHUV (QJLQH 3UH KHDWHU 6\VWHPV x ΖQ /LQH )XHO +HDWHUV 'LHVHO )XHO +HDWHUV x +\GUDXOLF )XHO +HDWHUV +\GUDXOLF 2LO +HDWHUV x 6WRUDJH 7DQN +HDWHUV 6WRUDJH 7DQN +HDWHUV &XVWRP +HDWHUV x &XVWRPHU 6SHFLDOV HWF

This includes digital and /4"+)#!3).-2 &.1 !2 print copies.

+)33+% !2 9

/ ,

Goes out to 28,000+ high quality postal & digital ()2 )-#+4$%2 subscribers.

$)')3!+ /1)-3 #./)%2

.%2 .43 3. ()'( 04!+)37 /.23!+ $)')3!+ 24"2#1)"%12

.-3!#3

/.6%1 6)/,!'!8)-%2 #.,

WOODL ANDSPOWER.COM UK : 0845 600 3335 | INTL : +44 138 644 2622

NOTES

ENGINE MANUFACTURERS GUIDE

R Schmitt Enertec GmbH

INNIO Jenbacher gas engines

Headquarters: A-6200 Jenbach (Austria) T +43 5244 600-0 F +43 5244 600-527 jenbacher.info@ge.com www.gejenbacher.com Manufacturer of gas driven generator sets and cogeneration systems in a power range from 0.25 to 3 MW. Model JMS 208 GS JMS 208 GS JMS 312 GS JMS 312 GS JMS 316 GS JMS 316 GS JMS 320 GS JMS 320 GS JMS 412 GS JMS 416 GS JMS 420 GS JMS 612 GS JMS 616 GS JMS 620 GS

Fuel

rpm

g g g g g g g g g g g g g g

1,500 1,800 1,500 1,800 1,500 1,800 1,500 1,800 1,500 1,500 1,500 1,500 1,500 1,500

Pel

Pth

330 335 625 633 834 848 1,063 1,060 844 1,131 1,415 1,820 2,433 3,041

358 406 731 808 988 1,079 1,190 1,313 892 1,194 1,492 1,792 2,399 3,020

Ratings natural gas standard, NOx ≤ 500 mg/ m3N. Dry exhaust gas; based on 5% O2. For engines with 1,200 rpm please contact GE Energy’s Jenbacher product team.

TAD1242GE TAD1640GE TAD1641GE TAD1642GE

352 393 433 485

409 462 509 570

Perkins Engines Company Limited

Peterborough PE1 5FQ Contact name:- Simon Gray Tel: +44 (0) 1733 583000 Email: gray_simon_j@perkins.com Perkins is one of the world’s leading suppliers of off-highway diesel and gas engines, offering dependable cost-effective power up to 2500 kVA in dieselor 1000 kWE prime in gas.

56743 Mendig, Germany T +49 2652 9351810 F +49 2652 9351822 info@rschmitt-enertec.com www.rschmitt-enertec.com Manufacturer of gas driven engines,generator sets and cogeneration systems in the range from 100 - 500 kW. RSE Engines for natural gas and biogas Model

fuel

Freq.

M06-G/B T0D41 g 50 M06-G/B TID41 g 50 M06-G/B T2D41 g 50 M08-G/B TID41 g 50 M08-G/B T2D41 g 50 M12-G/B TID41 g 50 M12-G/B T2D41 g 50 M06-G/B T0D41 g 60 M06-G/B TID41 g 60 M06-G/B T2D41 g 60 M08-G/B TID41 g 60 M08-G/B T2D41 g 60 M12-G/B TID41 g 60 M12-G/B T2D41 g 60 RSE engines for LPG M06-PT0D41 g 50 M06-PTID41 g 50 M06-PT2D41 g 50 M08-PTID41 g 50 M08-PT2D41 g 50 M12-PTID41 g 50 M12-PT2D41 g 50 M06-PT0D41 g 60 M06-PTID41 g 60 M06-PT2D41 g 60 M08-PTID41 g 60 M08-PT2D41 g 60 M12-PTID41 g 60 M12-PT2D41 g 60 RSE engines for Woodgas M06-HT2D41 g 50 M08-HT2D41 g 50 M12-HT2D41 g 50 M06-HT2D41 g 60 M08-HT2D41 g 60 M12-HT2D41 g 60

Electric output 140 kW 200 kW 250 kW 260 kW 333 kW 400 kW 500 kW 150 kW 210 kW 250 kW 280 kW 333 kW 420 kW 500 kW 115 kW 173 kW 205 kW 233 kW 260 kW 350 kW 450 kW 130 kW 173 kW 205 kW 233 kW 260 kW 350kW 450 kW 122 kW 166 kW 250 kW 140 kW 180 kW 275 kW

Volvo Penta

405 08 Gothenburg, Sweden Tel +46 31 235460

SCANIA ENGINES

SE-151 87 Sodertalje Sweden Tel +468553 81000 Fax +468553 898 12 E-mail engines@scania.com Web www.scania.com UK Contact – Mark Swindell Scania GB Ltd Tel +44 1908 329386 E-mail mark.swindell@scania.com Diesel & Gas engines for power generation Prime power 250kVA to 700kVA Stand by power 250kVA to 770kVA Engine range prime power 50hz & 60hz at (70% mean load factor) Scania produce diesel and gas powered engines for various Industrial and Marine applications, superior quality and reliability, offering exceptionally low fuel consumption.

All models are available to meet current emissions requirements, Scania engines are now available to meet both Tier 4F and EU Stage V. Alternative fuels Many of our engines can also operate on Bio-diesel conforming to EN14214 and HVO conforming to EN159540

Model Spec RPM kWm kVA TAD530GE Diesel 15002) 75 85 TAD531GE Diesel 15002) 88 100 TAD532GE Diesel 15002) 113 130 1) 15002) 76 86 TAD550GE Diesel 1) 15002) 89 101 TAD551GE Diesel TAD730GE Diesel 15002) 113 130 TAD731GE Diesel 15002) 132 152 186 TAD732GE Diesel 15002) 162 2) TAD733GE Diesel 1500 175 201 2) 213 245 TAD734GE Diesel 1500 1) 2) TAD750GE Diesel 1500 114 131 TAD751GE1) Diesel 15002) 13 152 1) 2) 1500 158 182 TAD752GE Diesel 1) 2) TAD753GE Diesel 1500 173 199 15002) 217 250 TAD754GE1) Diesel 2) TAD940GE Diesel 1500 241 277 TAD941GE Diesel 15002) 280 326 TAD1341GE Diesel 15002) 271 315 TAD1342GE Diesel 15002) 303 352 TAD1343GE Diesel 15002) 325 378 TAD1344GE Diesel 15002) 354 412 TAD1345GE Diesel 15002) 388 451 1) TAD1351GE Diesel 15002) 279 324 1) TAD1352GE Diesel 15002) 314 365 1) 15002) 328 381 TAD1354GE Diesel 1) TAD1355GE Diesel 15002) 355 413 TAD1640GE Diesel 15002) 392 461 TAD1641GE Diesel 15002) 430 505 TAD1642GE Diesel 15002) 503 591 TWD1643GE Diesel 15002) 536 630 TAD1650GE1) Diesel 15002) 393 462 TAD1651GE1) Diesel 15002) 430 505 Engines are also available for1800rpm/60Hz

t n e m o m y r e v e ’s e lif d in h Be s we’ve provided prime and TM

For 90 year nerator sets. standby power for over 3 million ge powering Today, our 5-2500 kVA engines are ses. communities, livelihoods and busines

www.perkins.com

POWER YOUR BUSINESS With efficient energy and economics

INNIO* is among the world’s leaders in CHP and CCHP solutions.

Power your business with INNIO’s flexible and innovative Jenbacher* CHP and CCHP energy systems, which deliver power, heat and/or cooling for your local site. With up to 95 % total efficiency, cogeneration can reduce your energy consumption and CO2 emissions by more than 30 % compared to the separate generation of power and heat for significantly lower energy costs. Combined with heat storage, you can operate your asset flexibly.

INNIO’s CHP and CCHP systems run on a wide range of gases with the option of converting to CO2-free H2** operation once that fuel is more readily available.

Let us support your transition journey. innio.com * Indicates a trademark. ** Optional scope on demand.

ENERGY SOLUTIONS. EVERYWHERE, EVERY TIME.