69
All articles are not for road use unless stated otherwise. For road use only!
Jets & spares
Surf to - www.Scooter-Center.com
Mikuni Idle Jets
Mikuni idle jets are available in the range 10 to 60 in steps of 2.5. The article number for Mikuni idle jets is composed of the code 222100 + the jet size in combination. A 17.5 idle jet article number is A 60 idle jet is article number
222100175 22210060
3.00 € 3.00 €
Main Jets
The main jets for the entire Mikuni TM range carburettors are identical and can be changed using a six sided spanner or socket. Jets sized 140 to 200 are available in steps of 5, and from 200 to 450 in steps of 10. The article number for Mikuni main jets is composed of the code 2705 + the jet size in combination. A 145 main jet is article number A 310 main jet is article number
2705145 2705310
3.50 € 3.50 €
Needle
From the many that are produced, we have selected the needles best suited to scooter engines. The needles are listed from leanest to richest for each carburettor model.
Mikuni TM24
J8-4DH07 J8-4F15 J8-4L06 J8-4H23
Mikuni TMX30
5EL68 5DP39
Mikuni TMX32
J8-6E25 J8-6DJ08-63 J8-6DJ08-61 J8-6AEJ01-61 J8-6AEJ01-63
Mikuni TMX35
6EN11-58 6EN11-57 6EN11-56 6EN11-55 6EN11-54
2700000 2700001 2700003 2700002
13.00 € 13.00 € 13.00 € 13.00 €
2700008 2700005
13.00 € 13.00 €
J86E25 J86DJ0863 J86DJ0861 J86AEJ0161 J86AEJ0163
13.00 € 13.00 € 13.00 € 13.00 € 13.00 €
2700004 2700009 2700010 2700011 2700012
15.90 € 15.90 € 15.90 € 15.90 € 15.90 €
Atomiser
We have also listed the atomisers from lean to rich. And yes, with a Mikuni three atomisers are ample to set-up a scooter's carburation. Atomiser (O-4-622) Atomiser (O-6-622) Atomiser (Q-0-458)
27459 27460 27458
14.90 € 14.90 € 14.90 €
Chokes
As standard Mikuni carburettors come equipped with a pull-choke mechanism with a twist knob on the carburettor itself. Not the handiest system for most scooters. To make choke operation more comfortable this can be converted to cable operation. The kit contains all the relevant parts to convert each carburettor model. In addition a choke cable is also required, which can be made-up from a throttle cable. Then the original choke lever can be used again.
Pull Chokes
TM24 Complete ready to install, brass TM28 Complete ready to install, brass TMX 27 & 35 Complete ready to install, brass TMX 30 & 32 Complete ready to install, plastic
Cable choke
TM24 & 28, brass TMX27 & 35, brass TMX 30 & 32, plastic
TM24/01 VM26/116 VM27/35 VM29/47
17.90 € 17.90 € 17.90 € 22.90 €
2599095 2599094 2599096
22.90 € 29.90 € 27.90 €
Cable Choke Conversion Kit
We can offer you a complete cable choke kit for the Mikuni TMX 27 and 35 carburettors. The cable and the operating knob are included in the kit. Kit for TMX 27 & 35
CA800109
€19.90
Powerjet Powerjet technology offers the advantage of Powerjet additional fuel delivery at certain rpm. The powerjet system richens the mixture via a separate jet at full burden and prevents a weakening of the fuel mix in constant high load conditions (EG. Motorway riding) Thanks to the powerjet the mid-range jetting can be set at a leaner level without risk of the engine being destroyed at full burden. The powerjet system is a standard feature of certain Mikuni carburettors (TMX 27, 30 and 38) and can be added as a conversion to others (TMX 32 35). However, even without this wonderful system, Mikunis are very adaptable to high load demands. Where previously you might have experienced the dreaded 'pinking', with a Mikuni the engine runs so smoothly you would think it was fuel injected. As a general formula the powerjet used should be approximately ¼ the size of the normal (non powerjet!) main jet. In order to work-out the normal (non powerjet) main jet size, the powerjet system needs to be closed off. This can be done by inserting a 4-5mm diameter piece of steel bar in the powerjet feed rubber tube. If the required main jet is say a 280, then you should select a 70 powerjet. The main jet should then be reduced by the same value and in this case a 210 should be installed.
5.-
Powerjet Conversion Kit For TM & TMX32 35
Jet (30,0) Jet (35,0) Jet (40,0) Jet (45,0) Jet (50,0) Jet (55,0) Jet (60,0) Jet (65,0) Jet (70,0) Jet (75,0) Jet (85,0)
2700930 2700935 2700940 2700945 2701150 2701155 2701160 2701165 2701170 2701175 2700985
MK-406 €49.90
Jet (87,5) Jet (90,0) Jet (92,5) Jet (95,0) Jet (97,5) Jet (100,0) Jet (102,5) Jet (105,0) Jet (107,5) Jet (110,0)
2700986 2700990 2700991 2700992 2700993 2700994 2700995 2700996 2700997 2700998