INSP ADJ
MAINTENANCE INTERVAL CHART
E
MAINTENANCE INTERVAL CHART The following chart should be considered strictly as a guide to general maintenance intervals. Depending on operating conditions, the intervals of maintenance should be changed. Initial Item
Remarks
COWLING: Water separator drain hole
Inspect
FUEL SYSTEM: Fuel line Fuel filter
Inspect Inspect/replace
CONTROL SYSTEM: Throttle cables Remote control throttle cable Throttle link lever Remote control shift cable Shift cable (FT9.9D) Engine idling speed Start-in-gear protection device
Inspect/adjust Inspect/adjust Inspect/adjust Inspect/adjust Inspect/adjust Inspect/adjust Inspect/adjust
POWER UNIT: Engine oil Oil filter Timing belt Valve clearance Ignition timing Thermostat Water leakage Motor exterior Exhaust leakage Cooling water passage LOWER UNIT: Gear oil Impeller Lower unit leakage Propeller GENERAL: Anode Battery Spark plug Wiring and connector Bolts and nuts Lubrication points
Every
10 hours 50 hours 100 hours 200 hours (Break-in) (3 months) (6 months) (1 year)
1
1
1
1
1 1
1 1 1
1 1
1 1
Inspect/change Replace Inspect/replace Inspect/adjust Inspect Inspect /replace Inspect Inspect Inspect Inspect/clean
1
1
1
1 1
Change Inspect Inspect Inspect
1
1
1 1 1 1
1 1 1 1
1 1 1 1 1 1 1
Inspect Inspect Cleaning/adjust/ replace Adjust/reconnect Tighten Lubricate
3-1
1 1 1 1
1
1
1
1
EVERY MONTH
1
1 1 1 1
3-2 3-2 4-3, 3-2
1 1 1
Refer page
3-3 3-4 3-5 3-6 3-7 3-8 3-10 3-11 3-11 3-12 3-12 3-14 5-34 — — — — 3-15 6-4, 6-29 3-16 — 3-16 3-17 — 3-18 — — 3-21